2021 JEEP WRANGLER Unknown Or Other Problems

EV Battery recall without resolution. After receiving the recall notice and scheduling service at the dealership, the Jeep Was kept for 6 weeks and they replaced both the EV battery and the starting 12v battery. After driving the vehicle for less than a week, the EV battery started making gurgling and bubbling sounds after starting and continued for about 30 sec - 1 minute after turning off power. No message or warning lights have indicated any type of issue. The dealership said the car is not safe to drive and asked me to have it towed to the shop. I have had to pay almost $3,000 out of pocket for a rental because I use my car for work. My reimbursement is still processing and my vehicle is back in the shop. This was the 4th attempt to upgrade the software and the first time replacing the battery to my...

The uconnect radio is not functioning correctly at 55000 miles it refreshes and restarts intermittently and the rear camera is not operating properly after switching to drive from reverse. The image remains in the screen for an extended period of time causing a view of the rear of the vehicle as it is driving forward. This gives a skewed perception of what is going on around the vehicle. It’s is distracting and confusing until the rear view camera returns to the “drive” condition of the vehicles transmission and removes the view of the rear of the vehicle from the radio.

There has been an electrical issue with this car since it was purchased in May 2021. The start stop system has always said service it and each time the dealership has said the temperature in the car has to be prime. It still doesn’t work. The key fobs continue to disconnect even with new batteries. The screen at times delays and needs an upgrade. The battery or both batteries even in the summer dies if the car isn’t driven for more than 3 days. We spend more time jumping the vehicle than driving it. It’s a 2021 and only has 35000 miles on it. Why pay for a vehicle that spends more time in the shop than in the driveway?

Recall 68C has NOT been remedied on my 2021 Jeep Wrangler 4xe (VIN [XXX] ). Details are as follows: Recall: Battery / high-voltage system (Recall 68C) Status: Failed battery test, vehicle held at dealer Delay: Quoted 4–8 weeks waiting for replacement battery Impact: Vehicle unusable / safety-related immobilization Mileage: 34,000 Dropped off: [XXX] CJDR on January 8, 2026 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I reached out to my dealer at the beginning of Jan after I received the notice that the recall repair was available. The dealer told me that they have no record of the recall for my vehicle. The dealer has been unresponsive since I complained.

On Tuesday January 6 2026, I was driving my 2021 Jeep Wrangler 4xe. I noticed smoke coming out the engine. I pulled over to the side of the road to determine the problem. Upon exiting the vehicle, I saw flames coming from the undercarriage of the engine. The fire soon engulfed the vehicle. 911 was called. Police and Fire responded. The vehicle was destroyed in the fire. I have photos and videos of the fire and aftermath, taken once I exited the vehicle. I assume the fire is the result of the recent recall on the battery components of the Jeep Wrangler 4xe. The vehicle is currently in an impound lot and would be available for inspection upon request. I have notified Jeep and my insurance of the incident, but the jeep has not as of yet, been inspected by either entity. The fire was of great risk to myself....

Basically stated, death wobble, after looking up symptoms. At 65 mph on the highway, hit a bump and the entire jeep shook uncontrollably. I just purchased it used not 10 minutes prior to the incident. The dealership failed to mention this and sold it as-is.

On April 15th 2025 my Instrument Panal Clusters IPC which is main computer system of Jeeps 2018-2024. It has service lights for check engine, tire pressure, def system recalibrations/cleanings, tells me how fast I'm going, oil levels, all other fluid levels, when I need a oil change, how many miles is on jeep, gas gage, along with all other issues or maintenance on a vehicle including if something is wrong or overheating of vehicle. After doing some research I did see there was a Ipc recall on Jeeps/Gladiators 2018-2024. After going on the website to check if my vin qualified it was sadly not included. I ended up taking my vehicle into the dealership and paid out of my pocket 150.00 to have my vehicle diagnosed. The dealership said it was indeed the Ipc but also said my vin number was not included which was a shock to them also...

