2005 FORD F-250 SD Suspensionfront Problems

2005 FORD F-250 SUPER DUTY, 69,000 MILES. TRAVELING APPROX 65 MPH, HIT A SMALL BUMP IN THE HIGHWAY AND THE FRONT SUSPENSION STARTED TO SHAKE UNCONTROLLABLY. I VERY NEARLY LOST COMPLETE CONTROL OF THE TRUCK. THIS NEVER HAPPENED BEFORE, BUT HAS HAPPENED TWICE SINCE. THE TIRE PRESSURE WAS CORRECT AT THE TIME OF THE FIRST INCIDENT, THE TIRES WERE BALANCED AND THE LUG NUTS WERE TORQUED TO FORD SPECS. REPLACED FRONT STEERING DAMPER, DID NOT RESOLVE THE PROBLEM. TALKED TO THE FORD DEALER AND THEY DENIED ANY KNOWLEDGE OF A SIMILAR PROBLEM. AFTER A FEW HOURS RESEARCH ONLINE, THIS PROBLEM IS WELL DOCUMENTED AND FREQUENT WITH THE FORD SUPER DUTY LINE FROM 05"-08". IT SEEMS TO BE AN ENGINEERING DEFECT AND FORD IS WELL AWARE OF THE PROBLEM, BUT IT DOES APPEAR THAT FORD HAS OFFERED ANY REMEDIES. THE NHTSA ALSO KNOWS OF THE PROBLEM. I VIEWED FOUR NHTSA VIDEOS...

2005 FORD F-250 SUPER CAB SUPER DUTY WOBBLE DANGEROUSLY WHEN DRIVING OVER THE SLIGHTEST RIPPLE OR BUMP IN THE ROAD OVER 50 MPH. EXTREMELY HARD TO CONTROL AND HARD TO STOP THE VEHICLE WHEN THE FRONT TIRES ARE SO OUT OF CONTROL AND WOBBLING. THE WHOLE TRUCK IS LIKE IT IS IN AN EARTHQUAK, WINDSHIELD CRACKS AND CUP HOLDERS FELL OUT. **TT

I HAVE HAD 3 INCIDENTS OF WHAT I HAVE FOUND TO BE CALLED THE "DEATH WOBBLE" IN MY 2005 F-250 4 DOOR CREW CAB 4 WHEEL DRIVE PICK UP TRUCK WHERE THE FRONT END OF THE VEHICLE GOES INTO A VIOLENT BOUNCING AND SHUDDERING AFTER PASSING OVER A BRIDGE JOINT OR SIMILAR UNEVEN SPOT ON THE HIGHWAY WHILE TRAVELING APPROX. 65 MPH. THIS RESULTED IN A NEAR LOSS OF CONTROL AND COULD NOT BE STOPPED UNTIL I WAS ABLE TO SLOW TO APPROX. 35MPH. THIS CAUSED A NEAR COLLISION WITH A VEHICLE ALONGSIDE ME AS WELL AS A NEAR REAR ENDING FROM THE VEHICLE BEHIND ME AS I HAD TO SLOW TO 35MPH IN THE HIGH SPEED LANE. EACH TIME THIS OCCURRED I HAD MY 2 YOUNG DAUGHTERS IN THE VEHICLE WITH ME. I HAVE READ THAT THERE IS A PROBLEM WITH THE TRACK BAR BEING AT AN IMPROPER ANGLE...

I OWN A FORD 2005 CREW CAB SUPER DUTY, THE VEHICLE SHAKES VIOLENTLY THROUGH THE FRONT END, HAVE TAKEN THE TRUCK TO FORD DEALERSHIP FOR "REPAIR" BUT IT DID NOT SOLVE THE PROBLEM. *TR

DRIVING AT HIGHWAY SPEEDS , THE TRUCK SHAKES VIOLENTLY AFTER HITTING A BUMP . THE ISSUE IS COMMONLY REFERRED TO AS A DEATH WOBBLE . YOU SLOW DOWN TO ABOUT 45 MPH OR SLOWER & IT STOPS . YOU CAN THEN RESUME YOUR TRIP . *TR

I RECENTLY PURCHASED A FORD 2005 F250 SUPER DUTY TRUCK. WHILE DRIVING ON THE HIGHWAY AT 70 MPH, I HIT AN UNEVEN SPOT ON THE ROAD THAT CAUSED THE FRONT END TO WOBBLE VIOLENTLY. I FELT I COULD NOT CONTROL THE TRUCK AND HAD TO APPLY THE BRAKES IMMEDIATELY. LUCKILY THERE WERE NO OTHER CARS NEARBY. WHEN THE TRUCK REACHED APPROXIMATELY 30 - 35 MPH, THE WOBBLE CEASED. ON MY WAY BACK HOME, THE WOBBLE OCCURRED AGAIN. THIS TIME I WAS TRAVELING AT 60 - 65 MPH AND HIT ANOTHER ROUGH SPOT ON THE ROAD. THIS IS A MAJOR SAFETY HAZARD THAT NEEDS TO BE RESOLVED BEFORE SOMEONE IS KILLED. I RESEARCHED THE PROBLEM ON THE INTERNET AND DISCOVERED THIS HAS BEEN ONGOING FOR A WHILE. THERE ARE NUMEROUS EXAMPLES FROM OTHER F250 AND F350 OWNERS WITH THE SAME PROBLEM THAT CAN BE FOUND ON THE INTERNET. THE FORD MOTOR...

