2004 FORD FREESTAR Power Train Problems

WAS DRIVING ON MY WAY HOME ON I85 AND THE CAR LOST SPEED AND REV UP ON RPM. READ CODES AN IT HAS A TORQUE CONVERTER CODE ON IT. I COULD HAVE BEEN INJURED BECAUSE MY CAR WAS NOT UNDER A RECALL AND I DIDN'T GET NO NOTICED. THAT WAS THE ONLY VEHICLE I HAVE AND NOW I HAVE NO WAY TO GET AROUND. IT WAS A VERY BUSY INTERSTATE I85 WHEN MY CAR LOST SPEED AND REVVED UP ON RPM WHILE I WAS IN MOTION WITH BIG RIGS BEHIND ME.

THE THIRD ROW SEATING LATCH HAS RUSTED OUT ON THE DRIVER SIDE. THE VEHICLE I BELIEVE HAS ISSUES THAT OTHER 2004 FORD FREESTAR VEHICLES HAVE THE SAME ISSUES AND WERE RECALLED. I HAVE CONTACTED FORD, AND THEY REFUSE TO HELP. I HAVE 4 CHILDREN AND I FEAR TO TAKE THEM ANYWHERE IN THIS VEHICLE. PLEASE HELP. THE VEHICLE JERKS AND STUTTERS WHEN IN DRIVE WHETHER I'M MOVING OR AT A STOP LIGHT AS LONG AS I AM IN ANY GEAR. IT ONLY HAS 85,000 MILES AND I'VE PURCHASED IT IN FEBRUARY.

THE VEHICLE STARTED SHIFTING ROUGHLY AND WITHIN A MATTER OF HOURS, FAILED TO MOVE WHEN IN REVERSE. I TOOK IT TO MY MECHANIC AND AFTER INSPECTING, WATER WAS FOUND IN THE TRANSMISSION. THE TRANSMISSION HAD TO BE PULLED AND REBUILT. APPROXIMATELY SIX MONTHS LATER, I HEARD A WHINNING NOISE THEN A CLICKING WHEN ACCELERATING, COMING FROM THE LEFT FRONT SIDE OF THE VEHICLE. I TOOK IT IN TO BE INSPECTED AND ONCE AGAIN THEY FOUND WATER IN THE TRANSMISSION, WHICH WAS NOT COVERED UNDER THE WARRANTY.

IM HAVING MANY ISSUES WITH MY VEHICLE. THE WORST ONE IS THE PASSIVE SECURITY SYSTEM THAT HAS STRANDED ME IN MANY AREAS BECAUSE IT REFUSES TO START. I HAVE TRIED MANY THINGS INCLUDING REPLACING TRANSPONDER KEYS AND THE TRANSCEIVER BUT I STILL AM GETTING THE FLASHING RED SECURITY LIGHT. IM SCARED TO DRIVE THIS THING IN THE WINTER DUE TO THE POSSIBILITY OF GETTING STRANDED IN COLD TEMPERATURES. ALSO THIS VEHICLE LETS WATER LEAK IN EVERYWHERE CAUSING SEVERE RUST AND MOLD ISSUES. ONE OF THE FLOOR SUPPORTS OF THE DRIVERS SEAT IS CLOSE TO BEING RUSTED THROUGH AND THE OTHER ONES ARE ON THEIR WAY OUT. THE BODY IS SEVERELY RUSTED AND IM NOT SURE HOW MUCH LONGER THIS THING WILL BE SAFE TO DRIVE.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING 25 MPH, THE VEHICLE FAILED TO SHIFT GEARS. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 60 MPH, THE TRANSMISSION WARNING INDICATOR ILLUMINATED AND THE TRANSMISSION FAILED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND WAITED APPROXIMATELY 30 MINUTES. WHEN THE VEHICLE WAS RESTARTED, IT OPERATED NORMALLY. AFTER FIFTEEN MILES, THE WARNING INDICATOR ILLUMINATED AGAIN AND THE TRANSMISSION FLUID STARTED TO LEAK OUT. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SEAL IN THE TRANSMISSION FAILED AND THE FLUID LEAKED OUT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 137,000.

