2005 FORD F-250 SD Suspension Problems

WHILE DRIVING HOME FROM WORK, JUST LEAVING TOWN I HIT 50 MPH AND THE TRUCK STARTS TO WOBBLE FROM SIDE TO SIDE AND VIBRATE TILL I SLOW DOWN TO UNDER 40 MPH. I GOT THE NOTICE FROM FORD TELLING ME IT ALL HAD TO DO WITH TIRE PRESSURE. I INFLATED THE TIRES TO THE REQUIRED PRESSURE AND IT ONLY MADE THINGS WORSE. I HAVE CONTACTED THEM THE FIRST TIME THIS HAPPENED ONLY FOR THEM TO TELL ME THERE IS NOTHING WRONG. CLEARLY THERE IS A PROBLEM. I HAVE SPENT SO MUCH MONEY REPLACING PARTS IN THE FRONT END OF THIS TRUCK. TIRES ARE NOW JUNK ON THE FRONT END. THE ONLY THING I COULD DO IS UNDER INFLATE THE FRONT TIRES TO GAIN BETTER CONTROL AND DRIVE SLOWER. STILL WOBBLES JUST NOT AS BAD. THIS IS AN ON GOING PROBLEM I HAVE EVERYDAY.

I WAS HEADING DOWN MY STREET IN MY NEIGHBORHOOD AND JUST BEFORE THE STREET BENDS TO THE LEFT MY TRUCK STALLED AND I LOST MY POWER BRAKES AND POWER STEERING. DOING THE BEST I COULD I TURNED THE WHEEL JUST ENOUGH TO AVOID THE CAR PARKED ON THE SIDE OF THE STREET THEN I PROCEEDED TO RUN THROUGH MY NEIGHBOR'S WROUGHT IRON GATE AND PLASTER COMING TO REST ON THE HILL IN HIS FRONT YARD. AFTER ASSESSING THE DAMAGE, I TRIED TO START MY TRUCK TO SEE IF I COULD MOVE IT. IT STARTED AND I MOVED IT TO MY DRIVEWAY. AFTER THE REPAIRS WERE DONE AT THE BODY SHOP I THEN TOOK IT TO MY MECHANIC WHERE HE DISCOVERED A FAULTY WIRE IN THE WIRE HARNESS CAUSING THE ENGINE TO STALL WITHOUT ANY NOTICE OR SIGNS OF TROUBLE. LATER I LEARNED FROM MY INSURANCE COMPANY THAT THERE WAS A...

WHEN EVER THE TRUCK GOES OVER SOMETHING LIKE AN BULGED EXPANSION JOINT OR A POT HOLE WITH SPEED IN EXCESS OF 40-45, IT WILL REACT VIOLENTLY. OFTEN THE VEHICLE WILL MOVE OVER A FOOT OR TWO(DEPENDING ON THE SPEED OF THE TRUCK) IN THE LANE OF TRAFFIC. THE BOUNCING/SHAKING OF THE FRONT WHEELS IS OVER IN SEVERAL SECONDS, BUT IS SEVERE NONE THE LESS. IF YOU HIT A BUMP ON A CURVE, THE VEHICLE WILL ALMOST GO OFF THE ROAD. THIS HAS HAPPENED ENOUGH TIMES OVER THE YEARS THAT I ATTEMPTED EVASIVE ACTION/SLOW WAY DOWN WHEN I SEE I'M ABOUT TO STRIKE SOMETHING THAT WILL SET THE SUSPENSION INTO BOUNCE MODE. MANY, MANY, MANY FORD SUPER DUTY OWNERS HAVE COMPLAINED ABOUT THIS ISSUE AND ALL FORD CAN SAY IS THAT IT'S THE OWNERS FAULT FOR NOT KEEPING THE TIRES AIRED PROPERLY. I DARE YOU TO COME DRIVE MY TRUCK!!!!!!!!! YES,...

I WAS DRIVING DOWN A MAIN ST, GOING ABOUT 35 MPH...WHEN I HIT A BUMP THE TRUCK WOULD SHAKE VIOLENTLY AND THE STEERING WHEEL WAS ALSO SHAKING VIOLENTLY , I HAD IT DIAGNOSED AS THE DRAG LINK BALL JOINT AND AN UPPER BALL JOINT BOTH ON THE PASSENGER SIDE FRONT...I GOT A LETTER IN THE MAIL FROM FORD JUST YESTERDAY ABOUT THE SHIMMY/SHAKING ISSUE, THE LETTER STATES THAT IT IS DUE TO TIRE PRESSURE IN WHICH I BELIEVE TO BE VERY WRONG!! *TR

