2004 DODGE DURANGO Engine And Engine Coolingexhaust System Problems
4 NHTSA complaints on file
Engine And Engine Coolingexhaust System Issues in the 2004 DODGE DURANGO
4 engine and engine coolingexhaust system complaints have been filed with NHTSA for the 2004 DODGE DURANGO. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
4
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Engine And Engine Coolingexhaust System Complaints
I OWN A 2004 DODGE DURANGO 4.7. THE MILES ARE 117,000. MY WIFE NOTICED A LOUD TICKING SOUND COMING FROM THE ENGINE. AFTER DOING SOME RESEARCH ONLINE ABOUT THE DURANGO I CAME OPEN ANOTHER OWNER THAT REPORTED IT BEING THE EXHAUST MANIFOLD. I BOUGHT A NEW EXHAUST MANIFOLD GASKET AND WHEN I WENT TO INSTALL IT I NOTICED THAT 6 OF THE BOLTS HAD BEEN BROKEN OFF. ON THE DRIVERS SIDE THE HEAT SHIELD WAS COMPLETELY MISSING. I WENT TO THE DEALER AND PURCHASED A NEW HEAT SHIELD AND REPLACEMENT BOLTS. AFTER I INSTALLED THEM THE TICKING CONTINUED, I TOOK IT TO MY MECHANIC AND HE TOLD HE WAS SURE IT WAS AN EXHAUST LEAK AND TO GO AHEAD AND REPLACE THE DRIVERS SIDE MANIFOLD. I PURCHASED THE MANIFOLD FROM THE DODGE DEALER AND ONCE I GOT THE OLD ONE OUT I NOTICED THEY DID NOT MATCH. THE FACTORY EXHAUST...
EXHAUST MANIFOLD BOLTS BROKE OFF. *TR
RECENTLY OUR DURANGO BEGAN MAKING A LOUD TICKING NOISE AT INITIAL START UP OF THE VEHICLE, WHICH WOULD DECREASE AND ULTIMATELY GO AWAY AS THE CAR WARMED UP. I TOOK MY CAR TO MY LOCAL SERVICE SHOP (NOT DODGE) TO HAVE OTHER WORK PERFORMED AND ASKED THEM TO TRY AND DETERMINE THE CAUSE OF THE PROBLEM. THE SAID THAT THE BACK TWO BOLTS CONNECT THE MANIFOLD TO THE BLOCK OF THE ENGINE AND THE HEADS OF THE BOLTS THAT SECURE THE HEAT SHIELD WERE BROKEN. THEY INSTRUCTED ME TO CONTACT THE DEALER BECAUSE IT LOOKED AS IF THE HEADS OF THE BOLTS AND THE BOLTS THEMSELVES HAD JUST BROKEN OFF, PROBABLY DUE TO HEAT FROM THE ENGINE. MY VEHICLE HAS 68,000 MILES SO I CALLED TO SEE IF IT WAS COVERED UNDER THE 70,000 MILE WARRANTY. WITHOUT LOOKING AT THE CAR, THEY TOLD ME THAT SOMEONE HAD TO HAVE BROKEN...
NOISE/LOW VIBRATION AT 70 MPH. MADE COMPLAINT AT SERVICE INTERVAL. COULD NOT BE DUPLICATED. NEXT TIME I TOOK IT IN 1500 MILES OVER WARRANTY THEY MANGE TO DUPLICATE. IT WILL COST 500.00 AND THEY THINK IT WILL FIX IT. REPLACE ALL HANGERS AND TAIL PIPE. NEXT ALL PLASTIC ON FRONT SEAT CRACKED AGAIN NO PLAN UNTIL AFTER WARRANTY MILES. *JB
Other 2004 DODGE DURANGO Problem Areas
Engine
326 complaints
Electrical System
171 complaints
Engine And Engine Cooling
155 complaints
Air Bags
136 complaints
Engine And Engine Coolingengine
76 complaints
Power Train
64 complaints
Vehicle Speed Control
41 complaints
Electrical System Instrument Clusterpanel
37 complaints
Power Trainautomatic Transmission
26 complaints
Steering
25 complaints
Unknown Or Other
22 complaints
Exterior Lighting
18 complaints
Fuelpropulsion System
18 complaints
Structurebody
18 complaints
Electrical Systemwiringinteriorunder Dash
17 complaints
Structure
13 complaints
Equipment
12 complaints
Interior Lighting
12 complaints
Fuel System Gasoline
11 complaints
Electronic Stability Control Esc
10 complaints
Service Brakes
10 complaints
Service Brakes Hydraulic
10 complaints
Tires
9 complaints
Electrical Systemwiring
8 complaints
Seat Belts
8 complaints
Engine And Engine Coolingenginegasoline
7 complaints
Electrical Systemignition
6 complaints
Air Bagsfrontal
5 complaints
Electrical System12v24v48v Batterycables
5 complaints
Equipmentelectricalradiotape Deckcd Etc
5 complaints
Power Trainautomatic Transmissioncontrol Module Tcmpcmtecm
5 complaints