FRONT SHAKES VIOLENTLY AT TIMES ON MY 2005 FORD F-250. FEELS LIKE THE WHOLE FRONT END OF THE TRUCK IS SHAKING APART. THE ONLY WAY I HAVE FOUND TO STOP IT IS TO DRASTICALLY SLOW DOWN MY TRUCK, WHICH IS A HUGE SAFETY HAZARD WHEN OTHER VEHICLES ARE FOLLOWING BEHIND ME. I SOMETIMES HAVE TO SLOW FROM 55 MPH TO 35 MPH. UPDATED 07/08/10 *BF UPDATED 07/09/10.*JB *TR

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH OVER A ROUGH PATCH ON THE ROAD, THE FRONT END OF THE VEHICLE SHOOK AND VIBRATED AND SEEMED AS IF IT WOULD LOSE CONTROL. THE FAILURE OCCURRED INTERMITTENTLY AND ALWAYS OCCURRED ON DRY PAVEMENT. THE VEHICLE WOULD FUNCTION NORMALLY IF IT WAS SLOWED TO APPROXIMATELY 30 MPH. THE FAILURE MILEAGE WAS APPROXIMATELY 25,000. THE CURRENT MILEAGE WAS APPROXIMATELY 25,500.

EXPERIENCED STEERING SHIMMY AT HIGHWAY DRIVING SPEEDS ON MULTIPLE OCCASIONS WHILE PULLING A TRAVEL TRAILER AND WHILE NOT PULLING A TRAILER. RESULTS IN VIOLENT VIBRATION OF THE ENTIRE VEHICLE TO THE POINT OF BEING DIFFICULT TO CONTROL. *TR

I HAVE A FORD F-250 PICK UP. SINCE I BOUGHT THE VEHICLE NEW, IT HAS HAD A HARD SUSPENSION. I THOUGHT IT WAS BECAUSE IT WAS BEEFIER THAN THE F-150S I HAVE DRIVEN ALL MY LIFE. THE 250 HOWEVER, WILL SHIMMY AND VIBRATE UNCONTROLLABLY AFTER GOING OVER A BUMP OR HIGHWAY SEAM AT SPEEDS BETWEEN 50 AND 75 MILES PER HOUR. THE DEALER TOLD ME IT WAS NORMAL AND FORD SENT A LETTER SAYING IT MAY BE THE AIR PRESSURE IN THE TIRES. IT IS NEITHER. THIS TRUCK IS HIGHLY UNSAFE TO DRIVE.*TR

2005 FORD F-250 CREW CAB 4X4, V-10, 56000 MILES. FRONT SUSPENSION WOBBLES AND STEERING WHEEL SHAKES WHEN HITTING POTHOLES OR ANY SORT OF GOOD BUMP AT SPEEDS 30 MPH AND ABOVE. NEW LARGER TIRES, 265/75/17 ONLY AMPLIFIES THIS PROBLEM TO AN UNCONTROLLABLE STATE AT HIGHWAY SPEEDS OF 65+. WHEN THE PROBLEM OCCURS, IT FEELS LIKE I AM DRIVING DOWN A WASHBOARD DIRT ROAD AT HIGH SPEED WITH THE STEERING WHEEL SHUTTERING UNCONTROLLABLY. I NEED TO SLOW THE TRUCK DOWN TO 50 OR SO JUST TO GET CONTROL BACK. TIRE PRESSURES ARE AT RECOMMENDED SPECS. WHEN DRIVING UNDER CONTROL AND STRAIGHT, THE STEERING WHEEL HAS A LOT OF SLOP LEFT TO RIGHT. I BOUGHT THIS TRUCK NEW IN FEB 05 AND I AM THE ORIGINAL OWNER. *TR

2005 F250 4X4 SUPER CREW BOUNCES VIOLANTLY WHILE DRIVING, HAPPENS FREQUANTLY, GOING TO TAKE IT TO FORD, BASED ON FORUMS,LOOKS TO BE A PROBLEM FOR MORE PEOPLE THAN JUST ME.

