2020 HYUNDAI PALISADE Engine Problems

I purchased a used 2020 Hyundai Palisade in June 2024. The vehicle has a defective engine caused by excessive oil consumption. I took the vehicle to the dealer service department and they confirmed the issue. A claim was made to Hynduai to replace the engine and it was denied. Not replacing the engine will further degrade the engine until it fails completely. Hyundai has been uncooperative is wanting to resolve the issue, even though is a commonly reported issue.

There is an oil leak coming from the oil filter housing, where it mates up to the block, causing the vehicle to lose oil

The vehicle, a 2020 Hyundai Palisade SEL, was located in a closed garage, unoccupied. Within 10 minutes of parking the car in the garage, it caught on fire, possibly originating on the front, driver's side. Due to this incident occurring inside a garage, there was damage to our home and a high risk of safety (including loss of life) to the home and its occupants. At this time, we are waiting for the insurance company to investigate the origin of the fire as there were no warning lights or any indication of risk. This fire happened very suddenly and unexpectedly and it is our sincere hope that a thorough investigation will prevent this from happening to other families.

My 2020 Palisade engine burns oil at an alarming rate. I have to add about 4 quarts of oil every couple of thousand miles. This is a known issue with Hyundai engines. The problem started about a year ago. At that time my car had 98,000 miles on it. I reported the problem to Hyundai. They said they were too busy to see me at that time and the earliest they could look at my car was over a month out. By the time they got me in and looked at my car they said I was over the 100k mile warranty and there was nothing they could do. This is a known issue with thousands of Hyundai motors. Hyundai has failed to recall their faulty engines and do right by their customers.

What component or system failed or malfunctioned, and is it available for inspection upon request? -The engine failed. How was your safety or the safety of others put at risk? -The vehicle stalled in the middle of a two lane road at the top of a hill, as well as in the middle of the highway. Has the problem been reproduced or confirmed by a dealer or independent service center? -Yes, the vehicle is currently waiting for a replacement engine because the original engine failed due to oil consumption issues. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? -No, the low oil light was never on. A warning code or light did not appear until the vehicle was stalled.

oil filter housing cracking and leaking How was your safety or the safety of others put at risk? if engine fails due to oil leak (no oil) oil on the road is never a good thing, Has the problem been reproduced or confirmed by a dealer or independent service center? yes it has been confirmed. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? no not at this time . Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? after oil service at dealer noticed small spots of oil, assumed it was residual from service, but spots are now the size of a paper plate after driving, for around 50 miles .

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine failed, as it was deemed "shot" by the dealership. Yes, the engine and vehicle are available for inspection upon request. 2. How was your safety or the safety of others put at risk? The vehicle began to stall while driving, which could have caused an accident, especially if the vehicle stalled in traffic or at high speeds. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the problem was confirmed by the dealership, which diagnosed the engine as needing replacement due to a lack of oil. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The vehicle has been inspected by the dealership. 5. Were there any warning lamps, messages, or other symptoms of the problem prior to...

The contact owns a 2020 Hyundai Palisade. The contact stated that while the vehicle was at a complete stop at a stop light, the Auto Start feature failed to function as intended. The contact stated that the engine shut off. The contact stated that the failure was a persistent failure. The contact stated that the failure occurred five times within a five-minute drive. In addition, the vehicle was previously taken to the dealer several times due to the failure. The failure could not be duplicated. The manufacturer was made aware of the failure and several cases were filed. The failure mileage was approximately 25,000.

The engine started running rough and when I checked the oil it was 4 quarts low. Despite the oil being more than half empty, the oil light on the dash never came on. This is dangerous and will end up hurting future owners or those who don’t get enough mileage on the vehicle within their warranty timeframe.

My 2020 Palisade has about 98,000 miles. A few months ago I brought it to the dealership because I thought my transmission was faulty. It turns out my car had burned up all but 1 qt of oil and it was affecting my engine, eventhough I changed my oil at 7,000 miles per the Hyundai manual (7500-10,000). I recently took the car in for an oil consumption test. I did an oil change, at my expense, and they set up the car for the test. I came back in 1000 miles and since my car had only burned up 3/4 of oil and not a full qt, Hyundai refused to do anything. I have driven 467 miles since that test and my dipstick shows an oil line 3/4 of the way to the bottom line already. I have a 100,000 powertrain warranty and a 120,000 bumper to bumper extended warranty...