2004 FORD FREESTAR [XXX]FORD IS CHARGING ME FOR THE REPAIR FOR THE TORQUE CONVERTER SUBFRAME 3-4 $600~$800 BUSHING KITS ($200 EACH) THEY WANT TO CHARGE ME. I INFORMED THEM THAT ONLY DO THE FACTORY RECALL REPAIRS THE PULLED MY VAN OUT AND TOLD ME THE CANT DO THE REPAIRS, BECAUSE THEY ARE SCARED OF THE BALL JOINTS AND TIE RODS MIGHT BREAK, THEN COMPLAINED ABOUT THE SUBFRAME MY HAVE TO BE CUT TO INSTALL NEW SUBFRAME BOLTS BUSHINGS ETC. JUST TO THEY CAN CONTINUE TO TAKE THE APART TO REPLACE THE TORQUE CONVERTER. THE AGREED TO CHARGE ME 300 LABOR AND TOLD ME TO PICK UP THE PARTS NEEDED SO I PURCHASED 2 TIE-RODS. 2 TRANSAXLES L-R, 2 LOWER CONTROL ARMS WHICH INCLUDED BALL JOINTS. THEY TOOK THE SUBFRAME APART THEN TOLD ME I NEED TO PAY AND ADDITIONAL $500 FOR A USED SUBFRAME FROM THE SALVAGE YARD. INSTEAD OF...

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE FAILED TO REVERSE. THE CONTACT TURNED OFF THE ENGINE AND TRIED AGAIN. A FEW MOMENTS LATER, THE CONTACT WAS ABLE TO DRIVE THE VEHICLE HOME. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING 35 MPH, THE TRANSMISSION MADE AN ABNORMAL NOISE AND STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.

GEARS FAILED TO ENGAGE. IT WAS SUDDENLY, NO ADVANCE WARNING. WE WERE DRIVING ON A 4 LANE HIGHWAY, IT JUST LOST POWER TO THE TRANSMISSION GEARS.

VEHICLE WAS STATIONARY AND WHEN STARTED WOULD NOT CONTINUE TO RUN, FINALLY DID RUN BUT WHEN PUT IN REVERSE VEHICLE WOULD NOT MOVE, SHIFTED INTO NEUTRAL AND ENGINE RPM PICKED UP FOR NO REASON, PUT INTO DRIVE AND VEHICLE SLIGHTLY MOVED AND ENGINE DIED. EARLIER IN DAY HAD DRIVEN VEHICLE WITH NO PROBLEM.

HAD THE RECALL FOR THE TORQUE CONVERTER DONE AND NOW MY VEHICLE SHAKES, SPUTTERS. WON'T ACCELERATE, THE RPMS JUMP UP HIGH, VERY LOUD NOISES COMING FROM UNDERNEATH VEHICLE. SOMETIMES IT WILL STALL OUT. CAN'T GO PAST 25-30 MPH IF IT EVEN GETS UP TO THAT! MY VEHICLE RAN PERFECT BEFORE TAKING IT INTO THE FORD DEALERSHIP AND EVER SINCE I GOT IT BACK WE HAVE HAD THIS PROBLEM. TOOK IT BACK TO FORD AND THEY TRIED TO SAY IT WAS THROTTLE CABLE SO HAD THAT FIXED AND IT STILL IS DOING THE SAME THINGS AS IT DID AFTER THE TORQUE CONVERTER WAS REPLACED. CAN'T DRIVE THE VEHICLE BECAUSE WHEN I GO TO ACCELERATE IT DOESN'T GO OR GET UP TO THE CORRECT MPH. THE WHOLE VEHICLE SHAKES REALLY BAD AND THE NOISES IT MAKES ARE VERY LOUD AND SOUND LIKE SOMETHING IS GOING TO BLOW UP. I THINK THE TORQUE...

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING 30 MPH, THE VEHICLE LOST POWER. IN ADDITION, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE AND INCREASED IN RPMS. THE VEHICLE WAS TOWED TO A PARKING LOT AND WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 71,423.