2005 F250 4X4 SUPERDUTY 5.4L CREW CAB, HAS VERY DANGEROUS FRONT WHEEL BOUNCE ON HIGHWAY OR NEAR HIGHWAY SPEEDS(50-70)MPH, THE TRUCK WAS IN STOCK CONFIGURATION WHEN THIS STARTED, APPROX. 26,000 MILES HAVE SINCE PUT LIFT KIT ON TRUCK AND HAS HELPED BUT THE BOUNCE TENDENCY IS STILL THERE.LARGER WHEELS AND TIRES HAVE HELPED OUT LOT, WITH THE FACTORY WHEELS/TIRES ON ITS A FOR SURE THING WHEN ON HIGHWAY AND COME ACROSS SERIES OF BUMPS OR A POTHOLE. I AVOID THE HIGHWAY WHEN POSSIBLE DUE TO THE VERY VIOLENT BOUNCE WHEN THIS OCCURS, PLEASE HAVE FORD FIX THIS PROBLEM. SELLING THIS TRUCK WILL NOT FIX PROBLEM, AND I HAVE TRIED DEALER SUGGESTIONS I.E AIR PRESSURE, ALIGNMENT... WAITING FOR FORD TO CORRECT THIS WITH RECALL, BUT NONE THAT I'M AWARE OF, WILL DEATH TO A MOTORIST PROMPT RECALL? I HOPE NOT, THANK YOU *TR

NEAR COMPLETE LOSS OF CONTROL WHILE DRIVING AT 55-60 MILES AN HOUR ON FLAT FREEWAY. SMALL BUMP SENT TRUCK INTO SHUTTERING WOBBLE. NO STEERING ALMOST NO BRAKES TOOK SEVERAL HUNDRED YARDS TO SLOW DOWN TO ABOUT 10-15 MPH AND REGAIN CONTROL OF VEHICLE. *TR

I HAVE A FORD F250 SD DIESEL 2WD TRUCK I HAVE REPLACE THE FRONT WHEEL BEARING 4 TIME IN 137,000 MILES. THE DEALER SAYS IT IS WATER AND DIRT INTRUSION. IT HAS NOT CAUSED ANY ACCEDENTS YET BUT IT IS ONLY A MATTER OF TIME. *CN

2005 FORD F250 SUPER DUTY 4X4. VIOLENT SHAKING AFTER HITTING A SMALL DEFORMED PART OF THE ROAD, SLOW VEHICLE TO 10 MPH TO STOP THE SHAKING. HAVE LOST CONTROL OF THE VEHICLE 2 TIMES IN THE LAST WEEK. I HAVE TAKEN IT TO THE SHOP AND NO ONE COULD FIND ANYTHING WRONG WITH THE VEHICLE. *TR

I HAVE A 2005 FORD F250 SD AND I HAVE HAD THE FRONT END SHIMMY OUT OF CONTROL ON ME 2 TIME. I HAVE STOCK TIRES ON IT TIRE PRESSURE IS AT MANUFACTURERS SPECS AND THIS IS JUST EXTREMELY DANGEROUS SOMEONE IS GOING TO GET KILLED BUY THIS. FORD OR SOMEONE NEEDS TO FIX THIS PROBLEM . THANK YOU [XXX] *TR PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*CC

FRONT END WHEEL SHIMMY. *TR

I OWN A 05 FORD F250SD TRUCK. WHILE DRIVING AT SPEEDS OF AROUND 50 AND UP WHEN I RUN OVER A POT HOLE OR ROAD ROUGHNESS THE FRONT END SHAKES VIOLENTLY.I HAVE TO SLOW DOWN VERY QUICKLY UNTIL IT STOPS AND THEN I CAN PROCEED. I TOOK IT TO THE FORD DEALERSHIP AND WAS TOLD TO REPLACE THE TIRES. I BOUGHT NEW TIRES AND IT FIXED THE PROBLEM FOR 6000 MILES. THAT'S WHEN I ROTATED THE TIRES. IT HAS BEGUN SHAKING AGAIN. THIS IS VERY DANGEROUS. IF I WERE IN HEAVY TRAFFIC WHEN IT OCCURRED I COULD WRECK. LOOKING UP THIS PROBLEM ON INTERNET I FOUND THIS IS A COMMON PROBLEM AMONG ALL NEWER MODEL FORD TRUCKS YET THERE IS NO RECALL FOR THIS. *TR

I HIT A SMALL POTHOLE TRAVELING ON I-295 AT 65 MPH. THE TRUCK BOUNCED OUT OF CONTROL AND DRIFTED INTO THE LEFT LANE. I BRAKED TO 35 MPH AND IT STOPPED. A SHOP MECHANIC SAID IT WAS OK. THE SAME THING OCCURRED RECENTLY ON I-64. HIT A ROAD PATCH AND BOUNCED TO A STOP. MY WIFE WAS HORRIFIED AT THE VIOLENT SHAKING. A MASTER MECHANIC COULD NOT FIND ANYTHING WRONG. THIS ONLY HAPPENS AT HIGH SPEEDS ABOVE 60 MPH. *TR

