2006 FORD F-350 SD Electrical System Problems

TL* THE CONTACT OWNS A 2006 FORD F-350 SD. THE CONTACT STATED THAT SEVERAL FAILURES OCCURRED WITH THE VEHICLE REGARDING THE ENGINE AND ELECTRICAL COMPUTER. THE VEHICLE WAS TAKEN TO SHAMALEY FORD (11301 GATEWAY BLVD W, EL PASO, TX 79936) WHERE THE TURBO, GLOW PLUGS, HEAD GASKETS, AND THE COMPUTER WERE REPLACED. DESPITE THE REPAIRS, THE VEHICLE FAILED TO START-UP AFTER MULTIPLE ATTEMPTS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000. THE VIN WAS NOT AVAILABLE.

THERE IS A PROBLEM WITH THE INSTRUMENT CLUSTER AND THE PLUGS. THE DASH GOES DEAD, INTERIOR LIGHTS DONT WORK. POWER WINDOWS DONT WORK RADIO SHUTS OFF. VEHICLE RUNS IMPROPERLY. THE VEHICLE CAN BE SITTING OR MOVING. I HAVE DONE RESEARCH AND FOUND FORD TRUCKS FROM AS EARLY AS 2002-2008 HAVE THIS ISSUE. ITS UNSAFEAND A KNOW ISSUEWITH THESE YEAR FORD TRUCK F150-F450. A NEW DASH IS VERY EXPENSIVE AND USED ONES RUN THE RISK OF THE SAME ISSUE HAPPENING AGAIN. THE FIX IS SIMPLE, THE COST IS NOT. THERES VIDEOS ON YOU TUBE DOZENS OF FORUMS. EXCURSION EXPEDITIONS ARE ALSO HAVING THE SAME ISSUE. IM N THE MID WEST ITS COLD. I DROVE TO PICK UP A COIPLE ATVS AN HOUR NORTH. HALFWAY BACK ISSUES HAPPENED WHILE WINDOW WAS DOWN. DROVE HOME PREG FIANCE 5YR OLD IN THE BACK -3 OUTSIDE-15 WINDCHILL N WE'RE DRIVE 65MPH TO GET HOME. THAT...

TL* THE CONTACT OWNS A 2006 FORD F-350 SD. THE CONTACT WAS DRIVING 25 MPH WHEN THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE MECHANIC ADVISED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED, BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 114,000.

ON 2006 FORD F350 VEHICLE WITH 6.0 DIESEL , THE EGR COOLERS HAVE DEFECT THAT CAUSE THEM TO LEAK. AFTER READING INTO THIS IT IS A COMMON ISSUE. I TOOK THE TRUCK TO FORD AND THEY STATED IT IS A VERY COMMON PROBLEM AND THAT I SHOULD LOOK INTO AN AFTERMARKET COOLER SINCE THE OEM UNIT FAILS QUITE OFTEN TO THE FREQUENCY OF 2 TO 3 WITHIN 100,000 MILES. THIS REPAIR IS APPROX. 1000 TO 2000 DEPENDING ON IF THE HEAD GASKETS HAVE BEEN SUBSEQUENTLY DAMAGED AS WELL. IN MY CASE I HAD TO REPLACE THE OIL COOLER ALONG WITH EGR COOLER AN EGR VALVE AND HEAD GASKET. MY TOTAL BILL WAS $2095.63 FORD STATED IT IS A VERY COMMON PROBLEM AND HAS TSB,S ON THIS BUT HAS NO PLANS FOR A VOLUNTARY RECALL. THEY DID STATE THAT THEY WILL ONLY COMPENSATE IF INSTRUCTED TO DUE TO A RECALL. THESE...

I HAVE A FORD F-350 THAT HAS HAD A VIOLENT FRONT END SHAKE AT FREEWAY SPEEDS. THE "SHAKE" HAS BEEN SO VIOLENT I THOUGHT I WAS GOING TO CRASH. I HAVE TAKEN IT TO FORD AND THEY CHANGE OUT A COUPLE PARTS AND THEN IT HAPPENS AGAIN WITHIN 20,000 MILES. THIS HAS HAPPENED 4 TIMES SINCE OWNING THE TRUCK (PURCHASED NEW IN NOV. 2006). I HAVE ALSO HAD PROBLEMS REPEATEDLY WITH THE HIGH PRESSURE OIL PUMP AND OR ELECTRICAL THAT FORD CANT RESOLVE. THE TRUCK IS NOW IN THE SHOP AGAIN. IT CRANKS BUT WILL NOT START THE TRUCK WAS GOING DOWN THE FREEWAY AT 70MPH AND IT JUST DIES AND WONT RESTART. THEY SAY IT IS HIGH PRESSURE OIL PUMP AND HAVE REPLACED IT 3 TIMES WITHIN 50,000 MILES. *TR