2006 FORD F-350 SD Fuel System Diesel Problems

THIS VEHICLES ISSUES BEGAN WITH THE GALVANIZING OF THE INTERIOR OF THE FUEL TANK FLAKING OFF AND GETTING INTO THE FUEL SYSTEM. IT IS A DIESEL. IT HAS BEEN TO THE SHOP TO HAVE THE FUEL TANK REPLACED, INJECTORS REPLACED, HIGH PRESSURE FUEL PUMP REPLACED TO NAME A FEW. ALL AFTER THE FUEL TANK PROBLEM. SINCE THEN THE VEHICLE HAS SHUT DOWN A NUMBER OF TIMES WHILE ON THE HIGHWAY. THIS IS EXTREMELY HAZARDOUS TO LOSE ALL POWER. FORTUNATELY OUR DRIVERS HAVE BEEN ABLE TO MANEUVER IT OFF THE HIGHWAY BEFORE CAUSING AN ACCIDENT. FORD HAS DENIED HAVING A PROBLEM WITH THEIR FUEL TANKS; HOWEVER, WHEN WE CHECKED AROUND WE FOUND IT TO BE QUITE COMMON. IN FACT WE HAD A DIFFICULT TIME SECURING A NEW TANK BECAUSE THERE WERE SO MANY REPLACEMENTS BEING DONE. I BELIEVE FORD SHOULD STEP FORWARD AND ADMIT THERE IS AN ISSUE AND DEAL WITH...

WAS DRIVING ON A HEAVY TRAFFIC HIGHWAY, IN THE MIDDLE LANE, AND TRUCK JUST QUIT RUNNING. THIS IS UNJUSTIFIABLE!! OVER $5000.00 IN REPAIRS TO GET TO GET THIS TRUCK TO RUN! WHY HASN'T FORD ISSUED A RECALL ON THIS NOTORIOUS PROBLEM ON THESE DIESEL ENGINES?! I WILL CONTINUE TO PURSUE A CLASS ACT LAWSUIT OVER THIS, I DO BELIEVE THERE ARE ENOUGH FORD OWNERS VERY UNHAPPY REGARDING THESE CONTINUING ISSUES.

TL* THE CONTACT OWNS A 2006 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING AT VARIOUS SPEEDS ON FIVE SEPARATE OCCASIONS. THE CONTACT ALSO STATED THAT THE FAILURE WAS DUE TO THE DELAMINATION OF THE FUEL TANK, WHICH CREATED A FLAKY SUBSTANCE WITHIN THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE FUEL TANK WAS DELAMINATING. THE CONTACT REPLACED THE FUEL FILTER HIMSELF AFTER THE FIVE SEPARATE FAILURES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 9,000. UPDATED 02/15/12*LJ UPDATED 04/26/12

TL* THE CONTACT OWNS A 2006 FORD F-350 SD. WHILE DRIVING 30 MPH, THE VEHICLE BEGAN LOSING POWER. THE DEALER DIAGNOSED THAT THE INNER LINING OF THE FUEL TANK WAS RUSTED AND FOUR INJECTORS WERE DAMAGED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 56,000.

TL* THE CONTACT OWNS A 2006 FORD F350. THE CONTACT STATED THAT THE VEHICLE SUDDENLY LOST POWER AND WOULD NOT ACCELERATE OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE FUEL TANK LINER, CAUSING THE FILTER AND FUEL LINES TO BECOME CLOGGED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 38,000.

