2015 HYUNDAI SANTA FE Engine Problems

No warning lights. Had started making a small noise that morning but nothing of concern, sounded like a rock in my tire. Was driving up hill, started struggling, then lost all power, had no brakes, Parts went flying out from under car. Smoke came out from hood. Had no brakes or power. Cars behind me could have been hit by flying parts, left a trail of parts on road. I had my kids in car and if we would have been going down hill I wouldn’t have been able to stop. Had entire engine replaced. Hole in engine block. Piston and and valve pieces on road

My car shut down while traveling at a normal speed on a freeway and I had to pull over as it slowed down. This was unsafe on a busy highway while I waited 3 hours to be towed. The car dealer service center stated a faulty connecting rod bearing failure caused the problem and requires a new engine to be installed. There were no warning lights or sounds prior to the problem. Regular maintenance was done including an oil change and filter within the 6month recommendation. The dealership said there was no oil and the engine seized.

The engine completely failed while driving on the highway. The check engine light appeared approximately 20 minutes prior to event. Vehicle was serviced regularly, Including at a hyundai dealership in July. Per our independent mechanic the engine seized up. The engine is available upon request.

Per the Theta Engine Recall Settlement, I had the recall work performed on my 2015 Hyundai Sante Fe on August 23, 2021. Roughly in October, the oil light faded on and off on the dashboard. I pulled into the Autozone and purchased 1 Quart of engine oil. I checked the dipstick in the parking lot and added the quart to the proper fill line of the engine dipstick. On 11/11/2021, while driving my vehicle, without any warning, the engine stopped and shut the car off in traffic. The oil light, check engine light, and service light came on then went off. I attempted 5 times to restart the engine before it would run. I took it to a Midas Auto shop where the diagnostic advised the engine failed and was damaged. I had the vehicle towed to Larry H. Miller Hyundai in Peoria, AZ 85382. The diagnostics indicated that the...

On or about October 16th 2021. After leaving a resturant I was unable to restart my car. It just would not turn over. I called a tow truck thinking It was possibly the starter. The vehicle was towed to Kia, where it was purchased. Upon inspection they(mechanics) also thought it was the starter. Being that the car is under an extended warranty, they contacted the appropriate company for the coverage. However the starter was or isn't the problem, they now believe it's the engine. Mind you I have less than 100,000 miles. I was told I would possiblly incounter a cost of 900.00 for them to determine what's wrong with the vehicle? At the time of me submitting this complaint, my car has been in the repair shop for 3 months. Can you imagine my rental expenses? I"ve read through several complaints of people expressing their concerns and complaints for...

Shortly after getting on the freeway the car suddenly decelerated and came to a complete stop. I was able to pull onto the shoulder just in time. The engine died and would not restart. My daughter and I were in a very dangerous situation that could have been tragic. The car was towed to a mechanic that confirmed the engine had seized and a whole new motor is needed.

On September 4, 2021 at approximately 11:30pm, my vehicle suffered a catastrophic engine failure while driving on a busy freeway in Southern California. There was no warning, only an immediate power lost and inability to accelerate, followed by a flashing check engine light and a chiming alert bell. My husband was driving and he was able to make it across 3 busy traffic lanes to the emergency lane. The sudden lost of power and the inability to accelerate created a significant danger on this busy freeway, California State Route 91. I believe we could have caused a significant accident on that freeway if we had not been able to pull over to the emergency lane in time. Since this incident, I learned through my own online research, that my vehicle was included in a class-action lawsuit which was settled on June 10, 2021. I purchased my vehicle used in late...

I do not know to the best of my knowledge but I do know at 80,000 miles my mechanic did a full plus and coil pack change and I’m not due for an oil change for 2000 miles but for some reason my 3rd cylinder is failing and they can’t figure it out so I’m having it taken back to the dealership.

The contact owns a 2015 Hyundai Santa Fe. The contact stated that while driving at various speeds, the vehicle would hesitate and jerk upon the depression of the accelerator pedal. Recently, the contact stated that the vehicle would shut off without warning. The contact stated that the vehicle would immediately restart after failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 100,000.

While driving home from work on a busy highway, the vehicle engine stopped without a warning. No noises no warning lights nothing. I am fortunate that I was in traffic and no one was behind me driving the normal 50 mph speed limit or I would have been severely injured. I was able to pull the car to the side of the road. The car would not turn over when pressing the ignition switch. The car was towed to a local repair shop and they thought it to be the starter, so that was replaced. They got the car to start, but it only ran with a very loud noise coming from the engine for approximately 20 minutes. The car no longer will turn over. It has now been towed again to a local Hyundai dealership and is awaiting a diagnosis. The local repair shop called again today letting us...