I NOTICED THAT WHEN I HIT A BUMP THE BED OF MY TRUCK BOUNCES ABOUT TWO INCHES, WHEN I LOOKED UNDER THE TRUCK I NOTICED ALL THE SUPPORTS UNDER THE BED WERE COMPLETELY ROTTED. I HAVE ALSO HAD PROBLEMS WITH MY BRAKES. IN LESS THAN 90,000 MILES I'VE REPLACED THREE BRAKE CALIPERS, TWO ROTORS, TWO SETS OF BRAKES, AND THE LAST TIME I HAD IT SERVICED THE BACKING PLATES WERE SO ROTTED THAT THE EMERGENCY BRAKE WOULDN'T WORK AND COULDN'T BE REPLACED WITHOUT ALSO REPLACING THE BACKING PLATES. I HAVE BEEN DRIVING FOR 50 YEARS AND HAVE NEVER EXPERIENCED THIS MUCH ROT. I FEEL THAT THE STRUCTURAL DAMAGE SHOULDN'T HAPPEN THIS SOON, AND FEEL THAT I SHOULDN'T BE RESPONSIBLE FOR THE COST TO REPAIR IT. *TR

WHILE DRIVING DOWN THE ROAD, HIT A SMALL POTHOLE IN THE ROAD AND THE SUSPENSION STARTED TO VIOLENTLY SHAKE THE TRUCK ALONG WITH SEVERE STEERING WHEEL OSCILLATIONS. NO CONTROL OF THE VEHICLE UNTIL I COULD GET SLOWED DOWN ENOUGH TO STOP THE OSCILLATIONS. I HAVE HAD THIS HAPPEN ON MY TRUCK MULTIPLE TIMES THROUGHOUT THE YEARS AT SPEEDS ANYWHERE FROM 30 TO 60 MPH AND CONTRARY TO OTHER REPORTS LISTED ON HERE, THE TIRE PRESSURE WAS CORRECT AND MADE NO DIFFERENCE. I HAVE PUT ON AFTERMARKET SUSPENSION AND TIRES SINCE THE ORIGINAL TIME THIS HAPPENED AND ADDED A STEERING STABILIZER WHICH HELPED TO KEEP THIS FROM OCCURRING BUT IT STILL HAPPENS ON OCCASION. THIS PROBLEM WAS BROUGHT UP TO MY DEALER AT THE BEGINNING AND THEY SAID THEY COULD FIND NO PROBLEMS. THE SHAKING AND BEATING OF THE VEHICLE WHEN THIS OCCURS IS UNBELIEVABLE. I FULLY BELIEVE THIS IS WHAT...

2005 FORD F-250 SUPER DUTY, STARTED AT @ 25,000 MILES IN 2008 AND STILL HAPPENS TODAY. HAPPENS WHEN TRAVELING OVER 60 MPH, WHEN YOU HIT ANY SMALL BUMP IN THE ROAD, THE FRONT SUSPENSION STARTED TO SHAKE UNCONTROLLABLY. IT IS VERY HARD TO CONTROL THE TRUCK. THIS HAPPENS ALL THE TIME ON THE FREEWAY. THE TIRE PRESSURE WAS CORRECT AT THE TIME OF THE FIRST INCIDENT, THE TIRES WERE BALANCED AND THE LUG NUTS WERE TORQUED TO FORD SPECS. TALKED TO THE FORD DEALER AND THEY DENIED ANY KNOWLEDGE OF A SIMILAR PROBLEM. AFTER A FEW HOURS RESEARCH ONLINE, THIS PROBLEM IS WELL DOCUMENTED AND FREQUENT WITH THE FORD SUPER DUTY LINE FROM 05"-08". IT SEEMS TO BE AN ENGINEERING DEFECT AND FORD IS WELL AWARE OF THE PROBLEM, BUT IT DOES APPEAR THAT FORD HAS OFFERED ANY REMEDIES. THE NHTSA ALSO KNOWS OF THE PROBLEM. I VIEWED FOUR NHTSA...

WHILE DRIVING ON PA INTERSTATE 81, MY 2005 F250 EXPERIENCED SEVERE DRIVING LOSS OF CONTROL WHEN THE FRONT SUSPENSION TRAVELED OVER AN AREA OF THE ROAD THAT WAS UNEVEN. THIS CAUSED THE TRUCKS INTERIOR AND EXTERIOR TO SHAKE UNCONTROLLABLY FOR A LONG PERIOD OF TIME TO THE EXTENT THAT THE VEHICLE WAS SHIFTING INTO THE OTHER LANE OF TRAFFIC. DECELERATING BY RELEASING THE GAS PEDDLE DID NOT IMMEDIATELY STOP THE SEVERE VIBRATIONS AND APPLYING THE BRAKES SEEMED TO INCREASE THE PROBLEM. MY ENTIRE FAMILY AND A NON-FAMILY MEMBER WAS IN THE VEHICLE AT THE TIME AND WE ALL FEARED FOR OUR LIVES. AFTER RESEARCHING THE INTERNET, THERE IS A VIDEO POSTED BY ANOTHER FORD OWNER AND IS EXACTLY WHAT WE HAD EXPERIENCED TOO. (HTTP://WWW.YOUTUBE.COM/WATCH?V=8EUQ6F8RGT4&FEATURE=RESULTS_VIDEO&PLAYNEXT=1&LIST=PLDCA2FF5512789E5A) IT IS KNOWN AS ' FORD F250 DEATH WOBBLE', WHEN VIEWING THE VIDEO, THE DEATH WOBBLE BEGINS AROUND 1 MIN 30 SEC INTO THE VIDEO AND...

