2012 FORD EXPLORER Engine Problems

The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 45 MPH, the traction control and check engine warning lights illuminated. The contact stated that a minute and a half later, while attempting to make a right turn, the steering wheel became firm, and added effort was needed to turn the steering wheel. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 170,000.

while driving the vehicle goes into what I have found is called sleep mode.. The check engine lite comes on and the left info panel shows that the all wheel drive is not working. The dealer tried to see what codes were set and found none. My solution is to pull off the road, put the vehicle in park and turn off the ignition. After about 30 seconds I can restart the vehicle and drive again. The restart lasts from 15 seconds to a month. I found a TSB ( 16-0139) that covered this problem. However it did not offer any cure. I am concerned that someone will hit me when this happens.

Engine mounds wearing out and Ford says they are in backorder for almost a year now. If there's such a demand. Then why isn't there recall that so many people are requesting them but Ford can't supply them.

Water Pump on the vehicle (That is inside the engine) start leaking without driver notice it. If you're driving in a busy Highway the engine can lose presure and stop in the middle of the highway puting driver and passengers in a risky position. This is a design mistake from FORD that they should address.

The truck has been in shop 5 times or actually 5 different dealerships. The recall has yet to be fixed but I continually pay to have the problem INVESTIGATED. The dash flashes loss of fuel pressure, service advance track soon, Battery level and mechanic wrench . I have this on video as it is constant occurrence. Each time ford takes it in they can't make the issue happen or recreate it. As told several times happens sporadic and not under any certain conditions. Over and over paying diagnostic fee and what they say will repair the issue only it happens pulling off the lot at 5 star ford Dallas Texas took it in under default to Bob Tomas Mckinney where they scanned it and found 17 communication errors left it there nothing was done but more exploration of issues going down the list of com failures and paying for each...

Water coolant leaking out, engine over heating. Having to constantly add coolant and limiting driving of the vehicle.

the car unexpectedly loses power while driving on the highway causing several near crashed having to move to the brake down lane .The wrench symbol shows up on dash and the car is trying to stall at idle. I have to shut it off and restart to drive it. Check engine light does NOT go on. Car has 96k miles .It has happened 4x's in the last month. My research says its the Throttle body. I am trying to bring it to Ford to confirm.

PERSISTENT EXHAUST ODOR IN VEHICLE UPON START UP . WHEN THE VEHICLE CRANKS UP AND WITH A/C ON THERE IS A STRONG EXHAUST ODOR , IT ISN'T AS NOTICEABLE AT HIGHWAY SPEEDS BUT STILL THERE . THIS ISSUE STARTED A COUPLE WEEKS AGO AND HASN'T WENT AWAY

MY TRUCK BURST INTO FLAMES 🔥 AND BURN TO THE GROUND WHILE PARKED IN THE DRIVE WAY. *TR

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE SHUT OFF AND THE LOW OIL PRESSURE WARNING LIGHT FLASHED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS DIAGNOSED WITH BOTH A DEFECTIVE O2 SENSOR AND LOW OIL PRESSURE SENSOR. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE AND INFORMED HER THAT THERE WERE NO RECALLS ON HER VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED AND WAS NOT TAKEN TO A DEALER. THE FAILURE MILEAGE WAS 143,000.