The 1st time it happened I was getting on highway and went over a Crack in road and my jeep started vibrating violently. Totally scared me but once I slowed down it stopped so I figured it was a fluke thing. My hubby drove it to Seattle and going 70 he went over grooved pavement and the shaking happened again. Third times a charm at 65 and didn't go over anything and it scared the crap out of me so bad I slowed down to 30 in a 60 in order for it to stop. Immediately contacted dealership and was told it would be hundreds of dollars and it isn't covered under warranty. I bought this Jeep brand new, only has 41,000miles and dont beat her up on off road because she is my daily driver. This violently shaking is scary and this could really do a new driver some...

I am reporting an ongoing steering/wheel wobble issue with my Jeep Wrangler. While driving at highway speeds, the vehicle suddenly begins to shake severely after hitting small bumps or uneven pavement. The wobble feels like the front end is vibrating uncontrollably, and the steering wheel oscillates left and right. I am forced to slow down significantly to regain control. This has happened multiple times, and the wobble creates a clear safety hazard because the vehicle becomes difficult to steer and maintain in the lane. The issue is unpredictable but tends to occur between approximately 45–65 mph. I have checked tire balance and suspension components, but the problem persists.

Hello, I am writing to escalate an urgent issue involving my vehicle recall and my scheduled shipment. I have paid over three thousand dollars to Montway as my broker, and at this point all involved parties have failed to provide a clear solution. I cannot move forward without immediate support. My Jeep is experiencing a recurring battery recall for the seventh time. This is a product defect that is outside of my control. My vehicle is scheduled to ship through Pasha in the coming days, and the recall must be resolved before drop off. Pasha has informed me that I cannot keep the vehicle at the port before the appointment window, and Montway has not provided any realistic guidance on where the vehicle can be safely held. I hired Montway to help coordinate this process. I paid for professional support. Being told to find a holding location myself while coordinating...

My clutch was recalled and I brought it in maybe around 10 times after because the service transmission light immediately came up after the recall fix. After bringing it to jeep for a year and engineers giving me the run around. First they said it was the way I was driving the clutch then after a year they said that the recall was to put a new sensor in and that is why the service transmission light is going on. This cannot be correct because they would have said that from the beginning. It is dangerous because you cannot see anything on the screen when the service transmission light comes up. They do not know what is wrong and are making up excuses after it was in the shop off and on for a year. The way I drive the clutch is normal and should never make the service transmission...

I was driving my 2021 Jeep wrangler and it started running poorly. I was near the dealership. I called them and told them I was headed to them asap. (I was within 3 mile range). The car died in the middle of an intersection. I could not put the car in neutral to move it out of the way of traffic. I got a tow truck to bring it to the dealership. Where they told me that the coolant tube fasteners for my vehicle were gone, and that the engine was blown, including the pump. Elbow screws were missing for the vehicle and coolant was everywhere in my vehicle. My car has 46,000 miles on it. It has had every single oil change ,reported recall done and service request to complete completed.. It has been taken very well care of and has only been to this one dealership.. according to...

My husband was turning left from one highway to another highway when a car who was trying to pass multiple vehicles behind us hit us on drivers side as we were turning causing my 2021 Jeep to be pushed completely off the road and into a ditch where we hit a large pole/electrical pole. We hit the pole so hard that it moved it. Our air bags did not deploy at all. I got a notification on my Jeep app stating that there was airbag failure. My husband and my body were shook pretty bad from the incident and could have been seriously injured due to the impact. Our Jeep was towed to the body shop and they stated the gentleman working there told my husband that our airbags should have deployed.

On 7/13/25, my 2021 Jeep Wrangler Unlimited with approximately 50,000 miles on it spontaneously caught fire as I was driving down the highway. The fire appeared to start in the engine compartment and very quickly moved to the entire front end of the vehicle. I pulled over on the side of the road and managed to safely exit the vehicle without physical injury. In minutes, the entire vehicle was consumed in flames. The fire department arrived within 10 minutes. When I departed the scene of the incident, fire fighters were still spraying water on the vehicle. After leaving the scene, I went to the hospital for psychological injury related to the incident. The investigation into the fire is currently underway. I do not have additional information about the cause or specific location of the fire. The vehicle is currently at a tow yard and is a total loss. It is...

