2006 DODGE RAM 2500 Electrical System Problems

Headlights- the passenger side headlight would come on then go off whenever it wants to and now the low beam does not work. I have tested the connection and replaced the bulb several times and still does not work. When driving at night it makes it difficult to see. And is also against the law to not having working headlights. Trailer lights- the drivers side brake light/blinker on any trailer that’s hooked to my truck does not work. I have taken it the a local shop (street dynamics which is out of business now) several times over the last 5 years to see if they can fix the issue. The fix was to put a jumper wire from the truck brake light to the trailer connector. I still do not have a blinker on the driver side of the trailer. Windshield wipers- the windshield wipers will come on and off...

The TIPM module is bad. This part controls quite a bit of electrical current to various areas of the vehicle. It stalls when stopped at a traffic light, it is not sending the brake light information to an attached trailer (left side only), gauges inside the vehicle have stopped working (to name a few of the items being affected by this control). This part can be inspected as it is currently still on the vehicle. Safety is a concern due to either not being able to move out of the roadway, and also when pulling a trailer as no one will see turn signals or brake lights on the tow vehicle as the power isn't going to the trailer lights. I was informed of the malfunction at a trailer dealership. The problems have been getting worse over the last 4 years of ownership of this vehicle. The check engine light...

I WAS DRIVING ON I-75 @70MPH, A LOUD BANG HAPPENED, TRUCK SHUT OFF, I GUIDED IT OFF THE ROAD. I HAD WIRES HANGING I LOOKED FURTHER AND SEEN THE FRONT DRIVE SHAFT BLEW APART. MY MECHANIC SAID IT HAD LOCKED UP. THE TRANSFER CASE, TRANSMISSION, FLOOR BOARD OF THE TRUCK WAS ALSO ALL DAMAGED. ALSO SAID I WAS LUCKY THAT THE TRUCK DID NOT CAUSE A SERIOUS ACCIDENT. THIS TRUCK IS A 2006 DODGE RAM 2500 HD. WELL TAKEN CARE OF. NO GIVEN REASON WHY THIS HAPPENED. MY MECHANIC SAID HE HAS SEEN THIS MANY TIMES IN THE DODGE TRUCKS THAT THE FRONT DRIVE SHAFT BLOWS APART. TOTAL DAMAGES WILL BE THE COST OF $8,000-$10,000

BLINKERS WILL TURN ON IN OPPOSITE DIRECTION OF WHAT LEVER IS APPLIED. RIGHT TURN SIGNAL COMES ON WHEN YOU TURN LEVER TO LEFT TURN. WINDSHIELD WIPERS RUN INTERMITTENTLY WHEN ON.

AIRBAG LIGHT CAME ON, A/C & SEAT HEATERS WON'T WORK. COLD START IN MORNING, AIRBAG LIGHT GOES OFF, A/C WORKS & SEAT HEATERS OK. TURN ENGINE OFF, NEXT START OF ENGINE, AIRBAG LIGHT ON, NO A/C OR SEAT HEATERS UNTIL NEXT MORNING. FIRST TIME THIS INCIDENT OCCURRED VEHICLE WAS STATIONARY, IN STORE PARKING LOT. AIRBAG LIGHT ON DURING TRIP HOME. AIRBAG INOPERABLE WHEN LIGHT IS ON.

COMPUTER CONTROLED VEHICLE CHARGING SYSTEM CAUSED THE PASSENGER SIDE BATTERY TO OVER CHARGE (DASH GAUGE INDICATING OVERCHARGING) AND SWELL CAUSING IRREPARABLE DAMAGE AND EXPLOSION OF THE BATTERY. THIS COULD HAVE STARTED AN ENGINE FIRE UNDER THE HOOD. FORTUNATELY IT DIDN'T. VEHICLE WAS ON MAIN INTERSTATE HIGHWAY WHEN THIS OCCURRED. I CONTACTED THE BATTERY MANUFACTURER THINKING IT WAS A BAD BATTERY, BUT THE TECHNICIAN STATED DODGE CHARGING SYSTEMS OF THIS PERIOD WIRED THE BATTERIES IN PARALLEL INCORRECTLY CAUSING THE AUX BATTERY TO OVERCHARGE WHILE THE MAIN BATTERY WAS READING UNDERCHARGED. "BATTERIES IN TRUE PARALLEL SHOULD BE CONNECTED NEGATIVE TERMINAL TO NEGATIVE TERMINAL AND POSITIVE TERMINAL TO POSITIVE TERMINAL." THE DODGE RAM 2500 24V CUMMINS I OWN (COMPLETELY STOCK) HAS THE NEGATIVE TERMINAL CABLE FROM EACH BATTERY CONNECTED DIRECTLY TO THE ENGINE BLOCK FOR GROUND. AND NOT CONNECTED TO EACH OTHER AT ALL. AGAIN, A PROPERLY WIRED PARALLEL BATTERY SYSTEM SHOULD HAVE...