My 2020 Hyundai Palisade has been a lemon from the beginning with numerous issues including a whistling sound when driving, a recalled trailer hitch known to cause fires, paint issues, rim paint issues etc… But the worst offender is the oil consumption issues. A few months ago I thought something was wrong with my transmission so I took my car to the dealership. I also had an oil change scheduled-which I get on time every time. It turns out that, in 7,000 miles (Hyundai recommends 7,500-10,000 miles between oil changes in their manual) I was down 5 quarts of oil-there were no leaks, my engine was using up the oil. My car only holds 6.9 quarts so I was almost out of oil which was causing driving issues including lack of power when starting up at lights, surging and bucking when stopping etc. The dealer refilled my car and told...

The contact owns a 2020 Hyundai Palisade. The contact stated while driving at an undisclosed speed, the vehicle stalled. The contact also noticed smoke coming from the engine. There was no warning light illuminated. Additionally, the rear passenger’s seat belts failed to function properly and would inadvertently release while driving the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that the engine, and the seat belt assemblies for all the rear passenger’s seats needed to be replaced. The vehicle was not repaired. The dealer was contacted. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 95,000.

I had just pulled into a (handicapped) parking space at my bank in Marana Az. as I prepared to stop with the brake still depressed, the car suddenly surged, with the tach going to 5000rpm. The vehicle jumped the sidewalk (with rear wheels making drag marks on the sidewalk. Vehicle shot up the slight rise , hit and demolished a concrete bench and some plants and was heading toward the main entrance when I shut the engine off with the ignition key. The car stopped less than 10 feet from the bank entrance. the car came close to going through the entrance shattering the glass doors and possibly injuring bank customers and employees. There was no warning, but this car has had 3 or 4 sudden engine surges before - about one every 1 1/2 years. Hyundai service has checked and denied any problems. On line queries indicate the surging...

The car is approximately 3.5 years old (2020) and the engine failed. The symptoms of the engine failure are the exact failures of all of the other Hyundai engines that failed over the last 10 years which were recalled. There needs to be further investigation in all of the engines Hyundai is putting out to protect people. Hyundai offered to pay 50% of this because they know they are wrong, but they need to pay 100% of customer issues.

The contact owns a 2020 Hyundai Palisade. The contact stated while driving at various speeds, the vehicle hesitated while attempting to accelerate. The contact stated that on another occasion while driving 60 MPH, the vehicle lost motive power and stalled. There was no warning light illuminated. The contact was able to restart the vehicle. The vehicle was taken to the dealer to be diagnosed and the contact was informed that there was no oil in the engine. The contact stated that the vehicle received an oil change however, the failure recurred. The vehicle was returned to the dealer twice and was diagnosed with a failure of cylinder #4. The contact stated that cylinder #4 was replaced; however, the failure recurred. Due to the failure persistent failure, the dealer was diagnosed, and it was determined that cylinder #2 had failed, and that the engine needed to be replaced. The vehicle was...

On 4 occasions the vehicle completely turned off while I was driving down the avenue. It turned on all the lights on the front panel before turning off completely.

Current mileage is 51,130. When slowing down to come to a stop;the engine shakes, vehicle stalls out, cuts off, and goes into park. No service or warnings lights where on the dash. I am able to re-start the engine after it stalls out. This has happened several times and now the engine is shaking and trying to idle down under normal driving conditions. There is also a tapping sound coming from the engine. Thankfully there was not much traffic the times the engine stalled, but this could have been a dangerous situation. If this would have happened during high traffic, a crash would have been inevitable. I went to my Hyundai dealership and service rep Chance (unsure of his last name), took vehicle for a test drive and he experienced above mentioned issues. The dealership was unable to give me a service appointment due to being very busy. No available...

The engine of my 2020 Palisade has burned about 1.5 quarts of engine oil every 1k miles. I found this when checked the dipstick after 3k miles and barely see any oil on the dipstick. Even with the oil level far below the LOW level, the car doesn't have any light to warn me about it is being low on oil. This problem can lead me to blown the engine by not having any oil, also stranded on the highway.

My 2020 Hyundai Palisade was serviced 10/23/23 with Daytona Hyundai (mileage around 31000). It has been serviced regularly--sometimes before schedule since it is hard to get the car into the dealership for servicing because they are always booked out months in advance. Today, 2/23/23, my car (35, 873 miles) is at the same dealer service center to fix a rattle in the dashboard which started as I drove off the lot on 10/23/23 after the dealership said everything was fixed and they have informed me that there is no oil in the car. There were no warning lights, no indication that there was no oil in the car. The dealership is doing an oil change.