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The hybrid-electric system, including the high-voltage battery, battery pack control module (BPCM), and associated cooling systems, repeatedly malfunctioned. These failures caused loss of power while driving, electrical odors, and error messages. The vehicle is currently at the dealership for service and is available for inspection upon request. 2. How was your safety or the safety of others put at risk? The vehicle has lost power multiple times while in motion, including on city streets and highways. These unexpected power losses significantly increased the risk of rear-end collisions and limited my ability to safely accelerate or steer in traffic. I have had to take anxiety medication when driving the vehicle due to fear of these events recurring, and I am deeply concerned about the safety of my family, including a newborn passenger. 3. Has the...

I own a 2021 Jeep Wrangler 4xe Unlimited, which has undergone three manufacturer recalls and two separate service (one handle during a recall visit) visits due to charging failures. The recalls were related to defrost system malfunctions, sudden loss of motor power, and high-voltage battery concerns. Each of these issues was addressed solely through **dealer-installed software updates**—updates that could not be completed over the air. These recalls and service visits highlight a troubling pattern: the vehicle’s core systems—including the BPCM, IDCM, PIM, TCM, and HCP—are deeply interconnected and dependent on one another. So far, my vehicle has required a total of **10 software updates**, with some systems needing multiple revisions. Most recently, Jeep addressed a “not charging” problem by once again performing a software update—this time affecting **five of the seven systems previously updated during recalls**. Despite the problem originating from their software architecture, Jeep charged me **$200 for the...

Coolant, leaking from jeep wrangler overheated, took it to my personal mechanic, who pointed out that there is a known issue and handed me the customer notification ZD8 coolant leakage, which states that the vehicle should be taken to a dealership and that the repair would be covered. I took it to the dealership. I was told that it is not covered and now I'm being charged over $500 for something that is a known issue. I have tried calling mopar.I've tried calling other eight hundred numbers to get someone to explain this to me yet.No one seems to be able to tell me anything.Other than there are no open recalls, which I already know can someone please explain why a known issue is not covered?

Coolant leaking, engine overheating, dealer says not covered issue despite it being a known issue (see customer satisfaction notification zd8 coolant leak. But dealership is going to charge me over five hundred dollars to replace a gasket and use some lock tight on my vehicle. I understand there isnt a RECALL on my vin in particular but I also can read and the narrative in the above mentioned notification matches my vehicle. 2021 Jeep Wrangler Unlimited 2.0 turbo engine. So why am I paying out of pocket for a "known" issue?

Date: [XXX] Subject: Immediate Safety Concern – 2021 Jeep Wrangler Sahara 4xe – Acceleration Failure Dear Jeep Customer Care, I am the owner of a 2021 Jeep Wrangler Sahara 4xe, VIN [XXX] , with approximately 50,000 miles. I am writing to report a critical and potentially fatal safety defect that occurred multiple times on [XXX], most notably at the intersection of [XXX] and [XXX] in Oregon. On multiple occasions, when attempting to accelerate from a full stop into an intersection with cross traffic traveling at 55 mph or more, the vehicle failed to respond to throttle input. Instead of accelerating, the Jeep simply rolled slowly into the intersection despite my foot fully depressing the accelerator pedal. This placed me at immediate risk of being struck broadside by oncoming vehicles at high speed, which could have resulted in catastrophic injury or death. The check engine light was on since [XXX] and...

I’m terrified to drive my jeep wrangler because of fire hazard due to high voltage battery. Can I ask the dealer to buy it back?

