2010 VOLKSWAGEN JETTA Fuelpropulsion System Problems

Why driving at 55mph the high pressure fuel pump grenaded sending metal shrapnel through the engine causing an immediate engine shut off while still driving. Entire fuel system has shut down as result

Im thinking electrical problems lights windshield wipers air locks windows locks dont work when you turn the car off lights dont go out! there is 6 recalls on this car i need to find out if they have been fixed. It was bought for my daughter and can not give it to her like this

I was driving 75 miles an hour on a major interstate and the car stopped accelerating while I was driving.(major safety issue) I was able to get to the side of the road and the car died and would not start again. The glow plug warning light started flashing as this was happening. I was able to get it towed to a repair shop or they told me the high-pressure fuel pump failed and that it was a catastrophic failure because there was metal from the pump through the whole fuel line.

VEHICLE WILL CUT OUT WHILE DRIVING AT HIGHWAY SPEEDS. THIS HAS BEEN HAPPENING FOR OVER A YEAR. MULTIPLE PARTS HAVE BEEN REPLACED OVER THIS TIME. THE INTERNET HAS MANY CASES OF THIS SAME PROBLEM HAPPENING TO OTHER PEOPLE. VW MUST KNOW ABOUT THIS PROBLEM. THIS IS A VERY DANGEROUS PROBLEM?

I WAS DRIVING DOWN A BUSY ROAD WHEN I SAW SMOKE COMING OUT FROM UNDER MY HOOD OF THE CAR. I IMMEDIATELY PULLED OVER ONTO A SIDE STREET AND POPPED THE HOOD. THE ENGINE WAS ENGULFED IN FLAMES. I THEN PULLED MY PANICKED 4 YEAR OLD DAUGHTER OUT OF HER CAR SEAT AND TOOK HER ACROSS THE STREET. WE THEN CALLED 9-11 AND THE SHERIFF'S DEPARTMENT AND FIRE DEPARTMENT SHOWED UP TO PUT OUT THE FIRE. I HAD MY CAR TOWED TO A MECHANIC WHERE HE SAYS THE FIRE WAS CAUSED BY A FUEL LINE. THERE IS A RECALL FOR THE SAME YEAR AND MODEL FOR MY CAR BUT IT IS NOT FOR MY VIN# EVEN THOUGH IT'S THE SAME CAUSE AS MY CAR'S FIRE!

CAR WILL UNPREDICTABLY STALL SOME TIMES, CLOSE THE IGNITION SWITCH AND ENGINE WILL BE ABLE TO START,,, WILL GO IN LIMP HOME MODE WHEN THE GLOW PLUG LIGHT WILL ILLUMINATE AND CHECK ENGINE LIGHT COMES ON FOR DTC P00AF....

ABS MODULE HAS FAILED. FUEL PUMP HAS FAILED. 3 DOOR LOCK MODULES HAVE FAILED. RADIO HAS FAILED. FUEL PUMP ISSUES CAUSED BATTERY DRAIN ISSUES.

WHILE DRIVING ANYTIME THAT WE WOULD SLOW DOWN OR PUT THE VEHICLE INTO REVERSE THE VEHICLE WOULD GO RANDOMLY IN NEUTRAL. IT WAS RANDOMLY THIS WOULD HAPPEN AND BECAME MORE FREQUENT. TOOK IT TO A DEALER AND THEY SAID WE WOULD HAVE TO HAVE THE TRANSMISSION REPLACED SOON. RIGHT BEFORE THIS THEIR WERE ABOUT ANOTHER $3,000 WORTH OF ISSUES WE HAD TO FIX.

I WAS DRIVING ON THE EXPRESSWAY WHEN A CAR ON THE SHOULDER PULLED OUT WITHOUT SEEING ME. I WENT TO HONK MY HORN AND IT DIDN'T WORK. I LUCKILY SWERVED INTO THE NEXT LANE WITHOUT HITTING THE CAR IN THE NEXT LANE. I FOUND OUT IT'S NOT JUST MY HORN BUT THE COCK SPRING NEEDS REPLACING. NOTHING ON MY STEERING WHEEL WORKS NOW AND MY AIRBAG WARNING LIGHT STAYS ON.

