2000 FORD EXPLORER Power Trainautomatic Transmission Problems

THE 2000 FORD EXPLORER SUV BEGAN TO SLOW DOWN AS THE ENGINE RPMS INCREASED. AFTER PULLING OVER AND TURNING THE IGNITION OFF, WE NOTICED SMOKE COMING FROM THE HOOD. UNDERNEATH THE CAR, FLAMES WERE DRIPPING DOWN FROM THE TRANSMISSION. WE USED A FIRE EXTINGUISHER TO EXTINGUISH THE FLAMES ON THE GROUND, AND ATTEMPTED TO OPEN THE HOOD. AFTER THE HOOD WAS OPENED, LARGE FLAMES WERE OBSERVED IN THE ENGINE COMPARTMENT. THE FIRE EXTINGUISHER WAS USED UNTIL EMPTY AND HAD LITTLE IMPACT. THE CAR BEGAN TO BURN QUICKLY AND THE FLAMES SPREAD FROM FRONT TO BACK. THE EMERGENCY SERVICES ARRIVED, EXTINGUISHED THE FIRE AND COLLECTED WITNESS STATEMENTS. NO ONE WAS HURT IN THE INCIDENT AND THE FRAME WAS TOWED VIA AAA TO A NEARBY AUTOMOTIVE SHOP. *KB

TL* THE CONTACT OWNS A 2000 FORD EXPLORER. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE GEAR SELECTOR WOULD NOT SHIFT INTO THE PARK POSITION. THE GEAR WAS SHIFTED INTO NEUTRAL TO ALLOW THE VEHICLE TO REMAIN STATIONARY AND THE ENGINE WAS TURNED OFF. THE CONTACT POSITIONED BRICKS IN FRONT OF EACH TIRE TO PREVENT THE VEHICLE FROM ROLLING. THE FAILURE WAS A CONTINUOUS OCCURRENCE. THE VEHICLE WAS TAKEN TO THE DEALER AND INDEPENDENT MECHANIC WHERE THEY INFORMED THAT THE FAILURE WAS RELATED TO THE GEAR SHIFTER CABLE. THE VEHICLE WAS NOT REPAIRED DUE TO THE PART BEING DISCONTINUED. THE FAILURE MILEAGE WAS APPROXIMATELY 120. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2000 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE JERKED WHEN THE CONTACT SHIFTED GEARS. THE FAILURE OCCURRED INTERMITTENTLY AT ANY SPEED. THE FAILURE ALSO OCCURRED WHILE THE VEHICLE WAS IN REVERSE GEAR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED THREE TIMES BUT THE FAILURE COULD NOT BE DUPLICATED. THE SOLENOID WAS REPLACED, BUT THE FAILURE CONTINUED TO OCCUR MORE FREQUENTLY OVER TIME. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 16. THE CURRENT MILEAGE WAS APPROXIMATELY 53,000. THE VIN WAS UNAVAILABLE.

2000 FORD EXPLORER [XXX] XLT 4 DR 4X4 OHV "X" VIN 4.0 OHV ENGINE. 2 RE-BUILT 5R55E TRANSMISSIONS. BOTH TIMES PO-741 CODES TORQUE CONVERTER CLUTCH SYSTEM STUCK OFF. HAD TO START IN LOW AND SHIFT TO DRIVE TO MOVE THRU GEARS. NO REVERSE UNLESS YOU GUN ENGINE THEN SLOWLY MOVES IN REVERSE SOMETIMES. RE-BUILT AT 113K AND AGAIN AT 195,000 MILES. SOMETIMES NO GEAR WHEN DRIVING. HAVE TO SWITCH OVERDRIVE OFF TO GAIN TRACTION. TRANS FINALLY QUIT AGAIN. DANGEROUS CONDITION. FORD DEALERS TELL ME NOTHING EXTRAORDINARY. HAVE NEVER EXPERIENCED SO MUCH TRANSMISSION PROBLEMS WITH ALL THE SUVS AND SEDANS I'VE OWNED. I BELIEVE A SAFETY RE-CALL IS IN ORDER. IT IS NO COINCIDENCE THAT RETAIL SHOPS REFER TO THE FORD EXPLORER AS THE FORD "EXPLODER". *TR

