2019 KIA OPTIMA Fuelpropulsion System Problems

I purchased this vehicle on [XXX], with approximately 170,150 miles. On [XXX], during a routine oil change at approximately 172,636 miles, it was discovered that the engine had no oil present. Shortly afterward, the oil warning light began flickering intermittently while driving. On November 4, 2025, at approximately 175,495 miles, a certified mechanic again confirmed that there was no oil present in the engine. At no point were there visible external oil leaks, indicating excessive internal oil consumption. This condition creates a serious safety risk, as sudden engine failure while driving could lead to loss of power, stalling, or accidents. Based on my experience and publicly known issues involving Kia engines, this appears to be a systemic defect rather than normal wear. I am requesting that NHTSA document and review this issue as a potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

After routine maintenance replacing the valve cover gasket, the low pressure GDI fuel line developed a leak in an area away from where the maintenance had occurred. After a 10 minute drive, the car developed a fire in the engine compartment. Upon investigation by an independent auto mechanic, it was determined that the fuel line had become brittle and developed a crack that had sprayed fuel into the hot surfaces of the engine compartment. This appears similar to the scenario affecting earlier Kia Optima models with the 2.0L Turbo engines. The heat from the fire caused the brakes to start to fail and the amber check engine light to come on within about 5 seconds before smoke was observed coming from the engine compartment. Fortunately, the fire occurred as the vehicle was pulling into the owner's driveway and a fire extinguisher was nearby and used to put out the fire....

My vehicle is consuming oil excessively. I have to put a whole quart of oil in my vehicle every 2 weeks. I am adamant about getting regular maintenance oil changes as well. My car had to be towed to a local auto shop due to the engine stalling and accelerator not working. They had to replace all 4 coil packs and 4 spark plugs due to dark, tarry oil covering the parts. The repairman told me my engine was at risk of failing, and that the repairs he did would not last without a new engine. I am worried about the car stalling or failing while driving, which puts an accident occurring at greater risk. My complaints resemble symptoms tied to previous Hyundai/Kia engine recalls. I am requesting investigation and manufacturer action related to this issue.

2019 Kia Optima EX - 59,000 miles - car miss fires and shakes on start. After a few seconds the car calms down and I can drive. Very dangerous since the fuel can stop flowing and the car can stall at any speed. Very dangerous!! Looks like several Kia's from 2019-2023 have been recalled for the same issue - High Pressure Fuel Pump - if my car is having the same issue at 59,000 miles why is this car not recalled, Very Dangerous! The Kia K5 which took over for the Optima is on the list why not the Optima EX.

I was just driving then noticed lack of acceleration and the engine light flashing. Loosing acceleration mid driving posed a great safety risk because no other drivers would know the issue I was experiencing and risked causing an accident. The vehicle was taken for a fault code reading which indicated a knock sensor code, later it was inspected at the dealership who confirmed an ECU issue. The police or insurance have not inspected the vehicle for this particular issue.

Oil is getting into cylinders causing spark plugs to misfire. Very high oil consumption so I have to put oil in it every other day in between oil changes. I’ve been to Kia Service department several times in the past 2 months.

Subject: Complaint Regarding Excessive Oil Consumption and Engine Hesitation in 2019 Kia Optima SX To Whom It May Concern, I am writing to formally lodge a complaint regarding my 2019 Kia Optima SX. Despite meticulous maintenance and care, I have been experiencing significant issues with the vehicle that are concerning, especially considering its relatively low mileage of only 107,000 miles. The primary issues are as follows: 1.Excessive Oil Consumption: My Kia Optima SX has been burning an excessive amount of oil, necessitating frequent top-offs well before the recommended oil change intervals. This is not only inconvenient but also raises serious concerns about the long-term health and reliability of the engine. 2.Engine Hesitation: The vehicle exhibits extreme hesitation during acceleration. This hesitation occurs sporadically, making it difficult to anticipate and presenting a potential safety hazard, especially when merging onto highways or attempting to overtake other vehicles. These issues are unacceptable for...

I currently have 119500 miles on my 2019 Kia Optima. I am losing oil somewhere between oil changes, and the car is beginning to hesitate while driving. I don't see oil on the ground but I have had to put in 2-3 1/2 quarts of oil way too often. For this to happen on some many vehicles, it must be a manufacturer defect. The hesitation just started and I'm taking it do get a diagnostic test. 11

I am writing to bring to your attention a critical safety issue with my 2019 Kia Optima SX 2.0 GDI Turbo, which has accumulated approximately 103,000 miles. This vehicle has recently developed several serious problems that I believe pose significant risks to both my safety and the safety of other road users. Firstly, my Kia Optima has been burning an excessive amount of oil. Specifically, it consumes over 5 quarts of oil within just 2,000 miles of driving. Despite thorough inspections, even from Kia Dealers there are no visible oil leaks, making this issue even more perplexing and concerning. Moreover, the vehicle has begun to shake violently while driving on the highway, which has led to a substantial loss of power in the middle of traffic. This unpredictable loss of power is extremely dangerous, especially at high speeds, as it compromises my ability to maintain control of the vehicle and...

Burns through oil. I have to consistently have oil on hand. 107,000 miles and being told my year does not fall under getting a new engine falls on me to replace it. This is an issue that falls on the manufacturer. Please help

Our 2019 Kia Optima has now stalled twice at a stop light in the past year. When it happens, we're able to restart the engine. In addition to stalling, the car struggles to start on some days and runs lumpy (minor surges in power) on other days. The symptoms match a problem Kia is aware of and for which it has provided an extended warranty (15 years/150,000 miles). Below is the wording from the extended warranty letter (2016-2020 MY Kia Optima Vehicles Low-Pressure Fuel Pump New Vehicle Limited Warranty Extension dated Sept 9, 2022): "If, at any time within the extended warranty period, you experience intermittent reduction in engine power, stalling while at idle, and/or inability or difficulty starting your engine, your authorized Kia dealership will diagnose the cause at no cost to you." When I took the car in after both incidents, the Kia dealer is not able to...

The morning of 9/26/2023 as I was driving on the freeway road and I experienced an intermittent reduction in engine power and had to pull over on the side of the freeway road. This was a very traumatizing experience and I was very lucky that I was not hit while awaiting to be towed. After my mechanic inspected my vehicle we received error code P1233 and advised me to call the dealership as this is something covered under an extended warranty. I scheduled an appointment for 9/27/2023 however, I dropped my car off on 9/26/2023 since I was able to arrange dropping it off a day earlier. I received a call very early on 9/27/2023 from Chuck, one of the mechanics at Westside Kia and he stated that my car was working perfectly fine. After I informed him of the issue I had he stated they would need to keep...