2014 FORD EXPLORER Engine Problems

CRACKED EXHAUST MANIFOLD. CAR HAS 75K MILES. $1300 REPAIR BILL FOR NEW MANIFOLD AND ATTACHED SENSORS.

THE WATER PUMP IN MY 2014 FORD EXPLORER 3.5L V6 ENGINE BEGAN LEAKING COOLANT. THE WATER PUMP HAD TO BE REPLACED AT 79,000 MILES. I BECAME AWARE OF THIS PROBLEM AFTER GETTING AN OIL CHANGE. THE COOLANT RESERVOIR HAD TO BE FILLED AND I WAS INFORMED OF A POSSIBLE COOLANT LEAK. TWO WEEKS AFTER GETTING THE COOLANT FILLED, MY RADIATOR FAN BEGAN RUNNING FAST AND LOUD. I BROUGHT IT INTO THE SHOP AND WAS TOLD I HAD A LEAKING WATER PUMP. THERE WAS ONLY ONE INCH LEFT OF COOLANT IN THE RESERVOIR AFTER JUST BEING FILLED UP. I WAS THEN TOLD IT WOULD TAKE 14-16 HOURS OF LABOR TO REPLACE THE WATER PUMP WHICH ITSELF COSTS LESS THAN $150. I WAS REFERRED BY THE SHOP TO THE DEALERSHIP BECAUSE THE WORK NEEDED WAS EXTENSIVE AND BECAUSE IT INVOLVED A FORD PART. THE DEALERSHIP REFUSED TO PAY FOR THE REPAIRS AND...

WHEN YOU ACCELERATE AT HIGHER SPEEDS IE ON THE FREEWAY THE CAR IS FILLED WITH EXHAUST SMELL.

2014 EXPLORER CONTINUOUSLY LEAKING COOLANT NEAR FRONT PASSENGER TIRE. DEALERSHIP REFILLED COOLANT AND PERFORMED A PRESSURE TEST AND WAS UNABLE TO DUPLICATE THE PROBLEM. ONE YEAR LATER, THE VEHICLE IS STILL LEAKING COOLANT AND I HAVE TO KEEP ADDING ADDITIONAL COOLANT. I AM CONCERNED THIS IS A WATER PUMP FAILURE AND COST TO REPAIR CAR WOULD BE UPWARD OF 8K

I'M GETTING CEL ERROR CODE P0016. THERE IS A RATTLING NOISE ON STARTUP AND SOMETIMES DURING HIGHWAY DRIVING EVERYDAY. MY EXPLORER SPORT HAS 65,340 MILES ON IT, W AY TO SOON FOR A TIMING CHAIN. THE DEALER STATED I PROBABLY HAVE TIMING CHAIN STRETCH AND THERE NO TSB TO RESOLVED THE ISSUE IN MY TRUCK EVEN THOUGH I HAVE THE SAME ECOBOOST ENGINE AS THE F150 THAT THE TSB 17-0026 DOES APPLY TO. WHY NOT THE FORD EXPLORER THAT HAS SAME EXACT ENGINE AS F150 WITH THE SAME PROBLEM? WHY WAS THE FORD EXPLORER ECOBOOST LEFT OUT OF THE TSB? THERE'S AN ISSUE WITH THE ENGINE NOT MODEL OF TRUCK. I'M HOPEFULLY LOOKING FOR FORD TO HONER THE TSB FOR MY VEHICLE THAT HAS THE SAME ENGINE DEFECT

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT TOOK THE VEHICLE TO ROWE FORD AUBURN (699 CENTER ST, AUBURN, ME 04210) FOR ROUTINE MAINTENANCE AND WAS INFORMED THAT THE EXHAUST MANIFOLD WAS LEAKING AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. CONSUMER ALSO STATED EXHAUST WAS LEAKING FUMES INTO CARGO AREA, WHICH CAUSED HEADACHES AND LIGHT HEADINESS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 165,000. *CW*JB

THERE IS AN ODOR LEAKING INTO THE CAR FROM EITHER THE ENGINE OR THE EXHAUST . I'VE NOTICED IT MULTIPLE TIMES OVER THE LAST FEW DAYS AND WE HAVE TO PUT THE WINDOWS DOWN TO NOT FEEL SICK WHEN WE BREATHE. IT HAPPENS WHETHER I AM DRIVING OR STOPPED AT A LIGHT. I ALSO STARTED FEELING TIRED WHILE DRIVING AND ALMOST FELL ASLEEP AT THE WHEEL IN THE MIDDLE OF THE DAY. I HAVE NOW STOPPED USING THE VEHICLE. SOMETHING IS VERY WRONG.

