2018 FORD ECOSPORT Engine Problems

Low oil light came on. Drove to dealer and they said need new engine. Quoted $9k

The contact owns a 2018 Ford EcoSport. The contact stated while driving 40 MPH, the vehicle started making a rattling sound. No warning lights were illuminated. The vehicle was taken to the residence. The contact stated that the vehicle then failed to restart. The vehicle was towed to the dealer and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and a case was opened. The failure mileage was 63,500.

While driving, the oil warning light came on. I took the car to Firestone where they said the oil was very black, but it had been less than 3,000 miles since it was changed last. They changed the oil and the light went off, but after leaving, I made it barely a quarter of a mile when the engine light came on and the car began jerking. I was able to continue driving at a very low speed to pull over safely. After parking, the car shut down and would not start back up. I had to get the car towed to the nearest Ford dealership. They diagnosed the car with an engine failure due to excessive metal debris found in the oil pan as well as in the valve train assembly. Apparently this is a known issue with the EcoSport that I was unaware of until this incident occurred....

Oil pump belt failed and caused engine to be bad, per independent service center. I have copy of the invoice, but it would not let me upload. Car drove like normal, then one day got in the car and "engine oil pressure low" message came on and the check engine light came on. Drove a couple blocks to get gas, car broke down on the way back from gas station (less than half a mile) all warning lights on dash came on and engine shut off. Towed to repair shop, estimated repair cost (engine ruined) is $6,419

The contact owns a 2018 Ford EcoSport. The contact stated that when the vehicle was started, the vehicle was idling unusually loud and shaking. The vehicle was taken to an independent mechanic where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 53,000.

The contact owns a 2018 Ford EcoSport. The contact stated while driving 40 MPH, the low oil level warning light illuminated, and the engine started knocking. The vehicle was taken to the dealer to be diagnosed; however, the vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 76,000.

1. The oil pump is belt driven and located inside the engine. The belt frayed and clogged the oil pump leading to low oil pressure. The car stalled on the interstate and is currently available for inspection at an out of state dealership. 2. The car gave no previous warning before abruptly decreasing in speed while we were driving on the interstate. 3. There have been other incidents, an employee at the dealer insinuated there might be a recall as this issue has been well reported and is under investigation. 4. The dealership has inspected the vehicle and said the engine was damaged due to an oil pump failure. They are requesting $6,500 dollars to repair the engine as it’s 5,000 miles over their powertrain warranty. The car is currently out of state so we had to rent a car to get home from visiting family for Christmas. 5. The...

Engine failed at 61500 miles. It is hot garbage.

Engine failed at 61500, regular oil changes, this vehicle is trash.

The oil light kept coming on over the course of a couple weeks. We changed the oil, and it seem to be running better for a few hours. Then the car started beeping at the driver, the acceleration was effected . It was making clicking noises and lots of warning signs. The car would barely move forward and the driver had to pull off into a neighborhood. We then have the car towed to the Ford dealership where they told us us the engine would need to be replaced due to the timing belt fair and oil pressure issues.

The contact owns a 2018 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate immediately. The transmission warning light was illuminated. The check engine warning light was later illuminated. The vehicle was taken to the dealer, where an oil pressure test was performed, and determined that the long block assembly, turbocharger, and engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was 65,428.

While driving on the interstate going 70mph, my Ford EcoSport's Engine oil pump light illuminated. Shortly after, the car began to slow down even though I was attempting to accelerate. This put me at a safety danger due to being in front of another vehicle who was also going around the same speed as I was. I was fortunate enough to be able to get off the road without getting in danger. When taken to Ford, they indicated that there was an issue with the motor and that it would need to be replaced.

After receiving an oil change the day before and getting the “all good,” I set out for a cross state road trip to see family. Less than halfway through our drive, about 400 miles in, my 2018 Ford EcoSport shut down on the side of the highway. I could not get my vehicle to turn on or move. I was given a warning on my dash that stated I needed service on my vehicle and less than ten seconds later the vehicle would not turn on. Considering I was on the highway, I was more than lucky that I was able to pull over in time. We sat in the vehicle for four hours waiting for a ($400) tow - when the tow got there he spent an hour getting the vehicle onto skates. The engine is locked and my wheels will not turn. I towed it to the nearest...

