2003 VOLKSWAGEN JETTA Seats Problems

WHEN THE SEAT HEATER IS TURNED ON, THE SEAT CATCHES ON FIRE. WHEN YOU LOOK AT THE PICTURE THAT IS SMOKE COMING FROM THE SEAT, THE HOLES WERE CAUSED BY THE SEAT HEATER.

THE ELECTRIC SEAT HEATER MALFUNCTIONED AND BURNED A HOLE IN THE SEAT WHILE IN USE. IT NO LONGER REGULATES. DANGEROUS FOR DRIVING. SMELLED LIKE A FIRE!

WHEN I WAS SITTING IN THE DRIVER'S SEAT WITH THE HEATED SEAT OPTION TURNED TO A 5 (HIGH), WHILE THE CAR WAS WARMING UP, I NOTICED SOME SMOKE COMING FROM THE RIGHT SIDE OF THE SEAT. THE HEATED SEAT STARTED TO BURN THROUGH THE CLOTH COVER DIRECTLY WHERE MY METAL JACKET ZIPPER WAS MAKING CONTACT WITH THE CLOTH SEAT SURFACE. I IMMEDIATELY POURED WATER ON THE SEAT TO ENSURE A FIRE DIDN'T START. I HAVE NOT ATTEMPTED TO USE THE SEAT HEATERS SINCE THIS INCIDENT.

THE RIGHT AREA OF THE DRIVER'S SIDE HEATED SEAT BEGAN TO GET EXCESSIVELY WARM SO I DISCONTINUED USE FOR A PERIOD OF TIME. SUBSEQUENT ATTEMPT AT USE RESULTED IN THE HEATING COIL BURNING THROUGH THE UPHOLSTERY. PICTURES ATTACHED. I HAVE DISCONTINUED USE AND LEARNED THERE IS AN EXPIRED RECALL FOR THIS AS A KNOW ISSUE.

DRIVER SIDE SEAT HEATER GETS VERY GOT. ON MARCH 4, 2016 AT 7:30AM NOTICED A BURNT SMELL AS I PARKED MY CAR (I HAD DRIVEN FOR ABOUT 20 MINS). WHEN I RETURNED AT 12PM FOR LUNCH, I NOTICED 2 BURNT AREAS OF MY LEATHER SEAT. MARCH 5TH, TRIED TO USE HEATER AGAIN BUT WITHIN 10 MINS IT GOT TOO HOT TO TOUCH AND BURNT SMELL, REALLY BAD. I SHUT IT OFF. I CAN'T USE THIS NOW. VERY DISAPPOINTED.

SOMEONE LEFT THE PASSENGER SIDE SEAT HEATER ON. I STARTED SMELLING A BURNING PLASTIC ODOR THEN I CAME ACROSS A SMALL BURN MARK. ANOTHER PERSON LEFT IT ON, THE WHOLE BECAME BIGGER BUT NO SCENT.

DRIVERS SIDE HEATED SEAT BURNED HOLE IN SEAT FABRIC AND BURNED PANTS AND RIGHT LEG. LOCAL DEALERSHIP STATED "NO RECALL ISSUED FOR THIS VEHICLE".

TL- THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH A BURNING PLASTIC ODOR WAS PRESENT INSIDE THE VEHICLE BEFORE THE PASSENGER SUDDENLY EXPERIENCED A BURNING SENSATION COMING FROM THE SEATED AREA OF THE PASSENGER SEAT. THE CONTACT INDICATED THAT THE PASSENGER SIDE SEAT HEATER ELEMENT HAD OVER HEATED CAUSING A BURN HOLE IN THE SEAT AND CAUSING A MINOR BURN TO THE PASSENGER. THE CONTACT STATED THAT A SMALL FLAMED TO THE PASSENGERS RIGHT PANT LEG HAD TO BE EXTINGUISHED DURING THE INCIDENT AND THE PASSENGER SEAT BURN HOLE MEASURED APPROXIMATELY 1 INCH IN DIAMETER. THE VEHICLE WAS DIAGNOSED AT THE DEALER. THE CONTACT WAS INFORMED THAT THE DEFECT WAS CAUSED BY A FAULTY HEAT ELEMENT INSIDE THE SEAT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 125,000. JFT

