2005 VOLKSWAGEN JETTA Power Train Problems

TUGGING OCCURS, BUT RARELY. THE CAR DRIVES SMOOTHLY BUT WILL DO A BIT OF A TUGGING. IT HAD THIS PROBLEM FOR A WHILE EVER SINCE IT WAS PURCHASED BACK IN 2015 IT WAS WORSE AT THOSE TIMES BUT FIXED THROUGHOUT THE YEARS. I'VE INVESTED MAJOR MONEY TO GET THE TRANSMISSION, MOTOR, AND SO ON OF WHAT THE MECHANIC HAS TOLD ME OF THE PROBLEMS THE CAR HAS HAD FIXED. *TR

THE TRANSMISSION IS TERRIBLY MADE. THERE IS ALSO AN ISSUE WITH THE FUEL INJECTION THAT DOES NOT ALLOW THE CAR TO RECEIVE THE CORRECT FUEL AS WELL AS THE GAS TANK. THE CAR JERKS BECAUSE OF THE GAS TANK AND THE CODES READ AD IF THE CAP NEEDS TO BE REPLACED BUT THE WHOLE GAS TANK NEEDS TO BE REPLACED.

2005 VW.JETTA - VIN# [XXX]. THE TRANSMISSION SHIFTS HARD & DOWN SHIFT HARD WHEN THE CAR HAS RUN FOR A PERIOD OF TIME DURING TRAVEL. ALSO, THE FAULTY AIR BAG LIGHT COMES ON WHEN THE CAR IS FIRST STARTED AND MAY SHOW INTERMITTENTLY WHILE DRIVING. THE CATALYTIC CONVERTER & 02 SENSOR HAVE BEEN REPLACED BUT THE CODES STILL SHOW WHEN PUT ON THE MACHINE. THE IGNITION KEY GETS STUCK IN THE IGNITION. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

MY CAR HAVES ALL THE GEARS HIGHLIGHTED ON THE DISPLAY AND OCCASIONALLY WHEN I'M DRIVING IT GETS STUCK ON A LOW GEAR WHEN I COME TO A COMPLETE STOP AND TRY TO START GOING OR IF IM IN THE HIGHWAY IT ALL OF A SUDDEN DECIDES TO SHIFT TO NEUTRAL GEAR MAKING ME SLOW DOWN ALL OF A SUDDEN WITH POTENTIAL TO HIT THE PERSON BEHIND ME OR CREATING A CATASTROPHIC ACCIDENT WITH MANY INJURIES OR EVEN DEATH TO DOES I MIGHT HIT JUST BECAUSE OF MY FAULTY TRANSMISSION AND I HAVE LOOK UP THE PROBLEM AND THERE ARE MANY PEOPLE WITH THE SAME TRANSMISSION TROUBLE THE NHTSA SEND A RECALL FOR THE 2009-2010 BUT THE PREVIOUS MODELS HAVE ALSO THE SAME PROBLEMS FOR IT SO PLEASE AT LEAST OPEN AN INVESTIGATION ABOUT IT SO THAT WAY ME AND MY FELLOW DRIVERS UNDERSTAND THE PROBLEM THAT KEEPS GOING ON.

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING 65 MPH, THE VEHICLE DID NOT ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE HAD TO BE TURNED OFF AND RESTARTED TO REMEDY THE FAILURE. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 279,000. THE VIN WAS NOT AVAILABLE. *TT CONSUMER STATED INCIDENT HAPPENS WHEN DRIVING IN THE RAIN.*JB

AXLE BOLTS WORKED LOOSE AND AXLE PUNCTURED TRANSMISSION HOUSING ON DRIVERS SIDE WITH OUT WARNING.

WE HAVE A 2005.5 VW JETTA AND HAVE BEEN EXPERIENCING HARD SHIFTING WHILE DRIVING FOR ABOUT A YEAR AND HALF . MORE RECENTLY THE GEARS ARE STALLING TO SHIFT WE WERE DRIVING IN A LOCAL STREET WHEN OUR CAR WOULD NOT SHIFT INTO 4TH GEAR THE ENGINE WOULD REV BUT WOULD NOT SHIFT. IT IS VERY UNSAFE FOR THIS TO HAPPEN WHEN YOU ARE ON BUSY ROADS OR MERGING ON TO HIGHWAYS ETC. WE HAVE NOT USED OUR CAR SINCE AND OUR MECHANIC TOLD US IT WAS U SAFE TO DRIVE. I CAN'T BELIEVE VW HAS NOT TAKEN OWNERSHIP FOR THERE MISTAKE AND MAKE A RECALL. OUR CAR JUST PASSED 100,000K AND SHOULD NOT BE HAVING THIS PROBLEM . TO FIX THE PROBLEM WE WERE TOLD ITS THE VALVE BODY AND THE PART ITSELF IS $1,200 NOT INCLUDING LABOR COST.