WHILE DRIVING DOWN THE INTERSTATE AT SPEEDS BETWEEN 65 AND 80 MPH AND WHILE GOING OVER ROAD BUMPS, THE FRONT-END WILL BEGIN TO VIBRATE TO THE POINT THAT ENTIRE TRUCK WILL SHAKE. AFTER SLOWING TO 45 MPH, THE SITUATION WILL SELF-CORRECT ONLY TO BEGIN AGAIN AFTER CROSSING ANOTHER BUMP OR CONCRETE BRIDGE. NO CRASHES/INJURIES HAVE BEEN NOTED THUS FAR. THIS IS THE 5TH TIME IN A PERIOD OF 48 HOURS THIS HAS HAPPENED. I HAVE FOUND NUMEROUS REPORTS ONLINE OF OTHERS EXPERIENCING THE SAME PROBLEM AND NONE HAVE FOUND A RESOLUTION. THIS IS A 2005 F-250 SUPERCREW 4X4. *TR

I HAVE A 2005 FORD F250 SD PICKUP TRUCK THAT HAS 25,000 MILES ON IT. I HAS BEGUN TO EXPERIENCE A VIOLENT FRONT END SHAKING AT HIGHWAY SPEED WHEN GOING OVER EVEN THE SMALLEST OF BUMPS. YOU NEED TO ALMOST STOP IN THE MIDDLE OF THE HIGHWAY TO MAKE IT STOP. THE DEALER SAYS THEY DON'T KNOW OF ANY PROBLEMS AND SO DOES FORD. BUT LOOKING ON-LINE IT IS VERY OBVIOUS THAT THIS IS A REAL ISSUE AND NEEDS TO BE RECALLED. IT IS ALSO REFERENCED AS "DEATH WOBBLE". *TR

FRONT END INSTABILITY, EXTREME VIBRATION, LOSS OF STEERING AT HIGHWAY SPEED AFTER HITTING ROUGH PAVEMENT. HAVE HAD VIBRATION AND BOUNCE IN FRONT END SINCE VEHICLE WAS PURCHASED NEW DEC 2004. REPEATED RETURN TO DEALERSHIP BUT UNABLE TO FIND POINT CAUSE. APRIL 25, 2005 CRUISE CONTROL AT 75MPH ON I4 FLORIDA ROUGH ASPHALT TRIGGERED SEVERE SHIMMY AND VIBRATION, LOSS OF STEERING (UNABLE TO PULL TO SAFETY LANE). CONTROL REGAINED ONLY BY BRAKING IN BUSY HIGHWAY SPEED TRAFFIC UNTIL VIBRATION CEASED. TIRES ARE NEW, ROTATED AT 3,000 AND KEPT AT FACTORY PRESSURE. THESE EVENTS HAVE OCCURRED SPORADICALLY SINCE PURCHASE IN DEC 2004. *TR

UNPREDICTABLE AND UNCONTROLLABLE SEVERE FRONT END VIBRATION AND OSCILLATION, CAUSING LOSS OF CONTROL OF VEHICLE. OCCURS RANDOMLY AND WITHOUT WARNING, AT FREEWAY SPEEDS. HAS RESULTED IN RUNNING ONTO THE SHOULDER OF THE ROADWAY AND SEVERAL NEAR COLLISIONS WITH OTHER VEHICLES. VEHICLE HAS BEEN INSPECTED AND REPAIRS ATTEMPTED ON SEVERAL OCCASIONS. DEALERSHIP ADVISES THAT THIS IS INHERENT TO YEAR, MAKE AND MODEL OF VEHICLE; AND CANNOT REPAIR THE PROBLEM. *TR

VEHICLE SHAKES VIOLENTLY WHEN GOING FASTER THAN 55 MILES AN HOUR AND HITTING A SMALL BUMP IN THE ROAD. HAVE TO SLOW DOWN IN ORDER FOR THE TRUCK TO STOP SHAKING PUTTING ALL PASSENGERS IN DANGER ON THE HIGHWAYS. *TR

THIS IS A FOLLOW UP TO A COMPLAINT I FILED ON 4/14/09 COMPLAINT # 10265310. I HAVE LOOKED INTO THIS MATTER AND FOUND OTHER CASES. THIS IS A SERIOUS PROBLEM THAT SHOULD BE ADDRESSED. HERE IS A LINK WITH MORE INFORMATION. HTTP://WWW.TOPIX.COM/FORUM/AUTOS/FORD-F-250-SUPER-DUTY/TOHP1M75VBFBFT9IL. *TR

I HAVE A 2005 FORD F-250 SUPERDUTY 4X4. I HAVE EXPERIENCED FRONT WHEEL SHIMMY 3 TIMES . I TOOK THE TRUCK TO A DEALERSHIP. THEY PUT ON A NEW FRONT STEERING SHOCK ABSORBER BUT IT OCCURRED AGAIN AFTER THE REPAIR. *TR

