2017 HYUNDAI SANTA FE Engine Problems

Total engine failure at 120,000 miles. Car shut down without warning while driving.

Oil consumption issue. the car was eating 2-2.5 qts per 1,000 miles of oil. Over numerous 1,000 mile tests, it was confirmed my care was eating oil. The dealership did a combustion chamber cleaning, but the car still eats almost 1qt of oil per 1,000. I was actually told by a service advisor not to refill the oil and let the engine blow while I was driving it which is a safety issue. In my research there is a known oil consumption issue and I want Hyundai to replace my engine. I've been trying to get this rectified for almost 8k miles and am at 85K. I feel like Hyundai is trying to get me limp to 100K so my warranty is over.

My car's VIN has not been listed on the recall list for the engine, but the recall description is exactly what happened to me and my family while driving our vehicle. We have been going back-and-forth with Hyundai USA and BBBAuto for two years trying to get approval without any progress or success. We purchased our vehicle used with approximately 68k miles September of 2021, and the engine seized around 75k miles in February of 2022. Attached is the initial diagnosis reflecting the exact recall problem that happened with our engine. Hyundai confirmed the diagnosis when our car was towed there once they opened for business, but we did not receive approval for the engine replacement under the warranty. The car has been undriveable since as we await our VIN on the recall list as no one will give us approval that we've talked with about it. There is a...

Something in the engine failed while driving 55mph on a state highway my vehicle started knocking. I have also noticed metal shavings when I checked the oil. I have had a local mechanic look at my vehicle and told me that I need an engine replacement. There were no warnings or clues prior to this happening. I have been highly recommended to not drive the vehicle in the current condition.

While highway driving a few hours from home, the car started shaking so I pulled over, turned the car off & called AAA. Prior to that, there were no warning lights or messages, until it died & the Check Engine light turned on. The car was towed to a Hyundai dealer in Wilmington, NC for diagnostics. They determined that the cause was a burned valve in cylinder 4 so it had no compression & the engine would not run. Their only repair option was to REPLACE THE ENTIRE ENGINE. Given that the car was inoperable, we had no choice but to do that. After further investigation, we discovered that this company has a widespread issue with their engines & also has a class-action lawsuit for similar problems. Hyundai mechanics have told us that they know their engines are problematic & they replace multiple ones every day of the week. A...

The contact owns a 2017 Hyundai Santa Fe. The contact stated that upon start the vehicle, there was an abnormal grinding noise coming from the engine. There was no warning light illuminated. The contact stated that the vehicle stalled soon after while depressing the accelerator pedal. Due to the failure, the vehicle was towed to Bell Road Mitsubishi (1901 E Bell Rd, Phoenix, AZ 85022) where the vehicle was diagnosed with engine failure. The dealer and the manufacturer were both notified of the failure and instructed the contact to tow the vehicle to the dealer. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 17V578000 (Engine and Engine Cooling). The vehicle remained in the possession of the dealer where it was towed. The failure mileage was unknown.

Our car started making noises and hesitating while revving engine to increase speed. Two days later we took the car to our mechanic. No warning lights. They test drove the car but apparently couldn't replicate the issue. Tried again and couldn't start engine. They thought it may be the starter. A new starter did not solve issue. They called us back and said the engine has locked up. It wasn't a safety issue as the car was parked but I assume it could have been an issue if we were driving it when engine locked up. We regularly change the oil. We have approx. 109k miles on the car. An engine should last longer than that.

I just bought this car with only 58,000 miles on it back in October. The dealership I went to pressured me into buying this car for $5,000 more than the Toyota I went in for. I had a bad feeling from the start, but I’m young and easily taken advantage of. While driving a couple weeks ago, taking my [XXX] son home from the park, a check engine light came on. (First light to ever come on since getting the car) I was worried and took it easy trying to get home. The car didn’t make it home , it stalled, then wouldn’t start again. I got it towed to Hyundai and found out the engine has seized. I’m devastated. I’m a single mother and couldn’t afford this car very easily to begin with. Now I’m stuck with a car that I won’t be able to afford to fix and...

In December 2023 while getting a routine oil change, the mechanic told me there was no oil in the car but it was common for these vehicles. They told me to start getting it checked at 3,000 miles and having it topped off. When I went again in March 2024, there was again no oil. (I barely drive the car as I work remotely from home and rarely leave my house.) I called a mobile mechanic who came out and checked out the vehicle and told me it was probably the turbo out. I paid to replace the turbo. While driving in April 2024 the car suddenly lost all power and I coasted into a gas station. It refused to start. When the mechanic came, there was again no oil. After towing it 20 miles home, I spent the next few weeks replacing fuel injectors, spark plugs, and everything I...