DRIVING AT HIGHWAY SPEEDS, THE ENGINE REMAINED AT 2000 RPM BUT THE MPH CONTINUOUSLY DROPPED TO BELOW 30 MPH UNTIL VEHICLE WAS STOPPED ON SHOULDER OF HIGHWAY. THE TORQUE CONVERTER WAS UNDER RECALL AND REPLACED PREVIOUSLY. THIS IS THE SAME SITUATION THAT OCCURRED AGAIN. I BELIEVE THE REPLACEMENT TORQUE CONVERTER WAS ALSO DEFECTIVE.

WHEN WE BOUGHT THIS VEHICLE WE LOVED IT BUT IT STEADILY WENT DOWN HILL. WE GOT NOTIFICATION OF RECALL ABOUT 6 MONTHS AFTER PURCHASE AND TRIED SEVERAL TIMES TO GET INTO THE DEALER. FINALLY GOT IT IN MARCH 2016 AND NOW HERE I AM PAYING ON A VEHICLE THAT THE TORQUE CONVERTER WENT OUT ON. PRIOR TO REPAIR THE TRANSMISSION WOULD ROUGHLY SHIFT AND JERK/LURCH INTO SELECTED GEAR AND AT HIGHER RATES OF SPEEDS WOULD SHUTTER AND TRANS LIGHT WOULD COME ON. NOW IT DOESN'T RESPOND TO THE GAS PEDAL RIGHT AWAY AND THEN THE ENGINE SHAKES/SHUDDERS AND THE DIPSTICK HAS A SUBSTANCE ON IT AND WHEN DRIVING TODAY IT JUST COASTED LIKE IN NEUTRAL! I HAVE 4 CHILDREN AND THIS DOES NOT GIVE ME FAITH IN FORD AND IT IS MY 3RD GENERATION STAR VAN AND MY 6TH FORD VEHICLE IN GENERAL.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING 50 MPH, THE TRANSMISSION SLIPPED WITHOUT WARNING. IN ADDITION, THE GEARS WOULD ONLY SHIFT AFTER THE VEHICLE REACHED 30 MPH OR ABOVE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000. THE VIN WAS UNAVAILABLE.

TRANSMISSION GET LOST WHILE DRIVING FORD FREESTAR 2004 VAN; DRIVING BACK FROM CHURCH, STOP IN TRAFFIC LIGHT THE VAN COULD NOT START AGAIN, PUSHED TO THE NEAREST GAS STATIONS, TOWED TO THE DEALER, WAS ADVISED THAT SINCE THEY CANNOT DO ANY DIAGNOSIS WITHOUT TURNING ON THE VEHICLE AND KNOWS WHAT IS WRONG WITH THE VAN, THEY NEED A NEW COMPUTER TO REPROGRAM THE CAR. PAID $2500 FOR COMPUTER REPLACEMENT AND REPROGRAMMING(RECEIPTS ATTACHED). I WAS TOLD ALL THE ISSUE WILL BE GONE. DURING THE DROP-OFF I TOLD THE SERVICE SPECIALIST THAT WHILE I AM DRIVING THE VAN SOMETIME WHILE INCREASING THE SPEED, OR JUST IN THE STEADY MOTION I DO EXPERIENCE CONDITION LIKE STUCK BACK AND FORTH, AND THEN MOVE; THE PROCESS REPEAT SOMETIME. TWICE THE CAR LOST POWER IN THE MIDDLE OF THE HIGHWAY THIS YEAR, AND WAS HELPED BY OTHER DRIVER TO STOP IT AND PUSH IT AWAY FROM...

