2004 DODGE DURANGO Engine Problems

The contact owns a 2004 Dodge Durango. The contact stated that while his wife was driving 10 MPH and making a left turn in the rain, the vehicle shut off. There were no warning lights illuminated. While at a car wash, the vehicle shut off. The contact stated that the water was entering the engine compartment. The vehicle was taken to the local dealer, where an unknown diagnosis was provided. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was 115,000.

CAR WAS PARKED ON A THURSDAY, WAS RUNNING FINE WITH NO PROBLEMS. RAINED ALL WEEKEND. WENT TO START IT ON MONDAY MORNING, PRODUCED A HORRIBLE GRINDING NOISE AND WOULD NOT START. RESEARCH SHOWS THAT THE COWL HAS ALLOWED WATER TO LEAK UNDER THE HOOD AND PUDDLE ON THE MOTOR ALLOWING IT TO SEEP INTO THE INTAKE AND HYDROLOCK THE MOTOR. APPARENTLY THIS IS A VERY COMMON PROBLEM WITH THIS YEAR MAKE AND MODEL BUT NOTHING HAS BEEN DONE TO RESOLVE IT. NOW I AM WITHOUT A RUNNING VEHICLE AND CAN NOT AFFORD TO FIX IT OR REPLACE IT.

GOOD DAY I OWN A PRECIOUS 04 DODGE DURANGO I'VE BEEN MAINTAINING WELL OVER THE YEARS. BUT AS OF LATE SOME ISSUES AROSE WITH MY AIR BAG SENSOR AND OIL LIGHT FLICKERING ON DASH WHEN BRAKE AT IDLE. I DON'T DRIVE TOO FREQUENTLY EXCEPT THE NORMAL WORK SCHEDULE MON-FRI SO I DONT GO FAR ESPECIALLY SINCE THESE PROBLEMS AROSE NEVER BEEN IN AN ACCIDENT NOR INTERGRATED PARTS

BLOWN ENEGINE DUE TO CYCLINDER MISFIRE AND BNDING ROD CAUSED BY FAULTY COWL PANEL. THIS HAPPENED WHEN IT RAINED I WENT TO START ENEGINE AND IT BLEW

THE PROBLEM HAPPENS TO EVERY HEMI VEHICLE. AS IT AGE. EXHAUST MANIFOLD WILL START TO LEAK. MAKING A TICKING SOUND.

MY ENGINE SHUTS OFF WHILE I AM DRIVING MY VEHICLE . WITHOUT WARNING. THIS HAS HAPPENED ON SEVERAL OCCASIONS. THE VEHICLE COMES TO A COMPLETE STOP WHEN IT SHUTS OFF.

WENT TO GO START DURANGO & HEARD A LOUD BOOM, & NOW IT SEEMS TO BE KNOCKING & NOT DRIVABLE NOW, AFTER DO RESEARCH ONLINE WE CAM ACROSS THAT ON THESE MODELS (2004 DODGE DURANGO 5.7 HEMI MAGNUMS) IT SEEMS TOO LEAK WATER INTO WHERE THE ENGINE IS DUE TO HOOD MANIFOLD IS DESIGNED HORRIBLY & WATER LEAKS ON WIRES, SPARK, PLUGS, ENGINE ETC. ETC. WE'VE NOTICED WHEN WE DROVE IN THE RAIN OR EVEN GOING THROUGH A CARWASH THAT THE DURANGO WOULD SPUTTER AS IF IT WAS GOING TO DIE & IT HAS A COUPLE TIMES & TOOK ABOUT 15 MINS TO START AGAIN, AFTER THIS EVENT HAS HAPPENED WE THANK GOD THAT IT HAPPENED AT HOME & NOT ON THE INTERSTATE AROUND OTHER VEHICLES BECAUSE THIS IS A SERIOUS SAFELY ISSUE THAT NEEDS TO BE ADDRESSED & NOW WE ARE OUT OF A VEHICLE AT THE MOMENT AND...

EARLY MORNING AFTER A HEAVY RAIN THE VEHICLE WAS STARTED AND AN EXTREMELY LOUD BANGING NOISE WAS COMING FROM THE ENGINE. ALL FLUIDS WERE MAINTAINED. THE VEHICLE WAS PARKED ON A CITY STREET.

THE VEHICLE WILL INTERMITTENTLY SHUT OFF WITHOUT WARNING. DOES NOT SPUTTER OR STALL OUT IT JUST SHUTS OFF LIKE YOU TURNED THE KEY OFF. NO CODES THROWN SO THE DEALER WONT ACKNOWLEDGE IT. VEHICLE WILL START RIGHT BACK UP BUT I HAVE SEEN SEVERAL COMPLAINTS WHERE PEOPLE HAVE WRECKED BECAUSE THEY LOST CONTROL OF STEERING AND BRAKING. SO FAR THIS HAS ONLY HAPPENED TO ME WHILE AT A STOP LIGHT BUT FROM OTHER REPORTS IT SOUNDS LIKE IT CAN HAPPEN AT ANY TIME.