Engine oil filter housing started leaking copious amounts of oil in cold weather. Dealership advised that it is a known issue but not covered by warranty. I had to source the part myself and pay an independent mechanic to replace the housing. Creates both an environmental hazard as well as risk of engine oil starvation.

Transmission issues and will probably need to have it replaced.

I am bringing my Palisade in to the Hyundai dealership after waiting 1.5 months for an appointment. During that time my 2020, with less than 24,000 miles on it, has consumed at least a quart of oil every 300 miles and continues to spike rev at 2500 rpms. There has been NO warning lights, low oil lights, NOTHING. My OTHER Hyundai (2017 Santa Fe Sport) which was purchased just 3 weeks after the Palisade...With NO warning, lost complete power while driving 75mph on a Hwy 80 miles from home. When towed to the Auto shop (with a $675 price to tow) we were told it was completely out of oil! No lights, no warning. They found a gasket leaking and replaced it and sent it home the next day after filling the oil. Two days later, driving down the Hwy, we feel a quick metal screech, engine starts knocking and...

[XXX] - I was turning left from a stop and my steering wheel abruptly stopped (wouldn't turn) and made a very loud noise. It released when I tried again. Didn't happen again for a couple weeks. This went on and on (seldom reoccurring). then it happened like 3 times in two days and I got concerned. November 2023 - I called the tire place because I had just had tire replaced right before this started. The mechanic was able to recreate it and told me it was an electric rack and pinion malfunction and part is about $1,600 and labor about $450. I told him I would call Hyundai since it should be under warranty. Hyundai told me to bring it in. I brought it in on [XXX]. They said they couldn't recreate it and had me pick it up. [XXX] - I drove to San Diego for work. Noise...

The engine is burning oil. I've had it inspected by Huyndai however they stated it would be 18+ months before getting it fixed. At this point it's burning 1qt oil every 3 weeks. I work from home, and drive my daughter to school a few times a week so not warranting that much oil in 3 weeks. I get oil changes every 4000 miles as recommended. My car will all of the sudden sputter, check engine light will go on, it will lurch forward which is a safety hazard to not only those in the car but those behind me in traffic. It has been inspected and reproduced by an independent service and a Hyundai dealer. Looking at the carfax, this has been an ongoing issue with this vehicle judging by the revious owners vehicle maintenance records.

Problems started about 1.5yrs ago - car would make horrible noises from the engine, knocking sounds, lost some electric/AV systems. Brought to local dealership, had a bunch of codes; dealer said issue with t-stat sensor. No issues for another 3k miles, knocking sounds again. Mentioned to service advisor during oil change, couldn't recreate. Same problem every 3k miles, dealer/service repeatedly couldn't recreate issue/sound. Check engine light comes on, dealer said issue with EZ-Pass interfering with computer, need to pay $150 to reset computer and move EZ-Pass. Continue to take car for oil changes at dealerhip every 3k miles. In May 2023, dealer/service used 0w20 oil instead of 5w30 - apparently dealer/service noticed no oil in car, but didn't tell us, thought different oil weight would help "stretch" oil to next oil change interval (it didn't - burned through all 6.9qts before the end of 3k miles). End of Sept 2023,...

My wife and I Were driving then all of sudden the engine light would come on and the car would hesitate and go then at anoqtpher time it stopped on my wife we travel often back and forth to the veterans hospital for treatment and we don’t feel safe any longer. We had it at the dealership about three times. Faulkner Hyundia. We thank you for your help

The car suddenly stalls during driving. It has been root-caused to engine oil consumption. I used my car for only 3K miles after my previous service (normal recommended oil change is 7.5K miles) before I saw the same stall issues and all kind of weird check lights going off. I had to top off my car with an additional 3.5 quarts of oil to be able to drive again.

In June we noticed the car would stutter at certain RPMs or certain speeds. We took the car in and it was diagnosed to "need oil". The car continued to have this issue upon return and we took the car back to the shop where it was diagnosed to be an engine issue. The danger in the car engine could have caused much more serious damage had we not diagnosed it properly with the dealership. After 44 days the car was returned with a remanufactured engine.

The engine totally stop in the middle of the road stoping an entire lane. Vehicle just popped a engine light I immediately called Hyundai and said i feel the vehicle has a problem its not going to last 1 min later it immediately stop and was towed to hyundai the following day hyundai notified me the vehicle did not have any oil and has oil consumption problems. It still had more than 2000 miles left for maintenance so its impossible for a new vehicle to have this type of issue so early. Im still under the 5 year warranty. Since then the vehicle is not safe to travel more than a certain amount of miles because the same issue can happen and put in danger the life of my entire family. Hyundai stated i have to take the vehicle every 1000 miles to measure the oil. The vehicle feels like...

