2018 FORD EDGE Engine Problems

I own a 2018 Ford Edge SEL 2.0L EcoBoost (VIN: [XXX] ). On August 24, 2021, with approximately 72,062 miles, the vehicle was taken to a Ford dealership due to engine performance issues. The dealership diagnosed coolant intrusion into the engine cylinders. The dealership determined the engine was not repairable and required full engine replacement. The repair invoice explicitly states coolant present in the cylinder and replacement of the engine was necessary. I paid $5,602.85 out of pocket for the repair. The vehicle was properly maintained, and I have oil change and service records from that period. No warning or misuse contributed to the failure. I later contacted Ford Motor Company to request reimbursement, as this failure appears consistent with the widely reported 2.0L EcoBoost coolant intrusion defect affecting similar Ford vehicles. Ford declined assistance, citing mileage and timing, and stated no active recall applied. I am submitting this complaint...

The contact owns a 2018 Ford Edge. While the contact's husband was driving at an undisclosed speed, the check engine warning light illuminated. In addition, when the vehicle was started, there was an abnormal rumbling sound coming from underneath the hood. The vehicle was taken to the dealer, where it was diagnosed, and DTC: P0303 and P0316 were retrieved. The failure was not acknowledged by the dealer at the time. The contact was informed that the vehicle was repaired. The contact stated that a tune-up was performed, and the coolant reservoir was refilled; however, the failure reoccurred. The vehicle was diagnosed with engine failure, and the contact was informed that the engine needed to be replaced. The vehicle was repaired. While speaking with the dealer, the dealer confirmed that the initial repair had not resolved the issue. The contact was notified of an unknown TSB regarding the failure. The contact...

Coolant is rapidly leaking into the number 2 cylinder causing rough idle, extreme venting form exhaust. Vehicle cannot be driven without causing catastrophic engine damage which could result in loss of power creating a safety issue, or engine fire. Ford knows about the design defect for years and refuses to recall the affected vehicle. The photos below are not my vehicle. They were downloaded from the internet. This is a known problem that Ford refuses to acknowledge.

I am submitting this complaint to report a serious engine defect involving coolant intrusion into the engine cylinders on my 2018 Ford Edge. The vehicle was inspected by a Ford-authorized dealership after engine performance concerns. Diagnostic testing confirmed positive combustion gases in the cooling system, indicating internal coolant leakage into the engine. The dealership has stated that the only recommended repair is replacement of the long block (engine). This condition is consistent with a known defect affecting Ford 2.0L EcoBoost engines, which Ford has acknowledged through Technical Service Bulletin 22-2229. Despite this acknowledgment, no recall has been issued for this vehicle. This defect poses a significant safety concern, as it can lead to: - Engine misfires and loss of power - Sudden engine failure while driving - Potential stalling or inability to safely operate the vehicle The failure occurred at approximately 63,110 miles, which is unreasonably low for catastrophic engine...

I have a 2018 Ford Edge. In late October of 2025 my engine light illuminated. The diagnosis was a P301, indicating a misfire in cylinder one. Spark plugs and cylinder 1 coil was replaced. No problems until December and engine light came on again, same code. Coil was replaced again and in January engine light came on again. Ford released TSB 19-2346 on 12-19-19 describing a possible coolant leak in to the cylinders and a engine replacement was suggested. I feel a recall is necessary to prevent safety issues created by slower than normal acceleration and /or engine fires.

The coils kept popping up check engine light. And turns out it was an injector failing, and cause my car to jerk a lot, and not accelerate when needing. My car would almost try to stop accelerating while on highway and jerk so much that it felt like I was going to wreck on the middle of a freeway.

Have had to fill up coolant 2x a week. Starting to smoke real bad on start up. Leading me to believe I’ve got a coolant intrusion on my hands

Ford has a known problem with Ecoboost engines can leak coolant into the engine’s valves. This happened to our vehicle and we had to replace the engine due to misfiring cylinders. The check engine light kept coming on. We intially replaced all spark plugs and coils. Then after that didn't resolve the problem, the entire engine had to be replaced.

My ford edge has a problem where coolant mysteriously disappears a flood like it’s getting vacuumed into engine cylinders causing the engine to run rough with white smoke coming from exhaust. This is on my 2.0l turbocharged ecoboost engine and I have already seen other consumer reports about other having the same issue all over social media and Ford will not do anything about it and will charge you almost $10,000 dollars for something that was their fault. They made a mistake in creating the engine block and thus now many people are suffering because of this.