UNKNOWN Jeep has been violently shaking uncontrollably while driving. Speed of driving has been between 30-75mph

Poor workmanship - soft top broken after single use

After picking up the 2021 Jeep Wrangler Rubicon 4xe from the dealership for repairs to the rotors and struts and bearings, the Wrangler was running roughly. Before I was halfway home, I called the dealer back to explain the engine was running roughly, wasn't able to get over 40mph, and was acting as if it was going to stall or lose power. I stated I needed to bring it back because I wasn't going to be able to drive it like this. Before I got halfway back to the dealership, the Wrangler lost power and was making a noise as if it was going to blow up. I was barely able to get it off the side of the road and narrowly missed a rearend collision from the vehicle behind me. I was on a dark, heavily traveled two lane road during evening work traffic hours. Dealership did send a...

Since purchasing my 2021 Jeep Wrangler Rubicon, the vehicle’s radio system has been defective, creating a significant safety hazard. The original radio (Radio 1) had a short that drained the battery and was replaced by a dealer. The replacement radio (Radio 2) has never functioned properly: the Bluetooth system fails to stay paired, requiring manual re-pairing every time the vehicle is started. Multiple software updates have been attempted, but the issue persists unchanged. This defect prevents reliable hands-free phone operation, which is critical for safe driving. My wife uses this vehicle daily to transport our children to school, and the lack of a functional hands-free system forces her to either forgo phone use entirely or risk distracted driving, violating Georgia’s hands-free law (O.C.G.A. § 40-6-241), which prohibits holding a phone while driving. This malfunction endangers my family and other road users, as it compromises the driver’s ability to communicate safely...

On [XXX], I was in Fort Lauderdale, FL for vacation with my 2 friends. I was driving for about 20-30 minutes on the road, got on the highway and noticed a rubber smell. I got off the highway. I still noticed the smell did not go away. So I opened the windows & turned off the AC. Then I saw white smoke coming from the vents and smoke coming from the right side of the hood, in front of the passenger side. I proceeded to pull over and parked the car. We exit the car & saw smoke/flames coming from the right passenger side & underneath the car. I called 911. There were no warnings or indications on my dashboard that something was wrong. I got my car serviced a month prior to this fire at a certified Jeep dealership. My car was deemed a total loss by my insurance....

The best way I can describe it is that it has the "Death Wobble". My mechanic is still attempting to get all of the parts that are needed and I just turned 44,000 on my Jeep.

I took my 2021 diesel Jeep in for a Y81 Emissions recall on 02.19.24. Since then, my vehicle has had its check engine light go on SIX TIMES with a P0133 alert which refers to an O2 sensor. I have taken it in to the dealership for a resolution six times. Currently, it is set to be diagnosed and repaired yet one more time on 01.22.25. Now we are in the middle of winter and I feel like the vehicle is about to die at intersections and roundabouts when I approach them. I tried to go through an arbitration with FCA USA LLC which produces the Jeep brand and it was denied for a repurchase of the vehicle because the arbitrator felt it was not a safety issue since I still drive the vehicle and they are technically not in violation of the warranty which I did not accept as...

I have been having random issues with my backup camera on my vehicle and noticed the recall only includes 2024 yrs. I have reported this to my dealership as early as right after purchase in Dec of 2021. I have had the vehicle for 3yrs and it the back up camera stops working randomly at minimum once a month and probably more often than that. My dealership every time I take in for service cant find any issues but now that there is a recall I would like to be included in it.

There is a air filter behind the dash glove box that continues to move (makes sound) as if its running after the vehicle is off. When you open doors you can hear the noise of the filter or component or something making a noise

My name is [XXX] . I am part of the the Jeep 4XE community. I have been heavily invested in the 4XE community from the very beginning. I have the first customer owned Wrangler 4XE, I run a YouTube channel with over 9,000 subscribers and a Facebook group with over 23,000 members. I have several concerns about the 4XE and the way Jeep is possibly mishandling safety issues. I would like to open a dialog with someone at the NHTSA to voice some of these concerns. There has been a lingering battery fire issue that Jeep has now addressed with two recalls. Stories of dealership mishandling are very common. We know if one Wrangler 4XE fire that has happened after the most recent 95B recall. There is also a high failure rate of a component that is called the Electric Coolant Heater. This item is needed for defrost functionality when...

