2000 FORD EXPLORER Engine And Engine Cooling Problems

See attached document for complaint.

2000 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO RECALL STATES ENGINE RUNNING WITHOUT IGNITION KEY COULD START A FIRE. CONSUMER STATES THOUGHT DEALERSHIP REPAIRED RECALL PROBLEMS. VEHICLE EXPLODED SEVEN MINUTES AFTER CONSUMER EXISTS VEHICLE. *SMD

TIMING CHAIN RATTLES. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPLORER. THE CONTACT WAS DRIVING 35 MPH WHEN SMOKE EMITTED FROM THE REAR END OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND NOTICED FLAMES COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS DESTROYED. THE POLICE AND THE FIRE DEPARTMENT WERE CONTACTED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 179,000.

SPARKPLUG SUPER-HEATED AND MELTED LONGITUDINALLY DESTROYING THE OUTERMOST SPARKPLUG THREADS (7 THROUGH THE SEATING SURFACE OF THE SPARK PLUG). INNER MOST THREADS, THE ONES DEEPEST INTO THE HEAD WERE NOT DAMAGED. A SECOND PLUG WAS INSTALLED ALONG WITH A NEW SPARK PLUG WIRE AND WITHIN 20 MILES, THE SPARKPLUG WAS AGAIN MELTED BEYOND SALVAGE AND THE NEW WIRE BURNED UP. DUE TO THE DESTRUCTION OF THE SPARKPLUG, IT WAS ABLE TO BE REMOVED WITHOUT TOOLS AS THERE WERE NO THREADS REMAINING IN THE CYLINDER HEAD. FORTUNATELY THE FIRE DAMAGE (LIKELY FROM THE SPARK OF THE PLUG) WAS LIMITED ONLY TO DAMAGING THE SPARKPLUG AND THE SPARK PLUG WIRE LABLED #3. *TT

THIS IS TO REPORT A FIRE IN A 2000 FORD EXPLORER: ON FRIDAY, 25 NOV 11, 5 ADULTS (MY HUSBAND, 2 SONS, DAUGHTER-IN LAW, AND MYSELF) AND 2 DOGS, LEFT BETHLEHEM PA FOR OUR FAMILY CHRISTMAS TRIP IN OUR 2000 FORD EXPLORER, PULLING A UTILITY TRAILER. THE INTENT OF THE TRIP WAS TO START AT A CHRISTMAS TREE FARM, CUT DOWN 3 CHRISTMAS TREES, HAUL THEM IN THE TRAILER AND CONTINUE WITH SEVERAL OTHER CHRISTMAS RELATED TRADITIONAL STOPS. MY HUSBAND, DROVE APPROXIMATELY 45 MINUTES NORTH TO BISSELS CHRISTMAS TREE HILL IN LEHIGHTON, PA. HE DID NOT USE CRUISE CONTROL BECAUSE WE WERE PULLING THE TRAILER. THE TRIP WAS FINE WITH ABSOLUTELY NO INDICATIONS THAT ANYTHING WAS WRONG WITH THE VEHICLE. IT ALSO HAD NOT HAD ANY SERVICE DONE TO IT RECENTLY (A QUESTION FREQUENTLY ASKED TO US). HE PARKED THE VEHICLE ALONG AN EMBANKMENT AT THE TREE FARM AND WE...

MY FORD EXPLORER CAUGHT ON FIRE. ALL I SAW WAS CLOUD OF SMOKE. THEN PEOPLE STARTED YELLING AND BLOWING THEIR HORN AT ME, THE UNBELIEVABLE, THAT MY CAR WAS ON FIRE. *TR

SPARK PLUG CLOSEST TO DRIVER DOES NOT SEAT AND COMES OUT. NOT A FULL BLOW OUT OF IT, BUT THE PLUG FEELS REAL LOOSE. I TRIED NEW PLUG BUT IT STILL FEELS LOOSE. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 30 MPH, ANOTHER DRIVER INFORMED THE CONTACT THAT THERE WERE FLAMES UNDERNEATH THE VEHICLE. SHE PULLED OVER ONTO THE SIDE OF THE ROAD AND NOTICED FLAMES UNDERNEATH THE VEHICLE AND THE HOOD. THE CONTACT QUICKLY REMOVED HER CHILDREN AND CHILD SEAT FROM THE VEHICLE. IN A MATTER OF SECONDS, THE HOOD BURST INTO FLAMES. THE VEHICLE WAS DESTROYED AND TOWED TO THE JUNKYARD. THE INSURANCE COMPANY WILL NOT INVESTIGATE THE FAILURE BECAUSE THE VEHICLE DID NOT HAVE COMPLETE COVERAGE. THE MIAMI MIDWAY POLICE DEPARTMENT FILED REPORT NUMBER PPOC9A02C02188. THE CURRENT AND FAILURE MILEAGES WERE 96,000.

