2016 FORD FOCUS Engine Problems

UNKNOWN. I believe this vehicle's engine is also impacted by the recall campaign number 18V735000, even though the engine is a 2.0L L4. The same issues that are mentioned in the recall campaign occurred with this vehicle around the 60k milage and 120k milage mark. These issues seems to happen every 60k miles. I did report this same issue with this system with this vehicle when this happened when the milage hit around 60k. The engine check light did show up each time this happened and the vehicle would stall immediately, even while driving at interstate speeds of around 70mph.

The coolant/antifreeze tank melts upon the returning coolant/antifreeze where the return line meets the tank due to the high temperature of the coolant/antifreeze and causes the coolant/antifreeze to spill onto the engine. This led to a high engine temperature increase warning and immediately made the vehicle to stall to prevent overheating of the engine. I already replaced the old tank with a new one. Also, the rear passenger seat belt began to fray and it makes it almost impossible to buckle up.

My car is having transmission issues that have been recalled many times before. The car does not move forward when I apply the gas, it violently shakes on acceleration, the engine doesn't always turn over, and will rev but not move forward at a green light. This is incredibly dangerous, especially when trying to enter the flow of traffic. It's been a known issue for years, I don't know why they canceled the recall.

PURGE CANISTER VALVE SYSTEM FAILURE. CAR SPUTTERS AND WONT START WHEN GAS IS PUT INTO THE CAR. CAR JERKS. CHECK ENGINE LIGHT STAYS ON.

I tried taking out the car and It completely stalled and went into neutral when driving . Ford has a recall for ford focus 2014-2016 but apparently mines not one.

In December of 2021, my Ford Focus experienced engine failure due to the oil pump belt snapping and the car stalled in the middle of the interstate while my husband was driving it down the road. At the time we spent close to $9,000 replacing the engine. The part that failed has since been recalled but Ford is refusing to reimburse us for any of the costs directly related to this recalled component. Last week my engine filled again on the road while my husband was driving home from work. He was going around 50 miles an hour at the time. This time the car began running rough before the light came on and he immediately pulled off the road and shut it down and left it on the shoulder until a tow truck could arrive.

My ford focus had experienced a clutch slipping and is stuck in 2 gear. The car also had antifreeze leak during this event. This occurred on January 31,2023. My Ford dealership is quoted a $3,240 repair cost for clutch system on an automatic transmission. Ford case number CXH01481389.

After receiving a routine oil change in December 2023, my vehicle began malfunctioning. The oil, engine, and battery lights came on abruptly. I returned to the Valvoline location (approx. 1 mile from my home) and they redid the oil change and noted that there were no signs of a leak and advised that I send the car to get a diagnostic done. My car stalled twice as I was driving it home. I then had the car towed to the dealership I purchased it from (Hyundai owned). They advised that an oil tensioner belt near the engine had shredded and pieces had lodged in the engine. Shortly after, the recall was released. Since then Ford has been zero help. I understand that the parts for the new belt are needed, however I need a new engine now due to their negligence. I've contacted Ford directly on numerous occasions as well...

The vehicle went into limp mode while driving. The mechanic says engine needs to be totally replaced at 68,300 original miles. The mechanic originally said it was related to the recall on the 1.0 liter engines and the oil pump. Now they say the head gasket is blown and entire engine needs to be replaced due to overheating. Ford says this failure is not related to the recall and the recall does not affect our car. Our safety was at risk with a catastrophic engine failure while driving. We have only taken it to an independent mechanic. We have to two it to Ford to have them verify and they want to charge to diagnose the issue. There were no warnings prior the malfunction.

The contact owns a 2016 Ford Focus. The contact stated that while his son was driving at an undisclosed speed, the vehicle lost motive power. The vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 115,000.

while driving on the freeway the engine became noisy. I pulled to the shoulder , the brakes hardly worked. I talked to a friend who advised me to drive home . At home I noticed that the oil warning light was on ,engine running. Oil level was checked ,was full. Engine was replaced at a ford dealership and returned to service on 23sep2021 at great expense to me.