ON JUNE 6TH, WHILE ROLLING UP TO AN INTERSECTION, THE GLOW PLUG SENSOR LIGHT FLASHED, AND THEN CAR STALLED. IT WOULDN'T START AGAIN. IT WAS EXTREMELY DANGEROUS AS THE MPH ON THE ROAD IS 50, AND THE CAR WAS NOT IN A GOOD POSITION TO BE MOVED TO THE SIDE OF THE ROAD. TONS OF CARS PASSING VERY FAST AT 9:30 PM. WE HAD IT TOWED TO THE DEALERSHIP, WHO FOUND METAL IN THE FUEL. THEY DIAGNOSED IT AND SAID THE FUEL PUMP HAD DIED. DUE TO THE EMISSIONS SCANDAL, VW GAVE US AN EXTENDED EMISSIONS WARRANTY, WHICH THANKFULLY COVERS THE ENTIRE FUEL SYSTEM! WOW! BUT THEN, THE DEALERSHIP SAID THEY TESTED THE FUEL AND SAID IT FAILED THE CONTAMINATION TESTS. I HAVE KEPT A LOG OF MY MILEAGE EVER SINCE I GOT THE CAR. IN FACT, I EVEN SAVED MY LAST FEW RECEIPTS WHICH SHOW I ONLY PUT DIESEL...

ENGINE STALLS OUT AS IF IT IS GETTING NO FUEL. IT HAPPENS WHEN IT IS STATIONARY, IN MOTION AND ON CITY STREETS ON OCCASIONS AND VERY DANGEROUS. SEEMS LIKE SOMETHING WRONG WITH THE FUEL PUMP.

OCCASIONALLY THE CAR WILL STALL AND SURGE CREATING A JOLT AT VARIABLE SPEEDS BUT ALWAYS WHILE IN MOTION. USUALLY WHEN ACCELERATING FROM IDLE BUT SOMETIMES DURING HIGHWAY DRIVING.

VEHICLE STALLS WHILE IN MOTION ON A STATE HIGHWAY BUT COASTING TO A STOP AT A TRAFFIC SIGNAL. CLUTCH PEDAL WAS FULLY DEPRESSED. HAS HAPPENED ABOUT 5 TIMES BETWEEN JULY 1, 2017 AND AUGUST 29, 2017. THIS VEHICLE IS A DIESEL. FUEL PUMP MIGHT BE LOOSING POWER. WEATHER WAS DRY. AIR AND FUEL FILTERS ARE NOT DIRTY. THEY WERE RECENTLY REPLACED.

LATERAL SPACING BETWEEN ACCELERATOR AND BRAKE PEDAL TOO NARROW. THIS SITUATION CAUSES THE DRIVER TO PUSH THE ACCELERATOR PEDAL WHEN REQUIRING BRAKING. ON AT LEAST ONE OCCASION THIS CAUSED ME TO IMPACT A STATIONARY VEHICLE DIRECTLY IN FRONT OF ME. THIS IS A DANGEROUS CONDITION THAT IS AGGREVATED WHEN LARGER FOOTWEAR IS WORN, THIS CONDITION SHOULD BE INVESTIGATED, AS IT AN UNACCEPTABLE PRESENTS A SAFETY RISK

DRIVING ON INTERSTATE HIGHWAY FOR GREATER THAN 30 MINUTES, THERE WAS ONSET OF STRONG RAIN CONDITIONS AT ABOUT 30 MINUTES OF DRIVING TIME -- THE EPC LIGHT CAME ON AND THE ABILITY TO ACCELERATE WAS LOST. SYMPTOMS OF DOWNSHIFTING WERE NOTED JUST PRIOR TO ONSET OF ISSUE. DEPRESSING THE ACCELERATOR RESULTED IN RPM INCREASE WITH NO ACCELERATION IN RELATIVELY FAST TRAFFIC (>50MPH). WAS ABLE TO PULL OFF SAFELY AND SHUT VEHICLE OFF. VERY DANGEROUS SITUATION IN HIGH SPEED/STRONG RAIN CONDITIONS. EPC LIGHT TURNED OFF AFTER SHUTOFF AND RE-START, AND I ASSUMED A SLIP ON WET SURFACE. RESTARTED AND ATTEMPTED TO REJOIN TRAFFIC. TRAVELED LESS THAN 50 FEET AND EPC LIGHT RE-LIT WITH NO SLIP, FOLLOWED IMMEDIATELY BY LIGHTING OF THE 'CHECK ENGINE' LIGHT. SAME LACK OF ACCELERATION AND INCREASED RPM WITH DEPRESSING THROTTLE PEDAL WAS NOTED. TURNED OFF ENGINE ON SHOULDER AGAIN AND RESTARTED AFTER FIVE MINUTE PERIOD IN ATTEMPT...

