2015 CHEVROLET SILVERADO 1500 Electrical System Problems

The failure occurred in the rear sliding window defroster electrical system, specifically at the left-side electrical connection of the power sliding rear window. The component overheated and ignited, causing fire damage and shattering of the rear left portion of the window. The vehicle and damaged components are currently available for inspection upon request. The defect resulted in an active electrical fire during normal vehicle operation (remote start while warming up). This posed a serious risk of vehicle fire, injury to occupants, and potential spread to nearby vehicles or structures. As a firefighter, I recognized the danger and immediately shut off the vehicle and ventilated it; without trained action, the incident could have resulted in a total vehicle loss or more severe consequences. Yes. Copeland Chevrolet in Hudson, Massachusetts inspected the vehicle and confirmed that the damage was consistent with the known defect in the rear sliding window defroster system, consistent...

Vehicle has electrical issues with headlamps flickering and power steering loss (which is electronic) at lower speeds. Power and radio intermittently cut out momentarily and on occasion a "stabilitrac loss" warning flashes. Looking online, many consumers experience this issue which appears to be due to faulty ground or battery connections and many have reported complete loss of power at highway speeds resulting in accidents. This appears on several Chevrolet vehicles, but especially on the Silverado and GMC Sierra 2014-2017 models. I am very surprised a recall has not been issued yet for this very dangerous and potentially fatal issue.

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the instrument cluster started flickering, and the vehicle stalled. During several failures, the check engine warning light illuminated, and during other failures, there was no warning light illuminated. The contact stated on several occasions that the vehicle restarted independently. The failure was an intermittent failure, but was a recurring failure. The vehicle was not taken to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 120,000.

When my windows are up the heater whines, now yesterday the rear window blew out, I’m being told it is a known issue with the 2015 Chevy Silverado, I saw it was recalled and fixed in 2020, obviously the fix did not work and now my truck is a fire danger.

I was driving down the road like normal then for a second smelled a burning smell then my back window (power sliding) drivers side just exploded and completely shattered.

My rear window defroster circuit started overheating causing my window to shatter.

I have had a problem with the theft deterrent system which, shuts the truck down and issues a message saying "turn the driver side window down and then up". After 5 minutes the truck starts back up by itself? This has occurred sitting in Popeyes drive thru line in August 2024 in Benton Harbor, Mi. This has occurred 3 times in the past week, 09/25/25 driving on Garrett road it shut down during the entry into a "s curve" 09/26/25 driving into my drive way 09/28/25 driving into my drive way Took the truck into Wimberley Chevy dealer and they searched for error codes and checked some of the ground wires not connected properly and found the negative cable on battery was ok. I don't know if any other wire connectors were checked, however I have had this before and the dealer said they would have to keep the truck...

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that the door locks were independently locking and unlocking, and the hazard lights were flashing intermittently. The contact stated that the interior lights and the headlights were activated without the contact using the key fob or manually turning the lights on. The contact stated that the 12-Volt battery and alternator were replaced, but the vehicle still experienced electrical failures. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the door lock actuator and the wiring harness needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The manufacturer was not informed of the failure. The failure mileage was approximately 129,000.

Windows motor shorts out. If driving vehicle cuts off in order for window motor to reboot. Once you cut back on, error code tells driver to role window down and then back up.

Experienced a problem with electrical theft deterrent system and it shut the vehicle off while driving. I tried to start the vehicle and nothing happened except it said theft deterrent system. I took the key out tried starting again and it turned over immediately. The dash said theft deterrent and I clicked dismiss but the dash icon (a car with a lock light) remained on. I then drove 11 miles home. I turned on my directional proceeded to brake upon approaching my driveway. As I attempted to turn the steering wheel the vehicle completely shut off. The info system stating theft deterrent active. I lost power steering and brakes. I needed to press the brakes with great force because the vehicle was headed towards the sidewalk and a road sign. Steering was virtually unresponsive. Vehicle stopped as the tires reached the curb and approximately 1 ft from the sign. Placed...

On 5 separate occasions during the last week my truck steering wheel became difficult to steer while executing a slow turn and then I lost all power almost causing me to crash. After my vehicle stopped I was able to restart it. I took my vehicle to a repair shop where they were unable to find any codes indicating a problem and suggested taking it to a dealer. I was able to find many people posting similar issues online and a service bulletin PIT5405C from January 2017. 2015 to 2017 Silverados were impacted according to this bulletin. When I contacted the Chevrolet Service department they could not find a recall for my vehicle.