The car stalled and reduced speed immediately from 30 mph to about 5 mph or less. it did not accelerate i had to pull over and tow to dealership. Car has a knocking noise also. this is two signs of the engine bearing and/or connecting rod bearing wear in the santa fes. Hyundai refused my claim to replace engine because the dealership could not replicate the problem. the car turned on again and drove fine according to the dealership. I do not feel safe driving the car, THIS IS A SAFETY ISSUE, IT IS NOT SAFE TO DRIVE THE CAR LIKE THIS, THE CAR COULD STALL IN THE HIGHWAY AT 70 MPH AND COULD CAUSE A CRASH HARMING MYSELF AND OTHERS. ACCORDING TO HYUNDAI WEBSITE IF CONTINUING TO DRIVE THE CAR IT COULD ALSO CAUSE A FIRE DUE TO MORE DAMAGE TO THE CONNECTING ROD. HYUNDAI NEEDS TO RECALL ALL...

2014 Hyundai Santa Fe Limited Ultimate 3.3L Vin F 114,441 miles No prior mechanical issues, pulled out on busy highway and pushed the gas pedal to merge into traffic. Upon pushing the gas pedal the car revved high rpms but would only go 5 mph. I was afraid I was going to get rear ended so quickly pulled off the road. Pulled off the road and restarted the car, the check engine light came on and the engine was shuddering and shaking. Put car in drive and there was no power took about 300 feet to get vehicle up to 30mph. Upon driving further had smell of exhaust fumes. Took the vehicle to the Courtesy Hyundai in Tampa and awaited the diagnosis on 5/22. Initial codes P0018, P2A03, and P0088 misfires on cylinders 2,4,6. Dealer said the CVVT Timing chain and tensioners were bad. I asked if I paid the...

Owner of Colonial Hyundai-Genesis 4423 W. Lincoln Hwy. Downingtown, PA 19335 John Ashdale Jo Miller/Service Advisor August 27, 2021 Lester Glenn Auto Group 386 NJ-Route 37 Toms River, NJ 08753 Sean Savage (Service Manager) September 8, 2021 cc: TASHA National Consumer Affairs Hyundai Motor America Case # [XXX] Hyundai Corporate.or headquarter office 10550 Talbert Avenue Fountain Valley CA 92708 Fax: 714-965-5000 Subject: Engine Replacement Simply that I did sent to explain nhtsa email explain all. We are deaf we don’t t have any accommodation like hearing drivers features such as biggest luxury same vehicle we have Sante FE 2015 Nd Kona 2020 free handset on steering wheel and blue link and also mirror on star on due to communication purpose . We are in risk for no accommodation for safety needs. Where is our emergency roadside accommodation none . So free handset for on steerling wheel is purpose what avoid...

On August 12th 2021, I was driving the engine started making a knocking/tapping sound. As I accelerated it sounded like something broke off, bounced around then shot out the bottom of my vehicle. My vehicle then started to smoke and leak oil all over the road. I pulled over and turned the engine off. We found the part that flew out of the engine, it was the connector rod. It had snapped off into two pieces and shot through the oil pan after passing through the engine causing irreparable damage. There were no warning signs, no check engine or oil lights, nothing. This happened out of the blue. Our safety as well as the safety of others were put at risk not only when the part flew out of the car and could have hit another vehicle, but it almost caught fire and it could have caused an accident had...

I was driving on the highway with my 3 children (I am 9 months pregnant) when we heard a loud pop from the engine, the car gave a sudden jolt and then a loud ticking sound started. The car had a hard time accelerating as I tried to pull over to a safe location. I felt my life and my family's life was in danger. The car was taken first to a mechanic where I was informed that they had several cases with the same issue from the same vehicles recently and recommended us tow it immediately to a Hyundai dealership as it was a recall issue and it was not safe to drive. We towed it to a Hyundai dealership and they informed us that it was a rod barring failure. They informed us that there was indeed an open recall for this particular issue however it was on...

My car engine caught fire on 04/18/2021 and totaled my car. I just received a recall notice from Hyundai for this issue via the USPS yesterday 06/29/2021. I had only 60,000 miles and expected to own this car another 3-5 years. I am out a new car payment and this could have burned my condo down as I was 2 blocks away from it driving home and routinely park in my garage.

The contact owns a 2015 Hyundai Santa Fe. The contact stated that while driving at various speeds the vehicle stalled and the two catalytic converters became inoperable. Additionally, the blue link screen failed to load and link the features. There were no warning lights illuminated. The vehicle was taken to the local dealer who diagnosed two catalytic converters that needed to be replaced. The vehicle was not repaired. The manufacturer was notified. The failure mileage was 115,000.