VEHICLE OVERHEATED WITHOUT WARNING LEAVING ME STRANDED ON A DESERTED HIGHWAY. AFTER SPEAKING WITH A MECHANIC AND HAVING THEM COME TO THE VEHICLES LOCATION AND PERFORMING A VISUAL INSPECTION HE STATED ANTIFREEZE WAS LEAKING FROM THE WATER PUMP. THE VEHICLE WAS TAKEN TO A LOCAL FORD DEALER AND UPON COMPLETING A DIAGNOSTIC CHECK THEY CONFIRMED THE 'INTERNAL' WATER PUMP HAD FAILED WITHOUT WARNING. I WAS CONTACTED 5 TIMES BY THE DEALERSHIP AND EACH TIME THE NEWS GOT WORSE. THEN FINAL CALL THE ADVISOR TOLD ME TO FIX IT AND NOTHING WAS GOING TO BE GUARANTEED TO LAST IT WAS GOING TO COST APPROXIMATELY $4,000 BEFORE TAXES. THEY'D ALSO HAVE TO CHANGE THE OIL TWICE ALONG WITH THE SPARK PLUGS. THE VEHICLE HAD JUST BEEN AT A LOCAL FORD DEALERSHIP FOR MAINTENANCE AND TO FIX OUTSTANDING RECALLS AND AFTER CHECKING THE SERVICE MANUAL NOTHING IS 'SUGGESTED' 'RECOMMENDED' OR 'REQUIRED' TO SERVICE...

I HAVE COOLANT LEAKING, I TOOK IT TO A SHOP TO BE DIAGNOSED AND WAS TOLD THAT IT WOULD COST OVER $2,000 SINCE THE WATER PUMP IS IN THE FRONT OF THE ENGINE, THERE IS ONLY 132,000 MILES ON MY CAR AND I SHOULDN'T BE HAVING THIS ISSUE!!

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT NOTICED AN ABNORMAL EXHAUST ODOR COMING FROM THE VENTILATION SYSTEM WITHOUT WARNING. THE CONTACT MENTIONED THAT THE ODOR WAS ONLY PRESENT WHEN THE VEHICLE WAS IDLING. THE VEHICLE WAS TAKEN TO HASTINGS FORD INC (3013 E 10TH ST, GREENVILLE, NC 27858, (252) 758-0114) WHERE IT WAS TEST DRIVEN AND DETERMINED THAT THE EXHAUST WAS LEAKING AT THE MANIFOLD. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED MULTIPLE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED CASE NUMBER: 25071531. THE FAILURE MILEAGE WAS APPROXIMATELY 111,000.

I BOUGHT MY EXPLORER IN JUNE 2019. AFTER PURCHASING I NOTICED THE SMELL OF THE EXHAUST INSIDE THE VEHICLE .THROUGHOUT THE SUMMER MONTHS I DROVE WITH THE WINDOWS DOWN DUE TO THE A.C. NOT WORKING PROPERLY . I CONTINUED SMELLING THE EXHAUST BUT FINANCIALLY UNABLE TO SEEK REPAIRS. WITH COOLER TEMPERATURES THE WINDOWS NOW CLOSED THE SMELL OF THE EXHAUST WAS MORE APPARENT AND I BEGIN TO EXPERIENCE SEVERE HEADACHES, FREQUENT NAUSEA, FATIGUE AND SOME DIZZINESS AND CONFUSION. I WAS TOLD OF REPORTS OF CARBON MONOXIDE ISSUES WITH THIS MAKE OF VEHICLE AND SPOKE TO FORD ABOUT REPAIRS AS WELL AS OTHER RECALLS NEEDED FOR MY EXPLORER. I TOOK MY CAR FOR THE REPAIRS TODAY AND AM STILL EXPERIENCING THE CARBON MONOXIDE ISSUE STILL. I WILL BE CONTACTING THE FORD DEALERSHIP TOMORROW AS THIS WASN'T REPAIRED. I'M CONCERNED FOR MY HEALTH AND HAVING THIS ISSUE NOT FIXED .

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE THE CONTACT'S WIFE WAS DRIVING 65 MPH, THE VEHICLE SHUT OFF COMPLETELY WITHOUT WARNING. THE CONTACT CALLED RIVERSIDE FORD LINCOLN (2089 RIVERSIDE DR, MACON, GA 31204, (478) 464-2900) AND WAS INFORMED THAT THEY WERE UNAWARE OF A POSSIBLE DEFECT AND SUGGESTED THE CONTACT BRING IN THE VEHICLE TO BE SERVICED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS ON THE VEHICLE. THE CONTACT WAS REFERRED TO NHTSA. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

CAR WON'T GO INTO PARK

OIL IS COLLECTING AT MY AIR INTAKE. I HAVE REPLACE THE PCV VALVE BUT IT IS STILL LEAKING OIL ONTO MY AIR FILTER. THIS IS ALSO CAUSING FUMES IN THE VEHICLE.