BOUGHT THE CAR USED IN 2014. ALWAYS HAD MISFIRE/ROUGH RUNNING PROBLEMS IN HEAVY RAIN OR A CAR WASH. IN MAY 2019, DRIVING IN THE RAIN, THE ENGINE FAILED CATASTROPHICALLY. RESEARCH ON LINE AND MY OWN REPAIRS DISCOVERED A FLAW IN THE FIRST GENERATION COWL GRILL. IT ALLOWED WATER TO FLOOD THE TOP OF THE ENGINE. A LEAK IN THE INTAKE MANIFOLD GASKETS ALLOWED THE WATER TO ENTER THE ENGINE, CAUSING IT TO HYDROLOCK. IT BROKE A CONNECTING ROD. IT DID HOWEVER STILL RUN, BUT WAS VERY NOISY. THE INTAKE LEAK WAS NOT NOTICED IN ANY OTHER CONDITIONS, NOR WAS THE CHECK ENGINE LAMP ON PRIOR TO THIS EVENT. THE ENGINE DID NOT USE OIL OR MAKE ANY OTHER NOISES PRIOR TO THIS EVENT. IT HAS ABOUT 175000 MILES.

VEHICLE WILL DIE WITHOUT WARNING YOU HOLE DRIVING CAUSING A SERIOUS RISK FOR COLLISION. ENGINE STOPS RUNNING AND IS VERY HARD TO STEER OR STOP WITH NO POWER.

COWL UNDER WINDSHIELD DOES NOT DIVERT WATER FROM ENGINE BAY. WATER POOLS ON ENGINE, GETTING INTO THE COIL-OVER-PLUGS (COP) AND INTAKE(GASKET) CAUSING HESITATION STALLING AND ENGINE FAILURE AFTER BEING EXPOSED TO WATER. RAIN, CAR WASH, USING THE WINDSHIELD WASHER. CHRYSLER HAS MADE 7 DIFFERENT VERSIONS OF THE COWL TO ADDRESS THE ISSUE BUT HAS NEVER ISSUED AN OFFICIAL RECALL. THOSE WHO DO NOT HAVE THE LATEST VERSION OF THE COWL (PART# 55362453AK) HAVE TO PAY FOR THE PART AND HAVE IT INSTALLED OR RISK HAVING ENGINE FAILURE WHILE DRIVING DOWN THE ROAD IN THE RAIN. PART THAT SHOULD BE INCLUDED IN RECALL 55362453AK "COWL" THIS IS A KNOWN ISSUE REPORTED BY "DURANGO" OWNERS THAT IS ALL OVER THE INTERNET

I HAVE EXPERIENCED THIS INCIDENT SEVERAL TIMES. WHEN IT RAINS REALLY HARD OR WHEN THE CAR IS TAKEN THROUGH THE CAR WASH, SOME HOW THE WATER REACHES THE MOTOR. IT WILL START ACTING UP (STALLING) AND HAVE TROUBLE "GOING." IT WILL THEN TRIGGER A CHECK ENGINE LIGHT AND THE MOTOR WILL DIE. I HAVE HAD THE CHECK ENGINE LIGHT CHECKED WHILE ON AND SPARK PLUGS REPLACED PER THE CHECK ENGINE LIGHT. IT IS VERY DIFFICULT TO PLAN ANY TYPE OF TRIP WITH THE THREAT OF RAIN WHILE DRIVING FOR FEAR OF BREAKING DOWN. THE CAR WASH WILL COMPLETELY KILL THE MOTOR AND TAKES SEVERAL TIMES TO RE CRANK. ONCE THE CAR IS DRY, IT RUNS PERFECTLY. I HAVE RED SEVERAL SIMILAR ISSUES ONLINE.

I WAS GETTING GAS AND AS I PULLED OUT OF THE GAS STATION I WAS GETTING A LOAD TICKING NOISE. TO FIND OUT LATER MY 5.7 HIMI LIFTER AND CAM SHAFTS NEEDS TO BE REPLACED. I GET A REGULAR OIL CHANGE AND FILTER CHANGE. I AM NOT SURE WHY THIS IS HAPPENING BUT I DID SEE THAT THIS IS NORMAL AND 5.7 HIMIS DODGE DURANGOS AND NOT UNDERSTANDING WHY IT HASN'T BEEN RECALLED. I'M A MOTHER OF 3 LITTLE ONES AND I'M TERRIFIED WE CAN GET STRANDED IF MY ENGINE DECIDES TO GO OUT DUE TO THIS ISSUE.