I was getting on the expressway and everything just seemed like it was on safety mode. My car gurgled, it wouldn't switch gears, the engine light kept flashing. I thought it was a transmission issue until I got it to a Firestone. They said the cylinder is missing on 2,4,6. And that there was a timing chain issue. The dealership says it sounds more like coils.... I'm experiencing all the same issues I'm reading about here. No warning, smelling something burning although no fire. The rpm kept going up at I'm giving gas but not the speed. It has 80,000. Why are only the sports models covered when there are so many cases of other models?

ENGINE LIGHT CAME ON, ENGINE STARTED TO MAKE A RATTLING SOUND. THE SOUND GOT WORSE WHEN ACCELERATING ESPECIALLY IF I WAS ATTEMPTING TO GO UP A HILL.I TRIED TO MAKE IT TO A MECHANIC, BUT THE ENGINE DIED ON THE WAY WHILE ATTEMPTING TO MAKE IT UP A BIG HILL AND WOULD NOT RESTART. I HAD IT TOWED TO A SHOP, THEY SAID THERE WAS NO OIL IN THE CAR DESPITE THE FACT THAT WE ALWAYS HAD OUR OIL CHANGED REGULARLY. THERE WAS NO SIGN OF A LEAK. THEY HAD TO PUT THREE QUARTS IN IT JUST FOR ANYTHING TO SHOW ON THE DIPSTICK. THE SHOP THAT I TOOK IT TO DID NOT DO ENGINE REPAIR AND RECOMMENDED THAT I HAD IT TAKEN SOME PLACE TO HAVE THE ENGINE REBUILT. THEIR THEORY WAS IS THAT SOMETHING BLEW AND THAT THE OIL WAS BEING BURNED UP. IT HAPPENED SO FAST. ONE...

MECHANIC SHOP CUSTOMER PRESENTS WITH COMPLAINT OF OIL LEAK AND NO SERPENTINE BELT. IINITIAL DIAGNOSIS. CAMSHAFT SEAL AND SERPENTINE BELT UPON OPENING UP FOUND EXTENSIVE DAMAGE TO TIMING AND HEADS. DAMAGE TO CAMSHAFT, ROCKER ARMS APPEAR TO BE BURNT FROM NO LUBRICANT. APPEARS TO BE BLUNT FORCE TRAUMA THAT CAUSED BROKEN PARTS. UNLESS WE OPEN UP THE ENGINE THERE IS NO WAY TO DETERMINE THE EXTENT OF DAMAGE TO THE INTERNAL ENGINE PARTS. THE RECALLS DEMONSTRATE OVER 129,000 ENGINES RECALLED FOR HYUNDAI AND THIS APPEARS TO BE CAUSED BY ENGINE DEFECTS. PICS CRANKSHAFT SEAL INSIDE ENGINE PIECE OF SERPENTINE BELT INSIDE ENGINE ROCKER ARM BEARING DAMAGE ROCKER ARM SERPENTINE DAMAGE EMAIL MORE PICS

CAR WAS STATIONARY AND WOULD NOT START, TOWED TO DEALER AND DEALER EXPLAINED ENGINE WAS BLOWN. I SEARCHED GOOGLE FOR RECALLS AND MANY HYUNDAI SANTA FE'S BETWEEN 2013-2019 HAD RECALLS, ALTHOUGH THEY WERE SPORTS MODEL AND OURS IS NOT A SPORTS MODEL, WE BELIEVE THAT THERE WOULD BE OTHER SANTA FE NON-SPORTS MODEL WITH SAME ISSUE. HYUNDAI INFORMED US THAT IT WOULD COST $18000 FOR A NEW ENGINE, THEY WOULD COVER HALF THE COST, WE PURCHASED THE CAR FOR AROUND $21000 - THIS IS RIDICULOUS AND TAKING ADVANTAGE OF CONSUMERS. I AM WAITING FOR PAPER WORK FROM HYUNDAI WITH REPORT BUT THERE IS NO WAY I CAN PAY $9000 TO GET A NEW ENGINE. ANY ASSISTANCE ON THIS GAUGING AND POSSIBLE ISSUE THAT OTHERS HAVE ENCOUNTERED WOULD BE APPRECIATED. I DO NOT THINK THEY ARE BEING HONEST. WE ALSO BROUGHT THE CAR IN PRIOR TO 100000 MILE WARRANTY EXPIRED WITH...

