2019 KIA OPTIMA Engine Problems

The vehicle experienced a sudden engine failure one day after undergoing a manufacturer emissions/service campaign at an authorized dealership. Prior to service, the vehicle operated normally with no warning lights, knocking, or drivability issues. After the failure, the dealership denied coverage and declined to inspect the engine oil. The vehicle was towed for an independent inspection, which found metal shavings in the engine oil, indicating internal mechanical engine failure. The sudden failure created a safety risk due to unexpected loss of engine function. The issue has been confirmed by an independent service center and the vehicle remains available for inspection. No warning lamps or symptoms were present prior to the failure.

The contact owns a 2019 Kia Optima. The contact stated that while the vehicle was parked, there was sputtering sound coming from the engine compartment, with the check engine warning light illuminated. The contact stated that while driving at an undisclosed speed, the vehicle was running rough. The vehicle was taken to the independent mechanic where it was diagnosed with a cylinder misfire and burned spark plug, and that there was oil inside the cylinder and on the spark plug. The contact was informed that the parts needed to be replaced. The vehicle was repaired but the failure reoccurred months later. The vehicle was taken back to the same independent mechanic where it was diagnosed with oil consumption, oil intrusion into the firing chamber, and that another spark plug needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was...

I purchased this vehicle on [XXX], with approximately 170,150 miles. On [XXX], during a routine oil change at approximately 172,636 miles, it was discovered that the engine had no oil present. Shortly afterward, the oil warning light began flickering intermittently while driving. On November 4, 2025, at approximately 175,495 miles, a certified mechanic again confirmed that there was no oil present in the engine. At no point were there visible external oil leaks, indicating excessive internal oil consumption. This condition creates a serious safety risk, as sudden engine failure while driving could lead to loss of power, stalling, or accidents. Based on my experience and publicly known issues involving Kia engines, this appears to be a systemic defect rather than normal wear. I am requesting that NHTSA document and review this issue as a potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Brought vehicle in for Recall-SC340 Theta II 2.4L GDI ECM S/W Upgrade. After service was performed I took my vehicle back home and noticed that my down shifting was different, jolty and clunky. Prior to the upgrade my vehicle shifted flawlessly. Took my vehicle back in to have them check it out and they told me that they couldn't feel it and that the upgrade wouldn't cause that. Called Kia Corporate and filed a complaint.

I purchased a used 2019 Kia Optima from a dealership in January 2025 with 103,000 miles. 11 months later it's burning oil. Every 2 weeks I have to add a quart of oil. I took it to my mechanic and they found cylinder 4 has been burning oil. They also found a technical service bulletin related to engine oil consumption. They recommended replacing long block assembly. They referred me to a Kia dealership. Currently, my vehicle is at a Kia dealership. They performed a "leak down test" and found cylinder 4 has been burning oil and recommend a long block assembly. I have a 3rd party warranty on my car. They are currently reviewing this claim. If they decide to replace the long block assembly, there will be additional uncovered costs that I feel Kia should be responsible for. I have only put 7,000 miles on this car since I...

Unknown needing help with new purchased car. Bought this car October/2025 with 93k on engine. Already been to dealership i Bought it from to have current issues im dealing with checked out and they only listen to it and said it was injector ticking clatter. Since then ive seen white smoke and the car burning excessive oil. I am adding oil to the car every 2-3 days. Still noticeable smoke and smell of burning oil. No recall on this vin. It seems as if this is a huge problem with this engine. Please help

Engine burners oil at about 1qt per 1000 miles. There is no leak, and no repair to stop the oil from burning quickly. I have to refill my engine with oil several times in between oil changes. Paint is peeling in various spots on my hood and bumper. I first noticed a small area along the border of the hood nearest the windshield (mostly visible from the driers seat). Then 3 more spots on the opposite side of the hood and eventually all over the bumper.