I HAVE AN EARLY MODEL MKV TDI JETTA , WITH AROUND 87,000 MILES ON IT. YESTERDAY, ON THE WAY HOME, THE DSG DUAL MASS FLYWHEEL LET GO WITH PIECES OF METAL COMING OUT ONTO THE ROAD AND TRAFFIC. I LOOKED UP THIS ON THE TDICLUB SITE AND FOUND NUMEROUS ISSUES WITH THIS PART IN EARLY PRODUCTION, WHICH IS NOT PART OF MAINTENANCE. IS THERE A SAFETY RECALL OR OTHER TSB ON THIS? I CANT DRIVE THE CAR AND JUST MADE IT HOME. IT WAS SCAREY.

THE REASON FOR THE LATE POST IS THAT I JUST DISCOVERED THIS SITE. I PURCHASED MY 2005 VW JETTA BRAND NEW IN 2005. IT HAD 61 MILES ON IT. I HAD THE CAR FOR ABOUT 5 MONTHS WHEN IT WAS SHIFTING VERY HARD AND NEARLY SNAPPING MY NECK. I TOOK THE VEHICLE TO THE VW DEALERSHIP OVER 30 TIMES WITHIN A YEARS TIME AND THEY CONTINUED TO TELL ME NOTHING WAS WRONG. THEY KEPT THE CAR AND DROVE IT AND IT OF COURSE IT WOULD NOT HAPPEN WHILE THEY DROVE IT. THEY ACTUALLY TOLD ME I WAS DRIVING THE CAR INCORRECTLY (WHAT THAT MEANS I DON'T KNOW). I WAS UNAWARE OF THE LEMON LAW AT THE TIME. THE CAR CONTINUED TO SHIFT EXTREMELY HARD. FINALLY AFTER IT WENT BACK FOR THE 30TH TIME I DEMANDED THAT THEY KEEP THE CAR AND DRIVE IT UNTIL IT HAPPENED. FINALLY AFTER 2 WEEKS...

THERE IS A PROBLEM WITH TRANSMISSION OF JETTAS ONCE I WAS ON THE HIGHWAY AND MY VEHICLE STALLED I WAS LUCKY AS THERE WERE NO VEHICLE BEHIND ME OTHER WISE THAT WOULD HAVE BEEN A CATASTROPHIC SITUATION FOR BOTH ME AND THE DRIVER BEHIND ME. I PULL OVER THE SHOULDER AND WAITED AND STARTED THE VEHICLE I WAS ABLE TO DRIVE AFTER SOME TIME. THIS IS A KNOWN ISSUE FOR ALL THE JETTAS VOLKSWAGEN KNOWS ABOUT THIS AND THEY EXTENDED THE WARRANTY FOR SOMETIME. THIS PROBLEM WITH TRANSMISSION VALVE BODY HAPPENS AFTER CERTAIN MILES. I AM OUT OF THIS COVERAGE AND THIS IS A SAFETY ISSUE AND I WOULD REQUEST THAT THERE SHOULD BE A SAFETY RECALL SO THAT THIS SHOULD NOT HAPPEN WITH ANY ONE ELSE. PLEASE TAKE ACTION AS SOON AS POSSIBLE. *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 93,000.

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE FAILED TO SHIFT GEARS. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE VALVE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 76,500.

I BOUGHT THE CAR IN MARCH OF 2012 AND ON THE WAY HOME I NOTICED THAT THE CAR WASN'T SHIFTING AT THE APPROPRIATE TIMES AND THERE WAS A TRANSMISSION ISSUE. AFTER I GOT HOME I CALLED THE DEALER AND ASK THEM OF THE CAR HAD ANY PREVIOUS ISSUES WITH THE TRANSMISSION, HE SAID NO AND NATURALLY I HAD TO REPLACE THE TRANSMISSION THAT WAS COMPATIBLE. 2 YEARS LATER I AM NOW HAVING THE SAME ISSUE WITH THE CAR AND I DID RESEARCH AND NOTICED I AM NOT THE ONLY ONE THERE ARE HUNDREDS OF PEOPLE I HAVE MY CAR AND ARE HAVING THE SAME EXACT ISSUE I AM. THAT BEING SAID THIS ISN'T A COINCIDENCE AND I AM IN THE SAME SITUATION I WASN'T TWO YEARS AGO HAVING TO PAY $1200 FOR A FIXED OR A NEW TRANSMISSION. THE REASON I KNOW THIS IS WHEN THE CAR IS IN FIRST...

