2012 HYUNDAI SONATA Engine Problems

I RECEIVED A NOTICE FOR SAFETY RECALL FOR MY CAR WHICH I JUST BOUGHT 3 MONTHS AGO FROM HYUNDAI DEALERSHIP IN TAMPA. MY CAR IS MAKING NOISE FROM THE ENGINE AS I DRIVE. I CALLED TODAY TO THE DEALERSHIP AND THEY STATED THAT I WOULD HAVE TO DROP THE CAR OFF. I SAID THAT'S FINE AS LONG AS I CAN GET A LOANER SO I CAN DRIVE TO MY WORK. THE PERSON (JEFFERY MARTINEZ) REFUSED STATING THAT THEY DON'T HAVE A LOANER CAR RIGHT NOW. I SAID YOU ARE GIVING ME APPOINTMENT FOR THURSDAY AND HOW CAN YOU TELL ME THAT THE LOANER IS NOT AVAILABLE FOR THURSDAY? HE JUST KEPT REFUSING AND SO I ASKED TO SPEAK TO A MANAGER AND HE JUST TELLS ME THAT THE MANAGER WILL CALL ME AND HANGS UP THE PHONE. I CALLED THIS MORNING AND TALKED TO A PERSON NAME KAREN AND SHE...

IN AUGUST, 2015 MY ENGINE SEIZED ON MY WHILE DRIVING; THERE WERE NO WARNING LIGHTS NOR ANY WARNING THAT ANYTHING WAS WRONG WITH THE CAR. THANKFULLY I WAS DRIVING 20 MPH ON A LOCAL RESIDEINTIAL STREET WITH NO CARS BEHIND ME SO I WAS NOT INJURED. HAD I BEEN ON THE HIGHWAY I WOULD HAVE BEEN SEVERELY INJURED IF NOT KILLED DUE THE IMMEDIACY OF THE CAR SHUTTING DOWN DEAD IN ITS TRACKS. A LOCAL HYUNDAI DEALERSHIP INSTALLED A BRAND NEW ENGINE AND THE CAR WAS RETURNED TO ME. I FOUND OUT A COUPLE OF WEEKS AFTER RECEIVING MY CAR BACK THAT HYUNDAI WAS PUTTING OUT A RECALL FOR ALL 2011/2012 SONATAS YET I FOUND IT INTERESTING THAT I HAD NOT RECEIVED ANY PAPERWORK. ON OCTOBER 11, 2015 MY CAR CAUGHT ON FIRE WHILE I WAS DRIVING. THE ENGINE SEIZED, I LOST MY BRAKES AND MY ABILITY TO STEER THE...

2012 HYUNDAI SONATA. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE ISSUES AND RECALL NOTICE 15V-568. *SMD THE CONSUMER STATED WHILE DRIVING, THE ENGINE BEGAN TO MAKE A LOUD KNOCKING NOISE AND HE LOST POWER TO THE VEHICLE. THE CONSUMERS MANAGED TO DRIVE TO AN AUTO MECHANIC JUST A FEW MILES AWAY, WHERE HE WAS INFORMED THE BEARINGS HAD GONE OUT AND THE ENGINE NEEDED TO BE REPLACED. THE CONSUMER HAD THE VEHICLE TOWED TO HIS MECHANIC WHERE THE ENGINE WAS REPLACED AT A COST OF $ 2656.83.*JB

DURING COLD WEATHER, THE 2.0 TURBO SONATA ENGINE WILL CUT POWER TO THE CAR AND GO INTO A "LIMP" MODE IF AN OVER BOOST CODE (USUALLY P0605 & P2110 ), IS TRIGGERED. THIS CAUSES AN UNSAFE SITUATION AS THERE IS VERY LITTLE POWER AVAILABLE TO GET OUT OF THE WAY OR CAN CAUSE A REAR VEHICLE CRASH. THERE HAVE BEEN A COUPLE TIMES WHERE THIS HAS HAPPENED ON 0 DEGREE DAYS OR EVEN AT 30 DEGREES. THIS WILL HAPPEN AT ANY SPEED IF THE BOOST PRESSURE IS EXCEEDED AND MAKES FOR A VERY DANGEROUS SITUATION. THE ECU SHOULD NOT BE CUTTING POWER OR FUEL, IT SHOULD BE REDUCING THE BOOST TO COMPENSATE FOR TEMPERATURE. THE ONLY WAY TO RESTORE THE POWER TO THE ENGINE, IS TO SHUT THE CAR OFF AND RESTART.....CODES WILL STILL BE ACTIVE BUT THE POWER WILL RESTORE ITSELF.

TL* THE CONTACT OWNS A 2012 HYUNDAI SONATA. WHILE DRIVING AT APPROXIMATELY 25 MPH, THE VEHICLE SPUTTERED AND THE ENGINE STALLED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V568000 (ENGINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,000.