My vehicle is consuming oil excessively. I have to put a whole quart of oil in my vehicle every 2 weeks. I am adamant about getting regular maintenance oil changes as well. My car had to be towed to a local auto shop due to the engine stalling and accelerator not working. They had to replace all 4 coil packs and 4 spark plugs due to dark, tarry oil covering the parts. The repairman told me my engine was at risk of failing, and that the repairs he did would not last without a new engine. I am worried about the car stalling or failing while driving, which puts an accident occurring at greater risk. My complaints resemble symptoms tied to previous Hyundai/Kia engine recalls. I am requesting investigation and manufacturer action related to this issue.

The motor burn oil even after the oil change is done. Also, the car shaking and is not damage to be found.

Red oil light came on along with check engine light took to shop got oil change and they test pressure all is good but oil light and engine light still on replaced oil pressure sensor switch and variable valve solenoid lights still on took to kia dealership they said say thing as first shop replaced oil pressure sensor switch again because they said the aftermarket one doesn't work on my car so bought part from dealer changed it light still on.

I recently had the engine replaced less than a year ago due to an engine recall on this model car, today 11/11/2025 the engine caught fire. We’ve kept up with oil changes on time and I had no alerts in the vehicle on the dash claiming the engine was hot.

Over the past couple years, the check engine light has came on and I immediately had a mechanic look at it. The first time they said it was my spark plugs and changed them. Then this year, a year later, the check engine light came on and it became hard to accelerate on my way to a mechanic. Once again, they said spark plugs, so they changed them and claimed that they didn't look to had been changed before. Now here I am a couple of months after that, my check engine light came back on and my car started making a funny noise on my way to work. I turned back around and went home since I was closer to home than work. It sounds like rocks popping when you start it or hit the gas. I had someone check the codes and it said engine 1 and 4...

I was just driving then noticed lack of acceleration and the engine light flashing. Loosing acceleration mid driving posed a great safety risk because no other drivers would know the issue I was experiencing and risked causing an accident. The vehicle was taken for a fault code reading which indicated a knock sensor code, later it was inspected at the dealership who confirmed an ECU issue. The police or insurance have not inspected the vehicle for this particular issue.

I am the owner of a 2019 Kia Optima FE with the 2.4L GDI engine (Theta II). Despite following a consistent maintenance schedule with synthetic oil changes every 4,000 to 6,000 miles, the vehicle is experiencing premature engine failure. Specifically, the engine has internal valve damage, and the shop diagnosed the issue as failure of an internal valve component. The vehicle also has a leaking axle inner boot, but the major concern is the engine. Kia has refused warranty coverage, goodwill assistance, or recall support despite this engine being part of a long-standing pattern of issues documented across many Kia and Hyundai vehicles with the Theta II platform. I still owe approximately $10,000 on this vehicle, and now face a potential $5,000+ repair due to a known manufacturing defect. Kia Consumer Affairs and the dealership both declined assistance, claiming my warranty has expired, even though this engine has been involved...

•Rapid oil loss — topped off every 1–2 weeks •Engine misfires, check engine light •Spark plug fouling and performance loss •Repeated advice to “just refill oil” and “wait for failure” •Unsafe to drive, especially as a working single mom

Engine seizures.

The engine appears to be consuming an abnormal amount of oil. There are no visible leaks or external damage, and the vehicle has not yet stalled or failed, but oil levels drop rapidly between oil changes. The engine is available for inspection upon request Driving with low or empty oil levels risks sudden engine failure while in motion, which could lead to loss of power, stalling in traffic, or even a crash. The oil warning light came on and went off at regular intervals unexpectedly during driving this week, which prompted me to get it to my mechanic asap to avoid potential engine damage or failure. They performed an oil change (even though I had done it there for this same car only 2133 miles ago NOT YET. I have contacted the dealership and have been advised to monitor the oil level or potentially conduct an oil consumption test. I...