I WAS TRAVELING 70 MPH ON A 3 LANE INTERSTATE, IN THE LEFT LANE. I WENT OVER A BRIDGE EXPANSION JOINT AND THE TRUCK STARTED SHAKING VIOLENTLY AND WOULD NOT STOP UNTIL I PULLED OVER TO THE SHOULDER. I CHECKED TO SEE WHAT MAY HAVE CAUSED THE SHAKING AND FOUND NO VISIBLE DAMAGE, AND SO PROCEEDED WITHOUT ANY FURTHER ISSUES. THE VEHICLE IS STOCK WITH PROPER TIRES, SUFFICIENT TREAD, AND WERE INFLATED TO WITHIN 2 TO 3 POUNDS OF FORDS RECOMMENDED TIRE INFLATION (I CHECKED THE NEXT DAY). *TR

MY 2005 F250 SUPER DUTY PICKUP TRUCK VIBRATES VIOLENTLY WHEN I CROSS A BUMP IN THE ROAD AT 65 MPH OR HIGHER. THIS IS VERY DANGEROUS BECAUSE IT IS BOUNCING SO MUCH THAT THE STEERING AND BRAKES DO NOT WORK PROPERLY. SO FAR THIS HAS ONLY HAPPENED DURING TRAVELING ON A STRAIT STRETCH. IF IT WHERE ON A CURVE, IT WOULD BE IMPOSSIBLE TO STEER. SOMETIMES IT VIBRATES INTO THE OTHER LANE. IT IS VERY SCARY. FORD ISSUED A SERVICE NOTICE NOVEMBER 2011 STATING TIRE INFLATION IS THE PROBLEM. THIS IS NOT THE PROBLEM AS THE TIRES ARE INFLATED PROPERLY. I HAVE TAKEN THE TRUCK TO THE DEALER AND THEY ALIGNED THE FRONT END BUT THAT DIDN'T HELP. FORD NEEDS TO FIND A FIX FOR THIS PROBLEM AND ISSUE A RECALL. *TR

UPON HITTING A BUMP AT 30 TO 40 MPH , STEERING VEERS FROM SIDE TO SIDE, ALSO KNOWN AS THE "DEATH WOBBLE"VERY UNSETTLING TO SAY THE LEAST,AFTER SOME RESEARCH ONLINE I WAS SHOCKED TO SEE THAT OTHER FORD 4X4 OWNERS HAVE THE SAME THING. I FOUND A COMPANY THAT SAYS THE STEERING GEOMETRY IS WRONG AND HAVE A FIX, WC MOTORSPORTS (508-203-9450)THIS SHOULD NOT BE HAPPENING , MY TRUCK HAS UNDER 40,000 MILES AND I AM AFRAID TO DRIVE IT. IT IS OBVIOUS THAT SOMETHING IS WRONG AND FORD HAS BEEN IGNORING FOR YEARS. WHAT DO I DO ?DO YOU WANT TO BUY IT? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

BETWEEN SPEEDS OF 40-65MPH TRUCK WILL GO INTO "DEATH WOBBLE" AFTER HITTING A POTHOLE, ROUGH SPOT IN ROAD, OR DIPS ( EX. OVER PASSES, BRIDGES). TRUCK WILL SHAKE VIOLENTLY TO THE LEFT AND RIGHT ALMOST CAUSING A WRECK. ONCE THIS HAPPENS I HAVE TO LET OFF GAS APPLY BRAKE SLOWLY TILL TRUCK STOPS THE SHAKING. TRAFFIC BEHIND ME HAS TO BRAKE, ALMOST CAUSING ACCIDENTS, NOT TO MENTION HOW HARD IT IS TO CONTROL THE TRUCK WHEN THIS HAPPENS. I HAVE ALMOST HAD A WRECK EVERY TIME THIS HAD OCCURRED. FIRST STARTED WHEN I BOUGHT THE TRUCK IN FEB. 2010 WITH 52,500 MILES. STILL HAPPENS TO THIS DAY AFTER REPLACING FRONT END PARTS, TRUCK NOW HAS 68K MILES. I'VE RESEARCHED ONLINE AND THIS SEEMS TO BE AN ISSUE LOTS OF PEOPLE ARE HAVING, NOT TO MENTION IT IS ONGOING. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. WHILE DRIVING APPROXIMATELY 75 MPH OVER A SLIGHT BUMP, THE VEHICLE BEGAN TO VIOLENTLY SHAKE. THE CONTACT APPLIED HEAVY PRESSURE TO THE BRAKE PEDAL TO STOP THE SHAKING. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED; THE DEALER STATED THAT THE CONTACT SHOULD CHECK THE TIRE PRESSURE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 39,600.