WHILE DRIVING TO WORK ON A VERY BUSY INTERSTATE MY 2010 VW JETTA TDI HAD A CHECK ENGINE LIGHT COME ON, IMMEDIATELY FOLLOWED BY MY CAR STUTTERING AND SHUTTING OFF IMMEDIATELY. AFTER NEING TOWED TO THE DEALER, I WAS INFORMED THE ENTIRE FUEL SYSTEM HAD TO BE REPLACED AND THAT THIS WAS A MAJOR ISSUES WITH VW DIESELS (ESP. YEARS 2009 & 2010). THE HPFP HAD BECOME SUCH A PROBLEM THAT THE MANUFACTURER EXTENDED THE WARRANTY FOR THE FUEL SYSTEM TO 120K MILES OR 10 YEARS. MY MILEAGE WENT OVER THE ALLOTTED AMOUNT BY 5K MILES BUT AFTER MANY CALLS TO VW CUSTOMER SERVICE THEY REFUSED ANY HELP, THEY WOULD NOT COVER THE $5,000 REPAIR, THE $3,000 IN PARTS OR ANYTHING. THEY REFUSED ANY TYPE OF HELP EVEN THOUGH THEY MOST CERTAINLY COULD HAVE ASSISTED ME. IT IS WELL KNOWN THAT THE FUEL PUMP IS POOR, EVEN THE REPLACEMENT PUMPS...

IGNITION SYSTEM KEEPS FAILING. CAR KEYS GET STUCK AND CAR WON'T TURN OFF AND HAVING A HARD TIME TUNING THE KEY TO START THE CAR. EACH TIME THE CAR IS PARKED AND THE STEERING LOCK IS DISENGAGED.

CAR SUDDENLY UNABLE TO ACCELERATE BEYOND 30 MPH. CAR GENTLY DRIVEN TO DEALERSHIP WHERE CAR DIED AND WAS UNABLE TO START. DEALERSHIP HAS INVESTIGATED AND FOUND METAL SHARDS FROM FUEL FILTER HAVE MIGRATED THROUGHOUT THE FUEL SYSTEM. COST OF REPAIR $5400. CAR IS PART OF VW BUYBACK PROGRAM. DEALER REFUSED TO BUY BACK VEHICLE WITHOUT REPAIR STATING VEHICLE MUST BE " ABLE TO GET TO DEALERSHIP ON ITS OWN'. I DROVE VEHICLE TO DEALER. DEALER REFUSES TO WORK WITH ME ON BUYBACK. NOW FORCED TO PAY FOR EXPENSIVE REPAIR. DEALER STATE REPAIR " EXPECTED DUE TO HIGH MILEAGE" I HAVE ALWAYS HAD HIGH MILEAGE VEHICLES AND HAVE NEVER BEFORE HAD METAL IN FUEL LINE DUE TO FUEL FILTER FAILURE.

DIESEL FUEL FILTER IS CLOGGING UP AND WAS TOLD THAT IT REQUIRED REPLACEMENT AT A COST OF $7,000.00.

WHILE ON A CITY STREET AT STOPPED AT A STOP LIGHT MY VW JETTA TDI MADE A FUNNY NOISE AND SHOOK. THEN IT ACTED LIKE IT WANTED TO STALL, THE GLOW PLUG LIGHT CAME ON. THE STOP LIGHT CHANGED AND I WAS ABLE TO PULL INTO A PARKING LOT. WHEN I PULLED INTO A PARKING SPOT BEFORE I COULD TAKE THE CARE OUT OF GEAR, IT STALLED. I WAS NOT ABLE TO GET THE CAR TO START AGAIN. I WAS TOLD BY VW OF SAN BERNARDINO THAT THIS WAS A KNOW ISSUE WITH THE HIGH PRESSURE FUEL PUMP. THE RECALL UPDATE WAS PREFORMED BACK IN 2014 TO PREVENT THE INCORRECT FUEL FROM BEING PLACED INTO THE VEHICLE. I AM A LONG TIME DIESEL OWNER AND HAVE NEVER PLACED THE INCORRECT FUEL INTO THE CAR. I BELIEVE THERE IS A DEFECT IN THE DESIGN OR MATERIAL RELATED TO THE HIGH PRESSURE...

MY CAR STALLED WHILE DRIVING IT WAS TOWED TO THE DEALERSHIP WHERE I WAS INFORMED THAT THERE WAS AN EXTENDED WARRANTY ON THE HIGH PRESSURE FUEL PUMP ASSOCIATED WITH MY CAR MAKE AND MODEL. I WAS THEN INFORMED THAT MY CAR WAS NOT COVERED UNDER THE EXTENDED WARRANTY BECAUSE I DID NOT HAVE A MISFUEL GUARD INSTALLED. I NEVER RECEIVED ACTUAL NOTICE THAT I WAS TO INSTALL A MISFUEL GUARD UNTIL THE DAY MY CAR STALLED AND HAD TO BE TOWED TO THE DEALERSHIP. THE DEALERSHIP RAN A FUEL TEST WHICH REVEALED THAT THERE WAS NO IMPROPER FUEL IN MY CAR, THUS, EVEN IF THE MISFUEL GUARD HAD BEEN INSTALLED, MY FUEL PUMP WOULD HAVE STILL FAILED. I HAVE CONTACTED VOLKSWAGEN AS WELL AND THEY ALSO INFORMED ME THAT BECAUSE I DID NOT HAVE THE MISFUEL GUARD INSTALLED, I WAS UNABLE TO BE COVERED UNDER THE WARRANTY, EVEN THOUGH THERE...