2000 FORD EXPLORER 4.0L SOHC. O/D LIGHT STARTED BLINKING WHILE DRIVING DOWN A HILL, WITHOUT THE ACCELERATOR PRESSED. WHEN I STARTED TO ASCEND THE NEXT HILL I WAS ALMOST REAR ENDED SINCE THE TRANSMISSION WOULD NOT SHIFT TO 4TH (OVERDRIVE) AND I HAD TO DEPRESS THE ACCELERATOR PEDAL ALMOST TO THE FLOOR TO GET THE POWER TO GET UP THE HILL. BOUGHT THIS VEHICLE TO REPLACE MY 1999 FORD ZX2 WHICH RAN GREAT MINUS THE FACT THE SUB-FRAME HAD COMPLETELY ROTTED OUT BETWEEN THE DRIVER SEAT AND THE REAR STRUT MOUNT. I'M SURE YOU WILL GET COMPLAINTS WHEN THOSE START BREAKING IN HALF ON THE HIGHWAY. *TR

2000 FORD EXPLORER,TRANSMISSION WILL SLIP,LOCK UP IN OVERDRIVE,PLACE IN REVERSE CAR LURCHES FORWARD.THE O/D OFF LIGHT FLASHES ENGINE RPMS ARE VERY HIGH.THERE ARE THOUSANDS OF PEOPLE THAT KEEP HAVING THE SAME PROBLEMS WITH THIS VEHICLE. IT HAS 4.0 ENGINE AND THE 5R55E AUTOMATIC TRANSMISSION. THIS VEHICLE IS DANGEROUS TO MY FAMILY AND TO THE PUBLIC YOU NEVER KNOW WHAT TYPE OF REACTION WILL COME OUT OF THIS TRANSMISSION. THE VEHICLE HAS 100,000 MILES ON IT. TAKEN TO AAMCO THEY QUOTED $2300.00 FOR REPAIRS. MY WARRANT COMPANYCOMPLETE AUTOMOTIVE REPAIR SERVIVES (C.A.R.S)WILL ONLY PAY FOR A SALVAGE YARD TRANSMISSION.THESE TRANSMISSION WERE ONLY MADE FRO A SHORT TIME. ANY TRANSMISSION FROM A SALVAGE YARD WILL HAVE THE OPERATING PROBLEMS. WHILE AT AAMCO A CUSTOMER BROUGHT HIS 1999 EXPLORER IN HIS TRANSMISSION WAS REBUILT BY AAMCO FEB OF THIS YEAR.IT IS STUCK IN OVERDRIVE AND WILL NOT GO INTO REVERSE. WARRANTY COMPANY SENT A...

FAULTY TRANSMISSION ON 2000 FORD EXPLORER. O/D LIGHT FLASHES AND TRANSMISSION SHIFTS HARD. OCCURS ON MID TO LONG RANGE TRIPS AND WILL LIKELY REQUIRE A TRANSMISSION REBUILD. IT IS KNOWN THAT THIS IS A COMMON ISSUE WITH FORD SUV'S/TRUCKS FROM LATE 90'S AND EARLY 2000'S, BUT FORD REFUSES TO "ACKNOWLEDGE" THE ISSUE. *TR

VEHICLES TRANSMISSION SLIPS CAUSING LOSS OF POWER TO GEARING. UNSAFE CONDITIONS EXISTS WHILE TRYING TO USE POWER TO AVOID ACCIDENTS. WHEN VEHICLE KEY IS SWITCHED OFF THEN ON AGAIN, TRANSMISSION RESETS UNTIL NEXT EVENT OF POWER LOSS. *TR

MY TRANSMISSION ON MY 2000 FORD EXPLORER XLT OVER DRIVE O/D LIGHT STARTED TO FLASH ON AND OFF. I ONLY HAVE 169,000 MILES ON THE TRUCK. WHEN I WAS DRIVING IT STARTED TO JERK AND SLIP OUT OF GEAR. NOW IT ONLY LET ME DRIVE ONLY IN ONE GEAR. I'VE CALLED THE FORD DEALERSHIPS AND SAYS THERE IS NOTHING WE CAN DO. IT SHOULD BE A RECALL ON THIS PROBLEM BECAUSE SO MANY FORD EXPLORER OWNERS UP TO THE 2002 MODEL HAS THE SAME PROBLEM WITH THEIR TRUCK AND THEY THE SAME RESPONSE WHEN CALL FORD DEALERSHIPS. THIS THE WEBSITE WITH ALL OF THE COMPLAINTS: HTTP://WWW.CARCOMPLAINTS.COM/FORD/EXPLORER/2002/TRANSMISSION/O_D_LIGHT_IS_BLINKING.SHTML. THIS ISSUE NEEDS TO ADDRESSED BECAUSE NO ONE WANTS TO BE IN THE MIDDLE OF ON COMING TRAFFIC AND CAN'T MOVE BECAUSE OF THE VEHICLE'S TRANSMISSION WANT ALLOW THEM TOO. THEY WILL BE IN AN ACCIDENT OR CAUSE ONE. *TR