PROBLEM #1 THE PASSENGER SIDE WINDOW WILL NOT WORK . IT'S CONTROLL MODULE WAS REPLACED IT WORKED ONE TIME AND STOPPED WORKING AGAIN. PROBLEM #2 THE DRIVE AXLE BROKE IN TRAFFIC LUCKILY WE WERE STOPPING AND WERE ONLY GOING ABOUT 5 MPH. PROBLEM #3 TODAY AFTER A NIGHT OF HEAVY RAIN WHEN THE VAN WAS UNLOCKED THE RADIO CAME ON BEFORE THE KEY WAS EVEN IN THE IGNITION. WHICH BRINGS US TO PROBLEM #4 THE BIGGEST AND NO DOUBT MOST EXPENSIVE. THE VAN STARTED AND WAS RUNNING KIND OF SLUGGISH BUT RAN FINE IN REVERSE BUT IF YOU SHIFT TO DRIVE THE VAN SHUTS OFF. YOU CANNOT START IT IN NEUTRAL EITHER. I HAVE HAD 2 INDEPENDENT MECHANICS LOOK AT IT TODAY BOTH SAY IT IS THE TORQUE CONVERTER. I LOOKED IT UP AND THERE IS A RECALL BUT OF COURSE IT'S THE WEEKEND AND I CAN'T CALL TO SEE...

DESPITE THE RECALL OF THE TORQUE CONVERTER AND REPLACEMENT OF PART, IT FAILED AGAIN. THE VEHICLE LOST ABILITY TO USE IT AFTER A SOCCER GAME. IT STARTED, BUT WOULDN'T DRIVE BEFORE LOOSING ALL POWER. IT WOUDN'T GO IN REVERSE AND HAD TO BE TOWED. THIS IS THE 2ND VEHICLE OF THE SAME MODEL TO DO IT THAT I OWNED. THIS COULD HAVE LED TO AN ACCIDENT, SINCE I WAS HEADING TO THE INTERSTATE WITH MY CHILDREN IN THE CAR. I AM CONCERNED THE PART SHOULD BE REPLACED AGAIN DUE TO EITHER A FAULTY PART OR THE WAY IT WORKS WITH OTHER PARTS. THIS IS A FINANCIAL BURDEN ON PEOPLE THAT OWN THESE VEHICLES.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING IN A MAJOR INTERSECTION. THE VEHICLE WAS ABLE TO RESTART SHORTLY AFTER AND BE DRIVEN FOR A COUPLE MINUTES, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 05/17/16*LJ *TR

I BOUGHT THIS CAR IN 2014. IT STRANDED ME ON THE SIDE OF THE ROAD IT WOULDN'T GO IN REVERSE OR DRIVE. FINALLY AFTER 4 HRS I GOT IT TO WHERE I COULD DRIVE IT HOME. TOOK IT TO A SHOP AND THEY SAID NOTHING WAS WRONG THEY HAD TO SEE IT ACT UP. EVEN THOUGH THE CHECK ENGINE SOON LIGHT WAS ON AND THE LIGHT FOR THE TRANSAXLE WAS ON THE SHOP SAID THEY PUT IT ON A DIAGNOSTIC MACHINE AND IT SHOWED NOTHING. SO I TOOK IT HOME AND IT WHEN I DRIVE IT IT JERKS AND THE RPM'S GO TO ABOUT 4000 RPM'S BEFORE IT SHIFTS. I HAVE HAD IT 4 TIMES AT A SHOP AND THE SAME THING HAPPENED THEY COULDN'T FIND ANYTHING WRONG. NOW IT HAS REALLY GONE BAD. IT NO LONGER SHIFTS YOU CANT GET IT PAST 35 MILES PER HOURS BECAUSE THE ENGINE...

VAN JUST LOST ALL POWER WITHOUT ANY WARNING WHILE DRIVING DOWN THE INTERSTATE AT 70 MPH. AFTER CALLING FORD I WAS INFORMED THAT THE RECALL FOR THE TORQUE CONVERTER WAS DONE IN 2011 AND NOW IT LOOKS LIKE THE SAME PROBLEM AGAIN.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN) HOWEVER, THE DEALER REFUSED TO REMEDY THE VEHICLE. THE CONTACT WAS THEN INFORMED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE CONTACT DECLINED. THE CONTACT STATED THAT AFTER LEAVING THE DEALER, AND DRIVING AT 25 MPH, SMOKE FILLED THE CABIN OF THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