Two weeks after an oil change (not by Ford) my 2016 Ford Focus 5dr EcoSport engine lost power climbing a hill outside my home. On inspection two mechanics told me it needed a new engine. $8000 for me to pay. The local Ford dealer replaced the engine and gave me a 3yr unlimited mileage warranty. No symptoms prior to the failure, now that is a recall (Campaign/NHTSA#23S64/23V905) I would like Ford to reimburse all of us who are out of pocket.

[XXX] daughter was driving her car on I87 in Albany NY when oil pressure light went on and car speed dropped from 65 to less than 30 while in middle lane of interstate forcing her to cross over lanes onto shoulder roadway and exit ramp where it lost all power. Have learned that the oil belt system failed without any warning or notice causing incident. Have since learned that vehicle motor has been damaged beyond repair and needs replacement. Contact with 4 separate representatives of FORD Customer Service has resulted in FORD denying our requests for assistance to replace the motor. Car is a 2016 Ford Focus SE with the 1.0 liter motor with 81,000 miles. Well maintained with records as needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Ford Focus. The contact stated while driving 30 MPH and attempting to accelerate, the vehicle shuddered abnormally. The contact stated that the vehicle hesitated to shift gear while losing motive power. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that the transmission friction element "A" was stuck in the on position and failed to keep the fork engaged. The vehicle was not repaired. The vehicle was taken to the dealer, who had not diagnosed the failure. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 14M02. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 82,000.

•Oil pump failed to send oil to the engine causing the brakes to go out. While trying to pull out into traffic, the engine made a pop sound, and lost the ability to accelerate. Engine and oil light turned on, was then unable to accelerate past 20mph and engine sounded horrible. • Our mechanic looked at the car and said the oil vacuum pump was obliterated inside the engine. He replaced the vacuum pump and said that the timing belt is inside the engine which is causing all the issues. • No warning lamps or messages appeared before this. Had just had an oil change a month before and there were no issues.

Bought brand new off stevens creek ford frontier, after just 45,000 miles it showed serious transmission issues. At first it would stall and pop up a transmission overheat warning and it would jolt when just trying to step on gas lightly. I brought it in to the dealer service and they said it needed a new clutch and once I got it back it doesn’t start unless I have it in neutral and doesn’t backup. The car is extremely unsafe and stalls on the freeway in front of other cars

The contact owns a 2016 Ford Focus. The contact stated while driving at 5 MPH, the vehicle jerked abnormally. The check engine warning light was illuminated. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 83,000.

Clutch and actuator a&b

2016 Ford Focus with 53,000 miles, driven less than 150 miles per week on average just getting back and forth to work and running errands. Check engine light came on on November 2, 2023. I got a P0344 code from my mechanic who is 5 minutes away from when the check engine light came on. He advised me not to drive the vehicle until he could get my car in on November 7. When I started the car to take it to the mechanic on the evening of November 6 for him to look at the next day, the oil light came on. It was a 5 minute drive from my home to the auto shop. He immediately said Oh, Oh, that's the bad oil light not the low oil light. I have routinely kept up with the recommended maintenance schedule and the car was last serviced on June 7,...

The contact owns a 2016 Ford Focus. The contact stated while driving approximately 65 MPH, the vehicle lost motive power. The vehicle was taken to a dealer where the vehicle was diagnosed, and it was determined that an unknown software needed to be updated. The software was updated but the failure persisted. Additionally, the contact stated that on several occasions while driving at various speeds, the vehicle lost motive power and stalled. The vehicle was towed to the residence. The manufacturer was notified of the failure. The failure mileage was approximately 71,000.

Have been dealing with error codes for cpv, something about fuel, and air intake. The vehicle continuously stalls. Difficult to get it to start after fueling up. Sputters at various different speeds from 5mph to about 50mph. The vehicle will totally shut down on me out of gas even at over a quarter tank to half tank full according to the gauge. I dont have dates for the incidents because they are consistent at this point.