2000 FORD EXPLORER HAS O/D LIGHT BLINKING. ROUGH SHIFTING FROM 1ST TO 2ND. BARELY IS ABLE TO GET INTO PARK WHICH LEAVES THE VEHICLE ABLE TO ROLL AWAY. (AUTOMATIC TRANSMISSION). *TR

2000 FORD EXPLORER HAS A DELAY IN SHIFTING ON TRANSMISSION, O/D OFF LIGHT FLASHING AND CAR WINDS OUT IN BETWEEN GEARS... VERY COSTLY SO FAR AND EXTREMELY DANGEROUS!!!!!!!!! *CN

2000 FORD EXPLORER 4.0 V6 SOHC WITH LESS THAN 120,000MILES- 5 SPEED OVERDRIVE TRANSMISSION IS GOING INTO FAILURE. SLIPS CONSISTENTLY WHEN SHIFTING BETWEEN SECOND AND THIRD GEAR, RPMS HAVE TO RAISE WELL ABOVE THE NECESSARY LEVEL TO ACTUATE THE SHIFTING MECHANISM, WHETHER IT MAY BE VALVES OR THE BANDS. *TR

2000 FORD EXPLORER TRANSMISSION MALFUNCTION. THIS IS A SAFETY PROBLEM WHICH SEEMS TO BE RAPID ON THE FORD EXPLORER LINE IN SEVERAL YEARS. THE TRANSMISSION SEEMS TO FAIL AT AN EARLY OR LATE INTO OWNERSHIP. I TALKED TO DEALER IN MY AREA AND THERE COMMENTS WHERE. DON'T TELL TRANSMISSION O/D LIGHT BLINKING AND TRANNY SLIPS, THE MINUTE I JUST SAID LIGHT COMES ON! THIS IS A SERIOUS SAFETY ISSUE AS WHEN DRIVING IT JUST GIVES OUT WITHOUT WARNING AND SLIPS WHEN ACCELERATING. I'M SURE IF YOU GET A SERVICE RELATED TRANSMISSION PROBLEM FOR THIS PARTICULAR VEHICLE YOU WILL FIND FORD HAS AND IS AWARE OF THE PROBLEM. BUT IT GOES BACK TO MONEY! I WAS MAKING A LEFT TURN WITH ONCOMING TRAFFIC AND IT JUST SLIPPED AND HAD TO PUNCH IT TO LEAVE INTERSECTION. *TR

I HAVE A 2000 FORD EXPLORER. SEVERAL YEARS AGO I HAD TO REPLACE THE TRANSMISSION, WHICH I UNDERSTAND IS VERY COMMON IN FORD VEHICLES. NOW JUST A FEW YEARS LATER I'M HAVING TRANSMISSION ISSUES AGAIN. THE CAR IS JOLTING AHEAD WHEN AT A COMPLETE STOP. AND ALSO NOT WANT TO GET INTO THE NEXT GEAR PROPERLY. I AM NOW TOLD THAT I HAVE TO REPAIR THE TRANSMISSION VALVE BODY. IT SEEMS THESE VEHICLES HAVE WAY TOO MANY TRANSMISSION ISSUES. *TR

ON AUGUST 28, 2009 I WAS DRIVING WITH MY HUSBAND AND TWO CHILDREN UNDER AGE 2 ON THE MASSACHUSETTS TURNPIKE WHEN OUR 2000 FORD EXPLORER SUDDENLY ACCELERATED. I COULD NOT STOP THE CAR WITH THE BRAKES AND WAS FORCED TO PUT THE CAR IN NEUTRAL TO FINALLY GET THE CAR TO STOP. I WAS USING THE CRUISE CONTROL AT THE TIME AND HAD IT SET JUST UNDER 70 MPH. MY CAR AT ONE POINT WAS GOING ALMOST 90 AS WE TRIED TO FIGURE OUT WHAT TO DO WHILE MY FOOT WAS ALL THE WAY ON THE BRAKE. WE WERE LUCKY TO HAVE SURVIVED THIS INCIDENT. A LOCAL GARAGE SAID THAT THE CRUISE CONTROL MUST HAVE STUCK AND THEY HAVE DISCONNECTED THE WIRES BUT NOW LEAVE US WITH DAMAGE TO THE CAR WE ARE STILL TRYING TO DIAGNOSE. *TR