Suspension
5 complaints
Engine And Engine Coolingcooling System
4 complaints
Equipmentapplianceair Conditioner
4 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
4 complaints
Suspensionrear
4 complaints
Visibilitywindshield
4 complaints
Structurebodybumpers
3 complaints
Suspensionfront
3 complaints
Suspensionfrontcontrol Armlower Ball Joint
3 complaints
Tiressidewall
3 complaints
Vehicle Speed Controlaccelerator Pedal
3 complaints
Vehicle Speed Controlcables
3 complaints
Vehicle Speed Controlcruise Control
3 complaints
Visibilitypower Window Devices And Controls
3 complaints
Visibilitywiper
3 complaints
Electrical System12v24v48v Battery
2 complaints
Electrical Systemhorn
2 complaints
Electrical Systemignitionmodule
2 complaints
Engine And Engine Coolingcooling Systemradiator Assembly
2 complaints
Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe
2 complaints
Latcheslockslinkages
2 complaints
Seat Beltsfront
2 complaints
Seats
2 complaints
Service Brakes Hydraulicfoundation Componentsdiscrotor
2 complaints
Steeringhydraulic Power Assist System
2 complaints
Steeringlinkagestie Rod Assembly
2 complaints
Suspensionfrontcontrol Armupper Ball Joint
2 complaints
Visibilityrearview Mirrorsdevicesexterior
2 complaints
Visibilitysunmoon Roof Assembly
2 complaints
Visibilitywindshield Wiperwasher
2 complaints
Wheels
2 complaints
Air Bagsfrontalsensorcontrol Module
1 complaint
Air Bagssidewindow
1 complaint
Child Seat
1 complaint
Electrical Systemwiringfuses And Circuit Breakers
1 complaint
Electronic Stability Controlautomatic Asc
1 complaint
Engine And Engine Coolingcooling Systemhoseslinespipingfittings
1 complaint
Engine And Engine Coolingexhaust Systememission Control
1 complaint
Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor
1 complaint
Engine And Engine Coolingexhaust Systememission Controlcrankcase Pcv
1 complaint
Engine And Engine Coolingexhaust Systememission Controlgas Recirculation Valve Egr Valve
1 complaint
Equipment Adaptivemobility
1 complaint
Equipmentelectrical
1 complaint
Equipmentelectricalnavigational Systemglobal Positioning System
1 complaint
Exterior Lightingbrake Lights
1 complaint
Exterior Lightingfog Lights
1 complaint
Exterior Lightingheadlights
1 complaint
Exterior Lightingturn Signalswitch
1 complaint
Fuel System Otherstoragefuel Gauge System
1 complaint
Power Trainaxle Assembly
1 complaint
Power Traindriveline
1 complaint
Power Traindrivelinedriveshaft
1 complaint
Power Traintransfer Case 4 Wheel Drive
1 complaint
Seat Belts Rearotherbuckle Assembly
1 complaint
Seat Beltsfrontanchorage
1 complaint
Seat Beltsfrontretractor
1 complaint
Seatsfront Assemblyrecliner
1 complaint
Seatsfront Assemblyseat Heatercooler
1 complaint
Service Brakes Air
1 complaint
Service Brakes Airantilockabs Warning Light
1 complaint
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipwheel Speed Sensortone Ring
1 complaint
Service Brakes Hydraulicfoundation Componentsdiscpads
1 complaint
Service Brakes Hydraulicpedals And Linkages
1 complaint
Steeringhydraulic Power Assistpump
1 complaint
Steeringrack And Pinionpinion Shaft
1 complaint
Structurebodydoor
1 complaint
Suspensionfronthub
1 complaint
Suspensionrearaxlenon Powered Axle Assembly
1 complaint
Tirestreadbelt
1 complaint
Traction Control System
1 complaint
Trailer Hitches
1 complaint
Visibilitydefrosterdefoggerhvac System
1 complaint
Visibilitydefrosterdefoggerhvac Systemfanmotor
1 complaint
Visibilityglass Siderear
1 complaint
Visibilityrear Window Wiperwasher
1 complaint
Visibilityrearview Mirrorsdevices
1 complaint
Wheelsrim
1 complaint