2003 FORD WINDSTAR Structureframe And Membersunderbody Shields Problems

TL* THE CONTACT OWNS A 2003 FORD WINDSTAR. THE CONTACT TOOK THE VEHICLE TO A AAA REPAIR FACILITY FOR INSPECTION. THE MECHANIC PLACED THE VEHICLE ON A LIFT AND FOUND RUST AND CORROSION ON THE AXLES AND SUBFRAME. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND FOUND THE SAME RUST AND CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. NHTSA CAMPAIGN NUMBER: 15V608000 (SUSPENSION) WAS REFERENCED. THE FAILURE MILEAGE WAS 147,131.

VEHICLE ON LIFT FOR OIL CHANGE WHEN MECHANIC NOTED THAT THE SUB-FRAME WAS ROTTED THROUGH ON THE DRIVER SIDE JUST ABOVE AND IN FRONT OF THE WHEEL. HE ALSO NOTED THAT A REPAIR BRACKET HAD BEEN INSTALLED AS PART OF THE RECALL ON THE PART OF THE FRAME BEHIND THE WHEEL. HE SAID HE WOULD NOT DRIVE THE CAR TOO MUCH LONGER WITHOUT GETTING IT REPAIRED. HE ADVISED THAT I SHOULD TAKE THE VEHICLE TO THE DEALER AND ADVISE FORD WHICH I DID. FORD DECLINED TO OFFER ANY ASSISTANCE SINCE IT WAS BEYOND THE RECALL WARRANTY PERIOD. THE REINFORCEMENT BRACKET WAS OBVIOUSLY NOT SUFFICIENT TO REPAIR THE CORROSION DAMAGE TO THE COMPLETE SUB-FRAME. *TR

MY WIFE DRIVING TO WORK THURSDAY 40 MPH AND REAR AXLE BROKE. LEFT REAR TIRE FORCED AGAINST WHEEL WELL CAUSING SIGNIFICANT SMOKE AND TIRE DAMAGE. PASSING CAR FLAG MY WIFE DOWN AND GOT HER TO PULL OVER. WHEN I CHECKED IT OUT LATER IN THE DAY FOUND THAT REAR AXLE WAS BROKE AND NOT DRIVABLE. COST TO FIX AT MY TOTAL EXPENSE 1030.00 PLUS TAX PLUS NEW TIRE. RECALL WAS PERFORMED IN 2011 AT KISTLER FORD TO INSTALL SOME KIND OF REAR AXLE SUPPORTS AND ALSO SOMETHING DONE TO REINFORCE FRONT SUBFRAME. AXLE IN BACK LOOKS LIKE IT BROKE INSIDE THE REINFORCEMENTS ON OR NEAR THE LEFT SIDE. KISTLER FORD SERVICE MANAGER STATED HE HAS SEEN THIS HAPPEN A FEW TIMES AFTER RECALL REPAIR AND FORD NOT WILLING TO TAKE CARE OF ADDITIONAL ISSUES AFTER THE RECALL. THAT DOES NOT SEEM ACCEPTABLE TO ME. SEEMS THEIR RECALL REPAIR NOT SUFFICIENT....

MINI VAN STEERING STARTED MAKING CLUNKING NOISE WHILE TURNING. THEN I NOTICE STEERING WHEEL IS NOT STRAIGHT WHEN CAR IS DRIVING STRAIGHT AND SOMETHING WAS WRONG WITH ALIGNMENT. AUTOMECHANIC TOLD ME PASSENGER SIDE SUB-FRAME ROTTED OUT AND MINIVAN IS UNSAFE TO DRIVE. I INVESTIGATED POTENTIAL RECALL OF WINDSTAR MINIVANS - I AM VERY UPSET THAT THIS COULD HAVE CAUSED ME TO CRASH ON THE HIGHWAY. ONLY A VERY THIN PIECE OF METAL REMAINS HOLDING THE FRAME IN PLACE. MINIVAN IS UNDRIVABLE AND NEED TO REPLACE SUBFRAME. *TR