MY FIRST CAR WAS A 2000 FORD EXPLORER AND I COULD NOT BE MORE DISAPPOINTED WITH THE PERFORMANCE OF THIS VEHICLE. ALTHOUGH I HAVE HAD THE CAR NOW FOR A FEW YEARS, IT HAS NEVER BEEN IN AN ACCIDENT. THERE HAVE BEEN SOME MINOR ISSUES WITH THE CAR THAT ARE EXPECTED WITH NORMAL WEAR AND TEAR. HOWEVER AT ONLY ABOUT 60,000 MILES I STARTED HAVING VERY BAD TRANSMISSION PROBLEMS. THE O/D LIGHT FLASHES NEARLY EVERY TIME I DRIVE THE CAR AND THE TRANSMISSION (AUTOMATIC) SKIPS EVERY TIME AFTER FIRST GEAR. AFTER DOING SOME RESEARCH I REALIZED THAT THIS IS NOT A RANDOM OCCURRENCE. THERE ARE NUMEROUS FORD EXPLORER OWNERS WITH THIS SAME PROBLEM AND FORD HAS YET TO ACKNOWLEDGE AND HELP FIX THIS PROBLEM. I INITIALLY THOUGHT THAT IT WAS JUST MY CAR POSSIBLY GETTING OLD, HOWEVER AFTER SPENDING HOURS RESEARCHING MY PROBLEM I QUICKLY REALIZED THAT THIS IS NOT...

I NOTICED A SLIGHT HESITATION IN THE TRANSMISSION SHIFTING FROM 1ST TO 2ND GEAR ONCE IN A WHILE YESTERDAY. WITHIN 5 MILES THE O/D LIGHT WAS FLASHING AND BY THE TIME I GO HOME(LUCKILY)5 MILES LATER, REVERSE WAS NOW NOT WORKING. I HAVE A CAR THAT HAS ALREADY HAD 1 TRANSMISSION REPLACED, NEEDING ANOTHER ONE. I AM EXTREMELY LUCKY THAT I DID NOT GET STRANDED!!!! *TR

AT 166,000 HEAD GASKET BLEW PLUS THERE WERE OTHER ENGINE PROBLEMS. REPLACED WITH ANOTHER ENGINE. NOW TRANSMISSION IS GOING OUT. IT WILL GO INTO REVERSE FINE BUT WILL GO INTO DRIVE WITH PROBLEMS. IF VEHICLE IS COLD IT WILL GO INTO DRIVE FASTER THAN WHEN IT IS WARMED UP. AT WARM TEMP IT MAY TAKE SEVERAL TRIES OF SHIFTING FROM PARK BACK TO DRIVE OR WAITING SEVERAL MINUTES FOR IT TO DROP INTO DRIVE AFTER SHIFTING OUT OF PARK. HAVE ONLY OWNED THIS VEHICLE LESS THAN 2 YEARS. *TR

O/D LIGHT FLASHING. GRIFFEN FORD COULD NOT ID PROBLEM. UNACCUSTOMED TO HOW THIS TRANSMISSION SHOULD HANDLE, I HAD NO IDEA HOW THE LOWEST GEAR RATIO SHOULD FEEL AND ASSUMED WHAT IT DID FEEL LIKE WAS NORMAL. AT 110,000 A/TRAN FAILED AND HAD TO BE REMANUFACTURED. USED PRIVATE SHOP. OUTSTANDING RE-BUILD AND THAT IS WHEN I FOUND OUT THAT I NEVER HAD A LOW(EST) GEAR BUT DID AFTER THE TRANSMISSION WAS REBUILT. FAITHFUL CHANGE AND CLEANING OF TRANS FLUID, NO TOWING EVER, AND EXCELLENT MAINTENANCE RECORD DID NOT PREVENT A TRANSMISSION FAILURE WHICH IS EVIDENCE OF FORD POOR QUALITY CONTROL AT THE MANUFACTURING OR ASSEMBLY LEVEL. OBVIOUSLY NO ONE EVER PICKED UP THE FACT THAT THE LOW GEAR NEVER WORKED, NOT AT THE FORD FACTORY, AT THE DEALERSHIP, BY SALES, OR SERVICE, AND WAS NEVER PROPERLY ROAD TESTED. POOR REFLECTION ON FORD MOTOR CORPORATION. *TR