TL* THE CONTACT OWNS A 2012 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 75 MPH, THE ENGINE STALLED WITHOUT WARNING. AFTER SEVERAL ATTEMPTS, THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BATTERY WAS LOW AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V568000 (ENGINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 27,560. UPDATED 1/27/16 *SS *JS

TL* THE CONTACT OWNS A 2012 HYUNDAI SONATA. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ONCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,300. UPDATED 1/13/16 LN *JS

IN AUGUST 2013 I PURCHASE SAID CAR. A MONTH LATER, I NOTICED THE ENGINE WAS CONSUMING/BURNING OIL EXCESSIVELY, APPROX. 1 QT./500 MILES. TOOK IT IN TO GLENDORA HYUNDAI, THEY TOPPED IT OFF...MY IMPRESSION OF THEM, NO BIG THING TO THEM. I TRIED TO TELL THEM SOMETHING, BUT TO NO AVAIL. I HAVE EMAILS OF MY CONCERNS TO GLENDORA HYUNDAI, ETC. ON JULY 1 THROUGH 9, 2015, I TOOK A ROAD TRIP IN THE SONATA TO VACATION IN DALLAS, TX. ON THE WAY BACK ON EARLY THURSDAY, JULY 9, THE ENGINE STARTED TO PING AND SPUTTER. PULLED OVER AND ASSESSED ENGINE FAILURE. I WAS 35 MILES AWAY FROM ODESSA, I FORTUNATE TO GET THERE SAFE. STRUGGLING AT 45 MPH OFF HIGHWAY 20, I WAS ABLE TO PULL IN AT 4:00AM INTO THE ODESSA HYUNDAI. I WAITED THAT FRIDAY MORNING UNTIL IT OPENED AT 7:00AM. ON FRIDAY, ODESSA HYUNDAI WAS ABLE TO...

TL* THE CONTACT OWNS A 2012 HYUNDAI SONATA. WHILE DRIVING APPROXIMATELY 50 MPH, THE INSTRUMENT PANEL LIGHTS BEGAN TO FLASH ON AND OFF BEFORE THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V568000 (ENGINE), BUT THE REMEDY TO REPAIR THE VEHICLE WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 50,000.

TL* THE CONTACT OWNS A 2012 HYUNDAI SONATA. WHILE DRIVING AT APPROXIMATELY 20 MPH, A LOUD KNOCKING NOISE WAS HEARD FROM THE ENGINE. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V568000 (ENGINE); HOWEVER, THE REMEDY OR PART WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 54,300.

I WAS DRIVING MY 2012 SONATA ON THE INTERSTATE AT NORMAL SPEEDS, WHEN I HEARD A BANG AND THEN SOME CLICKING COMING FROM THE ENGINE. THE ENGINE LIGHT CAME ON, SO I PULLED OVER QUICKLY. WHEN I GOT OUT OF THE VEHICLE, WHITE SMOKE WAS COMING FROM UNDER THE HOOD. WHEN I GOT OUT, THERE WAS A SMALL FIRE ON THE LEFT SIDE OF THE ENGINE. I CALLED 911 WHEN MY QUICK ATTEMPT TO PUT THE FIRE OUT WITH A BOTTLE OF WATER WAS USELESS. I WAS ADVISED BY 911 TO GET CLEAR OF THE CAR AND SO I WATCHED AS MY CAR WITH LESS THEN 35,000 MILES BURNED. THE VEHICLE WAS A TOTAL LOSS. THERE HAD BEEN NO ISSUES WITH THE CAR UP UNTIL THIS FIRE. IT TOTALLY BURNED IN ABOUT 15 MINUTES.

MY CHILDREN WERE DRIVING AND STOPPED AT A LIGHT. WHEN THE LIGHT CHANGED, MY SON PRESSED THE ACCELERATOR AND THE CAR DIDN'T MOVE. IT SHUT OFF. WHEN HE ATTEMPTED TO START IT, NOTHING HAPPENED. NO LIGHTS EVER CAME ON ON THE DASHBOARD. HAD THE CAR TOWED TO POHANKA HYUNDAI IN CAPITAL HEIGHTS, MD AND WAS TOLD THAT THE ENGINE WAS LOCKED UP AND THAT IT WAS NOT COVERED UNDER WARRANTY BECAUSE I WAS THE SECOND OWNER AND IT WOULD COST ME $5774,.88 TO HAVE IT REPLACED WITH A REBUILT ENGINE. I ALSO PURCHASED AN ADDITIONAL WARRANTY WHICH I THOUGHT WAS BUMPER TO BUMPER WHEN I PURCHASED THE CAR IN JANUARY 2014.

TL* THE CONTACT OWNS A 2012 HYUNDAI SONATA. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE FUEL PUMP, BUT THE FAILURE PERSISTED. UPON REFUELING THE VEHICLE, IT SURGED FORWARD. THE CONTACT LATER RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V568000 (ENGINE), BUT WAS UNABLE TO RECEIVE THE PART FROM THE DEALER WITHIN A REASONABLE TIME FRAME. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

IN OCTOBER 2014, I HAD AN INCIDENT WHERE MY CAR COMPLETELY SHUT DOWN WHILE DRIVING STRAIGHT ON THE FREEWAY (PLEASE SEE ATTACHED HYUNDAI PAPERWORK) WITHOUT WARNING. MY CAR WAS AT THE HYUNDAI DEALER IN NORTH PALM BEACH FOR 3 1/2 BUSINESS DAYS BEFORE FINDING OUT MY CAR WAS "FIXED" AND READY TO GO. THE FIRST TWO CONSECUTIVE DAYS MY CAR WAS THERE, I WAS CALLED BY THE SERVICE MANAGER ROB AND WAS TOLD THAT "THE ENGINE WAS COMPLETELY LOCKED UP, AND THEY HAD TO RUN A SERIES OF DIAGNOSTIC TESTS PRIOR TO REPLACING THE ENGINE" WHICH WAS UNDER WARRANTY (UNDER 60,000 MILES AT THE TIME). HOWEVER, I WAS CALLED ON DAY 3 WHERE ROB STATED THAT MY "ENGINE WAS RUNNING SMOOTHLY AND NO DIAGNOSTIC CODES WERE SHOWING UP." MY PAPERWORK FROM HYUNDAI STATES THAT THE ONLY PROBLEM WAS THE NEED TO TIGHTEN THE BATTERY TERMINALS AND RECHARGE THE BATTERY. CHECKING...