HIGH PRESSURE FUEL PUMP FAILED WHILE DRIVING ON THE FREEWAY 60 MPH CAR SUDDENLY LOST POWER AND LUCKILY I WAS IN THE SLOW LANE AND WAS ABLE TO PULL OVER TO SHOULDER

I BOUGHT THIS CAR IN MAY 2015 DUE TO THE AWESOME FUEL ECCONOMY PAIRED WITH SUPPOSED GREAT RELIABILITY.THE HIGH PRESSURE FUEL PUMP WENT OUT AROUND OCTOBER 2015. I WAS HEADED TO WORK AND THE ENGINE STARTED SKIPPING JUST FOR A SHORT TIME. I DROVE TO WORK WITHOUT ANY MORE ISSUES. WHEN I WAS LEAVING WORK, THE ENGINE STARTED RUNNING REAL ROUGH SO I PULLED OVER AND I HEARD A SQUEALING/RATTLING NOISE FROM AN AREA AROUND THE TIMING COVER. THE ENGINE STALLED. I STARTED IT BACK UP AND AFTER MAYBE 10 SECONDS IT STALLED AGAIN AND WOULDN'T START BACK UP. I TOWED THE CAR TO A VW SPECIALIST SHOP AND THEY DIAGNOSED THE ISSUE AS A FAILED HIGH PRESSURE FUEL PUMP AND REQUIRING REPLACEMENT OF THE ENTIRE FUEL SYSTEM. I HAD THE CAR TOWED TO A VW DEALERSHIP AND THEY'RE DIAGNOSTIC WAS THE SAME. THEY SENT OUT A FUEL SAMPLE AND...

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP AND THE FUEL INJECTORS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V621000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 115,000. THE VIN WAS NOT AVAILABLE.

WHILE EXCELERATING FROM A RED LIGHT MY CAR WENT INTO "LIMP MODE" AND LOST MOST OF ITS POWER. I COULD NOT DRIVE FASTER THAN 40 MPH OR 2400 RPM. I CONTACTED VW DEALER AND THEY INSTRUCTED ME TO DRIVE THE VEHICLE IN WHICH WAS ONLY 8 MILES FROM MY HOUSE. ENROUTE TO DEALERSHIP MY CAR LOST ALL POWER AND SHUT OFF IN THE MIDDLE OF THE ROAD. I COULD NOT START THE VEHICLE AND HAD TO GET IT TOWED TO THE DEALERSHIP. UPON INSPECTION, IT WAS FOUND THAT MY HIGH PRESSURE FUEL PUMP HAD FAILED WHICH CAUSED MY TURBO TO ALSO FAIL. THE FUEL IN THE TANK WAS NOT CONTAMINATED, THIS WAS JUST A FAILURE OF THE SYSTEM.

I AM UNABLE TO OPEN THE GAS FILLER FLAP TO FILL MY GAS TANK WITH GAS. THE FILLER FLAP USUALLY OPENS USING THE CENTRAL LOCKING SYSTEM IN CAR OR THE KEY POD. NEITHER ACTIVATES THE FILLER FLAP NOW. THIS IS A SERIOUS SAFETY ISSUE WHICH VOLKSWAGEN DOES NOT HAVE A SOLUTION FOR.

CAR IN SHOP FOR APPROXIMATELY 11 DAYS. ALTHOUGH CAR OUT OF WARRANTY, FIXED WITH AUTHORIZATION FROM VW OF AMERICA AS A "WARRANTY" REPAIR AT NO CHARGE TO ME. BAD FUEL NOT AN ISSUE (TESTED). HPFP AND ALL MAJOR FUEL SYSTEMS/LINES CLEANED OR REPLACED. HIGH PRESSURE FUEL PUMP FAILURE.

DEALERSHIP PERFORMED 90K MILE CHECKUP. ALSO ASKED THEM TO DETERMINE IF CEL P0472 WAS COVERED BY WARRANTY. THEY CONFIRMED CODE, AND SAID NOT COVERED UNDER ANY WARRANTY. THE ALSO ADVISED THE CAR IS SHOWING INTERMITTENT CODE OF P0638 FOR THROTTLE ACTUATOR CONTROL (BANK 1). WRITTEN ON THE ESTIMATE BY VW DEALERSHIP IS "TECHNICIAN NOTED THAT WHILE DRIVING VEHICLE INTO THE SHOP, VEHICLE HAD NO THROTTLE CONTROL AND WOULD NOT INCREASE IN ENGINE SPEED. TECHNICIAN RECOMMENDS REPLACING THE THROTTLE BODY AND EXHAUST PRESSURE SENDER. TECHNICIAN RECOMMENDS CUSTOMER NOT TO DRIVE VEHICLE --VEHICLE WILL AT SOME POINT STOP DRIVING (MOVING) - IT COULD STOP MOVING AT ANY POINT, INCLUDING CROSSING A INTERSECTION". I HAVE NOT HAD ANY ISSUES WHATEVER WITH MY THROTTLE, BUT DUE TO THEIR DOCUMENTATION, IT APPEARS THERE IS A SAFETY ISSUE HERE DESERVING OF A MANDATORY SAFETY RECALL.