I HAVE BEEN HAVING ISSUES ON MY 2005.5 VW JETTA FOR THE LAST SEVERAL MONTHS WITH IT SHIFTING HARD OR NOT GOING INTO GEAR. IT HAPPENS EVERY TIME THE CAR IS DRIVEN, SO MUCH TO THE POINT THAT I WILL NOT LET MY DAUGHTER OR WIFE DRIVE THE CAR AS I DO NOT FEEL IT IS SAFE FOR THEM. THEY HAVE BEEN STUCK IN THE MIDDLE OF THE ROAD AND THE CAR WOULD JUST SIT THERE AND REV, BUT NEVER ENGAGE IN DRIVE OR IT WOULD SHIFT SO HARD THAT THEY FELT LIKE THEY HAD WHIPLASH. I TOOK IT TO A REPAIR SHOP AND THEY TOLD ME IT NEEDS A NEW TRANSMISSION WITH THE PRICE SOMEWHERE BETWEEN $3-5K, PROBABLE CLOSE TO $7K IF YOU GO TO THE DEALER. AFTER DOING SOME RESEARCH ONLINE, IT APPEARS THIS IS A COMMON ISSUE AND VW IS AWARE OF THE PROBLEM, BUT SO FAR...

I BROUGHT MY CAR IN FOR AN EARLY 65K MILE SERVICE BECAUSE I NOTICED MY TRANSMISSION WAS NOT SHIFTING PROPERLY & WAS GETTING PROGRESSIVELY WORSE. I THOUGHT HAVING THE 85K SERVICE DONE WOULD TAKE CARE OF THAT, IT DIDN'T & IT GOT WORSE, SO I BROUGHT IT BACK TO THE DEALER. THE DEALER INDICATED THAT THE VALVE BODY WAS FAULTY & THAT IT WOULD COST $1000+ TO FIX. I JUST PAID OVER $1000 FOR THE K MAINTENANCE & OTHER REPAIRS; I CAN'T AFFORD THE ADDITIONAL EXPENSE. [XXX], IN THE SERVICE DEPARTMENT, STATED THAT THE ISSUE WAS ??NOT THAT BAD, ...THAT THEY SEE MUCH WORSE, ?WON'T BE A PROBLEM TO KEEP DRIVING IT...?. I WASN'T CONVINCED THAT A MALFUNCTIONING VALVE BODY WOULDN'T CAUSE ADDITIONAL PROBLEMS, BECAUSE WHEN I AM DRIVING IT FEELS LIKE THE TRANSMISSION IS ABOUT TO DROP OUT OF THE CAR & THE CAR HESITATES TO THE POINT THAT...

I WAS DRIVING ON THE FREEWAY WHEN AN ACCIDENT IN FRONT OF ME CAUSED ME TO ABRUPTLY STOP. IN ORDER FOR ME TO BACK UP AND GO AROUND, I HAD TO GET OUT THE VEHICLE AND PUSH IT BACKWARDS DURING RUSH HOUR TRAFFIC. *TR

THE CAR WOULD BUCK AND BUCK THEN GO INTO GEAR , THEN IT WOULD BUCK GET STUCK IN 3RD OR 4TH GEAR I WOULD HAVE TO TURN THE CAR OFF LET IT SIT THEN TURN IT BACK ON . THE PRNDS PANEL WOULD ALL LIGHT UP AND STAY ON AND SOMETIMES GO OFF IF THE CAR SAT FOR LIKE 2-3 DAYS BUT THE LIGHT WOULD STAY ON AND THE CAR WOULD DO THE SAME THING . THE TRANSMISSION WENT OUT THE MECHANIC STATED THE 3RD OR 4TH GEAR WAS STRIPPED AND THAT IT WILL COST ME ANYWHERE FROM 4K TO7K TO GET IT FIXED. *TR