PT SD FROM ALL THE INFORMATION JUST BARELY PUT 50 00 MILES ON EACH YEAR

BEGINNING TO HAVE PROBLEMS WITH INTERIOR LIGHTING SHORT CYCLING, SHUTTING OFF EARLY. SUSPECT THE TIPM IS GOING OUT.

THE HEADLIGHTS FAILED DUE TO THE TOTALLY INTEGRATED POWER MODULE (TIPM). RESEARCH REVEALS THAT THE TIPM FAILED ON MANY OF THE DODGE VEHICLES. THIS SYSTEM FAILURE IS A SAFETY HAZARD.

BOTH LOW BEAM HEADLIGHTS ARE INOPERATIVE. I HAVE A DAYTIME RUNNING LIGHT MODULE THAT I INSTALLED IN 2007 WHICH STILL OPERATES BOTH LOW BEAMS AT A REDUCED POWER, SO THE BULBS ARE BOTH GOOD. BOTH HIGH BEAMS ARE OPERATIONAL. I NOTICED THAT WHEN I HAD THE LIGHT SWITCH IN THE ON POSITION ON 3/26/17 AFTER DARK AND TURNED OFF THE ENGINE WITH THE HEADLIGHT SWITCH STILL ON, THAT THE LOW BEAMS WE'RE NOT ON, BUT THE OTHER LIGHTS WERE ON. THE DAYTIME RUNNING LIGHT MODULE ONLY POWERS THE LOW BEAMS WHEN THE IGNITION IS IN THE ON POSITION. IN RESEARCHING THIS ISSUE ONLINE, I FOUND THAT THIS IS A COMMON PROBLEM WITH THE 2006 MODEL SINCE IT HAS A TIPM WHICH CONTROLS THE LIGHT AND OTHER FUNCTIONS. THE TIPM DOES NOT HAVE REPLACEABLE RELAYS OR RESETTING CIRCUIT BREAKERS FOR THE HEADLIGHTS WHICH ALLOW THE QUICK AND EASY REPAIR OR AUTOMATIC...

MY INTERMITTENT WIPERS FAIL, THEY STICK ON, OR WIPE RANDOMLY OR EVEN DON'T WORK AT ALL. THEY WILL STOP, TURN OFF AT ANY POINT DURING THE WIPE AT ANY POSITION, AND SOMETIMES WONT TURN OFF WHEN SWITCH IS OFF. DOESN'T MATTER WHAT SPEED OR DRIVING STYLE THAT THIS HAPPENS ON.

MULTIPLE REPAIRS TO THE FRONT END SUSPENSION OF THE VEHICLE, TO THE POINT THAT WE ARE NOW PAYING FOR THE REPAIRS AND THE DEALERSHIP DENYING THEY REPLACED THE MOST RECENT TRACK BAR ON THE TRUCK AND BLAME THE TIRES ON THE TRUCK. I AM REALLY TIRED OF RUNNING OFF INTO A DITCH AFTER HITTING A BUMP IN THE ROAD OR STEER TO MISS A POTHOLE. JUST FIX THE TRUCK CORRECTLY AND STOP MAKING EXCUSES TELLING US IT IS OUR TIRES WHEN IT IS A 4X4 AND THEY CANNOT PUT MORE STURDY PARTS ON THE FRONT END OR TAKE BLAME FOR THE STEERING SHAFT AND GEAR BOX WHEN THESE HAVE BEEN RECALLED UNDER THE DEATH WOBBLE. HUB ASSEMBLY HAD TO BE REPLACED ON THIS TRUCK AS WELL. TRYING TO TURN THE VEHICLE INTO A PARKING SPOT AND CONSTANTLY HAVING TO BACK INTO A SPACE. THIS DEATH WOBBLE HAS GONE TOO FAR....