I have 69,800 miles on my car that is not even 5 years old. When driving to work this morning, I receiving an alert on my dashboard saying “low engine oil pressure”. I have heard about this issue and pulled over at a gas station to get my car towed to a Ford dealership. It is going to cost me about $8,000 to get a brand new engine in my fairly new car that is in great condition. This issue is a hazard to all owners and drivers on the road.

My 2018 Ford Ecosport issues began at 75,048 miles. I was driving on Highway 10 in North Ridgeville, Ohio attempting to get to the speed of 65 miles per hour when my Ecosport failed to accelerate. The engine light indicating oil came on. My life flashed before my eyes when other cars on the road failed to manuver around me, almost rear ending me off the highway. I had my Ecosport towed to a Ford dealership after this incident. I was told the oil pump and the oil pump belt had malfunctioned, which resulted in engine damage. Autonation Ford in Westlake, Ohio estimated an engine repair at approximately $7,000.

I was driving home on Christmas Eve with my daughter when my Check Engine light came on. Then the Low Oil Pressure alarm started going off and the car was driving sluggish. Any time I used the accelerator, the alarm came on. I parked the car and had it towed to an independent shop. They advised it was the oil pump and that the engine was not receiving any oil. Upon inspection, there was metal on metal in the engine. Now they have advised that I will need a new engine.

Engine failure due to known 2018 Ford Ecosport issue: While driving down the road oil pressure pump light flashed on, car slowed down to 30mph and started a ticking noise. Diagnosis: oil pump belt tensioner failed causing no oil pressure subsequently completely destroying the engine, turbo charger and vacuum pump. The Service adviser stated that the Ford company knows the problem with the oil pump tensioner exists, but will not acknowledge the problem. My cost for replacement, repairs and labor is $6,209.08 and not having a vehicle to drive as a mother of two I cannot afford these unexpected expenses on a well maintained vehicle.

I had to have my 2018 Ford ecosport towed to the Ford dealership after the low engine oil pressure light came on and wouldn't start. Ford dealership stated it would be 6700 to even look at it and that was nothing they could do engine miles are 89000 and will not start

Oil pump failure.

Engine oil pump failed and didn't give any warning lights until the engine was knocking from the lack of oil. The motor only had 51,216 miles on it. I've changed the oil at regular intervals and never drive it low of oil. Ford wouldn’t do anything for me. So I had to pay $6300 out of pocket.

My car first came on with a check engine light at 53,000 miles. Got it coded that the car prompted and it was reading P015B which indicates bank 1 sensor 1 of O2 sensors experiencing a lean to rich response issue. I scheduled an appointment with a mechanic to have it looked at. It drove fine for 24 hours. The next day my car started to run rough and the oil light came on as well with an error message reporting low oil pressure. I recently got an oil change done a week prior. I did take the car back to where I got the oil change. The company did not find any issues with the oil change but proceeded to change it anyway again. They advised me at that point to not drive the car till diagnosed at a dealership. At this point I have had the car towed...

The oil pump went out and ruined the motor. The low engine oil pressure alarm didn't go off until after the car quit. Had it towed to the dealership. They've had it for 2 months. Waiting on them to call for me to pick it up.

Car went into limp mode then shut off while driving. Towed to mechanic, who tried to fix the codes that popped up. After fixing the codes, still didn’t turn on. Towed it to ford, it’s still there. They have told me it’s the oil pump and that it fell off. They have also said it just happens with these cars. They are waiting on one last test to confirm, but have told me I need a new engine, and there was nothing I could do to prevent this, that I was lucky to get to 72k miles, as other cars oil pumps fell off at 50k.

While driving, a warning came on my dashboard that I was unfamiliar with as it had never come up before. It informed me my oil pressure was low. I called someone familiar with cars and they told me I may need an oil change. As there were no gas stations near where I exited, I continued to my destination another ten minutes from when the warning came on during which my car began making a rattling/grinding sound. Additionally, my became nearly impossible to accelerate and took about 30 seconds longer than it usually would to reach a specific speed. I parked, and when someone arrived with oil for me, we discovered the oil level was not low based on the dip stick nor was it leaking. This is when we began to suspect that the oil pump had failed. Upon further investigation, this seems to be a common issue with...

I have a 2018 Ford economy sport. I frequently took good care of this car . I changed the oil regularly. A out 3 weeks ago I was driving my car and the oil pressure light appeared on my car after I just got it fixed. Shortly thereafter the engine went out and left me stranded with no car . I had to come up with $7000 to replace install new engine. I tried to get warranty dept with Ford to fix my car the decl8ned over reasons that have nothing to do with the car engine going. I called the car dealership Matthew's Motors in Wilmington North Carolina and they offered no help . Prior to this fiasco one of my coils blew in the engine. I was stranded 3 days in Virginia. I replaced the coils put new sparkplugs and parts over 600 in repairs. The car ran...

