2014 KIA SORENTO Engine Problems

My Grand daughter' car. May 9th 2024 discovered engine oil is in the engine coolant system. KIA tech says it a blown head gasket or the threads that were machined into bolt holes in the engine block for the head bolts are pulling out. Safety hazard, engine could have failed on interstate or in traffic and posed a threat to driver and others traveling on roadway. No warning of any type.

Engine failure similar to other Kia Engine Class Action Lawsuit

While driving car it suddenly lost acceleration. RMP's wouldn't go above 1.5. Speed wouldn't go above 20MPH. Check engine light came on. Was going up a hill with lots of cars behind me and suddenly could barely move. Made it to an Advance Auto and they ran diagnosis on the check engine light and it came up with 2 different codes, relating to fuel system and crankshaft. When I got the vehicle to my local mechanic they saw the codes also, and that the car had gone through 4 quarts of oil. I wasn't at the mileage for an oil change yet, so not sure why oil was almost gone. Mechanic did and oil change and issue was still not fixed. Stating engine needs to be replaced. I have several other people with Kia's who have also recently expirenced massive oil consumption and engine dying. Car was running fine prior...

My car started overheating, then started a clicking noise and smoking. Took it to the Jackson, MI KIA dealership. Service Tech said I have a blown head gasket, but KIA discontinued the V6 motor, so I can’t get a new motor. I searched online, found out the V6 motor was discontinued because of this very issue. There was a class action lawsuit/settlement, but it was before I purchased this vehicle. What if anything can be done ? I feel duped. None of the salespeople told me about this issue.

BLOWN HEAD GASKRT DUE TO HEADBOLTS BOLTS STRIPPING UNDER NORMAL WEAR AND TEAR, 116,000 MI.

Multiple reports of; Codes P0171 System too lean bank 1 P0138 O2 sensor circuit high (b1s2) P0087 Fuel pressure too low P0036 B1S2 *** frequent fuel pump and fuel injector replacements/ services due to defects in the system. Causing major damage in other systems including engine.***

My 2014 kia sorento its knock sound from engine

The HECU fuse in my Kia has the risk of starting an engine fire. It is currently part of a recall. I have checked this with your organization using my VIN number. I am unable to drive my vehicle due to the potential risk for me and passengers. This has made life extremely inconvenient. Even going to work has been difficult because I've had to rely on other modes of transportation. Kia has been unable to provide a replacement part, even though the recall was first announced over 6 months ago. I am unable to sell my vehicle because of this recall as well. We are expected to not use our vehicles but Kia is not providing a replacement part in any sort of a timely manner. They need to move their focus from the new vehicles to fixing these before someone is seriously injured.

Kia Dealers has diagnosed that vehicle has had a Catastrophic Engine Failure Was driving and vehicle just died almost got rear ended etc.... due to engine failure never received notices of this engine issue Start reading and it states at any giving time engine can seize At this point Kia dealer give me the round around there is a recall for engine failure it was checked by Kia dealer know no one can give me an straight answer and I need at least a rental vehicle until this gets solve and they don't want to honor that But they were real quick to call me to charge me $205 dollars for full diagnostic of vehicle

Engine failed on the road. Lost acceleration. Had it in dealer for knocking and loss of acceleration but found nothing. Dealer said drive until failure or warning lights. One Week later it failed on the freeway. Now dealer says blow bearing bolt/rod and engine will be $16,000 to replace. We have only ever serviced this car at Dealers and bought it new. Dealer says Engine is not covered but read this is a KNOWN issue with the engines.

While driving on the highway, I noticed my temperature gauge went all the way to hot, but then it went back to the middle. It did this 2 or 3 times before I reached my destination. On the way home, it did this, again. Except, the gauge went up to hot and stayed there when I was about 3 miles from home. Once the engine cooked, I checked for coolant and realized it was empty - as was my oil (even though I had an oil change in October). I refilled the oil and coolant only to have the coolant run out from the bottom of the engine. I took the car to a radiator repair shop and was told the from head gasket had blown. He said I would need a new engine. A second opinion yielded the same answer. The engine light never came on and the car...

The contact’s girlfriend owns a 2014 Kia Sorento. The contact stated while driving 70 MPH, the engine overheated. The contact pulled over and checked the vehicle. The coolant reservoir was low on coolant, the engine oil level was low, and there were metal shavings in the oil. The check engine warning light was illuminated. The vehicle was towed to the residence. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 77,842.