I HAVE A 2006 DODGE RAM 2500 THAT HAS A COUPLE ISSUES. THE LATEST IS NO LEFT LOW BEAM. THERE IS NO FUSE TO CHANGE EITHER. FROM MY RESEARCH, IT APPEARS THAT IT IS THE TIPM THAT WILL NEED TO BE REPLACED. THIS ALL HAPPENED AFTER PULLING MY TRAILER. DURING THAT TIME, MY ABS AND BRAKE LIGHT CAME ON AND. ALSO, I HAVE THE NOTORIOUS "DEATH WOBBLE." I HAVE SPENT OVER $4,000 ON STEERING COMPONENT REPAIRS, WHICH INCLUDE 3 GEAR BOXES AND 2 POWER STEERING PUMPS IN LESS THAN TWO YEARS, TIRE RODS, PITMAN ARM, ETC. I AM TAKING MY TRUCK BACK TO THE SHOP TOMORROW TO HAVE MY UJOINTS REPLACED, ALL NEW SHOCKS, AND THE ABS/BRAKE SENSOR REPLACED FOR $1,100. I GUESS MY NEXT REPAIR WILL BE THE TIPM TO FIX THE HEADLIGHT ISSUE AT WHAT I GATHER TO BE AROUND THE $1,000 MARK. WHEN WILL DODGE FIX THESE...

TL* THE CONTACT OWNS A 2006 DODGE RAM 2500. WHILE MAKING A TURN, THE TRAILER LIGHTS DID NOT ILLUMINATE. THE FAILURE OCCURRED WITHOUT WARNING. THE DEALER DIAGNOSED THAT THE TIPM MALFUNCTIONED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

TL* THE CONTACT OWNS A 2006 DODGE RAM 2500. THE CONTACT STATED THAT THE HEATER AND AIR CONDITIONER WERE NOT WORKING. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE HEATER BOX FRACTURED AND NEEDED TO BE REPLACED AT COST. THE MANUFACTURER REFERRED THE CONTACT TO NHTSA AND STATED THAT THERE WERE NO FAILURES. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 163,000.

I HAVE A 2006 RAM 2500 I HOOKED UP SOME TRAILER LIGHTS AND NOW I HAVE NO LOW BEAM HEADLIGHTS. THERE IS NO CODES SHOWING ON REPAIR SHOPS READER (I HAVE NO DEALER AVAILABLE WHERE I LIVE). THE INTERNET HAS TONS OF COMPLAINTS ABOUT THE TIPM AND HOW IT SHUTS DOWN IF IT DRAWS TOO MANY AMPS. WELL YOU WOULD THINK A FUSE WOULD BE USED FOR THAT AND NOT HAVE TO REPLACE A $1000 COMPUTER BOARD. RIGHT NOW I CAN ONLY DRIVE DURING DAYLIGHT HOURS OR ONLY WITH THE HIGH BEAMS. CUSTOMERS SHOULD NOT HAVE TO PAY OVER A $1000 TO FIX A FAULTY DESIGN. DODGE SHOULD HAVE TO CREATE A FIX OR REPAIR OUR VEHICLES.

I HAVE TURN SIGNALS ON MY 2006 DODGE RAM 2500, BUT I DO NOT HAVE FUNCTIONING TRAILER BRAKE OR SIGNAL LIGHTS THROUGH THE FACTORY INSTALLED TOWING PACKAGE. THIS IS THE SAME PROBLEM NO MATTER WHICH TRAILER I AM PULLING. CHECKING FOR VOLTAGE STATES THAT THERE IS LOW VOLTAGE DUE TO THE TPIM. THIS OCCURRED AT 84,000. ALSO, WHILE THE VEHICLE IS RUNNING THE IGINATION KEY CAN BE PULLED OUT. $1,000 IS ALOT TO REPAIR A TOWING PACKAGE AND I DO NOT KNOW HOW LONG THIS WOULD LAST.

I OWN A 2006 DODGE RAM 2500. THE TURN SIGNALS ON THE VEHICLE MALFUNCTION. WHEN SIGNALING A LEFT TURN, THE RIGHT TURN SIGNAL WOULD FLASH, OR BOTH HAZARDS WOULD FLASH, OR SOMETIMES THEY WOULD NOT WORK AT ALL, THEN ALL OF A SUDDEN WOULD START MISFIRING AGAIN. THERE ARE 85,000 MILES ON MY TRUCK.