MY HUSBAND PURCHASED THE CAR IN FEB 2015. WE TOOK A TRIP IN THE CAR TO NY IN SEPT 2015. ONLY 7MONTHS OF OWNERSHIP. WHILE DRIVING ON A CITY STREET, ALL THE LIGHTS BLINKED ON. THE CAR STARTED TO SLOW DOWN, WE HEARD A LOUD KNOCKING NOISE. WE TURNED THE CAR OFF, TURNED IT BACK ON AGAIN. THE CAR JUST STALLED. LUCKILY WE DIDN'T GET INTO AN ACCIDENT. WE TOWED IT TO THE NEAREST HYUNDAI DEALER, WHO TOLD US WE WILL HAVE TO PAY FOR ANOTHER ENGINE. THEY COULDN'T EVEN ASSIST US WITH A RENTAL. SO WE ARE PAYING OUT OF POCKET FOR A RENTAL CAR. LUCKILY THIS RECALL WAS SET. HOPEFULLY WE CAN GET REIMBURSED FOR THIS RENTAL CAR.

TL* THE CONTACT OWNS A 2012 HYUNDAI SONATA. WHILE DRIVING AT 15 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE COMPARTMENT OF THE VEHICLE. IN ADDITION, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO MULTIPLE DEALERS WHO DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V568000 (ENGINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 94,000.

TL* THE CONTACT OWNS A 2012 HYUNDAI SONATA. WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 89,895.

TL* THE CONTACT OWNS A 2012 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE AT A STOP LIGHT, THERE WAS STRONG ABNORMAL ODOR OF FUEL. IN ADDITION, THE VEHICLE STALLED WITHOUT WARNING AND WOULD TAKE MULTIPLE ATTEMPTS TO RESTART. THE FAILURE RECURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

WAS DRIVING DOWN THE INTERSTATE FROM FL TO SC AT 75MPH WITH AN INFANT IN THE CAR WHEN WITH NO WARNING STARTED MAKING A LOUD NOISE, LUCKILY AN EXIT WAS RIGHT THERE WITH A GAS STATION AND WAS ABLE TO ROLL THE CAR IN. I CALLED A TOW TRUCK AND HAD IT TAKEN TO THE HYUNDAI DEALERSHIP WHERE THEY SAID MY MOTOR HAS SEIZED. I WAS STRANDED AT NIGHT TIME WITH AN INFANT IN GEORGIA, 2 HRS AWAY FROM HOME KNOWING NO ONE. I AM A SINGLE MOM THAT IS ALREADY STRUGGLING FINANCIALLY AND NOW I AM TOLD THAT I HAVE TO PAY $5,300 FOR A NEW ENGINE FOR A CAR THAT IS 3 YEARS OLD!!! I'VE BEEN READING A LOT OF THE SAME PROBLEMS HAVE OCCURRED WITH OTHER PEOPLE WITH THE EXACT YEAR VEHICLE.

I WAS BRINGING A RESCUE DOG TO HIS NEW OWNERS AND DRIVING ON CRUISE CONTROL AT 70 MPH ON HIGHWAY 495 SOUTH BEEN DRIVING FOR ABOUT 1 1/2 HOURS( NOT A CONSTANCE 70 MPH) AND THE LIGHTS ON MY DASH BOARD LIT UP LIKE A CHRISTMAS TREE AND I HAD NO POWER IN THE GAS PETAL. STOPPED ON SIDE OF HIGHWAY. CALLED INSURANCE COMPANY FOR A TOW AND CONTACTED A RENTAL CAR AGENCY. THE CAR WENT TO A WESTFORD BP GARAGE IN WESTFORD MASSACHUSETTS THE PEOPLE WHO RESCUED THE DOG RESCUED US ALL FROM SIDE OF HIGHWAY AND HE REFERRED US TO THAT GARAGE.. WENT HOME AND WENT TO LOCAL DEALERSHIP AND HAD IT TOWED THERE, WHICH IS CLOSER TO MY RESIDENT THEY DID A CHECK AND DETERMINED THAT I NEEDED AN NEW ENGINE. WE BOTH GOT ON THE PHONES WITH HYUNDAI AND HYUNDAI PAID FOR THE PARTS BUT I...

ENGINE SEIZED WITHOUT ANY WARNINGS (AS HYUNDAI STATES WE WOULD HAVE) WHILE DRIVING APPROXIMATELY 73-75 MPH. WAS ACCELERATING TO MOVE FROM LEFT LANE TO RIGHT IN ORDER TO EXIT HIGHWAY DURING RUSH HOUR TRAFFIC ON NJ 78 WEST. WITHOUT WARNING ALL LIGHTS CAME ON AND ENGINE SHUT DOWN. PAYING TO HAVE A USED ENGINE INSTALLED WITH A 1 YEAR WARRANTY. DEALERSHIP SAYS HYUNDAI WILL NOT REPLACE OUR ENGINE FOR FREE BECAUSE WE WERE OVER THE WSRRSNTY PERIOD.

WHILE DRIVING ON THE INTERSTATE I NOTICE MY CAR MAKING A KNOCKING NOISE,AND ENGINE LIGHT ON. I THEN PULLED OVER AND THE CAR COMPLETELY DIED. I HAD MY CAR TOLLED TO HYUNDAI SERVICE DEPARTMENT.THEY INFORMED ME THAT MY OIL PAN HAD SLUDGE AND METAL PARTICLES. THEY INFORMED ME THAT IT WAS BECAUSE OF LACK OF OIL CHANGES AND NEED TO REPLACE THE ENGINE.I DISAGREED,BUT WAS FORCE TO REPLACE THE ENGINE AT ANOTHER REPAIR SHOP.WITH THE RECENT HYUNDAI SONATA RECALLS, I FEEL THIS WAS THE EXACT SAME PROBLEM I HAD. I AM HOPING THAT I CAN GET SOME ANSWERS AND A REFUND.