MY 2010 VW JETTA TDI IS THROWING CHECK ENGINE LIGHT CODES OF P0472 AND P0471. BOTH OF THESE HAVE TO DO WITH EXHAUST PRESSURE SENSORS AND I THINK THIS IS AN ENVIRONMENTAL ISSUE AND SHOULD BE SUBJECT TO A MANDATORY RECALL. THE LOCAL VW DEALERSHIP DENIES ANY RECALL WOULD COVER THESE CEL CODES.

UNDER NORMAL DRIVING CONDITIONS, CAR LOST ALL POWER, COMPLETELY STALLED IN FLOWING TRAFFIC ON A 2 LANE HIGHWAY AND WOULD NOT RESTART.

HPFP, HIGH PRESSURE FUEL PUMP FAILURE, IN MOTION ON CITY STREET STOPPED RUNNING, WILL NO LONGER START.

FUEL LINE #2 FAILED AFTER RECALLED REPAIR ON FUEL LINE #2 WAS PERFORMED. FUEL WAS SPILLING ONTO HOT ENGINE. I THINK THE ORIGINAL RECALL WAS NHTSA CAMPAIGN ID NUMBER : 11V490000. LOOKS TO ME THAT CAUSE OF FAILURE WAS SAME AS COVERED IN RECALL-VIBRATION FATIGUE.

THE CAR LOST POWER WHILE GOING UPHILL AND WOULD ONLY REACH SPEEDS OF ABOUT 20MPH ON A 40MPH ROAD. THE CAR CHECK ENGINE LIGHT HAD COME ON ABOUT A MONTH BEFORE. I WAS TOLD THERE WAS A PROBLEM WITH THE HIGH PRESSURE FUEL PUMP AND IT WOULD NEED TO BE REPLACED BUT THE CAR WOULD BE SAFE TO DRIVE UNTIL IT STOPPED POWERING UP TO TOP SPEED.

YEAR: 2010 BUILD DATE: AUG 2009 MAKE/MODEL: JETTA SPORTWAGEN TDI TRANNY: 6M MILEAGE: (ACTUAL MILES AT TIME OF PROBLEM OR WHEN PROBLEM BEGAN) 57,500 DIESEL FUEL SOURCE: SHELL AND CHEVRON ADDITIVES: NOPE PROBLEM: TOOK MY TDI TO AN INDEPENDENT. FIRST TIME EVER (ALWAYS DEALER SERVICED). HAD A CHECK ENGINE LIGHT COME ON. CODE WAS A FUEL PRESSURE SENSOR. REPLACED. CAR WOULD NOT START. FOUND RUST IN FUEL FILTER CANISTER. FOUND RUST ON THE IN-TANK PUMP. REPLACED ALL THREE PUMPS, CANISTER, FUEL LINES '*THE INDEPENDENT TOOK IT ONE PIECE AT A TIME AS TO NOT OVERCHARGE. ULTIMATELY, REPLACING THE HPFP SOLVED THE ISSUE. IN FACT, THE FUEL PRESSURE SENSOR THEY ORIGINALLY REPLACED THEY PUT BACK IN AND IT WORKED, SO THEY RETURNED THE ONE FROM THE DEALER. DEALER: CHARLES MAUND, AUSTIN, TX STATUS: SINCE I HAD MY WORK DONE AT AN INDEPENDENT, VW OF AMERICA IS SCOFFING AT PAYMENT AS NOTED...