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated while driving at various speeds, the gauges on the instrument cluster were fluctuating, and the power steering warning light and the stabili-trak warning light lights were illuminated. The contact pulled over to the side of the road and allowed the engine to cool down. The contact stated that upon restarting the vehicle, the vehicle responded as needed. The contact stated that the failure had been occurring mainly in hot weather. Additionally, the contact stated that if the vehicle was not pulled over to the side of the road until the vehicle cooled down, the vehicle gradually lost motive power. The contact stated that the failure had been occurring intermittently. The vehicle was taken to several independent mechanics, where the failure could not be duplicated. The vehicle was taken to the dealer, where the same assessment was made. The vehicle...

I remote started my vehicle about 5 minutes prior to getting in. After I got in and placed the key in the ignition, I started to smell smoke. I see in my rear view mirror the entire cab of my truck started to fill with smoke. When I turned my head around the interior of my rear window was on fire and my entire truck cab filled with smoke. I get out of the vehicle and immediately try and look for help as the fire was inside of my vehicle and the smoke smell was overwhelming. The fire then died out and the driver’s side pane on the rear window then shattered. I am now left with a shattered window and a vehicle that is left with unknown damage from a fire inside the pane. After going back and forth with a dealer that contacted Chevy for me, they determined...

Vehicle shuts off when stopping. Everything goes dead. It will eventually start again, but very annoying. What happens when it shuts off going down the highway? No power steering or power brakes, that's what!

I heard a sharp click like metal on metal, then I lost all power from the engine. I was on the highway close to rush hour and I was trying to move to the right side of the road and get off on the shoulder, the engine would start long enough to get off the road and then that was it. The engine was dead. I called for a flatbed tow truck through my insurance. I had no idea as to what had happened. However, I have read many reports of engine failure concerning the 5.3 v8 engine which I have. The Chevrolet Silverado 1/2 ton pickup was towed on a flatbed truck to Chevrolet, They found that the engine had dropped a valve in the #7 cylinder and some rocker arms, etc also had broken. The final billing was $7092.89 I was in traffic going around 60mph when the...

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that after his wife had activated the remote starter, the rear defroster began emitting a burning sizzling sound, overheated, and short circuited, causing the rear windshield to crack. The contact became aware of Manufacturer Communication Number: N192265660, NHTSA ID Number: 10171416 (Power Train, Electrical System). The dealer was contacted, and it was confirmed that the vehicle was not included in the TSB or recall. The vehicle had not been diagnosed. The vehicle had not been repaired. The manufacturer was made aware of the failure, and it was confirmed that the vehicle was not included in the Manufacturer Communication Number. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 103,267.

While driving I loose my power steering, most of my electrical systems shut down including the radio, driver information center, AC and the stability control system. I get a quick dash warning light that says stability rack and it goes off. Issue mostly occurs while making turns making it hard to steer the vehicle

Mi camión está marcando un problema de servicio del sistema de freno de remolque y amanece con la batería baja y cuando voy conduciendo la mayoría de tiempo se pone muy duro el pedal del freno y hace un ruido muy raro cuando freno y también cuando acelero truena cómo si trajera un Fierro suelto en el motor

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that on several occasions while the vehicle was parked with the door ajar, there was no warning chime alerting the driver that the door was opened. The contact also stated that when both turn signals were activated, there was no audio warning. On other occasions, while driving at various speeds with the turn signals activated, there was no audio warning. Additionally, on several occasions, while driving at various speeds, the seat belts were not engaged and there was no warning chime alerting the driver of the issue. The vehicle was not diagnosed or repaired. The contact believed that the failure was associated with NHTSA Campaign Number: 14V301000 (Electrical System, Seat Belts). The manufacturer was made aware of the failure. The failure mileage was approximately 41,000.

Used the remote start feature to warm up my truck (automatically turns on rear defrost). Upon entering the vehicle I could smell smoke. While driving I turned around and noticed smoke pouring from rear window. I turned off the rear defrost and the window exploded! I contacted the dealer and they claimed the recall had already been completed and they could not assist me.

Rear window started smoking while rear defrost was turned on the rubber seal started melting smoke started coming between cabe and truck bed window scattered after I got out and closed the door

The vehicle lost power steering and being an electronic system, there is nowhere to add fluid to the system. There was a recall for this issue from 2018 to 2019 and the repair service was performed on this vehicle. I now have to pay for the repairs that were once covered under a recall for a known issue.

Electric power steering ,loses power ,on board computer lost memory ,clock went 0,active fuel management mileage recorder to 0,M/L smog number to no ready

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated that while stopped at a STOP sign and attempting to drive off, the doors locked, the vehicle lost power steering functionality and lost motive power and stalled. The contact was able to shift into neutral and move out of the way of traffic. The contact then restarted the vehicle and drove to his destination. The contact stated that the failure had occurred twice. The dealer was contacted and made aware of the failure. The contact stated that a representative inspected the vehicle but was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 116,000.