I STARTED EXPERIENCING A HOT SPOT IN THE DRIVER'S HEATED SEAT IN THE FALL OF 2012. I HAVE TO PUT A CUSHION BETWEEN MY RIGHT LEG AND THE SEAT OR IT WILL NEARLY BURN. I HAVE ALSO BEEN HAVING AN ISSUE WITH EITHER THE O2 SENSOR OR CATALYTIC CONVERTER WHENEVER IT RAINS AND IT'S COOL WEATHER. THE CAR WILL LOSE POWER, SPUTTER AND LURCH UNTIL IT HAS BEEN RUNNING FOR A WHILE THEN IT ACTS NORMALLY. FINALLY, FOR THE PAST TWO MONTHS THE REAR DOOR LOCKS WILL NOT OPEN WITH THE KEYLESS ENTRY OR BY HITTING THE LOCK/UNLOCK BUTTON ON THE DOOR. I JUST REACHED THE 100K MARK AND KEEP UP REGULAR MAINTENANCE ON MY CAR SO I'M A LITTLE UPSET THAT THINGS LIKE THIS ARE HAPPENING SO EARLY. *TR

BOTH FRONT SEATS, THE BOTTOM RIGHT SIDE BOLSTER BURNED. THE HEATED FRONT SEATS WILL OVER HEAT, THE FAILURE APPEARS TO BE CONFINED TO THE RIGHT BOLSTER ON THE BOTTOM SECTION OF THE SEAT. THE HEATING ELEMENTS GET HOT ENOUGH TO BURN THROUGH THE SEAT MATERIAL. BEING THE SIDE OF THE SEAT I WAS ABLE TO SHIFT MY LEG AWAY AND POWER OFF THE HEATED SEAT. IF LEFT ON THE SEATS WILL START TO SMOKE. I CONSIDER THIS A SAFETY ISSUE, I HAVEN'T TRIED , BUT IT SEEMS AS THOUGH THE SEAT COULD CATCH ON FIRE IF LEFT ON. THE LOCAL DEALER'S SERVICE REP SAID JUST UNPLUG IT THE OPTION. *TR

AFTER NOTICING FOR WEEKS THAT MY HEATED SEATS WOULD ONLY WORK WHEN TURNED TO 5 (PASSENGER SEAT DOESN'T WORK AT ALL), MY LEG BEGAN BURNING WHILE DRIVING. I SMELLED SOMETHING BURNING AND LOOKED DOWN TO SEE THAT THERE WAS A HOLE IN MY SEAT AND THERE WAS SMOKE COMING OUT OF IT. I IMMEDIATELY TURNED THE SEAT OFF AND HAVEN'T TURNED IT ON SINCE. WHEN I CONTACTED VW, THEY TOLD ME THAT MY VEHICLE WAS NOT INCLUDED IN THE HEATED SEAT RECALL AND THAT I WOULD BE RESPONSIBLE FOR THE COST OF DIAGNOSING THE PROBLEM AS WELL AS FOR THE REPAIRS. *TR

SHORTLY AFTER TURNING THE DRIVERS SEAT HEATER ON, OPERATOR SMELLED SOMETHING BURNING AND FELT HER LEFT LEG BURNING. SHUT HEATER OFF AND TOOK TO DEALER, WHO ACTED SURPRISED THAT WE HAD A PROBLEM!! THEY CHARGED US TO LOOK AT THE SEAT, CLAIMING THE POWER SUPPLY WIRE UNDER THE SEAT HAD BEEN PULLED APART SHORTING OUT THE GRID WIRING. LONG STORY SHORT, THEY CLAIMED SOMETHING MUST HAVE BEEN JAMMED UP UNDER THE SEAT CAUSING THE PROBLEM. THEY OFFERED TO DO THE NECESSARY REPAIRS FOR $630. I THOUGHT THEIR ANSWER WAS CREATIVE, BUT AFTER READING ALL THE OTHER COMPLAINTS WHICH ARE VIRTUALLY IDENTICAL(QUARTER SIZED HOLE IN THE SEAT COVER), I'M CALLING [XXX]. I AM DISGUSTED WITH HOW VW HAS RESPONDED TO ALL OF US. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DRIVER'S SEAT HEATER MALFUNCTIONED. RIGHT SIDE OF SEAT HAS SMALL BURN MARKS, IS DISCOLORED, HAS EXPOSED ELEMENTS, AND SEAT FOAM IS MELTED. TWO PAIRS OF PANTS OBTAINED SINGE MARKS ON SEPARATE OCCASIONS. I DRIVE THE CAR TO AND FROM THE CITY VIA INTERSTATE FOR 40 MINUTES EACH WAY. SEAT HEATERS ARE TYPICALLY ON FOR ABOUT 20 MINUTES. BEGINNING IN NOVEMBER WHEN I USED THE SEAT HEATERS I COULD SMELL A SLIGHT BURNING SMELL. SINCE IT WAS THE BEGINNING OF THE WINTER SEASON I FIGURED IT WAS JUST HEATED DUST ON MY SEATS FROM BEING INACTIVE ALL SUMMER. THE FINAL TIME I USED THE SEAT HEATERS (1/26/12) THE SMELL GOT SO BAD THAT I HAD TO OPEN THE SUN ROOF FOR AIR. I ALSO NOTICED THE SEATS GOT HOTTER THAN USUAL AND WONDERED IF MY SEAT BACK WAS HEATING AT ALL. AS WAS USUAL WHEN THE SEAT WAS HOT ENOUGH I...