ON MY 2005 FORD F250 SUPERDUTY TRUCK WITH ONLY 31000 MILES, THE FOUR CAB ENERGY SUSPENSION MOUNTS ARE DETERIORATING. ONE LOWER PART OF THE REAR DRIVER SIDE MOUNT IS GONE CAUSING THE CAB TO BOUNCE. *TR

TL*THE CONTACT OWNS A 2005 FORD F250. WHILE DRIVING THE VEHICLE BEGAN TO SHAKE VIOLENTLY. HE ALSO BEGAN TO EXPERIENCE A VIOLENT FRONT END SHAKING AT HIGHWAY SPEEDS OF OVER 10 MPH WHEN DRIVING OVER MINIMAL BUMPS IN THE ROAD AND UNEVEN SURFACES. THE FORD DEALER WAS CONTACTED AND THEY ADVISED THE CONTACT TO HAVE AN ALIGNMENT PERFORMED AND TO ROTATE HIS TIRES WHICH DID NOT CORRECT THE FAILURE. HE ALSO HAD SHOCKS INSTALLED IN AN ATTEMPT TO CORRECT THE FAILURE; HOWEVER, THE FAILURE PERSISTED. THERE WERE NO ADDITIONAL REPAIRS MADE TO THE VEHICLE IN AN ATTEMPT TO CORRECT THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE UNDER 85,000. UPDATED 3/10/10 *CN UPDATED 06/04/10*JB

I CURRENTLY OWN A FORD F 250 PICKUP TRUCK, WHEN I AM DRIVING 40 TO 50 MPH MY TRUCK STARTS TO SHACK VIOLENTLY. I HAVE READ MANY FORUMS ON THIS AND MANY PEOPLE ARE HAVING THE SAME PROBLEM . WHY HAS FORD NOT RECALLED MY TRUCK TO FIX THIS PROBLEM WHEN THEY KNOW THERE IS A PROBLEM? MUST SOMEBODY GET HURT OR WORSE KILLED DUE TO FORDS NEGLECT OF THIS PROBLEM? *TR

FORD F-250 SUPERDUTY- WHILE DRIVING AT 55MPH OR HIGHER,AND YOU HIT A SMALL POTHOLE OR DIP IN THE ROAD, THIS VEHICLE GOES INTO A VIOLENT SHIMMY. THE VEHICLE IS UNCONTROLLABLE AND EXTREMELY DANGEROUS. I WON'T LET ANY OF MY FAMILY MEMBERS RIDE IN THE TRUCK WITH ME AND CRINGE AT THE THOUGHTS OF HAVING TO DRIVE IT ON THE INTERSTATE! IT HAS SHAKEN ME OFF THE ROAD AND INTO THE DITCH OR MEDIAN SEVERAL TIMES. *TR

I BOUGHT A 2005 F250 CREW CAB AND SINCE ABOUT 25K MILES MY TRUCK WILL WOBBLE WHEN I HIT A BUMP AT 45-60 MILES PER HOUR. THE SHACK/WOBBLE IS SO INTENSE THAT YOU FEEL THE FRONT OF THE TRUCK IS GOING TO LOOSE THE TIRES. THIS HAS HAPPENED ABOUT 6 TIMES NOW AND I KNOW SOMETHING IS VERY WRONG BUT FORD WILL NOT DO ANYTHING EXCEPT TELL ME TO CHECK MY TIRE PRESSURE. TIRE PRESSURE IS CHECKED ALMOST MONTHLY ON MY TRUCK AND I KNOW THAT IS NOT THE ISSUE. IT IS HARD TO HAVE RE-CREATE THE ISSUE WITH A TECH, SINCE IT DOES NOT HAPPEN ALL THE TIME. I AM GETTING THE RUN AROUND WITH FORD AND HAVE SPENT THOUSANDS OF DOLLARS TRYING TO FIX THE PROBLEM MYSELF. I KNOW OF OTHER FORD OWNERS THAT HAVE THE SAME PROBLEM AND FORD REFUSES TO DO ANYTHING. *TR

2005 FORD F250 FRONT END SHAKES VIOLENTLY WHEN DRIVING OVER BUMPS IN ROAD INCLUDING SPEED BUMPS, AT ANY SPEED. SHAKES SO BAD THAT VEHICLE WANTS TO LEAVE THE ROAD SIDEWAYS. SHAKES LIKE A DOG WAGGING OFF WATER. REPLACED STEERING STABILIZER, SHOCKS, TIRES AND HAD FRONT ENT CHECKED. STILL SHAKING. GETTING READY TO TURN IN TO CLUNKER PROGRAM. NEVER BUY A FORD AGAIN, THEY KNOW THIS IS A PROBLEM. *TR