THE TRUCK WILL NOT POWER THE LEFT STOP LAMP OR SIGNAL LAMP ON ANY OF MY TRAILERS; HOWEVER, THE LEFT SIGNAL AND STOP LAMP ON THE TRUCK WORK PERFECTLY. DODGE DEALER INDICATED THAT THE PROBLEM WAS IN THE TRUCK'S TIPM WHICH DOES NOT HAVE A FUSE FOR THAT PORTION OF THE TRAILER'S LIGHTING AND BURNED OUT INTERNALLY. DEALERSHIP INDICATED THAT THE ONLY WAY TO REPAIR IS TO REPLACE THE TIPM WHICH COSTS $1026.00. DEALERSHIP ALSO INDICATED THAT THIS IS A MAJOR PROBLEM ON THIS VEHICLE WHICH THEY HAVE SEEN BEFORE. THERE IS NOTHING TO INDICATE THAT THE TRAILER LAMPS AREN'T WORKING EXCEPT TO PHYSICALLY OBSERVE THEM. THIS TIPM ALSO CONTROLS NUMEROUS OTHER THINGS IN THE TRUCK AND INFO FROM THE DEALERSHIP AND INTERNET SEARCHES INDICATE THERE ARE MANY SERIOUS PROBLEMS OCCURRING DUE TO THEM MALFUNCTIONING. THESE ARE DEFECTIVE UNITS THAT SHOULD BE RECALLED. CONSUMERS SHOULD NOT HAVE TO PAY OVER...

TURN SIGNAL WILL FLASH THE OPPOSITE SIGNAL THAN THE DIRECTION YOU DESIRE. EXAMPLE, TURNING ON THE LEFT TURN SINGLE WILL CAUSE THE RIGHT TURN SIGNAL TO FLASH, AND VISE VERSA, AS WELL AS CAUSING THE EMERGENCY SIGNALS TO ACTIVATE. I AM UNABLE TO INDICATE TO OTHER DRIVERS MY CORRECT DIRECTION OF TURN WHILE DRIVING IN TRAFFIC OR AT A SIGNAL LIGHT, STOP SIGN, MERGING, CHANGING LANES, ECT..

TL* THE CONTACT OWNS A 2006 DODGE RAM 2500. THE CONTACT STATED THAT THE TURN SIGNALS ON THE VEHICLE NEEDED TO BE REPAIRED. WHEN SIGNALING A LEFT TURN, THE RIGHT TURN SIGNAL WOULD FLASH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 128,000.

I WAS DRIVING DOWN THE ROAD AND THE ENGINE STARTED DYING THEN TAKING BACK OFF, THEN ALL OF A SUDDEN THE SPEED ODOMETER DROPPED TO ZERO WOULDNT COME BACK UP WHILE I WAS STILL MOVING, THEN THE ABS LIGHT THE CHECK ENGING LIGHT AND THE BRAKE LIGHT AND WASHER FLUID LIGHT ALL CAME ON AND I LOST POWER TO THE TAIL LIGHTS HEAD LIGHTS AND THE WINDOWS STARTED ROOLING UP AND DOWN BY THEM SELVES. WHEN I GOT HOME AND TURNED OFF THE TRUCK I CALLED THE DEALER AND THEY SAID THAT IT WAS THE TIPM AND IT WOULD HAVE TO BE REPLACED. THEY SAID THE TRAILER I WAS PULLING MUST OF HAD A SHORT AND THATS WHAT CAUSED IT. I TOLD THEM THAT I WASNT PULLING A TRAILER AND THEY CALLED ME A LIAR AND HUNG UP ON ME THE WINDOWS CONTINUED TO ROLL UP AND DOWN UNTILL THE...

WHEN SWITCHING ON A TURN SIGNAL, BOTH LIGHTS FLASH OR NOTHING HAPPENS. WIPERS FAIL OR WORK SPORADICALLY. WIPERS DON'T WORK WHEN I NEED THEM TO AND CAUSES ME TO NOT DRIVE IN THE RAIN. THE BLINKERS WORK HALF THE TIME AND ALMOST CAUSES SOMEONE TO HIT MY TRUCK BECAUSE THEY THOUGHT I WAS TURNING RIGHT WHEN I HAD THE BLINKER TO TURN LEFT.

UPON RESTARTING MY 2006 DODGE RAM 2500 DIESEL, MY ABS LIGHT AND PARKING BRAKE LIGHT CAME ON AFTER DRIVING A FEW SHORT MOMENTS ,I ALSO NOTICED THAT SPEEDOMETER INDICATOR WAS NOT WORKING BUT THE VEHICLE RPM INDICATOR WAS. CAUSING MYSELF SOME CONCERN I CHECKED MY BRAKES AND NOTICED I HAD A HARD BRAKE PEDAL WHEN APPLIED BUT WAS STILL ABLE TO STOP. I CONTACTED MY LOCAL DEALERSHIP AND TOOK MY VEHICLE IN FOR SERVICE FOR THIS ISSUE AND RECALL NOTICE CONCERNING THE DRIVERS AIR BAG INFLATOR. I WAS CONTACTED BACK BY MY SERVICE ADVISER, ASKING FOR APPROVAL FOR ADDITIONAL TWO HOURS OF DIAGNOSES TIME DUE TO THE FACT HIS MECHANIC COULD NOT FIND THE PROBLEM.I WAS NOTIFIED AT END OF THE DAY THAT THE ISSUE WAS FOUND TO BE FAULTY POWER DISTRIBUTION CENTER, OUTPUT FAILED FOR CIRCUIT F202 UNABLE TO RECOVER TIPM THRU RECONFIGURATION. NO PDC AVAILABLE THRU PARTS AT...