WHEN ACCELERATING FROM A PARKED POSITION, THE ENGINE APPEARS TO SKIP, AND OR BUCK. IT IS NOTICEABLE, BUT THE DEALER CANNOT REMEDY IT.

THE ENGINE BEGAN LEAKING COOLANT CAUSED BY THE WATER PUMP SEAL FAILING. WE HAVE HAD SEVERAL OTHERS THAT ALSO HAVE HAD WATER PUMP FAILURES.

BELIEVE THERE IS AN ISSUE WITH CARBON MONOXIDE IN MY VEHICLE. WHILE DRIVING FOR ABOUT 4 HOURS THE CARBON MONOXIDE DETECTOR IN MY BAG BEGAN TO SOUND INDICATING THE PRESENCE OF CARBON MONOXIDE. IT DID NOT STOP UNTIL I REMOVED IT FROM THE VEHICLE. I WAS LIGHT HEADED AND EXPERIENCING NAUSEA AT THE TIME.

ON SUNDAY SEPTERMBER 1ST WHILE I WAS DRIVING BACK HOME A LIGHT ON MY DASHBOARD CAME ON, IT SAID "ENGINE COOLANT OVER TEMPERATURE" IN RED LIGHT. I WAS SCARE BECAUSE I WAS STUCK IN THE FREEWAY AND I WAS STILL FAR AWAY FROM HIM AND MY KIDS WERE IN THE BACK. I DROVE VERY SLOW AND MANAGED TO GET HOME. ON TUESDAY I TOOK MY CAR TO THE FORD DEALERSHIP AND THEY TOLD ME THAT I HAVE TO REPLACE MY WATER PUMP, AND IT WAS A HARD AND LONG SERVICE AND THAT IT WAS GOING TO COST ME $3,300. I AM SURPRISE OF HOW MUCH THAT COSTS, ESPECIALLY THAT IT HAPPENED ON MY 2014 FORD EXPLORER. I BOUGHT IT BRAND NEW AND I'VE BEEN TAKING IT TO FORD DEALERSHIP EVERY 7,000 MILES TO GET THE MAINTENANCE. PLUS, THE LAST TIME THAT I TOOK IT IN TO THE DEALERSHIP FOR ITS...

I WAS GETTING HEADACHES WHILE DRIVING SO I PURCHASED A CARBON MONOXIDE DETECTOR FOR MY EXPLORER FOR $149.00. IT REGISTERED AROUND 18-20PPM WHEN DRIVING. JULY 2019 I HAD THE 'REPAIR' DONE AT MY LOCAL DEALER. AUGUST 2019, MORE HEADACHES AND MY VEHICLE STILL REGISTERS 18-20 PPM WHILE DRIVING. THE APPARENT FIX DID NOTHING TO CORRECT THE CARBON MONOXIDE FROM LEAKING INTO MY CABIN AREA. DRIVING WITH AIR CONDITIONER ON AND IN RECIRCULATING MODE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 40 MPH, THE VEHICLE BACKFIRED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CRANKSHAFT AND CAM SHAFT SENSORS NEEDED TO BE REPLACED. THE CONTACT CALLED SUNRISE FORD OF FONTANA (LOCATED AT 16005 VALLEY BLVD, FONTANA, CA 92335, (888) 629-1239) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 100,000.

WHEN SUDDENLY ACCELERATING TO SPEED OVER 65 MPH , EXHAUST GAS/FUMES ENTER THE MAIN CABIN, AND LINGER FOR SOMETIME, UNTIL I OPEN ALL WINDOWS TO DISSIPATE THE FUMES. THIS ISSUE ALWAYS OCCUR DURING SUDDEN ACCELERATION. I HAVE TAKEN VEHICLE TO DEALER SEVERAL TIMES AND THEY INSTALLED EXTERNAL SEALS BUT ISSUE CONTINUES, EVEN AFTER THE FIXES.

TIMING CHAIN AND CAM PHASERS CAUSING VEHICLE TO EXCEL ERASE AND STOP WITH NO CONTROL. POWER STEERING GOING IN AND OUT WHILE DRIVING.