OUR VEHICLE HAS NEVER HAD ANY ISSUES, NO CHECK ENGINE LIGHT, NOTHING. WE WERE DRIVING ON THE HIGHWAY AT APPROXIMATELY 60MPH WHEN THERE BEGAN TO HAVE A KNOCKING, RATTLING NOISE FROM THE ENGINE. WE PULLED OVER TO CHECK IT, NO CHECK ENGINE LIGHT OR ANYTHING STILL. DROVE THE VEHICLE TO OUR REPAIR SHOP, AND ON THE WAY THERE, OUR ENGINE BLEW. STILL NO CHECK ENGINE LIGHT CAME ON. OUR VEHICLE ONLY HAD 133,000 MILES ON IT, SO OF COURSE IT'S OUT OF WARRANTY. SUCH A HUGE BURDEN. WE ARE NOW STUCK HAVING TO REPLACE THE ENGINE, WHILE OWING A CRAP TON OF MONEY ON THIS SUV.

WHEN DRIVING ON THE HIGHWAY 65MPH AFTER 15 MIN THERE IS A BURNING RUBBER SMELL, THE OIL IS LOW EVEN THOUGH I CHANGED IT 3 WEEKS AGO, IT IS CONSUMING TWICE AS MUCH GAS AS BEFORE. I CALLED A CERTIFIED HYUNDAI DEALER AND THEY HAVE NO AVAILABILITY, I HAVE A SAFTEY CONCERN BECAUSE ENGINE FIRES CAN HAPPEN. NOT SURE IF THIS IS RELATED TO ABS RECALL

AFTER GETTING GAS, I NOTICED A STRANGE SOUND COMING FROM MY CAR. I DROPPED IT OFF WITH MY MECHANIC WHO RECOGNIZED THIS AS A HYUNDAI GDI ENGINE HAVING DEFECTS. I HAD THE CAR TOWED TO A HYUNDAI DEALERSHIP THAT CONFIRMED THE BEARINGS WERE WORN AND ENGINE ROD WAS ALMOST THROUGH THE ENGINE. HYUNDAI HAS REFUSED TO COVER EXPENSE TO REPAIR.

2015 HYUNDAI SANT FE LIMITED 3.3L AWD, PURCHASED NEW FROM DEALERSHIP, 129,280 MILES. ROUTINE OIL SERVICE WITH MOBIL 1 SYNTHETIC AND WIX FILTERS SINCE PURCHASED. TRAVELING 75MPH ON I-10 (FLORIDA) WITH CRUISE CONTROL ON. NOT TOWING, TRAVELING STRAIGHT. AS THE VEHICLE STARTED UP A SMALL GRADE IN THE ROAD, THE CRUISE CONTROL SURGED (AS NORMAL TO MAINTAIN VEHICLE SPEED) I HEARD A BANG, CHECK ENGINE LIGHT CAME ON, OIL LIGHT CAME ON, ENGINE DIED IMMEDIATELY. I IMMEDIATELY SHIFTED INTO NEUTRAL AND LOOKED OUT THE PASSENGER WINDOW TO MERGE ONTO THE SHOULDER AND NOTICED AN ORANGE GLOW OUTSIDE (IT WAS NIGHT). ONCE STOPPED, OPENED HOOD AND NOTICED SMELL OF OIL, OIL POOLED IN THE UNDERBODY FAIRING. CHECKED OIL DRAIN PLUG AND FILTER, AS I HAD AN OIL CHANGE 700 MILES PRIOR. BOTH WERE STILL PROPERLY INSTALLED. TOWED TO LOCAL MECHANIC, DIAGNOSIS WAS SEIZED ENGINE. INSPECTED ENGINE BLOCK AND NOTICED FIST SIZED...

MY 2015 HYUNDAI SANTA FE HAS BEEN RECALLED DUE TO THE ANTI-LOCK SYSTEM (ABS) MODULES THAT COULD LEAK BRAKE FLUID INTERNALLY AND CAUSE AN ELECTRICA SHORT OVER TIME. THE PISTON SEALS IN THE ABS MODULES'S HYDRAULIC VALVE COULD LEAK BRAKE FLUID INTO THE ELECTRONIC CONTROL UNIT (EUC) . AN ELECTRICAL SHORT IN THE ABS MODULE COULD INCREASE THE RISK OF AN ENGINE COMPARTMENT FIRE. THE SAFETY RECALL LETTER I RECEIVED 12-24-20 STATED TO CALL THE NEAREST HYUNDAI DEALER AS SOON AS POSSIBLE TO SCHEDULE AN APPOINTMENT TO HAVE THIS REPAIRED. I CALLED ON JAN 12, 2021 TO MY DEALERSHIP AND WAS TOLD THE PARTS TO FIX THE RECALL WERE NOT IN YET AND THEY COULD NOT TELL ME WHEN THEY WOULD BE AVAILABLE. I FIND THIS TO BE VERY CONCERNING THAT I MAY HAVE A CAR THAT ANYTIME COULD CATCH ON FIRE AND HYUNDAI CANNOT FIX IT.