My car shows that it is running hot but there is no leaks. I took my car to the mechanic and changed the radiator and the thermostat thinking that was the problem get my car back and my car is still running hot so I take it back to the mechanic and he inspects my engine again and that's when he tells me that the screws in my engine are not tight like they are supposed to be and that at some point there was a recall for my car due to the engine over heating I tried calling kia and they weren't any help

Car started overheating and was using excessive amounts of oil. When trying to run my heat the smell of the coolant was coming into the cabin in which myself and my children could have inhaled it. I took it to my local Kia dealership and was informed after diagnostics that it was leaking both oil and coolant from the same spot, the head gasket is leaking, and the cylinder head bolts are stripped. In all a whole engine replacement will need to be done on 3.3 V6 GDI Lambda Il

The kia Sorento has been very well serviced and maintained. On 3/8/24 while driving on the hwy the temperature began to rise. The vehicle was immediately pulled over and shut down. After letting the vehicle sit for approximately an hour to let engine cool my mechanic arrived and inspected it and found metal shavings in the oil and vehicle was started after inspection it is knocking. I've gone online to your website ran the VIN number and it says that this particular vehicle has no recall but this exact year model Sorento has had two different recalls on the same engine that I have in this vehicle for exactly what my vehicle just did. My vehicle only has 78,000 miles on it and I have all service records for it. I'm wanting to know why the other engines of the exact same year make model were recalled for exactly what...

This is regarding recall #23V652.The manufacturer has failed or is unable to remedy this safety recall since 09/25/2023 in a timely manner. This put myself and family member at risks everytime we operate the vehicle. KIA advised us to park it afar to avoid fire hazard. However, my car has already been broken in once so I am too traumatized to park it far away from my house. This is a serious safety concern that should be promptly addressed.

Engine lost power. Analysis indicates the catalytic converters failed and need replacement. The engine and catalytic converters were replaced June 2022. This power loss occurred on major interstate, which could have resulted in death or serious injury. Defective products still being used. Per the dealer, the replaced parts have a warranty of 12 months or 12,000 miles. They know these issues exist and persist, putting lives at risk. We did have an engine light come on a few moments before the engine failed.

My car was at Kia for a key fob issue. A day later the engine started ticking. I’m told I need a new engine. My car had no issues. I want to know if it can be related to this recall or if my car should’ve been recalled for the 2017 engine recall sc147. I am not convinced that they didn’t cause this when they had it as it started the next day it was driven. They will not take responsibility for it of course.

Was driving on highway when suddenly the vehicle lost power and couldn't maintain speed. Once stopped smoke came out from under hood which turned out to be from coolant. Had car towed to independent shop where it was determined that the engine head gasket/s are bad and engine head bolts and block. Fix is it needs a new engine. Always had maintenance done at dealer and this happened just out of warranty 106k miles.

I received a recall notice from Kia dated 11/14/2023. The notice said that the HECU hydraulic electronic control unit could short circuit and catch the car on fire whether driving or parked. They suggest parking away from anything that could catch fire. There is currently no remedy for this serious safety issue. It has been 3 months already and there is no time line for a remedy. They offer no options such as a loaner car to help mitigate the risk to personal safety while driving this car. I would like to have some interim solution until there can be a remedy of this serious safety risk. This is an unacceptable safety risk. Thank you for your time and attention. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine died with no sign. Was told engine had no oil

Engine seized while driving. Had to be completely replaced.

No lights went on the dash. N warning that the engine was damaged. Now 2 mechanics have agreed that the engine is bad Just got the car used from dealer in March and no one knew anything about it. I’m devastated

The contact owns a 2014 Kia Sorento. The contact stated while driving 50 MPH, the contact heard an abnormal ticking sound. The contact was able to pull over safely. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who determined there was a hole in the engine block. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the contact that the repairs were not covered under recall. The failure mileage was approximately 103,000. The VIN was not available.

With no warning the Kia suddenly started shaking and shuddering and white smoke started coming out of the exhaust while driving down the freeway. There were no symptoms of the problem prior to the failure. Took it to a mechanic and he said the car has a blown head gasket. A second mechanic confirmed the diagnosis.

Kia smelled of electrical burning/fire after driving. burning smell permeated into dwelling. Notified KIA Customer Care Center at 1 (800) 333 4542. Case [XXX] initiated day of engine burning/fire [XXX]. No response from Kia. Called to inquire on update January 16th, 2024. Spoke with Mary. Mary had no update. Asked to speak with her manager, She transferred me and call dropped. Unprofessional conduct with life-threatening Kia engine bomb sitting in my driveway. Initiated complaint on Kia's website and another case number was generated - [XXX]. Tried calling back to no avail. Call dropped five times. Initiated this NHTSA complaint immediately after last call dropped by Kia. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2014 Kia Sorento. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine compartment, and the vehicle then lost motive power. The contact was able to coast to the shoulder of the roadway; however, the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the engine. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 162,000.

The shop I took it to tested the compression and 3 cylinders were out. They said I need A new engine at 120k miles on it.