I HAVE OWNED THIS VEHICLE SINCE NEW AND ONLY USE FOR 6 WEEKS A YEAR AT OUR VACATION HOME. I HAVE HAD STEERING/ENGINE[INJECTORS]/DRIVELINE ISSUES BUT BIGGEST CONCERN IS THE TIPM. I MADE THE MISTAKE AND PLUGGED IN THE BOAT TRAILER AND THEN THE LEFT LOW BEAM WENT OUT. TOOK TO DEALER FOR A REFLASH AND THEY WERE ABLE TO MAKE THE HEADLIGHTS WORK BUT NOW HAVE THE TURN SIGNAL ISSUE. THEY INFORMED ME I NEED ANOTHER TIPM SO SINCE I HAVE BOUGHT 1 ALREADY[OFF WARRANTY] I AM HOPING WITH ALL THE COMPLAINTS, FIAT/RAM WILL ISSUE A RECALL AS THIS IS A SAFETY ISSUE? I TURN LEFT AND THE RIGHT INDICATOR COMES ON???I WOULD RATHER HAVE NO LOW BEAM THAN THIS ISSUE. I WILL NEVER OWN A FIAT VEHICLE DUE TO MY PAST AND CURRENT ISSUES WITH THE TIPM IN THIS 2006 DODGE RAM [MADE IN MEXICO] 2500 LARAMIE WITH A...

TL* THE CONTACT OWNS A 2006 DODGE RAM 2500. THE CONTACT STATED THAT THE TURN SIGNALS AND BRAKE LIGHTS MALFUNCTIONED ON THE TRAILERS ATTACHED TO THE VEHICLE. THE CONTACT MENTIONED THAT NO WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE FAILURE OCCURRED AT ANY SPEED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE AMPERAGE WAS INCORRECT AND NEEDED TO BE RESET. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000. THE VIN WAS NOT AVAILABLE. UPDATED 12/03/15*LJ

FIVE PIN TRAILER ELECTRICAL CONNECTION CORRODES W CAP COVER IN PLACE. THE TURN SIGNALS, HEAD LIGHTS, WIPERS, BRAKE LIGHTS, BACK UP LIGHTS, INTERIOR LIGHTS, DASH INSTRUMENTS WILL NOT OPERATE CORRECTLY. HEAD LIGHTS MAY NOT TURN OFF. DEALER CUT CONNECTION FIVE PIN OFF, PUT ELECTRICAL TAPE ON THE EXPOSED WIRE ENDS. WOULD HAVE REQUIRED TO REPLACE THE ENTIRE WIRE HARNESS. REPAIRED, THE CONNECTION WITH A NEW SPLICED 5 PIN CONNECTION PURCHASED FROM A LOCL HARDWARE STORE.

WHEN I ACTIVATE LEFT TURN SIGNAL THE RIGHT TURN SIGNAL ACTIVATES. WHEN I ACTIVATE THE RIGHT TURN SIGNAL IT OPERATES CORRECTLY. ALSO DOESN'T SEEM TO HAPPEN WHEN TILT STEERING IS IN UP POSITION ONLY WHEN TILT STEERING IS IN DOWN POSITION. ALSO WINDSHIELD WIPERS HAVE STOPPED WORKING MID ROTATION. THEN STARTED WORKING AGAIN IN A SHORT TIME PERIOD. I BELIEVE THESE PROBLEMS ARE RELATED.

TL* THE CONTACT OWNS A 2006 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V795000 (AIR BAGS) AND 15V313000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT EXPERIENCED WHAT WAS DESCRIBED IN THE RECALL, FOR THE LAST TWO YEARS. MA 08/10/15 UPDATED 08/18/15*JB

TL* THE CONTACT OWNS A 2006 DODGE RAM 2500. ANOTHER VEHICLE CUT IN FRONT OF THE CONTACT'S VEHICLE CAUSING THE CONTACT TO LOSE CONTROL AND VEER OFF THE ROAD. AS A RESULT, THE CONTACT CRASHED INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE PARTS WERE NOT AVAILABLE FOR NHTSA CAMPAIGN NUMBERS: 14V817000 (AIR BAGS) AND 14V795000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 32,000. UPDATED 6/8/15*CN