MY 2005 FORD F-250 SUPER DUTY POWERSTROKE DIESEL CREW CAB PICK UP TRUCK SHAKES AND SHIMMIES VIOLENTLY WHEN THE FRONT END HITS A POT HOLE OR TRAVELS OVER A ROAD SURFACE VARIATION. I HAVE HAD 4 INCIDENTS WHERE ON THE FREEWAY TRAVELING AT SPEEDS IN EXCESS OF 65 MPH THE VEHICLE BEGAN SHAKING AND SHIMMYING SO VIOLENTLY THAT THE TRUCK CHANGED LANES AND WAS BEYOND MY ABILITY TO CONTROL THE VEHICLE. I WAS FORCED TO TAKE EMERGENCY ACTION AND EXIT THE ROADWAY. ON ONE OCCASION THE TRUCK STRUCK A FENCE POLE ADJACENT TO THE ROAD WAY AFTER HITTING A GROOVE IN THE ROAD AT A SPEED OF 45 MPH. *TR

LOSE OF STEERING DO TO POOR DESIGN OF FORD F-250 AND F-350 SOLID FRONT AXLE WITH SPRINGS. FROM 2005 TO PRESENT. I HAVE NEW TIRES AND RIMS,BALANCED,HAD FRONT END CHECKED FOR ALIGNMENT, MY TRUCK LIKE SO MANY OTHERS ARE HAVING SEVER FRONT END SHIMMY DO TO THE POOR DESIGN ON FORD TRUCKS. I HAVE CONTACTED LEGAL ADVICE FROM THE ADVICE OF OTHER GOVERNMENT AGENCIES. THE ATTORNEY GENERALS OFFICE,BBB, AND THE CONSUMER PROTECTION AGENCY. THIS IS MY SECOND COMPLAINT ABOUT THIS MATTER, AND IM A LITTLE UPSET TO KEEP GETTING THE ONLY RESPONSE YOU AND THE FORD CO. CAN COME UP WITH, TIRE PRESSURE!!! COME ON YOU KNOW ITS THE POOR DESIGN OF THERE FRONT ENDS. I'VE SPENT THOUSANDS TO HELP DEAL WITH MATTER TO NO BETTER RESULTS. SO FROM HERE I WILL SEEK LEGAL HELP TO PROTECT MY FAMILY AND MYSELF FROM POSSIBLE SEVERE INJURY OR DEATH. I HOPE FORD...

WHILE DRIVING VEHICLE WILL START TO SHAKE, EVEN WORSE IF I HIT A BUMP IN A CORNER. HAVE TO STOP FOR IT TO GO AWAY. *TR

I OWN A FORD F-250 SUPER DUTY[2005] WITH 14,000 MILES ON IT. I HAVE HIT A SERIES OF SLIGHT BUMPS TRAVELING ON THE GARDEN STATE PARKWAY TRAVELING AT ABOUT 65 MPH. THE FRONT END OF THE TRUCK AND STEERING WHEEL SHOOK SO VIOLENTLY, I THOUGHT THE FRONT END OF THE TRUCK DIS-ENGAGED FROM THE REST OF THE BODY. THE STEERING WHEEL SHOOK SO VIOLENTLY I COULD HARDLY HOLD ON TO IT. I TOOK MY FOOT OFF THE GAS AND APPLIED THE BREAK VERY GENTLY. I MUST HAVE SLOWED DOWN TO 30 MPH BEFORE THE TRUCK BECAME UNDER CONTROL AGAIN. MEANWHILE THE CAR BEHIND ME HAD TO SLAM ON HIS BREAKS DO TO MY TRUCK BEING OUT OF CONTROL AND THE RAPID DE-ACCELERATION ON A MAJOR HIGHWAY. I HAD TO PULL OVER AS SOON AS I WAS ABLE TO CHECK WHAT I THOUGHT WOULD BE MAJOR FRONT END DAMAGE. AFTER ALL,...

DRIVING AT SPEED. 2005 FORD F-250 VIOLENT FRONT END DEATH WOBBLE, DEALER SAID IT NEEDED ALIGNMENT, THEN SAID IT WAS MY TIRES,WITH NEW TIRES IT STILL DID IT. DEALER SAID THAT IT WAS OKAY. NOTHING WRONG. UNTIL YESTERDAY WHILE DRIVING TO INTER FREEWAY,AT 45MPH SLIGHT ROUGH ROAD SENT MY FORD TRUCK INTO VIOLENT DEATH WOBBLE ALMOST CAUSED AN ACCIDENT, BY HITTING CONCRETE BARRIER. LOST TOTAL CONTROL OF MY TRUCK. I'VE CONTACTED LEGAL COUNSEL TO SEE WHAT MY OPTIONS WILL BE, ALSO INFORMED TO MAKE CONTACT WITH DEALER SHIP TO SEE WHAT THEY INTEND TO DO. I HAVE EXTENDED WARRANTY ON MY TRUCK. DOES THIS FALL UNDER WARRANTY? OR LAW SUIT? *TR