2.0L EcoBoost engine - while driving the 2018 Ford Edge with approximately 50K miles, the vehicle displayed a rapid overtemp condition and then a check engine light for a misfire on cylinder 2. Coolant was almost empty and I re-filled the resivoir and dealer reset the check engine light. This happened about two more times with the coolant resivoir along with multiple check engine lights for the #2 cylinder. Each time the Ford dealer reset the check engine light for the #2 cylinder but did not give information about why the coolant level was dropping to almost zero. I went to a different dealer who referred me to the Ford TCB 22-2229. I Spoke to Ford customer service directly and the engine long block was replaced at my expense since Ford would not pay for the repair.

The defect involves the engine block or cylinder head design, which allows engine coolant to intrude into the engine's combustion cylinders. Coolant mixing with the engine oil will cause a catastrophic failure and can lead to an engine fire. Ford has issued Technical Service Bulletins TSB 19-2346 but it does not cover any cost and no recalls have been issued. This is a known manufacturing defect in which Ford is taking no accountability.

2018 Ford Edge with 119K miles. Issue has been determined to be the known issue of coolant intrusion into the cylinders. The issue was noticed while stopped at a traffic light, vehicle started "reving" and showed RPM fluctuations. On two separate occasions, the vehicle lost all ability to accelerate while driving. It's also has white smoke coming out of the exhaust and has been losing coolant at an alarming rate. After multiple inspections and other attempted fixes (water pump replacement, spark plugs replaced, fuel pump replaced), it's been determined that the coolant intrusion is to blame. The vehicle is deemed unsafe to drive in the current state and extended warranty is no longer in affect due to the mileage.

The contact owns a 2018 Ford Edge. The contact stated that while attempting to start the vehicle, the engine hesitated to turn over. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed with a coolant intrusion in the engine. The vehicle was not repaired due to the costs. The manufacturer was made aware of the failure. The failure mileage was approximately 89,000.

Coolant leak into the cylinders of an ecoboost engine. Coded out. Inspection found that the coolant had been pulled into the engine. No recall, needs entire engine replaced.

2018 Ford Edge engine size 2.0 ecoboost has a coolant intrusion that Ford is well aware of but refuse to help customers with the problem. Engine could fail while driving on the highway but they have not issue an emergency recall for it.. This is a very serious manufacture error on behalf of Ford Motor.

The problem began in early August 2025 when the check engine light came on and the vehicle misfired. A Ford mobile technician inspected it before 8/23/25, confirmed Diagnostic Code P0303 (Cylinder 3 Misfire), but said it was likely just a bad ignition coil. Based on that, I went to Midas on 8/23/25 for a tune-up and coil check. On 9/29/25, the check engine light returned and for the first time the coolant over-temperature warning illuminated. Midas confirmed coolant intrusion into Cylinder 3: borescope and pressure test showed leakage, leak-down test failed with air entering the coolant reservoir, and visible coolant loss was present. At 80,445 miles, the engine was deemed unsafe and required full replacement. Hawk Ford confirmed no warranty extensions or programs applied. The repair cost was $10,500 out of pocket. This defect matches Ford TSB [XXX] , is widely reported in EcoBoost engines, and creates a serious safety...

There is a coolant intrusion into the cylinder bores of the engine. This has been confirmed by VanBortel Ford in East Rochester NY. When the issue first occurred the engine light came on and the vehicle would no longer run properly.

My car started overheating this morning. Took it to my mechanic & he told me I had a cracked head gasket where coolant was leaking. He thought there was a recall/notice about some coolant issues. Sent me to our local Ford dealership; they said my vehicle wasn't covered under any recalls. But there is a notification about this very issue. I attached a screenshot of the exact issue listed online that matches my problem.

Driving felt weird like the vehicle was stuttering and I heard liquid sloshing around as I was driving. Check engine light came on and turned off again on its own on 2 separate occasions within 2 weeks. The first time it came on, I made an appointment at the service center but the check engine light had gone off by the time I brought it in. I was told they couldn't diagnose it if the check engine light was off. When it came on again, I took it to my local Ford service center and they diagnosed it with coolant leaking into the cylinder, causing a misfire. The recommended solution is a full engine replacement costing over $8,000. Apparently this is a known issue and a service bulletin was issued in 2022 (before I bought the car used) but Ford is refusing to issue a recall. The car only has...