I was in the left lane of an interstate highway accelerating to pass, going about 75 mph. My car made a bang and all power was lost. I was able to coast to the right lane and fortunately was at an exit. Smoke was coming from under the hood. We pushed the car to a vacant parking lot. From there it was towed to our mechanic who identified a hole in the engine block caused by a piston rupturing through the block. The car had 69,000 miles on the engine and was well maintained.

the car shut off doing 60mph it was very scary took it to mechanic it had 2 codes the check engine light was on they cleaned the throttle body it ran but was struggling and rough idling drove to work and it wanted to stall multiple times put it in neutral to get idle up at a light then it stalled at a light drove home very afraid that it would shut off again took to the same mechanic to explain what happened have appt for estimate to fix . i need this car for work and am very scared to drive it as is never know when it will shut off called the dealer that sold me the car and all they said was theres no recalls and bring it in. i had an extended warranty but they said i was over by 1000 miles so no warranty i...

Vehicle suffered sudden loss of power. No warning lights initially but engine sounded odd at idle. Was able to return home with vehicle as happened nearby. Nothing obvious wrong upon visual inspection but vehicle was undrivable except at slow speed. Eventually check engine light came on while vehicle parked. Made appointment at local dealership. Check oil light also came on in route to dealership. If this had happened on highway would have put me in an unsafe situation. After some research turns out this is a known problem for the 1.0 Ecoboost engine. The oil pump belt fails and shreds clogging up the internals of the engine. In my conversations with Ford they admit it is a known problem but have not taken any steps to support vehicle owners as most failures have occurred outside the warranty. In my case at about 61,000 miles. Also learned direct from Ford that...

The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the check oil warning light illuminated, and the vehicle lost motive power. The vehicle was towed to an independent mechanic, who diagnosed a failure with the timing chain. The vehicle was not repaired. The manufacturer was notified of the failure but was unable to assist. The failure mileage was 105,000.

The contact owns a 2016 Ford Focus. The contact stated that while driving at various speeds, the vehicle was vibrating abnormally. There was an abnormal rumbling noise detected while the vehicle was in first gear. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who stated that the clutch and transmission needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed the contact that the repair was not covered under warranty. The contact stated that the failure was related to NHTSA Campaign Number: 18V845000 (Power Train). The failure mileage was approximately 100,000.

The engine blew due to a faulty oil pump that Ford knows about. The oil pump leaks and causes metal shards to enter the engine which causes it to cease while driving. Ford refuses to fix the engine due to out of warranty. This is a known issue for 1.0 Liter engine vehicles such as the Ford Focus and Ecosport. Our Foed dealer has 2 in the shop for same issue. There is also a class action lawsuit against them.

The contact owns a 2016 Ford Focus. The contact stated that while the transmission was shifting gear there was a loud sound coming from the vehicle and the vehicle shook abnormally. The vehicle became unable to shift out of park and felt as though the vehicle was in neutral. The check engine warning light was illuminated. The contact took the vehicle to the dealer to be diagnosed and the contact was informed that the transmission control module had failed and needed to be replaced. The vehicle had not been repaired. The manufacturer stated that the failure was related to TSB Number: 14M02 (Power Train) however, the vehicle was out of warranty. The approximate failure mileage was 53,000.

The engine shuddered and failed to shift at start from stop sign. It has had 2clutch or transmission changes and now just before 40,000 it shuddered at start from stop sign and almost stopped. Almost hit from behind. How many times much this be fixed before it is done right ?I intended this to be my forever car as I’m 73 years old. Of course the warranty was changed from 10,years to 7. I usually always had good success with Fords . If this doesn’t get covered my new Ford will be a Subaru.

Random misfire and wondering if Head Gastker recall repair was done on this vehicle

The contact owns a 2016 Ford Focus. The contact stated while driving at various speeds, there was a whining sound coming from the transmission with the "Transmission Fault" message displayed. The cause of the failure was not yet determined. Additionally, the vehicle had experienced an oil leak and was taken to the local mechanic who diagnosed that the chain gasket was faulty and needed to be replaced. The chain gasket was replaced, and the vehicle was repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 159,000.

The contact owns a 2016 Ford Focus. The contact stated that while her son was driving at an undisclosed speed, the vehicle lost motive power. The oil warning light was intermittently illuminated. The vehicle coasted to the dealer, where it was diagnosed that the engine and turbocharger needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 87,000.