IDLER PULLY WENT BAD THREW BELT..ONLY HAD 32,000 MILES ON IT...IN MOTION ON A CITY STREET.HAPPEND ON A SUNDAY WILE ON VACATION IN FLORIDA..TOOK TO FIRESTONE DEALER TO FIX..COST ME $372.00 TO FIX...

FUEL SMELL/FUMES ENTERING PASSENGER CABIN WHEN AC/HEAT IS ON. SOMETIMES AT A STOP OR SLOW PACE AND WINDOWS ARE OPEN FUMES OR SMELL IS APPARENT. ONCE PARKED YOU CAN SMELL FROM THE FRONT PART OF THE VEHICLE IN THE HOOD NEAR THE WIPER BLADES.

WE HAVE EXPERIENCED A CLICKING NOISE ON OUR CAR OVER THE LAST COUPLE OF WEEKS AND MY WIFE HAS BEEN COMPLAINING OF HEADACHES AND FATIGUE DURING THE SAME TIME AS WELL. WE TOOK THE CAR INTO THE SHOP AND IT HAS BEEN IDENTIFIED AS A CRACK EXHAUST MANIFOLD WHICH WOULD COST US $1,100 TO FIX. I RESEARCHED AND SAW THIS 1.3MILLION REPORTS OF THE SAMETHING. I CALLED FORD AND THEY REFUSED TO HELP WITH THE REPAIRS AS THERE IS NO RECALL ON THIS ISSUE. I AM NOT SURE HOW YOU DON'T RECALL A VERY KNOWN ISSUE THAT I NOW SEE PERSONALLY CAUSES HEALTH ISSUES THAT COULD BE FATAL - PLUS YOU GET WITH A COST THAT THEY ARE AWARE OF. NOT GOOD BUSINESS AND VERY DANGEROUS - IT IS SAD IT MAY TAKE A FATAL ACCIDENT BEFORE FORD RECALLS THIS.

CHAIN DRIVEN WATER PUMP FAILURE AT 85,000 MILES

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS AN OPEN THROTTLE FAILURE THAT CAUSED FUMES TO ENTER THE CABIN OF THE VEHICLE. THE FAILURE WAS SIMILAR TO THAT LISTED IN NHTSA ACTION NUMBER: EA17002 (STRUCTURE, ENGINE AND ENGINE COOLING), BUT THE VEHICLE WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

2014 FORD EXPLORER 3.5 LITER ECO-BOOST >>OIL LINES LEAK AT TURBO , CAUSING OIL TO LEAK DOWN ONTO EXHAUST. VERY BAD SMELL !! THERE IS ALREADY RECALLS FOR NEWER MODELS BUT NOT THE 2014. PEOPLE ARE GOING TO GET HURT. FORD ONLY STATED TO KEEP MY RECEIPTS FOR REIMBURSEMENT IF THERE IS EVER A RE-CALL?

WON'T TURN OFF WHEN TURN OFF BUTTON IS PUSHED TO TURN VEHICLE OFF, WE HAVE TO KEEP PRESSING BUTTON ON GEAR SHIFT AND IT HAS TAKEN 35 MINUTES TO TURN IT OFF WHICH JUST HAPPEND TODAY OCT. 30, 2018 IT HAS RAISED THE DRIVER SEAT TWICE ALL BY ITESELF WHILE THE VEHICLE HAS BEEN TURNED OFF AND NO ONE IS IN THE VEHICLE WHEN THIS HAS HAPPENED. IT MAKES ODD NOISES INSIDE THE DASH WHEN VEHICLE IS TURNED OFF

HEADACHES BY MY HUSBAND AND MYSELF WHILE DRIVING OR RIDING. CARBON MONOXIDE READINGS FIRST TIME READ AT 11PPM ON A 10 MINUTE TRIP. CONTINUAL MONITERING READS AT 6-9 ON NORMAL DRIVING. READINGS AT 14 ON ACCELERATION. I FEEL IT'S UNHEALTHY AND SAFETO DRIVE THIS CAR DAILY.

EXHAUST STARTED COMING INTO REAR OF VEHICLE. WE WERE ABLE TO SMELL IT WHEN THE CAR WAS STOPPED OR MOVING SLOWLY. PEOPLE IN THE BACKSEAT COULD SMELL IT BEFORE THOSE IN THE FRONT COULD.