I OWN A FORD 2005 F250 SUPER DUTY FX4 PICK UP. WHEN THE TRUCK GOES OVER A BUMP OR UNEVEN ROAD SURFACE THE FRONT END BECOMES SHAKY AND THE VEHICLE HAS A SIDEWAYS MOVEMENT , THIS IS MORE EVIDENT IF IT OCCURS WHILE ROUNDING A CURVE IN THE ROAD. THIS VEHICLE WAS PURCHASED NEW AND THE PROBLEM HAS BEEN ON GOING. ON 07/07/09 I ALMOST VEERED INTO A BUS . *TR

FORD F250, 2005 SUPERDUTY - FRONT END SHAKES VIOLENTLY WHEN DRIVING OVER A ROAD IMPERFECTION (BRIDGE TRANSITIONS, BUMPY ROADS ETC..) I'VE BROUGHT IT BACK NUMEROUS TIMES AFTER THE FIRST STEERING SHIM RECALL AND MADE CALLS BUT HAVE GOTTEN NO WHERE. THEY TOLD ME TIRE PRESSURE , BUY NEW TIRES AND THERE IS NOTHING THEY CAN DO! NOW MY TRUCK IS OUT OF WARRANTY THEY SAY BRING IT IN WE'LL FIX IT. FORD SHOULD BE ASHAMED OF THEMSELVES! I NEVER KNEW ABOUT THIS COMPLAINT SIGHT BEFORE, I WISH I DID THEN. *TR

TL*THE CONTACT OWNS A 2005 FORD F250 SD. WHILE DRIVING 70MPH ON THE INSIDE LEFT LANE, THE VEHICLE DROVE OVER A SMALL BUMP IN THE ROAD AND BEGAN SHAKING UNCONTROLLABLY. THE CONTACT HAD DIFFICULTY STEERING THE VEHICLE AND WAS UNABLE TO DRIVE INTO THE EMERGENCY LANE. AFTER SHAKING FOR 3 TO 5 MINUTES THE VEHICLE BEGAN OPERATING NORMALLY. THE DEALER DIAGNOSED THE VEHICLE AND STATED THAT THERE WAS A TECHNICAL SERVICE BULLETIN TO PLACE A DAMPER IN THE SUSPENSION. THE VEHICLE WAS REPAIRED AND THE FAILURE NO LONGER EXIST. SHORTLY AFTER THE FAILURE OCCURRED, THE CONTACT RECEIVED A WARNING LETTER STATING THAT MAINTAINING THE PROPER TIRE INFLATION LEVEL WOULD AVOID THE FAILURE FROM RECURRING. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 80,000.

VERY SEVERE UNCONTROLLABLE FRONT END SHIMMY. VEHICLE WAS TAKEN TO DEALER AND NO TROUBLE WAS FOUND. SERVICE ADVISOR ADVISED TIRE BALANCING AND ALIGNMENT. I PAID FOR THAT SERVICE OUT OF POCKET AND PROBLEM STILL PERSISTED. I THEM REPLACE THE TIRES OUT OF POCKET. PROBLEM STILL PERSISTED. I THEN REPLACED THE SHOCKS AND STEERING STABILIZER OUT OF POCKET. PROBLEM IS 90 PERCENT BETTER BUT YOU MUST BE CAREFUL OF THE VEHICLE LIMITATIONS. IN MY OPINION THEIR IS A VEHICLE DESIGN FLAW. EXACT DATES CAN BE SUPPLIED IF NECESSARY. *TR

WHILE TRAVELING AT ABOUT 60 MPH I LOST CONTROL OF MY TRUCK DUE TO VIOLENT SHAKING OF THE FRONT END. I HAD TO PULL OVER AND LET SPEED DECREASE TO 20 MPH TO REGAIN CONTROL. THIS HAPPENED TWICE IN A 2 MILE PERIOD. I THEN DROVE ON SHOULDER OF THE ROAD AT 20 MPH TO GET HOME. THIS HAS BEEN A CONSISTENT PROBLEM SINCE I BOUGHT THE TRUCK NEW IN 2005 BUT IT HAS NEVER BEEN THIS BAD. I ORIGINALLY THOUGHT IT WAS BECAUSE IT WAS A 4 WHEEL DRIVE. I AM NOW NOT WILLING TO DIVE AT HIGH SPEEDS. THIS IS A SUPER DANGEROUS PROBLEM!!! *TR

OUR COMPANY HAS 3 2005 F-250 WORK TRUCKS AND THE ALL HAVE THE SAME PROBLEM ,WHEN YOU REACH APPROX. 55MPH YOU GET A VIOLENT SHAKE FROM THE FRONTEND,AND OR IF YOU HIT A POTHOLE IT IS VERY DANGEROUS, LIKE YOUR GOING TO LOSE CONTROL DUE TO THE SHAKING AND NOBODY CAN FIND A TOTAL FIX TO THE PROBLEM,I THINK FORD SHOULD HAVE A RECALL OR SOMETHING! *TR

