2004 FORD FREESTAR Engine And Engine Cooling Problems

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THE AIR CONDITIONING WOULD NOT COOL THE INSIDE OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THE DEALER ADDED FREON, BUT IT DID NOT CORRECT THE PROBLEM. THE DEALER ALSO STATED THAT THE COMPRESSOR WAS OPERATING PROPERLY. THE CONTACT STATED THAT THE AIR CONDITIONING DID NOT SEEM TO TRULY START WORKING UNTIL THE VEHICLE SPEED WAS AT 40 MPH AND ABOVE. THE VEHICLE WAS NOT FURTHER REPAIRED.THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 140,000. *TR

WHEN THE VEHICLE IS WET THE SYSTEM SEEMS TO SHORT CIRCUIT ITSELF. IT CAUSES IT TO SHIMMY AND SHAKE AND IT WONT ACCELERATE. WE NOTICED IT SEVERAL TIMES AND TOOK IT IN WHERE WE WERE TOLD IT WAS THE CAMSHAFT SENSOR BUT AFTER HAVING IT REPLACED TWICE IT IS STILL HAVING THE ISSUE. THE CHECK ENGINE LIGHT IS CONTIGUOUSLY ON AND IT BLINKS ERRATICALLY WHEN EVER ANY WATER IS PRESENT. I'VE BEEN TOLD THE SENSOR CAN GO FAULTY DO TO A COIL ISSUE ALLOWING WATER TO LEAK ON THINGS IT SHOULDN'T. *TR

THE CAR WAS DRIVING FINE ALL OF A SUDDEN THE FREESTAR LOST POWER, I WAS DOING T MOST 40 MPH BECAUSE IT WAS DURING RUSH HOUR ON THE I15 HWY BY HESPERIA EVERYTHING WAS FINE AND ALL OF A SUDDEN MY CAR LOST POWER AND BEGAN TO FEEL LIKE IT WAS LOOSING POWER AND THEN I SAW IT GO FROM FORTY TO SLOWER MPG AND I HAD MY FOOT ON THE ACCELERATOR I IMMEDIATELY PULLED OVER AS SOON AS I COULD AND THERE WAS SMOKE AND THEN THERE WAS FIRE MY 1CAR WAS BURNT A TOTAL LOSS MY DAUGHTER AND I BARELY ESCAPED WITH OUR LIVES MINUTES BEFORE THE VAN EXPLODED SOMEONE HAD PUT US IN HER CAR AND DROVE US FORWARD SAVING OUR LIVES WHEN THE FIRE DEPARTMENT ARRIVED I WALKED BACK TO MY CAR AND THE FIRE HAD EXPANDED FAR PAST WHERE ME AND MY DAUGHTER WERE STANDING....

MANY ISSUES WITH THE VAN & THEY CONTINUE. PURCHASED FROM 1 PREVIOUS OWNER, JAN '09 AROUND 60K MAY 2010, 74K MILES- REPLACED SPARK PLUGS & WIRES, FUEL SYSTEM CLEANER: ROUGH IDLE $432.23 DEC 2010, 83K MILES - REPLACED FRONT AXLE & SWAY BAR LINKS: $822.89 APRIL 2011, ? MILES, - REPLACED PLUGS & WIRES, COIL PACK: ROUGH IDLE $700.85 JAN 2012, 100K MILES - REPLACED PVC EVAP HOSE, R&R FUEL FILTER, FUEL INJECTOR CLEANER: ROUGH IDLE $228.40 AUG 15 2012, 106K MILES - RECALL, TORQUE CONVERTER REPLACED: COSTING ME $162.14 TO REPLACE SEALS & TRANSMISSION FILTER AUG 16 2012, 106K MILES - REPLACED EGR VALVE: ROUGH IDLE & ENGINE LIGHT ON AFTER RECALL FIX $135.95 (DEALERSHIP WAS KIND ENOUGH TO ONLY CHARGE FOR LABOR) AUG 31, 2012, 107K MILES - ENGINE IS STILL RUNNING ROUGH, PIERCING NOISE WHILE DRIVING, SOMETIMES IT GOES AWAY WHEN I AM TURNING. *TR