I HAVE AN EXHAUST SMELL COMING FROM MY VENTS. THIS ODOR IS PRESENT IN THE FRONT AND BACK SEATS OF THE CAR. IT IS PRESENT WHEN THE VEHICLE IS IN MOTION, AS WELL AS WHEN IT IS STATIONARY. IT HAPPENS AT RANDOM TIMES AND CAN HAPPEN WHILE DRIVING AT A SLOWER RATE, AND WHILE DRIVING AT HIGH SPEEDS. THE DEALERSHIP CANNOT IDENTIFY THE SOURCE OF THE SMELL.

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT THE THROTTLE BODY ASSEMBLY WAS FAULTY. WHEN THE CONTACT DEPRESSED THE ACCELERATOR PEDAL, THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT PULLED THE VEHICLE OVER AND IT STARTED SHAKING. WHEN THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE, IT OPERATED NORMALLY. SAMES FORD (4721 AYERS ST, CORPUS CHRISTI, TX 78415, (361) 851-7600) DIAGNOSED THAT THE THROTTLE WAS FAULTY AND PROVIDED THE REPAIR COST. THE MANUFACTURER STATED THAT THERE WAS NO RECALL AND ADVISED THE CONTACT TO SAVE THE RECEIPTS FOR REIMBURSEMENT IF A RECALL WAS ISSUED. THE FAILURE MILEAGE WAS 58,900. *TT CONSUMER STATED CAR WOULD NOT ACCELERATE ON A BUSY ROAD. PROBLEM WAS FIXED.*JB

WHEN TRYING TO MAKE AN UNPROTECTED LEFT TURN AT A STOP SIGN, I PRESSED THE GAS AND MY CAR DIDN'T MOVE FOR A COUPLE OF SECONDS ONCE IT DOD MOVE IT TOOK A FEW MORE SECONDS FOR IT TO ACCELERATE QUICKLY TO SAFELY MAKE MY TURN. THE ONCOMING TRAFFIC IN THE LANE I WAS CROSSING OVER FOR THE TURN HAD TO BRAKE SUDDENLY BECAUSE MY CAR DIDN'T MAKE IT THROUGH THE INTERSECTION FAST ENOUGH. I WAS TOLD THAT MY TURBO BOOST WAS BAD. I HAVE A 2012 ECO BOOST MODEL AND IT WAS CLASSIFIED AS 'UNDER BOOST' WHICH WASN'T ALLOWING MY CAR TO ACCELERATE PROPERLY AND WOULD EVENTUALLY GIVE OUT COMPLETELY NOT ALLOWING ME TO ACCELERATE AT ALL.

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING 30 MPH, THE VEHICLE STALLED, SHUT OFF, AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO CROSSROADS FORD OF SANFORD (3251 NC-87, SANFORD, NC 27332, (888) 352-5045) WHERE THE CONTACT WAS INFORMED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 87,362. *TT *TR

WHILE DRIVING ON HIGHWAY, LOST POWER AND SPEED DROPPED. IT WAS LIKE ENGINE STOPPED WORKING PROPERLY. HAD TO PULL OFF ROAD, IT WAS SO SCARY ON HIGHWAY TO LOOSE POWER NOT TO MENTION DANGEROUS!!! CHECK ENGINE LIGHT CAME ON. AFTER TAKING TO FORD DEALERSHIP, FOUND OUT THAT ECOBOOST TURBO HAD BLOWN AND SEIZED UP.

