2005 CHRYSLER 300 Engine And Engine Cooling Problems

I STARTING DRIVING FROM THE INTERSECTION THE LIGHT HAD JUST TURNED GREEN. AFTER GETTING OUT OF THE INTERSECTION THE CAR MADE A LOUD NOISE FROM THE REAR AND STOPPED AND WOULD NOT MOVE. I HAD TO HAVE THE CAR TOWED. MY WORK ASSOCIATE WHO WAS IN THE WITH ME SAID THE CAR SOUNDED LIKE I HAD JUST LOSS MY REAR-END. WHEN I GOT THE CAR TO MY PRIVATE MECHANIC HE SAID THE REAR-END WAS BAD AND NEEDED REPLACING. *TR

MY DAUGHTER (12YRS.) AND I WERE ON THE FREEWAY/CAR POOL LANE (DOUBLE YELLOW LINES) AND THE CAR STALLED/TURNED OFF COMPLETELY. I TRIED NOT TO PANIC BUT I DAUGHTER DID WHEN THE LIGHTS, ENGINE AND NOT TO MENTION THE STEERING WHEEL WAS VERY HARD TO TURN. AT THIS TIME I HAD TO CROSS OVER THE DOUBLE YELLOW LINE AND CUT OFF A FEW CARS WHO ALL MOST REAR ENDED ME, ALL CARS HONKED AT ME AND MY LITTLE ONE WAS FREAKING OUT. IT TOOK 24 MINUTES TO GET OFF THE FREEWAY BECAUSE IT KEPT STALLING AND WOULDN'T CONTINUE TO STAY ON. THIS IS A VERY UN SAFE SITUATION, I PRAY NO ONE GETS HURT FROM THIS. CAR CONTINUED TO STALL AND TURN OFF AND AT THIS TIME IT'S JUST SITTING BECAUSE OF FUNDS AND JUST FED UP WITH THIS CAR.... NOT MENTION MY PARKING LOCK MECHANISM BROKE LAST MONTH AND MY...

THERE WAS AN OIL LEAK AT THE REAR OF VEHICLE AND THE DEALER REPLACED THE REAR AXLE PINION SEAL AND YOKE. ALSO ON THIS DAY THE TRIM PIECE AROUND THE DRIVERS SEAT CAME LOOSE AND THEY REPLACED THE SIX (6) SCREWS THAT HAD FALLEN OUT. NEXT THE DRIVER SIDE SUN VISOR CLIP BROKE AND THEY REPLACED IT. AS OF THIS REPORT, JUNE 6, 2013, BOTH VISOR CLIPS ARE BROKEN. LASTLY, THE CARPET ON THE FLOOR BOARD FRONT PASSENGER SIDE IS COMING UP. 02/17/05, THERE WAS A RECALL ON VEHICLE D29 REPROGRAM PCM AND TCM08-D2-91-82, RECALL ON VEHICLE D28 BATTERY CABLE STUD FASTENERS RECALL D28 INSPECT BULKHEAD STUD 08-D2-81-82 ; RECALL ON VEHICLE D50 RADIATOR ISOLATOR BRACKETS. THE BOLTS WERE BROKEN AND REPLACED WITH RAD SUPPORT BRACKETS 07-30-10-50 07-D5-01-82. I WAS CHARGED 32.05 FOR LABOR, G.O.G., EPA PLUS TAX. 08/24/07, SLACK IN LEFT OUTTER TIE ROD END. THE SEEING OIL LIGHT...

I WAS DRIVING WITH THE A/C ON AND IT JUST COMPLETELY SHUT DOWN. THE AIR CONDITIONING DOES NOT WORK AT ALL NOW, WONT LIGHT UP OR ANYTHING. SINCE THIS HAS HAPPENED, THE AIR LIGHT HAS BEEN ON AS WELL. *TR

TL* THE CONTACT OWNS A 2005 CHRYSLER 300. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY STALL WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. UPDATED 12/16/11