The contact owns a 2014 Kia Sorento. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the check engine, the MIL, and the ABS warning lights were illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000. VIN tool confirms parts not available.

The contact owns a 2014 Kia Sorento. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving approximately 65 MPH, the vehicle started losing motive power. The contact stated no warning light was illuminated. The contact was able to coast off to the side of the highway and then noticed smoke coming from underneath the vehicle. The contact did not open the hood and had the vehicle towed to an unknown dealer. The contact stated the dealer advised that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was unknown. VIN tool confirms...

Fuel pump/engine began failing before the engine locked up. I was driving down a country road and lost power. When I floored it the top speed was approx. 7 MPH. I did not have anywhere to pull over. It has been inspected by the manufacturer and they said it needs a new engine. There were no warning signs or anything. I don't know how to answer if the problem has been reproduced. Via Kia forums, this is a common issue that is usually handled with the extended warranty. I've contacted Kia and they admit I'm having issues. Quote from their email "We apologize about the issues you are having with your engine and fuel pump in your 2014 Kia Sorento."

The vehicle shows that it is running hot but when I check there is coolant in the reservoir but then when I check the radiator there is little to no coolant in it

The contact owns a 2014 Kia Sorento. The contact stated that while driving at an undisclosed speed, the engine oil light illuminated. The vehicle was taken to the dealer and diagnosed with excessive oil consumption and that the engine needed to be replaced. The vehicle was not repaired. The contact was advised that the engine would not be replaced until the rod bearings had failed unless she wanted to pay for the replacement of the engine. The contact stated that she had recently experienced an additional failure with the vehicle. The contact stated while driving at an undisclosed speed, the service engine light, ABS, traction, and tire pressure warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed rear wheel speed sensor. The contact was informed that the rear wheel speed sensor needed to be replaced. The vehicle was repaired. The contact stated...

The engine randomly around 45,000 miles started using large amount of oil. The engine started ticking. It is available for inspection, upon request. The safety of myself and others is put at risk as the engine is a ticking time bomb to blow up. When it first starts happening, you do not notice, as you get regular oil changes at the dealership and they never once say that your oil was dangerously low when you brought it in. The problem has been expressed to me by independent service shops as a gdi issue. I called the dealership and they said the only thing they can do is an oil consumption test for $600. The vehicle has not been inspected by the manufacturer. There are no warnings lamps that come up at all, not for low oil or anything.

Car timing failed on the 3.3 and stalled car in the road. This is a very common problem and these need to be fixed. These cars randomly jump timing with no warning what so ever. Kia knew these were an issue and should replace the engine in my car along with everyone else that has this issue. Car is at a shop now with a confirmed jumped timing.

Engine seized again after the last recall and engine replacement leaving me stranded in an intersection and $416 in towing expenses transported to the mechanic and back home when told engine is seized

I have a 2014 Kia Sorento with a 3.3l engine. There was a catastrophic blow of the head gasket that resulted in engine temperatures spiking while driving on the interstate. This led to excessive deceleration and stopping on the side of the interstate. After researching, this is an ongoing problem with this vehicle. It even has a nickname, "Soft Block", from KIA using substandard materials to build their engines. I submitted a complaint against Kia through the NHTSA website on November 10th. Since that time, I have come to realize that Kia has issued a warranty extension for 2016-2017 Kia Sorento's with the 3.3l Lambda engine for cooling leaking and head gasket issues. What would be the process for expanding your open investigation (NHTSA Action Number: PE23019) to include the 2014 and 2015 model years of the Kia Sorento with the 3.3l engine? This is the exact same engine, and...

Replaced engine 1/31/23 had open recall per 21v331was not repaired even though they wasn’t suppose to return vehicle according to recall. They said It would be safe to drive.Said they had no remedy to fix they would call me. Few days car stalls alternator was hanging had to replace. They didn’t replace properly. With in a month cars brakes were acting weird took in for diagnostic back brakes no remedy. Call Kia still no parts for recall. Sept 11,23 was pulling off expressway during 5 o'clock traffic my brakes locked up I had no control. Towed to Kia they wanted 75. to look at it then 2700. to fix the brakes. And stated I had no brake fluid. Which was just checked. They said recall did not cover the repairs Neither the engine recall nor the brake, hecu, abs, stability control recall. I contacted Kia they told me they would...

ENGINE FIRE, NO WARNING, VEHICLE WAS PARKED OUTSIDE AND OFF WHEN IT CAUGHT FIRE

The contact owns a 2014 Kia Sorento. The contact stated while driving at approximately 25 MPH and making a turn, the engine seized. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that there was an internal engine failure, connecting rod damage, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and opened a case, but no additional assistance was provided. The contact stated that the failure was related to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling). The failure mileage was approximately 75,000.