THE CONTACT OWNS A 2006 FORD F-350 DIESEL. THE VEHICLE AT IDLE OR DRIVING DOWN THE ROAD WILL WITHOUT NOTICE BEGIN TO BUCK, AND SUDDENLY INCREASE RPM'S AND ACCELERATE,OR WILL STALL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPLACED THE ERG VALVE. THAT CORRECTED IT FOR ABOUT 30 DAYS AND THEN IT STARTED IT AGAIN. I TOOK IT BACK AND THEY TOLD ME I WOULD HAVE TO REPLACE THE MANIFOLD NEXT, BECAUSE THE CARBON THAT HAD BUILT UP IN THE MANIFOLD. AFTER A LENGTHY DISCUSSION THEY ADMITTED THAT THIS IS A SERIOUS PROBLEM WITH THIS ENGINE. THE FORD ENGINEERS TOLD THEM THAT THIS ENGINE WAS DESIGNED BY INTERNATIONAL FOR THE EUROPEAN MARKET AND THEIR DIESEL FUEL IS MORE REFINED THAN OURS, STATING THAT IS WHAT IS CAUSING THE PROBLEM. FORD REFUSES TO STAND BEHIND THE PROBLEM. JUST LOOK AT THE INTERNET ABOUT THE 6.0 DIESEL ENGINE AND THERE...

2006 FORD F-350 SUPER DUTY DIESEL DUMP TRUCK. THIS TRUCK HAS BEEN TO CROWLEY FORD IN PLAINVILLE CT. OVER 50 TIMES , YES THAT'S RIGHT I SAID 50. THE TRUCK HAS BEEN TOWED IN NO LESS THAN 6 TIMES IN 4 YEARS. MANY TIMES LEAVING A CREW OF 5 STRANDED ON THE SIDE OF A HIGHWAY. FORD TECHNICIANS HAVE NOT BEEN ABLE TO DETERMINE WHAT IS WRONG WITH THE VEHICLE. TRUCK WILL SUDDENLY LOOSE POWER OR JUST SHUT OFF. FORD HAS DENIED THAT THERE IS ANYTHING WRONG WITH THIS PARTICULAR TRUCK AND MOTOR BUT THERE ARE MANY CONTRACTORS IN OUR AREA THAT ARE HAVING THE SAME PROBLEM. RECENTLY THE TRUCK SAT AT CROWLEY FORD FROM MARCH 1 THROUGH THE END OF MARCH, THEIR TECH'S NOR FORDS TECH'S COULD FIGURE OUT WHAT WAS WRONG WITH IT. THEY ARE STILL DENYING THAT THE GAS TANK DELAMINATION HAS ANY BEARING ON THE SITUATION....

WE OWN A FORD F-350 DIESEL PICKUP. IT IS A 2006, PURCHASED NEW. IT HAS HAD REPEATED POWER FAILURE IN THE LAST TWO AND HALF YEARS, WITH OTHER SIMILAR PROBLEMS BEFORE THAT. MOST RECENTLY WE HAD IT TOWED TO OUR DEALERSHIP TO THE TUNE OF $2500.00 REPAIR FOR FUEL INJECTORS AND FUEL INJECTOR MODULES. THE PROBLEM, IS SAFETY FOR OUR LIVES AND POSSIBLY OTHERS IN OUR PATH. THE VEHICLE HAS RECURRING ENGINE FAILURE CAUSING IT TO DIE WHILE DRIVING. THIS HAS HAPPENED NOT ONLY AT A STOP LIGHT, BUT THROUGH INTERSECTIONS, AND ON STRAIGHT ROADS. WE MOST RECENTLY HAD IT DIE TWICE WHILE PULLING 2 HORSES IN A TRAILER. QUICKLY SHIFTING INTO NEUTRAL TO RESTART TO AVOID AN ACCIDENT. IT HAD TO BE TOWED TO OUR HOME JUST LAST THURSDAY APRIL 14TH DUE TO NOT RESTARTING. TODAY, APRIL 18TH, WE TOOK THIS TRUCK TO OUR LOCAL FORD DEALERSHIP AS WAS...

TL*THE CONTACT OWNS A 2006 FORD F-350 SD. WHILE DRIVING 50 MPH THE VEHICLE STALLED. AFTER THREE ATTEMPTS THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE DIESEL FUEL TANK WAS CONTAMINATED AND THE COATING INSIDE THE TANK CAME APART. THEY WILL NOT REPAIR THE FAILURE UNDER WARRANTY BECAUSE HE USED THE WRONG DIESEL FUEL. THE CONTACT WILL BE RESPONSIBLE FOR THE REPAIR COST OF $7,000. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 11,000.