MY VAN SUDDENLY WENT OUT OF GEAR AND THE VAN LURCHED FORWARD, WHILE DRIVING AT ABOUT 35 MPH. THANKFULLY WE WERE IN TOWN, AND NOT GOING A FASTER SPEED OR ON A MAJOR HWY! AFTER COASTING TO A SAFE PLACE, WE FINALLY MANAGED TO GET IT TO GO BACK INTO GEAR FOR A SHORT TIME. AFTER SEVERAL ATTEMPTS, WE MANAGED TO GET IT HOME. IT REFUSES TO GO INTO GEAR NOW AND HAS BEEN PARKED SINCE THEN. I KNOW THERE HAS BEEN A RECALL ON THE TORQUE CONVERTER FOR THIS MAKE AND MODEL, AND THOSE CUSTOMERS HAVE EXPERIANCED THE EXACT SAME SYMPTOMS AS MY VAN. THIS IS OBVIOUSLY A PROBLEM WITH A LOT MORE VANS THAN ORIGINALLY THOUGHT AND THE RECALL NEEDS TO BE EXTENDED TO OTHER VIN #S, INCLUDING MINE.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING AT ANY SPEED, THE VEHICLE JERKED BACK AND FORTH WITHOUT WARNING. THE CONTACTED RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN) AND THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSISTED THAT THE RECALL REPAIR WAS PERFORMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE RECALL REPAIR WAS PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT PROVIDED.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO HAVE IT REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 13V081000 (SEAT BELTS); HOWEVER, IT WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN). AFTER THE RECALL WAS PERFORMED, THE TRANSMISSION FLUID LEAKED AND THE GEAR SHIFT HESITATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 219,000.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING 55 MPH, THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT DISCOVERED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 142,004.

MY CAR HAS SPENT 10 DAYS AT FORD TO BE SERVICED AFTER HAVING THE SAFETY RECALL SERVICE FOR THE TORQUE CONVERTER PERFORMED. THE VEHICLE WAS BEHAVING UNPREDICTABLY, SOMETIMES STALLING OUT WHILE IDLED, STALLING OUT WHILE IN MOTION, SOMETIMES IDLING WITH HIGH OR LOW RPMS. THE DEALERSHIP TOOK IT BACK IN TO CHECK THE TORQUE CONVERTER, THEY THEN SAID IT WASN'T THE TORQUE CONVERTER BUT THE THROTTLE BODY, THEY THEN CLEANED THAT AND SAID IT'S NOT THE THROTTLE BODY, IT'S THE PCM. THE PCM IS TAKING ON WATER FROM A FLAWED DESIGN OF THE ABOVE PCM WHERE WATER IS RETAINED AND EVENTUALLY LEAKS ON TO THE CONNECTOR. THIS OF COURSE IS NOT COVERED BY FORD, AND CAN COST UP TO $1200 TO REPLACE. THIS ISSUE CREATES A NUMBER OF DIFFERENT SYMPTOMS MAKING IT HARD TO IDENTIFY THE ORIGIN OF THE PROBLEM. CAUSING EXTENDED STAYS FOR MAINTENANCE. THIS SHOULD BE RECTIFIED BY...

2ND TIME THAT THIS HAS HAPPENED. WAS DRIVING WHEN THE VAN STARTED BUCKING/SPUTTERING/SURGING. IT WOULD DIE AND THEN FIRE RIGHT BACK UP JUST TO DO IT ONCE AGAIN. SOAKED PCM CONNECTOR WAS TO BLAME BOTH TIMES. THIS IS OBVIOUSLY A DESIGN FLAW BY FORD AND NEEDS TO BE TAKEN CARE OF. I'M GLAD I WAS NOT ON THE INTERSTATE OR IN THE MIDDLE OF AN INTERSECTION.

FOLLOWING THE SAFETY RECALL REPLACEMENT OF MY 2004 FORD FREESTAR'S TORQUE CONVERTER MY VAN LOST ALL POWER WHILE APPROACHING AN INTERSECTION GOING APPROXIMATELY 15MPH. THE VEHICLE WAS IN MOTION AND THERE WERE NO INDICATIONS OF A PROBLEM (NO LIGHTS ON THE DASHBOARD, NO ODD NOISES, NOTHING). THE VEHICLE JUST LOST ALL POWER AND CAME TO A STOP, LUCKILY I WAS JUST SHY OF THE CROSS-TRAFFIC. THERE ARE MAJOR PROBLEMS WITH THE TRANSMISSION OF THIS VEHICLE IF IT DIES AFTER GETTING THE PROBLEM PART, THE TORQUE CONVERTER, REPLACED AS A RESULT OF A SAFETY RECALL. UPON BRINGING IT BACK TO A FORD DEALERSHIP TO HAVE THE REPLACEMENT PART REINSPECTED, I WAS TOLD THERE ARE NO CODES BEING THROW BY THE COMPUTER AND THE CAR IS FINE. CLEARLY THE CAR IS NOT FINE IF IT'S STALLING OUT WITHOUT WARNING WHILE IN MOTION. I'M VERY FRUSTRATED.