ALL RECOMMENDED REPAIRS HAVE BEEN COMPLETED ON THE FORD EXPLORER AND EXHAUST FUMES ARE STILL PRESENT IN THE CABIN.

WE BROUGHT THE VEHICLE TO THE DEALER AROUND WITH ABOUT 10,000 MILES ON MAY 2018 STATING WE SMELLED EXHAUST FUMES INSIDE THE VEHICLE. THEY PUT SOME TYPE OF RUBBER PLUGS IN THE LIFT GATE REAR HATCH. THIS DIDN'T CURE THE PROBLEM. BROUGHT THE VEHICLE BACK ON AUGUST 21, 2018 WITH 13,800 MILES AND TOLD THEM WHEN WE TRIED TO ENTER A FREEWAY WHILE ACCELERATING INTO TRAFFIC WITH THE A/C ON THERE IS A VERY PROFOUND ODOR OF EXHAUST FUMES INSIDE THE VEHICLE. THEY STATED THERE WAS A TSB ISSUED FOR THIS VEHICLE BACK IN 2016 FOR THIS ISSUE. BUT UNFORTUNATELY EVEN THOUGH THE CAR ONLY HAS 13,800 MILES ON IT NOW, IT IS OVER THE 3 YEAR WARRANTY PERIOD AND THE EXTENDED WARRANTY WE PURCHASED FROM THEM FOR 50,000 OR FIVE YEARS WON'T COVER IT EITHER. DEALER WANTS TO CHARGE US 1,100 FOR THE REPAIRS. WHICH SHOULD HAVE BEEN COVERED...

EXHAUST SMELL/FUMES WERE NOTICED TWICE ON A 3 HOUR TRIP. PASSENGERS IN THE VEHICLE FELT NAUSEATED AND HAD HEADACHES THAT WERE NOT PRESENT BEFORE THE TRIP AND WERE RELIEVED AFTER EXITING THE VEHICLE.

EXHAUST FUMES COMING IN THROUGH A/C VENT UPON RAPID ACCELERATION. HAD ALWAYS BEEN A PROBLEM SINCE FIRST PURCHASING THE VEHICLE IN 2014. FORD HAS TRIED TO REPAIR PROBLEM FOUR TIMES AND IT IS STILL NOT FIXED. IT IS A DESIGN FLAW THAT FORD HAS NOT ADDRESS SINCE 2011 WHEN THIS MODEL FIRST CAME OUT AND STILL ARE PRODUCING THE VEHICLE WITH SAME DESIGN. THE REASON WHY THE FORD EXPLORER POLICE CARS HAVE MORE ISSUES IS NOT BECAUSE OF ALTERATION WITH THE VEHICLES IT IS BECAUSE THEY DRIVE THE VEHICLES FASTER AND THE HARDER YOU PUSH THE VEHICLE THE MORE YOU WILL NOTICE THE EXHAUST FUMES. THAT'S WHY THERE HAVE BEEN MORE ISSUE'S WITH FORD EXPLORER OLICE VEHICLES. THE ISSUE HAPPENS ALL THE TIME. THE VEHICLES NEED TO BE RECALLED BEFORE MORE PEOPLE GET HURT.

UPON ACCELERATION IN PASSING GEAR THERE'S A FOUL ODOR COMING THRU THE AIR VENTS. IT SMELLS LIKE AN OVER HEATED HAIR DRYER. IT'S BAD ENOUGH THAT THE WINDOWS NEED TO BE OPENED TO LET THE ODOR OUT. MY SUV IS IN THE SHOP FOR THE 2ND TIME IN A YEAR WITH THE SAME PROBLEM. TODAY'S DATE IS 07/02/2018

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 55 MPH, THE STEERING WHEEL FAILED TO MOVE. THE FOLLOWING DAY, THE VEHICLE FAILED TO START AND THE OIL PRESSURE, STARTING SYSTEM FAILURE, TRACTION CONTROL, AND ENGINE COOLANT WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED A LOCAL DEALER (EXPRESSWAY FORD, 3800 HIGHWAY 62 W, MT VERNON, IN 47620, (812) 838-4366) AND WAS INFORMED THAT THE VEHICLE WAS NOT COVERED UNDER A WARRANTY OR RECALL. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT TO HAVE THE VEHICLE TOWED TO THE LOCAL DEALER. ADDITIONALLY, THE CONTACT WAS REFERRED TO NHTSA. THE FAILURE MILEAGE WAS 120,336.