I took my jeep into the dealer for my 4xe 95b recall. They did not show me pass or fail my car went in on no battery 2 1/2 hrs later they said my car was done. I do not believe they completed the drive cycle test to show pass or fail my odometer reading was only a few miles more then when I dropped it off and no battery charge gas gage hadn't moved. There is no way they did a complete drive cycle. They didn't charge it to over 75% they did not drive it until it was a warm enough temp to run the test. I got nothing but a receipt stating recall software update was done and drive test done. Nothing about if it passed or failed. And under my jeep app they put miscellaneous vehicle inspections. The recall still shows on my car.

Ev battery. Oct 4. Code for replace ev battery. Shop wouldn’t replace ev battery because ANOTHER recall for ev came out Oct 6. Recall not available until Nov. appointment for Jan 6. Recall done. No codes for ev battery. Get 1 miles down the road. Won’t run in electric. Switched to hybrid 9 more miles it’s doesn’t use any ev battery. Get into town. No power to pull away from stop sign. I get home and park. Car doesn’t work any more. Won’t turn off. Not all the way. Try to move it. No power. This is going to kill somebody. No throttle at all.

Metal chunks found in engine oil, and as were not metal powder swirl, shavings, or specs, possibly from bottom engine crankshaft. At the crank pulley, with the belt off, I could feel nudge by hand from the middle, for an engine component with max specified endplay 0.012 inches, or fraction of a millimeter. An existing manufacturer recall, and not a safety recall, for this 2021 Jeep Wrangler 2.0L Turbo is inspection for loose bolts for water pump inlet. This vehicle will not be available for inspection requests, because it is still not, and waiting to be, diagnosed as the dealer could not necessarily hear an engine issue. I have heard it knock, like a rumbling V8 and turbo whined, and recently I decided to strain the old and knocking oil that I kept and discovered metal. There was something wrong all along. Top engine, with good gas mileage, has been...

After performing the 95B recall, within 20-30 miles of driving the CEL came on. After powering off and back on the “service charging system” alert displayed on the dash. The vehicle seemed drivable however, and I proceeded to drive it to the dealership two days later which is about 4 miles away. In multiple instances when trying to accelerate from a stop the vehicle would not accelerate to more than 3-4 mph for multiple seconds leaving me stranded pulling out across traffic in the middle of an intersection waiting on the car to accelerate to a normal speed. Regardless of how much the accelerator was pressed the vehicle just rolled forward very, very slowly. Eventually, the vehicle lurched forward violently. Within this 3-4 mile drive this happened 3 times. The car remained jerky and unpredictable. I was fortunate to be driving at a low traffic time and made sure to...

I have had 2 separate incidents with this tow bar system. Both resulted in catastrophic failure of the equipment. In Oct. 2024 while traveling in Atlanta Ga. a retaining pin came out of the tow bar on one side and resulted in the tow vehicle becoming uncontrollable. I convinced myself this was operator error. Since then, I replaced the damaged tow bar with the equivalent tow bar from Etrailer. Again on Fri [XXX] the same thing happened again with a lost pin resulting in uncontrollable vehicle while travelling through Shreveport La. I firmly believe that this tow bar system has some design flaws that allows the retaining pins to dislodge while experiencing rough road conditions. This system is designed to flat tow a vehicle behind an RV. The RV in question is a 2024 Jayco Seneca rated to tow up to 10,000lbs. The vehicle being towed is a 2021 Jeep...