TL* THE CONTACT OWNS A 2006 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V795000 (ELECTRICAL SYSTEM) AND 14V817000 (AIR BAGS); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

ISSUE: LOW BEAM HEADLIGHT BULBS QUIT WORKING, AFTER SEVERAL REPLACEMENTS, INSTALLING NEW BULBS (LAMPS) DOES NOT REPAIR THE ISSUE. THE VEHICLE CURRENTLY HAS NO LOW BEAM HEADLIGHTS, THE VEHICLE ONLY HAS HIGH BEAM HEADLIGHTS. NOT DRIVABLE AT NIGHT. TIPM (TOTALLY INTEGRATED POWER MODULE) IS AT FAULT ACCORDING TO DODGE TECHNICIAN. THE LEFT (DRIVERS SIDE) LOW BEAM HEADLIGHT WENT OUT IN 2007, I REPLACED THE HEADLAMP BULB. OK. THE RIGHT (PASSENGER SIDE) LOW BEAM HEADLIGHT WENT OUT IN EARLY 2008. I REPLACED THE HEADLAMP BULB. OK. IN 2012 ,BOTH LOW BEAM HEADLIGHTS WENT OUT. I REPLACED BOTH LAMPS.OK. IN 2013, THE RIGHT (PASSENGERS SIDE) LOW BEAM HEADLAMP WENT OUT. I REPLACED THE RIGHT (PASSENGERS SIDE) LOW BEAM LAMP, BUT THE LIGHT STILL DOES NOT WORK. I TOOK TO SHOP, AND THEY ATTEMPTED TO REPAIR, BUT COULD NOT LOCATE ISSUE. THEY SAID, NO FUSES TO REPLACE, IT HAS A TIPM MODULE THAT...

RECURRENT ELECTRICAL ISSUES, THAT DO NOT INVOLVE BLOWN FUSES OR BULBS. ENGINE DIAGNOSTIC CODES HAVE INDICATED TIPM PROBLEMS AND I HAVE HAD TO "ERASE CODES" TO RESTORE FUNCTIONALITY. THEN 2-3 MONTHS LATER RECURRENT PROBLEMS, ABNORMAL CODES AND ERASURE RESTORES FUNCTION. CODE DESCRIPTION INDICATES THAT THE TIPM WILL ONLY ALLOW 6 OR 8 RESETS ( DO NOT RECALL EXACT NUMBER) BEFORE TIPM WILL 'LOCK UP' AND NEED TO BE REPLACED. DESCRIPTION OF EPISODES: > RECURRENT MALFUNCTION OF INSTRUMENT LIGHTS. SUDDENLY ALL DASH LIGHTS AND TAIL LIGHTS SHUT OFF, YET BRAKE LIGHTS, HEADLIGHTS AND HAZARD LIGHTS REMAIN ON. HOWEVER, FOG LIGHTS CANNOT BE TURNED OFF, EVEN AFTER HEADLIGHTS OFF. THE DASH LIGHTS THEN FLASHED 4 TIMES, REMAINED OUT 2-3 MINS THEN FLASHED 4 TIMES. IN ADDITION TO THE LIGHTING PROBLEMS, THE VEHICLE BEGAN MISFIRING AND EVENTUALLY STALLED. WOULD NOT RESTART. ACTED LIKE NO SPARK AVAILABLE TO CYLINDERS. 5 MINS LATER, TRUCK STARTED...

STARTED TRUCK TO LEAVE FOR WORK ONE MORNING AND HEAD LIGHTS WOULD NOT COME ON. DEALERSHIP SAID IT HAS A BAD TIPM. *TR

AIRBAG WARNING LIGHT FLASHES INTERMITTENTLY WHILE VEHICLE IS IN MOTION. OCCURS APPROXIMATELY 1X/WEEK. HAS BEEN ACCOMPANIED BY ERRATIC TURN SIGNALS AND DASH LIGHTS. *TR

2006 DODGE RAM POWER WAGON, FIRST THE TRUCK STARTED WHEN IT WANT TO, WE WOULD HOLD THE KEY SEVERAL TIMES AND IT WOULD START, THEN AFTER ABOUT A WEEK THE TRUCK WOULD NOT TURN ON AT ALL: REPLACED BATTERY REPLACED STARTED REPLACED ALTERNATOR CHECK THE ELECTRONICS IN THE STEERING COLUMN A FRIEND CAME AND CHECK IT ON HIS COMPUTER AND IT SAID OVER VOLTAGE HE RESET THE COMPUTER AND IT STARTED. NOW I CAN NOT KEEP THE BATTERY CHARGED, I HAVE UNLOCKED ANY EXTRA LIGHTS I HAD ADDED MY REMOTE START. I READ LAST WEEK THAT THERE IS A FIBER OPTIC LINE THAT WOULD DISCONNECT IF THERE WAS AN EXTREME SHAKING, I GOT NEW TIRES AND THEY WERE BAD SO THE TRUCK SHOOK EVER BAD. WHAT ARE YOUR THOUGHTS? *TR