THE ISSUE WITH MY VEHICLE IS WITH ITS SUBFRAME. THE FRONT DRIVER'S SIDE PORTION OF IT IS RUSTING OUT. I TOOK IT IN ON 11/4/13 TO A LICENSED VEHICLE SERVICE PLACE FOR A REGULAR OIL CHANGE, ONLY TO HAVE THE MECHANIC TELL ME THE SUBFRAME IS RUSTING OUT. AFTER LEARNING THIS NEWS (AND VIEWING THE SUBFRAME MYSELF TO OBSERVE THE CONDITION), I TOOK IT INTO A FORD DEALERSHIP TO HAVE IT FURTHER INSPECTED. THE SECOND INSPECTION WAS ON 11/7/13. AT THE LOCAL FORD DEALERSHIP, THEY ALSO INSPECTED THE REAR AXLE (WHICH WAS PART OF A FORD RECALL IN THE PAST). THE DEALERSHIP COULD SEE WHERE AN ATTEMPT TO APPLY SOME TYPE OF COATING TO IT ANOTHER TIME DID NOT CHANGE THE FACT THAT THERE WAS NOW A SIX-INCH CRACK RUNNING DOWN THE CENTER OF THE AXLE. A SERVICE CONSULTANT FROM THE DEALERSHIP TOOK MANY PICTURES TO SEND TO FORD. I...

ABOUT MARCH OF 2012 MY 2003 FORD WIND STAR'S LOWER CONTROL ARM SEPARATED FROM THE SUB FRAME "ENGINE CRADLE". I TOOK MY VAN TO DEALER. THEY DID DO A REPAIR TO SUB FRAME, WHICH I DID NOT FIND SATISFACTORY, FORD CORP. HAD THEM CUT OFF WHAT WAS LEFT OF ANY DAMAGED BRACKETS AND CLAMP STEEL BRACKETS ONTO A SUB FRAME THAT IS ALREADY DAMAGED DUE TO HEAVY RUST AND CORROSION. NOW ABOUT ONE YEAR LATER "MARCH OF 2013" THE SWAY BAR MOUNT, WHICH IS PART OF THE SUB FRAME HAS RUSTED OUT. MAKING DRIVING VERY UNSAFE AND UNSTABLE. THIS PROBLEM SHOULD HAVE BEEN RECTIFIED WHEN THE RECALL WAS DONE IN 2012. I TOOK VAN BACK TO THE DEALER. THEY SENT PICTURES TO FORD CORP. FORD DID NOT APPROVE ANY REPAIRS TO SUB FRAME STATING THAT IT WAS NOT PART OF ORIGINAL RECALL. NOW HOW IS THAT POSSIBLE IF THE SUB...

MECHANICS AT BIG MIKE NAUGHTON AURORA DENVER FORD, INC, AND PRIVATE MECHANIC DISCOVERED RUST AND CRACKS THROUGH OUT REAR AXLE. *TR

MY DEALERSHIP JUST CONFIRMED THAT THE FRONT (PASSENGER) SIDE ENGINE MOUNT THAT IS PART OF THE SUBFRAME HAS CORROSION TO THE EXTENT THAT THERE ARE TWO PERFORATIONS COMPLETELY THROUGH THE ENGINE MOUNT. I WAS TOLD THAT THE RECALL FOR THE SUBFRAME HAS CLOSED AND THAT THERE IS NO RECOURSE FOR GETTING FINANCIAL ASSISTANCE WITH THIS. HOWEVER, THE SERVICE MANAGER ([XXX]) ALSO ADMITTED THAT THE EXTENT OF CORROSION AND PERFORATION DID NOT OCCUR IN ONE YEAR ( I HAD THE ORIGINAL RECALL SERVICE DONE IN MAY OF 2011). THEREFORE, I QUESTION WHY THEY DID NOT BRING THIS TO ATTENTION OF THE RECALL AND INCLUDE THE REPAIR ACCORDINGLY. THIS IS A SAFETY ISSUE AND I WOULD APPRECIATE ANY HELP YOU CAN GIVE ME. THE DEALERSHIP WHERE I HAD THE SERVICE PERFORMED IS ROY O'BRIEN FORD IN ST. CLAIRE SHORES MI AND THEIR PHONE NUMBER IS 586-776-7600. INFORMATION REDACTED PURSUANT TO THE FREEDOM...