MOTOR LOCKED. *TR

1. THE EVENTS LEADING UP TO THE FAILURE. THERE ARE HUNDREDS OF REPORTS ON THE INTERNET ABOUT LONG TERM AND SYSTEMIC OIL SLUDGE PROBLEMS CAUSING SUDDEN CATASTROPHIC ENGINE FAILURES IN DODGE AND CHRYSLER VEHICLES USING THE 2.7L V6 ENGINE SPANNING FROM APPROX 1998-2005. MY WELL MAINTAINED 2005 CHRYSLER 300 ENGINE FAILED SUDDENLY AND DANGEROUSLY WHILE DRIVING. AND THIS WAS 1 MONTH AFTER PAYING THE CHRYSLER DEALER $850 TO CHANGE THE TRANSMISSION FLUID AND COOLANT AT FACTORY SUGGESTED DATES. WITH ONLY 56,000 MILES AND OIL CHANGED EVERY 5000 MILES (OWNERS MANUAL SUGGESTS 7500) THE CHRYSLER DEALER INITIALLY WANTED OVER $2000 TO FIX AN UNEXPLAINED INTERNAL WATER PUMP LEAK, AND TIMING CHAIN FAILURE. ONLY AFTER HEATED DISCUSSION DID THEY BACK DOWN AND REPAIR IT FOR A $100 DEDUCTIBLE UNDER THE 7/70 DRIVEDRAIN WARRANTY. 2. THE FAILURE, HOW OFTEN IT OCCURS, ITS CONSEQUENCES. SIMPLY USING GOOGLE AND ENTERING "CHRYSLER 2.7L ENGINE FAILURE" LEADS...

ENGINE IN 2005 CHRYSLER 300 LIMITED HAS BEEN USING OIL SINCE BOUGHT. THE CAR WAS BUT FROM THE CAR DEALERSHIPS OWNER. IT WAS HIS WIFE'S CAR AND HAD 18,000 MILES ON IT. HAVE TAKEN IT BACK TO CHRYSLER DEALERSHIP FOR SERVICE AND HAVE COMPLAINED ABOUT THE OIL USAGE. TO DATE THEY HAVE DONE NOTHING TO DETERMINE WHERE THE OIL IS GOING. HAVE NOTIFIED CHRYSLER BY CERTIFIED LETTER WITH NO RESPONSE FROM THEM AT ALL. *TR

ENGINE FAILURE ON HIGHWAY DUE TO SLUDGE. I HAVE ALL PROOF OF TIMELY OIL CHANGES. CHRYSLER DOES NOT WANT TO TAKE RESPONSIBILITY. *TR

ENGINE LIGHT COMES ON AND VEHICLE HESITATES. TOLD BY EXTENDED WARRANTY COMPANY THAT THERE IS A DESIGN FLAW WITH MY 2005 CHRYSLER 300. DEALERSHIP SAYS THERE IS A CARBON BUILD UP ON THE VALVES AND COMBUSTION CHAMBER THAT CAUSES THE VALVES TO STICK CREATING A MISFIRE. *TR UPDATED 09/18/07 *TR

TL*THE CONTACT OWNS A 2005 CHRYSLER 300C. THE CONTACT STATED THAT THE DRIVER'S SEAT FAILED TO MOVE AND THE VEHICLE WOULD STALL AND SHUT OFF EVERY TWO MONTHS. THE FAILURES USUALLY OCCUR WITHOUT WARNING AND WHILE DRIVING 15 MPH. ON JULY 17, 2007, THE VEHICLE WAS TOWED TO THE DEALER AND THEY FOUND NOTHING WRONG. THE CURRENT MILEAGE IS 37,000 AND FAILURE MILEAGE WAS 8.

DT*: THE CONTACT STATED THE VEHICLE STALLED WHILE MAKING A LEFT TURN ON MULTIPLE OCCASIONS. ALSO, THE VEHICLE VIBRATED DUE TO CARBON BUILD UP. THE ENGINE VIBRATED UNTIL IT WOULD STALL, AND ALWAYS STALLED WHILE MAKING A LEFT TURN. THE SERVICE DEALER DETERMINED THE VEHICLE NEEDED A NEW IGNITION COIL AND CYLINDER HEADS.