MY 16 YEAR OLD DAUGHTER WAS DRIVING OUR 2010 VW JETTA CLEAN DIESEL TDI ON THE INTERSTATE AT 65 MPH WHEN SUDDENLY THE GLOW PLUG LIGHT CAME ON AND THERE WAS LOSS OF POWER; SHE PUSHED DOWN ON THE ACCELERATOR BUT TO NO AVAIL. AS THE CAR SLOWED DOWN, SHE WAS ABLE TO TAKE THE NEARBY OFF RAMP AND GET CAR TO THE SIDE OF THE ROAD. BY THE TIME THE CAR WAS COASTING TO THE SIDE OF THE ROAD THERE WAS A TOTAL LOSS OF POWER - STEERING, BRAKES, EVERYTHING. THE CAR WAS TOWED TO THE LOCAL VW DEALERSHIP WHERE THEY INFORMED WITH THE HIGH PRESSURE FUEL PUMP HAD FAILED AND IT WOULD COST $8,000 TO REPAIR. THE VOLKSWAGEN APPROVED MISFUELING GUARD WAS INSTALLED AT THE LOCAL VW DEALERSHIP SOON AFTER WE RECEIVED A LETTER FROM VW REGARDING IT. A WEEK PRIOR WE HAD RECEIVED IN THE MAIL FROM...

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. WHILE AT A STOP LIGHT, AN ABNORMAL NOISE COULD BE HEARD COMING FROM THE ENGINE WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE HESITATED PRIOR TO THE ENGINE FAILURE. THE VEHICLE HAD TO BE TOWED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE ENGINE WAS DEFECTIVE. THE HIGH PRESSURE FUEL PUMP RELAY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 10,000.

WHILE DRIVING IN MIDDLE LANE OF THE FREEWAY MY 2010 VOLKWAGEN JETTA TDI LOST POWER AND AND ENGINE LIGHT CAME ON. VEHICLE WAS ALMOST STRUCK BY TRAFFIC WHILE MAKING MY WAY TO THE RIGHT SIDE OF THE ROAD. CAR WAS TOWED TO LOCAL REPAIR SHOP WHERE I LEARNED THAT THE VEHICLE'S HIGH PRESSURE FUEL PUMP HAD FAILED. AFTER RESEARCHING THIS ISSUE I LEARNED FAILURE THIS HAPPENED FREQUENTLY 2009 - 2010 TDI CLEAN DIESEL VEHICLES AND INFORMATION ABOUT THIS PROBLEM IS WELL DOCUMENTED. THIS ISSUE NEEDS TO FIXED BEFORE A SERIOUS INJURY OR DEATH OCCURS.

THE HPFP FAILED ON MY VEHICLE CAUSING METAL TO CONTAMINATE THE ENTIRE FUEL SYSTEM. VWOA STATES THAT THEY WILL ONLY COVER VEHICLES WITH UNDER 120000 MILES. HOWEVER, MY VEHICLE IS SLIGHTLY OVER THAT AMOUNT. FROM THE RESEARCH I HAVE DONE, THIS PROBLEM HAS EFFECTED A LARGE AMOUNT OF VW TDI OWNERS. SINCE DIESELS ARE PURCHASED FOR THE SOLE PURPOSE OF BEING DRIVEN ON THE HIGHWAY, EXTENDING THE WARRANTY TO 120,000 MILES WILL NOT COVER MOST 5 YEAR OLD DIESELS ON THE ROAD. VW NEEDS TO TAKE RESPONSIBILITY FOR THIS FAILURE AND ISSUE A RECALL TO THOSE IMPACTED BY THIS FAILURE.

WHILE DRIVING CAR STALLED AND THE GLOW PLUG LIGHT CAMP ON, LUCKILY WE WERE ON OUR STREET AND NOT IN HIGH TRAFFIC AREA. CAR WILL NOT START AND BEING TOLD THAT WE HAVE METAL PIECES IN OUR ENGINE. 8500 FIX FOR A 2010 CAR THIS SHOULD BE COVERED UNDER SOME SORT OF RECALL OR WARRANTY IF THESE HIGH PRESSURE FUEL PUMPS ARE FAULTY. *TR

WHILE TRAVELING EASTBOUND ON INTERSTATE 82 IN WASHINGTON OUR 2010 JETTA EXPERIENCED A SAFETY-RELATED MALFUNCTION; THE "GLOW PLUG" LAMP ILLUMINATED, THEN THE "SERVICE ENGINE NOW" LAMP ILLUMINATED, FOLLOWED BY AN IMMEDIATE COMPLETE LOSS OF POWER AND THE ENGINE SHUT OFF. AFTER COMING TO A STOP, THE ENGINE WAS ABLE TO BE RE-STARTED AND THE VEHICLE WAS "LIMPED" WITH LIMITED POWER TO WITHIN A MILE OF OVERTURF VOLKSWAGEN IN KENNEWICK, WASHINGTON. THERE THE ENGINE EXPERIENCED ANOTHER TOTAL LOSS OF POWER AND WAS UNABLE TO BE RE-STARTED. THE VEHICLE WAS TOWED TO OVERTURF VOLKSWAGEN AND WE WERE INFORMED THAT THE "HIGH PRESSURE FUEL PUMP" HAD EXPERIENCED A CATASTROPHIC FAILURE, RESULTING IN METAL SHAVINGS FROM THE PUMP ENTERING THE FUEL SYSTEM, CLOGGING THE FUEL INJECTORS, AND STARVING THE ENGINE OF FUEL. WE WERE INFORMED THAT THIS ISSUE IS A DESIGN FLAW AND IS WELL KNOWN TO VOLKSWAGEN, BUT WERE TOLD THAT OUR VEHICLE...