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE OPERATING THE VEHICLE, THERE WAS AN ODOR BEING EMITTED FROM THE EXHAUST THAT CAUSED THE CONTACT TO FEEL NAUSEOUS AND DIZZY. THE VEHICLE WAS TAKEN TO BARBER FORD (640 E 8TH ST. HOLLAND, MICHIGAN 49423) ON THREE SEPARATE OCCASIONS TO HAVE THE VOLUNTARY FORD EXHAUST CAMPAIGN COMPLETED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THE FAILURE HE WAS EXPERIENCING WAS NOT PART OF THE VOLUNTARY FORD EXHAUST CAMPAIGN. THE FAILURE MILEAGE AND VIN WERE NOT PROVIDED.

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS WITH THE ACCELERATOR PEDAL DEPRESSED, THE VEHICLE STALLED AND THE OIL PRESSURE AND POWER TRAIN WRENCH WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS UNABLE TO START ON THE FIRST ATTEMPT. THE FAILURE RECURRED OVER THREE TIMES. THE CONTACT NOTICED THE FAILURE AFTER SHE DEPRESSED THE ACCELERATOR PEDAL AFTER A COMPLETE STOP. THE LOCAL DEALER (GULF COAST FORD, N, 3000 STATE HWY 288, ANGLETON,TX, 77515) WAS CONTACTED SCHEDULED AN APPOINTMENT FOR TWO DAYS LATER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 155,000.

AN EXHAUST ODOR REPEATEDLY OCCURRED IN THE CABIN WHILE THE VEHICLE WAS ACCELERATING.

ROTTEN EGG/SULFUR SMELL INSIDE CABIN/OCCUPANT AREA COMING FROM VENTS WHEN ENGINE UNDER HEAVY LOAD SUCH AS GOING UP HILL OR COMING ONTO HIGHWAY AND RPM'S INCREASE, ACCELERATING AT HIGHER SPEEDS TO MERGE INTO TRAFFIC FROM OFF RAMP. NOTICED MORE WHEN AC IS ON. BOUGHT VEHICLE USED FROM A LOCAL CAR DEALER IN FEB OF 2017

(RE)STARTING AUGUST 1, 2017, WHILE DRIVING, THE VEHICLE WOULD SUDDENLY AND WITHOUT WARNING DECELERATE, WITH NO RESPONSE FROM THE GAS PEDAL. FORD CALLS THIS THEIR "LIMP HOME MODE." THE WRENCH ICON WARNING WOULD DISPLAY AND THE ENTIRE VEHICLE WOULD SHUDDER UNTIL IT WAS PUT IN PARK AND TURNED OFF. USUALLY, IT WOULD RESUME NORMAL OPERATIONS AFTER BEING RESTARTED, HOWEVER, ON ONE OCCASION, IT TOOK THREE ATTEMPTS TO RESTART. AFTER TWO SUCH INCIDENTS OCCURRING IN LESS THAN A MILE, I DON'T FEEL SAFE DRIVING ON THE HIGHWAY (OR, REALLY, ANY OTHER PLACE) AS THERE IS NO INDICATION TO OTHER DRIVERS AND THE VEHICLE ACTIVELY DECELERATES, RATHER THAN COASTING. DURING ONE SUCH INCIDENT, THE DECELERATION WAS SO PRONOUNCED THAT PASSENGERS JERKED FORWARD IN THEIR SEATS AND A CANINE PASSENGER LOST ITS FOOTING, FALLING INTO THE BACK OF THE SEATS. WE PREVIOUSLY EXPERIENCED THIS SAME ISSUE IN 2015, LEAVING ME AND A SMALL...

PURCHASED THIS CAR IN AUGUST 2015. EVERY TIME I ACCELERATE QUICKLY TO PASS SOMEONE OR GO UP HILL FUMES ENTER THE CAR. VERY STRONG ODOR AND I HAVE TWO YOUNG DAUGHTERS WHO ARE UNABLE TO TELL ME IF THEY FEEL FUNNY FROM THE FUMES. PURGE VALVE SENSOR REPLACED DUE TO ENGINE LIGHT COMING ON REPEATEDLY.