Car began giving us an issue while driving several months ago : driving up hills at a speed of 20 mph or less, the vehicle begins to jerk and pulse. There is also a knocking sound coming from the rear of the vehicle. Much of this also happens in parking lots at speeds of less than 10 mph. Driving at a speeds of greater than 60 mph / highway the car will pulse as well. This does not change with driving modes: ECO, Comfort, Sport or SMART mode. The engine is the same throughout modes- jerking and hesitating. When driving from highway to get gas or stop the car will have trouble when pressing on the gas pedal after being stopped then trying to enter the highway. The car is slow to respond to the gas pedal and will not accelerate matching your foot on the pedal. After some time...

Engine is burning oil in excess. Vehicle Stalled out, 'chugging' and poor performance as well as a knocking sound from the engine compartment. Upon checking under the hood, vehicle was found to be over 2qts low on oil. My safety and those of other are put at risk from the stalling of the vehicle in daily traffic. Damage to the engine could result in vehicle failure while driving causing accident putting self and those in the vehicle or around the vehicle in harms way. Took in to an auto mechanic, advised this was a problem they have seen/been made aware of in similar vehicles of the same Make. Now having to continuously monitor oil levels. Vehicle is currently at approx. 72500k miles., sluggish driving started at around 70k miles, thought it was bad fuel. Vehicle died multiple times at around 72400 miles, heavy chugging/vibration of entire vehicle and noise from...

I am having 2 issues with my 2020 Palisade. First off, for the last 7 months I can feel some sort of slip in my transmission when I am between 40-60 mph. I took in in back in November to the dealership and they claim they didn’t find any issues that I could reschedule and drive it with one of the techs at another appointment. Fast forward, took it to a different dealership this week for a second opinion because it’s still happening and more frequent. They told me they felt it happen once. My car is still under warranty. They suggest a transmission flush, but it wasn’t covered under warranty. My second problem is I’ve been caught in heavy downpour storms. Two times my car check engine light comes on and my car goes in limp mode. Basically puts me stranded because the car won’t run. After a day...

The engine seems to be consuming oil and diminishing the oil levels before the required oil change period. This causes the vehicle to make loud noises, cause erratic error codes/issues, including stall while driving. This seems to be a common problem across Hyundai Palisades from 2020 model year when I looked up in Hyundai Palisade and Kia Telluride forums. I'm surprised there is no recall despite such a wide spread issue with this model.

Excessive oil consumption. Consuming 2 qts of oil every 1000 miles. Has been to the dealership 8 times in the last 15 months. 2 spark plugs from the same cylinder have failed leaving me stranded. My dealership and Hyundai Consumer Affairs continue to give me the run around with oil consumption tests and combustion chamber cleanings rather than admit this is a faulty engine. The first spark plug failed at 25k miles and the second one from the exact same cylinder failed 7k after. Blue smoke comes out of the exhaust frequently on engine start up which I have communicated this several time proving that their fixes aren't preventing the oil from leaking inside the combustion chamber. But they will insist that that I have to continue oil consumption tests, despite having 8 done on the car already. I do not feel safe driving this vehicle knowing that the engine...

I bought this car as a certified pre-owned, picked it up on January 18, 2023. This is our family car and we took it on a 350 mile each way road trip on Jan 27. Upon arrival to our destination, driving around the city I noticed a lot of white smoke coming from the exhaust. I checked the oil and there wasn't oil registering on the dipstick, so I added 5 quarts of oil to the car to get us home on Sunday Jan 29. Upon returning home, I got the car back to the dealer and they had it for a couple days but "couldn't replicate the smoke". The dealer began an oil consumption test based on Hyundai's instructions. Now I have to take the car back in every 1,000 miles to be checked. I picked the car up on Feb 9 and have continued to drive it around...

My wife and myself were on a little road trip and the vehicle lost power while on the freeway. It wouldn't go over 60 mph which was concerning as we were in the middle of freeway traffic. I managed to get to an exit and shut off the vehicle. I restarted it and it seemed to be fine. We continued to where we were going and on the way home, the same thing happened, again at freeway speeds. I was able to exit again, turned the vehicle off then restarted and it was ok. We were almost home and it shut off, while driving which is exciting but not in a good way. It restarted and ran fine. It did throw an engine code this time. It said it was a fuel pressure issue. A few days later we figured we should take it by the dealership, which is two...