VEHICLE HAS A PROBLEM WITH CAM PHASERS, CAM POSTITION SENSORS & STRETCH TIMING CHAIN

EXHAUST SMELL IN PASSENGER CABIN AFTER HARD ACLERATION!

DURING COMMUTES TO AND FROM WORK, TYPICALLY WITH STOP-AND-GO CONDITIONS AT SLOW SPEED, I BECOME VERY SLEEPY AND INATTENTIVE, ALMOST TO THE POINT OF PASSING OUT. THIS HAPPENED RECENTLY AFTER HAVING THE CAR SERVICED FOR OIL CHANGE AND A STANDARD 15-POINT INSPECTION.

STRONG EXHAUST ODOR CAN BE SMELLED IN THE CABIN SHORTLY AFTER STARTING THE VEHICLE AND WHILE DRIVING. THIS ODOR CAUSES NAUSEA AND LIGHTHEADEDNESS WHILE IN THE VEHICLE. DRIVING WITH THE WINDOWS OPEN DOES HELP TO DISSIPATE THE SMALL BUT DOES NOT TAKE IT AWAY COMPLETELY.

I DRIVE MY FORD EXPLORER ALMOST EVERY DAY AND I WAS BECOMING PROGRESSIVELY FATIGUED AND DIZZY ( LOSS OF NORMAL BALANCE). I COULD NOT PIN PONT THE PROBLEM AREA UNTIL I RECEIVED AN "URGENT RECALL NOTICE" FROM OUR REGULAR FORD DEALERSHIP IN BELVIDERE, ILLINOIS. MY DOCTOR ORDERED A SPECIAL BLOOD TEST WHICH CONFIRMED A HIGH LEVEL OF CARBON MONOXIDE IN MY BLOOD. THE VEHICLE WAS REPAIRED BUT I STILL HAVE SOME AMOUNT OF THE HEALTH PROBLEMS. THANKS, JIM

SMELL EXHAUST IN CABIN UNDER ACCELERATION WITH HVAC SYSTEM ON ESPECIALLY IN RECIRCULATE MODE. VEHICLE HAS BEEN TO DEALERSHIP 5 TIMES WITH THE CURRENT SERVICE BULLETINS PERFORMED AND CAN STILL SMELL EXHAUST IN THE CABIN. THE VEHICLE WAS UNDER WARRANTY WHEN FIRST REPORTED AND THE ISSUE NOT RESOLVED AND FORD SAYS THAT'S ALL THEY CAN DO.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 65 MPH, THE 18-MONTH OLD CHILD, WHO WAS IN A SAFETY SEAT ON THE REAR PASSENGER SEAT, BECAME UNRESPONSIVE. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE CONTACT CALLED 911. THE CHILD WAS TAKEN TO THE EMERGENCY ROOM WHERE THE DOCTOR RAN SEVERAL TESTS, BUT WAS UNABLE TO DIAGNOSE WHAT HAPPENED TO THE CHILD. THE CHILD RECOVERED AND WAS RELEASED FROM THE EMERGENCY ROOM. THE CHILD WAS TAKEN BACK INTO THE VEHICLE AND, FIVE MINUTES INTO THE DRIVE BACK TO THE CONTACT'S RESIDENCE, THE FAILURE RECURRED. THE CHILD BECAME RESPONSIVE WHEN THE CONTACT ROLLED DOWN THE WINDOW. THE CHILD WAS TAKEN TO THE PEDIATRICIAN WHO RULED OUT THAT THE CHILD MIGHT HAVE SUFFERED A SEIZURE. BOTH THE MOTHER AND THE PEDIATRICIAN SUSPECTED THAT THE CHILD MIGHT HAVE SUFFERED FROM CARBON MONOXIDE POISONING. THE DEALER...