I HAVE A VW JETTA 2005 THAT HAS THE 2.5 ENGINE. FOR THE LAST THREE MONTHS, THE AUTOMATIC TRANSMISSION HAS STARTED SHIFTING GEARS BY ITSELF IN HARD SHIFTS, MOSTLY FROM 1ST TO 2ND AT ODD TIMES. I WAS TOLD THIS WAS A KNOWN PROBLEM IN THE VWS AND REQUIRED A TRANSMISSION REBUILD. (I'VE HEARD THAT A NUMBER OF TIME). I HAD TO HAVE THE TRANSMISSION REBUILT AT A COST OF $4,000 TO END THE PROBLEM. *TR

I WROTE TO YOU ABOUT A MONTH AGO ABOUT RECALLING THE 2005 JETTA. NOTHING CAME OUT OF IT. IT IS MY FIRM BELIEF THAT THERE IS SOMETHING WRONG WITH THE TRANSMISSION. GOOGLE THE PROBLEMS WITH THE 2005 JETTA AND YOU WILL SEE TONS ABOUT COMPLAINTS REGARDING THEIR TRANSMISSION WOES. PLEASE BE OBJECTIVE IN YOUR INVESTIGATION. *TR

WE BOUGHT THIS CAR FROM A FIRST OWNER IN 2010 FOR MY DAUGHTER WHO WAS THEN A SENIOR AT UC DAVIS. NO PROBLEM FOR THE FIRST 2 YEARS BUT 2013 SEEMS TO BE THE BEGINNING OF SOME PROBLEMS. THE MOST MAJOR ONE IS THE TRANSMISSION. THERE IS A SLIPPAGE ON 2ND, 3RD, AND 4TH GEARS. THERE IS A JOLT ACCOMPANYING THE SLIPPAGE AND IF THERE IS A BABY ONBOARD, I PROBABLY FEEL THE BABY WILL BE SUFFERING SOME KIND OF PAIN. CHECKED THE INTERNET FOR SIMILAR COMPLAINTS FROM OWNERS OF THE SAME MODEL AND SEEMS THIS IS A COMMON PROBLEM WITH THE 2005 JETTA BUT THERE WAS NO RECALL. PLEASE INVESTIGATE. *TR

07/22/13 I BROUGHT MY CAR IN FOR AN EARLY 100K MILE SERVICE BECAUSE I NOTICED MY TRANSMISSION WAS NOT SHIFTING PROPERLY & WAS GETTING PROGRESSIVELY WORSE. I THOUGHT HAVING THE 100K SERVICE DONE WOULD TAKE CARE OF THAT, IT DIDN'T & IT GOT WORSE, SO I BROUGHT IT BACK TO THE DEALER. THE DEALER INDICATED THAT THE VALVE BODY WAS FAULTY & THAT IT WOULD COST $1000+ TO FIX. I JUST PAID OVER $1000 FOR THE 100K MAINTENANCE & OTHER REPAIRS; I CAN'T AFFORD THE ADDITIONAL EXPENSE. [XXX], IN THE SERVICE DEPARTMENT, STATED THAT THE ISSUE WAS ??NOT THAT BAD, ...THAT THEY SEE MUCH WORSE, ?WON'T BE A PROBLEM TO KEEP DRIVING IT...?. I WASN'T CONVINCED THAT A MALFUNCTIONING VALVE BODY WOULDN'T CAUSE ADDITIONAL PROBLEMS, BECAUSE WHEN I AM DRIVING IT FEELS LIKE THE TRANSMISSION IS ABOUT TO DROP OUT OF THE CAR & THE CAR HESITATES TO THE POINT...

2005.5 JETTA--VEHICLE HAS ROUGH SHIFTING BETWEEN 2ND AND 3RD GEARS. AS WELL AS DOWNSHIFTING. WHILE DRIVING ON A MOUNTAINSIDE, GOING 65 MPH, THE CAR SUDDENLY DOWNSHIFTED TO 3RD GEAR AND WOULD NOT ACCELERATE. I HAD TO PULL OVER ON THE SIDE OF A MOUNTAIN, WITH CARS FLYING BY ME. THE CAR WOULD NOT SHIFT GEARS UNTIL TURNED OFF AND ON AGAIN. THIS IS NOW HAPPENING DURING REGULAR ACCELERATION AT LOW SPEEDS. THIS IS A HUGE SAFETY CONCERN, AS I COULD HAVE BEEN REAR ENDED BY ANOTHER VEHICLE DUE TO LOSS OF POWER/SPEED. *TR

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE LOST ACCELERATION POWER WHILE ATTEMPTING TO MERGE INTO HIGHWAY TRAFFIC. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE TRANSMISSION VALVE BODY HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 86,000.