WHILE DRIVING THROUGH RESIDENTIAL AREA MY ENGINE MADE LOUD CLICKING SOUNDS AND LOST COMPLETE POWER. I COASTED TO A SIDE STREET AND PARKED. THERE WAS NO WARNING LIGHTS OR PRIOR ISSUES TO ALERT ME THAT MY ENGINE WAS TROUBLED. TRIED TO RESTART AND THE ENGINE WAS SHAKING AND MAKING NOISE SO I CUT IT OFF AND CALLED FOR A TOW. AFTER RETURNING HOME I BEGIN TO RESEARCH THE PROBLEM AND FOUND HUNDREDS OF COMPLAINTS WITH THE SAME EXACT ISSUE ON THE SAME MODEL AND YEAR CAR. THIS TOLD ME THAT MY ENGINE PROBLEMS WERE JUST A COINCIDENCE BUT MORE OF A MANUFACTURER DEFECT. I HAD A MECHANIC VERIFY THAT MY ENGINE WAS GONE AND NEEDED TO BE REPLACED. THIS IS AN EXTREMELY DANGEROUS SITUATION. LUCKILY I WAS NOT DRIVING AT HIGHWAY SPEEDS WHICH SOME DRIVERS REPORTED. HYUNDAI, OF COURSE, REFUSES TO ACKNOWLEDGE THIS ISSUE. I SEE TWO LAW FIRMS THAT...

MY DAUGHTER WAS DRIVING ON THE HIGHWAY IN THE 2ND TO LEFT LANE ABOUT 65 MPH, CHECK ENGINE LIGHT WAS ON AND ALL OF THE SUDDEN SHE LOST COMPLETE CONTROL OF THE ACCELERATOR PEDAL. SHE SAY'S SHE PUSHED IT ALL THE WAY DOWN TO THE FLOOR SEVERAL TIMES, NO PRESSURE, NO CONTROL AND OBVIOUSLY SLOWED DOWN. SHE MOVED OVER TO GET TO THE RIGHT SHOULDER TO STOP AND SEE WHAT IS THE ISSUE, LUCKILY THE BRAKES WORKED (HARD PEDAL), BUT MANY CARS WERE DODGING HER TRYING NOT TO HIT HER. SHE DIDN'T GET IN AN ACCIDENT, BUT SURE CLOSE TO BEING IN ONE AND HIGH SPEEDS. FRIGHTENING TO SAY THE LEAST. I HAS ABOUT 87,000 MILES ON THE CAR. I AM STILL CONCERNED IF I PUT ANOTHER ENGINE SHOULD I WORRY ABOUT THIS HAPPENING AGAIN? IT COULD HAPPEN AGAIN UNLESS IT'S RECALLED AND THE PROBLEM FIXED! I AM JUST GLAD...

ON MORE THAN A DOZEN OCCASIONS SINCE PURCHASE, THE VEHICLE HAS NEGLECTED TO ACCELERATE WHEN THE GAS PEDAL IS DEPRESSED NEARLY CAUSING ME TO BE HIT BY ONCOMING TRAFFIC. ADDITIONALLY, THE VEHICLE HAS SLAMMED ON THE BRAKES AT HIGH RATES OF SPEED WHEN THE DRIVER WAS BARELY APPLYING PRESSURE TO THE PEDAL; ALMOST CAUSING THE VEHICLE TO BE REAR ENDED. THE VEHICLE HAS BEEN INSPECTED BY TWO HYUNDAI DEALERSHIPS FOR THE ISSUES; OF WHICH THEY CLAIMED TO HAVE REPLICATED. BOTH DEALERSHIPS STATED THAT IT WAS NORMAL BEHAVIOR FOR THE VEHICLE AND THERE WAS NOTHING THEY COULD DO TO MAKE THE ISSUES GO AWAY.

MY WIFE AND LITTLE KIDS WERE TRAVELING ON HIGHWAY WHEN THE CAR LOST POWER STEERING AND ALL THE LIGHTS LIGHT UP ON THE INSTRUMENTAL PANEL. LUCKILY, SHE WAS ABLE TO MANEUVER THE CAR TO A SIDE OF THE ROAD AVOIDING REAR-ENDED COLLISION. THERE WAS NO INDICATION OF ANY PROBLEM UP UNTIL LAST SECOND. IT WAS TOWED AWAY AND LATER DECLARED AS ENGINE SEIZED. THIS CAR IS DANGEROUS AND HAZARD ON A ROAD.

ON AUGUST 7, 2015 AT APPROXIMATELY 9:30 PM, I WAS COMING BACK FROM RUNNING AN ERRAND WITH MY 16-YEAR OLD DAUGHTER IN THE CAR WITH ME. I MADE A RIGHT-HAND TURN WHEN SUDDENLY, ALL OF THE LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED AND THE ENGINE STOPPED. ADDITIONALLY, I LOST ALL POWER STEERING, ETC. I WAS ABLE TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD IMMEDIATELY, BUT ALMOST GOT REAR-ENDED BY A PICKUP TRUCK THAT WAS FOLLOWING ME. I TURNED OFF THE CAR, LET IT SIT FOR A FEW MINUTES, AND STARTED IT UP AGAIN. THE CAR SEEMED FINE AT THAT POINT, AND I WAS ABLE TO CONTINUE MY SHORT DRIVE BACK TO MY HOME (APPROXIMATELY 1.25 MILES). WHEN I ARRIVED AT HOME AND PLACED THE CAR IN PARK, THE OIL PRESSURE LIGHT WAS FLICKERING SLIGHTLY. I TURNED THE CAR OFF AND WENT INTO THE HOUSE FOR THE NIGHT....