TURBO GONE BAD - CAR BEGAN MAKING LOUD RATTLE NOISE WHEN STARTED. NOISE WOULD SUBSIDE SOME AFTER A FEW MINUTES. CAR HAS BEEN VERY SLOW TO ACCELERATE, WHENEVER IT'S BEING DRIVEN, OVER THE LAST FEW MONTHS. HAVE TO REALLY PRESS DOWN ALL THE WAY ON THE GAS IN ORDER TO KEEP IT GOING. THE MPG HAVE BEEN STEADILY DECLINING AS WELL OVER THE LAST FEW MONTHS. DEALER TOLD ME IT'S A "TURBO PROBLEM". WAS TOLD THAT 180 OTHER 2012 EXPLORERS ARE ALSO AFFECTED, PARTS ON BACK-ORDER FOR SIX WEEKS. CAN'T DRIVE CAR. REPAIR COST APPROXIMATELY $3500. FORD OFFERING NO RELIEF AT THIS POINT.

I AM EXPERIENCING THE EXHAUST FUMES SMELL IN MY VEHICLE WHEN ACCELERATING UP HILLS OR WHEN MERGING INTO TRAFFIC. MY FAMILY HAS SUFFERED SYMPTOMS SUCH AS HEADACHES AND LIGHTHEADEDNESS DUE TO THE SMELLS. THE SMELL IS A VERY STRONG EXHAUST FUMES SMELL AND LASTS FOR AT LEAST 30 SECONDS TO A MINUTE.

TURBO FAILURE WHILE DRIVING, LARGE LOSS OF POWER AND POTENTIAL FOR AN ACCIDENT. TURBO CHARGER FAILED ON MY 2.0L ECOBOOST ENGINE AT 58,000 MILES. TURBO FAILED WHILE IN TRAFFIC AND CAUSED VERY POOR PERFORMANCE AND COULD HAVE EASILY CAUSED A WRECK. TURBO FAILURE DOES NOT CREATE A CHECK ENGINE LIGHT OR GIVE ANY INDICATION THAT IS HAS FAILED OTHER THAN A LARGE LOSS OF POWER AND THE ENGINE CONTINUES TO RUN. TURBO FAILURE IS SUDDEN AND THERE IS NO INDICATIONS PRIOR TO IT FAILING. THE TURBO WAS NOT COVERED BY WARRANTY DUE TO VEHICLES AGE EVEN THOUGH UNDER 60K.

OUR 2012 FORD EXPLORER HAS A HEAVY FUEL SMELL IN THE CABIN AFTER DRIVING FOR MORE THAT A FEW MINUTES. IT SEEMS TO BE GETTING WORSE AS TIME PASSES.

I ABRUPTLY ACCELERATED AROUND A CAR THAT MANEUVERED INFRONT OF ME AND MY INTERIOR CABIN WAS FILLED WITH AN NAUSEATING EXHAUST SMELL. I GOT A HEADACHE, LIGHT HEADED, AND PULLED OVER, BECAUSE I WAS STARTING TO GET DIZZY AND DEVELOP HEADACHES. THIS OCCURRED ON A HIGHWAY, AND NEARLY KILLED ME. I AM FURIOUS.

MY VEHICLES AIR TURNS ON ON IT'S OWN AS YOU DRIVE. THIS IS NOT THE AC NOR HEATER. AS YOU DRIVE YOU CAN HEAR YOUR AIR VENTS TURN ON AND YOU SMELL A FOUL SMELL AND THE AIR PUSHING THROUGH THE VENTS IS MUGGY STICKY AIR THAT MAKES YOUR SKIN FEEL CLAMMY. THIS HAS BEEN REPORTED TO THE DEALERSHIP BEFORE AND HAD BEEN "REPAIRED" HOWEVER, THE AIR CONTINUES TO PUSH THROUGH THE VENTS WHETHER YOU HAVE THE SWITCH SET TO ON OR NOT.