MY 2005 VW JETTA GLI STALLED SUDDENLY WHILE I WAS DRIVING @ 35-MPH. AFTER PULLING OVER AND OPENING THE HOOD TO ASSESS DAMAGE, I TURNED THE IGNITION KEY BUT ALL I HEARD WAS THE STARTER BEING ENGAGED. ONCE THE CAR WAS TOWED TO AN INDEPENDENT REPAIR SHOP, THE TECHNICIAN INFORMED ME THE TIMING BELT BROKE/SNAPPED. I WAS SKEPTICAL BECAUSE MY OWNER'S MANUAL SAYS TIMING BELTS SHOULD BE REPLACED AT 110,000 MILES ACCORDING TO VW'S RECOMMENDED MAINTENANCE SCHEDULE. DURING REPAIRS, THE TECHNICIAN SAID THAT MY VALVES WERE BENT BECAUSE THE 1.8T IS AN INTERFERENCE ENGINE WHICH MEANS THAT CAMS, ROCKERS AND LIFTERS MUST BE REMOVED IN ORDER FOR THE CYLINDER HEAD TO BE SENT TO A MACHINE SHOP FOR ADDITIONAL REPAIRS. TOTAL COSTS = $3,865.66. THERE WAS A CLASS ACTION LAWSUIT AGAINST VW TIMING BELTS BUT I WAS DENIED REIMBURSEMENT BY THE ADMINISTER/CUSTODIAN CLAIMS WERE NO LONGER ACCEPTED AFTER 2009. I...

TL* THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. THE CONTACT STATED THAT SHE NOTICED THE TRUNK FAILED TO CLOSE. THE CONTACT HAD TO SLAM THE TRUNK SEVERAL TIMES IN ORDER FOR IT TO CLOSE PROPERLY. ADDITIONALLY, THE FRONT DRIVER SIDE DOOR FAILED TO LOCK AND THE OPEN DOOR WARNING LIGHT ILLUMINATED CONSTANTLY. THE CONTACT ALSO STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE JERKED FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,375. ... UPDATED 02/28/13 *BF UPDATED 03/11/13

HI, SO MY 2005.5 2.5L VOLKSWAGEN JETTA STARTED MAKING NOISES UPON ACCELERATION AND THE ENGINE WOULD SHIFT QUITE HEAVILY DURING IDLING. THE CHECK ENGINE LIGHT WENT ON AND I TOOK THE CAR TO DEALERSHIP. APPARENTLY, THERE IS AN ISSUE WITH THE TIMING CHAINS OF THE ENGINE. NEVER MISSED A MAINTENANCE, AFTER ONLY 68,000 MILES IT DOESN'T SEEM OKAY THAT TIMING CHAINS ARE ALREADY AFFECTED. AFTER LOOKING AT A FEW FORUMS ONLINE, IT SEEMS THAT THIS IS A VERY COMMON PROBLEM FOR VOLKSWAGEN JETTAS FROM THAT TIME. PLEASE INVESTIGATE! THANK YOU. *TR

TRANSMISSION FAILS TO ENGAGE INTO THIRD GEAR, THEN ENGINE REVS UP, THEN SLAMS INTO GEAR. TRANSMISSION STAYS IN THIRD GEAR REGARDLESS OF SPEED. TRANSMISSION STAYS IN FIFTH GEAR REGARDLESS OF SPEED. *TR

I PURCHASED THIS CAR FROM A DEALERSHIP ON 10-8-2012 UP IN THE WASHINGTON, D.C. AREA AND DROVE IT BACK HOME TO MY HOUSE IN SC. EVERYTHING WAS FINE ON THE WAY HOME. THE VERY NEXT DAY ON MY WAY INTO WORK THE CAR HESITATED WHEN IT WAS SUPPOSED TO SHIFT FROM 3RD GEAR TO 4TH GEAR AND THEN SUDDENLY DOWNSHIFTED ALL THE WAY BACK TO 1ST GEAR WHICH MADE THE CAR DE-ACCELERATE FROM 35-40MPH TO 10MPH WITHIN 40 FEET OR SO. THE ENGINE REVVED TO 6000 PLUS RPMS WHICH SCARED ME BUT NOT AS MUCH AS THE BIG TRUCK THAT WAS TOWING A TRAILER THAT HAD TO SKID OFF THE ROAD AND GO AROUND ME TO AVOID AN ACCIDENT. THIS IS NOW A DAILY OCCURRENCE. I CARRY MY 16 MONTH OLD DAUGHTER AROUND IN THIS CAR AND I'M SCARED TO DEATH THAT SOMEONE IS GOING TO SMASH INTO THE BACK...