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, SHE SMELLED SOMETHING BURNING. AFTER INSPECTION, SHE NOTICED A HOLE IN THE SEAT FROM THE SEAT WARMER BECOMING EXCESSIVELY HOT. THE DEALER ADVISED THE CONTACT TO NOTIFY THE MANUFACTURER OF THE FAILURE. THE MANUFACTURER INFORMED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CURRENT AND THE FAILURE MILEAGES WERE 134,000.

MY 2003 JETTA SEAT CAUGHT ON FIRE WHILE DRIVING HOME. I WAS USING MY SEAT HEATER AT THE TIME. I WAS BURNED ON MY LEG.

I CURRENTLY OWN A 2003 VOLKSWAGEN JETTA. PASSENGER SEAT HEATER GETS EXTREMELY HOT AND VERY CONCERNED DUE TO BURN RISK TO CHILDREN AS WELL AS POSSIBLE FIRE HAZARD. *TR

MY DRIVERS SIDE SEAT HEATER DOESN'T RECOGNIZE THE SETTING OF 0-5. IT'S EITHER ON, OR OFF. MEANING, 0-4 THE SEAT HEATER DOESN'T HEAT THE SEAT. BUT WHEN I TURN IT TO 5 ON THE SETTING WITHIN 10 MINUTES THE SEAT GETS SO HOT IT BURNS MY LEGS THROUGH CLOTHING. *TR

MY 2003 JETTA DRIVER SIDE HEATED SEAT IS FAILING. THE PROBLEM STARTED IN JANUARY 2011. THE DRIVER SIDE HEATER COIL WAS RECALLED BACK IN 2007 AND HAD BEEN REPLACED THROUGH THE RECALL, HOWEVER, THE REPLACEMENT PART IS FAULTY AS WELL. THIS TIME, THE HEATER COIL HAS BURNED THE LEATHER SEAT AND BURNED A HOLE IN MY NORTH FACE DOWN COAT. LUCKILY THE COAT IS THICK SO I DID NOT GET BADLY BURNED. I HAD CONTACTED VOLKSWAGEN DIRECTLY AFTER THIS ASSUMING THEY WOULD REPLACE THE HEATED SEAT COIL SINCE THE INITIAL REPLACEMENT FROM THE RECALL WAS BAD, THEY WERE NOT HELPFUL AND SAID THE CAR WAS PAST WARRANTY. WHICH IT WAS BY ABOUT 3 MONTHS. HOWEVER, GIVEN THE SITUATION OF A PRIOR RECALL AND REPLACEMENT OF THE PART WITH ANOTHER BAD PART, I EXPECTED MORE FROM THE COMPANY. I THEN WENT TO MY DEALER WHO CHARGED ME $120 "DIAGNOSTIC FEE" TO...

MY SEAT HEATER FAILED IN MY 2003 VW JETTA, BURNING A HOLE IN THE SEAT UNDER MY LEFT [XXX]. I WAS STARTLED WHEN SUDDENLY THERE A STRONG BURNING SMELL IN THE CAR, THEN A HOT SPOT IN THE SEAT OCCURRED WHICH CAUSED ME TO HAVE TO QUICKLY SHIFT MY SEATING POSTING AND I IMMEDIATELY TURNED OFF THE SEAT HEATER. LUCKILY I WAS DRIVING SLOWLY IN THE CITY AND ABLE TO PULL IN THE IN A PARKING SPOT QUICKLY AND THE SEAT OR MY CLOTHING DID NOT CATCH ON FIRE. THE SEAT WAS SET TO 3 ON A SCALE OF 1-5. THE CAR HAS ABOUT 125K MILES ON IT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *LN