Engine continues to leak oil. Cannot be driven. 2014 Kia Sorento SUV which is under recall for engine fires yet they state her particular vin is not under the recall.

The engine on my 2014 Kia Sorento has failed. I brought the vehicle in to Bob Sight Kia to have them diagnose the problem. They claimed that when they drained the oil, they only found 3/4 of a quart of oil and for that reason, Kia was denying the claim for a new engine. I find it hard to believe that there was only 3/4 of a quart of oil in the car as we conducted regular maintenance on the vehicle and provided all service records. When I contacted Kia, they stated that they had not received any documentation from Bob Sight Kia, and specifically no technical details why the engine had failed, or provide an estimate for repair costs. In the last three weeks that our Sorento has been at Bob Sight Kia (brought to dealer on 9-9-23), when I call to speak with the service center point of...

Car was traveling from Atlanta and the speed odometer on the car showed it was dropping then knock noise pull over then I made to exit and check oil Guage the sensor lights never showed when I had picked up the person house I took to said it was crank sensor and started it heard knocking sound and I call NHTSA reported incident and was giving a claim number haven't heard anything since I no its recall on engine cause I had received paperwork that it was and also saw report on news

Engine was replaced in 2021 due to oil consumption issues. After copays and having a rental car for 2 months while waiting for repairs I shelled out about 7k. Now catalytic converter has failed, about one week after last oil change. Extended coverage is just over by mileage according to dealership and unsure if Kia will cover, awaiting response. After researching this issue with my vehicle, I found other owners who had the same issue and suggested it should have been replaced with engine as there was a past recall for this. Others stated that Kia is not covering even though there was a recall. Even if they covered the parts that would help substantially. Car currently at service center at Kia dealership awaiting to see if Kia will assist at good will or cover under the recall.

We bought the car 6 months ago from a dealership and since then the breaks are bad the engine makes this strange noise it always smells like oil is burning. The seat belts don't stay latch and I hr suspension is all over the place.

After work, a severe dust storm hit. I drove to the grocery store and then home (30 miles) in the dust storm. The next morning, as I was driving to work, I heard a weird knocking noise, but no engine lights came on. My car would not start during my lunch break, nor when I got off work. My boyfriend tried to jump it off. When that didn’t work, we traded the battery out since it was still under warranty. That did not work. We went back the next day and checked my oil levels and other fluids - all were good. My boyfriend then hooked up his small code reader which didn’t read any problems. The next day my mom started the car by putting the spare key up to the start button. She took it to Gene Messer Kia about 5 miles away. She said no engine lights...

Car recently hit 103,000 miles and was taken in for its scheduled oil change. Mechanic discovered that only a single quart of oil was left in the engine during the oil change despite regular maintenance. Metal flakes were found in the oil that was removed which points to a similar recall with the engine bearings identified in 2017. However, the VIN of this vehicle is not showing up in the recall list. Mechanic is recommending the engine be replaced in the vehicle.

In May of 2021 my 2014 Kia Sorrento had major engine problems. I brought it to Myrtle Beach Kia immediately and after 5 months of back and forth and paying for rental vehicles, I was told that they would not cover any repairs due to the Recall! I then paid $8, 663.63 for a repair that was never fully completed. Immediately after receiving vehicle back, check engine light was on. Numerous call to the dealership and I was told dont worry it just needs to cycle through. My vehicle has NEVER been properly serviced by them. I have kept up will all oil changes and maintenance in the meantime. I was told the check engine light codes were PO335 & PO 0018. I have had the Camshaft Bank Sensor and Crankshaft sensor replaced on [XXX] and this vehicle STILL has same check engine light on and is not receiving proper...

The contact owns a 2014 Kia Sorento. The contact stated that after an oil change and driving approximately 1,200 miles, there was no oil in the engine. The contact stated that there was no visible oil leak. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 153,000.

iT APPEARS MY CAR IS BURNING OIL, THERE IS NO LEAKAGE. I KEEP OIL CHANGES ON A REGULAR BASIS AND NOW CHECKING OIL LEVELS DAILY. IT IS USING 1-1.5 QTS EVERY 2 WEEKS. THIS PROBLEM WAS FOUND WITH LAST OIL CHANGE. MY CAR NOW SEEMS TO SEIZE WHEN TAKING OFF INCONSISTENTLY. I DON'T KNOW IF TWO PROBLEMS ARE CONNECTED. THERE ARE NO WARNING LIGHTS COMING ON. I CONTACTED CARTOWN KIA ABOUT 3 TIMES BY PHONE, LEAVING MESSAGES, AND ONLINE BUT NO RESPONSE.