I WAS DRIVING ON I-64 DOING ABOUT 65-70MPH AND CROSSED OVER BRIDGE/ROUGH SPOT IN ROAD WHEN IT THREW THE TRUCK INTO A BAD SHIMMY. IT HAS HAPPENED AT LEAST 10 TIMES IN THE PAST YEAR. I TOOK THE TRUCK TO A FORD DEALER AND WAS TOLD THAT IT NEEDED A NEW CAMBER KIT THAT WOULD CHANGE BY 1 DEGREE. I HAD TO PAY FOR REPAIRS. THE PROBLEM STILL EXIST. *TR

WE HAVE CONTINUOUS ISSUES WITH THE SHIMMY AND UNCONTROLLABLE SHAKE IN THE FRONT END OF OUR 2005 F250 SUPER DUTY (GAS). AT SPEEDS OF 55 AND HIGHER, THE TRUCK WILL SHAKE UNCONTROLLABLY OFF THE ROAD AT THE SLIGHTEST UNEVEN OR BUMP IN THE ROAD. WE HAVE TAKEN IT TO DEALERSHIPS NUMEROUS TIMES AND THE ONLY THING THEY HAVE DONE IS TO REPLACE THE DAMPER ASSEMBLY ON JUNE 6TH. PROBLEM STILL EXISTS AND SEEMS TO BE MORE ERRATIC AND FREQUENT. *TR

FRONT END SHAKES VIOLENTLY AFTER HITTING POT HOLES OR BUMPS IN THE ROAD. TO THE POINT WHERE A COLLISION IS HIGHLY POSSIBLE. *TR

FORD SD F250 4WD - LIKE OTHERS, SEVERE SHIMMY, ESPECIALLY ON EXPANSION JOINTS ON FREEWAYS. CAN AND DOES SPOOK THE DRIVER. SCARY MOMENTS. DEALER CHECKED, AND SAID STEER STABILIZER SHOULD BE REPLACED?? AT 61,000 K - NO WAY. OTHERS ARE SAYING SAME THING, INCLUDING BALL JOINTS BEING WORN OUT??? *TR

WHEN DRIVING ON THE HIGHWAY ABOVE 50MPH THE FORD 2005 F250 SUPER DUTY BEGINS TO SHAKE VIOLENTLY TO THE POINT OF LOOSING CONTROL. THEY ONLY WHY TO STOP THE SHAKING IS TO SLOW DOWN IMMEDIATELY AND FORCE ANY FOLLOWING TRAFFIC TO SLAM ON THEIR BRAKES TOO. THE ITEMS THAT BRING ON THIS SHAKE (OSCILLATION) ARE THE FOLLOWING. THE PROBLEM OCCURS WHEN: 1. ON A HIGHWAY GOING OVER 50 MPH 2.HIITTING A BUMP IN THE ROAD. ONCE A BUMP IS HIT ABOVE 50MPH, THE OSCILLATION (LEFT TO RIGHT) BEGINS. I HAVE BEEN IN SEVERAL INCIDENTS WERE THE CARS BEHIND ME MUST MANEUVER OR STOP AND RISK RUNNING INTO OTHER VEHICLES. *TR

2005 FORD F-250 SD SHAKING VIOLENTLY AFTER GOING OVER UNEVEN SURFACES ON HIGHWAY. WE WERE OUT OF THE STATE WORKING FOR 10 DAYS AND DEPENDED ON THIS VEHICLE SO THE FOLLOWING DAY WE TOOK IT TO A FORD DEALER AND ALL THEY HAD TO SAY WAS THE TIRES NEEDED 80 POUNDS OF AIR. AS SOON AS WE RETURNED HOME WE TRADED IT OFF AND GOT A 2006 AND IT IS DOING THE SAME THING AND A COMPLAINT HAS BEEN FILED ON IT AS WELL. DONE WITH FORD TRUCKS, IF FORD DOESN'T THINK ANY BETTER OF ITS CUSTOMERS THAN TO PUT AN UNSAFE VEHICLE ON THE ROAD WE ARE GOING TO CHEVROLET. *TR

MY FORD F250 SD 2005 HAS A VIOLENT UNCONTROLLABLE SHAKING IN THE FRONT END. THIS PROBLEM HAS BECOME MORE FREQUENT AS THE TRUCK GETS OLDER. WHEN THIS HAPPENS I HAVE TO PULL OVER AND STOP. *TR

VIOLENT SHAKING AFTER HITTING POT HOLES OR EXPANSION JOINTS ON HIGHWAYS AT SPEEDS RANGING FROM 55 TO 75MPH. THE SHAKING CAUSES A COMPLETE LOSS OF STEERING CONTROL AND WILL NOT STOP UNTIL SLOWING BELOW 40MPH. AFTER READING SEVERAL POSTS ONLINE I SEE THIS IS AN ONGOING PROBLEM WITH THESE TRUCKS AND NEEDS TO BE FIXED BEFORE SOMEONE GETS KILLED. *TR