I WAS DRIVING THE VEHICLE AND IT WAS RAINING OUTSIDE AND AS I WAS DRIVING ALL OF A SUDDEN MY CAR JUST DIED IN THE MIDDLE OF THE FREEWAY NO WARNING ,NO NOTHING JUST DIED I ALMOST WAS REAR ENDED, I TOOK IT TO A MECHANIC WHO SAID THE PCM IS NOT SEALED PROPERLY AND GOT WET AND FRIED OUT THIS IS UNBELIEVABLE THAT FORD WOULD SEE TONS OF THESE COMPLAINTS LIKE I HAVE SEEN ONLINE SAME PROBLEMS AND PUT PEOPLE LIVES AND THEIR CHILDREN'S LIVES IN DANGER WITH THIS POOR MANUFACTURING. WHAT CAN I DO ??? THANK YOU [XXX] VIN UNAVAILABLE INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR*JB

STARTED SPUTTERING, JERKING, AND STALLING PCM WAS WET CAUSING ALL KINDS OF HAVIC LOST POWER GOING INTO A TURN AND ALMOST WENT INTO A DITCH FORD NEEDS TO RECALL THIS ONGOING PROBLEM AND GET IT FIXED BEFORE SOMETHING MAJOR HAPPENS ALOT OF PEOPLE ARE COMPLAINING AND FORD KNOWS IT IS THERE FAULT AND THEY HAVE A PROBLEM BUT REFUSES TO TAKE CARE OF IT.

TORQUE CONVERTER REPLACED A YEAR AGO COMPLETE TRANSMISSION FAILURE ALMOST WENT INTO A DITCH TRYING TO GET IT OFF THE ROAD NO PROBLEM WITH TRANSMISSION UNTIL I HAD FORD REPLACE TORQUE CONVERTER DUE TO RECALL

I HAD THE TORQUE CONVERTER RECALL PERFORMED ABOUT 8 MONTHS AGO. WHILE DRIVING TODAY, THE TORQUE CONVERTER FAILED. FORD DEALERSHIPS REPLACED TORQUE CONVERTERS WITH FAULTY TORQUE CONVERTERS.

ACCELERATING AT 35-45MPH. LOSS OF POWER AS ENGINE STARTS A GRINDING NOISE AND WONT UPSHIFT TO NEXT GEAR. INDY MECHANIC HAD TO REPLACE/REBUILD TRANSMISSION .RECALL FOR TORQUE CONVERTER WAS PERFORMED BY FORD DEALER PRIOR TO PROBLEM.

WHEN DRIVING DOWN THE ROAD AS VEHICLE APPEARS TO SHIFT FROM DRIVE TO OVER DRIVE THERE IS A SHUDDER IN THE TRANSMISSION. I HAVE HAD VEHICLE CHECK BY A PROFESSIONAL REPAIR FACILITY AND BEEN ADVISED THAT THE TORQUE CONVERTER IS BAD. THIS VEHICLE DOES NOT FALL UNDER THE RECALL, ALTHOUGH I AM HAVING THE SAME PROBLEM OF THE VEHICLES THAT WERE RECALLED. I AM HOPING THAT A REVISION CAN BE DONE ON THIS VEHICLE AND ALL OTHERS LIKE CAN BE INCLUDED IN THE RECALL.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 30 MPH, THE ACCELERATOR PEDAL WAS APPLIED AND THERE WAS NO ENGINE POWER. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. IN 2013, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN), BUT THE FAILURE RECURRED RECENTLY BECAUSE THE REMEDY WAS INSUFFICIENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 162,801.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE SHIFTING FROM REVERSE TO DRIVE, THE VEHICLE SUDDENLY WOULD NOT ACCELERATE FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO INDICATED THAT THE TORQUE CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT INDICATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN) IN 2012 FOR THE SAME FAILURE. THE FAILURE MILEAGE WAS 135,928.