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STOPPED ACCELERATING. THE CONTACT WAS ABLE TO SAFELY COAST TO A STOP. THE VEHICLE WAS PUSHED HOME BY ANOTHER VEHICLE. THE CONTACT EXAMINED THE VEHICLE AND NOTICED THAT THE ENGINE SEIZED IN ADDITION TO THE TRANSMISSION FAILURE. THE VEHICLE HAD NOT BEEN INSPECTED BY A DEALER, NOR HAD IT BEEN REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 90,000. UPDATED 04/27/12*LJ THE CONSUMER WAS INFORMED, THE TRANSMISSION COULD NOT BE LOOKED AT, UNTIL THE ENGINE WAS REPLACED. UPDATED 04/27/12

THE VEHICLE WILL BEGIN TO ACT LIKE IT IS GOING TO STALL AT HIGH SPEEDS OR GOING UP HILL. WE NOTICE IT MORE WHEN WE ACCELERATE REALLY FAST LIKE AN ON RAMP TO THE HIGHWAY, BUT IT ALSO HAPPENS WHEN IT NEEDS THE EXTRA POWER GOING UP HILL. I HAVE TAKEN IT IN AND I WAS TOLD IT WAS WATER GETTING INTO THE PCM CAUSING ELECTRICAL PROBLEMS WITH READ OUTS ON TEMPERATURES AND OTHER THINGS. WE HAVE ALREADY HAD TO GET THE TORQUE CONVERTER REPLACED A FEW YEARS AGO AND I WAS TOLD THAT IT MAY HAVE BEEN TO ISSUES WITH THE PCM. *TR

DROVE VEHICLE TO STORE, WENT IN TO DO SHOPPING CAME OUT TO LEAVE VEHICLE WOULD START BUT WOULDN'T ACCELERATE. TWO DAYS BEFORE INCIDENT IT HAD BEEN RAINING IN GRAND JUNCTION COLORADO. HAD VEHICLE TOWED TO FORD AND WAS TOLD TODAY THAT THE PMC IS FULL OF WATER! IT'S GOING TO COST ME OVER 1500.00 TO FIX THIS! WHAT WOULD OF HAPPENED HAD IT DECIDED TO GO OUT AS I WAS DRIVING DOWN THE ROAD WITH MY TWO KIDS IN THE CAR? OR WHEN RUSHING MY SEVERE ASTHMATIC TO HOSPITAL? *TR

I PURCHASED THIS VEHICLE IN 2009. HAD IT IN THE SHOP 3 TIMES IN THE FIRST YEAR FOR SUSPECTED TRANSMISSION PROBLEMS WHILE UNDER DEALER WARRANTY. EACH TIME I WAS TOLD THERE WAS NO ISSUE AND THE TRANNY WAS STRONG. HAVE HAD ISSUES SINCE THE BEGINNING. DURING A RECENT TRIP TO THE GROCERY STORE THE TRANSMISSION SEEMED TO SLIP OUT OF GEAR WITH TOP SPEEDS REACHING 23 MPH. LUCKILY I WAS ABLE TO MAKE IT HOME. PARKED THE VAN. NEXT MORNING WHEN I WENT TO START IT, IT WOULDN'T EVEN TURN OVER. I PUT A NEW BATTERY IN IT AND IT RAN. CONTINUED TRANSMISSION PROBLEMS. I TOOK IT BACK TO THE FORD DEALER AND WAS TOLD I NEEDED A NEW TRANSMISSION TO THE TUNE OF $3500. THEY DIDN'T EVEN INSPECT IT. I WAS TOLD THERE WAS A RECALL BUT MINE NEEDED MORE THAN THE TORQUE CONVERTER SO I WOULD BE RESPONSIBLE....

FIRE IN ENGINE. MECHANICAL ASSESSMENT RIGHT NOW IS TRANSMISSION FAILURE. DON'T HAVE SPECIFICS OUTSIDE OF THAT, BUT I SEE TRANSMISSION FAILURES THIS MONTH BY FORD FOR MY VEHICLE, AND I'M NATURALLY CONCERNED. *TR

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER AND A COVER WAS PLACED OVER THE COMPUTER TO KEEP WATER FROM GETTING ENTERING AND DAMAGING THE COMPUTER BUT THE REPAIR DID NOT CORRECT THE FAILURE. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE DEALER ADDED SEALANT TO THE COVER THAT WAS PROTECTING THE COMPUTER. THE VIN WAS NOT AVAILABLE. THE CURRENT MILEAGE WAS 103,000 AND THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 03/27/12*LJ THE CONSUMER STATED THE COMPUTER IS LOCATED DIRECTLY UNDER THE WINDSHIELD, ALLOWING WATER TO DRIP ON THE COMPUTER.