2003 VOLKS JETTA PASSENGER SIDE HEATED SEAT STOPPED WORKING, AND THE DRIVER SIDE ONLY HAS TWO POSTIONS...BURN YOUR BUTT OR OFF. COULD HAVE BEEN A DANGEROUS SITUATION HAD I BEEN ON A HWY AT HWY SPEEDS. *LN

HEATED SEATS MELTED A HOLE IN THE LEATHER AND BURNED MY BUTT. VERY VERY HOT. IT SMELTED LIKE BURNT RUBBER AND SMOKE INSIDE THE CAR. *TR

2003 VOLKSWAGEN JETTA PASSENGER SIDE HEATED SEAT BECAME SO HOT, THAT THE LEATHER WAS BURNED, SMOLDERED AND BEGAN TO CATCH FIRE. SINCE I WAS SITTING ON THE SEAT AT THE TIME, IT ALSO BURNED MY PANTS AND MY SKIN AS WELL. *TR

DRIVER SIDE SEAT HEATER OVERHEATING, BURNT MULTIPLE HOLES IN SEAT AS WELL AS BURNT LEG. SETTING WAS PLACED ON 2 OF 5 WHEN SEAT WAS BURNT.

MY CAR DRIVER SEAT IS BURNED WITH SOME SMOKE BECAUSE OF FAULTY SEAT HEATER. *TR

OVERHEATED DRIVER SEAT, WHICH BURNED HOLE THROUGH DRIVER'S SEAT AND LEFT A 2" BURN MARK ON SWEATER THAT WAS IN CONTACT WITH THAT AREA OF THE SEAT. THIS IS A 2003 VW JETTA TDI (TURBO DIESEL). *TR

2003 JETTA SEAT FAILS IN REAR END ACCIDENT. *TR

RECALL FOR 2003 VOLKSWAGEN JETTA- SEAT HEATER DEFECT CAUSING SEATS TO GET TOO HOT EVEN CAUSING FIRE IN SOME INSTANCES. BROUGHT MY JETTA TO RIVERSIDE VOLKSWAGEN IN RIVERSIDE, CA. INSPECTION AND REPAIRS MADE IN 2006. YESTERDAY, 1/25/2010, DRIVER SIDE SEAT HEATER STARTED TO BURN A HOLE IN SEAT. DID NOT BURN ALL THE WAY THROUGH AS I TURNED THE HEATER OFF BEFORE HAND. FELT SOMETHING THAT RESEMBLED A BEE STING BEFORE REALIZING THAT IT WAS THE SEAT HEATER THAT WAS MALFUNCTIONING. BURNING SMELL DETECTED. CALLED VW RIVERSIDE, SAID THAT IT WOULD NOT BE A COVERED FIX BASED ON RECALL INFO. COMPLAINT OF FAILED INITIAL REPAIR. *TR

I WAS IN A REAR END INCIDENT IN WHICH MY 2003VW JETTA WAS STRUCK ALMOST DEAD-ON IN THE REAR BY A 2009 BMW SEDAN. BOTH MY WIFE, SEATED IN THE FRONT PASSENGER SEAT, AND I, DRIVING, WERE WEARING THREE POINT SEAT BELTS. THE AIRBAGS IN OUR VEHICLE DID NOT DEPLOY. BOTH THE DRIVERS SEAT AND THE FRONT PASSENGER'S SEAT WERE RECLINED ALMOST COMPLETELY AS A RESULT OF THE IMPACT, TO THE POINT THAT ANY REAR SEAT PASSENGERS WE MIGHT HAVE HAD IN THE CAR WOULD HAVE BEEN PINNED BY THE RECLINED FRONT SEATS. *TR UPDATED 05/20/09 *BF UPDATED IVOQ 05/27/09.*JB

THE HEATED SEAT ON THE PASSENGER SIDE OF OUR 2003 VW JETTA TDI GOT VERY HOT ON MY RIGHT LEG, I REACHED DOWN TO FEEL THE SEAT AND IT BURNT MY HAND. WE TURNED ON THE LIGHTS AND THE SEAT HAD A BURNED HOLE WITH SMOKE COMING OUT OF IT. HAD I BEEN WEARING MY COAT IT COULD HAVE CAUGHT FIRE BEFORE I FELT THE INTENSE HEAT. *TR