OIL CONSUMPTION WITHIN 200 MILES BLIND SPOT DETECTION DOESN'T WORK

I HAVE ALREADY REPLACED THE MAP SENSOR AND THE BATTERY LAST YEAR. CAR WAS SHUTTING OFF WHILE DRIVING WITH NO WARNING. CHECK ENGINE LIGHT WOULD STAY ON. RECENTLY IN LAST COUPLE MONTHS NOTICED ISSUES WITH THE BRAKES. WHEN APPLYING PRESSURE TO BRAKES WHILE ON FREEWAY THE STEERING WOULD SHAKE AND FEEL LIKE I HAD NO CONTROL. JUST RECEIVED NOTICE OF A BRAKE RECALL BUT THERE IS STILL NO REMEDY. HOW LONG DO I WAIT FOR THEM TO COME UP WITH A REMEDY?

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING 40 MPH, SHE HAD HEARD AN ABNORMAL KNOCKING SOUND COMING FROM THE ENGINE. AS THE CONTACT ATTEMPTED TO PULL OVER, THE VEHICLE BEGAN TO LOSE POWER WITH SEVERAL WARNING LIGHTS ILLUMINATED. THE CONTACT WAS PULLED OVER TO SHOULDER AND BLACK SMOKE STARTED COMING FROM THE ENGINE. DUE TO THE FAILURE, THE CONTACT HAD THE VEHICLE TOWED TO POHANKA HYUNDAI OF FREDERICKSBURG (5200 JEFFERSON DAVIS HWY A, FREDERICKSBURG, VA 22408). THE NEXT DAY, THE CONTACT WAS INFORMED THAT A CONNECTING ROD BECAME DEFECTIVE AND LED TO COMPLETE ENGINE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 108,818.*DT CONSUMER STATED VEHICLE IS CURRENTLY AT POHANKA HYUNDAI OF FREDERICKSBURG.*JB

TL* THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE STARTED TO SMOKE FROM THE EXHAUST PIPE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE ENGINE WAS BURNING OIL AND NEEDED TO BE CHANGED. THE OIL WAS CHANGED IN HOPES IT WOULD REPAIR THE FAILURE. THE VEHICLE WAS THEN TOWED TO HERB CONNOLLY HYUNDAI, 520 WORCESTER RD, FRAMINGHAM, MA 01702, AND WAS DIAGNOSED THAT THE ENGINE OIL LEVEL WAS PERFECT ON ARRIVAL AND WAS NOT REPLICATING THE FAILURE OF THE SMOKE. THE FAILURE RECURRED. THE VEHICLE WAS THEN TOWED TO MIRAK HYUNDAI, 1165 MASSACHUSETTS AVE, ARLINGTON, MA 02476, WHERE IT WAS DIAGNOSED THAT TOO MUCH OIL WAS ADDED. THE DEALER INFORMED THE CONTACT WAS TO PICK UP THE VEHICLE. THE DEALER INFORMED THE CONTACT THAT THERE WAS NO REMEDY AVAILABLE FOR THE OPEN RECALL OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC). THE CONTACT STATED THAT...

GOOD MORNING, I'M REACHING HERE BECAUSE HYUNDAI HAD BEEN NEGLECTING HELPING ME WITH A RECALL THE VEHICLE HAS. THE VEHICLE IS IN THE DOMINICAN REPUBLIC. THE VEHICLE IS AT THE MAGNA HYUNDAI, OFFICIAL DEALER FROM HYUNDAI IN THE DOMINICAN REPUBLIC. I'M ATTACHING THE LAST EMAIL CORPORATE HYUNDAI USA SENT ME. ALL I'M ASKING IS TO FIX THE ENGINE FAILURE BECAUSE OF THE RECALL. THE DEALER IN THE DOMINICAN US WILLING TO COOPERATE IF HYUNDAI USA GIVES THEM THE GREEN LIGHT. THE VEHICLE WAS BUILT HERE IN THE USA. THE VEHICLE WAS JUST USED FOR ABOUT 1K MILES. WE BOUGHT IT IN MARCH 2020.

THERE IS ONE RECALL OUT ON MY 2015 HYUNDAI SANTA FE SPORT HAVING TO DO WITH RISK OF ENGINE COMPARTMENT FIRE. THE ABS SYSTEM CAN LEAK ONTO AN ELECTRICAL MOTOR AND CAUSE AN ENGINE COMPARTMENT FIRE. I HAVE NEVER RECEIVED AN OFFICIAL WORD ON THIS RECALL - ONLY WORD OF MONTH/ RADIO. THERE IS NO REMEDY YET UNTIL END OF OCTOBER 2020.