INCIDENT OCCURRED WHEN APPROACHING AN INTERSECTION. ENGINE DIED AS IF THE CAR RAN OUT OF FUEL. TRIED TO RESTART THE CAR BUT THE CAR WOULD NOT TURNOVER. IT WOULD ONLY CRANK. ACTED LIKE IT RAN OUT OF FUEL BUT THERE WAS HALF A TANK OF FUEL.

HIGHWAY DRIVING, GLOW PLUG LIGHT STARTED FLASHING, STARTED LOSING POWER, THEN STALL. MANAGED TO COAST OFF ONTO AN EXIT RAMP. MECHANIC TOWED, FOUND BATTERY/ALTERNATOR FINE, FUEL PRESSURE FINE, SUGGESTED DEALER REPAIR. VW DEALER SAYS ENTIRE FUEL SYSTEM NEEDS REPLACING: HPFP, FUEL LINES, ETC. NOTED NHTSA INVESTIGATION PENDING ON VOLKSWAGEN FUEL PUMP PROBLEMS FOR SIMILAR MAKE, MODEL, YEAR: NHTSA ACTION NUMBER :EA11003

PULLED AWAY FROM STOP SIGN INTO TRAFFIC. ENGINE QUIT AS IF FUEL WAS CUT OFF. COASTED TO SIDE OF ROADWAY. CAR WOULD NOT RESTART THOUGH IT DID CRANK. ABOUT A THIRD OF A TANK OF FUEL, 80K SERVICE WAS TWO WEEKS AGO. CAR HAD TO BE TOWED TO SHOP.

THE CAR STARTED TO MAKE A STRANGE SOUND AND SHORTLY AFTER LOST ALMOST ALL POWER THEN STALLED OUT. THE GLOW PLUG LIGHT WAS FLASHING WHICH INDICATES A SIGNIFICANT PROBLEM. IT RESTARTED BUT STILL HAD NO POWER. I PULLED OVER TO THE SIDE OF THE ROAD WHERE IT STALLED AGAIN AND NOW WOULD NOT RESTART. I HAD THE CAR TOWED TO MY MECHANIC WHERE THEY FOUND THAT THE HPFP HIGH PRESSURE FUEL PUMP HAD FAILED. WHEN IT FAILED IT SELF DESTRUCTED PUTTING METAL SHAVINGS THROUGHOUT THE FUEL SYSTEM. VW'S RECOMMENDED REPAIR IS TO REPLACE THE ENTIRE FUEL SYSTEM AT A COST OF OVER $8000. THIS VEHICLE HAS BEEN METICULOUSLY MAINTAINED AND HAS NEVER BEEN MISFUELED. *TR

I ENJOYED THIS CAR FOR THE FIRST YEAR FROM THEN ON NOTHING BUT CONSTANT PROBLEMS. THE DAUL MASS FLYWHEEL, THE DIESEL PARTICULATE FILTER #1 AT 98000 MILES WITH A CON ARTIST SERVICE MANAGER AT LAGDON VW IN VERNON CT. TELLING ME I NEEDED ANOTHER ONE 3 WEEKS LATER AND IT WAS MY FAULT AND NOT COVERED WITH VWOA STANDING BY THE DEALER I TOOK THE CAR TO A NON VW REPAIR SHOP AND THEY LAUGHED WHEN I TOLD THEM MY STORY AND HAD THE DIESEL PARTICULATE FILTER FIXED IN 10 MINUTES WITH NO CHARGE. THE CAR PASSED STATE EMISSIONS WITH NO PROBLEM. THE HIGH PRESSURE FUEL PUMP WENT. NOW WITH 6 PAYMENTS LEFT IT NEEDS TOO MUCH TO LIST AND I MAY DEFAULT ON LOAN BECAUSE OF CONSTANT MONEY SPENT ON REPAIRS. THE CREDIT UNION SAYS THEY MAY STOP FINANCING VW TDI'S BECAUSE OF ALL THE COMPLAINTS AND DEFAULTS. *TR