I WAS GOING 45 MILES AN HOUR WITH ALL MY 4 CHILDREN AND HUSBAND IN VEHICLE WHEN WITHOUT WARNING THE VEHICLE SHUT OFF. THERE IS NO CODE VEHICLE LOSES POWER STEERING AND BRAKE FUNCTION AND YOU HAVE TO SHUT VEHICLE DOWN AND RESTART TO GAIN CONTROL AGAIN. THIS HAS HAPPENED 7 TIMES! THERE IS NO CODE BEING GIVEN NO ONE CAN DIAGNOSE THIS ISSUE I HAVE BEEN EVERYWHERE AND BEEN TOLD THAT NO ONE CAN DO ANYTHING FOR ME THIS IS RIDICULOUS I HAVE SEEN THIS PROBLEM SPREAD ALL OVER DODGE FOR YOU AND I CANNOT BELIEVE THAT THIS IS NOT A RECALL A WHOLE FAMILY MY FAMILY ALMOST DIED MULTIPLE TIMES BECAUSE OF ITS END THIS IS NOT RIGHT THAT THERE IS NOT A RECALL ON THIS THIS IS SERIOUS THERE HAVE BEEN HUNDREDS OF NEAR-DEATH ACCIDENTS BECAUSE OF THIS ISSUE ALONE THIS NEEDS TO BE LOOKED INTO THIS...

TAKARA RECALL I PUT OIL ON THE ENGINE CONSTANTLY AS I DONT KNOW WHERES IS GOING THROUGH. NO SMOKE OR LEAK.

I AM ORIGINAL OWNER AND LOVE MY DURANGO BUT SINCE I HAVE OWNED IT I CANNOT DRIVE IN RAIN. THE VEHICLE SPUTTERS AND DIES AND CHECK ENGINE LIGHT COMES ON. I FOUND SEVERAL PLACES ONLINE OF PEOPLE WITH SAME COMPLAINT AND THE ISSUE IS THE ORIGINAL COWL. I LOOKED AND MINE DOES NOT HAVE A TALLER RIDGE AROUND THE WIPER BOLTS OR A RIDGE TO DIVERT THE WATER FROM RUNNING INTO MY ENGINE. I NEED THE 2ND GENERATION COWL THAT WAS IMPROVED PART #55362453AK OUR FAMILY ALWAYS BUYS DODGE, MY HUSBAND HAS THE 1500 TRUCK AS WELL AS MY DAUGHTER. I DON'T UNDERSTAND WHY DODGE HAS NOT PUT A RECALL OUT ON THIS ISSUES THAT SO MANY ARE COMPLAINING ABOUT. I HAVE TAKEN MY DURANGO SEVERAL TIMES TO THE SERVICE DEPT. AND THEY COULD NEVER FIND THE PROBLEM BUT ONLINE AFTER SEEING EVERYONE WITH SAME ISSUE AND HOW THEY ARE...

BLEW A HOLE IN THE SIDE OF THE ENGINE BLOCK WITH A FAILED ROD/PISTON ON A SLOW RIGHT TURN .... ALWAYS TOOK METICULOUS CARE OF THE ENGINE... 5.7 HEMI SHOULD HAVE LASTED 250K TO 300K MILES.... IT BLEW AT 130K MILES.

THE VEHICLE WOULD ALWAYS DRIVE ROUGH WHENEVER IT RAINED AND WOULD EVEN DIE WHEN GOING THROUGH A CAR WASH. IF IT STARTED RAINING WHILE IN TRAFFIC, I HAD TO KEEP MY FOOT ON THE BRAKE AND THE GAS WHEN COMING TO A STOP OTHERWISE THE VEHICLE WOULD STALL. AFTER RAINING ALL NIGHT, I CAME TO START MY VEHICLE IN THE MORNING AND IT ONLY MADE A TERRIBLE CLUNKING NOISE WITHOUT STARTING. LUCKILY, I WAS NOT DRIVING IN TRAFFIC WHEN THE VEHICLE DECIDED TO STOP RUNNING DUE TO RAIN, SOMETHING THAT A VEHICLE SHOULD NOT IRREGULARLY AND SUDDENLY SHUT OFF OVER.

2004 DODGE DURANGO 5.7 HEMI THESE VEHICLES ARE SHUTTING OFF WITHOUT WARNING NO STEERING, BRAKES LIGHTS, HAZARDS, NOTHING IS OPERABLE VEHICLE DOESN'T STUTTER OR STALL AT ALL NO WARING LIGHTS JUST SHUTS RIGHT OFF MULTIPLE PEOPLE ARE REPORTING THE EXACT SAME PROBLEM THIS IS A SERIOUS DEFECT AS THERE AREN'T ANY CODES OR SIGNS OF FAILURE

AFTER A NIGHT OF RAINING I STARTED UP MY VEHICLE TO A TERRIBLE KNOCKING SOUND. BLOWN MOTOR DUE TO DEFECTIVE COWL ALLOWING WATER TO LAY ON TOP OF INTAKE. AND SUCKED THROUGH INTAKE GASKETS.CAUSING A HYDRAULIC AND BLOWN MOTOR. COMPREHENSIVE INSURANCE SAID MECHANICAL FAILURE. INTERNET SAYS ENOUGH ABOUT THIS VIEHICLE. RODS THROUGH THE BLOCK UPON IGNITION.

