2021 CHEVROLET SILVERADO 2500 — Problems, Recalls & Safety Data

The vehicle experienced a sudden and complete transmission failure at approximately 77,800 miles. There was no prior abuse or modification. The failure resulted in loss of normal drivability and required full transmission replacement. The transmission was replaced with a remanufactured unit due to catastrophic internal failure. Repair costs were approximately $7,000. I am aware of similar GM transmission issues and recalls affecting comparable model years and components. Although my VIN is not currently listed under a recall, the failure appears consistent with known GM transmission defect patterns. The failure occurred while the vehicle was in the middle of an intersection in heavy traffic, resulting in sudden loss of vehicle functionality. A child passenger was onboard at the time. The incident created a significant safety hazard due to loss of drivability in an active traffic environment.

On 01/16/2026, Quirk Chevrolet completed product safety recall N242482680 for the Brake Pressure Switch Connector Fire on my vehicle. Shortly after, my vehicle would come to an abrupt stop on its own while driving. This happened twice on my way home and then the third time at home at which point, it would no longer move forward or backward. The vehicle needed to be towed to the dealership that did the recall. After researching online, I discovered this is a known issue after the recall because the recall component is faulty. One source reports the cause is an improperly manufactured jumper harness which is missing protective tape or a faulty internal C-clip in the cylinder. Another source states the post-service emergency brake issues often stem from a software update meant to enhance safety or an incomplete repair of the brake pressure switch wiring harness. The update automatically engages the parking brake. I absolutely know that the catastrophic failure of my vehicle's braking system was a direct result of the recall work; however, the dealership made me pay for the repairs out of pocket until such time as GM or Chevy makes an "official" recall on the faulty recall. My safety and the safety of others was put at risk by way of my vehicle stopping abruptly on its own. The problem has been reproduced by many sources online - just do an online search "2021 Chevy 5500 emergency brake issue after brake recall completed" and see all the results that come up corroborating my personal experience. Quirks Chevrolet in Manchester, NH inspected the vehicle. No warning lamps or messages appeared on the dash. Please contact me if you want any additional information or copies of receipts, etc. My vehicle is available for inspection upon request.

first issue was around April-May 2025 when my engine started knocking and burning fuel. Warning light came on and it went right in to the dealer where I have all my maintenance done. They determined that it due to (2) faulty fuel injectors and I had them replaced at that time. In December of 2025 my engine started doing the same thing as before with the knocking and burning fuel and reduced speeds when on the highway so again it went into the dealer. It has since been in there and first was told it was the fuel injector again. They priced out the one was bad and I asked them to replace the remaining 6 fuel injectors so I didn't have this issue again in the near future. They did and the vehicle had the same issues going on. During the next inspection it was determined that the engine needed new rocker arms. These were replaced but this also did not solve the problem and the vehicle would not pass the regeneration on the engine. During the next inspection it was determined that we needed to replace a cylinder and one of the valves. After this was complete they were still having issues and then I was told that the Piston was bad and there are (2) bad valves so I need an entire engine replacement. My truck only has 130,000 miles and has been in the shop for almost 2 months last year from engine issues and it has had all maintenance completed at he same dealership with Records.

first issue was around April-May 2025 when my engine started knocking and burning fuel. Warning light came on and it went right in to the dealer where I have all my maintenance done. They determined that it due to (2) faulty fuel injectors and I had them replaced at that time. In December of 2025 my engine started doing the same thing as before with the knocking and burning fuel and reduced speeds when on the highway so again it went into the dealer. It has since been in there and first was told it was the fuel injector again. They priced out the one was bad and I asked them to replace the remaining 6 fuel injectors so I didn't have this issue again in the near future. They did and the vehicle had the same issues going on. During the next inspection it was determined that the engine needed new rocker arms. These were replaced but this also did not solve the problem and the vehicle would not pass the regeneration on the engine. During the next inspection it was determined that we needed to replace a cylinder and one of the valves. After this was complete they were still having issues and then I was told that the Piston was bad and there are (2) bad valves so I need an entire engine replacement. My truck only has 130,000 miles and has been in the shop for almost 2 months last year from engine issues and it has had all maintenance completed at he same dealership with Records.

first issue was around April-May 2025 when my engine started knocking and burning fuel. Warning light came on and it went right in to the dealer where I have all my maintenance done. They determined that it due to (2) faulty fuel injectors and I had them replaced at that time. In December of 2025 my engine started doing the same thing as before with the knocking and burning fuel and reduced speeds when on the highway so again it went into the dealer. It has since been in there and first was told it was the fuel injector again. They priced out the one was bad and I asked them to replace the remaining 6 fuel injectors so I didn't have this issue again in the near future. They did and the vehicle had the same issues going on. During the next inspection it was determined that the engine needed new rocker arms. These were replaced but this also did not solve the problem and the vehicle would not pass the regeneration on the engine. During the next inspection it was determined that we needed to replace a cylinder and one of the valves. After this was complete they were still having issues and then I was told that the Piston was bad and there are (2) bad valves so I need an entire engine replacement. My truck only has 130,000 miles and has been in the shop for almost 2 months last year from engine issues and it has had all maintenance completed at he same dealership with Records.