AFTER HAVING THE 2011 REAR AXLE AND SUBFRAME RECALL DONE MY TRANSMISSION FAILED WITH NO WARNING SIGNS WHAT'S SO EVER . . . . SHORTLY AFTER SPENDING TWO THOUSAND ON HAVING THE TRANSMISSION REBUILT IN AUGUST MY BRAKE LIGHT CAME ON AND MY ABS STARTING KICKING IN WHEN I APPLY MY BREAKS AND WHEN MY ABS LIGHT COMES ON MY BRAKES ARE FINE AND MY VAN DOESN'T COME UP ON THE ABS RECALL . . . . . . FORD NEEDS TO GET THEIR ACT TOGETHER AND FIX THESE VANS. *TR

TL* THE CONTACT OWNS A 2003 FORD WINDSTAR. THE CONTACT STATED THAT AFTER RECEIVING NOTIFICATION OF A MANUFACTURER'S RECALL FOR THE MOTOR BRACKETS, THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS. MONTHS AFTER THE RECALL REPAIRS WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH, THE ENGINE BEGAN SHIFTING ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED THE CONTACT THAT TWO MOTOR MOUNTS WERE FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MECHANIC ADVISED THE CONTACT THAT THE FAILURE MAY HAVE BEEN CAUSED BY THE PREVIOUS RECALL REPAIRS. THE FAILURE MILEAGE WAS APPROXIMATELY 186,000. THE VIN WAS UNAVAILABLE. UPDATED 02/09/12*LJ UPDATED 04/18/12

TL* THE CONTACT OWNS A 2003 FORD WINDSTAR. WHILE DRIVING IN REVERSE AT APPROXIMATELY 5 MPH THE CONTACT HEARD A SNAPPING SOUND. THE CONTACT STOPPED THE VEHICLE AND NOTICED THE FRONT PASSENGERS SIDE SUSPENSION HAD DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE FRONT PASSENGER SIDE LOWER CONTROL ARM AND SUSPENSION DETACHED FROM THE VEHICLE. THE MECHANIC NOTIFIED THE CONTACT OF A RECALL RELATED TO THE FAILURE. THE DEALER WAS THEN NOTIFIED AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V030000 (STRUCTURE: FRAME AND MEMBERS:UNDER BODY SHIELDS). THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE SUB FRAME WAS CORRODED AND NEEDED TO BE REPLACED. THE TECHNICIANS REPAIRED BOTH FRONT LOWER CONTROL ARMS AND BODY MOUNTS. THE SUSPENSION BAR WHICH DETACHED FROM THE VEHICLE...

2003 FORD WINDSTAR MINIVAN. CONSUMER EXPRESSES DISCONTENT IN REGARDS TO VEHICLE RECALL AND UNSAFE TO DRIVE *TGW THE CONSUMER STATED THE VEHICLE WAS RECALLED. IT WAS THEN DETERMINED THE VEHICLE COULD NOT BE REPAIRED AND WAS NOT SAFE TO DRIVE. THE CONSUMER WAS OFFERED A SETTLEMENT AMOUNT OF $6,675. HE STATEMENT THE SETTLEMENT OFFER WAS NOT ADEQUATE. *JB

2003 FORD WINDSTAR. CONSUMER WRITES IN REGARDS TO THE PERFORMANCE OF THE FORD MOTOR COMPANY AND TWO SAFETY RECALLS *TGW THE CONSUMER STATED THE INSPECTIONS AND REPAIRS WERE NOT CONDUCTED IN A TIMELY, EFFICIENT, AND RESPONSIBLE MANNER. THE CONSUMER STATED WHEN HE FINALLY RECEIVED AN APPOINTMENT FOR THE AXLE INSPECTION, IT WAS DETERMINED THE AXLE WAS CRACKED IN THREE PLACES. THE DEALER DID NOT HAVE THE REPLACEMENT PARTS AND THE VEHICLE WAS DEEMED UNSAFE TO DRIVE, AND THEREFORE, IT WAS LEFT AT THE DEALER FOR OVER A MONTH. THE CONSUMER STATED HE THEN RECEIVED ANOTHER RECALL RELATING TO THE SUBFRAME. THE CONSUMER CONTACTED THE DEALER REGARDING THE SECOND RECALL AND WAS INFORMED THEY WERE AWARE OF IT AND HE WOULD BE CONTACTED WHEN THE REPAIRS FOR THE SECOND RECALL HAD BEEN COMPLETED. THE CONSUMER RECEIVED A VOICE MAIL FROM THE DEALER STATING THE PARTS FOR THE AXLE HAD ARRIVED. HOWEVER,...