Engine failure

Original owner, received in mail that this vehicle was recalled for engine issues. Provided a lifetime warranty for engine. Noticed my vehicle began consuming oil more than normal. I constantly have to put oil in the car 2-3/ week. The shops say it doesn’t need an oil change the oil is burning fast. Never notice any leaks bit my vehicle began to not pick up speed and shop said the oil is burning and possible engine is getting ready to go. Called dealership and they said they won’t replace u less the engine is totally blown and I need to have all type documents showing I’ve been doing maintenance although this is a known issue. Constant oil changes.

I was driving in the rain on the highway and engine light started flashing!

The contact owns a 2019 Kia Optima. The contact stated that while driving at various speeds, an abnormal engine oil consumption was noticed. The check engine oil warning light illuminated abnormally often, shortly after an oil change had been performed. The vehicle was taken to a local dealer, where it was diagnosed with defective piston oil rings. The vehicle was not repaired due to the warranty being deemed invalid. Upon further investigation, the contact related the failure to an unknown recall; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 65,000.

Lights appeared on the dash and the vehicle locked and would not drive. This happened as I was actively driving. I had the vehicle towed and was told by the Kia dealership that it was my abs/hecu. Before this happened, there was no warning lamps or messages. The car was driving normally.

My engine is burning oil at an alarming rate, my car is not recognizing low oil, so I no oil lights are appearing. I have to go to the oil change place weekly to have my oil checked. When my oil is low, I have to pay to have my oil replenished between months of my oil changes. My and my son safety was put at risk, when I found out at an oil change visit, I had less than an quart of oil I was driving around with. Which can cause engine failure while driving, overheating, and reduced performance while driving. This was confirmed by an oil change facility. I am currently in a ongoing dispute with the dealership I received my car from. The Kia dealership is refusing to do any maintenance until I can produce five years of oil change records that are not showing on car...

Oil is getting into cylinders causing spark plugs to misfire. Very high oil consumption so I have to put oil in it every other day in between oil changes. I’ve been to Kia Service department several times in the past 2 months.

My 2019 Kia Optima purchased brand new. Kia released a service bulletin on 3/1/22 citing “excessive oil consumption for 2011-2021 Optima's”. I took it in for the "updates" for said service bulletin for the engine and was told that my engine is good and covered now for the life of the engine even past the 100k miles (mind you no one mentioned doing an excessive oil consumption test at this time). On 3/22/24 car had 104k miles on it and the oil light came on. I had an oil change just 2500 miles or so prior. Pulled into an autozone and it was almost bone dry. I put oil in it and the light went off. I took it to Evans Kia and was told that they couldn't do anything because it was past 100k warranty and that they couldn't run the DX test to determine if it was excessively...

UNKNOWN. Vehicle is burning through oil every 1,000 miles or so. Excessive oil consumption which i am aware there is a recall. However Kia states my VIN # is not included. While at the dealer service department for failed A/C system, we questioned the excessive oil consumption and engine replacement. We were told they found nothing wrong. Having to top off oil every 1,000 miles or so. It does not make it to the next oil change before the light comes on. No oil leaks. Mechanic said known problem with this engine. Most recently the starter went bad, alternator, and battery. Replaced with a second brand new battery and car won't start again. Dash is lighting up erratically, new battery dead. As if something is drawing all power and draining brand new batteries. This car has a little over 86,000 miles and one thing after another is failing. The car...

HAD CAR FOR 2 AND 1/2 YEARS STARTING ABOUT 9 MONTHS AGO STARTED HAVING ISSUES WITH OIL LEAKING ISSUE. I NOTICED WHEN STARTING CAR AND MADE SHAKING SOUND BOUGHT TO MECHANIC AND TOLD ME THE OIL LEAKED HAVE TO REPLACE SPARK PLUGS AND HAVE DONE ABOUT 4 TIMES NOW SEPT 2024, FEB 2025, 03-14-25 AND THIS MORNING 03-23-25. I'M STILL MAKING PAYMENTS ON THIS CAR BESIDES COSTS FOR REPAIRS. THANKS APPRECIATE ANY HELP. MY MECHANIC SAID WHEN ENGINE WAS BUILT NOT PUT IN STRAIGHT IN VEHICLE WONDERING IF THIS RELATED TO MY ISSUE.