THE CAR AFFECTED IS A 2010 VW JETTA TDI. EVER SINCE I'VE OWNED THE CAR, IT HAS HAD AN ISSUE WITH RUNNING RUFF OR STALLING OUT. AT 30,426 MILES I HAD THE DEALER LOOK AT THE VEHICLE. THEY RAN A DIAGNOSTIC AND TEST DRIVE WITH NO ISSUES FOUND. THIS ENOUGH FOR IT TO BE NOTICEABLE, BUT NO SYMPTOMS ARE PRESENT. I BROUGHT THE CAR IN AGAIN FOR THE SAME ISSUE ON 12/8/14 AT 83748 MILES, BUT THIS TIME THERE WAS AN ESP ERROR THAT FLASHED IN THE MDI DISPLAY AND THEN WENT AWAY. THE DEALER COULD NOT VERIFY THE CUSTOMER COMPLAINT. THE SERVICE MANAGER ALSO STATED THAT HE HAD A SIMILAR VEHICLE WITH THE SAME PROBLEM AND THE COULD ALSO NOT BE DIAGNOSED. AT THE TIME THE DEALER TOLD ME THAT I COULD HAVE THE SOFTWARE UPGRADED AND THAT WOULD BE A CHARGE TO ME OR I COULD HAVE THE...

I WAS DRIVING MY 2010 VW JETTA TDI IN A PARKING LOT, SLOWING DOWN AT LESS THAN 5 MPH TO STOP. ALL OF A SUDDEN, THE ENGINE STALLED WITHOUT WARNING. NO WARNING OR CHECK ENGINE LIGHTS CAME ON AT ALL. I HAD TO PUT THE CAR INTO PARK TO RESTART IT. SINCE THIS INCIDENT, THE ENGINE SEEMS TO BE SPUTTERING AT LOW SPEEDS. *TR

FLEW TO DALLAS TO PURCHASE THIS CAR 2/27/15. DROVE IT HOME 1500 MILES TO LOS ANGELES OVER 2 DAYS. GOT TO EL PASO ON 3/1/15 & GOT INTO AN ACCIDENT TRAVELING AT A VERY SLOW SPEED (15MPH OR LESS) GOING DOWNHILL. MY PARTICULAR ISSUE COMES IN THE WAY OF HOW THE TRANSMISSION BEHAVES GOING DOWNHILL AT HIGH OR SLOW SPEEDS. WHEN THE CARS ECU (ELECTRONIC CONTROL UNIT) SENSES THE CAR GOING DOWNHILL, AND YOU TRANSITION FROM THE THROTTLE PEDAL TO THE BRAKE PEDAL, THE CAR BEHAVES AS IF YOU WERE DRIVING A MANUAL TRANSMISSION DOWNSHIFTING & STAYING IN GEAR. NOW YOU MAY THINK THAT'S NOT A PROBLEM, BUT....SINCE THESE TRANSMISSIONS TECHNICALLY ARE MANUAL TRANSMISSIONS WITH AN AUTOMATIC CLUTCH...IF YOU WERE DRIVING A MANUAL TRANSMISSION CAR & WANTED TO STOP QUICKLY AS I DID TO AVOID HITTING ANOTHER CAR, YOU WOULD PUSH THE CLUTCH IN TO DISENGAGE THE TRANSMISSION FROM THE...

WHILE DRIVING, GLOW PLUG INDICATOR FLASHED RAPIDLY, INDICATING ENGINE MALFUNCTION. CAR EXPERIENCED A REDUCTION IN POWER. AFTER PARKING IN PARKING LOT, CAR STARTED UP AND APPEARED INITIALLY OK, BUT THEN EXPERIENCED TOTAL ENGINE FAILURE AFTER DRIVING <300 FEET. CAR WAS TOWED TO MECHANIC. MECHANIC INDICATES THAT METAL FRAGMENTS/FLAKES WERE FOUND DISTRIBUTED THROUGHOUT FUEL SYSTEM/ENGINE, CONSISTENT WITH FAILURE OF HIGH PRESSURE FUEL PUMP. MECHANIC STATED THAT THIS CONDITION WAS CONSISTENT WITH PICTURES/DESCRIPTION FOUND IN TECHNICAL SERVICE BULLETIN 23 14 03.

VEHICLE LOST POWER AND WENT INTO LIMP MODE, DASH SAID SERVICE ENGINE. CAR DIED A FEW MINUTES LATER AS I TRIED TO LIMP IT TO THE DEALER AND IT WOULD NOT RESTART. I HAD TO TOW THE VEHICLE AT MY OWN EXPENSE BUT VOLKSWAGEN DID PAY FOR A COMPLETELY NEW FUEL SYSTEM. CAUSE OF THE PROBLEM WAS A FAILURE OF THE DIESEL HIGH PRESSURE FUEL PUMP. THERE ARE THOUSANDS OF CASES OF THIS SAME PROBLEM DOCUMENTED HERE: HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=299854 VOLKSWAGEN NEEDS TO BE HELD ACCOUNTED FOR A DEFECT IN THEIR COMMON RAIL DIESEL CARS IF THERE ARE THIS MANY PROBLEMS. *TR