While going through an S curve the dash lights went dark and engine quit while pulling a trailer. Had no power steering or brakes. Put it in neutral and was able to get engine started again before hitting a car coming from the other direction. On initial start up, there was a message "action required, open then close driver window". All dash settings for radio, information and media had to be reset. This is dangerous, vehicle shutting down randomly, as it could cause accident and injury or even death.

#1- I had my truck in a few years ago for a brake issues that they said was a computer reprogramming issue and vacuum pump. They repaired and the issue slowly came back. Now it feels as if there is little to no assist with braking and stopping distance is growing. I feel like my family is at risk if there were ever to be a time I need to brake hard or fast. Theire are no warning lamps but obvious excessive braking effort and can feel the brake rotors through the pedal. #2- Intermittently, at low speeds, pulling into parking lots and parking spaces while turning the steering wheel, electrical power cuts out, steering wheel jerks out of hand, and a dash light comes on saying "service stabilitrack". This is a huge safety issue that could certainly cause an accident. I have Googled this very common issue with my...

Power steering randomly stops working, sometimes warning lights come on when this happens. There is a recall affecting 2015 chevy vehicles that is related to a defect in the power steering system that causes similar issues, but my VIN is not part of the recall. How can I get the manufacturer to fix this?

At low speed power steering will cut off and kick in opposite direction, radio will blank out followed by service stabilitrak warning has happened multiple times in last few wks since first of Sept 2023

I have been having problems with my vehicle cutting off and I would jump start. It often gave be a theft code on the dash. Until one day it stops starting all together. Now to find out there is a recall on the electrical system I was told by my mechanic please contact me so I can get this resolved will be with out of transportation, paying insurance and a car note thank you.

Truck shuts down, power steering quits working and forces vehicle wheel back other direction, stablitrack light comes on, ac shuts down, truck loses power, sometimes completely shuts down while turning.

[XXX]. My 2015 silverado with the 5.3 randomly just shuts off. When slowing down and at 10 to 20 mph, the Instrument panel goes dark, the engine shuts off, no power steering or brakes and almost crashed into someone. I turn the key it starts back up, but have to reset time and date and lose radio channels. Once a message about stabilitrac flashed after starting back up. Truck can be for Inspection. This problem happened 4 times in one morning it is being looked at now on [XXX]. There hasn't been any warnings. It just shuts down. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving on the highway, I came to stop in traffic. Power shut off in truck. I had AC on and radio on and everything turned off.Dashboard went blank as well. Power restored and service stabiltrack notification came on. This happened multiple times while on road. Got off as soon as possible and took to dealership. Dealership has yet to get back to us. I believe this is related to the two recalls that I had completed. At no point should I lose power in the vehicle and not be able to control the car. This could have been a tragedy if driving at full speed and for vehicle to shut down.

“Service trailer brake system” this message randomly appears with no trailer connected at all, i recently bought a brand new trailer and im scared to tow it since there is no current fix for this error message on the display, it comes on randomly and will not stop popping up and dinging it is a huge distraction as it repeatedly does it over and over, also when it does this you lose trailer brakes which is very unsafe especially in the mountains. This has been a known issue for years that is why i don’t understand why there is only a fix for the 22-23 models. Gm needs to address this issue as there are tons and tons of complaints, it is never safe to lose trailer brakes especially with all that weight you could burn up the truck brakes and cause an accident or if the trailer starts swaying...

The component or system is the Electronic Power Steering System and my vehicle is available for inspection at any time needed. Although this started last week and is happening randomly it has happened three times all in the last week. While making a turn I lose all power steering, in fact all power and have to try to maneuver the truck safely. This is the same issue that GM issued a recall for GM recall 18289. NHTSA Campaign # 18V586. This problem is very dangerous and I almost collided head on due to this problem when leaving work and in a turning zone. The first time it happened my mom said it jerked the steering wheel. lost all power and she had to manhandle it to keep from hitting a child that was walking across the parking lot at a Dollar General store. I need to see about getting my...

When turning on defroster heard a buzzing/hissing/sizzling sounds. Rear defroster wires extremely hot and burning smell coming from wires. GM knows about this problem but only issued a recall in Canada and I am in US

Truck stalles when wheel is turned at idle or low speed. No warning just dies. No problem restarting.