Our 2018 Ford Edge started idling rough after spark plug change and after dealer tested it they told us it had engine coolant in #2 Cylinder and that driving it could lead to catastrophic engine failure. Only fix is complete engine block replacement (Recommended by Ford in Bulletin TSB22-2229) along with new turbo as it may also have been damaged by coolant leak. (Could also damage catalytic converter. This is a known default due to design fault in 2.0 litre engine. Since vehicle is off warranty, the repair replacement is going to cost over $10,000.00. I understand this is affecting a serious number of Ford customers with this engine, a number of which have been quietly replaced under warranty. I feel Ford owes their customers replacement costs on this issue and a recall should be issued. If ones motor seizes up suddenly while driving it could result in injury or...

The engine failed before 55,000 miles. Collant is getting into the engine and causing a cylinder failure. This is a known problem for this engine. The Ford mechanic and other mechanics stated that they no longer use that engine due to the problem. Since I did not purchase an extended warranty, Ford is requiring nearly $12,000 to replace the engine. Started rough 1 morning, then ran fine within 1 mile. Next start was smooth, but the check engine light came on. The check engine light did not stay on consistently. The next time it felt rough, I took it into Ford to see what was happening.

Now have had my battery replaced twice for some weird reason my car keeps dying when nothing appears to to have been left on inside the vehicle. My Ford edge titanium 2018 has the settings that shit down the wngine with a 30 second shut down and same with anything left in it shuts it off. So why is my car constantly dying with a new battery is my vehicle pat if the 80 something Ford edges that has connection issues with the alternator etc. please help with already two recalls that my vehicle has but can’t be replaced due to parts not ready for repairs by ford. Help!!!

The car has been having a chemical smell when it starts. I recently was driving from San Antonio, Texas to Austin, Texas and received a warning that my car was overheating. The warning went off immediately and I continued driving it. A few days later, I got an oil change and was told that I had no coolant in the vehicle. They filled the coolant for me. I continued driving the car. This week, the car was shaking pretty violently when I turned on the ignition. I proceeded to drive it and it drove normally. The following day, a check engine light came on. I took it in to see a mechanic that day and they confirmed that I had a coolant intrusion problem caused by the 2.0L Eco boost engine which is defective and allows coolant to escape into the engine injectors. Ford is not taking any responsibility for...

Coolant intrusion defect. The engine coolant leaks into the combustion chamber, due to a failure in the engine block design. TSB 19-2346 issued by Ford addresses this known and serious issue for my 2018 Ford Edge, 2.0L EcoBoost engine. In 2024, I purchased a used, 2018 Ford Edge with 49k miles. A few months after I purchased this used vehicle at a dealership, my Check Engine light came on. The vehicle showed other symptoms of white smoke, coolant loss, misfiring and rough idle. I brought my car to a local dealership (not the same dealership that I purchased the vehicle) and they confirmed the coolant intrusion defect. When I purchased the vehicle, it didn't come with a warranty. I tried getting help from by calling Ford Customer Service, and they offered no goodwill assistance and no coverage assistance at all. I ended up having a new engine put in my...

At 77,000 Kilometers, check engine light came on, during inspection it is observed that there is an active coolant intrusion leak in cylinders 1 and 3. This is a Ford Edge 2018, with a 2.0L Ecoboost engine. The car is undriveable and needs a full engine replacement.

Cylinder misfire, caused coolant intrusion into cylinder caused by defective motor wall. This could have caused by engine to lock up while driving and cause an accident. Luckily I was able to get it to the dealer before that happened. FORD is aware of this defective motor in these models but has refused to issue a recall. My car is a 2018, however, the car ONLY has 50,000 miles on it. I want others to know of this danger. These engines should be recalled before someone is hurt in crash due to this defect.

2018 ford edge with 2.0 ecoboost engine over heating leaking coolant into cylinders caused engine failure. Lucky this did not catch fire. Ford knows the issue and will not put out a recall. Very dangerous and disgusting business practice.

I had a Cylinder misfire (code P0302) due to coolant intrusion into the engine cylinder. This was due to a crack in the engine block. This is a common issue with the 2.0L ecoboost engine. No recall. Ford's fix was for me to replace the long block engine with a redesign version to fix the casting problem. This cost was covered by me, even though this is a known common issue by Ford that requires an engine replacement. The engine had 78,193 miles on it, so it was out of warranty. Repair cost me over $7,000. There is are currently lawsuits due to this case and engine. [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car has a coolant leak and has been diagnosed as having coolant intrusion. I was told that there is a recall but it doesn’t include my VIN