On 9/29/24 with the rear window removed and the top in a closed position while driving highway speeds, the driver side rear window of my vehicle, without warning, flew off and moments later the rear driver side support flew off. The side windows of the vehicle had previously never been removed. It was a shocking experience that left me quite shaken, yet out of control to mitigate. Fortunately, there were no vehicles immediately behind me taking the impact of flying car parts, however, had there been this could have been deadly. The dealership will not be able to fully access the vehicle until 10/16/24. Upon speaking to the service manager they will take a quick look at it today (9/30)

Beginning September 30th I experienced the Death Wobble while driving on the highway. It cause violent shaking of my vehicle. It stopped when i slowed to about 50 MPH, each subsequent day after that it would start shaking when i reached a speed of over 60 MPH. It is currently with the dealer to be repaired. Issues include: steering shock has air, also there is an updated longer shoulder bolt that holds the dampner that should fix the steering wheel shake. They also discovered the shock absorbers leak shock oil. In addition, I have had to replace the auxiliary battery placed 2x since I have bought and it is already draining to low levels, which will prevent the electronic system to work less than 1 year after replacing the battery last. These all are defects to the design and should be recalled as they are safety issues.

My 2021 Jeep Wrangler suffered a power steering massive leak and gear box is defective. I only had 19,000 miles on it and the steering is very very loose and has always been loose since I purchased it. I have an appointment with Kings Crysler Jeep, Mason Ohio on September 24, 2024. The Head Service Advisor noted I was out of the 3 year/36,000 mile warranty by 2.5 months. He has NEVER heard this happening but now I think I might tow the vehicle to the dealership. No warning lights alerted me.

When driving above 30 MPH and going over a bump the car shakes and wobbles Violently feeling like the tires and steering wheel will fall off. This has been referred to as the “death wobble.” The car has some warranty remaining and is going in for repair with an authorized Jeep dealer.

Driving in electric mode around 40mph into a 55mph zone I could not accelerate and the jeep started to slow down. I put the hazards on and pulled over. Shut the jeep down and restarted. Putting hybrid mode and it seemed to work fine.

Hi, I am hereby, reporting that a clutch recall and software update was done on my 2021 wrangler jeep rubicon and the jeep would shut down when pressing the gas pedal and bogs down while driving. The jeep is still at the dealership since June 18 2024 and haven't heard anything from them so far and they won't give me a loaner vehicle. I don't have any other vehicle to drive. Any help in this matter would be greatly appreciated. Thank you.

- loss of power -lag in gas pedal response - struggles to go up hills - lunges forward at times - its a 2021 and starting to have corrosion issues

Stellantis just issued recall for backup camera - believe my Wrangler is experiencing the same issue - sometime the screen is black and other time the lines are missing when backing up. This is an intermittent issue. Was sure that my car would have been part of the recall when I saw info on news but was surprised it was not.

Jeep has failed to repair the outstanding recalls--one of which says my Jeep can spontaneously combust on/off, charging/not charging, driving/not driving. Jeep offered to buy back my Jeep and now has put it into processing hell, essentially reneging its offer to buy back my Jeep, which I have in writing.

I am concerned for the safety of my family with the recall of my jeep Wrangler. There is no remedy, is it safe to drive?

Drivers sun visor broke off while driving on November 2023 on a 2021 Jeep. I was driving at a residential area going 30mph. Dealership fixed it and assessed it as a safety issue. I brushed off the incident and considered it as normal wear and tear. Then in April 2024 the passenger sun visor broke off. I was on the interstate driving 70mph. I seldom carry passengers and when I do it's mostly after sunset. In both cases, we simply flipped visor down and it broke off. The roads were smooth both times. I went online to search for recalls but instead found many forums experiencing the same issue and suggesting to buy a 3rd party sun visor repair kit.

The clutch pressure plate was recalled in February 2023 and they still have not repaired. Seems unreasonable to have a recall for 13 months with no remedy

Jeep death wobble. Same problem as the 2018/2019 models. Over 45 mph and/or hit a bump and the Jeep wobbles uncontrollably and won’t stop until you slow to almost a stop. Incredibly dangerous for highway driving. There are no warning signs before it happens. This happened to me on a congested and fast moving highway.

Took my jeep Wrangler 4xe for the [XXX] recall fix to Cole Chrysler Dodge Jeep dealership in San Luis Obispo California. My vehicle was returned to me in less than 4 hours of drop off with a depleted electric battery. The recall fix was not done correctly per Stellantis instructions. I’ve opened up a formal case with Jeep cares but no contact has been made. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)