I own a 2015 Chevy Silverado LD. There was a recall that included (among other vehicles) the 2014 Silverado LD and the 2015 Silverado HD but not the 2015 LD. It is for the base radio audio output not working causing audible safety warnings to not work as well. I have this problem on my truck. I took the truck to a local dealership but they claimed to have no knowledge of this faulty condition.

There was a buzzing from rear window while defroster was ON. Upon closer inspection, there was smoke coming from the defroster electrical connections while on and there was an electrical arcing sound present.

Service trailer brake system warning will come up on screen when there’s nothing wrong with it. It is completely random and distracts you from driving with 3 loud chimes and no way to change to volume of the chimes. Most times it will come on 5-10 times in a row and then go away. I’ve tried fixing it like countless others but no success. The chimes are so loud and distracting it causes headaches and frustration

Hard brake petal at low speed when I'm trying to park vehicle, dealership kept truck for five days, service Rep said, he couldn't get to my truck,. I picked up my truck and I took it to another Dealership they claimed that my brakes problem was completed, Matick Chevrolet Jan 6, 2023 . Problem # ,2 High Pressure Fuel pump needs replacing as per Matick Chevrolet inspection on 1/6/2023 their Mechanic inspected my truck , I have their invoice stating that and two more invoices from ,one from Pep Boy's diagnosed bad Fuel pump and another invoice from Good Year Tires diagnosing bad High Pressure Fuel pump is bad with 45 psi. Pep Boy's also diagnosed my Brakes Vacuum Booster Pump needs replacing and remove and replace another Brake Booster vacuum pump and they listed two different parts numbers, #3 my Electrical System causes my dashboard monitor to jump back...

While driving at low speeds (approx 5-10 mph) the brake pedal became stiff and very difficult to stop. This issue happened with no prior warning or indication of the issue. As a result of this issue severe damage to personal property housing and vehicles was nearly missed. Upon research this has been a common issue for GM vehicles specifically trucks and SUVs.

Turned my truck on and rear defrost was active. Sizzling sound started occurring in rear window. Inspected sound and saw a small amber electrical fire starting. Immediately turned off defroster. After about 10 seconds I heard a loud “pop” noise and saw that the rear driver’s side of the rear window was shattered.

Rear window defroster began to SMOKE while being on for a few minutes (under 6). Smoke was visible next to sliding window.

The contact owns a 2015 Chevrolet Silverado 1500. The contact stated while driving and making a turn in the driveway, the vehicle lost electrical power inadvertently. The contact was able to restart the vehicle after approximately two minutes. The contact stated that the failure had been reoccurring while driving and making a turn. The contact stated that the failure reoccurred while his wife was driving on a busy road. The contact’s wife was unable to veer to the side of the road. The contact’s wife was able to restart the vehicle after approximately four minutes. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 142,000. The contact stated that the battery and the power distribution fuse box have been replaced.

My control panel keeps flicking the radio with phantom touches to the touch screen. It is making all sorts of gyrations, shifting over to my speed indicator screen, at times, the radio turns on by itself, very loud. I find online that many people are having similar issues with this condition. This is very distracting to the driver while driving on the highway, it should be considered a safety issue. Can you please research how many vehicles are having this issue? Thank you, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Trailer brake system I have owned this Chevy Silverado 2015 since 2018 when I purchased it certified from a used car dealership in upstate New York. About one year into owning the vehicle I started to experience an alarm that was flash trailer brake system. This alarm would beep and flash in my center consul restricting me from sight distracting me from driving and is almost impossible to drive the car without distraction. I checked YouTube I called the manufacture I did so much to figure out what was going on and why this was happening considering I do not show any thing I did not understand why the trailer brake would cause such a problem considering I never told anything.After about three months of driving the car this trailer brake system alarm stopped. Now recently 2022 the trailer break system alarm is back and flashes nonstop and is relentless....

The electrical system randomly shuts down. It has done this multiple times in the past several months. Everything shuts off, including engine, power steering, etc. It has done this both while sitting idle and when driving. Most times, it will come back on after a few seconds but I have had to coast off the roadway, and have it towed back home. This is VERY DANGEROUS!!! Fortunately, the times it has shut down while driving has been during daylight hours because if this were to happen at night, I would lose all lights, therefore making a serious crash almost certain.

NHTSA campaign number 18V586. GM’s recall is 18289. Power steering at low speeds with voltage drop causes power steering to lose control

Service Trailer Brake light comes on continuously making it very distractive when driving no matter if you dismiss the message on the dash.

While driving my dash and power steering would go out suddenly without any warning and last for several minutes before regaining electrical power. Engine would still be operating and I was still able to drive it but I lost all power and electrical indicators when it would happen.