DT*: THE CONTACT STATED WHILE DRIVING 15 MPH ON A STREET, THE INSTRUMENT CLUSTER PANEL AND GAUGES INTERMITTENTLY FLICKERED OFF AND ON, FOLLOWED BY THE ENGINE STALLING WITHOUT WARNING. AFTERWARDS, THE CONTACT SHUT OFF THE ENGINE AND RESTARTED WITHOUT FURTHER INCIDENT. THE VEHICLE WAS INSPECTED BY A DEALER WHO WAS UNABLE TO DUPLICATE THE PROBLEM. THE PROBLEM PERSISTED, AND THE MANUFACTURER WAS ALERTED.

THIS IS MY SECOND NEW CHRYSLER 300 PASSENGER VEHICLE THAT HAS HAD THE SAME PROBLEM. THE PROBLEM OCCURS WHEN THE CAR IS PUT INTO THE REVERSE POSITION. ONCE, YOU START TO BACK-UP THE CAR CUTS OFF. THE FIRST CAR WAS RETURNED TO THE DEALER AND EXCHANGED FOR A SECOND NEW CHRYSLER 300. THE SAME PROBLEM EXISTS. THE DEALERS MECHANIC SAID THE PROBLEM WAS THE "THROTTLE". I BELIEVE THIS IS A SERIOUS PROBLEM, BECAUSE IF IT CONTINUES TO CUT OFF -- ANOTHER CAR MAY HIT ME AND CAUSE AN ACCIDENT. *JB

HAVE LEASED MY CHRYSLER 300 C FOR A LITTLE OVER A YEAR. THE VEHICLE HAS HAD A RANDOM STALLING ISSUE WHICH HAS OCCURRED 3 TIMES IN THE LAST YEAR. DEALER WAS UNABLE TO REPRODUCE THE CONDITION BUT DID RE-FLASH THE PCM WITH A DRIVEABILITY UPDATE. VEHICLE JUST RECENTLY STALLED WHILE TURNING LEFT ONTO A MAIN ROAD. THE VEHICLE STALLED IN THE MIDDLE OF TRAFFIC LANES AND I WAS NEARLY HIT BY TWO VEHICLES WHILE TRYING TO RESTART THE CAR. THE CAR RESTARTED AND I PROMPTLY DROVE IT TO THE DEALERSHIP. I JUST RECEIVED A CALL THAT THEY CAN NOT DUPLICATE THE PROBLEM BUT ARE INVESTIGATING FURTHER. I DO NOT FEEL THAT THIS VEHICLE IS SAFE AND AM CONCERNED THAT I MAY BE INJURED OR INJURE SOMEONE ELSE IN THE EVENT THAT THE VEHICLE STALLS IN TRAFFIC AGAIN. *NM

STEERING WHEEL VIBRATES SPEEDOMETER GOES FROM 65 TO 40 ENGINE LIGHT COMES AND STAYS ON DATES 2/24/05 4/1/25 4/11/05 4/25/05 THE DEALER WANTED THE CONSUMER TO CONTINUE DRIVING THE VEHICLE WITHOUT DETERMINING WHAT THE PROBLEM WAS. THE ONLY THE THING THAT THEY WERE WILLING TO DO WAS CHANGE THE SPARKS PLUGS. *JB THERE WAS ALSO A WHISTLING NOISE WHILE ON THE FREEWAY. THE WINDSHIELD WAS REMOVED AN RE-INSTALLED. *SC THE AIR BAG LIGHT ILLUMINATED ON SEVERAL OCCASIONS *JB

WHILE MAKING A LEFT HAND TURN VEHICLE STALLED. CONSUMER PULLED OVER AND RESTARTED THE VEHICLE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.*AK UPDATED 12/14/2005. THE SUNROOF SHATTERED WHEN THE CONSUMER CLOSED HIS DOOR. THE DEALER CLAIMED THIS OCCURRED BECAUSE THE GLASS WAS BINDING IN THE TRACK. THE HEADLINER WAS COMING DOWN IN THE REAR. . *NM

INTERMITTENTLY WHILE DRIVING ON CALIFORNIA FREEWAY BETWEEN 55 TO 65 MPH VEHICLE STALLED . THIS CAUSED LOSS OF STEERING AND BRAKES. DEALERSHIP INSPECTED VEHICLE SEVERAL TIMES, BUT COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *AK