2005 F-250 SUPERDUTY LARIAT 4 DOOR 4X4 VIOLENT SHAKING WHEN HITTING ROUGH ROADS. *TR

SHAKES VIOLENTLY AND UNCONTROLLABLY AT VARIOUS TIMES AND SPEEDS WHEN HITTING A BUMP OR UNEVEN SURFACE. USUALLY OCCURS AT 60-75 MPH. VERY DANGEROUS AND SCARY! DEALER BLAMES TIRES WHICH ARE ALMOST BRAND NEW. *TR

TRUCK HAS HAD MANY ELECTRICAL ISSUES SINCE I PURCHASED IT. TRUCK ALSO HAS A TERRIBLE BOUNCE WHEN IT HITS A POTHOLE. *JB

I HAVE A 2005 FORD F250 SUPER DUTY FX4 PICKUP THAT I PURCHASED TODAY. ON THE WAY HOME, AT ABOUT 65-70MPH, I HIT A BRIDGE JOINT WHICH SENT THE FRONT END INTO AN EXTREMELY VIOLENT WOBBLE. I HAD TO SLOW DOWN TO ABOUT 20MPH FOR IT TO GO AWAY. WHEN I GOT HOME, I RESEARCHED THE PROBLEM ON THE INTERNET, AND FOUND IT TO BE A VERY COMMON PROBLEM. I BELIEVE THAT FORD HAS ISSUED A TSB FOR THIS PROBLEM, BUT I FEEL THAT A RECALL SHOULD BE ISSUED BECAUSE OF HOW DANGEROUS THE ISSUE IS. THE CONSUMER SHOULD NOT HAVE TO PAY TO REDESIGN A FACTORY ENGINEERING PROBLEM. THE WOBBLE WAS SO BAD THAT THE TRUCK MOVED INTO THE NEXT LANE. *TR

TL*THE CONTACT OWNS A 2005 FORD F250 SUPER DUTY. HE STATED THAT WHILE DRIVING HIGHWAY SPEEDS THE VEHICLE WOULD BOUNCE AND SHIMMY. THE DEALER STATED THAT THEY HAVE DONE ALL THAT THEY COULD DO. THE FAILURE MILEAGE WAS 18,000 AND THE CURRENT MILEAGE WAS 22,000. THE VIN NUMBER APPEARED TO BE INCORRECT.

WHILE DRIVING AT INTERSTATE SPEEDS, AFTER DRIVING OVER A BRIDGE JOINT OR POT HOLE, THE BOUNCE OFTEN CAUSES THE FRONT END TO GO INTO A VIOLENT HARMONIC STEERING OSCILLATION THAT ONLY STOPS WHEN YOU SLOW DOWN. YOU HAVE SEVERAL SECONDS TO SLOW DOWN BELOW 35 MPH BEFORE THE OSCILLATION CAUSES LOSS OF CONTROL OF THE VEHICLE. THE STEERING OSCILLATION IS VIOLENT ENOUGH TO CAUSE THE VEHICLE TO HAVE TO HAVE A STEERING ALIGNMENT AFTER EACH EPISODE. THE DEALERSHIPS HAVE A TECHNICAL SERVICE BULLETIN (TSB) THE RECOMMENDS: FRONT END ALIGNMENT, REPLACE STEERING STABILIZER, CHECK TIRE PRESSURE, CHECK FRONT END FOR LOOSE COMPONENTS. I HAVE HAD THIS SERVICE AND IT DID NOT FIX THE PROBLEM. THE TRUCK HAS BEEN TO THE DEALERSHIP 3 TIMES AND THE PROBLEM IS NOT RESOLVED. *JB

2005 FORD F250 CREW CAB SUPER DUTY V10 TRITON. WHILE DRIVING AT A SPEED ABOVE 30 MPH AND HITTING SOME BUMPS ON THE ROAD THE TRUCK WILL GO INTO A VIOLENT OSCILLATION WHERE ALL THE WHEELS HOP UP AND DOWN CAUSING ME TO NEARLY LOOSE CONTROL. THE ONLY WAY I HAVE FOUND TO STOP THIS SEVERE WHEEL HOP IS TO PUT THE VEHICLE IN NEUTRAL AND QUICKLY BUT SAFELY GET THE VEHICLE BELOW 10 MPH (5 MPH IF LEFT IN GEAR). THIS USUALLY HAPPENS AT SPEEDS ABOUT 50 MPH BUT IN TWO CASES IT HAS HAPPENED AT SLOWER SPEEDS INCLUDING ONCE AT RIGHT AT 30 MPH. I HAVE HAD PASSENGERS INCLUDING CHILDREN IN THE VEHICLE WHEN THIS HAS HAPPENED AND THEY HAVE ALL FEARED FOR THEIR LIVES WHEN IT OCCURS. I FIND MYSELF DODGING BUMPS IN THE ROAD AT THE RISK OF CAUSING AN ACCIDENT MYSELF TO KEEP THIS FROM...