THE TIPM MODULE FAILED AND LEFT HEADLIGHT WENT OUT AT NIGHT. REPAIR SHOP DID TEMPORARY BYPASS LEFT SIDE TIPM OUTPUT FOR LOW BEAM. HEADLIGHTS FAILED COMPLETELY ON BOTH SIDES, HIGH BEAM AND LOW BEAM IN AUGUST 2014. REPLACED TIPM ASSEMBLY ON 9/19/14, $924.99 FOR PARTS AND $112.50 FOR LABOR. *TR

DRIVER'S HEADLIGHT WILL NOT WORK EVEN AFTER PUTTING IN A NEW BULB, RADIO INTERMITTENTLY COMES ON AND GOES OFF AND THE TRAILER LIGHTS WILL NOT STAY ON. VEHICLE CHECKED OUT BY A CERTIFIED REPAIR SHOP AND THEIR FINDINGS POINTED DIRECTLY TO A DEFECTIVE INTEGRATED FUSE MODULE BOX IN MY 2006 DODGE RAM 2500. REQUESTING TO FILE A FORMAL COMPLAINT AND TO JOIN ANY CLASS ACTION SUITS IN PLACE TO HELP OFF SET AN ESTIMATED REPAIR BILL OF AROUND $1,000.00 BY A LOCAL DODGE DEALERSHIP. THE PART A LONE IS $704 AND IT IS SET BY CHRYSLER AND THERE IS NO FINDING A CHEAPER PRICE. *TR

TL* THE CONTACT OWNS A 2006 DODGE RAM 2500. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE INSTRUMENT PANEL AND GAUGES FAILED. IN ADDITION, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INDEPENDENT MECHANIC. BOTH THE DEALER AND AN INDEPENDENT MECHANIC STATED THAT THE POWER DISTRIBUTION CENTER NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED ON TWO SEPARATE OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 217,000. THE VIN WAS NOT AVAILABLE.

FAILURE OF CLUTCH/STARTER INTERLOCK SWITCH, VEHICLE WILL START WITH CLUTCH OUT. *TR

LOST TURN SIGNAL ON LEFT SIDE OF VEHICLE ALSO LOST TRAILER TURN SIGNAL WAS TOLD AT DEALERSHIP IT WAS THE TOTALLY INTEGRATED POWER MODULE WAS THE REASON .AT FIRST THE SIGNAL WOULD FLASH VERY FAST THEN IT QUIT ALL TOGETHER. GUESS THIS IS A COMMON PROBLEM WITH DODGE VEHICLES LOTS OF POST ABOUT IT ON THE INTERNET. *TR

GOING DOWN THE HIGHWAY AT 60 MPH IN A DOWNPOUR. HAD WINDSHIELD WIPERS ON LOW, TURNED THEM UP TO HIGH AND THEY SLOWED DOWN UNTIL THE COMPLETELY QUIT. LUCKILY GOT OFF OF HIGHWAY TO SAFE LOCATION TO GET TOWED TO MY SHOP. AFTER DIAGNOSING PROBLEM, FOUND OUT IT IS THE TIPM(TOTALLY INTEGRATED POWER MODULE). *TR

COULD NO LONGER ACTIVATE THE HIGH BEAMS AND WINDSHIELD WASHER. AFTER CHANGING THE MULTIFUNCTION SWITCH WAS TOLD THE ISSUE IS IN THE TIPM. NEED TO REPLACE POWER MODULE ASSOCIATED WITH FUSE BOX. *TR

DIRECTING AIR TO DEFROST WINDSHIELD DOES NOT WORK = SAFETY HAZARD. AIR ONLY BLOWS FROM FRONT VENTS AND WILL NOT CHANGE TO ANY OTHER POSITION: DEFROST OR FLOOR, NO MATTER THE SETTING SELECTED ON THE CLIMATE CONTROL (AIR FLOW) KNOB. *TR