ENGINE SEIZED ON 2015 HYUNDAI SANTA FE. NO WARNING AT ALL. TOWED TO LOCAL MECHANIC SHOP. DID NOT TAKE TO HYUNDAI DEALERSHIP. MECHANIC FOUND NO OIL IN THE DIP STICK. SYNTHETIC OIL CHANGE DONE A LITTLE OVER A MONTH AGO. VEHICLE JUST WENT OVER 100K IN MILEAGE. I'VE KEPT UP WITH THE MAINTENANCE SCHEDULES. HAS TO BE SOMETHING WITH THESE HYUNDAI ENGINE.

FUEL CONSUMED MORE , LIGHTENING IN BACK NOT CLEAR , ENGINE SOUND ,

ENGINE SEIZED-NEEDED COMPLETE REPLACEMENT; $3,344 PAID TO WAIKEM HYUNDAI CANTON, OH- ENGINE LIGHT CAME WHILE DRIVING AND CAR STALLED. NEVER STARTED AGAIN, TOWED TO WAIKEM HYUNDAI, DENIED WARRANTY COVERAGE STATING NO PROOF OF ADEQUATE OIL CHANGES, EVEN THOUGH MANY PUBLISHED REPORTS OF HYUNDAI SANTA FE ENGINE FAILURES. I BELIEVE ENGINE RECALLS EXIST FOR 2014, ONE YEAR AWAY FROM OUR 2015- BELIEVE ISSUES OBVIOUSLY WEREN'T FIXED AND HYUNDAI NOT BEING ACCOUNTABLE FOR THEIR MISTAKES. OWNED MANY, MANY VEHICLES OVER MANY YEARS...NONE EVER HAD COMPLETE ENGINE FAILURE LIKE THIS HYUNDAI. REPAIR RECEIPT AVAILABLE UPON REQUEST.

WAS DRIVING TO WORK ON AN INTERSTATE HIGHWAY, GOING APPROXIMATELY 65-75MPH FOR ABOUT 10 MINUTES. AS I PUSHED THE ACCELERATOR TO PREPARE FOR A LANE CHANGE, I REALIZED THAT I COULD PUT THE ACCELERATOR ALL THE WAY TO THE FLOOR WITH NO RESPONSE. I IMMEDIATELY NOTICED THAT MY "CHECK ENGINE" LIGHT APPEARED. I TRIED AGAIN UNSUCCESSFULLY, THEN TRIED THE BREAKS. THE BREAKS WERE VERY STIFF, AS IF THEIR POWER TO THE ENGINE WAS CUT OFF. I TRIED TO TURN OFF OF THE HIGHWAY ONTO THE CURB, AND I NOTICED THAT MY STEERING WHEEL WAS ALSO VERY STIFF. ALTHOUGH I COULD TURN, IT TOOK MUCH MORE STRENGTH THAN USUAL. I LET THE SPEED DECLINE NATURALLY UNTIL IT STOPPED ENTIRELY ON THE SIDE OF THE HIGHWAY. WHILE STOPPED, I TRIED REPEATEDLY TO USE THE BREAKS, GAS, AND TEST THE STEERING, BUT THE SAME ISSUES WERE THERE WITH ZERO SUCCESS. ONE THING I...

I WAS DRIVING ON HIGHWAY WHEN SUDDENLY, THE ENGINE TURNED OFF WITHOUT ANY WARNING (0 RPM ON DASH). I PULLED THE CAR OVER TO THE RIGHT SHOULDER OF HIGHWAY AND ATTEMPTED TO RESTART THE CAR MULTIPLE TIMES, BUT THE ENGINE/CAR WOULD NOT RESTART. I REMEMBER SMELLING A BURNING SMELL THE NIGHT BEFORE THIS INCIDENT. ALSO, SMELLED THE SAME BURNING SMELL FROM THE ENGINE COMPARTMENT ON THE DAY OF THE INCIDENT AFTER THE ENGINE UNEXPECTEDLY TURNED OFF. THERE WAS NO ENGINE LIGHT ON OR ANYTHING PRIOR TO THIS EVENT. THIS COULD HAVE BEEN A VERY DANGEROUS SITUATION HYUNDAI!

MY TRANSMISSION WENT OUT AT 114,000 MILES THEY FOUND METAL SHAVINGS IN IT, WE HAD IT REPLACED. NOW AT 134,000 MILES THE ENGINE WENT OUT, THEY FOUND METAL SHAVINGS IN THAT ALSO. IT HAS BEEN SITTING AT HYUNDAI SINCE DECEMBER 2019 IT IS NOW FEBRUARY 2020 AND STILL WITHOUT A CAR OR A RENTAL. SERVICE DEPARTMENT BUILT AND NEW ENGINE AFTER THEY TESTED THE ENGINE IT STARTED MAKING NOISES AGAIN AND APPARENTLY HYUNDAI SENT THEM SOME PART THAT DIDN'T FIT NOW THEY HAVE TO FIX IT AGAIN... HYUNDAI CORPORATE HAS ONLY OFFERED TO PAY HALF OF THE REPAIRS EVEN THOUGH IT WAS AN ENGINE MALFUNCTION. BOTH OF THESE ISSUES HAPPEN WHILE DRIVING. THE ENGINE SHUT DOWN WHILE ON THE FREEWAY WHEN IT BROKE.