Was driving down two lane road and all of a sudden oil pressure light came on car started shaking and I was close by a truck stop, pulled in and checked oil, it was fine but the engine seemed real hot, so I knew something was really bad. So called my mother and she came and picked me up after I contacted tow truck to have it towed to Harrisburg Illinois at Jim Hayes where I purchased it on 03/15/2021 and paid the $2,424.00 extended warranty. Yesterday on 12/14/2023 we drove to dealer and was informed it needed new motor. And that we would be refunded the 250.00 dollar tow bill and will only have to pay the 100.00 deductible to have the new motor put in. Plus if they don`t have a loner car come in today 12/15/2023 the warranty will rent us a vehicle and have it delivered...

My car is at Ford getting a new engine due to a faulty oil pump. I know there’s a class action suit against Ford for this same issue. My car is a 2018 Ford EcoSport with 22,000 miles. This shouldn’t happen with only 22,000. This is costing me $8600.00 which is crazy.

I have purchased this vehicle in June 2019 and the engine went out while I was driving out of town on 07/02/2021; I have had to replace the engine and the turbo, I had to pay a tow of $340 to the nearest Ford dealership (Marietta, Ga-Gary Service Advisor.) They told me the belt jumped the internal valve timing in the engine. I had to call FORD CORPORATE to beg someone to help me replace the engine because I was at 60,101 miles and the warranty only covered engine repair up to 60K. I was able to get a case manager John Ashley (866-631-3788 ext 79212) and she was able to get ford to cover majority of the $6800 cost of the repairs which I had to wait till November 12 to pick up my car because they said since it was covid the engines and turbos were on back...

In December of 2021 my vehicle started to feel like it was "trying to die" for lack of a better words. On December 18th I took it to Firestone in Tulsa, Ok to have it check and the mechanic at the time told me to take it directly to Bill Knight Ford in Tulsa, Ok where it was purchased. On the way there the vehicle completely shut down while on the highway with every warning light coming on. It was left in a parking lot that night and was towed to Bill Knight the following Monday. They said there was a manufacturing issue with the engine and that it was known to Ford and that a new engine would need to be put in the vehicle. Not sure if this truly qualifies but was told there is a lawsuit pending because so many people have encountered this problem.

Engine failed without ever showing a check engine light or any other warning. One day there was a rattle coming from the engine, so we took the car to the ford dealership. Then they told us that the oil pump failed and that the car needed a new engine.

The vehicle had an intense loss of power and slowed down to a few miles per hour even with the gas pedal pushed down all the way. This put us in harms way until we could get out of the way of moving traffic. In a parking lot, the vehicle stopped and would not start. The engine light came on briefly before the event. The vehicle was towed to the dealer. The service department indicated that the engine was bad and a new one would be needed. The vehicle was held by the service department for about a month until another engine became available. The failed engine was then replaced. The service documentation indicated that there was debris in the failed engine. Due to the extended warranty in place, only the $100 deductible fee was paid. While we are grateful that we did not have to pay the full price...

I was doing 60 mph on a back road when I had sudden loss of engine power and the oil pump light came on. Car is now in the shop and cannot be driven due to oil pump failure and needing a whole new engine. The oil pump light was ONLY flickering and would not STAY ON the whole time until I had my check engine light come on and lost power. It has been inspected by Gallery Ford in Pekin, Illinois and I was told a new engine was required but they are on back order and no one new when they would get it in. They have a 2019 sitting on the lot for 7 months due to this same issue. This started happening on the freeway and it puts myself in the line of danger when people. When I am going slow or even stopped someone could...

My car’s “low engine oil pressure” light came on at the end of a long road trip. I immediately began getting off the highway and trying to exit. That’s when the car stopped accelerating and I coasted to a stop in a neighborhood right off the road. I drove for less than 3 minutes after the light came on. My car was towed and the mechanic at the dealership told me it was a problem with the engine and I had no oil. I called my insurance, assuming a large pothole I hit on the road trip caused damage. But the adjuster found no evidence of damage at all. It turns out, the engine’s oil pump belt was shredded due to a tensioner problem. I googled this issue in my model car and discovered that the NHTSA is apredatory investigating this problem across 2018-2021 Ecosports. This is extremely concerning bc...