The alternator suddenly failed. This caused the batter to rapidly deplete and lose all electrical function of the vehicle. Loss of power steering, breaks, lights, instrument cluster and gauges. basically the vehicle rolled to a stop. Further investigation has shown that this issue is not uncommon on the Palisade. A quick google search revealed dozens of people with the same issue. Since it’s on several year models of the Palisade it points to the alternator. It goes out and the battery cannot support the electronics.

The contact owns a 2020 Hyundai Palisade. The contact stated that while his wife was stopped at a traffic light, the vehicle lost motive power and stalled without warning. After restarting the vehicle, the vehicle experienced rough driving. The contact later discovered that the engine oil level was extremely low. The vehicle was towed to the dealer. The dealer performed an oil consumption test, an engine leak down, engine compression test, and carbon cleaning on the engine; however, the vehicle continued to experience the failure. The manufacturer was notified of the failure. The failure mileage was 13,700.

Dealership says that the car was 5qts of oil. Scarring on piston #6. Check engine light came on and indicated Transmission issue

While driving in heavy rains , check engine light comes up and vehicle starts vibrating. Once the vehicle is stopped and restarted the light & vibration goes away. This happened twice in 2 months ( July & aug 2021) and while driving in Interstate. I did report to the dealer/service manager after the first time and they were not able to pull up any logs/codes from the vehicle computers. The second time, it happened, I took the photo of the same. First time it occured when I had about 17500 miles on the vehicle. Second time it was 19643 miles. Both times it was raining heavily and speed was between 40- 50 miles/hour

About 1 1/2 hours into a 7 hr trip driving on vacation the car started running rough. Upon slowing the engine shut off several times. The car started knocking and the check engine light came on about 30 min from our destination. We took it to the closest Hyundai dealer who informed us the engine needed to be replaced because it had no oil in it. We NEVER had a low oil light or check oil light come on. I had checked the oil life before we left on our trip and knew I had a cushion of several hundred miles before it was due for an oil change. This could have caused all of us in the car since the car shut off and all power was gone.

WHILE DRIVING ON HIGHWAY 290 WEST TO FREDICKSBURG, TEXAS ON APRIL 2,2021, SPEED LIMIT VARIES FROM 50-60 MPH, THE VEHICLE JUST STOPPED, ALL SYSTEMS WERE OUT, MESSAGE ON THE SCREEN SAID "TAKE TO SERVICE, WHEN CONVENIENT". IT WAS VERY SCARY AS THE VEHICLES FROM BEHIND WERE HONKING AND I COULD NOT GET THE CAR TO THE SIDE. IT COULD HAVE BEEN A MAJOR ACCIDENT WITH FATALITIES.

VIBRATION AT SPEEDS OF 64/65MPH AND UP. NOT SURE IF DRIVESHAFT OR TRANSMISSION. HYUNDAI HAS ISSUED A TSB BUT WILL NOT HONOR IT. I HAVE ASKED 2X FOR DEALER SERVICE DEPT. TO EVALUATE THIS PROBLEM. THEY SAID THEY DO NOT HAVE TO HONOR THIS TSB. I HAVE SEEN ON FORUMS OTHERS ARE HAVING SAME PROBLEM WITH CARS MADE IN DECEMBER 2019. IT IS PAINFUL TO DRIVE ON THE HIGHWAY AND I DO NOT KNOW IF IT IS THE DRIVESHAFT, WILL IT BREAK? WILL THE TRANSMISSION FAIL? THIS IS A BRAND NEW CAR PURCHASED NEW AND IT IS UNSAFE TO DRIVE ON THE HIGHWAY AND I CANNOT GET HYUNDAI TO LOOK AT THE PROBLEM AND THEY HAVE SENT EMAILS SAYING TOUGH LUCK. THIS IS ANYTIME YOU ARE DRIVING ON INTERSTATES OR HIGHWAYS WITH SPEED LIMITS OF 70MPH..AT AROUND 64/65 CAR STEERING WHEEL, SEAT, FLOOR VIBRATES UNLESS YOU GO BELOW 63MPH. HAPPENS...

I BOUGHT THE CAR IN JAN 2020, AND FOUND THAT IT WAS LEAKING OIL ON JUNE 2020, AFTER 4500 MILES. THE OIL LEAK LOOKS TO BE SIGNIFICANT AS I HAD FOUND DROPS AND PUDDLES ON MY GARAGE FLOOR. THE OIL LEAK SEEMS TO BE COMING FROM THE TRANSMISSION/ENGINE CONNECTION AREA, OR POSSIBLY THE UPPER OIL PAN. THE CAR IS CURRENTLY STILL IN DEALER SERVICE FOR REPAIR. *TR