WE WERE TRAVELING AT APPROXIMATELY 65 MPH IN THE 2ND FROM RIGHT LANE IN HEAVY RUSH HOUR TRAFFIC WHEN THE ENGINE ABRUPTLY STOPPED AND COULD NOT BE RESTARTED. MY WIFE HAD DIFFICULTLY STEERING AND BRAKING TO MOVE TO THE BREAKDOWN LANE FROM THE LOSS OF ENGINE POWER. IT WAS VERY FORTUNATE THAT WE WERE NOT HIT BY ONCOMING TRAFFIC. THE CAR WAS TOWED TO THE DEALER WHO STATED THAT THE ENGINE HAD SEIZED AND NEEDED TO BE REPLACED AT GREAT EXPENSE.

WHILE DRIVING AT A SPEED OF 70 MPH THE ENGINE QUIT. THERE WAS NO PREVIOUS NOISE OR INDICATION OF A PROBLEM. TOW TRUCK DRIVER TRIED TO JUMP START WITH NO SUCCESS. TOWED TO HYUNDAI DEALER. THEY TESTED THE BATTERY AND DETERMINED THERE WAS A DEAD CELL. NEW BATTERY WAS INSTALLED STILL WOULD NOT START. AFTER FURTHER INVESTIGATION IT WAS DETERMINED THE ENGINE SEIZED UP. ORDERED AND INSTALLED A NEW REMANUFACTURED ENGINE. TOOK ELEVEN DAYS TO COMPLETE. UPDATE 9/15/15*CW UPDATED 12/13/2017*CN

I HAD A MINOR FENDER BENDER ( A PERSON HIT ME AND TOOK OFF) 1 BLOCK LATER THE ENGINE DIED. IT WAS TAKEN TO THE SHOP WHERE I WAS FIRST TOLD IT NEEDED A NEW BATTERY AND A STARTER. BATTERY WAS ONLY 12 MONTHS OLD AND STARTER WAS NOT A PROBLEM. I HAD IT TOWED TO HYUNDAI AND THEY TOLD ME THE ENGINE SEIZED FROM SLUDGE AND WATER. I I DONT EVEN HAVE A SPRINKLER SYSTEM FOR WATER DAMAGE AND WE ARE IN A DROUGHT AND THE OIL WAS CHANGED A FEW MONTHS AGO. I HAD READ ABOUT THE SEIZED ENGINE ISSUES ON THIS MODEL BUT HYUNDAI SAYS THAT IS NOT TRUE. I POINTED OUT TO THEM THAT NO OIL LIGHT CAME ON AND NO CHECK ENGINE LIGHT CAME ON.I HAVE HAD NO PROBLEMS WITH THIS CAR UNTIL THIS HAPPENED. THEY REFUSE TO DO ANY THING ABOUT IT BUT ARE...

ENGINE RATTLING SOUND UPON ACCELERATION AND OIL BURNING FAST.BROUGHT INTO DEALERSHIP 3X FOR THE SAME CONCERN. TWICE WHILE IT WAS STILL UNDER WARRANTY. SENT HOME SAYING THEY COULDN'T FIGURE IT OUT. EVEN ASSURED US IT WAS NOTHING SERIOUS. ON THIRD TIME (60,800 MI), CAR BURNED THROUGH OIL AND OIL LIGHT CAME ON, RATTLING SOUNDS CAME BACK, STEREO STOPPED WORKING, CAR DIED (NEW STARTER NEEDED). DEALERSHIP INSPECTED IT AND SAID THEY FIGURED IT OUT THIS TIME (HOW CONVENIENT THAT THEY FINALLY DID RIGHT AFTER THE WARRANTY EXPIRED), SUGGESTED A BRAND NEW ENGINE. SAYS THERE WAS TONS OF SLUDGE AND METAL SHAVING IN THE OIL. THEY CITED 'OWNER NEGLECT'. WE PROVIDED THEM EVERY DOCUMENTATION OF MAINTENANCE AND CONSISTENT OIL CHANGES. DENIED HONORING OUR WARRANTY. DID RESEARCH AND FOUND 2011-2012 SONATAS HAVE A MANUFACTURING ENGINE DEFECT. PEOPLE ALL HAVE SAME ISSUES AND OUTCOMES WITH THEIR CARS. HYUNDAI WILL NOT EVEN LOOK AT OUR...