TL* THE CONTACT OWNED A 2015 HYUNDAI SANTA FE. WHILE DRIVING 5-10 MPH, SMOKE AND FLAMES APPEARED FROM THE FRONT OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND CONTACTED THE FIRE DEPARTMENT. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A POLICE TOW YARD. THE CONTACT WAS UNAWARE IF THE VEHICLE WAS INSPECTED. DON MOORE HYUNDAI (3200 VILLA POINT, OWENSBORO, KY 42303, (270) 685-5555) AND THE MANUFACTURER WERE INFORMED OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.

DRIVING ON THE INTERSTATE THE ENGINE STARTED MAKING A NOISE AND THE CHECK ENGINE LIGHT ILLUMINATED. AT THAT POINT DRIVING IT STRAIGHT HOME THE ENGINE STALLED SEVERAL TIMES, ONCE WHILE MAKING A TURN THROUGH A BUSY INTERSECTION, I WAS LEFT WITH NO POWER. THIS IS SIMILAR TO THE ISSUES I READ INVOLVING SANTA FE ENGINE RECALLS FOR THE 2013, 2014, AND 2017 MODEL YEARS.

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 75 MPH, THE VEHICLE SUDDENLY DECELERATED TO APPROXIMATELY 40 MPH. THE VEHICLE WAS TAKEN TO WILLIAMSBURG HYUNDAI (7277 RICHMOND RD, WILLIAMSBURG, VA) WHERE IT WAS DIAGNOSED THAT THE ENGINE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT INDICATED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER A MANUFACTURER CAMPAIGN FOR THE SAME FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 56,000.

THE ENGINE IS THE 2.0 TURBO AND SINCE ABOUT 10,000 MILES IT RUNS SLIGHTLY ROUGH AT IDLE IN GEAR, IT EITHER DOES NOT KICK DOWN SMOOTHLY TO ACCELERATE, OR IT SUDDENLY TAKES OFF UNEXPECTEDLY RAPID. THE ACCELERATION IS SPORADIC, UNEVEN AT ONE END, OR JERKING INTO THE TURBO FUNCTION AT THE OTHER END.

WHILE DRIVING ON CITY STREET AT ABOUT 40 MPH, A KNOCKING SOUND WAS HEARD FROM THE ENGINE. AFTER DRIVING ANOTHER 5 MILES THE NOISE BECAME LOADER AND THE ENGINE CHECK LIGHT CAME ON. TOOK THE VEHICLE TO THE DEALERSHIP (HYUNDAI OF COOL SPRINGS, FRANKLIN, TN) FOR SERVICE. AFTER SEVERAL DAYS WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THEY FOUND SLUDGE AND METAL SHAVINGS INSIDE THE ENGINE AND OIL PAN. HYUNDAI WAS NOTIFIED OF THE PROBLEM AND DENIED THE CLAIM. THE DEALERSHIP CHANGED THE OIL AND TOLD ME I WOULD HAVE TO PAY FOR A NEW ENGINE. VEHICLE HAS APPROXIMATELY 68,000 MILES. STILL UNDER WARRANTY. CAN NO LONGER DRIVE THE CAR.

RANDOMLY, FROM A STOP, WHEN ACCELERATING THE ENGINE TEMPORARY STALLS OR HESITATES FOR 1-2 SECONDS. THIS VERY DANGEROUS AND SCARY. IT HAS BEEN HAPPENING SINCE THE CAR WAS NEW AND THE DEALER REFUSES TO RECOGNIZE THE PROBLEM. IT HAS PROBABLY HAPPENED 50 TIMES OR MORE. ONLINE SEARCHES SHOW MANY COMPLAINTS OF THE SAME ISSUE WITH ALL MODELS WITH THE 2.X TURBO ENGINE.