MY VEHICLE STALLS IN THE RAIN. IT STALLS AT A STOP OR ROLLING SPEEDS. IT IDLES ROUGH FIRST AND THEN STALLS OR SHUTS OFF. SOMETIMES THE CHECK ENGINE LIGHT WILL COME ON, BUT NOT ALWAYS. THIS ONLY OCCURS IN THE RAIN. I'VE HAD SEVERAL MECHANICS LOOK AT IT, AND THEY CAN'T FIGURE OUT HOW TO SOLVE THE PROBLEM. I'VE SPENT A LOT OF MONEY TRYING TO GET THIS FIXED. THROUGH ONLINE RESEARCH, I'VE DISCOVERED THAT MANY OTHER DURANGO OWNERS ARE EXPERIENCING THIS SAME ISSUE.

MY 2004 DODGE DURANGO HAS THE 5.7 HEMI. DURING HEAVY RAINS THE ENGINE WOULD START TO RUN ROUGH AND THE ELECTRICAL SYSTEM SHUT DOWN ON ME THREE DIFFERENT TIMES IN THE MIDDLE OF DRIVING DUE TO THE RAIN. DURING THIS ELECTRICAL SHUTDOWN STEERING WAS IMPOSSIBLE AND I WOULD HAVE TO STOP THE VEHICLE IN THE MIDDLE OF TRAFFIC. THE VEHICLE DID THIS TO ME ONE TIME IN THE MIDDLE OF TURNING AT AN INTERSECTION. FORTUNATELY NO ACCIDENT OCCURED. I FOUND THAT THE ISSUE WAS BEING CAUSED BY A FAULTY SEAL AT THE WIPER COWL. THIS LEAK LATER BLEW MY ENGINE AS THE WATER LEAK FOUND IT'S WAY INTO THE CYLINDERS AND BLEW A PISTON ROD. I WAS TOLD THAT THIS DEFECT HAS BEEN REPORTED TO CHRYSLER BY HUNDREDS OF PEOPLE.

2004 DODGE DURANGO. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE. *LD THE CONSUMER STATED THE ENGINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND DID NOT OFFER ANY ASSISTANCE DUE TO THE VEHICLE BEING OUT OF WARRANTY. *JS

I PURCHASED MY '04 DURANGO IN 2014 WITH 70,000 MILES ON IT AND JUST PAID IT OFF LAST MONTH. I HAVEN'T EVEN RECEIVED THE TITLE YET BUT YET I HAVE A TRUCK THAT DOESN'T RUN ANYMORE. ABOUT A WEEK OR SO AGO I WENT OUT TO START MY TRUCK AND THE ENGINE BEGAN TO KNOCK VERY LOUDLY. WE HAD A SMALL RAIN/SNOW EVENT THE NIGHT BEFORE AND THE TRUCK HAD BEEN SITTING OUTSIDE IN THE ELEMENTS. I IMMEDIATELY TURNED OFF THE TRUCK AND WENT BACK INSIDE TO MAKE SOME CALLS AND GET ON THE INTERNET. I FOUND OUT THAT THERE HAS BEEN AN ONGOING ISSUE WITH THIS TRUCK CONCERNING WATER LEAKING INTO THE ENGINE CAUSING IT TO HYDROLOCK THE ENGINE CAUSING CATASTROPHIC ENGINE FAILURE/ ENGINE REPLACEMENT. PRIOR TO THIS, I HAD ISSUES WITH THE TRUCK CONCERNING IDLING AND/OR STALLING DURING THE RAIN OR WHEN GOING THROUGH A CAR WASH. I...

DURANGO SLT 5.7L V8 HEMI ENGINE HYDRO LOCKED AND THREW A ROD WHILE THE VEHICLE WAS PARKED. THE HYDRO LOCK ISSUE IS WIDELY REPORTED WITH THE 2004 FIRST GENERATION OF THE HEMI ENGINE. HOWEVER, DODGE DOES NOT ACKNOWLEDGE THIS MANUFACTURING DEFECT AND SAFETY ISSUE.