CAME OUT FROM WORK, WENT TO START MY FORD FREESTAR, THE CAR TURNED ON BUT COULD NOT MOVE IT. THE WHEELS WOULD TURN, ATTEMPT TO REVERSE OR DRIVE AND NOTHING WOULD HAPPEN. WAS INITIALLY TOLD BY A MECHANIC ABOUT THE TORQUE CONVERTER, THEN HAD TO REPLACE THE TRANSMISSION. *TR

DRIVING ON FREEWAY AT 60MPH THE VAN JUST STOPPED ACCELERATING, THE RPM ACTED CRAZY. WE PULLED TOO SIDE OF ROAD AND WOULD NOT MOVE IN ANY GEAR. I HAVE HAD ROUTINE OIL CHANGES AND MAINTENANCE, THERE WAS NO SIGNS OR WARNING OF ANY TRANSMISSION PROBLEMS. VEHICLE TOWED. I HAVE BEEN TOLD MY VAN NEEDS NEW TRANSMISSION. *TR

I WAS DRIVING DOWN THE ROAD AND THE VEHICLE DROPPED OUT OF GEAR AND LOSS ACCELERATION. IT WOULD NOT GO BACK INTO GEAR. *KB

2004 FORD FREESTAR LOST ALL ACCELERATION AND STOPPED ON MAJOR ROADWAY. NO PREVIOUS SIGNS OF TROUBLE FROM TRANSMISSION. CLASS ACTION FILED IN US DISTRICT COURT AUGUST 2010 DECLARING FAULTY MANUFACTURING. FORD REFUSING TO REPAIR WITHOUT FULL PAYMENT OF $3200. CURRENT MILEAGE 94,000. HOW MANY MUST GET ROBBED BEFORE THIS IS ADDRESSED? *KB

TRANSMISSION ISSUES HAD TO BE REPLACE, CHECK ENGINE LIGHT WILL NOT TURN OFF. I HAVE READ MANY REPORTS ONLINE ABOUT ISSUES WITH THE TRANSMISSION IN THE 2004 FORD FREESTAR, SENSOR LIGHT ISSUES, TRACKING LIGHT ISSUES. NO WARNING TRANSMISSION JUST DIED 200 MILES FROM HOME. *TR

THE MAIN ENGINE COMPUTER (ECM, PCM, AKA EEC) CONSTANTLY GETS WET DUE TO A DESIGN FLAW. WATER DRIPS DOWN ON THE COMPUTER AND WILL CAUSE THE ENGINE JUST TO DIE WHILE DRIVING THE CAR ON THE HIGHWAY. THIS CAUSES A VERY DANGEROUS SITUATION! *TT

TL*THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED WITHOUT ANY WARNING. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO THE RESIDENCE HOME. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR HAD IT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THEY WERE UNAWARE OF THIS FAILURE WITH HIS YEAR, MAKE AND MODEL VEHICLE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 80,700.

TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE WOULD STALL WITHOUT WARNING WHEN DRIVING VARIOUS SPEEDS. THE VEHICLE WOULD RESTART SPORADICALLY OR THE CONTACT WOULD HAVE THE VEHICLE TOWED. IN ADDITION, THE VEHICLE WOULD ALSO START INDEPENDENTLY WITHOUT THE KEY BEING IN THE IGNITION. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO ADVISED THAT WATER HAD ENTERED THE COMPUTER CORRODED THE SYSTEM WHICH CAUSED THE FAILURE. THE CONTACT CONFIRMED THAT THE FAILURE WOULD MOST RECUR WHEN THERE WAS RAINY WEATHER. THE MANUFACTURER WAS CONTACTED WHO OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 90,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 87,000.

TL-THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT WHEN DRIVING IN INCLEMENT WEATHER THE WATER ENTERS INTO THE ELECTRIACL SYSTEM AND STALLS THE VEHICLE. THIS FAILURE HAS OCCURRED ON 7 DIFFERENT OCCASIONS. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY WOULD GET THE WATER OUT AND BLOW DRY THE WET AREA. THEY ALSO ADVISED HER THAT THERE WAS NO OTHER SOLUTION. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE AND ARE NOT AWARE OF THIS OCCURRING IN OTHER VEHICLES. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE. TB