DRIVING ON MAJOR HWY, CAR LOST POWER AND SO I LOOKED FOR A PLACE TO PULL OVER, WHEN I GOT TO SIDE OF RD THE CAR STALLED OUT AND DIED COMPLETELY. WOULDN'T RESTART AGAIN. ENGINE LIGHT CAME ON AND BATTERY LIGHT AND OTHER LIGHTS. I TRIED TO CRANK WITH NO LUCK. CALLED FOR HELP. GOT TOWED TO NEAREST SHOP. IT WAS MOTOR THAT FAILED. NO SIGN EXCEPT LOST POWER AND DIED. SAME CONDITION AS MOTORS THAT WERE RECALLED AND MY MOTOR IS A 2014 AND I HAVE EXTRA WARRANTY AND THEY TURNED ME DOWN. I NEED HELP PLEASE.....HELPPPPPPPPP

TWICE ENGINE QUIT WHILE OPERATING WITH NO WARNING. ONCE AT 60MPH AND THE OTHER AT SLOW SPEED WHILE TURNING AROUND. RESTARTED BY PLACING IN NEUTRAL AND PUSH START BUTTON WHILE STILL MOVING. 21000+ MILES. DEALER OFFERS NO EXPLANATION. THERE ARE NUMEROUS REPORTS OF SIMILAR INCIDENTS WITH HYUNDAI VEHICLES. NO FIXES I HAVE BEEN ABLE TO FIND AND LITTLE SATISFACTION FROM THE MFR.

HIT ACCELERATOR AND WON'T SHIFT INTO GEAR, LOUD REVS AND THEN HEAR A BANG AND THE CAR JUMPS AS IT FINALLY SHIFTS INTO GEAR. THIS HAS HAPPENED RANDOMLY THROUGHOUT THE LIFE OF MY CAR AT RANDOM, I DIDN'T THINK MUCH OF IT, THEN LAST WEEK, I START TO LOSE POWER, AND SAME THING, IT HAPPENS MULTIPLE TIMES ON THE SAME DRIVE. NEVER ONCE WHEN THIS HAPPENS DID I GET A CHECK ENGINE LIGHT. THEN IT GOT SCARY AS WHILE ON THE FREEWAY THE VEHICLE WOULD DOWNSHIFT WHEN TRAVELING AT A HIGH RATE OF SPEED ON ITS OWN WHILE IN DRIVE. STILL NO CHECK ENGINE LIGHT CAR FINALLY GETS BACK TO CORRECT GEAR RATIO FOR THE SPEED. FINALLY THE CHECK ENGINE LIGHT COMES ON. NOW THE CAR WON'T SHIFT OUT OF 4TH GEAR, NO 1ST OR SECOND GEAR.

WHILE DRIVING THE VEHICLE ON THE HIGHWAY, I NOTICED THE CHECK ENGINE LIGHT CAME ON. I CHECKED THE OIL LEVEL AND OTHER FLUIDS. THE OIL WAS VERY LOW. I PUT IN A FEW QUARTS OF OIL IMMEDIATELY AND TOOK THE VEHICLE TO GET AN OIL CHANGE PROFESSIONALLY SHORTLY AFTER. I NOTICED THE ENGINE WITH HESITATE AND IDLING BECAME ROUGH. AT THE SAME TIME, THE FUEL MILES PER GALLON DECREASED DRASTICALLY.

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. WHILE DRIVING 75 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE AND OTHER WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE CONTACT POWERED OFF THE VEHICLE, RESTARTED IT, AND WAS ABLE TO DRIVE. THE VEHICLE WAS TAKEN TO LEN STOLER HYUNDAI (1906, 11275 REISTERSTOWN RD, OWINGS MILLS, MD 21117, (443) 249-8884) WHERE IT WAS DIAGNOSED THAT METAL WAS FOUND THROUGHOUT THE ENGINE AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND CASE NUMBER: 11185417 WAS OPENED. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

MY HYUNDAI IS 3 YEARS OLD WITH 70,000 MILES ON IT , I'VE MAINTAINED THE VEHICLE ACCORDING TO MANUFACTURERERS SUGGESTIONS . THE CAR HAD NO CHECK ENGINE LIGHT ON OR WARNINGS THAT SOMETHING WAS WRONG AND THE NEXT DAY I START MY CAR AND IT'S MAKING A VERY LOUD TICKING NOISE WHILE DRIVING AND SLOWLY LOSING POWER UNTIL IT EVENTUALLY STALLED OUT . I WAS ABLE TO GET THE VEHICLE TO MY MECHANIC TO HAVE IT SCANNED , THE SCAN SHOWED THE EXHAUST SOLENOID HAS FAILED AND THE TIMING WAS ADVANCED , AGAIN THIS HAPPENED FROM THE CAR RUNNING PERFECTLY FINE ONE DAY TO THE ENGINE SHUTTING DOWN THE NEXT . SO THE MECHANIC TOOK THE SOLENOIDS OUT AND FOUND METAL SHAVINGS COVERING THEM . I'VE SINCE READ NUMEROUS COMPLAINTS ABOUT THIE TYPE OF ENGINE IN THIS VEHICLE THE THETA 11 GDI 2.0T , WHICH HAS BEEEN RECALLED 2011-2014 MODELS...