2016 FORD FOCUS VIN: 1FADP3F20GL341128 Mileage: 64,750 Hello I am having problems with my 2016 Ford Focus. The vehicle is shuddering, moving forward, problems in shifting, vibrating and Ford cannot do anything about this as they have told me that you have not added this model on the recall. I got the vehicle checked over by Ford and they said it is the same issues as the other Ford Focus and Fiesta have and they said they need to replace the clutch and TCM. However this would be charable to me because you have not added this model in the recall. At the Sound Dealership in Renton WA there was 3 cars with the same issue and one being the same fuel flex model as mine. Is this something you could check as Ford will not help me at all. Thank you

Have tried repeatedly to get the CPV recall performed however all dealerships or authorized repair locations have been giving me multi month waits since it started showing the alarm code for it in Dec. 2021. Due to it being the only vehicle my family has we were out in a wait list to bring it in when they had the parts and never got called back. Now the Transaxle is not engaging 4/5/6th gear intermittently. Was informed that it would be 3K for a new transaxle even though I have not had the vehicle for that long.

Transmission went out. 2016 ford focus are known for bad transmission

Transmission Fault Service Now warning light keeps coming on and off. I’ve taken it to multiple places to have it checked out and nobody can find and actual issues that would cause the transmission to fail. I got stuck in the middle of an intersection because the transmission randomly stopped. I’ve had to have it towed.

Almost a year ago I noticed my check engine light came on and so I checked the codes which is P1450 - Unable To Bleed Up Fuel Tank Vacuum - Ford - Powertrain. Everytime I fill the gas tank the engine studders and fails upon startup, usually on the 3 or 4th start the engine finally idle and I'm able to change gears. I thought this was the issue that was supposed to be resolved back in 2019 when I took my car into Ford to have the recall issue fixed. Well whatever they did back then didn't fix it and looks like I'm not the only one this is happening to.

Water pump failed. This is the second time it happens. First time happened back in 2019 and it happened in the highway luckily, I was able to pull over and no accident happened as it was during high traffic flow. It was repaired by Ford but only because I had purchased a supplemental repair package thru Ford Focus when I signed the purchase agreement. Then another issue occurred with the thermostat and it was repaired as well thru the supplemental because they didn't cover it. I leaned that day that the water hoses were damaged as well, which it was due to the prior issue with the water pump but Ford did not fix it as they said it was not covered, I argued that the problem happened because it the water pump and thermostat going bad, a chain reaction, yet they didn't want to fix it unless I paid...

The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact used a portable scanner and retrieved DTC codes regarding the fuel rail pressure - Low. The contact’s husband replaced the canister purge valve (CPV); however, the contact stated that the failure reoccurred, and the vehicle was jerking, and losing motive power, and hesitating to restart. The vehicle was diagnosed again, and the contact retrieved fault codes for the fuel rail system again. The vehicle was then taken to a local dealer, where it was diagnosed that the fuel pump needed to be replaced. The contact's husband completed the repair; however, the contact stated that after refueling and driving at an undisclosed speed, the low fuel warning light illuminated. The contact referenced the failures to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline); however, the VIN was...

I was driving and the car started running hot. The overheating warning came on and said to pull over safely. I was not in an area where I could stop. The light eventually went off and the temp went back to normal. There are no noticeable leaks. The car has also been shifting hard, sputtering during acceleration, and revving really high. I think there needs to be a recall issued immediately. I'm only at 56k miles.

The contact owns a 2016 Ford Focus. The contact stated while driving at various speeds, the vehicle lost motive power and stalled. Additionally, the vehicle stalled occasionally after refueling. The check engine warning light was illuminated. The contact was able to restart the vehicle occasionally after several attempts. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the canister purge valve remained open causing the failure. The contact stated that the failure was related to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline); however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 79,000.