WE HAVE NOTICED INTERMITTENT ODORS IN THE CABIN. SULPHUR SMELLING ODOR AFTER ACCELERATING QUICKLY (FOR EXAMPLE PASSING, MERGING). IT HAPPENS WHEN THE HEAT IS ON, OR OFF. IT HAS HAPPENED INTERMITTENTLY FOR AS LONG AS WE CAN RECALL HOWEVER THE SMELL IS NOW (APPROX. THE LAST YEAR) NOTICEABLE JUST ABOUT ANY TIME WE DO HIGHWAY DRIVING. IT ALMOST EXCLUSIVELY HAPPENS ON THE HIGHWAY. ON THE INFREQUENT OCCASION THAT I NEED TO MAKE A QUICK ACCELERATION WHILE DOING AROUND-TOWN DRIVING, THE SMELL CAN BE NOTICED. I AM CURRENTLY RECEIVING MEDICAL ATTENTION FOR SEVERE SYMPTOMS OF, WHAT I BELIEVE TO BE, CARBON MONOXIDE EXPOSURE. SYMPTOMS INCLUDE EXTREME FATIGUE AND HEADACHES.

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR WHILE OPERATING THE VEHICLE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL ODOR COULD NOT BE DIAGNOSED; HOWEVER, THE CHECK ENGINE INDICATOR FAILURE WAS DIAGNOSED AS AN AIR FILTER NEEDING TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

DROVE VEHICLE WITH AIR CONDITIONING ON AND RECIRCULATION CLOSED FROM TEXAS TO VIRGINIA AND BACK AT NORMAL HIGHWAY SPEEDS. THERE WAS AN EXHAUST SMELL IN THE CAR MOST TIMES. HAD TO BE TAKEN TO EMERGENCY CARE WITH RESPIRATORY DISTRESS A COUPLE OF DAYS AFTER RETURNING. WAS ON TREATMENT FOR COPD FOR THE NEXT FIVE YEARS.

MY 2012 FORD EXPLORER WOULD ALL OF A SUDDEN SOUND LIKE IT WAS SLIPPING OUT OF GEAR WHILE DRIVING. I WOULD LOSE ALL CONTROL OF THE ACCELERATOR & VEHICLE WOULD IDLE VERY ROUGH. THE "WRENCH" LIGHT WOULD APPEAR ON THE DASH DISPLAY. I WOULD HAVE TO DRIFT OVER TO THE SIDE OF THE ROAD, TURN THE VEHICLE OFF, & THEN RE-START THE VEHICLE. THIS HAPPENED WITHOUT WARNING & BECAME MORE FREQUENT. DEALERSHIP REPLACED THE THROTTLE BODY (AT MY COST) & EXPLAINED NO RECALL HAD BEEN DETERMINED YET, BUT EXPECTED IT TO BE ISSUED IN THE FUTURE DUE TO THE NUMBER OF COMPLAINTS. I ALSO HAD TO PAY TO HAVE MY SELECTOR LEVER ASSEMBLY REPLACED AGAIN SINCE I WAS AGAIN HAVING THE ISSUE OF VEHICLE PROBLEM OF "SHIFT TO PARK" APPEARING ONCE AGAIN. THE FIRST TIME THIS PART WAS REPLACED IT WAS COVERED UNDER TSB 15-0047, BUT THIS TIME IT WAS...

DROVE ABOUT 2 MILES IN THE MORNING WHILE TURNING ONTO THE INTERSTATE RAMP THE STEERING LOCKED UP WOULD NOT GO OVER 30MPH, SUV STARTED TO SMOKE WHILE THE TEMPERATURE GAUGE NEVER CHANGED INSIDE OF THE VEHICLE. LUCKY TO NOT HAVE CAUSED A MAJOR ACCIDENT. AFTER HAVING VEHICLE TOWED, PER THE MECHANIC THE COMPUTER SYSTEM IS FRIED, MOTOR VALVES MELTED, AND ALL SPARK PLUGS NEED TO BE REPLACED. THIS SUV IS ONLY A 2012 AND SHOULD NOT HAVE THIS MAJOR OF PROBLEMS WHEN IT HAS BEEN WELL TAKEN CARE OF. FORD REALLY NEEDS TO LOOK FURTHER INTO THIS SO THIS DOES NOT HAPPEN TO SOMEONE ELSE.