October 10, 2023, vehicle was taking to dealership for oil leaks and check engine light. After inspection, the Mechanic replaced valve cover gaskets, new valve cover, injection o-rings, that was for oil leaks. Check engine light was for VMV valve, thermostat. Dealer had it for 4 days, mileage at 62,043. November 22, 2023, my elderly mom who I bought this car for was driving on a highway, lost complete engine while driving, completely stopped in the middle of the highway, the car is not drivable and suddenly stopped with no engine response to even drive it to the side. ON A HIGHWAY. She had to get people to push her off to the side of the road. Towed the vehicle to the dealer. The car has 63,265 miles and the mechanic has confirmed that the engine is completely defective due to no oil pressure in the car, oil pump wasn't...

I was on the way home from work when out of no where the engine light and a indicator saying low engine oil pressure came on I totally lost power driving on a highway and the car came to a stop. Mechanic told me it was the oil belt tensioner caused the engine failure and now i have to pay 4000 dollars on top of my monthly car and insurance company for a vehicle that just quite on me.

10/27/23 Driving and "Low Engine Oil Pressure Warning" came on. Pulled over as soon as I could. Husband loaded it up on a trailer the next morning to the Ford dealership. They called that afternoon to tell us that a NEW ENGINE is required!!!! It took until 11-24-23 and OVER $5,500 for a new engine to get my vehicle back! There is a 3 year warranty on the new engine, but no reassurance that this will not occur again. The vehicle had only 58,xxx miles on it.

11/19-While driving on interstate received "Low Engine Oil Pressure Warning" while trying to work through traffic to get off the interstate vehicle slowed from `65mph to `25mph would not accelerate and was almost rear ended and hit by other vehicles. Vehicle was towed to Ford dealer and was told that the Engine would need to be replaced. Research is showing a flaw in the Engine Oil pump design and many customers are reporting same issues. Repairs are estimated at $6,100 with No assurance from Parts Dept. at dealership that the replacement engine will have been updated and corrected this issue.

THIS HAS BEEN NOTHING BUT A BURDEN WITH THIS CAR. THE ENGINE HAS FAILED MULTIPLE TIMES IT HAS BEEN TAKEN TO FORD AND WAS FIXED MANY TIMES. IT IS AVAILABLE TO BE LOOKED AT ANYTIME. IT CAN'T BE DRIVEN, IT HAS BEEN PARKED IN MY DRIVE FOR MONTHS NOW. THE ENGINE HAS FAILED ON ME MULTIPLE TIMES WHILE DRIVING AND PUT ME AND MY FAMILY AT RISK OF INJURY. THIS ENGINE FAILURE HAS CAUSED ME TO RELY ON OTHER PEOPLE FOR TRANSPORTATION TO WORK AND OTHER MEDICAL APPOINTMENTS. THIS VEHICLE HAS ALSO HAD TO BE TOWED MULTIPLE TIMES AND PUSHED TO A SAFE LOCATION DUE TO THE ENGINE FAILING AND CAUSING MY CAR FROM GOING TOP SPEED TO 20MPH ON THE HIGHWAY. NO WARNING LAMPS WERE GIVEN TO ME AND THIS VEHICLE HAS BEEN INSPECTED AND TAKEN TO FORD MULTIPLE TIMES TO BE LOOKED AT AND INSPECTED. DOCUMENTATION CAN BE...

I bought my car brand new Ford ecosport. Car was running good until couple of weeks ago. My engine broke down in middle of high way 15 and 805 free way in California. Oil pressures which I tow the car to mechanic that night. The mechanic called me the next day and told me and said oil pump issues which led to break engine. I called and went to Ford dealer they won't work with me. My car is 74k miles which is they told is out warranty. My issue is the car has major mechanical issues. I didn't any warning signs before ford broke down. I would like to file complaint. So please let me know what I need to do . There is over 95 complaint with the same issue.

This model of the Ford Ecosport needs to be recalled due to a faulty engine. My engine had to be replaced at 70k miles because of a design flaw. As I was driving, the car indicated low oil pressure and stopped accelerating. The engine had to be completely replaced.