I AM WRITING TO YOU IN REGARDS TO PHYSICAL ILLNESS THAT I HAVE SUFFERED AS WELL AS MY PASSENGERS FROM MY 2014 FORD EXPLORER POLICE INTERCEPTOR PACKAGE. STARTING BACK WHEN I FIRST PURCHASED THE VEHICLE AT APPROXIMATELY 59,000 MILES, I HAVE EXPERIENCED AN EXHAUST ODOR IN THE CABIN SHORTLY AFTER ACCELERATING OVER 3,000RPMS. THIS ISSUE HAS BEEN INVESTIGATED AT MY LOCAL DEALERSHIP TWICE, WITH THE TECHNICIAN CONFIRMING THE SMELL. AFTER THIS WORK WAS PERFORMED, I STILL TO THIS DAY AM SUFFERING FROM EXHAUST FUMES AND PHYSICAL ILLNESS DIRECTLY RELATED TO MY FORD EXPLORER. ALL REPAIR ORDERS FROM INVOLVED FORD DEALERSHIPS ARE IN MY POSSESSION CONFIRMING EXHAUST FUMES ARE STILL ENTERING THE CABIN. FROM THE TIME I TOOK OWNERSHIP IN OCTOBER 2016, I HAVE EXPERIENCED PHYSICAL ILLNESS WHEN DRIVING THE VEHICLE FOR MORE THAN 1 HOUR AT A TIME. I GET EXTREMELY LIGHTHEADED AND NAUSEATED, WHICH HAS CAUSED ME TO FREQUENTLY...

DRIVING ON HIGHWAY APPROX 65 MPH IN RAIN. SUDDEN LOSS OF POWER STEERING, MESSAGE ON DASHBOARD INDICATING CHECK CHARGING SYSTEM, THEN HILL ASSIST FAILURE, THEN WARNING MESSAGE THAT ALL ACCESSORY POWER WAS DISABLED TO CONSERVE POWER. THEN ALL LIGHTS ON DASHBOARD LIT UP. LOSS OF POWER STEERING IN RAIN ON HIGHWAY ALMOST CAUSED VEHICLE TO LOSE CONTROL AND BE INVOLVED IN MULTIPLE CAR ACCIDENT. SERPENTINE BELT WAS FOUND TO BE IN PROPER CONDITION, AND WAS ABLE TO DRIVE HOME ALTERNATE ROUTE ALONG 35MPH ROADS. NO FURTHER PROBLEMS ASIDE FROM OCCASIONAL SQUEAK UNDER ACCELERATION. IMMEDIATELY FOLLOWED UP WITH SERVICE CALL, SERPENTINE BELL WAS IN GOOD CONDITION, BUT BELT TENSIONER SPRING HAD FAILED. VEHICLE HAS ONLY 57,000 MILES. SEEMS EXCESSIVELY EARLY FOR THIS TYPE OF PART TO FAIL.

STRONG EXHAUST SMELL IN THE CABIN OF THE SUV. EVERY TIME THE ACCELERATOR IS PRESSED FOR A ACCELERATION THAT IS FAST A STRONG EXHAUST SMELL IS NOTICED IN THE CABIN OF THE SUV. THIS IS THE SAME SMELL THAT COMES FROM THE EXHAUST PIPES.

EXHAUST LEAK INTO VEHICLE

EXHAUST FUMES IN CABIN WHEN ACCELERATING AT HIGHER SPEEDS, ESPECIALLY WHEN ENTERING INTERSTATE AND PASSING CARS AT HIGHER SPEEDS.

THIS IS A FOLLOW UP TO NHTSA ID 11019920 FILED 8/26/17. EXHAUST ODOR, SMELLS LIKE SULFUR, STRONG, PUNGENT, COMING THROUGH DAHS BOARD VENTS DURING SUSTAINED ACCELERATION AND SHORTLY AFTER. THE PROBLEM IS REPEATABLE EVERY TIME: PUT VENT SYSTEM IN RECIRCULATION MODE, SUSTAINED ACCELERATION OVER 3,000 RPM, WAIT 5 SECONDS, STRONG SULFUR ODOR COMES THROUGH DASH BOARD VENTS. I AM NOW EXPERIENCING HEADACHES ON A CONSISTENT BASIS AS I HAVE BEEN DRIVING THE VEHICLE MORE OFTEN FOR COMMUTING SINCE PURCHASING IT IN MARCH 2017 WITH 25K MILES. I AM SEEING A DOCTOR AND AM BUILDING A CASE FOR MORE SEVERE HEADACHES WITH INCREASED DRIVING IN MY EXPLORER. TODAY, I DECIDED TO LOOK UNDER THE VEHICLE - I AM INCLUDING PHOTOS OF THE EXHAUST MANIFOLD WHICH SHOWS A CRACK NEAR THE PIPE-TO-FLANGE CONNECTION. AND, NO, MY VEHICLE IS NOT A POLICE CRUISER AND IT DOES NOT HAVE AFTERMARKET PARTS INSTALLED. HOW MANY...