7 year old car requires full engine replacement due to lost compression. For the 2 1/2 years I've owned it 1 entire year has been spent either stranded on the insterstate or at the dealership service repair. Fuel gauge does not monitor or distrubute correct fuel available. I have spent $600 in tows to the dealership . Multiple reports/complaints have been filed against this model & year includeing with NHTSA. "Common problems found on the 2016 Ford Focus include the transmission shuddering, engine failures, as well as issues with the power steering system. Overall, these problems are more severe than in other compact cars, leading to expensive repair bills when parts fail" Please investigate quickly as this is safety related as well as consumer gouging

There is a recall with Ford of 2018 Ford Focus Recall Item Affected: FUEL SYSTEM, GASOLINEDate Announced: 10/22/2018 The description of this recall is what is happening to my car, but because my vin doesn't show up they won't look at it. There are no codes, but as I turn on the car and go to drive within 45 seconds it's stalls, in traffic or wherever. I need help.

The contact owns a 2016 Ford Focus. The contact stated that a large amount of white smoke was coming from the exhaust tip with the check engine warning light illuminated. The vehicle was driven to a dealer where it was diagnosed with a cracked engine block and that the engine needed to be replaced. The manufacturer was also notified of the failure and informed him that there were no recalls on the vehicle. The vehicle had yet to be repaired. The failure mileage was approximately 90,000.

The contact owns a 2016 Ford Focus. The contact stated that while parked and running the vehicle stalled. The engine warning light was illuminated. The gauges were showing incorrect readings. The contact called the local dealer who informed him that the vehicle was not covered under warranty or recall. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 18V735000 (Fuel System Gasoline). The manufacturer was not contacted. The approximate failure mileage was 109,000.

1st Started having issues with advancing, at idle stops,when engaging fuel, it will hesitate and run poorly. after a week, engine light started turning on, and stating that transmission, was running hot, and need it to stop and cool down. after the 2nd time, the vehicle runs rought, and grinding can be heard by shifting gear. An off duty Ford worker, checked vehicle with a computer and stated that the transmission clutch had gone out. checked the internet and stated that Ford Focus from 2012 to 2016 had a recall. yet I enter my vin number and nothing is said. I am currently paying my vehicle and can not drive it, have 3 children, and no money to repair. can you please help.

I have been having problems with ford focus for a long time. I have been told that this is normal. Recently, I had my car fixed by ford. Soon after, I was having problems with car slow start, hesitation and studdering. This is the same problems I was having before. I was told by Ford dealership that it was not the transmission. They told me that it was a crack engine head and purge valve problem. I paid for the fix even though I felt like it should have been covered in a recall. The car is not fix. I have completed 2 surveys with Ford. The department of transportation should investigate ford for its ford focuses.

The contact owns a 2016 Ford Focus. The contact stated while driving 50 MPH, the check engine warning light illuminated, and the vehicle stated shaking. The contact stopped in a parking lot and turned off and restarted the vehicle. The contact was able to drive to a dealer. The vehicle was diagnosed, and the mechanic stated that coolant was leaking from the vehicle. The contact stated that an unknown valve was replaced; however, the failure continued. The manufacturer was contacted and stated that the vehicle was not under recall and referred the contact to the NHTSA hotline to file a complaint. The failure mileage was 120,000.

The contact owns a 2016 Ford Focus. The contact stated that the check engine warning light was intermittently illuminated. While attempting to accelerate, the vehicle exhibited a slight hesitation with the check engine warning light illuminated. The contact took the vehicle to a certified mechanic who diagnosed that the purge valve failed and needed to be replaced. The vehicle was repaired. The vehicle was taken to the dealer, and it was confirmed that the vehicle was not included in NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The manufacturer was made aware of the failure and confirmed that the vehicle was not included in the recall. The approximate failure mileage was 50,000.

The oil pump failed while driving causing the engine to seize up. This occurred moments after the oil light came on giving the driver little time to react. The only lights indicated on the dash panel were the oil pressure and check engine lights. The engine seized and the car died while driving through a busy metropolitan area. The vehicle had to be physically pushed out of a busy intersection to get it out of the way of traffic. The vehicle was taken to the dealership where they found no oil in the filter, but plenty of oil in the pan. There were remnants of metal and belt material in the pan as well.