O/D LIGHT STARTED FLASHING AND WOULDN'T CORRECT WITH THE BUTTON ON THE GEAR SHIFT. EXPLORER WOULD REV AT INAPPROPRIATE TIMES. MILEAGE HAS DROPPED FROM 21 TO 16 MPG WHICH OUTRAGEOUS. TOOK IT IN TO BE CHECKED EXPECTING THE SENSORS TO BE OFF BUT WAS TOLD THE TRANSMISSION WAS SHOT, THE CONVERTER WAS BUSTED, METAL IN THE TRANSMISSION, WOULD NEED TO COMPLETELY REPLACE THE TRANSMISSION. *TR

PROBLEM WITH TRANSMISSION. SLIPS BETWEEN 2ND AND 3RD GEAR. OVER DRIVE LIGHT IS FLASHING. TOOK TO REPAIR SHOP AND COST $300, DID NOT FIX PROBLEM. *TR

IN EARLY SEPTEMBER, MY TRANSMISSION LOCKED UP WHILE ON A TRIP WITH MY FAMILY. THE MILEAGE AT THE TIME WAS UNDER 85,000 MILES. IT COST ME OVER $1500 TO HAVE A REBUILT TRANSMISSION INSTALLED. APPARENTLY, OTHER FORD EXPLORER XLT OWNERS HAVE HAD THE SAME ISSUE. IN ADDITION, SEVERAL MONTHS LATER, BOTH WHEEL HUB ASSEMBLY'S HAVE GONE BAD TO THE TUNE OF OVER $800. THE MILEAGE IS STILL UNDER 90,000. I HAD TO TAKE THE VEHICLE IN AGAIN TODAY AND FOUND OUT THAT A BALL JOINT HAS GONE BAD NEAR THE WHEEL HUB ASSEMBLY AND IT'S GOING TO COST AROUND $250 TO REPLACE THAT. IT'S UNFATHOMABLE THAT FORD WOULD BE ALLOWED TO PUT OUT SUCH A SHODDY VEHICLE THAT FALLS APART ONCE YOU GET OVER 80,000 MILES USAGE. *TR

CONSUMER'S 2000 FORD EXPLORER CAUGHT FIRE. CONSUMER STATED HE WOULD LIKE REIMBURSEMENT FOR PERSONAL ITEMS WHICH WERE IN THE VEHICLE AT THE TIME OF THE FIRE. *KB PRIOR TO THE FIRE, THE ENGINE WOULD NOT START. THE CONSUMER RECEIVED A RECALL NOTICE REGARDING A POTENTIAL FIRE CONCERNING THE SPEED CONTROL DEACTIVATION SWITCH. THE TRANSMISSION HAD BEEN REPLACED A MONTH EARLIER. *JB

I WAS TOLD IN DEC 2004 BY MY MECHANIC THAT MY TRANSMISSION WAS FAILING (MY VEHICLE HAD ONLY 32K MILES AT THE TIME), BUT BECAUSE MY 2000 FORD EXPLORER WAS TOO OLD, THERE WAS NOT ANY THING THAT I COULD DO OTHER THAN PAY FOR A REPAIR. REGARDLESS OF AGE, I DON'T THINK ANY TRANSMISSION SHOULD FAIL WITH ONLY 32K MILES ON THE CAR. *TR

VEHICLE UNDERWENT 95000 MILE INSPECTION WHICH INCLUDED CHANGE OF TRANSMISSION FLUID AND FILTER IN OCT 06. IN FEB THE TRANSMISSION FAILED ON RETURN FROM SHORT TRIP. LOCAL FORD GARAGE ADVISED THAT LIKELY CAUSE WAS LEAKING TRANSMISSION SEAL. THERE WAS NO EVIDENCE OF ANY TRANSMISSION LEAK ON DRIVEWAY, OR GARAGE FLOOR. THERE WAS NO PROBLEM WITH VEHICLE NOT SHIFTING CORRECTLY UNTIL EVENING OF PROBLEM. IT WAS AS IF ALL FLUID WAS LOST AT ONCE BUT GARAGE CLAIMS THAT IT WAS PRESSURE LEAK? *JB

PREMATURE FAILURE OF AUTOMATIC TRANSMISSION, 2000 FORD EXPLORER, TRANSMISSION IS THE SAME USED IN THE PINTO. VERY UNDER RATED FOR WHAT IT IS EXPECTED TO PERFORM. *NM

