2006 CHEVROLET TRAILBLAZER — Problems, Recalls & Safety Data
N/A
Safety Rating
1,440
Owner Complaints
8
Recalls
21
Service Bulletins
0
Investigations
Overview of the 2006 CHEVROLET TRAILBLAZER
The 2006 CHEVROLET TRAILBLAZER has received a total of 1,440 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 10 recall campaigns affecting this vehicle, covering issues with EXTERIOR LIGHTING:HEADLIGHTS, VISIBILITY:POWER WINDOW DEVICES AND CONTROLS. 21 technical service bulletins have been issued by General Motors, LLC for this model year. The most commonly reported problems involve the Fuel System Gasoline (434 complaints), Electrical System (229 complaints), and Exterior Lighting (103 complaints).
Recalls for the 2006 CHEVROLET TRAILBLAZER
NHTSA has recorded 10 recalls for the 2006 CHEVROLET TRAILBLAZER, potentially affecting up to 1,723,819 vehicles.
Recall 15V519000 — EXTERIOR LIGHTING:HEADLIGHTS
| 429,170 vehicles affected
Defect: General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module (HDM) may overheat and fail, causing the headlamps and daytime running lights to not illuminate.
Consequence: Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.
Remedy: GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is...
View full details →Recall 15V599000 — VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
| 9,932 vehicles affected
Defect: General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board, causing window switches to become inoperative. Previously, the...
Consequence: The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.
Remedy: GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer...
View full details →Recall 14V404000 — VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
| 184,611 vehicles affected
Defect: General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the...
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to...
View full details →Recall 13V248000 — VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
| 193,652 vehicles affected
Defect: General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power...
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done...
View full details →Recall 13V248000 — ELECTRICAL SYSTEM
| 193,652 vehicles affected
Defect: General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power...
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done...
View full details →Recall 12V406000 — VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
| 278,174 vehicles affected
Defect: General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia,...
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at...
View full details →Recall 12V406000 — ELECTRICAL SYSTEM
| 278,174 vehicles affected
Defect: General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia,...
Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.
Remedy: Parts for this recall are expected to available in March 2013. GM will notify Buick, Chevrolet, and GMC owners when parts are available. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, and GMC owners at...
View full details →Recall 06V417000 — AIR BAGS:FRONTAL
| 794 vehicles affected
Defect: CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER...
View full details →Recall 05V552000 — EQUIPMENT:OTHER:LABELS
| 32,068 vehicles affected
Defect: CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT...
View full details →Recall 05V455000 — STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
| 123,592 vehicles affected
Defect: CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339,...
View full details →Owner Complaints for the 2006 CHEVROLET TRAILBLAZER
1,440 complaints have been filed with NHTSA for the 2006 CHEVROLET TRAILBLAZER. Below is a breakdown by vehicle component.
Most Recent Complaints
The contact owns a 2006 Chevrolet Trailblazer. The contact stated that while having a routine oil change by an independent mechanic, the contact was informed that the frame was rust on the vehicle was rusted. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 226,569.
The contact owns a 2006 Chevrolet Trailblazer. The contact received notification of NHTSA Campaign Number: 13V248000 (Electrical System, Visibility). The contact stated that on several occasions while the vehicle was running or while driving at various speeds, the passenger's window switch was depressed from the driver's side door panel, and there was a clicking sound coming from the front passenger’s side of the vehicle, and the window failed to roll up or roll down. Additionally, the contact stated that on several occasions, when the driver's side window switch was depressed, the window failed to roll up or roll down. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown. Parts distribution disconnect.
The contact owns a 2006 Chevrolet Trailblazer. The contact received notification of NHTSA Campaign Number: 13V248000 (Electrical System, Visibility). The contact stated that on several occasions while the vehicle was running or while driving at various speeds, the passenger's window switch was depressed from the driver's side door panel, and there was a clicking sound coming from the front passenger’s side of the vehicle, and the window failed to roll up or roll down. Additionally, the contact stated that on several occasions, when the driver's side window switch was depressed, the window failed to roll up or roll down. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown. Parts distribution disconnect.
The headlamps have quit working when driving at night but will come back on later. This has happened several times. I found GM recall number 14291 that is supposed to include 2006 Chevy Trailblazers and pertains to this problem. The local dealership told us that our vehicle has a vin number that is not covered. It would seem that all model 2006 Chevy Trailblazers would use the same HDM modules in them when they were built. Is ours covered?
Just need a recall sheet for shipping vehicle.
Safety Rating for the 2006 CHEVROLET TRAILBLAZER
NHTSA has not yet tested the 2006 CHEVROLET TRAILBLAZER in its New Car Assessment Program.
Technical Service Bulletins for the 2006 CHEVROLET TRAILBLAZER
General Motors, LLC has issued 21 technical service bulletins (TSBs) for the 2006 CHEVROLET TRAILBLAZER. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
120089007A — EQUIPMENT
This informational bulletin provides information on dealer responsibility for cargo carrying capacity labeling and the part numbers for the labels.
PIP4945B — ENGINE
This Preliminary Information communication provides information to the technician about vehicles that may have Service Engine Soon Malfunction Indicator Lamp on. Technician may find a Diagnostic Trouble Code P0017 may be set current or history. Technician will need to follow published Service Information and all technical services bulletins for Diagnostic...
12180E — VEHICLE SPEED CONTROL
Driver Door Switch Short Circuit
PIP4568N — ENGINE AND ENGINE COOLING
This Preliminary Information communication provides information to the technician that some vehicles may have a Service Engine Soon lamp, engine misfire on cylinder 1, 4, 6, or 7 and/or tick noise. Technician will follow service information diagnosis first. If service information diagnosis does not isolate the cause of this concern...
SB-12180-D — ELECTRICAL SYSTEM
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
12180A — ELECTRICAL SYSTEM
Driver Door Switch Short Circuit
12180D — ELECTRICAL SYSTEM:WIRING:POSITION/LIMIT SENSOR/SWITCH
Driver Door Switch Short Circuit
12180D — STRUCTURE:BODY:DOOR
Driver Door Switch Short Circuit
SB-2915 — ELECTRICAL SYSTEM:WIRING
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
11323 — LATCHES/LOCKS/LINKAGES
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Showing 10 of 21 technical service bulletins.
NHTSA Investigations for the 2006 CHEVROLET TRAILBLAZER
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the CHEVROLET TRAILBLAZER
- 2001 CHEVROLET TRAILBLAZER — 29 complaints
- 2002 CHEVROLET TRAILBLAZER — 1,573 complaints
- 2003 CHEVROLET TRAILBLAZER — 1,160 complaints
- 2004 CHEVROLET TRAILBLAZER — 1,302 complaints
- 2005 CHEVROLET TRAILBLAZER — 1,902 complaints
- 2006 CHEVROLET TRAILBLAZER (current)
- 2007 CHEVROLET TRAILBLAZER — 965 complaints
- 2008 CHEVROLET TRAILBLAZER — 261 complaints
- 2009 CHEVROLET TRAILBLAZER — 34 complaints
Other CHEVROLET Models
- CHEVROLET MALIBU — 28,991 total complaints
- CHEVROLET SILVERADO 1500 — 22,175 total complaints
- CHEVROLET IMPALA — 15,197 total complaints
- CHEVROLET TAHOE — 12,511 total complaints
- CHEVROLET EQUINOX — 12,135 total complaints
- CHEVROLET BLAZER — 11,032 total complaints
- CHEVROLET SILVERADO — 10,928 total complaints
- CHEVROLET SUBURBAN — 10,375 total complaints