FRONT END BOUNCES UNCONTROLLABLY AT HI WAY SPEEDS UNTIL YOU STOP , IF STILL ON THE ROAD. *TR

WHILE DRIVING ON THE HIGHWAY AT AROUND 60 MPH I HIT A SMALL BUMP IN THE ROAD, A NORMAL SEAM IN THE MACADMN. MY TRUCK STARTED TO SHAKE VIOLENTLY. I HAD VERY LITTLE TO NO CONTROL OF THE STEERING, AND THE BRAKING WAS ALSO VERY POOR. THE TRUCK SHOOK SO BAD THAT IT IMPAIRED MY VISION ALL I COULD DO WAS LET OFF THE ACCELERATOR AND HOLD ON TO THE STEERING WHEEL. THE TRUCK DRIFTED INTO THE LEFT LANE WHILE SLOWING. AROUND 35-40 MPH THE SHAKING WENT AWAY AND THE TRUCK ACTED NORMAL. I PULLED OFF THE ROAD AND INTO A MALL PARKING LOT AND CHECKED UNDER THE TRUCK FOR ANYTHING OBVIOUSLY WRONG AND FOUND NOTHING. I DROVE MY TRUCK HOME ABOUT 10 MILES NO MORE PROBLEMS. WHAT A VERY SCARY EPISODE. *TR

I HAVE A 2005 F-250 THAT HAS A VIOLENT FRONT END SHAKE AT AROUND 60MPH AFTER HITTING A RUT OR SMALL POTHOLE, PROBLEM DOES NOT GO AWAY UNTIL I SLOW DOWN. TAKEN TO DEALER AND THEY: "INSTALLED UPDATED STEERING DAMPENER AND BRACKET PER 07-10-10 RETORQUED SUSPENSION FASTENERS.... R&R LONG AND SHORT DRAG LINK CHECK TOE RECENTER STEERING WHEEL. THE SAME PROBLEM DEVELOPED SHORTLY AFTER. I WILL BE TAKING TO DEALER AGAIN. *TR

SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AFTER HITTING UNEVEN ROAD SURFACE, DOING ABOUT 55MPH. THE SHAKING IS SO BACK IT THROWS THINGS OUT OF THE VISOR AND STUFF OFF OF THE SEAT ON TO THE FLOOR. TODAY WAS THE SECOND TIME THIS HAS HAPPEN. THIS IS A 2005 F250SD WITH 20789 MILES ON IT AND THIS IS JUST STARTING TO DO THIS. BOTH TIMES THIS HAPPEN HAD ENOUGH ROAD SHOULDER TO PULL OVER AND STOP. IF THIS HAPPEN ON A NARROW SHOULDER FREEWAY BRIDGE OR CONCRETE BARRIER I WOULD PROBABLY HIT SOMEONE OR SOMETHING. FORD NEEDS TO DO SOMETHING ABOUT THIS BEFORE SOMEONE DIES, THEN THERE WILL BE LAW SUITS. *TR

OUR COMPANY HAS 3 2005 F-250 WORK TRUCKS AND THE ALL HAVE THE SAME PROBLEM ,WHEN YOU REACH APPROX. 55MPH YOU GET A VIOLENT SHAKE FROM THE FRONTEND,AND OR IF YOU HIT A POTHOLE IT IS VERY DANGEROUS, LIKE YOUR GOING TO LOSE CONTROL DUE TO THE SHAKING AND NOBODY CAN FIND A TOTAL FIX TO THE PROBLEM,I THINK FORD SHOULD HAVE A RECALL OR SOMETHING! *TR

VIOLENT SHUDDER AND STEERING OSCILLATION. THIS FIRST HAPPENED AFTER DRIVING OVER A SLIGHT DROPOFF AT ABOUT 60MPH AND THE WHOLE TRUCK SHUDDERED SO VIOLENTLY I HAD TO BRAKE AND ATTEMPT TO STEER THE VEHICLE TO THE MEDIAN (THIS WAS HARD TO DO). THIS HAS HAPPENED FREQUENTLY SINCE AND HAPPENS AT LOW SPEEDS ALSO (40MPH) THE STEERING WHEEL HAS BEEN SHAKEN OFF CENTER DUE TO THIS. MY WIFE WILL NOT DRIVE THE VEHICLE AS ITS QUITE SCARY WHEN THIS HAPPENS AT RELATIVELY HIGH SPEEDS AND IS VERY SUDDEN AND UNEXPECTED, I ALSO WILL NOT ALLOW MY CHILDREN TO RIDE IN THE VEHICLE AS I FEEL A BAD EPISODE OF THIS SHIMMY/SHUDDER COULD EASILY CAUSE AN ACCIDENT. I HAVE ALSO GONE THROUGH 5 SETS OF TIRES (IN UNDER 70,000 MILES) DUE TO BEING UNABLE TO KEEP THE FRONT END ALIGNED. I WAS QUITE UPSET AFTER THE FIRST INCIDENT AND IMMEDIATELY BROUGHT THE...