2000 FORD EXPLORER WHILE PARKED IN OUR DRIVEWAY (PARKED- KEYS OUT AND IN MY POCKET) IT BEGAN ROLLING BACKWARD. I WAS ABLE TO JUMP IN AND DEPRESS THE BRAKE PEDAL JUST BEFORE IT WOULD HAVE ROLLED OF THE HILL AND INTO THE STREET. THEN IT DID THE SAME THING AGAIN THE NEXT DAY. *NM

2000 FORD EXPLORER TRANSMISSION WENT OUT AT 54,000 MILES, REBUILT COST $1,350. CAR IS AT 128500 MILES AND TRANSMISSION HAS GONE OUT AGAIN! CAR HAS NOT PILED TRAILER OR LOAD ON SYSTEM. FORD TRANSMISSIONS ARE JUNK! *JB

I HAVE A 2000 FORD EXPLORER WITH 46,000 MILES ON IT. I NOTICED A DELAY GOING INTO FIRST GEAR ON TRANSMISSION. TOOK CAR TO DEALER AND THEY REPAIRED TRANSMISSION TO THE COST OF $2900. I AM 61 YEARS OLD AND DRIVE VERY LITTLE. I EXPECTED AT LEAST 100,000 MILES FROM THIS VEHICLE BEFORE MAJOR PROBLEMS. DEALER FOUND ELC TRANS DIAGNOSTIC FOUND INTERNAL WEAR. FOUND INTER AND OD SERVO PISTON HARD 2-3 SHIFT VALVE STICKING. R/R VALVE BODY. PISTONS OVERHAULED AND FLUSHED COOLER LINES .REPLACED CONTROL ASSEMBLY,GASKET, PISTON AND ROD, SCREEN ASSEMBLY, CONVERTER ASSEMBLY & FLUID. *JB

2000 FORD EXPLORER WITH 58,000 MILES. TRANSMISSION SLIPS WHEN SHIFTING GEARS. 'OD OFF' LIGHT FLASHES. DEALER WANTS TO REPLACE VALVE BODY AND TORQUE CONVERTER. I DON'T THINK THERE SHOULD BE MAJOR TRANNY PROBLEMS LIKE THIS AT 60K. I HAVE FOUND SEVERAL OTHER PEOPLE WITH SIMILAR PROBLEMS ONLINE. *NM

DT*: THE CONTACT STATED WHILE DRIVING, THE OVERDRIVE LIGHT WAS FLASHING. THE VEHICLE WAS PULLED OVER TO DETERMINE A PROBLEM. WHEN THE VEHICLE WAS PUT IN DRIVE THERE WAS NO REACTION, AND REVERSE WAS INOPERABLE. THE VEHICLE WAS PUT IN SECOND GEAR AND TAKEN TO THE DEALERSHIP. THE DEALERSHIP DETERMINED THE TRANSMISSION NEEDS TO BE REPLACED. *NM

DT: THE CONTACT STATED WHEN THE VEHICLE WAS SHIFTING FROM SECOND TO THIRD GEAR THE ENGINE REVVED. IF HE KICKED THE VEHICLE INTO PASSING GEAR THE ENGINE REVVED EVEN MORE. A LOCAL REPAIR SHOP STATED THAT IT WAS THE BLOW-OFF VALVE THAT BURNED OUT THE BANDS IN THE TRANSMISSION. THE REPAIR SHOP DID REBUILD THE TRANSMISSION. FORD HAD PREVIOUSLY ISSUE A SERVICE BULLETIN FOR THIS COMPONENT. *AK

DT: THE CONSUMER STATED THAT WHEN GOING TO PASS ANOTHER VEHICLE THE PASSING GEAR WAS NOT WORKING. THE PASSING GEAR WAS DEFECTIVE. THE CONSUMER HAD VEHICLE FIXED BY A DEALER AND IT COST HIM $800.00. THE VEHICLE SPEED WAS ABOUT 50 MPH, HE HIT THE PASSING GEAR AND THE VEHICLE DROPPED TO FIRST GEAR. THE CONSUMER WAS INVOLVED IN A NEAR MISS AS A RESULT. THE CONSUMER CALLED THE MANUFACTURER, AND THEY DID NOT REIMBURSE HIM ANY MONEY. THE DEALER REPLACED THE GEARS IN THE TRANSMISSION.*AK UPDATED 11/02/05. *JB

1) SLIPPAGE IN 2-3 SHIFT OF AUTOMATIC TRANSMISSION CAR WITH 63K MILES 2) PREMATURE FAILURE OF THE AUTOMATIC TRANSMISSION; COSTLY REPAIR ($2700) 3) REQUIRED REBUILD OF TRANSMISSION