SEVERE RAPID VIBRATION IN STEERING WHEEL AFTER HITTING SMALL CHANGES IN SURFACE PLANE - ACKNOWLEDGE SPEED 70-80 - POSSIBLE UNBALANCED SUSPENSION FOR ELEVATION OF CHASSIS? VERY DANGEROUS, VERY REAL PROBLEM. *JB

DRIVING 2-LANE HIGHWAY 55-70 MPH WHEN CHANGE IN ROAD SURFACE (BUMP, FROST HEAVE, ROAD BED SURFACE MATERIAL CHANGE) CAUSED FRONT END TO SHAKE VIOLENTLY, NEARLY CAUSING LOSS OF CONTROL. ONLY WAY TO STOP SHAKING WAS TO SUDDENLY DECREASE SPEED TO APPROXIMATELY 35-50 MPH IN TRAFFIC ON RAIN-SLICK ROADWAY. THIS OCCURRED 4 TIMES IN COURSE OF 350 MILE TRIP, EACH OCCURRANCE BECOMING MORE VIOLENT IN NATURE AND REQUIRING MORE EFFORT TO MAINTAIN CONTROL. LAST OCCURRANCE WAS AS OPERATOR WAS PASSING 18-WHEELER...AS I PULLED ALONG SIDE, VEHICLE BEGAN TO SHAKE VIOLENTLY. AS OPERATOR FINISHED PASSING AND RETURNED TO LANE OF TRAVEL, HAD TO BRAKE SUDDENLY TO REGAIN CONTROL, NEARLY CAUSING SKID ON RAIN-SLICK ROAD AND ALMOST CAUSING FOLLOWING VEHICLES TO TAKE EXTREME MEASURE TO AVOID COLLISION. *JB

CONSUMER'S 2005 FORD F250 SHOOK WHEN IT HIT A BUMP. *TS WHEN THE STEERING WHEEL STARTED SHAKING THE CONSUMER COULD NOT MAKE IT STOP UNTIL HE LOWERED HIS SPEED TO APPROXIMATELY 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER 5 TIMES FOR THIS PROBLEM BUT THEY HAVE BEEN UNABLE TO DUPLICATE OR REMEDY THE PROBLEM. AS OF 9-26-05 THE VEHICLE HAS BEEN AT THE DEALER. AN ENGINEER AGREED THAT THERE IS A PROBLEM BUT DOESN'T KNOW WHAT THE PROBLEM IS. THE CONSUMER WOULD LIKE FOR THE MANUFACTURER TO BUY BACK THE TRUCK. *NM

F250, SUPER DUTY, 3/4-T, 4X4, 4WD, SHORT BOX. ALL SPEEDS IT IS NOTICEABLE. AT HIGHWAY SPEEDS (75+ MPH), ENCOUNTERING BUMPS, SEVERE SHIMMY IN FRONT END, NEARLY CAUSING LOSS OF CONTROL OF VEHICLE. FLEET OF 7 TRUCKS ALL EXPERIENCE SAME, SOME WORSE THAN OTHERS. DEALER HAS DONE ALL POSSIBLE TO REMEDY, INCLUDING AFTERMARKET HEAVIER DUTY FRONT STEERING STABILIZER (AT OUR EXPENSE). INCIDENT DATE IS LAST DATE IT OCCURRED TO MY CRUISER TRUCK. IT HAPPENS EVERY TIME A BUMP IN THE HIGHWAY IS ENCOUNTERED WITH EVERY TRUCK OUR DEPARTMENT BOUGHT FOR USE AS LAW ENFORCEMENT VEHICLES. THE MAGNITUDE OF THE WOBBLE IS DEPENDANT ON THE SPECIFIC TRUCK AND THE SPEED TRAVELED. REALIZE THAT AS LAW ENFORCEMENT RESPONSE VEHICLES, OFTEN THIS INVOLVES VERY HIGH SPEED. THE HIGHER THE SPEED, THE WORSE THE PROBLEM.

DT: VEHICLE WILL GO TO THE LEFT OR THE RIGHT, AND CONSUMER WILL NEVER FEEL STEERING WHEEL MOVE. TOOK VEHICLE TO DEALER , LINED IT UP, PUT NEW TIRES ON IT, PUT NEW CASTERS ON, AND ROTATED IT. BUT VEHICLE STILL HAS THE PROBLEM. *AK

WHILE DRIVING DRIVER NOTICED THAT THE VEHICLE SWAYED FROM LEFT TO RIGHT ON ITS OWN. THEN, VEHICLE VIBRATED UNCONTROLLABLY. DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE TO THE DEALER. MECHANIC INFORMED THE DRIVER THAT DEALERSHIP WAS AWARE OF PROBLEM, BUT A SOLUTION WAS UNDETERMINED AT THIS TIME. *AK