AT 166,000 HEAD GASKET BLEW PLUS THERE WERE OTHER ENGINE PROBLEMS. REPLACED WITH ANOTHER ENGINE. NOW TRANSMISSION IS GOING OUT. IT WILL GO INTO REVERSE FINE BUT WILL GO INTO DRIVE WITH PROBLEMS. IF VEHICLE IS COLD IT WILL GO INTO DRIVE FASTER THAN WHEN IT IS WARMED UP. AT WARM TEMP IT MAY TAKE SEVERAL TRIES OF SHIFTING FROM PARK BACK TO DRIVE OR WAITING SEVERAL MINUTES FOR IT TO DROP INTO DRIVE AFTER SHIFTING OUT OF PARK. HAVE ONLY OWNED THIS VEHICLE LESS THAN 2 YEARS. *TR

TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHEN THE VEHICLE IS STARTED, THE ENGINE MAKES A LOUD RATTLING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY DISCOVERED THAT THE TIMING BELT WAS OFFLINE. THE DEALER INFORMED THE CONTACT THAT THEY WERE CONDUCTING A FREE REPAIR FOR THIS FAILURE; HOWEVER, THE TIME HAD ALREADY EXPIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WERE NO LONGER HONORING THE REPAIR. THE FAILURE MILEAGE WAS 130,000. UPDATED 06/17/08. *LJ UPDATED 06/17/08

TL*THE CONTACT OWNS A 2000 FORD EXPLORER. THE FUEL LINE RUSTED AND DEVELOPED TINY PIN HOLES AND CRACKS. THE ENGINE LIGHT ILLUMINATED ALSO. THE CONTACT WAS INFORMED THAT THE COST WOULD BE BETWEEN $400 AND $500 TO REMOVE THE TANK. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 34,200 AND FAILURE MILEAGE WAS 34,100.

DT*: THE CONTACT STATED THE ENGINE RATTLED AND THE VEHICLE NEEDED THE ENGINE BOLTS TIGHTENED TO RESOLVE THE ISSUE. THE VEHICLE HAD BEEN TO A PRIVATE MECHANIC BUT NOT A SERVICE DEALER.

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN FRONT OF THE RESIDENCE, A NOISE WAS HEARD, THEN FIRE WAS NOTICED COMING FROM UNDER THE HOOD. THE CONTACT CALLED THE FIRE DEPARTMENT WHO EXTINGUISHED THE FIRE AND REPORTED THE FIRE AS ELECTRICAL FAILURE FROM THE SPEED CONTROL SYSTEM. THE CONTACT TOOK PICTURES OF THE CHARRED VEHICLE. THE INSURANCE COMPANY DEEMED THE VEHICLE A TOTAL LOSS. THE DEALERSHIP WAS CONTACTED BUT NEVER RETURNED THE CALL. THE MANUFACTURER WAS ALSO CONTACTED WHO INFORMED HER THE VEHICLE WAS NOT INCLUDED IN ANY RECALL PERTAINING TO THE SPEED CONTROL SYSTEM DUE TO THE VIN. THE FIRE DEPARTMENT HAD NOT DETERMINED WHAT CAUSED THE FIRE, HOWEVER, THE CONSUMER HAD READ ABOUT REPORTS WHERE VEHICLE WERE CATCHING ON FIRE DUE TO FAULTY CRUISE CONTROL SWITCHES. UPDATED 12/13/06. *JB UPDATED 04/03/07. *JB