The engine has an oil consumption problem. In early April, the oil crankcase was empty between oil changes. I change the oil religiously every 5k miles. In early April, the engine had zero oil and examination showed no leaks. The key safety issue is that no engine warning lights came on. The only reason I discovered the issue was because I noticed it was not running properly and took it to my local Goodyear Service Center who confirmed. The engine could have very easily seized up while I or a family member was driving putting us in real danger of an accident. The issue has been confirmed by the dealer - they are WELL aware of this engine oil consumption issue. One Hyundai dealer inspected the car and tried to tell I had two leaks - valve cover and oil pan gaskets. Both my Goodyear Service Center and a SECOND...

Driving car at highway speed down a mountain road with heavy traffic, A loud thump from motor and lost power, NO warning lamps PRIOR TO PROBLEM. No indication or odd noises from motor before complete failure. Oil had been replaced approximal two months before with no noticeable oil usage or burning. Oil changes completed every 3 to 4 months since purchase in 2019. Car required 2 quarts oil to fill to level. Without power assist to brakes, car was dangerous in heavy traffic. Car is available for inspection until paid off in two months and then will be scrapped. Independent machinic indicated noise sounds like rod journal had failed due low oil.

Our 2017 Santa Fe experienced a completeengine failure back in February at 106k miles while driving on the highway. I was driving the SUV when it lost power. There were no check engine lights or any warning signs from the car beforehand. We kept up on all the maintenance and regular oil changes. The local Hyundai dealership told us the car had experienced a failure in the short block on the engine and that it would require a completely new engine. It has been in the shop for close to a month.

Engine failure while on the highway. There were no warnings or check engine lights. The mechanic at a local shop stated that the engine seized up. The car had received regular maintenance up to that point.

While traveling to work about 1 mile before my exit, my 2017 Santa Fe Sport Ultimate 2.0T started sputtering and losing speed. I was scared to death traveling on a major highway (Rt 1). I immediately put the emergency blinkers on while continuing to lose speed. I barely made it off the highway before the car just STOPPED DEAD on the curve. NO POWER STEERING-NOTHING! THE CAR WOULDN'T MOVE! Terrified of tractor trailers and cars flying off the exit, I called the State Police to come as my protection from getting hit .While waiting, two Good Samaritans were concerned for my safety and stopped to help move the car partially out of the road (no steering). The state police arrived and waited while I got a tow truck seeing I was visibly upset. I later received a call from the auto shop telling me the engine was gone, The performed...

2017 Hyundai Santa Fe sport 2.0 purchased brand new on July 2016. A month ago with 73322km mileage, engine failure occurred on the highway. First, I heard a rattling sound, then car started to shake, engine light blinking, oil change light went off (which never) happens, and the car started to decelerate on the highway. Upon finding the next exit, as I was turning right at the lights, car shut off completely. Went to the nearest Hyundai dealership which was within 2kms. The car was moderately drivable up to the dealership, and was advised that it is unsafe for continuous use. The dealership's diagnostics were: piston or 2nd cylinder was not compressing and spark plug burned. Hyundai Streetsville, Mississauga advised me to pay $8000 for a new engine or sell them the car. Had the car towed from this dealership to my local dealership Schlueter Hyundai in Waterloo. Their diagnostics...

Complete engine failure with vehicle excessively consuming oil with no warning indicators. Issue has been recognized by dealer as known issue. Safety risk with car complete shut down with no warnings.

Owned this vehicle for 4 years without any issues. Driving home on a friday, made a stop at a friends dance studio, and as I pulled into the parking lot my car just randomly died. I was able to restart the vehicle without any problems and there were no error messages on my car to indicate an issue. I drove the car home for it to die on me again as I was pulling onto my road. At first we thought maybe alternator. Still no messages are being indicated on my vehicle. My husand drove the car to the mechanic on Monday and as he drove it started making noises. He was able to get it to the mechanic. It was later that day that we were advised there was only a quart of oil left in my car (oil changes pretty regularly), per the mechanic the engine is toast....

I have 146k miles on it, engine has bad rod knock sound at the start and while driving. Fuel quality and engine oil replacement has not been compromised. There is no check engine light on, and vehicle runs at very low rpm.