On August 19, 2025, Koons Woodbridge Ford determined my 2028 Ford Edge requires a long block replacement due to coolant intrusion into cylinder 3, per customer invoice RO# [XXX] Tag# [XXX]. This is a known issue, which is documented by technical service bulletin 22-2229. Aimee DePugh, Koons Woodbridge Ford Service Advisor, informed me that I should contact Ford to request reimbursement. However, the guidance I received was to send the dealership service manager written correspondence requesting the dealership restore the engine at their expense because of the known engine design flaw. I sent the dealership a note via their online portal on August 20, 2025. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have a 2018 Ford Edge Titanium Eco Boost with 115,000 miles on it. I bought it used in 2018 with 17,000 miles on it. The engine light came on and I took it to a repair shop. The codes are p0303 and p0316. They inspected the cylinder and there is coolant leaking into cylinder 3. Apparently this is very common for this vehicle and is described as a design flaw. With this problem being very common and a known design flaw from Ford, I strongly encourage a recall.

2018 Ford Edge, 79K miles. Check engine light came on and I immediately had it checked out. It was misfiring, spark plugs were replaced to attempt to fix the issue. Light came back on a few weeks later, it was discovered that coolant was leaking into cylinder 3 and causing the misfire. Ford recommends that the engine be replaced. This appears to be an issue that Ford is very aware of and many Ford Edges are affected, yet there is not a recall. This defect may lead to overheating and can result in the cylinder head cracking, total engine failure, and/or engine fires. This puts me and other drivers at significant risk and I am very displeased with Ford.

This car hesitates, engine light indicates misfire. Dealer confirms coolant leaking into the engine. I find out now this is a well known and widespread problem with Ford engines in this era. The car is unsafe to drive due to impending sudden and complete engine failure.

Vehicle was taken in for service after the check engine light illuminated. Upon inspection, it was determined that coolant is leaking into the No. 2 cylinder, requiring a complete engine replacement. This is a serious safety concern, as engine failure can occur without warning. The vehicle is a 2018 model with only 51,159 miles, purchased new from the local Ford dealership, and should not be experiencing a major engine failure at such low mileage.

There is coolant leaking into my engine because the Eco Boost engines malfunction. My entire engine has to be replaced. This has already been reported as a huge issue for years and years. It needs to be a recall. TSB 19-2346

The contact owns a 2018 Ford Edge. The contact stated that while attempting to start the vehicle, the engine failed to turn over. There were several unknown warning lights illuminated. The vehicle was towed to a local independent mechanic to be diagnosed, and the contact was advised that the engine was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 140,000.

Found trouble code PO304 in the computers history indicates that the misfire is not coming from the spark plug or ignition coil. Checked the fuel injector and no problem was found. Removed cylinder#4=spark plug and found a small amount of evidence that coolant is entering the cylinder. There is a TSB for engine blocks cracking and causing the problem. This was found by the auto service I use. Called dealership and was told this does happen. A new engine would have to installed if my engine light comes back on. They would have put in the same type of engine! REALLY? Wouldn’t this happen again with a new engine? I do not know how to download the service slip

On July 20,2025, at about 4:30pm to 5:30pm, I drove less than two blocks from home when the engine light and the overterature light came on suddenly. Simultaneously, the vehicle began to shake. I was about two to three blocks from an Auto Zone parts supply store. I drove there slowly. Once at the location, I asked for assistance in determining what caused the issue with my car. The representative used a device that indicated that check engine failed, and emission ready status was no. I was advised to purchase coolant for my model vehicle. Once purchased, the representative tried to fill the reservoir. However, the reservoir indicated that it was full after using less than half of what was in the gallon bottle. We waited a while to determine if the level would decrease. While at the store, the level remained constant at the full level. He recommended that...

Engine has coolant intrusion Drivers seat belt will lock periodically

Check engine light came on and car stalled. The fault was a misfire in cylinder 2 and 3. When I checked vehicle out coolant was low and coolant leaked into cylinder. Checked online and saw thousands of complaints for the same thing

I own a 2018 Ford Edge with the 2.0L EcoBoost engine. My engine recently failed and was diagnosed by a Ford dealership as suffering from coolant intrusion into the cylinders. This has resulted in engine misfires, overheating, coolant loss, and eventually a non-functional engine. This appears to be a widespread and well-documented issue across multiple Ford models and years, due to a design flaw in the engine block or head gasket area that allows coolant to enter the combustion chamber. I was not notified of any recall or service bulletin, yet this issue has caused major financial and safety concerns. There is currently a class-action lawsuit related to this defect, and Ford has not issued any official remedy despite knowing of the issue for years. I am submitting this report in hopes that NHTSA will investigate this defect and urge Ford to issue a recall or remedy before more consumers...