MY ENGINE SEIZED WITH NO WARNING. I WAS TRAVELING DOWNHILL AND THE MOTOR JUST SHUTOFF. HAD THE VEHICLE TOWED TO THE DEALER WHO NOTIFIED ME THAT THE ENGINE WAS SEIZED. THIS IS A HUGE SAFETY CONCERN AS IT COULD HAVE HAPPENED IN THE MIDDLE OF TRAFFIC. *TR

I WAS DRIVING HOME FROM WORK WHEN ALL OF A SUDDEN MY CHECK ENGINE LIGHT CAME ON AND I STARTED HEAR NOISES COMING FROM MY ENGINE. I PULLED OVER SOMEWHERE SAFE AND EVENTUALLY HAD TO GET IT TOWED TO A HYUNDAI DEALER. I'M NOT THE ORIGINAL OWNER OF THE CALL SO THE DEALER TELLS ME I CANT USED THE 100,000 MILE WARRANTY. I HAVE ANOTHER WARRANTY COMPANY WHO WANTS THE DEALER SHIP TO COME TO A FINAL DECISION AS TO WHY MY ENGINE STOPPED WORKING. THERE WAS NO SLUDGE IN MY OIL PAN BUT THERE US METAL WHICH OBLIVIOUSLY MEANS SOMETHING MESSED UP ON THE INSIDE. HYUNDAI IS TELLING ME UNDER NO CIRCUMSTANCE WILL THEY FURTHER INVESTIGATE WHAT HAPPENED TO MY VEHICLE AND WYNN IS TELLING THEM THEY WILL NOT PAY FOR MY VEHICLE UNLESS THEY HAVE THE SPECIFIC REASON AS TO WHY A ENGINE THAT ONLY HAD 86,000 MILES...

WHEN ATTEMPTING TO ACCELERATE THE VEHICLE TO GET ONTO THE FREEWAY THE ENGINE LOST ALL POWER. THIS INCIDENT HAS HAPPENED MULTIPLE TIMES ON MULTIPLE OCCASIONS, EACH TIME HYUNDAI AND THE DEALERSHIP HAVE FAILED TO IDENTIFY AND FIX THE PROBLEM. EACH POWER FAILURE EVENT HAS BEEN A NEAR ACCIDENT. I AM CONCERNED FOR THE MY PASSENGERS AND MY OWN SAFETY. THE VEHICLE HAS RECEIVED ALL REGULAR MAINTENANCE, OIL CHANGES AND RECALLS. A CASE HAS BEEN OPENED WITH HYUNDAI CUSTOMER SUPPORT. *TR

EARLIER THAT DAY THE WRENCH WAS LIT UP ON THE DASHBOARD, BUT IT DISAPPEARED. I WAS DRIVING OUT OF MY NEIGHBORHOOD AT ABOUT 15-20 MPH AND THE SCREEN READ "WARNING! DO NOT DRIVE! IRREPARABLE DAMAGE TO ? I CAN'T REMEMBER" IT STARTED TO FREEZE THE DRIVING. THEN I PARKED IT AND IT WOULD NOT START BACK UP. IT WAS TOWED TO THE DEALER AND THEY REPLACED THE BATTERY AND HPCU. IT SCARES ME TO THINK WHAT WOULD HAVE HAPPENED IF I WAS ON THE FREEWAY. I BOUGHT THIS CAR APRIL 20, 2014 AND NOW CAN JUST GET 2/3'S WHAT I PAID FOR IT. SAD, BUT TRUE. WHEN I GET SOME MONEY I WILL BE TRADING THIS IN AS I AM NERVOUS DRIVING THIS CAR NOW. *TR

WITHOUT NOTICE/WARNING, ENGINE STARTED MAKING A METALLIC KNOCKING/FLAPPING SOUND WITH A LOT OF BLUE SMOKE EXHAUST WHEN RAPIDLY ACCELERATING. SHORTLY AFTER, ENGINE OIL LIGHT FLICKERED MOMENTARILY. FROM PAST EXPERIENCE, I KNEW TO PAY ATTENTION TO THIS. BY THE END OF THE SAME DAY, I ADDED ALMOST 5 QUARTS OF OIL. I ALSO BROUGHT THE CAR TO LOCAL HYUNDAI DEALER FOR A LATE AFTERNOON (4:30PM) APPOINTMENT JUST BEFORE NEW YEAR'S EVE. SERVICE ADVISOR MENTIONED THAT "BY THE TIME THE ENGINE OIL LIGHT COMES ON YOU'VE GOT LESS THAN A QUART OF OIL LEFT". HE SUGGESTED WE BRING THE CAR BACK WHEN THEY WOULD HAVE MORE TIME TO WORK ON IT. I PLANNED TO HAVE 40000-MILE SERVICE AND EXPECTED A SOMEWHAT EXPENSIVE REPAIR, SO I NEEDED TO WAIT UNTIL FEB 4, WHEN I WOULD HAVE FUNDS AVAILABLE. I BROUGHT THE CAR FOR SERVICE ON 2/4, AND WAS TOLD LATER THAT DAY THAT...

WAS DRIVING 35 MPH MAKING A TURN WHEN I HEARD A KNOCKING NOISE. WAS SUBTLE AT FIRST. CHECKED OIL AND WAS LOW. ADDED 1 QRT OF OIL. DROVE HOME ABOUT 2 MILES AND KNOCKING BECAME EXTREMELY LOUD. TOOK IT TO LEN STOLER HYUNDAI DEALERSHIP AND THEY STATED THAT EXHAUST MANIFOLD, DRIVE BELT, PISTONS, AND VALVES NEED TO BE REPLACED. BASICALLY, $6300.00 WORTH OF WORK. CAR IS UP TO DATE ON ALL MAINTENANCE. NO OTHER ISSUES WITH CAR. WARRANTY DOES NOT COVER ENGINE DAMAGE AND NO HELP WAS GIVEN. I HAVE SEEN MANY OTHER COMPLAINTS ABOUT THE SAME ENGINE ISSUES. HYUNDAI SHOULD REPLACE! *TR