Over the past 50,000 miles we have put on the car we have had major oil leaks and now the engine is burning oil. The engine has stalled multiple times and now sounds like a diesel. We have spent over $3000 in repairs and still will have to replace our car as it continues to worsen. Metal shavings have been found in the oil. No remedies have been found, aside from replacing the engine.

I was driving on the highway at 65 miles per hour and my 2017 Santa Fe began to decelerate. I tried pushing hard on my petal and it would not accelerate past 30 mph. I got off the highway as safely as I could. I heard a knocking sound while driving and the check engine light came on after my car experienced this problem.

Engine seizure happened while driving and the engine caught on fire. The car was well maintained and had been up-to-date on all recalls.

The car started making a very loud knocking noise while driving and became un-drivable due to the engine knocking and sputtering. Safety was compromised due to not being able to safely drive the vehicle the appropriate speed as this began suddenly. The car was taken to the dealership where the determined that it had rod bearing failure and the engine needed replaced. There is a recall for the same make, model, and year of the car, but the VIN number is different. The recall that is out for other VIN of the same car and engine states that there is rod bearing failure due to a faulty crankshaft. This has been confirmed by the dealership. There were no warning lights or indications that the car was not in proper mechanical shape prior to the issue. The dealership and corporate are unwilling to work with us to have this issue repaired...

My car was burning oil much faster than it should have been. On [XXX], my car started making a very loud knocking noise, and my engine blew out while on [XXX] in Nashville, TN. Thankfully I was able to pull over with friends trailing me. There was a burnt smell coming from under the hood. The problem has been confirmed by my local Hyundai dealer. The service department at the dealer attempted to get my car approved for an engine replacement, and Hyundai Motor America has denied the authorization. According to Hyundai, a recall from August 9, 2018 was not addressed on my vehicle. They have documentation that proves that I was not the owner of the vehicle when the recall was issued, therefore, I was not made aware of the recall. Because the recall was not addressed, they are refusing to fix my car for free OR offer any...

Was going down the highway at 65 when my vehicle completely lost the accelerating component. Almost got rear ended so I pulled off. Then made it to work when it happened again. The engine light came on and gave 2 codes. Finally got it towed to the dealership where they have decided it’s either a new timing chain or new engine due to mechanical loss. They discovered there was no oil in the car and they have also found metal shavings in my oil. Now they are telling me I need a whole new engine. I only have 135,644 miles on this car. The car was driving perfectly fine the day before and had just been to the dealer and looked over 1,500 miles before and I was told everything was perfect working condition.

The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving 40 MPH, the vehicle lost motive power. The vehicle was taken to an independent mechanic. The mechanic performed an oil change, and the contact was informed that metal shavings were found in the oil. The contact was advised to take the vehicle to the dealer. The vehicle was towed to the dealer but was not diagnosed or repaired. The contact was informed that there would be a fee required to diagnose the vehicle. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 72,000.

I was driving down a busy road when engine seized, no warnings on dash prior to failure. Luckily, I was able to catch a break in traffic and safely cruised into an open parking lot. Otherwise, it could have easily resulted in a collision. The incident occurred on Wednesday 11/22/2023. The 2017 Santa Fe had regular oil services and did not show or indicate any signs it required attention. No check engine light, no oil pressure, light, absolutely nothing. The car simply cut out while driving at around 35-40mph. Santa Fe was towed and the dealership mentioned rod bearing failure and engine knock. The estimate to fix it was 18k which was not feasible for me at the time. Additionally, the dealership claimed it was a common problem with the make, stating they had received multiple cars that Thanksgiving weekend. I worked with the dealership, but they did not seem...

Engine seized up on the interstate with no warnings. Almost got hit by 2 semi's as I tried to get off the next exit. I had 3 small children riding with me and it was terrifying. Got it towed 100 miles to the nearest dealer and they said the engine was consuming oil and the engine seized up. They said they are "well aware" of this problem, but without any recall, the bill is entirely on me. The recall does cover most Hyundai models, but for some reason, it missed mine.. but clearly has the same issues.

Engine is overheating causing vehicle to burn through oil. I take the interstate every day, putting myself and others at risk if my vehicle breaks down. My oil sensors do not work, and do not display or illuminate. They flash on for a brief second and then disappear.