TRANSAXLE BROKE WHILE I WAS IN A FASTFOOD DRIVE THRU. COMPLETE LOSS OF DRIVABILITY. *TR

HAD THE TORQUE RECALL DONE LAST AUGUST BY A LOCAL DEALERSHIP, AND WHILE ACCELERATING YESTERDAY I LOST ALL CONTROL OF THE VEHICLE AND THE ENGINE STALLED, TRANSMISSION IS NOW SHOT AND THE PCM IS DAMAGED FROM THE MOISTURE EVEN THOUGH I HAD COMPLETED THE TSB THE DEALERSHIP ADVISED ME OF. SEVERAL SENSORS KEPT FAILING RANDOMLY, AND WOULD ONLY LAST ABOUT A MONTH. *TR

STOPPED AT A STOP SIGN AND THE VAN WOULD NOT MOVE. NO GEARS WORKED. COUPLE DAYS LATER, IT DROVE FINE. COUPLE DAYS LATER NO GEARS AGAIN. (AND THE TORQUE CONVERTER WAS REPLACED UNDER RECALL IN 2012) NOW WON'T START AND DASHBOARD GOES CRAZY AFTER THE KEY IS OUT. WITH ALL THE TRANSMISSION PROBLEMS AND THE WET PCM PROBLEMS, I CAN'T BELIEVE FORD DOESN'T HAVE TO RECALL THESE VAN BECAUSE OF THE PCM!! THIS VEHICLE IS A HAZARD TO DRIVE. *TR

TL*THE CONTACT OWNS A 2004 FORD FREESTYLE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE VEHICLE FAILED TO ACCELERATE. THE CONTACT SHIFTED TO PARK AND THE VEHICLE FAILED TO SHIFT GEARS. THE CONTACT MENTIONED THERE WAS AN INTERNAL TRANSMISSION LEAK. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 40 MPH, THE TRANSMISSION BEGAN TO HESITATE AND SLIP GEARS WITHOUT WARNING. IN ADDITION, THE TRANSMISSION FAILED TO FUNCTION IN REVERSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 92,000. THE VIN WAS UNAVAILABLE.

WHILE DRIVING ON THE FREEWAY AT 55 MPH MY VEHICLE LURCHED FORWARD DRASTICALLY AND THEN STALLED. I WAS ABLE TO GET IT TO THE SIDE OF THE ROAD COASTING AS I WAS IN THE OUTSIDE LANE. I COULD RESTART THE CAR BUT ONLY GO 50-100 FEET AND IT WOULD STALL AGAIN. I MANAGED TO GET IT OFF THE ROAD INTO A PARKING LOT AND FOUND OUT THE CAR WOULDN'T GO INTO REVERSE. ALTHOUGH I COULD GO FORWARD. I AM NOW BEING TOLD THAT THERE WAS A TORQUE CONVERTER RECALL FOR THIS YEAR AND MAKE OF CAR BUT NOT FOR MY VEHICLE. I AM BEING TOLD THE TRANSMISSION WILL NEED REBUILT AND BE AT A COST OF 3000-3900 DOLLARS. THE CAR HAS APPROX. 102,000 MILES ON IT. I WAS TOLD BY THE TRANSMISSION SHOP THIS IS A COMMON PROBLEM WITH THIS CAR EVEN IF THEY ARE REPAIRED THEY TEND TO HAVE...