IT WAS A RAINI DAY AND DECIDED TO GO TO THE STORE TO GET GROCERIES. I WAS DRIVING MY VEHICLE TO GET TO THE STORE FROM MY HOME TO THE WHOLE FOODS IN SAN FRANCISCO CA ON FREEWAY I-280 NORTH NEAR THE EXIT ON GENEVA I HEARD A LOUD NOICE COMING FROM THE ENGINE COMPARTMENT, SO I DECIDED TO GET OUT ON THE EXIT TO SEE WHAT WAS GOING ON, I TURN LEFT ON GENEVA AV I WAITED ON RED LIGHT ON GENEVA AV AND HOWTH ST WHEN LIGHT TURN GREEN I LET GO THE BREAK AND STARTED TO GO SO I CAN PARK ON THE STREET AND ALL OF THE SUDDEN I HEARD A LOUD SOUND AND SAW A LOT OF SMOKE SO I PULLED OVER ON 33 GENEVA AV SAN FRANCISCO CA AND LOOKED AROUND AND FOUND PIECES OF THE ENGINE ON THE ROAD AND NEAR THE STARTER...

CAR HAS A NEW ENGINE AND THIRD WATER PUMP. IT FAILED AFTER 5000 MILES AND ENGULFED IN FLAMES CAUSING THE FAILURE OF THE BELT, TENSIONER, MAIN DRIVE PULLEY AND AC COMPRESSOR. TODAY DODGE JUST RECALLED THESE PUMPS FOR THE VERY SAME REASON BEARING FAILURE AND SUPER HOT CONDITIONS CAUSING FIRES AND FAILURE. I WAS JUST REDRIVING ALONG THE TRUCK HAS BEEN RUNNING WELL AND SHOWED NO SIGNS OF ISSUES, NO NOISE, SMELL, LIGHTS OR STRUGGLE. CAR WAS AT NORMAL OPPERATING TEMPURTURE AND DAYTIME TRAFFIC. STOPPED FOR GAS STAYED FOR A COUPLE MINUTES THEN DRIVE ON, WITHIN TWO MILES WITHOUT ANY WARNING OR NOISE THE CAR STARTED SMOKING PULLED OVER AND SMELLED A RUBBER NOTICES NO LEAKS IN THE WATER DELIVERY SYSTEM OIL, TRANS, OR POWER STEERING, THE BELT WAS RED HOT AND SMELLED LIKE A HOUSE FIRE CAR WAS TAKEN 200 YARDS TO PEP BOYS AND REPAIRED AT THE COST...

HAS HAD PROBLEMS WITH ENGINE ON DURANGO 4.7L OVERHEATING, I DRIVE 15 MINUTES TO WORK WHEN ITS WARM OUTSIDE AND ITS ALREADY OVERHEATING, IVE CHECKED VARIOUS FORUMS ONLINE EACH ONE HAD NUMEROUS PEOPLE COMPLAINING ABOUT THE SAME ISSUE, WITH ALL THE PEOPLE COMPLAINING I FIGURED DODGE WOULD FIND A SOLUTION, OR FIGURED SOMEONE WOULD FILE A CLASS ACTION SUIT, BUT NOTHING HAS BEEN DONE.

1. RECALL FAILED TO REPAIR AIR BAG FAILURE. CURRENTLY - AIRBAGS ARE NOT FUNCTIONAL (DASH WARNING LIGHT). 2. AT APPROXIMATELY 72,000 MILES - VEHICLE BEGAN TO SHOW SIGNS OF RUST THROUGH AT BOTH REAR QUARTER PANELS AND BOTH ROCKER PANELS. BY 85000 MILES - COMPLETE BODY RUST THROUGH FAILURE WAS IRREPARABLE - VEHICLE WAS MAINTAINED EXCEPTIONALLY CLEAN. 3. AT 100000 MILES - NOTED BY WAY OF MECHANIC THAT THE ENGINE WAS 'SLUDGED UP' TO THE POINT THAT THE VALVE TRAIN WAS STARVED OF LUBRICATION AND SUBSEQUENTLY - THE ENGINE HAS ENCOUNTERED WHAT APPEARS TO BE A TOTAL CATASTROPHIC FAILURE. VALVES, LASH ADJUSTER, PISTON ROD OR BEARINGS MAY ALL BE DESTROYED DIRECTLY DUE TO POOR DESIGN AND LOW QUALITY COMPONENTS FROM FCA. THERE ARE HUNDREDS (THOUSANDS) OF SIMILAR COMPLAINTS ACROSS MULTIPLE MEDIA REGARDING THIS 'FAMILIAR' DODGE ENGINE BREAKDOWN. FCA - OF COURSE - DENIES CULPABILITY CITING POOR USER MAINTENANCE. I HAVE...