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING 35 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PURGE VALVE WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 53,128.

WHILE DRIVING THE VEHICLE SUDDENLY POWER WOULD BE LOST. WHEN APPLYING MORE PRESSURE TO THE ACCELERATOR, NO USABLE POWER WAS PRESENT AND THE VEHICLE COULD NOT EXCEED 30 MPH. AFTER THIS OCCURRED ON THE 4TH TIME ON A SUBSEQUENT DAY, THE "ENGINE" SYMBOL WAS DISPLAYED. CURRENTLY THE VEHICLE IS AT A FORD DEALERSHIP TO TROUBLESHOOT THE PROBLEM. ON TWO OCCASIONS THIS DISCREPANCY WITH ACCELERATION AND FUNCTIONALITY OF AVAILABLE POWER NEARLY CAUSED AN ACCIDENT WITH SMALL CHILDREN IN THE VEHICLE. THIS SHOULD CAUSE A MAJOR CONCERN TO OTHER OWNERS AND FORD MOTOR COMPANY AS A WHOLE DUE TO THE POTENTIAL DAMAGE, INJURY, OR DEATH THAT COULD OCCUR DUE TO COMPLETELY LOSING ACCELERATION AND/OR POWER WHILE DRIVING. *TR

STRONG EXHAUST (BURNING OIL SMELL) COMING INTO CABIN UNDER MEDIUM TO HIGH ACCELERATION THROUGH VENTILATION ( AC ON) . THE SMELL PERMEATES THE CAR AND BURNS YOUR NOSTRILS. I COULD SMELL IT FOR QUITE SOME TIME EVEN AFTER EXISTING THE VEHICLE (AS THE SMELL REMAINS IN MY NOSE). EVEN FELT A BIT LIGHTHEADED AFTER EXISTING THE VEHICLE. I HAVE HAD PASSENGERS NOTICE THIS SMELL ON SEVERAL OCCASIONS ALSO.

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT OBSERVED AN ABNORMAL ODOR THROUGH THE AIR CONDITIONING UNIT WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 27,000.

FOR ABOUT THE LAST YEAR, I WOULD SMELL SOMETHING BURNING INSIDE MY VEHICLE WHEN ENTERING THE FREEWAY. I WAS NEVER ABLE TO IDENTIFY THE SOURCE OF THE SMELL, EVEN AFTER REPEATEDLY STOPPING TO SNIFF THE ENGINE COMPARTMENT AND AROUND THE TIRES AND EXHAUST. I COULD NOT DETECT THE SMELL OUTSIDE OF THE CAR, NOR DID I FIND ANY EVIDENCE OF ANYTHING BURNING (NO SMOKE, CHARRED AREAS, STUCK BRAKES, MELTED RUBBER, ETC). THERE DIDN'T APPEAR TO BE ANY PATTERN, AS I WOULD SMELL SOMETHING BURNING AT DIFFERENT POINTS IN MY COMMUTE, WITH THE ONLY TIME I CONSISTENTLY EXPERIENCED IT BEING MERGING ONTO THE FREEWAY. ON JUNE 20, 2016 AT 1:38 PM CENTRAL TIME, I SENT MY HUSBAND THE FOLLOWING TEXT: "IS THE FIRE EXTINGUISHER STILL IN THE CAR?" DUE TO THE OVERPOWERING SMELL OF SMOKE IN THE PASSENGER COMPARTMENT SHORTLY AFTER GETTING ON THE FREEWAY. I ROLLED DOWN THE WINDOWS AND...