PCM GETS WET AND CAUSES ALL KINDS OF PROBLEMS! SHOULD BE A RECALL! CAN CAUSE VEHICLE TO JUST STOP WHILE DRIVING, SHORTS OUT THINGS. TURNS LIGHTS, RADIO, ETC ON EVEN WHEN VAN NOT ON. PROBLEMS WITH STARTING WHEN IT RAINS. CD PLAYER AND CRUISE CONTROL NO LONGER WORK, DID THE PCM FRY THEM TOO?? DANGEROUS ACCIDENTS COULD HAPPEN AND I AM TERRIFIED TO DRIVE IT BUT IT IS ONLY VEHICLE I HAVE. PLEASE HELP GET A RECALL!! *TR

TURNS OUT THERE WAS A RECALL ON THE 2004 FORD FREESTAR IN 2012 REGARDING THE TORQUE CONVERTER. HERE IT IS TWO YEARS LATER AND IT GOES OUT AGAIN. THIS SHOULD NOT HAPPEN. THERE NEEDS TO BE ANOTHER RECALL ON THE TORQUE CONVERTER AND IT NEEDS TO BE FIXED PROPERLY THIS TIME BEFORE THERE IS A DEATH FROM THE INCIDENT. I HAD TWO KIDS UNDER THE AGE OF 3 WITH ME AT THE TIME AND SITTING IN THE POURING RAIN, IN CHILLY WEATHER, WAITING FOR A RIDE HOME WAS NOT FUN. FIX IT FORD!!! *TR

TRANSMISSION WENT OUT WHILE COMING HOME FROM CHRISTMAS WITH FAMILY ON RT I70 JUST BEFORE HAGERSTOWN MD. LOST ALL FLUID FROM TRANSMISSION CAUSING ENTIRE VEHICLE TO FILL WITH SMOKE. THERE IS A RECALL FOR THE TORQUE CONVERTER I HAVE SINCE BEEN INFORMED THAT COULD CAUSE THE TRANSMISSION ITSELF TO FAIL. HOWEVER THE DEALER SAYS ONLY THE TORQUE CONVERTER IS UNDER RECALL AND WANTS $3000 TO REPLACE ENTIRE TRANSMISSION! THEY HAVE NOT EVEN LOOKED AT THE TRANSMISSION TO SEE WHAT IS WRONG. THEIR REASONING IS THAT SINCE THE FLUID CAME OUT AND COVERED UNDERSIDE OF VAN THEN IT MUST BE A COMPLETELY BAD TRANSMISSION. *TR

2004 FORD FREESTAR TOWED TO THE GARAGE DUE TO A TRANSMISSION ISSUE. *MW THE CONSUMER STATED HE DID NOT RECEIVE A RECALL LETTER, UNTIL AFTER HE HAD THE REPAIRS DONE ON THE VEHICLE. THE CONSUMER HAS FULL DOCUMENTATION THAT FORD AGREED TO PAY FOR ALL EXPENSES DIRECTLY RELATED TO THE RECALL EVEN IF THE REPAIRS WERE DONE BY A PRIVATE BUSINESS. THE VEHICLE HAD NO FORWARD OR REVERSE MOVEMENT. THE TORQUE CONVERTER WAS REPLACED. *JB

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT TRANSMISSION FLUID SPEWED OUT OF THE VEHICLE AND THE VEHICLE FAILED TO ACCELERATE PAST 45 MPH. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 87,822. UPDATED 12/09/14*LJ THE CONSUMER STATED THE TRANSMISSION BLEW OUT OF THE DIPSTICK ALL OVER THE MOTOR. VEHICLE CAME TO A STOP ON A BUSY INTERSTATE ALMOST CAUSING AN ACCIDENT. THE DEALER WOULD NOT ASSIST UNDER RECALL. UPDATED 10/5/15 *JS

. IN ADDITION TO CAUSING AN ENGINE TO STALL, WHICH MAY OR MAY NOT THEN RESTART, TRANSMISSION SHIFT POORLY, THE VEHICLE HAS HAD ERRATIC POWER, ALMOST EVERY TIME THERE IS AN INABILITY TO SHIFT THE VEHICLE INTO EITHER FORWARD OR REVERSE. ON START UP NO MATTER THE TEMP OF VEHICLE THE IDLE RPM IS HIGHER THAN NORMAL IN PARK ! IT HAS BEEN SERVICE MANY MANY TIMES.. NOW OUR TRANSMISSION FLUID LOOKS LIKE PEPTO BISMOL !! *TR