WHEN DRIVING OUR VAN IT STARTED TO JERK AND THE ENGINE LIGHT STARTED FLASHING. IT THEN STALLED OUT ON US. IT WAS RAINING THAT DAY AND IT CONTINUED TO DO THIS. THE NEXT DAY WHEN THE RAIN STOPPED IT QUIT AND RAN FINE, BUT STARTED AGAIN THE MINUTE WE HIT ANY MOISTURE. THE COMPUTER IN THE VAN ALSO STARTED SENDING ERROR MESSAGES CONSTANTLY, CHECK BRAKE FLUID, CHECK OIL, CHECK REAR BRAKE LIGHTS, CHECK TRACTION CONTROL, CHECK DOORS AND SO ON WHEN THESE THINGS WERE CHECKED THERE WERE NO PROBLEMS WITH THEM. THE ENGINE LIGHT CONTINUED TO FLASH SO WE HAD SOMEONE LOOK AT IT AND FIX IT. THEY TOLD US THE COIL PAK WAS BAD AND REPLACED IT FOR US. THE VAN RAN FINE FOR 1 WEEK AND THEN THIS STARTED AGAIN. SO WHEN I WENT ONLINE TO DO SOME RESEARCH ON THIS I FOUND A SITE ON TOPIX, COMPLAINTS...

2004 FORD FREESTAR ENGINE CONTROL MODULE COMPUTER DIE @ ABOUT 80000 MILES TRANMISSION FAIL AT ABOUT 65000 MILES DEFECTIVE OE CONFORMAL COATING IS REMOVED FROM THE ENTIRE ECM BOARD INCLUDING UNDERNEATH CHIPS AND REPLACED WITH UPGRADED CONFORMAL COATING; CORRECTS AN OE DESIGN FLAW AND ENSURE CHIPS WILL NOT LIFT FROM THE BOARD CAUSING THE UNIT TO FAIL. *TR

TL*THE CONTACT OWNS A 2004 FORD FREESTAR. THE VEHICLE STALLED INTERMITTENTLY WHILE DRIVING APPROXIMATELY 20 MPH. THE CHECK ENGINE LIGHT ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC SEVERAL TIMES. THE MECHANIC REPLACED THE GAS FILTER, AND CAM SENSOR TWICE, BUT FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE FAILURE WAS CAUSED BY THE POWER CONTROL MODULE. THE ESTIMATED REPAIR COST WAS $940.00. REPORT 1898911628 WAS FILED WITH THE MANUFACTURER. THE MANUFACTURER STATED THAT THEY HAVE NOT RECEIVED ANY RELATED COMPLAINTS. THE FAILURE MILEAGE WAS 79,000 AND THE CURRENT MILEAGE WAS 80,800.

MY 2004 FREESTAR SUDDENLY QUIT RUNNING LAST WEEK. THERE WAS VERY LITTLE FORWARD POWER AND NO REVERSE POWER. IT ALSO BEGAN SITTING AND SPUTTERING TERRIBLY AND WOULD NOT START. I MADE IT TO THE EDGE OF TRAFFIC. IT HAD BEEN WET AND RAINY ALL WEEK. NOW THAT THE WEATHER IS DRY THE VAN STARTS. THIS IS AN ONGOING ISSUE. I HAVE ALREADY REPLACED THE TRANSMISSION ONCE. *TR

I NOTICED THE NHTSA MAY HAVE OPENED A PROBE ON THE 2004 FORD FREESTAR TRANSMISSION ISSUE. THE TRANSMISSION HAS FAILED TWICE AT 65,000 MILES , ONCE WITH MY WIFE DRIVING ALONE AT NIGHT AT HIGHWAY SPEED, AND THE SECOND TIME WITH MY 17 YEAR OLD DAUGHTER DRIVING AT NIGHT WITH FRIENDS. BOTH TIMES CREATED EXTREMELY DANGEROUS SITUATIONS TO THE OCCUPANTS AND FELLOW DRIVERS ON THE ROAD AROUND THEM. THE FIRST THE TRANSMISSION FAILED AT 65 MPH, LOST POWER COMPLETELY. AT THE TIME I HAD THE VAN TOWED TO LINDSAY FORD IN WHEATON, MD AND THE TORQUE CONVERTER REPLACED FOR $2,200. TWO MONTHS LATER THE INCIDENT OCCURRED AGAIN WITH MY DAUGHTER DRIVING AND WE HAD IT TOWED TO THE DEALER AGAIN AND THEY "COULD NOT DUPLICATE THE PROBLEM AND SAW NO CODES"- PAID ANOTHER $300 FOR "CAMSHAFT SENSOR REPLACEMENT" THIS IS AN EXTREMELY DANGEROUS SITUATION. I HAVE HEARD THIS ISSUE HAS...