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, there was white smoke coming from the exhaust and the check engine warning light illuminated. The contact parked the vehicle and inspected the vehicle. The contact noticed that the oil was milky. The vehicle was taken to an independent mechanic, where it was diagnosed with a misfire and a coolant leak into cylinder #1. The contact was informed that the coil packs needed to be replaced. The vehicle was not repaired. The vehicle was driven to the residence. The contact researched and determined that the symptoms indicated that the failure was caused by a blown head gasket. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. In addition, the contact stated the vehicle was not drivable. The manufacturer was made aware of the failure, and a case was filed. The...

Computer error P0304 - misfiring in cylinder 4. Diagnosed with a coolant leak into the cylinder. Potential Safety Issues: Loss of Power: A misfire can cause sudden power loss, particularly during acceleration or at high speeds, increasing the risk of accidents, especially in traffic or on highways. Engine Stalling: If the misfire worsens, the engine may stall, leaving you unable to control the vehicle, which is dangerous in busy areas or intersections. Overheating Risk: Coolant intrusion into cylinder 4 (as noted in TSB 22-2229) can lead to overheating if the cooling system is compromised, potentially causing engine failure or fire hazards. Catalytic Converter Damage: Persistent misfires can overheat and damage the catalytic converter, potentially leading to a fire risk under the vehicle. Beyond this, it is my 17 year old daughter driving this car and she could be stranded some place unsafe due to not starting or in the middle...

Hello, I have had this Ford edge for about two years. My first year it started giving me problems so I took it in and they told me that I needed a whole new engine which is shocking because I just got it, as I saved for money they told me it should last a little bit longer, so I held it off for a little bit and recently it started to jump every time I was at a stoplight or a stop sign and sometimes just completely shut off, so I took it in again and they told me that I need a whole new engine and that there are no recalls on my car so I did some research and I’ve noticed that a lot of people have problems with the exact same thing that I do on their 2018 Ford edge. I’m really just hoping that there...

The coolant system leaked into the engine causing over heating while driving on the interstate causing the engine to stop running while passing a having to pull to the side of the road while cars were dodging me and I was almost rear-ended by a semi-truck. We took it to a independent service center and it was confirmed. This car was sold to me by a Martinez Auto Sales person names Luis Ramirez. He told me the car was in good condition. I got 30 miles off the lot before the occurrence. I took the car to a independent service center and have later found that the car was confirmed to have this issue by Team Ford in Dennison IA on August 15th 2024. My incident took place on [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My check engine light came on. Took it to my mechanic. Had a misfire on cylinder 1. Replaced coil and spark plugs. Check engine light came back on. Replace coil again. Check engine light came back on. Engine now needs replaced because of a coolant intrusion issue. Ford is aware and has posted a TSB 19-2346, but will not assist with it getting replaced.

2.0L Ecoboost Engine. At 58,000 miles coolant leaking into cylinder. Creating fumes and dangerous possible engine failure situations. Service department at Ford Dealer has diagnosed and confirmed the problem with engine rebuild/replacement. The recommended solution at $12,000 in repairs. Vehicle in past warranty period.

Presence of coolant in engine cylinders

The 2018 Ford Edge I currently own and according to my research, there have been several class action suits that have been filed due to the customer experiencing "coolant intrusion" into the engine rendering the vehicle useless without repair. My vehicle only has 50,000 miles on it and needs $6-7,000.00 worth of repairs to correct the problem. The current resale value without this issue is $10-13,000.00 but is now worth basically scrap. Cases that have been filed are Case [XXX] [XXX] et al. v. Ford Motor Co. in the United States District Court Eastern District of California. According to this case it states, "It pertains to 2013-2019 Ford Escape, 2013-2019 Ford Fusion, 2015-2018 Ford Edge, 2016-2019 Lincoln MKC, and 2016-2019 Lincoln MKZ models equipped with the 1.5L, 1.6L, and 2.0L EcoBoost engines, specifically, citing coolant intrusion as its chief focus." There are similar cases filed in U.S. District Court for...

Coolant Intrusion in Cylinder 3; Engine Liight remains on after Engine Tune Up w/ 48.2K Miles. Rough idle, White tail pipe vapor on cold start, Code P0303,. Cylinder 3 Misfire are symptoms. 4) Plugs, Air Filter, Cylinder 3 Ignition Coil Pack replaced, Fuel System cleaner added to 2) fuel refills. Car Battery replaced. Engine Light returned after battery replacement. Symptoms Resembles Ford TSB 19-2346, dated 12/19/2019