TSB FRONT END OSCILLATION IIRC. OR AS KNOWN ON THE INTERNET AS THE DEATH WOBBLE (WHICH SEEMS VERY FITTING AS THE TRUCK GOES COMPLETELY OUT OF CONTROL, IT FEELS AS IF THE WHOLE FRONT END IS COMING APART!)? SEVERE SHAKING AT HIGH SPEEDS OR ON ROUGH ROADS-JUST DRIVING ALONG AND ALL OF THE SUDDEN SEVERE SHAKING OCCURS SO SEVERE THAT THIS COULD CAUSE AN ACCIDENT, ALMOST LIKE BOTH FRONT TIRES BLOW OUT AT THE SAME TIME, SEVERE STEERING DIFFICULTIES WHEN THIS HAPPENS, IF YOU COME TO A COMPLETE STOP AND THEN TAKE OFF IT STOPS?INTERMITTENT BUT INCREDIBLY DANGEROUS! HAS HAPPENED 3 TIMES WITHIN THE LAST 2 WEEKS?ONCE ON A GRAVEL ROAD, ONCE ON A ROAD WITH POTHOLES AND ONCE ON RT43 SMOOTH AS GLASS ROAD AT A SPEED OF 65MPH?THIS IS ALWAYS A SUDDEN ONSET- NO WARNING?THIS NEEDS TO BE ADDRESSED, MY CHILDREN WERE IN THE CAR WHEN WE WERE...

WE HAVE CONTINUOUS ISSUES WITH THE SHIMMY AND UNCONTROLLABLE SHAKE IN THE FRONT END OF OUR 2005 F250 SUPER DUTY (GAS). AT SPEEDS OF 55 AND HIGHER, THE TRUCK WILL SHAKE UNCONTROLLABLY OFF THE ROAD AT THE SLIGHTEST UNEVEN OR BUMP IN THE ROAD. WE HAVE TAKEN IT TO DEALERSHIPS NUMEROUS TIMES AND THE ONLY THING THEY HAVE DONE IS TO REPLACE THE DAMPER ASSEMBLY ON JUNE 6TH. PROBLEM STILL EXISTS AND SEEMS TO BE MORE ERRATIC AND FREQUENT. *TR

DRIVING ON HIGHWAY AT SPEEDS OF 65 MPH, GOING OVER A BUMP ON THE ROAD, THE FRONT END STARTS SHAKING VERY BAD UNTIL YOU GET BELOW 40 MPH, IT IS ALL YOU CAN DO TO KEEP IT UNDER CONTROL. *TR

I HAVE A 2005 F250 WHEN I HIT A BUMP ON THE HIGH WAY AT 50MPH OR HIGHER THE TRUCK FRONT END AND STEERING WHEEL SHAKE VIOLENTLY AND FEELS LIKE YOU ARE GOING TO LOOSE CONTROL OF THE TRUCK. VERY DANGEROUS. *TR

I OWN A 2005 SUPER DUTY POWER STROKE AND WHEN I HIT A POT HOLE OR WHEN I'M TAKING A TURN TO THE LEFT FROM 40 MPH TO 50 MPH MY TRUCK GETS THE DEATH WOBBLES UNTIL I HIT THE BRAKES AND GET DOWN TO ABOUT 15-20 MPH. I DON'T EVEN LIKE DRIVING IT CAUSE YOU DON'T KNOW WHEN IT'S GOING TO HAPPEN. IT'S KIND OF SAD WHEN YOU PAY SO MUCH FOR A NICE TRUCK AND YOUR AFRAID TO DRIVE IT. I THINK FORD NEEDS TO HAVE A RECALL ON THESE TRUCKS BEFORE SOMEONE GETS KILLED, IT REALLY IS THAT BAD! *TR

2005 F-250 SHORT BED 4X4 SUPER DUTY 5.4 V-8. TRUCK SHAKES OUT OF CONTROL AT HIGH SPEED WHEN ROUGH ROADWAY IS PRESENT. HAS DONE THIS SINCE 18,000 MILES AND GETS WORSE WITH AGE. FORD REFUSES TO FIND THE PROBLEM, AS THEY ONLY DRIVE TRUCK AROUND TOWN. HAVE ASK THEM TO TAKE ONTO INTERSTATE, BUT THEY DON'T HAVE TIME ! FORD REPLACED THE DAMPER AT 34,000, HELPED, BUT DID NOT FIX! HAVE HAD MY FRONT END MAN LOOK AT FRONT END, AND HE COULD ONLY FIND SLACK IN THE STEERING GEAR BOX, BUT THAT DIDN'T FIX THE PROBLEM EITHER. THIS TRUCK IS UNSAFE AND FORD NEEDS TO STEP UP TO THE PLATE AND FIX THE ISSUE BEFORE SOMEONE GETS KILLED! THE LAST TIME IT DID IT I HAD MY 5TH WHEEL TRAILER BEHIND ME AND IT TOOK ME ACROSS 2 LANES OF TRAFFIC INTO THE MEDIAN, AND SCARED ME TO DEATH,...

