2005 FORD F-250 SD Service Brakes Problems

ON SEVERAL OCCASIONS, MY F250, SUPER DUTY 6.0 DIESEL BECAME SLUGGISH AND GAS MILEAGE SUFFERED IMMENSELY. THEN, WITH ONLY 53,000 MILES, MY LEFT REAR DISK BRAKE CALIPER WAS DRAGGING AND STARTED SMOKING. AT MY COST AND ON THE LEFT REAR, I HAD FORD REPLACE THE CALIPER, PADS, BRAKE LINE AND RESURFACE THE ROTORS. ALSO, THE RIGHT REAR ROTOR WAS RESURFACED. AT 54,000, I MAKE A 100 MILE TRIP AND THE RIGHT REAR CALIPER STARTED DRAGGING. I AM NOT SURE HOW TO FIX THIS SINCE NO ONE HAS THE SOLUTION.ADDITIONALLY, I DO NOT HAVE THE MONEY TO REPLACE THE ENTIRE BRAKE SYSTEM. HOWEVER, THIS COULD CAUSE TOTAL BRAKE FAILURE AND A POSSIBLE FIRE RESULTING IN FATALITIES.

THIS IS THE THIRD TIME I HAVE ENCOUNTERED THIS PROBLEM, AND REPORTED THIS PROBLEM AS WELL. . BROUGHT TO FORD DEALERSHIP AND TOLD THEY DID NOT FIND ANYTHING WRONG WITH THE VEHICLE. IT CONTINUED TO HAPPEN. I BROUGHT THE TRUCK TO AN INDEPENDENT REPAIR SHOP WHO KNEW RIGHT AWAY THAT THE CALIPERS WERE SEIZED.. I PAID APPROXIMATELY $1100.00 FOR THAT BRAKE JOB AND TOLD THAT FORD WOULD NOT WARRANTY THE PARTS IT WAS BEYOND THE WARRANTY. I WAS TOLD THERE WAS A RE-DESIGN OF THE BRAKE SHOES. THEY REPLACED ONE REAR ROTORS, "FREED UP" ONE REAR CALIPER. I DID ADVISE DRIVERS FRONT WAS SEIZING UP AT ONE POINT AS WELL. I WAS PROVIDED THE REAR ROTORS AND SHOES. THE SHOES WERE WELL WITHIN USABLE RANGE WHICH WAS NOTED BY MYSELF, ALSO A DIESEL MECHANIC AND A INDEPENDENT AUTO REPAIR SHOP. THE DAY I PICKED UP THE VEHICLE I WAS DRIVING...

I NOTICED THAT WHEN I HIT A BUMP THE BED OF MY TRUCK BOUNCES ABOUT TWO INCHES, WHEN I LOOKED UNDER THE TRUCK I NOTICED ALL THE SUPPORTS UNDER THE BED WERE COMPLETELY ROTTED. I HAVE ALSO HAD PROBLEMS WITH MY BRAKES. IN LESS THAN 90,000 MILES I'VE REPLACED THREE BRAKE CALIPERS, TWO ROTORS, TWO SETS OF BRAKES, AND THE LAST TIME I HAD IT SERVICED THE BACKING PLATES WERE SO ROTTED THAT THE EMERGENCY BRAKE WOULDN'T WORK AND COULDN'T BE REPLACED WITHOUT ALSO REPLACING THE BACKING PLATES. I HAVE BEEN DRIVING FOR 50 YEARS AND HAVE NEVER EXPERIENCED THIS MUCH ROT. I FEEL THAT THE STRUCTURAL DAMAGE SHOULDN'T HAPPEN THIS SOON, AND FEEL THAT I SHOULDN'T BE RESPONSIBLE FOR THE COST TO REPAIR IT. *TR