EXTERIOR LIGHTS STOPPED WORKING PROPERLY. NO TURN SIGNAL ON DRIVER SIDE WHEN HEADLIGHTS ARE ON. ALSO WHEN HEADLIGHT SWITCH IS ON BACKUP LIGHTS COME ON,CAB BRAKE LIGHT COMES ON,AND DRIVER SIDE SIGNAL BLINKS RAPIDLY LIGHTING FAINTLY THE. *TR TURN SIGNAL BULB,AND RUNNING LIGHT WITH NO BRAKE LIGHTS.BUT HE FRONT DRIVER SIDE TURN SIGNAL WORKS. *TR

RANDOM ELECTRICAL PROBLEMS. *TT

THESE TRUCKS HAVE BEEN SOLD WITH FAULTY ELECTRICAL SYSTEMS THAT DODGE HAS NOT BEEN ABLE TO CORRECT WITH OUT COSTING THE OWNERS THOUSANDS OF DOLLARS. THE TPIM MODULE CONSTANTLY NEEDS TO BE REFLASHED AND REPLACED TO KEEP YOUR TRUCKS ELECTRICAL SYSTEM WORKING. THEY HAVE DESIGNED THIS SYSTEM SO THAT THE CONSUMER CANNOT REPAIR OR EVEN INSPECT THE SYSTEM WHICH I BELIEVE IS A VIOLATION OF FEDERAL LAW. ALL OF THESE VEHICLES HAVE ISSUES WITH THE MODULE AND DODGE HAS MADE MILLIONS OF DOLLARS BECAUSE OF THEIR FAULTY PART. THIS MODULE AFFECTS LIGHTS, WIPERS, A/C, CRANKING SYSTEM ETC... THIS NEEDS TO BE LOOKED AT CAREFULLY AND DODGE SHOULD BE HELD LIABLE TO REPAIR THIS PROBLEM. *TR

THE BLINKERS ARE ERRATIC. THE LEFT BLINKER COMES ON WHEN THE RIGHT IS APPLIED AND VISE VERSA. THE BLINKERS WILL SWITCH SIDES IN THE MIDDLE OF A TURN AND AT TIMES THEY WILL BOUNCE BACK AND FORTH BETWEEN RIGHT AND LEFT TURN. THE WINDSHIELD WIPERS WILL JUST TURN THEMSELVES OFF AT TIMES AND OR SPEED UP AND SLOW DOWN BY THEMSELVES AT TIMES. SEEMS VERY DANGEROUS AND A RECALL SHOULD BE CONSIDERED. AT THE MINIMUM A TECHNICAL BULLETIN DESCRIBING THE PROBLEM SHOULD BE ISSUED. THIS SEEMS TO BE A COMMON PROBLEM WITH THIS MODEL. *TR

ANOTHER ISSUE WITH THIS TRUCK TIPM IDLING IN DRIVEWAY HORN HONKS BY ITSELF LIGHTS HIGH BEAMS TURN ON AND OFF BY THEMSELVES BLINKERS WORK INTERMITTENTLY THIS TRUCK HAS BEEN A PAIN I HAVE MADE A FORMAL COMPLAINT ABOUT THE BALL JOINTS THEY HAVE BEEN REPLACED 3 TIMES IN LESS THAN 51000 MILES DODGE DEALER REPLACED THEM TWICE WHILE UNDER WARRANTY BUT REPLACED THEM ON MY OWN THE LAST TIME ALSO STEERING GEARBOX SNAPPED IN HALF REPLACED THAT WHILE PULLIN 18 FOOT TRAILER GOT STOPPED BUT COULD NOT GET OUT OF THE ROAD WE SPEND ALOT OF MONEY ON OUR TRUCKS WHILE DODGE MAKES ALOT OF MONEY BUILDING JUNK I HAVE BEEN OFFERED 35,000 FOR THE TRUCK BUT I WONT SELL IT TO ANYONE TO HAVE THESE PROBLEMS. *TR

WHEN EVER I USE MY BLINKERS GOING RIGHT OR LEFT THEY DON'T ALWAYS TURN ON IN THE DIRECTION I'VE ASKED THEM TO. THEY WILL GO FROM RIGHT TO LEFT QUICKLY AND BACK AND FORTH. EXAMPLE I AM MAKING A LEFT TURN AND TURN MY LEFT TURN SIGNAL ON. IT BLINKS LEFT AND RIGHT SWITCHING BACK AND FORTH. THIS ISN'T JUST HAPPENING WITH THE LIGHTS INSIDE ON MY DASH, IT ACTUALLY TURNS THE BLINKERS ON OUTSIDE IN MY LIGHTS AS WELL. NO ONE CAN TELL WHICH DIRECTION I AM ACTUALLY TURNING. *TR