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

EXHAUST SMELL IN CABIN AFTER ACCELERATION, FOR EXAMPLE DURING ATTEMPTS TO PASS ON HIGHWAY, ETC. SOMETIMES REFERRED TO AS "ROTTEN EGG SMELL". SMELL IS DEFINITELY GETTING IN TO CABIN. DISSIPATES AFTER SEVERAL MINUTES. HAVE BEEN EXPERIENCING NEUROLOGICAL PROBLEMS FOR ABOUT 6 MONTHS NOW (RANDOM, CONSTANT MUSCLE FASCICULATIONS THROUGHOUT BODY, STRANGE HEADACHES AND HEAT-RELATED SENSATIONS, ETC), TRYING TO WORK WITH DOCTORS TO FIGURE OUT IF SYMPTOMS ARE RELATED TO VEHICLE AND THE SMELL. THE SMELL IS WELL-DOCUMENTED ON THE POPULAR FORD EXPLORER FORUMS ONLINE, AND HAPPENS USUALLY UNDER HARD ACCELERATION OR HIGHWAY SPEEDS.

SINCE DAY ONE OF OWNERSHIP I SIGNALED TO THE SERVICE DEPARTMENT THAT I SMELL FUMES IN THE CAR WHILE USING CLIMATE ON HEAT OR COLD. THEY TESTED AND SAID ALL IS OK. AFTER 1 YEAR IT STILL HAPPENS EVERY TIME I USE CLIMATE, SOMETIMES MORE OBVIOUS THAN OTHER TIMES. NO SMOKE ENTERS THE CABIN, JUST A HEAVY ODOR. I ALWAYS HAVE TO OPEN THE WINDOW TO BE ABLE TO STAY IN THE CAR. WORRIED ABOUT LONG TERM EFFECTS ON MY FAMILY AND OUR FUTURE BABY. CALLED FORD EVEN TODAY TO ASK IF THEY HAVE ANY DOCUMENTATION ON THIS PROBLEM..SAID NO.

WHEN WE ACCELERATE IN OUR 2012 FORD EXPLORER, THE CABIN IS FILLED WITH EXHAUST FUMES. MANY TIMES WE ARE REQUIRED TO ROLL THE WINDOWS DOWN TO LET THE FUMES OUT AS THEY CAUSE HEADACHES AND SMELL BAD. THIS MAINLY OCCURS WHEN WE ACCELERATE ON TO A HIGHWAY/INTERSTATE FROM THE ON RAMP.

WHILE DRIVING DOWN THE HIGHWAY MY EXPLORER MADE A LOUD CLUNK SOUND AND THEN THE WRENCH SYMBOL APPEARED ON MY DASHBOARD. THEN THE GAS PEDAL QUIT WORKING, AND WE HAD TO ROLL OFF THE HIGHWAY AVOIDING BEING HIT BY OTHER TRAFFIC. I HAD TO STOP AND RESTART MY CAR 5-6 TIMES BEFORE THE GAS PEDAL WOULD WORK AGAIN. THIS HAS HAPPENED 5 TIMES IN THE PAST TWO MONTHS, AND WHEN I CALLED TO HAVE IT SERVICED THEY TOLD ME THE WRENCH LIGHT HAD TO BE ON FOR THEM TO IDENTIFY THE PROBLEM. BUT I CANT GO ANYWHERE WHEN THE WRENCH LIGHT COMES ON AND A TOW TRUCK WILL NOT TOW A CAR WITH IT RUNNING FOR ME TO GET IT TO THE DEALERSHIP TO BE TESTED. THIS IS A SAFETY ISSUE THAT OTHER PEOPLE ARE HAVING. THE THROTTLE BODY IS GOING OUT ON MANY EXPLORERS AFTER 55,000 MILES. IS IT...

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING 15 MPH, THE ENGINE STALLED AND THE LOW ENGINE PRESSURE LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE DEALER REPROGRAMMED THE COMPUTER, BUT THE FAILURE RECURRED NUMEROUS TIMES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 56,700. THE VIN WAS NOT AVAILABLE.