04 DURANGO SLT 4.7 V8. RATTLING/RAPPING NOISE ON START UP THAT WORSENED THROUGH THE DAY. NOISE COMING FROM RIGHT SIDE OF ENGINE BAY. BROUGHT TO MECHANIC AND IDENTIFIED VALVE SEAT(S) IN THE ALUMINUM HEAD(S) HAVE 'DISINTEGRATED' AND/OR 'DROPPED' CAUSING THE VALVES TO SLAP ON ACCELERATION AND MULTIPLE OTHER CATASTROPHIC ENGINE ISSUES. FCA (CHRYSLER/DODGE) HAS BEEN NOTIFIED OF MY COMPLAINT AND THEY'RE FULLY AWARE OF THIS FATAL ENGINE FLAW IN THEIR LATE MODEL V8 ENGINES YET THEY REFUSE TO ACKNOWLEDGE OR EVEN ADVISE OWNERS OF REPAIR OPTIONS. THEY MUST BE TOLD TO GO GOOD FOR THIS SITUATION. THIS OCCURRED AT 110,000 MILES. MY OPTIONS NOW ARE: A $2000 ENGINE REPAIR, $4000 ENGINE REPLACEMENT - OR - TO 'JUNK' THE VEHICLE - DON'T GET ME STARTED ABOUT THE [XXX] RUST ON THIS THING, EITHER... I FEEL RIPPED OFF FROM A FEW DIFFERENT ANGLES HERE BY CHRYSLER/DODGE AND I KNOW THERE ARE THOUSANDS...

WHILE DRIVING IN THE RAIN ALL OF A SUDDEN THERE WAS A LOUD NOISE AND MY ENGINE STARTED KNOCKING LOUDLY. I WAS ABLE TO PULL THE ENGINE AND PULL IT APART AND FOUND THERE WAS WATER IN THE INTAKE AND THE NUMBER 5 CYLINDER ROD HAD BROKE. LUCKILY THE PART THAT BROKE WENT DOWN AND THE OIL PAN GASKET/WINDAGE TRAY SLOWED IT DOWN ENOUGH TO NOT GO THROUGH THE BLOCK. AFTER FURTHER INSPECTION I NOTICED THAT THE INTAKE GASKETS WERE NOT SEALING PROPERLY AND ALLOWED WATER TO BE SUCKED INTO THE INTAKE AND THEN HYDRA LOCKED THE NUMBER 5 PISTON. WHEN I PUT IT TOGETHER I NOTICED THE "SEAL" ON THE COWL WASN'T EVEN TOUCHING THE WINDOW AND THAT LET THE RAIN GO DIRECTLY INTO THE ENGINE COMPARTMENT AND SIT ON THE ENGINE. PUT THOSE TWO PROBLEMS TOGETHER WITH THE RAIN AND NOW I HAVE A MOTOR THAT IS BROKEN....

THE WINDSHIELD WIPER COWLING ALLOWS WATER TO FLOW RIGHT OVER THE ENTIRE ENGINE AND RIGHT INTO THE INTAKE. MY DODGE WAS SITTING FOR 2 WEEKS DURING HEAVY RAINS AND WHEN I TRIED CRANKING IT UP FOR THE FIRST TIME, THE ENGINE HYDROLOCKED.

THE WINDSHIELD WIPER COWL BECAME DEFECTIVE AND LET WATER INTO THE ENGINE COMPARTMENT, SPECIFICALLY THE FUEL INTAKE MANIFOLD. AFTER ABOUT 5 YEARS OF RANDOM WATER RELATED STALLS (RAIN,DEW,CAR WASHES) WHICH COULD NEVER BE REPLICATED BY NUMEROUS MECHANICS AND THEREFORE NOT PROPERLY DIAGNOSED, WATER EVENTUALLY FOUND ITS WAY INTO A PISTON CHAMBER. WHILE ON THE FREEWAY IN SAN FRANCISCO ON MARCH 31,2017, HYDROLOCK ENSUED AND CAUSED THE NUMBER FOUR PISTON ROD TO SNAP AND BREAK THROUGH THE ENGINE BLOCK DESTROYING THE ENGINE. I WAS AT THE DODGE DEALERSHIP IN COLMA A FEW WEEKS PRIOR FOR AN UNRELATED AIRBAG RECALL FIX AND SPOKE TO THE A SERVICE SUPERVISOR ABOUT THE WATER RELATED STALLING ISSUE. HE BASICALLY TOLD ME TO GO SOMEWHERE ELSE BECAUSE THEY ONLY USE OE PARTS AND EVEN IF THEY COULD FIGURE OUT THE PROBLEM (NO GUARANTEE), THEY PROBABLY COULDN'T GET ORIGINAL PARTS. HE ACTED LIKE HE WAS DOING ME...