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

VEHICLE HAS MANUAL TRANSMISSION, DRIVER SELECTED FIRST GEAR AT AN INTERSECTION, PULLED AWAY FROM LIGHT WHEN IT CHANGED TO GREEN, TRIED TO CHANGE TO SECOND GEAR, HOWEVER GEAR LEVER STUCK IN FIRST GEAR, WOULD NOT MOVE INTO NEUTRAL, LUCKILY DRIVER HAD ENOUGH FORWARD MOMENTUM TO CLEAR INTERSECTION AND ROLL OFF TO THE SIDE OF THE ROAD. WITH ENGINE RUNNING DRIVER IS UNABLE TO SELECT A GEAR, ONLY WAY TO PUT TRANSMISSION INTO A GEAR IS TO TURN OFF THE ENGINE, VEHICLE TAKEN TO VOLKSWAGEN DEALER FOR REPAIR, CLUTCH PRESSURE PLATE HAD CRACKED IN HALF. *JS

AS I TRY TO ACCELERATE THE GEARS JUMP ERRADICALLY.

2005 .5 MODEL YEAR VOLKSWAGEN JETTA TDI (TURBODIESEL) WITH AUTOMATIC (DSG) TRANSMISSION. ON SEVERAL OCCASIONS WHILE DRIVING CAR, THE TRANSMISSION WILL FOR NO REASON SHIFT INTO NEUTRAL, AND ALL TRANSMISSION INDICATOR LIGHTS 'PRNDS' WILL FLASH SIMULTANEOUSLY. SO FAR, IF ENGINE IS SHUT OFF AND THEN RESTARTED, THE TRANSMISSION WILL AGAIN FUNCTION NORMALLY. I BELIEVE THIS HAS HAPPENED 4 OR 5 TIMES NOW. ON ONE OCCASION, THE CAR WAS IN AN INTERSECTION WHEN IT BECAME IMMOVABLE WHICH PRESENTS A SAFETY HAZARD.I CAN SEE THAT THERE IS A MASSIVE AMOUNT OF INFO ON MANY VW INTERNET SITES ABOUT THIS ISSUE, IN FACT IF YOU SIMPLY GOOGLE 'VW DSG FLASHING PRNDS' OR 'VW DSG TRANSMISSION PROBLEMS' ANYONE CAN FIND IT. IT IS A COMMON PROBLEM. I SEE THAT HHTSA HAS BEGUN AN INVESTIGATION BASED ON THIS FOR 2007 THRU 2009 MODEL YEARS, OBVIOUSLY A PROBLEM ON 2005/2006 VW WITH DSG TRANSMISSION AS WELL....

TRANSMISSION FAILURE. WON'T SHIFT FROM SECOND TO FIRST. OR FIRST TO SECOND. IF ENGINE IS VERY HOT IT WILL MOST TIMES BUT NOT AT ALL IF COLD OR WARM. *TR

3 OCT 2011: THIS VEHICLE'S FLYWHEEL ASSY FAILED AT APPROXIMATELY 85,000 MILES. FORTUNATELY, THE FAILURE OCCURRED WHILE I WAS AT A VERY LOW RATE OF SPEED IN A NON-CONGESTED AREA. AFTER THE EVENT, I HAVE COME TO REALIZE THAT THIS IS A KNOWN PROBLEM ON DSG TRANSMISSIONS AS INSTALLED ON A VARIETY OF VW MODELS. VW DOES NOT APPEAR TO BE INTERESTED IN DISCUSSING THIS ISSUE FOR MODEL YEARS 2005 / 2006. I AM ONE OF THE LUCKIER ONES AS I REGULARLY MAKE LONG DISTANCE - INTERSTATE TRIPS WITH FAMILY IN-TOW. VOLKSWAGEN SHOULD BE HELD ACCOUNTABLE TO ACCEPT FULL FINANCIAL RESPONSIBILITY TO NOT ONLY TAKE CARE OF CUSTOMERS WHO HAVE EXPERIENCED SUCH LOW-TIME FAILURES BUT, ALSO, EXPAND ANY RECALL THAT MAY BE IN-PLACE FOR LATER MODELS SO AS TO PREVENT POTENTIAL LIFE-THREATENING ACCIDENTS WITHIN THE OVERALL DRIVING POPULATION. I HAD BEEN DRIVING A "TIME BOMB" FOR ALMOST 5 YEARS AND,...