DRIVING DOWN A SMALL HILL, CAME TO A COMPLETE STOP. MADE A RIGHT HAND TURN STARTED TO ACCELERATE AND LOST ALL POWER. DRIFTED TO THE LEFT HAND SIDE OFF THE ROAD AND CAME TO A COMPLETE STOP IN THE LEFT DRIVE LANE OF THE HIGHWAY. VERY DANGEROUS SPOT TO BE IN. *TR

TL*THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING 45 MPH, THE FRONT DRIVER'S SIDE TIRE SHOOK HEAVILY. THE CONTACT ALSO HEARD A VERY LOUD NOISE COMING FROM THE ENGINE. SHE TOOK THE VEHICLE TO A MECHANIC AND WAS INFORMED THAT A NEW HUB ASSEMBLY AND WHEEL BEARINGS WERE NEEDED. THROUGH ONLINE RESEARCH, THE CONTACT DISCOVERED NHTSA CAMPAIGN ID NUMBER 04V446000 (WHEELS:CAP/COVER/HUB). THE MANUFACTURER STATED THAT THE WARRANTY WAS EXPIRED ON HER VEHICLE AND THAT THE RECALL WAS NEVER REPAIRED ON HER VEHICLE. IT WAS UNKNOWN WHETHER OR NOT HER VIN WAS INCLUDED IN THE RECALL. THE VEHICLE HAS NOT YET BEEN REPAIRED, BUT THE CONTACT BELIEVES THAT THE VEHICLE SHOULD BE REPAIRED ACCORDING TO THE RECALL SINCE THE FAILURES ARE IDENTICAL. THE FAILURE MILEAGE WAS 90,000 AND CURRENT MILEAGE WAS 98,000.

AT APPROX. 60K MILES, WHILE DRIVING AT STEADY SPEEDS BETWEEN 40-45MPH AND 55-65 MPH, THE ENGINE WILL STUTTER/HESITATE FOR LESS THAN A SECOND. THE OCCURS AT RANDOM BUT SEEMS TO BE INCREASING IN FREQUENCY AND INTENSITY LATELY. FROM THE HUNDREDS OF COMPLAINTS, THE MOST LOGICAL IN MY VIEW ARE A FAILED COIL PACK; THE PCM MODULE OR A TRANSMISSION SENSOR. MY RESEARCH ALERTED ME TO THE HUNDREDS OF UNEXPECTED TRANSMISSION FAILURES THAT OCCURRED WITHOUT ANY PRIOR WARNING. WE ARE SENIOR CITIZENS AND LIVE AND COMMUTE IN A VERY RURAL AREA. IF WE HAD A TRANSMISSION FAILURE AS HAS BEEN REPORTED/DESCRIBED REPEATEDLY, OUR SAFETY AND WELFARE WOULD BE SERIOUSLY AT RISK. WE DON'T HAVE ANOTHER $30K TO REPLACE THIS VAN, SO WE ARE HAVING THE TRANSMISSION REBUILT AS A "PRE-EMTIVE" MEASURE. WE ARE ALSO REPLACING THE COIL PACK AT THIS TIME. THE DEALER IS TO EVALUATE THE OTHER SUSPECT COMPONENTS AND...

DOES ANYONE READ THESE? MY DAUGHTER POSTED A COMPLAINT OVER A YEAR AGO. I JUST READ THROUGH A NUMBER OF COMPLAINTS ABOUT THE 2004 FORD FREESTAR'S TRANSMISSION PROBLEMS. MY SON-IN-LAW PURCHASED THIS VAN FOR MY DAUGHTER FOR MOTHER'S DAY OF 2006 BECAUSE THEY WERE EXPECTING ANOTHER SON AND OUTGROWING THEIR JEEP GRAND CHEROKEE. IN THE WINTER OF 2006 IT STARTED ACTING UP. WE HAD TO GO GET THEM ON CHRISTMAS EVE AS THEY WERE BROKE DOWN ON THE SIDE OF A COUNTRY ROAD ON THEIR WAY TO OUR HOUSE FOR CHRISTMAS. IT WAS DIAGNOSED A CRANK SHAFT SENSOR. AFTER COMING UP WITH THE MONEY TO REPLACE THAT, IT WORKED FINE FOR A WHILE. STARTED AGAIN. THEY WERE TOLD THEY MOST HAVE GOT A FAULTY CRANK SHAFT SENSOR AND REPLACED IT AGAIN. SOME TIME LATER, IT STARTED AGAIN. THEY TOOK IT TO A TRANSMISSION SPECIALIST THAT REPLACED SOME MORE SENSORS. IT...