O/D LIGHT FLASHING, TRANSMISSION SLIPPING AT SPEEDS OVER 40 MPH. VEHICLE ONLY HAS 63K MILES. TRANSMISSION REPLACED, MECHANIC STATES KNOWN PROBLEM WITH THIS TRANSMISSION IN THIS 2000 FORD EXPLORER XLT

EXPLORER 4/4 EDDIE BAUER. EASTER DRIVING DOWN HIGHWAY SMOKE CAME FROM FRONT OF VEHICLE. DEALER ADVISED THAT GEARS HAD BURNED OUT AND REPAIRED. TRANSMISSION WENT OUT AGAIN AND WAS REBUILT. FLUID WAS THROWN OUT ON TO THE HIGHWAY. ON THIRD FAILURE TRANSMISSION WAS REPLACED. ON SATURDAY THIS WEEK TRANSMISSION WENT OUT AGAIN PUNTA GORED FLORIDA AND IS CURRENTLY AT THE DEALER FOR REPAIR. *AK

WHILE DRIVING VEHICLE MAKES A CLANKING NOISE. THE VEHICLE TAKES UP TO 2-5 SECONDS UPON CHANGING GEARS TO REVERSE. GOING UP HILL IT WILL DOWN SHIFT VERY HARD AS IF THE FLOOR BOARD IS BEING KNOCKED OUT. THE DIFFERENTIAL, AND REAR END WERE REPLACED. *AK

ON 12-27-04 OUR 2000 FORD EXPLORER STARTED TO SHIFT POORLY AND THE OVER DRIVE LIGHT STAYED ON, THE LIGHT SHOWS THE CAR WILL NOT GO INTO OVER-DRIVE. I TOOK THE EXPLORER TO THE REPAIR SHOP AND WAS TOLD THE TRANS. HAD A CRACK IN THE DRUM IN THE VALVE BODY OF THE TRANS. VEHICLE WAS REPAIRED COST 2229.62 VEHICLE ONLY HAS 56,000 MILES. I LOOKED ON THE NET AND FOUND MANY COMPLAINTS WITH THE SAME PROBLEM TWO PEOPLE SAID IT OCCURRED TWICE SAME PROBLEM. TO ME IT SOUNDS LIKE A MAJOR PROBLEM WITH THE 2000 EXPLORER MY WIFE DRIVES THIS VEHICLE VERY CAREFULLY NEVER DOING ANYTHING BUT GOING TO WORK OR GOING GROCERY SHOPPING. I AM VERY MAD I THINK FORD IS MAKING A LOT OF JUNK THIS TRANNY FOR ONE. MAYBE FORD SHOULD HAVE A RECALL ON THIS TRANNY. *JB

WHEN PLACING THE VEHICLE IN REVERSE IT WILL NOT MOVE. CONSUMER HAS TO FLOOR THE ACCELERATOR ALL THE WAY DOWN BEFORE IT WILL MOVE.*AK

PURCHASED EXPLORER XLT WITH AUTOMATIC TRANSMISSION. REPEATED PROBLEMS HOLDING GEARS, LACK OF POWER. TWICE WAS BROUGHT TO DEALER FOR DIAGNOSTICS, WHICH WERE INCONCLUSIVE. PROBLEM CONTINUED AND EVENTUALLY TRANSMISSION WAS REPLACED BY DEALER. NO PROBLEMS FOR FIRST EIGHT MONTHS WITH THE NEW TRANSMISSION, BUT NOW WHEN TRAVELLING AT HIGH SPEEDS, THE OVERDRIVE DIS-ENGAGES CAUSING A LOSS OF POWER. UPON RE-START OF CAR, PROBLEM SUBSIDES. THE CAR WAS EXAMINED AT THE DEALER TWO MORE TIMES, BUT THEY WERE UNABLE TO REPLICATE THE FAILURE AND NO WORK HAS BEEN DONE.*AK

PROBLEMS WITH TRANSMISSION ON 2000 FORD EXPLORER.*MR COMPONENT'S WITHIN THE TRANSMISSION HAD TO BE REPLACED AT 43000 MILES. THIS IS THE SECOND FORD EXPLORER THE CONSUMER HAS OWNED WITH TRANSMISSION PROBLEMS. THE CONSUMER SEEKS SOME FINANCIAL ASSISTANCE. *NM

WHILE TEST DRIVING THE VEHICLE CONSUMER SAW A BLINKING OVER DRIVE LIGHT ON DASH BOARD. VEHICLE WAS TAKEN TO ANOTHER DEALER, WHO FOUND THAT THE TRANSMISSION NEEDED TO BE REPLACED. *AK