ON 2006 FORD F350 VEHICLE WITH 6.0 DIESEL , THE EGR COOLERS HAVE DEFECT THAT CAUSE THEM TO LEAK. AFTER READING INTO THIS IT IS A COMMON ISSUE. I TOOK THE TRUCK TO FORD AND THEY STATED IT IS A VERY COMMON PROBLEM AND THAT I SHOULD LOOK INTO AN AFTERMARKET COOLER SINCE THE OEM UNIT FAILS QUITE OFTEN TO THE FREQUENCY OF 2 TO 3 WITHIN 100,000 MILES. THIS REPAIR IS APPROX. 1000 TO 2000 DEPENDING ON IF THE HEAD GASKETS HAVE BEEN SUBSEQUENTLY DAMAGED AS WELL. IN MY CASE I HAD TO REPLACE THE OIL COOLER ALONG WITH EGR COOLER AN EGR VALVE AND HEAD GASKET. MY TOTAL BILL WAS $2095.63 FORD STATED IT IS A VERY COMMON PROBLEM AND HAS TSB,S ON THIS BUT HAS NO PLANS FOR A VOLUNTARY RECALL. THEY DID STATE THAT THEY WILL ONLY COMPENSATE IF INSTRUCTED TO DUE TO A RECALL. THESE...

ENGINE FILTERS GET CLOGGED UP AND CAUSE THE TRUCK TO RUN ERRATICALLY AND STALL, CAUSED FROM DEBRIS FROM A FAULTY FUEL TANK. *TR

FUEL TANK DELAMINATED CAUSING ENGINE STUTTER OR COMPLETE SHUT OFF. FUEL TANK REPLACED BY FORD UNDER WARRANTY. HAD VEHICLE IN FOR SERVICE/ REPAIR AND WAS TOLD THAT THERE WAS PROBLEMS WITH NEW TANK BUT THAT IT WAS NOT COVERED UNDER WARRANTY. *TR

TL* - THE CONTACT HAS A 2006 FORD F-350 SUPER DUTY, THAT CONTINUOUSLY EXPERIENCES SEVERE LOSS OF POWER. WHILE DRIVING ON THE HIGHWAY, OR GOING UP A HILL THE VEHICLE STALLS WITHOUT ANY PRIOR WARNING. THE VEHICLE DOES NOT HAVE ENOUGH POWER TO PULL THE 5TH WHEEL. THE CONTACT HAS TAKEN THE VEHICLE TO THE DEALER AND THEY STATED THAT THE INJECTORS BROKE IN HALF, DUMPING RAW FUEL INTO THE HOT OIL OF THE MOTOR. THEY ALSO STATED THAT THERE ISN'T ANY KNOWN REPAIR FOR VEHICLE'S FAILURE. THE CONTACT CAN PROVIDE COPIES OF INVOICE REPAIR. *JB UPDATED 2/27/2007 - THE CONSUMER HAS TWO IDENTICAL VEHICLES AND BOTH FAILED IN THE SAME MANNER. *NM

CHECK ENGINE LIGHT ON SEVERAL TIMES AND UNABLE TO IDENTIFY PROBLEM. 10/10/06 EGR POSITION ERROR BUT STATED OKAY AT THIS TIME. SEVERE LOSS OF POWER FOUND 4 INJECTORS REPLACED 11/27/06. 12/08/06 CHECK ENGINE LIGHT ON WITH REPLACEMENT OF EGR VALVE 12/18/06. TURNS OVER WITHOUT START WITH PUFFS OF BLACK SMOKE. ENGINE GOT HOT. SMOKE SMELLED OF ANTIFREEZE AND LOST ALL POWER. REPLACED 4 INJECTORS, FUEL PUMP, FUEL LINE FITTING. 1/12/07 SEVERE LOSS OF POWER, TRUCK AT GARAGE. *JB