MY FAMILY AND I WERE STOPPED AT A STOP SIGN IN OUR 2004 FORD FREESTAR. WE TURNED LEFT AND ALMOST AT THE SAME INSTANT THE CAR'S ENGINE STARTED A REVVING NOISE AND (LUCKY FOR US) OUT OF THE INTERSECTION THE CAR WOULDN'T GO. WE WERE ALMOST SMASHED BY A TRUCK TURNING THE SAME CORNER. WE HAD THE CAR TOWED TO OUR FORD DEALERSHIP. I WAS DOING RESEARCH ON FORD FREESTARS AND FOUND THEY HAD TORQUE CONVERTER PROBLEMS. I CALLED THE DEALERSHIP BACK AND THEY COULDN'T GIVE ME ANY UPDATES. AT THIS TIME I TOLD THEM OF MY RESEARCH AND TOLD THEM IT'S PROBABLE THE TORQUE CONVERT. THEY CALLED BACK THE NEXT DAY AND CONFIRMED IT'S THE TORQUE CONVERTER. CALLED FORD CUSTOMER SERVICE AND THEY TOLD US IT'S NOT ON RECALL BECAUSE 'THERE HASN'T BEEN ENOUGH ACCIDENTS OR DEATHS." THERE WERE ALMOST 4 A WEEK AGO IN IL, LUCKY FOR MY...

TL*THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SPORADICALLY STALL WITHOUT WARNING. USUALLY WHEN THE VEHICLE STALLS, IT TAKES APPROXIMATELY 15- 30 MINUTES TO RESTART. THE VEHICLE WAS TAKEN TO THE DEALER ON THREE OCCASIONS, BUT THEY FAILURE COULD NOT BE DUPLICATED. THE FAILURE MILEAGE WAS 52,000 AND CURRENT MILEAGE WAS 57,000.

FAILURE OF CAM SENSOR, THEN COMPLETE FAILURE OF TRANSMISSION 2 WEEKS LATER. *TR

TL*THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 35-40 MPH, THE VEHICLE BEGAN TO HESITATE AND THE INSTRUMENTAL PANEL LIGHTING FLASHED. THE VEHICLE SHUT OFF A FEW MINUTES LATER AND WAS TOWED TO THE DEALER. THE DEALER STATED THAT WATER PENETRATED THROUGH THE WINDSHIELD WIPER MOTOR AREA AND CAUSED THE MAIN COMPUTERIZED SYSTEM TO FAIL. THE INSTRUMENT PANEL HAD TO BE REPLACED, THE GAS LINE HAD TO BE BLOWN OUT, AND THE SPARK PLUGS WERE REPLACED. THE INSURANCE COMPANY INVESTIGATION CONCLUDED THAT THE FAILURE WAS DUE TO A PRODUCT DEFECT. THE MANUFACTURER ACKNOWLEDGED RECEIVING THE CONTACT'S WRITTEN COMPLAINT; HOWEVER, THEY WOULD NOT ASSIST WITH THE $1,200 REPAIR COST THAT THE CONTACT HAD TO PAY. THE FAILURE MILEAGE WAS 58,502.

MRS. ATTEE WAS STARTING OUR FORD FREESTAR, WHEN SHE HEARD A CLICKING NOISE AND NOTICED WHAT SHE THOUGHT WAS SMOKE COMING FROM THE HOOD. SHE(MRS. ATTEE) THEN OPENED THE HOOD TO FIND A SMALL FLAME COMING FROM THE ENGINE, SHE PROCEED TO CALL THE FIRE DEPARTMENT. WITHIN 5 MINUTES THE VAN 'S ENGINE WAS ENGULFED IN FLAMES. WHEN THE FIRE DEPARTMENT ARRIVED IT WAS TO LATE, THE FIRE HAD ALREADY DONE ITS DAMAGE(TOTALED). *TR

WHILE DRIVING MY FORD FREESTAR THE ENGINE STARTED TO MISS. AFTER A SHORT DISTANCE IT DIED COMPLETELY. LUCKILY, I WAS ON A SIDE ROAD AND ABLE TO PULL TO THE SIDE OUT OF THE TRAFFIC. THE PROBLEM WAS THE RESULT OF A MANUFACTURING DEFECT ALLOWING WATER TO LEAK INTO THE ENGINE COMPARTMENT AND THEN INTO THE PCM DESTROYING IT. AT 29,000 MILES THE PCM HAD TO BE REPLACED WITHOUT ANY PAYMENT BY FORD. *TR