TL* THE CONTACT OWNS A 2004 DODGE DURANGO. WHENEVER IT RAINED OR SNOWED, WATER LEAKED INTO THE INSIDE OF THE VEHICLE THROUGH THE HOOD. THE WATER ENTERED THE MOTOR AND CAUSED THE VEHICLE TO STALL AND THE ENGINE TO SHUT OFF WITHOUT WARNING. THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE WATER WAS LEAKING INTO THE MOTOR AND THE PISTONS, WHICH CAUSED THEM TO FAIL. AS A RESULT, THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

DRIVING AT 30MPH ON CITY ROAD THE DURANGO LOST FULL POWER. NO POWER STEERING, BRAKES OR ACCELERATION WITH GAS. HAD TO PUT DURANGO IN NEUTRAL AND TURN KEY OFF AND BACK ON. AFTERWARDS IT WAS NORMAL AGAIN. VERY DANGEROUS AND SCARED TO DRIVE WITH FAMILY IN IT. *TR

I WENT TO THE DODGE DEALER AND MADE THE COMPLAINT AND THEY COULDN'T FIGURE IT OUT AND TOOK IT TO MIDAS AND ANOTHER CAR REPAIR SHOP AND THEY COULD FIGURE IT OUT AND WHEN I LOOKED AT IT ONLINE IT SAID IT WAS THE COWL SO I WENT BACK TO THE DODGE DEALER AND TOLD THEM. THEY LOOKED AT ME LIKE I WAS CRAZY HAD TO PRINT OFF WHAT EVERYONE ONE HAD COMPLAINED, SO THEY REPLACED THE RUBBER UNDER THE HOOD WHICH WAS 40 DOLLARS NOT THAT COSTLY. BUT STILL WHEN IT RAINS, IT RUNS ROUGH AND LIKE IT GOING TO DIE. THIS IS AN ACCIDENT WAITING TO HAPPEN. THIS SHOULD BE A RECALL. WHEN IT FIRST HAPPENED I WAS GOING TO NEW YORK. VERY SCARY GOING THROUGH THE MOUNTAINS AND IT STARTING RAINING HARD ALL OF THE SUDDEN GOING 70 , DROP TO 30. TRUCKS ON MY BUTT. NOT...

GAS AND BODY ISSUES: WHEN YOU GO TO FILL UP THE GAS SPRAYS OUT. I HAVE A VERT STRONG SMELL OF GAS AND THE LOWER FINDER BY THE WHEEL WELL HAS RUSTED BADLY. MOTOR: WHENEVER THERE IS HEAVY RAIN, MY CAR WILL STOP RUNNING. MOST RECENTLY WHEN I TURN ON THE AC OR HEATER THE CAR STALLS. I ALSO JUST RECENTLY HAD TO CHANGE OUT A MANIFOLD WHICH CAUSED ANOTHER SET OF PROBLEMS. I OWNED A DURANGO BEFORE THIS ONE AND LOVED IT. THIS ONE HAS CHANGED MY MIND AND I WILL NEVER OWN ANOTHER.

THE RH SIDE OF THE EXHAUST MANIFOLD CONTINUOUSLY HAS AN EXHAUST LEAK!

RECENTLY WHEN RAIN FALLS HEAVILY THE ENGINE STARTS SPUTTING & CUTS OFF THEN ENGINE LIGHT COMES ON. TOOK IT TO MECHANIC & THEY PUT THE MACHINE ON IT. IT SHOWS NOTHING IS WRONG. PUT KEEPS DOING IT ONLY WHEN HEAVY RAINS FALLS. FINALLY WENT ONLINE TO ALL THE OTHER COMPLAINTS TO DODGE & FOUND OUT ITS THE COWLING. CHANGED THE COWLING BUT ITS STILL DOING IT. ITS A DODGE PROBLEM BUT THEY WILL NOT FIX THEIR PROBLEM & ITS COSTING ME A LOT OF MONEY. DODGE NEEDS TO DO SOMETHING ABOUT THIS IMMEDIATELY

MY 2004 DODGE DURANGO SUFFERED THE CATASTROPHIC ENGINE FAILURE DUE TO HYDROLOCK FROM THE POOR COWL DESIGN. I LIVE IN BEAR COUNTRY, IF THIS HAD HAPPENED WHILE I WAS IN A REMOTE AREA I COULD HAVE EASILY BEEN STRANDED WITH 800LBS OF CLAWS AND TEETH. I STARTED THE MOTOR IN MY DRIVEWAY DURING A LIGHT RAIN SHOWER ONLY TO HEAR AN OBVIOUS PROBLEM IN THE ENGINE, IT RAN FOR 5 SECONDS THEN DIED. PLENTY OF VEHICLES HAVE BEEN AFFECTED BY THIS ISSUE, BUT NO RECALL HAS BEEN ISSUED. THE 2012 HEMI HAD A VERY SIMILAR ISSUE AND A RECALL WAS ISSUED.

TL* THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT RECIEVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V770000 (AIR BAGS) AND 15V313000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. ALSO, THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2004 DODGE DURANGO. WHILE THE VEHICLE WAS PARKED, IT FAILED TO START WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE PUSH ROD FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.