CHECK ENGINE LIGHT CAME ON WHILE RETURNING HOME AFTER SHOPPING. CAR WAS TOWED TO THE REPAIR SHOP. DIAGNOSIS WAS CATASTROPHIC FAILURE OF ENGINE DUE TO A TIMING CHAIN JUMP ON A 72K MILE, 2.5 LITER, 2005 VW JETTA TWO MONTHS AFTER PURCHASE. *TR

HARD SHIFTING, IT HARD SHIFTS AND IT KEEPS GETTING WORSE. I WAS TOLD IT WAS THE VALVE BODY BUT VOLKSWAGEN DOES NOT WANT TO PAY FOR IT BECAUSE IT IS A FEW MILES OVER THE 100,000 MILE WARRANTY WHEN I HAVE READ MANY THINGS SAYING THAT VOLKSWAGEN WAS HAVING PROBLEMS WITH THE VALVE BODY. *TR

JETTA 2005.5 SEDAN (AUTOMATIC) HARD SHIFTED BETWEEN 2ND & 3TH GEARS, DISPLAYING SHUDDERING AND HESITATION DURING ACCELERATION IN TRAFFIC. SINCE OCTOBER 2010 HARD SHIFTING HAS CONTINUED DAILY AND FREQUENCY OF SHIFTING HESITATION ISSUE HAS WORSENED. HARD SHIFTING WITH HESITATION UP BETWEEN 3TH AND 4TH, AND ALSO HARD SHUDDERING DOWNSHIFT BETWEEN 3RD AND 2ND. DEALER HOOKED VEHICLE TO COMPUTER ON FEB 14, 2011 AND STATED TRANSMISSION HAS NO ERRORS. DEALER WOULD NOT TEST DRIVE FOR LONGER THAN 4 MILES, DEALER STATED HARD SHIFT DID NOT OCCUR IN THAT 4 MILE PERIOD, TEST WAS NOT AT FREEWAY SPEEDS, OWNER WAS NOT IN THE VEHICLE. DEALER STATES VEHICLE IS NOT ELIGIBLE FOR VALVE FIX. VEHICLE SHIFTING FAILURE IS HAZARDOUS AND DANGEROUS HIGHWAY CONDITION.

VW JETTA 2.5L 2005 OUT OF THE BLUE CHECK ENGINE LIGHT CAME ON AT 81,000 MILES. RANDOM MISFIRE AND VACUUM LEAK CODES. TURN OUT TO BE TIMING CHAIN STRETCHED CAUSING THE PROBLEM COST $2000 TO FIX. *TR

WE RECENTLY BOUGHT A 2005 VOLKSWAGEN JETTA (THE NEWER DESIGN ALSO COINCIDED 2005.5) FROM A PRIVATE INDIVIDUAL IN MARCH 2010. WE NOTICED THERE WAS A SLIGHT PROBLEM WITH SHIFTING GEARS THAT CONTINUED TO GET WORSE. IN JUNE 2010 WE TOOK THE CAR TO A LOCAL VOLKSWAGEN DEALER AND DISCUSSED THE PROBLEM. THEY TOLD US IT SOUNDED LIKE THE DUAL MASS FLYWHEEL WAS THE PROBLEM. THAT THERE WAS 2 DIFFERENT MANUFACTURERS THAT MAKE THE FLYWHEELS AND THEY NO LONGER USE ONE OF THE MANUFACTURERS DUE TO DEFECTS AND PROBLEMS WITH THE FLYWHEELS THEY MADE. THEY SAID IT WAS A KNOWN PROBLEM THAT THE FLYWHEELS WERE BAD AND WOULD NEED REPLACED WAY BEFORE THEY WERE SUPPOSE TO. EVEN THOUGH THE PROBLEM WAS KNOWN BY VOLKSWAGEN THEY REFUSED TO FIX REPLACE THE DEFECTIVE PART. THEY SAID WE COULD CONTINUE TO DRIVE IT AND BUT WOULD CONTINUE TO GET WORSE AND END UP TEARING...