ON THE 27TH OF MARCH IN 2004, MY 2000 FORD EXPLORER TRANSMISSION WENT OUT IN CHICAGO. THE VEHICLE MALFUNCTIONED WHILE STOPPED AT A STOP LIGHT. THE CAR THEN WOULD NOT MOVE. THE VEHICLE DOES HAVE 59,000 MILES ON IT. WHEN I MOVED THE VEHICLE BACK TO MY HOMETOWN VIA MY OWN HAULING CAPABILITES, THE DEALERSHIP WHERE THE CAR HAS BEEN SERVICED SINCE THE TIME OF PURCHASE, REFUSED TO HELP ME WITH ANY REPAIRS EVEN THOUGH IT HAD BEEN IN THEIR SHOP ONLY FIVE DAYS BEFORE THE TRANSMISSION WENT OUT. WHEN I ASKED THEM WHAT THEY SUGGESTED, THEY INFORMED ME THAT I NEEDED TO CONTACT FORD MYSELF AND START TALKING WITH THEM. AFTER TALKING WITH FORD SEVERAL TIMES I REALIZED TAHT I WAS NO WHERE. THEY REFUSED TO HELP AND DID ABSOLUTELY NOTHING TO MAKE ME SATISFIED. I HAVE RECEIVED NO ASSISTANCE WHATSO EVER FROM THEM. IA M PERSOANLLY AWARE THAT...

WHILE SHIFTING GEARS VEHICLE JERKED. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE TRANSMISSION NEEDED TO BE REPLACED DUE TO WORN-OUT PARTS.*AK

TRANSMISSION FAILED PREMATURELY. TRANSMISSION WAS REPLACED THREE TIMES. *AK

2000 FORD EXPLORER TRANSMISSION SLIPPING 2ND AND 3RD TO OVERDRIVE. OD KICKS OFF & WILL NOT RESET. DEALER CHARGED US FOR REPLACEMENT OF "SEPARATOR PLATE" AND "VALVE BODY". GASKET MATERIAL FOUND LODGED IN VALVE BODY BY DEALER. THIS IS A FORD DESIGN FLAW, BUT WE HAD TO PAY OVER $900 TO GET IT FIXED! VEHICLE HAS ONLY 66,000 MILES ON IT.*AK

INDEPENDENT SHOP REPLACED TWICE THE AUTOMATIC TRANSMISSION. DEALER NOTIFIED. *AK

WHILE DRIVING VEHICLE JERKS WHEN AUTOMATICALLY SHIFTING GEARS. DEALER STATED THAT AUTOMATIC TRANSMISSION NEEDED A NEW VALVE KIT. *AK

WHILE CAR IS SHUT OFF AND IN PARK, AND WITHOUT WARNING VEHICLE WOULD POP OUT OF GEAR INTO REVERSE. CONSUMER HAD BEEN TO THE DEALERSHIP ON TWO SEPARATE OCCASIONS, BUT PROBLEM STILL OCCURRING. *AK

ONE YEAR AGO I STARTED MY CAR AND PRESSED ON THE GAS AND IT WOULDN'T GO. THE DEALERSHIP CORRECTED THE PROBLEM UNDER MY WARRANTY. IN JULY 2003, MY EXPLORER BEGAN SLIPPING BETWEEN 2ND AND 3RD GEAR. TOOK TO DEALERSHIP AND THEY STATED THAT BY REPLACING THE GASKETS THIS SEEMS TO CORRECT THIS PROBLEM IN OTHER FORD EXPLORER VEHICLES. THE COST WAS $500. REPLACING THE GASKETS DID NOT CORRECT THE PROBLEM ,AND THE DEALER SAID THAT I NEEDED A NEW TRANSMISSION. THEY ALSO STATED THAT MY CAR WAS NO LONGER COVERED BY A WARRANTY. I HAD 41,000 MILES AND THE WARRANTY ENDED AT 36,000. I CONTACTED FORD'S CUSTOMER SERVICE AND THEY SAID THAT IT WAS MY RESPONSIBILITY TO FIX SINCE MY WARRANTY ENDED. THEY ALSO SAID THAT THERE IS NO RECALLS. MY VEHICLE BEGAN SLIPPING BETWEEN 1ST AND 2ND AND 2ND AND 3RD. I TOOK MY EXPLORER TO AAMCO TRANSMISSIONS KNOWING...