FIRST TIME NOTICED THAT THE OIL PAN IS LEAKING AT 15,042 MILES. TOOK THE CAR TO THE DEALERSHIP AND THEY RESEALED IT UNDER WARRANTY. STARTED LEAKING AGAIN AT 22,566 MILES AND TOOK IT TO THE DEALERSHIP. THIS TIME THEY REPLACED THE OIL PAN AND RESEALED IT AGAIN UNDER THE WARRANTY. I JUST NOTICED IT THAT IT'S LEAKING AGAIN AT 30,660 MILES. I AM REALLY CONCERNED THAT THIS BRAND NEW CAR IS LEAKING OIL LIKE THIS. ALSO, I STRONGLY FEEL THAT THE FIX IS NOT ADDRESSING THE UNDERLYING ISSUE WHICH MAY BE SOMETHING ELSE. I THINK HYUNDAI NEEDS TO LOOK AT THIS ISSUE CLOSELY AND MUST COME UP WITH A PERMANENT SOLID FIX. I HAVE BEEN READING ON THE HYUNDAI SONATA FORUM THAT MANY ARE FACING THE SAME PROBLEM. I AM SURPRISE THAT THERE IS NO RECALL FOR THIS YET. THIS IS MY FIRST AND LAST HYUNDAI. *TR

THE CAR HESITATES DURING START UP! I HAVE HAD IT INTO THE SHOP APPROX 9 TIMES SINCE WE HAVE HAD THE CAR. THIS LAST TIME (APPROX 30K MILES) THEY TOLD ME IT WAS NORMAL. I AM AFRAID THIS CAR IS AN ACCIDENT WAITING TO HAPPEN! *TR

SMELL OF GAS, THIS CAR HAVE HAD 2 MOTOR REPLACED ONE IN JUNE 2014/ 2ND IN AUGUST 2014 AND NOW A THIRD IN OCT 23, FILLED THE CAR UP WITH GAS, GOT ON THE INTERSTATE AND THE CAR STARTED CUTTING BACK, BIG CLOUDS OF SMOKE CAME FROM THE REAR END, BLACK SUTT ON THE EXHAUST PIPES.THE CAR PUTTER ON THE INTERSTATE, HAD TO GET OFF THE ROAD CAR SHUT DOWN WHILE TRY TO STEER TO SAFETY, ONCE CAR SHUT DOWN IT BECAME HARD TO CONTROL, WENT OTHER THE SIDE OF RODE, HIT A WATER PIPE LINE, CAR NEVER CRANK AFTER THAT. HAD TO BE TOWED TO HYUNDAI DEALER SHIP. THIS IS THE 2ND TIME I HAVE REPORTED THIS CAR. NOW IT IS IN THE SHOP AWAITING ENGINEERING TO REVIEW IT. FOR THE 3RD MOTOR. *TR

WHILE DRIVING UPHILL AT ROUGHLY 50 MPH THE ROD BEARING IN MY 2.4 LITER HYUNDAI SONATA FAILED. THE ENGINE WAS RUNNING APPROXIMATELY 5000 RPMS AT THE TIME OF FAILURE. THE MOTORS WAS RUINED. THE VEHICLE HAS BEEN MAINTAINED ACCORDING TO THE NORMAL USE MAINTENANCE SCHEDULE, HAVING OIL CHANGES EVERY 5,000 MILES. *TR

CAR ACCELERATED SUDDENLY AND COULD NOT BE STOPPED. I WAS IN A PARKING LOT AND BACKED UP TO LEAVE, ACCIDENTALLY HITTING A STORAGE CONTAINER WITH MY REAR BUMPER. I PUT CAR IN DRIVE TO MOVE FORWARD AND THE CAR ACCELERATED OUT OF CONTROL BY ITSELF TRAVELING FAST ABOUT 30 FEET. I TRIED TO BRAKE BUT COULD NOT STOP THE CAR. WE HIT A FENCE, MOVING THE FENCE ABOUT 5 FEET AND HIT THE CAR PARKED ON THE OPPOSITE SIDE OF THE FENCE, SMASHING IN THE PASSENGER SIDE OF THE CAR. WE HAD OUR SEAT BELTS ON AND WERE NOT INJURED BUT WITHOUT SEAT BELTS WE WOULD HAVE BEEN THROWN THROUGH THE WINDSHIELD. I DO NOT FEEL SAFE DRIVING THIS CAR ANYMORE. *TR

AN ENGINE ROD BLEW A HOLE IN THE ENGINE BLOCK. THIS WAS DONE AT A SPEED OF AROUND 48 MPH. THIS IS BASED ON THE DEALERSHIP TECHNICIAN INSPECTION. LUCKILY I WAS NOT NEXT TO ANOTHER CAR WHEN THIS OCCURRED OR IT VERY LIKELY WOULD HAVE CAUSED AN ACCIDENT. *TR

WHILE ATTEMPTING TO ACCELERATE FROM A STOP THE VEHICLE GOT TO 30 TO 35 MPH AND WOULD NOT GO ANY FASTER DESPITE PRESSING GAS PEDAL AND RPMS WENT UP TO 7 AND 8. AFTER PUSHING GAS PEDAL SEVERAL TIMES THE CAR WILL FINALLY INCREASE IN SPEED WHICH IS VERY CONCERNING GIVEN I DRIVE ON AN INTERSTATE. THIS HAS HAPPENED 3 TIMES IN PAST 4 MONTHS AND SAME EXACT THING AT 10 MPH AND RPM WENT TO 4 AND 5 AND CAR WOULD NOT INCREASE SPEED. I STOPPED VEHICLE AND ACCELERATED AND THEN IT OPERATED NORMALLY. DEALERSHIP HAS BEEN IN UNABLE TO DUPLICATE IT AND HAS QUESTIONED ME SEVERAL TIMES ABOUT DRIVING WITH TWO FEET WHICH I DO NOT DO AND LAYING PURSE ON CONSOLE AGAINST SHIFTER WHICH I ALSO DO NOT DO. 3 OF THE 4 TIMES IT HAPPENED IT WAS AT THE BEGINNING OF MY DRIVE WITHIN FIRST MILE...