OVER THE PAST THREE TO FOUR MONTHS MY 2000 FORD EXPLORER (6 CYLINDER W/ SOHC ENGINE) HAS DEVELOPED A PROBLEM WITH THE ENGINE. THE PROBLEM OCCURS ON AN INTERMITTENT BASIS. AT TIMES THE ENGINE WILL NOT START. WHEN IT DOES START IT WILL NOT IDLE AND DIES UNLESS THE RPM'S ARE MANUALLY HELD AT A HIGH ENOUGH LEVEL TO ALLOW THE ENGINE TO RUN. WHEN BRAKING AT ANY SPEED THE ENGINE WILL DIE WHEN THE AUTOMATIC TRANSMISSION SHIFTS FROM A HIGHER GEAR TO A LOWER GEAR ALLOWING THE RPM'S TO FALL BETWEEN SHIFTS. THIS REQUIRES SHIFTING THE CAR INTO NEUTRAL TO RE-START WITH A LOSS OF ALL POWER STEERING AND BRAKING FUNCTIONS. A FIRST IT SEEMED THE PROBLEM ONLY OCCURRED AFTER THE CAR WAS PARKED OUTSIDE DURING HOT DAYS. NOW THE PROBLEM OCCURS AT DIFFERENT TIMES AND DIFFERENT WEATHER CONDITIONS. THE CAR RECENTLY HAD THE FUEL SYSTEM SERVICED (ALONG WITH...

I HAVE A 2000 FORD EXPLORER WITH 46,000 MILES ON IT. I NOTICED A DELAY GOING INTO FIRST GEAR ON TRANSMISSION. TOOK CAR TO DEALER AND THEY REPAIRED TRANSMISSION TO THE COST OF $2900. I AM 61 YEARS OLD AND DRIVE VERY LITTLE. I EXPECTED AT LEAST 100,000 MILES FROM THIS VEHICLE BEFORE MAJOR PROBLEMS. DEALER FOUND ELC TRANS DIAGNOSTIC FOUND INTERNAL WEAR. FOUND INTER AND OD SERVO PISTON HARD 2-3 SHIFT VALVE STICKING. R/R VALVE BODY. PISTONS OVERHAULED AND FLUSHED COOLER LINES .REPLACED CONTROL ASSEMBLY,GASKET, PISTON AND ROD, SCREEN ASSEMBLY, CONVERTER ASSEMBLY & FLUID. *JB

HEAD GASKET DEFECTIVE. COOLANT IS MIXING WITH THE OIL. $2000 REPAIR JOB. *JB

2000 FORD EXPLORER MOTOR SKIPS AND RACES WHEN STARTED UP.***NO ANSWER REQUIRED***. *MR THE VEHICLE RAN ROUGH AND THE GAS MILEAGE WAS POOR. THE VEHICLE WAS TAKEN TOT HE DEALER. THE DEALER CLEANED THE MANIFOLD BUT THIS DID NOT RECTIFY THE PROBLEM. THE VEHICLE WAS TAKEN BACK TO AND INDEPENDENT MECHANIC WHO RAN A DIAGNOSTIC TEST. THE TEST CONCLUDED THAT THE FUEL PRESSURE REGULATOR NEEDED TO BE REPLACED AND THE MANIFOLD NEEDED TO BE REMOVED AND CLEANED. IT APPEARED THAT THE DEALER NEVER CLEANED THE MANIFOLD AS THEY STATED. *NM

ON 20 MAR 2005 WHILE DRIVING MY 2000 FORD EXPLORER THE CHECK ENGINE LIGHT CAME ON. I PULLED TO THE SIDE TO CHECK THE PROBLEMS, EVERYTHING SEEMED NORMAL EXCEPT IT WAS IDLING ROUGH. I CALLED THE DEALER THE NEXT DAY TO BRING IT IN. I BROUGHT IT TO THE FORD DEALER ON 21 MAR 2005. I WAS TOLD THAT AFTERNOON, THAT IT WAS THE CYLINDER HEAD GASKET. I CALLED THE DEALER ON 22 MAR TO CHECK AND SEE WHEN I COULD PICK IT UP AND WAS TOLD THAT IT WOULD NOT BE READY BECAUSE THEY FOUND THE CYLINDER HEAD HAD A CRACK. I CALLED ON 23 MAR TO CHECK AND WAS TOLD BOTH CYLINDER HEADS WERE CRACKED AND THERE IS A POSSIBILITY THAT THE ENGINE MAY HAVE TO BE REPLACED. I WAS ALSO TOLD THAT THEY WERE WAITING FOR AN ADJUSTER FROM FORD TO MAKE A DETERMINATION TO SEE IF...