WHEN TRAVELING DOWN HIGHWAY FROM SPEEDS RANGING FROM 50-70 MPH IF UNEVEN ROAD IN ENCOUNTERED (POTHOLES, ROUGH ROADS, OBJECTS IN ROAD..ETC) VEHICLE GOES INTO VIOLENT FRONTEND SHAKE. WHEN THIS SHAKING OCCURS IT IS AN IMMEDIATE THREAT TO NOT ONLY PERSONS IN VEHICLE BUT IN ANY VEHICLES SURROUNDING OUR OWN. REDUCING SPEED AND BRAKING IS THE ONLY WAY TO REGAIN CONTROL OF VEHICLE. *TR

FORD F250 FRONT END SHAKING WHEN YOU HIT ROUGH SPOT ON FREEWAY AT 65 MPH IT 2005 F250. *TR

MY FORD F 250 TRUCK SHAKES UNCONTROLLABLY AT HIGHWAY SPEEDS WHEN THE FRONT SUSPENSION IS UPSET ON HIGHWAY. NORMALLY OCCURS AT OR ABOVE 65 MPH, THE WAY TO RE-GAIN CONTROL IS SLOW CONSIDERABLY. THIS IS CONSISTENT WITH FACTORY AND REPLACEMENT TIRES. FORD STATED THAT THERE IS A PROBLEM, BUT THAT IT DOESN'T WARRANT A RECALL. *TR

2005 FORD F-250 TRUCK FRONT END WOBBLE. HAS DONE IT SINCE ABOUT 20,000 MILES. DRIVING 55+ MILES PER HOUR, TURNING TO THE LEFT, FRONT END AND STEERING WHEEL SHAKES VIOLENTLY. *TR

2005 FORD F250 4X4, 4 DOOR, AUTO, 5.4L GAS, APPROX. 39K MI. TRAVELING AT INTERSTATE HIGHWAY SPEED, IN A SWEEPING LEFT HAND CURVE, CROSSING ROUGH PAVEMENT, A SEVERE STEERING WHEEL SHAKE AND FRONT WHEEL SHIMMY COMMENCED, CAUSING LOSS OF STEERING CONTROL, INVOLUNTARY RAPID LANE CHANGE AND NEAR ACCIDENT. I SLOWED TO 25 MPH IN ORDER TO REGAIN CONTROL OF THE TRUCK. LIVING IN FL AND WORKING IN SC AT THE TIME, I WAS FORCED TO DEAL WITH DIFFERENT FORD DEALERS IN THE COLUMBIA, SC AND BARTOW, FL AREAS. ON THE ADVICE OF VARIOUS FORD SERVICE DEPARTMENTS, I REPLACED TIRES, WHEELS, BALL JOINTS, SHOCKS (TWICE), STEERING STABILIZER, HAD MULTIPLE ALIGNMENTS AND WHEEL BALANCES PERFORMED. AS I WAS STRANDED OUT-OF-TOWN WITH A TRUCK THAT WAS HANDLING PROGRESSIVELY WORSE, I SPENT APPROXIMATELY $4,500 IN PARTS REPLACEMENTS BEFORE THE PROBLEM WAS REMEDIED. THREE FORD DEALERSHIPS ACKNOWLEDGED THAT A SERIOUS PROBLEM EXISTED AND THAT THE...

WHEN TRAVELING AT INTERSTATE HIGHWAY SPEEDS, TRAVELING OVER BRIDGE/OVERPASS EXPANSION JOINTS WILL CAUSE THE FRONT AXLE/STEERING TO SHAKE VIOLENTLY. THIS SEEMS TO SET UP SOME KIND OF WEIRD HARMONIC VIBRATION THAT THE FRONT END CANNOT RECOVER FROM. EVEN AFTER THE ROAD SMOOTHES OUT, FRONT AXLE WILL CONTINUE TO SHAKE VIOLENTLY UNTIL SPEED IS DECREASED TO ABOUT 40MPH. THIS SHAKING IS INCREDIBLY VIOLENT. A LOSS OF CONTROL IS HIGHLY POSSIBLE. TRUCK HAS BEEN TO THE DEALER TWICE AND HAD THE STEERING STABILIZER REPLACED, THIS HAS NOT FIXED THE ISSUE. DEALER HAS NOT BEEN ABLE TO DUPLICATE THE PROBLEM DUE TO THE RANDOM OCCURRENCE AND SPECIFIC ROAD CONDITIONS REQUIRED. I HAVE DRIVEN FORD TRUCKS MY ENTIRE LIFE, THIS IS NOT A NORMAL "CHARACTERISTIC OF VEHICLE". SOMETHING IS WRONG WITH THE DESIGN ON THE FRONT END OF THESE TRUCKS. MY WIFE WILL NOT DRIVE IT. SOMEBODY IS GOING TO GET KILLED. *TR