Our 2018 Ford EcoSport with less then 50,000 miles had an engine failure while driving on the highway. This was due to the loss of oil pressure. We were out of the warranty by just a few weeks and Ford provided no help or support. We found out that this was a common problem with the engine on this style car but again there was zero support or help from Ford. The old pressure light came on while on a road trip with my wife. Once the light came on the car stopped accelerating so we pulled off the highway and took or car to the nearest Ford Dealership. They told us the engine was destroyed and needed to be replaced. Again we were offered zero support or answers from Ford and we had no choice but to pay over $7,000 to get a new engine in a year old...

I bought my 2018 firs eco sport 3 months ago. Right after my 3rd car payment, the low oil pressure light came on. Took pictures of the dipstick, oil was good! Just had it changed , with receipt, 90% life left. Made it to miles down the road car made a little noise and stalled and would not start. Ford dealer had it Wednesday evening and on Monday they still have not touched my car! 202 complaints on this issues !

I just bought the car and a year later it started showing low engine oil and then the whole car stopped running in the middle of the road. The engine went out.

The engine failed at 57,000 miles due to an oil pump failure. There was no warning light or check engine light. I was on the freeway and the car started to shake I was able to get off the freeway but this could have ended badly if I was unable to control the car on the freeway. The car has been at the dealer for over five weeks now waiting on a replacement engine that I am responsible for paying for even though it was not my fault to the tune of $8,500. The engines are going out on several of these cars and they need to be recalled it is a huge burden of expense and also accidents that are happening even resulting in death.

The contact owns a 2018 Ford EcoSport. The contact stated that while driving at an undisclosed speed, the low-pressure oil warning light illuminated. The contact stated that the vehicle had received an oil change approximately five days prior to the failure. The contact was able to drive the vehicle to the local Midas where the contact was informed that the oil pump was not processing the engine oil. The contact was advised not to start the vehicle, and to have it towed to the dealer. The vehicle was towed to the dealer where it was diagnosed with an oil pump failure. The contact was informed that the engine, oil pump, wet belt, and turbo needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The manufacturer advised the contact that the warranty had expired and to report the...

I have had my vehicle's oil changes done regularly and have copies of those receipts. It only has 64,961 miles. While driving to work on 11/6/23 on a busy road my car gave me a "dangerously low oil pressure" warning light and I could hear a loud noise from my engine. The car behind me almost hit me as I began to slow; very glad I was not on the interstate yet. We had not had any problems with the engine before and have had no comments of concerns from mechanics during regular maintenance. We had it towed to the Ford dealership where I bought it, Steve Marsh in Milan, TN. They diagnosed the problem as being a failure of the oil pump belt and said I need a new engine that will cost $6,200. This belt is not due to be replaced until 150,000 miles per my owner's manual....

The contact's employer owns a 2018 Ford Ecosport. The contact stated that while his employee was driving at approximately 75 MPH, the oil pressure and check engine warning lights illuminated. The contact stated that the driver observed an abnormal sound coming from the engine compartment. The vehicle was steered to the side of the road and turned off. The vehicle was not able to be restarted. The vehicle was towed to a dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 35,000.

The contact owns a 2018 Ford Ecosport. The contact stated that while her husband was driving at approximately 60–65 MPH, the vehicle lost motive power and stalled. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was repaired, but the failure recurred. Two days prior to the failure, the vehicle had received a routine oil change and maintenance service at the dealer. The contact stated that while driving at approximately 30 MPH, the vehicle stalled. The wrench symbol was displayed. The Ford pass indicated there was a power train failure. The oil was changed prior to the failure. The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was contacted and stated there was no warranty coverage on the vehicle. No assistance was provided....

I am writing to you as I have many concerns about my Ford EcoSport. As I commute to my job or drive to pick up errands, my car suddenly stops. I would make a complete stop and I forget to press the Start/Stop button to disable it from shutting off the engine. This has happened several times and I have taken in my car before and all of the Ford dealerships and service workers have no idea of what the problem is or why it is doing this so frequently. I try to start my car and for some reason, it is not starting properly. It continues to make the sounds of it possibly starting and then it shuts off completely. This is the only vehicle that I have to commute with and do my daily errands. I am very concerned about this vehicle and how it is not a...

DRIVING DOWN ROAD WAY APPROX 35-40 MPH, SPEEDOMETER WENT UP TO 50MPH, DOWN TO 30MPH, ENGINE WAS SHAKING AND SOUNDED LIKE A LAWN MOWER, THEN ALL THE DASH LIGHTS CAME ON, OIL PRESSURE, CHANGE OIL, CHECK ENGINE, ABS, ALL LIGHTS, CAR DIED AND WILL NOT START.