I was driving down the highway and noticed a sudden loss of power and a knocking sound coming from the engine that made a sound that matched the rpm's. It is available for inspection upon request however the battery is currently dead and it obviously has a serve knock. The safety of not only myself but other bystanders driving around me were at risk by my car potentially catching fire while driving. I have had one certified dealership tell me my car isn't effected by any recalls so there isn't anything they can do. There have been no formal inspections done to the vehicle. There were no warning lights on when we purchased the vehicle and no lights came on before, during or after this problem started. We have changed the oil every 3k miles and took really well care of this vehicle as we only had it for 3mo...

On Friday March 22 2024 I was attempting to merge onto the highway but an individual wouldn't let me in which forced me to have to slam on my breaks. After I was able merge, roughly 2 miles down the highway I started hearing what sounded like a belt flapping under the front of my car, the noise increased into a banging I noticed I was losing speed so I pressed on the gas petal and received no exeleration. I immediately pulled to the side of the highway. No lights came on to alert that there was an issue prior. I pressed on my brake and it was rock hard and my wheel seized. I turned off my vehicle to attempt to restart it when I turned the key there once one click sound and all the alerts lights came on. I was unable to turn the wheel or press...

Engine stalled back in January. Car has been at dealership ever since. I'm waiting on backordered parts to arrive to my 3rd party because so many engines are being replaced. Hyundai flat out told me that a used or remanufactured engine would eventually do the same thing. I've been told it was "catastrophic Engine failure" with shavings in my oil pan. My oil changes and upkeep were up to date which is why my 3rd party warranty company is agreeing to putting a reman Engine in. Hyundai should be made to provide new engines not remanufactured junk of the same problem. Too many people are going through what I'm going through. I have 3 more years of payments but only a year left for my warranty and still no car to drive. Here is a link to an entire group of people experiencing the same issues. My coworker also has...

On [XXX] (a Sunday, 9 pm), my 19 year old daughter was driving our 2017 Hyundai Santa Fe Limited when a solid yellow check engine light came on. No other warning lights were on. She called us, but since a solid check engine light should not indicate an emergent issue, we advised her to carefully drive the car back to school and we'd get it checked out the next day (since it was after 9 pm on a Sunday). The vehicle didn't make it that far. While driving, the car suddenly lost power and stalled. It started up again but made a terrible sound. We were able to call roadside assistance and had the vehicle towed to a nearby Hyundai dealership. The dealership tells us the car needs a new engine and that our VIN it is not covered under any of the other current engine recalls (even though this...

Catastrophic engine failure on a major highway. Just over 113k miles on it. 1 day prior, the car sounded louder than usual but otherwise, was working fine. I drove several places the next day and the check engine light came on towards the afternoon (yellow, not flashing, no other lights) 30 minutes before this issue occurred. I was accelerating on a busy highway and all of the sudden it completely downshifted, oil light and battery light came on. I pulled to the shoulder and white smoke was coming from the engine, horrible smell in the cabin. Car was dripping oil. I was told it was a broken rod that punctured the engine. I could have been in a major accident after decelerating so quickly on this particular highway and I was stranded on a very small shoulder fearing the car or myself getting hit for hours. As of right now,...

My 2017 Santa Fe experienced a catastrophic engine failure while driving on the highway. My [XXX] son was on his way home when the car began to make what he described as a knocking. He began to merge so he could exit the highway. By the time he made it over 1 lane, the vehicle began losing power and smoking. He barely made it to the shoulder before hearing a "loud bang" and thick, black smoke blocking his vision. Him and my [XXX] , fearing the vehicle was on fire, immediately exited the vehicle into the median. No warning lights ever came on in the vehicle, no warning, nothing. When my husband and I arrived, we found several pieces of the engine along the roadway and the oil pooled under the front passenger tire. We had the vehicle towed the next morning to the dealership, 50 miles away and a...

The contact owns a 2017 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed failures with the engine and catalytic converter and informed the contact that the engine had no compression. The vehicle was not repaired. The vehicle was then towed to the dealer, who confirmed the diagnosis and informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 104,000. The VIN was not available.

My mil lamp light came on and all of a sudden my vehicle would not accelerate had scanner out I. My car and was told I need a new engine. Researched the theta crankahaft issues could that have caused my engine to fail? I had no warning whatsoever

While driving car engine slowed down/lost power engine light came on, pulled over and it shutdown,. It would even try to start back up. Next day it started and made rattling noise from the engine. Towed vehicle to dealer, dealer said had a bad rod bearing and needed a new engine. Dealer and /or Hyundai would not repair this when we just paid to fix a similar issue (see below) Seems a lot of the 3.3L engines have these issues. We had a similar problem less than a year earlier, car slowed down while on interstate and would only go 35 mph. Engine would rev up but not go faster. (Danger for us and other drivers). Message came up said to take to dealer. Took to dealer said timing slipped need timing chain guides and cams' etc. $4,000 in repair. This seamed similar (Slow down etc.) to what happened this...