WHENEVER IT RAINS OR I GO THROUGH A CAR WASH MY CAR DIES AND THE SERVICE ENGINE LIGHT COMES ON. THE STEERING WHEEL WON'T MOVE, THEREFORE I HAVE NO CONTROL OVER MY CAR. WE WERE IN TENNESSEE THE FIRST TIME THIS HAPPENED AND WE WERE COMING DOWN THE MOUNTAIN WHEN IT DIED AND WE LOST ALL CONTROL AND ALMOST GOT HURT AND ALMOST HURT OTHERS.

TL* THE CONTACT OWNS A 2004 DODGE DURANGO. WHILE THE VEHICLE WAS PARKED, THE POWER OUTLET IN THE CENTER CONSOLE STARTED SMOKING. THE CONTACT AND THE PASSENGER FOUND THE SOURCE OF THE SMOKE, PULLED THE PANEL OFF THE CENTER CONSOLE, AND NOTICED THE OUTLET WAS ON FIRE. THE CONTACT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. ON ANOTHER OCCASION, THE CONTACT HEARD LOUD GRINDING NOISES COMING FROM THE ENGINE. WHILE DRIVING 50 MPH AND WITHOUT WARNING, THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED AND DRIVEN TO THE CONTACT'S RESIDENCE. ONCE HOME, THE VEHICLE STALLED. UPON FURTHER INVESTIGATION, THE CONTACT STATED THAT THE SPRING SEPARATED FROM THE ENGINE AND THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 135,000.

AFTER NOTICING A DIFFERENCE IN DRIVING POWER FROM A STOP THE RPM'S WOULD ALMOST HIT 2K BEFORE MOVING. ENGINE LIGHT CAME ON AND SAID THAT I HAD A MISS-FIRE IN CYLINDER 8 AND I NEEDED A NEW IGNITION COIL. BOUGHT NEW PLUGS AND AN IGNITION COIL AND PROCEEDED TO CHANGE THEM OUT. THE DRIVERS SIDE OF THE ENGINE PLUGS STILL LOOKED CLEAN AND NEW. THE PASSENGERS SIDE WERE BURNT, HAD MOISTURE AND THE CYLINDER 8 PLUG WAS FOULED AND BROKE OFF IN THE ENGINE. FINISHED CHANGING EVERYTHING OUT AND PUT THE TRUCK BACK TOGETHER WITH STILL NO CHANGE IN CODES OR POWER. FOUND THAT THE STARTER WAS CORRODED AND INFORMATION CONCERNING A BAD COWL DESIGN CAUSING HYDRO-LOCKING OF THE ENGINES. ALSO REPLACED THE EXHAUST GASKETS 3 TIMES IN 5-6 YEAR PERIOD EACH TIME WITH BROKEN BOLTS FOUND. CHANGED OUT THE PCM, THEN REPLACED ALL THE INJECTORS WHICH WERE FOUND TO...

ROD PIERCED THRU THE BOTTOM OF ENGINE AND LOCKED UP (110K MILES), FAMILY ON BOARD AND HAPPENED WHILE TURNING AT BUSY INTERSECTION.. HAD TO REPLACE ENGINE USED( FOUND ONE WITH 70K, WAITING ON THIS ONE TO DO THE SAME) CONSUMES TONS OF OIL. ELECTRICAL WITHIN DRIVER SEAT AND CD PLAYER ARE FAULTY/BROKEN. RUST ON REAR OUTER WHEEL WELLS. (NOTICED THIS RUST IS APPARENT IN EVERY SAME MODEL MAKE YEAR THAT I RUN ACROSS)

TL* THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, A LOUD KNOCKING NOISE EMITTED FROM THE ENGINE AS THE FRONT END VIBRATED SEVERELY. THE VEHICLE STALLED WITHOUT WARNING. AFTER RESTARTING, THE VEHICLE RESUMED WITH AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO WAS UNABLE TO LOCATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,714.

TL* THE CONTACT OWNS A 2004 DODGE DURANGO. WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO VIBRATE SEVERELY AND VARIOUS WARNING LIGHTS ILLUMINATED. THE CONTACT PULLED OVER AND RESTARTED THE VEHICLE WITH NO FAILURE PRESENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE THROTTLE BODY WAS SERVICED. THE VEHICLE WAS REPAIRED. ON ANOTHER OCCASION, WHILE PARKED, THE VEHICLE WAS UNABLE TO START. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE WAS NOT FOUND. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 61,953.

TL* THE CONTACT OWNS A 2004 DODGE DURANGO. THE CONTACT STATED THAT THE ENGINE COMPARTMENT FLOODED IN THE RAIN CAUSING THE VEHICLE TO STALL WITHOUT WARNING. THE VEHICLE FAILED TO START ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.