I USE MY HEATED SEATS ALMOST DAILY IN THE WINTER MONTHS. I USED IT THIS MORNING FOR ABOUT 20 MINUTES AS I DROVE FROM HOME TO THE GYM, THEN ANOTHER 10 MINUTES AS I DROVE FROM THE GYM TO THE STORE. WHEN I GOT INTO MY CAR AFTER THE STORE, IT WAS STILL ON THE SAME SETTING (5), I HAD DRIVEN ABOUT 50 YARDS IN THE PARKING LOT, WHEN I FELT A SHARP PAIN IN MY LEFT UPPER LEG/BUTT. I MOVED SLIGHTLY, THEN BEGAN TO SMELL SMOKE. I FELT AROUND WITH MY HAND AND FELT THE "HOT" WIRE AND THE HOLE IN MY SEAT. IT TOOK ME A MOMENT TO REALIZE WHAT IT WAS, AND THEN I IMMEDIATELY TURNED DOWN THE HEATED SEAT TO OFF, THEREBY PREVENTING FURTHER DAMAGE AND PAIN. LUCKILY THERE WAS LIMITED DAMAGE TO MY CLOTHING AND I WAS NOT SERIOUSLY INJURED, BUT HAD I BEEN DRIVING...

I TURNED ON THE DRIVER'S SEAT HEATER TO 5 (HIGHEST SETTING) ON MY 2003 VW JETTA TDI WHEN LEAVING MY HOUSE AT 7 AM. I USED THIS REGULARLY TO WARM THE SEAT FOR A FEW MINUTES ON COLD MORNINGS, THEN WOULD TURN IT OFF (LOWER SETTINGS NEVER PRODUCED NOTICEABLE HEAT). WITHIN ONE MINUTE I FELT A BURNING/ELECTRICAL SENSATION IN MY UPPER LEFT THIGH. I WAS DRIVING ON A MOUNTAIN ROAD AND THE PAIN MADE ME JUMP IN MY SEAT AND NEARLY LOSE CONTROL OF THE CAR. I PULLED OVER AND TURNED OFF THE SEAT HEATER (HAVING HEARD OF PROBLEMS WITH THE HEATER). THE LEATHER SEAT HAD A BLISTER ABOUT THE SIZE OF A CIGARETTE BURN BUT HAD NOT BURNED COMPLETELY THROUGH. WHILE I STOPPED THE HEATER BEFORE IT BURNED THROUGH THE SEAT (AND MY PANTS), THE REAL DANGER WAS IN A POSSIBLE ACCIDENT FROM THE BURN/SHOCK THAT CAUSED ME TO...

THE HEATED SEATS IM MY 2003 VW JETTA STARTED TO CATCH ON FIRE. *TR

WHILE DRIVING DRIVER SMELLED AND COULD SEE SMOKE AND REALIZED DRIVERS SEAT WAS ON FIRE. DRIVER MANAGED TO PULL OVER AND PUT OUT FIRE ON SEAT. VOLKSWAGEN OF AMERICA DID NOTHING - TOLD OWNER THEY HAD NOTHING TO SAY. DEALER REPLACED SEAT. *JB

I WAS DRIVING MY 2003 VW JETTA UNDER NORMAL ROAD CONDITIONS. I STOPPED AT A RED LIGHT IN AN INTERSECTION, CONTINUED WHEN IT TURNED GREEN. I HIT A SMALL SIZED POTHOLE AT THE OTHER END OF THE INTERSECTION AT SPEEDS BELOW 15MPH, WHICH CAUSED THE WRONGFUL DEPLOYMENT OF THE SIDE CURTAIN AND SEAT AIRBAGS AS WELL AS LOCKING THE SEATBELT TENSIONER MAKING IT INOPERABLE. I INSPECTED THE VEHICLE AFTER THE INCIDENT AND FOUND NO DAMAGE WHATSOEVER TO ALL BODY PANELS AND WHEELS/TIRES. THE FOLLOWING MORNING I HAD A MECHANIC INSPECT THE CAR FOR ANY SUSPENSION OR STEERING PROBLEMS AND NONE WERE FOUND. I TOOK THE VEHICLE TO THE DEALER WHERE I PURCHASED IT TO HAVE IT FIXED UNDER WARRANTY AND THE DEALER AND VW OF AMERICA HAVE DENIED WARRANTY REPAIRS AND HAVE NOT YET DONE ANYTHING TO FIX THE PROBLEM. I DID RESEARCH ON THE INTERNET FOR SIMILAR INCIDENTS WITH...