Driving on the interstate and the engine seized up. I was driving with three little children and we barely made it to an off ramp. This was extremely dangerous. After looking up the issue, I found there were 1000's of unhappy customers that drive similar models that had the same exact issue happen to them. I keep up to date all oil changes, as many other customers, but Hyundai says it's not their fault? How can companies like Hyundai sell a car that have numerous engine failures and not have a recall? I am terrified not only with the expense of the repair, but putting my children in another Hyundai, with the fear of it happening once again.

My vehicle experienced catastrophic engine failure while driving on the freeway. It had just over 100k miles. I heard a repetitive clicking sound when pressing on the accelerator. After 2 minutes, the car shuddered and black smoke filled the cabin. When I pulled over, oil was s pouring onto the road. The car was serviced 2 weeks prior including oil change by a certified mechanic with no problems identified. I never had a check engine light. I initially had the vehicle towed to my local mechanic who found 3 ruptured holes in the bottom of the engine block. I was told that it looked like "rod failure". When I notified Hyundai corp, I was told that the vehicle was no longer under warranty due to it being purchased pre-owned and because I had surpassed 100k miles. They told me that I could file a "goodwill" claim, but that it could...

I have always kept up on my oil changes. Driving down the road all of a sudden my engine turned off. No check engine lights or anything. Toed it to the dealer and the said the motor seized. Looking online this is a known problem. Vehicle no longer coverd by warranty.

Vehicle has intermittent engine stalling, but is still running. Possible dangerous situation if making left turn with oncoming traffic. This has happened to many times since my owner ship. Bought this car used. I am 2nd owner. 33k mi when purchased in 3-2021

I was driving down the highway when my vehicle shut off. After pulling off on the highway and opening the hood, there was a notice that the engine had overheated. Upon inspection, there was no oil nor any coolant left in the engine. I have records to demonstrate regular maintenance, and oil changes every 5000 miles

2017 Hyundai Santa Fe Ultimate with 88K miles experienced knocking while driving. Immediately stopped and was towed to dealership. Dealership diagnosed failure of rod bearing on cylinder 1. Motor could have seized up and caused accident on highway. Dealership has inspected. No lights or warnings present when this occurred.

Engine stalled multiple times while driving. Took it to the dealer, and the entire intake side camshaft bank and all 4 phasers had to be replaced. Engine only has 128K miles on it and has been serviced on schedule, so this should not be occurring.

My wife was driving our kids to school and got onto the highway when the vehicle lost power. There were no warning lights before the engine failure. The engine stopped running and she was just able to coast off of the highway. The check engine light came on as well as the high temperature and other warning lights. My wife turned the car off and let it sit for a couple of minutes while she called for help. When she started the car again there was no check engine light or other warning lights. She drove the kids to school but noticed the car was lacking power. I met her at the kids school and plugged in my OBDII reader and no issues were logged on the ECU. I drove the car to the dealership and the car had very little power. The dealership looked at the vehicle and a...

My wife was driving down the freeway to work during morning commute when her 2017 Santa Fe just lost power, was only able to go maybe 20mph which during an early morning Bay Area commute is very dangerous... No engine light or any warning lights, this lasted for a couple miles until the next exit she pulled off still no warning indicators showing, she turned off the car for a few minutes, then turned it back on to continue to work there was still almost no power but no indicators on the dash, finally after a few minutes started driving normal again. The next day when she was on her way to work, she started getting an oil light, I drove 45min to her job checked and oil level was fine, turns out oil pressure sensor was bad. After that was replaced everything seemed normal for around 1month or so...

Oil changes up to date and all of a sudden oil is gone, no leaks per the servicer. Engine started knocking but it is not one that is on recall. No low oil warning lights came on or anything. Now its costing half the price of the value of the car to repair which is over $7k and its not yet paid off and I got this vehicle 08/2022. This is just sad and no on can tell me why this is doing this on so many vehicles with my car vin range.

Catastrophic engine failure.

Failed crankshaft rod bearing

Engine bearing failure, sudden and without warning. Engine started to use oil between oil changes. Loud knocking started suddenly during starting and then continuous knock while running. Identical with issues related to recall 168, but my VIN does not show that recall effects my vehicle.