Oil consumption

Excessive oil consumption for a car with 45,000 miles with no observed leaks under the car or on the outside of the engine

P1326 code. Check engine light flashing. Is in limp mode with limited power.

I recently had an oil change and not even 600 miles later the oil is completely gone. My engine is burning oil like crazy. This just started happening at the 95,000 miles mark

Since January 2024 I have had to replace the spark plugs more than 3 times. It has also had to have an oil change done at least every two months regardless of the miles that were put in it. BURNING OIL LIKE CRAZY Mid October 2024 a full tune up was done as well as oil change and less than two weeks later it started bucking like a bronco and all oil was gone out of it. Check engine light is on and oil light goes on and off. Cannot drive at all

Defective piston rings leading to excessive oil consumption, spark plug deterioration, and potential engine failure.

Engine is consuming too much oil engine is shaking and knocking engine light is on reducing speed will cut off in mid drive

The contact owns a 2019 Kia Optima. The contact stated while driving approximately 65 MPH, the vehicle made an abnormal knocking sound and started vibrating and shuddering. The contact stated that the vehicle started to lose motive power and failed to respond upon depressing the accelerator pedal. The vehicle stalled and failed to restart. The contact stated that the check engine warning light illuminated while attempting to restart the vehicle. Additionally, the contact stated that the vehicle had previously experienced engine failures and electrical fuse failures. The contact stated that the 12-volt battery was previously replaced three times. The contact had taken the vehicle to two local dealers. The second dealer referred the contact to the manufacturer for assistance. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 18,000.

The contact owns a 2019 Kia Optima. The contact stated that while driving at various speeds, the vehicle lost motive power and stalled. During the failure, a flashing check engine warning light was illuminated. The vehicle was towed to the local dealer who determined that the engine had experienced excessive oil consumption. The cause of the failure was not yet determined, and the vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 30,449.

The car is using oil like crazy and is not leaking anywhere out of the vehicle. Stalling out while driving and then accelerating. Has completely lost power and rolled down an onramp. Completely unsafe. Took for diagnostic and they wanted to say I needed a new gas cap. Replaced, still doing same thing. Hesitant to start even and the alternator is less than a year old.

This vehicle is a lemon. It is a 2019 with 81,000 miles. How in the world does the engine start knocking when i have consistently, kept up with the maintenance on this vehicle. If i do not hear something soon im weakening legal action. Since May 18TH i have been without a car.i am a single mom and this is so difficult. Mind you it was towed July 5th from where it broke down on me.

I am having to change the plugs in this car monthly. The car goes into limp mode and will not go over 15 miles an hour. There is oil getting in the plugs and causing them to burn. This car uses a lot of oil. Lots of oil!! these issues started at 100,011 miles. I have also noticed that this car has started accelerating on its own.

The contact owns a 2019 Kia Optima. The contact stated that while driving at an undisclosed speed, the oil pressure warning light illuminated. The contact stated that shortly afterwards, the check engine warning light illuminated, and the vehicle started losing motive power while attempting to accelerate. The contact stated that the vehicle was shuddering and jerking while driving. The contact also stated that the Forward Collision Avoidance sensors activated inadvertently while driving or the vehicle was parked. The vehicle was taken to a local dealer where it was diagnosed with excessive oil consumption and the contact was advised that the failure with the Forward Collision Avoidance sensors was the regular function of the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 57,813.

Subject: Complaint Regarding Excessive Oil Consumption and Engine Hesitation in 2019 Kia Optima SX To Whom It May Concern, I am writing to formally lodge a complaint regarding my 2019 Kia Optima SX. Despite meticulous maintenance and care, I have been experiencing significant issues with the vehicle that are concerning, especially considering its relatively low mileage of only 107,000 miles. The primary issues are as follows: 1.Excessive Oil Consumption: My Kia Optima SX has been burning an excessive amount of oil, necessitating frequent top-offs well before the recommended oil change intervals. This is not only inconvenient but also raises serious concerns about the long-term health and reliability of the engine. 2.Engine Hesitation: The vehicle exhibits extreme hesitation during acceleration. This hesitation occurs sporadically, making it difficult to anticipate and presenting a potential safety hazard, especially when merging onto highways or attempting to overtake other vehicles. These issues are unacceptable for...