TL*THE CONTACT OWNS A 2003 FORD WINDSTAR. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE WAS COVERED WITH RUST AND SHAKING VIOLENTLY WHILE DRIVING. THE BRAKE PEDAL ALSO EXTENDED TO THE FLOORBOARD WHEN IT WAS ENGAGED. ALL OF THE GAUGES ON THE INSTRUMENT PANEL FELL BELOW ZERO, THE BRAKE LIGHT ILLUMINATED WHILE ALL OF THE LIGHTS ON THE INSTRUMENT PANEL BEGAN TO SHUT ON AND OFF. THE REAR AXLE WAS CRACKED ON EACH END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO ADDED TWO PLATES ON EACH SIDE OF THE AXLE. THE CONTACT REFERENCED RECALL 10V385000 (SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY) & RECALL 11V030000 (STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS) BUT WAS CONCERNED WITH THE REMEDIES AND STATED THAT THEY WERE INADEQUATE. THE CONTACT ASKED THE DEALER IF THEY COULD GUARANTEE THAT THE AXLE WOULD NOT BREAK WITH THE TWO PLATES BUT RECEIVED NO GUARANTEE. THE MANUFACTURER...

TL*THE CONTACT OWNS A 2003 FORD WINDSTAR. THE CONTACT STATED THAT AFTER RECEIVING A RECALL NOTICE IN REGARDS TO NHTSA CAMPAIGN ID NUMBER 11V030000(STRUCTURE: FRAME AND MEMBERS:UNDERBODY SHIELDS) AND 10V385000(SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY). SHE TOOK HER VEHICLE INTO THE DEALER NOVEMBER OF 2010 FOR BOTH RECALLS AND THE PARTS WERE NOT AVAILABLE TO PERFORM THE RECALL REPAIRS. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THERE ARE NO FAILURES AT THIS TIME.

BROUGHT MY 2003 FORD WINDSTAR SEL (WITH 78,397 MILES ON IT) IN TO DEALER TO HAVE IT CHECKED FOR SUBFRAME RECALL, THE ENGINE LIGHT BEGAN FLASHING, AND THE ABS, BRAKE LIGHT, AND TRAC OFF LIGHTS HAD ALL GONE ON. DURING THE DIAGNOSIS, THEY FOUND THAT THE SUBFRAME WAS FINE, THE SPARK PLUGS NEEDED TO BE REPLACED, THE IGNITION COIL NEEDED TO BE REPLACE (CAUSING CYLINDER 3 TO MISFIRE), AND THE PCM NEEDED TO BE RESEALED FOR MOISTURE. (MARCH 3RD, 2011) THEY FOUND NO HARD CODE FOR THE BRAKES. WE GET THE NECESSARY WORK DONE, DRIVE THE VAN HOME, AND WITHIN A DAY THE ABS LIGHT, BRAKE LIGHT, AND TRAC OFF LIGHT COME BACK ON. CALL AND HAVE THE DEALER LOOK AT VAN AGAIN, THEY NOW FIND CODE 1185 (PIN POINT TEST FOUND ABS MODULE NOT RESPONDING). THE DEALER REPLACED THE ABS MODULE AND RESCANNED WITH NO CODES AND WAS ROAD...

CONSUMER ARM WAS PINCHED WHILE SHE WAS RESTING IT ON THE WINDOW LEDGE OF THE VEHICLE. *MR THIS PROBLEM WOULD OCCUR WHILE IN THE PASSENGER SEAT. WHEN THE LOCK SNAPPED DOWN, THE CONSUMER'S ARM WOULD BE BADLY PINCHED. *SC