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THE ENGINE SURGED AND CAUSED THE VEHICLE TO ACCELERATE UNEXPECTEDLY. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE DRIVER WAS ABLE TO PLACE THE GEAR IN NEUTRAL AND MANEUVER TO THE SIDE OF THE ROAD TO SAFELY STOP THE VEHICLE. A COMPLAINT WAS FILED WITH THE MANUFACTURER AND THE CONTACT WAS PROVIDED CASE NUMBER: CAS-13346113-C5W0T8. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 34,000.

WHEN EVER I EXHILARATE I CAN SMELL EMISSIONS IN MY CABIN OF MY TRUCK TO THE POINT THAT I HAVE TO OPEN THE WINDOWS OR ILL GET DIZZY AND HEADACHES. AT LOW SPEEDS AND HIGH SPEEDS AS WELL.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT CARBON MONOXIDE ENTERED THE VEHICLE THROUGH THE VENTS. THE CONTACT WAS ALERTED BY THE CARBON MONOXIDE DETECTOR INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO JOHN BLEAKLEY FORD IN LITHIA SPRINGS, GA 30122 (PHONE (770) 941-9000). THE DEALERSHIP REPLACED THE VENTS AND THE EXHAUST SYSTEM; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

MY 2014 EXPLORER HAS BAD FUME SMELLS IN THE CABIN WHEN ACCELERATING TO PASS VEHICLES. I HAVE TAKEN IT TO THE DEALER ONCE TO HAVE IT REPAIRED BUT IT STILL DOES IT. I HAVE ALSO HAD A FUME SMELL IN MY NOSE THAT IS THERE WHEN I AM NOT IN THE CAR. I DIDN'T KNOW WHAT IT WAS AND AM SCHEDULED FOR AN MRI BUT I HAVE RECENTLY REALIZED THE CAR CABIN SMELLS THE SAME AS THE SMELL IN MY NOSE.

I PURCHASED MY USED 2014 FORD EXPLORER SPORT IN JANUARY 2017. IT IS IN EXCELLENT CONDITION, HOWEVER I HAVE DISCOVERED THAT MY VEHICLE EMITS A SULPHUR "ROTTEN EGG" SMELL WHEN I ACCELERATE TO A HIGH SPEEDS. AFTER RESEARCHING THIS ISSUE, I FOUND THAT IT IS A COMMON PROBLEM WITH FORD EXPLORERS BETWEEN YEARS 2013-2017 AND MAY BE AN EXHAUST ISSUE. I HAVE A WARRANTY ON MY VEHICLE, BUT NOTICED THIS IS NOT COVERED PART AS PART OF MY WARRANTY PACKAGE AND THERE IS CURRENTLY NOT A FORD RECALL ON THIS ISSUE. THIS IS UNSAFE AND A PROBLEM FOR MANY OWNERS LIKE ME. I DO NOT FEEL SICK WHEN I DRIVE MY CAR, BUT HAVING EXHAUST CHEMICALS IN THE AIR WHEN I DRIVE CAN POSE A SERIOUS THREAT AFTER REPEATED EXPOSURE AND COULD POTENTIALLY CAUSE SERIOUS HEALTH PROBLEMS FOR ME AND OTHER PASSENGERS. IT IS AN ISSUE THAT IS CLEARLY OBVIOUS...

I HAVE THIS CAR FROM 2014 AND IS AN EXHAUST FUMES AND CARBON MONOXIDE WAFTING INTO THE CABIN, THE DEALER TRIED TO REPAIR IT SEVERAL TIMES, SEALING THE REAR END, REPLACING THE EXHAUST BUT THE PROBLEM PERSIST, THEY ARE CURRENTLY WORKING ON ANOTHER SOLUTION, I DO NOT KNOW WHAT TO DO NEXT, THEY ALWAYS TRY TO AVOID THE PROBLEM THANKS RODRIGO DIAZ

EXPERIENCING STRONG EXHAUST FUMES INSIDE CABIN WHEN RUNNING HEAT OR AC. THE SMELL IS MORE PROMINENT WHEN VEHICLE IS SITTING STATIONARY WITH ENGINE RUNNING.