My car was having to get the spark plugs once a month loosing oil. Lots of Oil is coming out through the exhaust my grandfather just saw it. I still owe 20,00 on this car. I was told by Kia I’m going to need a new engine. I stopped driving it

I currently have 119500 miles on my 2019 Kia Optima. I am losing oil somewhere between oil changes, and the car is beginning to hesitate while driving. I don't see oil on the ground but I have had to put in 2-3 1/2 quarts of oil way too often. For this to happen on some many vehicles, it must be a manufacturer defect. The hesitation just started and I'm taking it do get a diagnostic test. 11

I am writing to bring to your attention a critical safety issue with my 2019 Kia Optima SX 2.0 GDI Turbo, which has accumulated approximately 103,000 miles. This vehicle has recently developed several serious problems that I believe pose significant risks to both my safety and the safety of other road users. Firstly, my Kia Optima has been burning an excessive amount of oil. Specifically, it consumes over 5 quarts of oil within just 2,000 miles of driving. Despite thorough inspections, even from Kia Dealers there are no visible oil leaks, making this issue even more perplexing and concerning. Moreover, the vehicle has begun to shake violently while driving on the highway, which has led to a substantial loss of power in the middle of traffic. This unpredictable loss of power is extremely dangerous, especially at high speeds, as it compromises my ability to maintain control of the vehicle and...

Burns through oil. I have to consistently have oil on hand. 107,000 miles and being told my year does not fall under getting a new engine falls on me to replace it. This is an issue that falls on the manufacturer. Please help

GDI MOTOR CONSUMES A LOT OF OIL

The contact owns a 2019 Kia Optima. The contact stated while the vehicle was parked, there was oil leaking from underneath the hood. The vehicle was taken to an independent mechanic where the oil was changed; however, the failure recurred. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,008.

The engine is consuming oil very fast and needing oil way before the next oil change. The oil consumption test Kia did stated that it was 2 quarts low after the first 1000 miles. Car does not have extended warranty but this a manufacturing defect. Suggestion was new motor. Also it's recall for the forward collision safety feature but my car vin is not included even though it goes off when nothing is in front of me. They want me to pay for these issues the motor cost the same as the payoff of car. This is ridiculous, I purchased Kia due to having a older model that almost got 300,000 miles on it before transmission died. I got a great payment and a newer car but didn't expect to have this motor issue or safety problem with no help from manufacturer. I'm stuck keeping oil in car so it's...

2019 Optima EX excessive oil consumption. Oil changed every 3000 miles, but is always empty within 1000miles. Car has 101,000 miles. Took to Kia dealership due to loss of power on acceleration and stalling and excessive oil consumption, they said I have multiple misfires on cylinder 1, excessive sludge buildup under cap and again no oil present. I was advised the engine needed replaced and that somehow this is a me problem and not a Kia problem. Spoke with Kia support and because it’s 1,000 miles over warranty they will not do anything even though they are aware of excessive oil consumption issue in these motors

Engine is consuming extreme amounts of oil. I have never been late for an oil change, and often go before I’m even due. My car was stalling and the RPM was fluctuating. I had to pull over and turn the car off. I then noticed my oil light on for 2 seconds, then it turned off. I’m not due for an oil change for another 2,000 miles. I pulled in to a mechanic shop (thankfully I was right next door) and low and behold, hardly any oil in my car. Had maybe half a quart left. I should have been good for another 2,000 miles. This is not the first time this has happened either. I no longer feel comfortable driving myself or my kids in this vehicle. It has been nothing but constant worry about my engine dying, burning or stalling. This car only has 70,000 miles on it...