2015 CHEVROLET SILVERADO 1500 — Problems, Recalls & Safety Data

In Michigan- stopped for lunch - used remote start as always when it’s cold. Came out and got back on the road and about ten minutes later a loud bang and the back window shattered. A quick google said it’s a known problem on this model with the power sliding window due to the rear defrost and there’s a recall for Canada and 10 us states but Illinois isn’t covered. Hard to understand when it’s the same part number. GM customer service rep also stated they won’t cover it when we called the corporate office. If we’d been alerted we would’ve disabled the rear defrost long ago. Frightening to know it’s a fire hazard and what if we’d had children in the back.

Driving the truck, a nut fell against my foot. I pulled over and looked underneath to where this Nut could have come from. I realized that the brake pedal was very loose. I did a Google search to see what break pedal Nut could have loosened and Fallen off. I identified that there was a recall for the brake pedal pivot nut on these trucks. From that, I looked up to that section and found that the nut did indeed come from that part. I called the local Chevrolet dealership and they informed me that my VIN number was not part of that recall list. It is obvious that General Motors left the numbers off of that recall for vehicles that are still being affected by that problem. I called General Motors customer service and spoke to Brandy at customer service and she was not willing to help and only told me to contact this government agency. In order to prevent fatalities of innocent lives, I am reporting this.

The failure occurred in the rear sliding window defroster electrical system, specifically at the left-side electrical connection of the power sliding rear window. The component overheated and ignited, causing fire damage and shattering of the rear left portion of the window. The vehicle and damaged components are currently available for inspection upon request. The defect resulted in an active electrical fire during normal vehicle operation (remote start while warming up). This posed a serious risk of vehicle fire, injury to occupants, and potential spread to nearby vehicles or structures. As a firefighter, I recognized the danger and immediately shut off the vehicle and ventilated it; without trained action, the incident could have resulted in a total vehicle loss or more severe consequences. Yes. Copeland Chevrolet in Hudson, Massachusetts inspected the vehicle and confirmed that the damage was consistent with the known defect in the rear sliding window defroster system, consistent with GM Customer Satisfaction Program XXX. The vehicle has been inspected by an authorized GM dealership (Copeland Chevrolet). No police or insurance inspection has occurred to date. No warning lamps, messages, or prior symptoms were present. The failure occurred suddenly and without warning during normal operation while the vehicle was warming up using the factory-installed remote start. This is a known defect acknowledged by GM under Customer Satisfaction Program XXX (which expired in 2022), which described overheating and fire risk in the rear sliding window defroster electrical connection. That program was limited by state and excluded Massachusetts, so I was never notified despite identical risk. This same defect is currently the subject of an active safety recall in Canada, where it is treated as a fire hazard requiring corrective action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2015 Chevrolet Silverado complete engine failure. At 143,000 miles the engine failed because of the displacement on demand fuel injection system/lifters. Lifter failed without warning, destroyed the camshaft, cam bearing and crank and crank bearings. Chevrolet/GM were no help at all and took on responsibility for building defective engines they knew would fail after the warranty expired. I ended up spending nearly $17,000 to have a remanufactured engine installed.

Vehicle has electrical issues with headlamps flickering and power steering loss (which is electronic) at lower speeds. Power and radio intermittently cut out momentarily and on occasion a "stabilitrac loss" warning flashes. Looking online, many consumers experience this issue which appears to be due to faulty ground or battery connections and many have reported complete loss of power at highway speeds resulting in accidents. This appears on several Chevrolet vehicles, but especially on the Silverado and GMC Sierra 2014-2017 models. I am very surprised a recall has not been issued yet for this very dangerous and potentially fatal issue.