CRANKS HAFT CRACKED AND CAUSED ENGINE FAILURE. *AK

THE CONSUMER WAS DRIVING WHEN SHE HEARD A LOUD NOISE WHILE TURNING INTO HER DRIVEWAY. THE VEHICLE WAS SMOKING AND CAUGHT ON FIRE. THE FIRE WAS PUT OUT WITH A GARDEN HOSE. THE VEHICLE WAS TOWED TO THE DEALER. THE WHEEL BEARINGS WERE FOUND TO BE DEFECTIVE. ON THE NEXT INCIDENT, THE CONSUMER TOOK THE VEHICLE TO THE MECHANIC TO HAVE THE FRONT END ALIGNED, WHEN THE VEHICLE WAS INSPECTED THE BALL JOINT FELL OFF INTO THE MECHANIC'S HAND JULY 8, 2004. *LA ALL OF THE PROBLEMS HAD BEEN ON THE DRIVERS SIDE. THERE WERE ALSO PROBLEMS WITH THE ENGINE. *SC *JB

CAR WOULD NOT START WITHOUT PRESSING GAS PEDAL TO THE FLOOR. ONCE STARTED HAD TO KEEP MY FOOT ON THE GAS TO PREVENT IT FROM STALLING. *LA

WHEN STARTING VEHICLE AFTER FUELING IT BEGAN TO HESITATE/STALL. *AK

THE FIRST TIME I HAD A PROBLEM IS WHEN MY CAR WOULDN?T START ON MY WAY TO WORK, AND THE CHECK ENGINE LIGHT CAME ON. IT WAS A FEW DAYS AFTER I GOTTEN IT. SO I TOOK IT IN AND THEY SAID THEY CHECKED THE ENGINE AND TURNED OFF THE LIGHT. THEY TOLD ME I SHOULD HAVE IT SERVICED. SO I DID. THE OTHER TIME I TOOK IT IN, IT HAD DIED ON ME WHILE DRIVING DOWN MY UNCLES APARTMENT HILL. THEY SAID THEY WERE GETTING SOME WEIRD CODES FROM THE COMPUTER OR SOMETHING. THEY SAID THEY WOULD GET ME AN APPOINTMENT WITH FORD. THEN THEY CALL LATER THAT DAY AND TELL ME THEY WILL BRING SOMEONE IN TO LOOK AT THE CAR WHO SPECIALIZES IN FORD MODELS. I NEEDED A CAR SO I HAD TO RENT A CAR WHILE THEY HAD MY CAR IN THE SHOP SO THAT I...

COOLANT LEAKED INTO THE OIL. *PH THE CONSUMER WAS TOLD THE INTAKE MANIFOLD FAILED WHICH CAUSED THE COOLANT TO LEAK. THE ENTIRE ENGINE HAD TO BE REPLACED. *JB

THE FIRESTONE TIRES WERE REPLACED WITH GOODYEAR TIRES DUE TO HUMMING NOISES AND RECALL#00T005000. THE ENGINE MADE NOISE, VIBRATED, OVERHEATED AND WOULD NOT RESPOND UPON ACCELERATION. THE VEHICLES FAULTY SHOCKS CAUSED NOISE WHEN DRIVING OVER BUMPS IN THE ROAD, VIBRATION AND NOISE IN THE FRONT END. THE ABS WARNING LIGHT ILLUMINATED. THE DRIVERS SIDE WINDOW WAS OFF TRACK, WOULD NOT GO UP ALL THE WAY AND WENT UP UNEVENLY. THE STARTER BECAME STUCK MADE SCRAPING SOUNDS. THE CONSUMER REQUESTED A FULL REFUND OF THE PURCHASE PRICE IN ACCORDANCE TO THE LEMON LAW. *MR *SCC *NLM

I HAVE A LETTER I SENT TO FORD MOTOR CORPORATION AND WILL ATTACH TO THIS E-MAIL

CONSUMER STATES WHEN STARTING THE VEHICLE THE ENGINE WOULD MAKE A TICKING SOUND. CONSUMER STATES ENGINE IS NO LONGER ANY GOOD. DEALER NOTIFIED. TS

WHEN STARTING VEHICLE TEMP GAUGE DOES NOT READ, CHECK GAUGE & ENGINE LIGHT COME ON. MUST WAIT AT LEAST 5 MINS FOR TEMP TO COME UP. REPORTED TO FMC THEY STATE NORMAL MUST WAIT FOR WARM UP BEFORE DRIVING.