TL* THE CONTACT OWNS A 2012 HYUNDAI SONATA. THE CONTACT STATED THAT AFTER PARKING AND TURNING OFF THE VEHICLE IN HER RESIDENTIAL GARAGE, THE VEHICLE STARTED ROLLING BACKWARDS. IN AN ATTEMPT TO STOP THE VEHICLE THE CONTACT FELL WHICH CAUSED HER TO SCRAPE HER CHIN NEEDING 10 STITCHES. THE CONTACT WAS TAKEN TO THE EMERGENCY ROOM. THE FAILURE MILEAGE WAS 39,000. THE CONSUMER STATED SHE AND THE POLICE ATTEMPTED TO PIECE TOGETHER THE SCENARIO, THAT THE VEHICLE WAS NOT IN PARK, WHEN SHE TURNED IT OFF. THE CONSUMER STATED THE VEHICLE COULD BE PUT INTO ANY GEAR, AND IT COULD ROLL, WHETHER IT WAS ON A FLAT OF HILLY SURFACE. UPDATED 08/20/14 UPDATED 8/27/14*CN

WHEN I APPLIED BREAK MY RPM IDLE GOES UP. I DON'T KNOW IF THAT IS SAFE I SHOW IN OTHER CAR RPM GOES DOWN. I TOOK TO DEALER GOT OIL CHANGE. AND I ASKED WHY THIS HAPPENS. HE TOLD ME TO CHACK ECO SYSTEM. I CHACK ECO SYSTEM IT WAS ON OFF POSTION. I ASK HIM WHEN I BOUGHT CAR I NEVER SHOW RPM GO UP WHEN I HATE BREAK. THERE NO ENGINE SING COMESUP ON DASHBOARD EITHER. THIS REALLY SAFETY CONCERN FOR MY FAMILY. RPM SHOULD NOT GO UP WHEN U HATE BREAKS. IT'S SHOULD BRING RPM DOWN. RPM SHOULD GO UP WHEN U HATE GAS PADEL. I GET THIS. BUT WHEN I GO TO ANY SPEED. AND TRIED TO APPLIED BREAK IT SHOULD DROP RPM SHOULD NOT GO UP.

UNINTENDED ACCELERATION, HAD TO SLAM ON BRAKES AND PUT CAR INTO NEUTRAL IN ORDER TO PREVENT SHOOTING INTO A INTERSECTION OF ONCOMING TRAFFIC. THE CAR IMMEDIATELY THREW A NUMBER OF CODES, AND A ENGINE CONTROL SYSTEM CONDITION CODE, CHECK ENGINE CODE.... DEALER TELLS ME WHEN UNLOADED OFF THE TOW-TRUCK THAT THE BRAKE PEDAL WENT TO THE FLOOR, AFTER 6 DAYS OF HAVING THE CAR THE DEALERSHIP SERVICE MANAGER IS TELLING ME NO PROBLEM COULD BE FOUND DUE TO NOT BEING ABLE TO REPRODUCE THE PROBLEM. *TR

2012 HYUNDAI SONATA. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE REVVED VERY HIGH WHEN STARTED. *SMD THE CONSUMER TOOK THE VEHICLE TO THE DEALER, BUT THE PROBLEM COULD NOT BE DUPLICATED. SEVERAL WEEKS LATER, THE ENGINE REVVED TO 4000 RPM. AGAIN, THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM.

WALKED OUT OF STORE I HAD BEEN SHOPPING IN FOR OVER AN HOUR AND CAR WAS IN FLAMES. THE FIRE INVESTIGATOR EXPLAINED IT AS AN ELECTRICAL SHORT THAT STARTED AT THE MAIN ENGINE WIRE HARNESS AND MELTED THE TUBING/WIRING ALL THROUGH THE ENGINE COMPARTMENT DOWN NEAR PASSENGER HEADLIGHT AND THE MELTING WIRES/TUBING/RUBBER DRIPPED AND IGNITED ON A PILE OF LEAVES UNDERNEATH THE CAR IN THE PARKING SPACE. THE RESULTING FIRE AND ELECTRICAL BURN MELTED ALL RUBBER PLASTIC,EXTERNAL BELTS, WIRE HARNESS, FRONT BUMPER, INTAKE MANIFOLD AND ANY PLASTIC RUBBER,FLUID LIDS, EXTERIOR PARTS SURROUNDING OR ATTACHED TO THE ENGINE. *TR

2012 HYUNDAI SONATA GLS. MILEAGE NOT AS ADVERTISED. STICKER SAID 25 CITY AND 35 HIGHWAY. HAVE TRACKED MILEAGE FROM 1000 TO 5000 MILES AND AVERAGES 23 MPG INCLUDING SOME HIGHWAY DRIVING. NEVER DRIVE AGGRESSIVELY. I BOUGHT THIS CAR THINKING I WOULD BE GETTING MILEAGE AS ADVERTISED. TRIED TO CALL HYUNDAI CUSTOMER SERVICE AT 800-633-5151 FOR A CASE NUMBER AND WAS ON HOLD FOR 10 MINUTES BEFORE HANGING UP. ALLEN HYUNDAI DEALER SAYS NOTHING THEY COULD DO AND RECOMMENDED GOING TO ANOTHER DEALER FOR MILEAGE TESTING OR CALL HYUNDAI CUSTOMER SERVICE. *TR