2005 VOLKSWAGEN JETTA TDI SEDAN - ENGINE RAN ROUGH AND NOTICED SLIPPAGE AND HESITATION DURING ACCELERATION FROM FULL STOP. REPEATED RESULTS FROM REPAIR SHOP VISITS FOUND NO PROBLEM, WAS TOLD THIS WAS "NORMAL"... THE FAILURE OCCURRED WHILE DRIVING AT NORMAL HWY SPEED. A LOUD BANG FOLLOWED BY COMPLETE ENGINE FAILURE. VISIT TO DEALER CONFIRMED CATASTROPHIC FAILURE OF DUAL MASS FLYWHEEL, CAUSING COLLATERAL DAMAGE TO ENGINE AND TRANSMISSION. REPAIR ESTIMATE WAS FROM $5K TO $15K. VW AND THE DEALER OFFERED NO ASSISTANCE DUE TO VEHICLE OUTSIDE OF MANF WARRANTY PERIOD, DESPITE CAR BEING WELL MAINTAINED BY THE BOOK. RESEARCH ON OWNERS FORUMS AND WEB SHOWS THIS SAME ISSUE IS PREVALENT IN THE 2005-2009 MODEL YEARS. FOUND OVER 3000+ INSTANCES FROM OWNERS COMPLAINING OF THE SAME ISSUE FROM AS LITTLE AS 15K MILES OF USE....ITS CLEAR THIS IS A MANF DEFECT IN THE DUAL MASS FLYWHEEL AND THAT VW HAS NOT RECOGNIZED...

ON FEBRUARY 16TH WHILE RUNNING ERRANDS I PULLED THROUGH A DRIVE THROUGH FOR LUNCH, CAR WAS RUNNING AND SOUNDED JUST FINE, AFTER PULLING AWAY I HEARD A LOUD "SHRIEKING" NOISE AND THEN A CLUNK, THE CAR LOST POWER AND MADE A GRINDING NOISE, I IMMEDIATELY PULLED INTO THE ADJACENT PARKING LOT AND SHUT THE CAR OFF, I WAITED A FEW MINUTES THEN RESTARTED THE CAR IT STARTED JUST FINE BUT SEEMED TO BE IDLING A LITTLE ROUGH, I SHIFTED CAR INTO DRIVE AND LIGHTLY PRESSED THE ACCELERATOR THE GRINDING NOISE WAS PRESENT SO I PUT THE CAR BACK IN PARK AND SHUT OFF THE ENGINE, CALLED AAA AND HAD THE CAR TOWED TO THE DEALERSHIP. THE DEALERSHIP THEN CALLED ME LATER THAT AFTERNOON AND INFORMED ME THAT THE DUAL MASS FLYWHEEL HAD SEPARATED AND WOULD NEED TO BE REPLACED, THEY QUOTED ME $1800 FOR THE REPAIR. I WAS INFORMED THAT...

2005 VOLKSWAGEN JETTA BUCKS AND SHAKES WHILE DRIVING. CONSUMER STATES THAT THE VEHICLE SOUNDS LIKE IT JUST WANTS TO SHUT OFF AND NOT RUN. WHILE VEHICLE WAS IN THE SHOP THE LOANER GOT HIT AND DEALER WOULD NOT RETURN HER CAR UNTIL PAYMENT WAS MADE. *KB THE CONSUMER STATED THE FIRST TIME THE PROBLEM HAPPENED, SHE HAD COME TO A FULL STOP. WHEN SHE WENT TO ACCELERATE, THE VEHICLE ALMOST STALLED, STARTING BUCKING AND WAS SLUGGISH. IMMEDIATELY AFTERWARDS, THE ENGINE LIGHT ILLUMINATED. THE DEALER STATED THE RESET A COMPONENT, HOWEVER 1 MONTH LATER THE PROBLEM RE-SURFACED. THE CONSUMER WAS TOLD THE PROBLEM WAS SEVERAL DIFFERENT THINGS, BUT EACH TIME THE COMPONENTS WERE REPLACED, THE PROBLEM WOULD COME BACK. *JB

TL*THE CONTACT OWNS A 2005 VOLKSWAGEN JETTA. WHILE APPROACHING A STOP AT 70 MPH, THE CONTACT PLACED THE CLUTCH IN AND IT FAILED TO RELEASE. THE VEHICLE HAD TO BE TOWED TO THE DEALER AND THEY STATED THAT THE FAILURE WAS DUE TO DRIVER ERROR. THE CLUTCH WAS REPLACED AND THE DEALER DID NOT CHARGE FOR LABOR. THE PART COST $1,800. THE FAILURE OCCURRED TWICE. THE VEHICLE IS CURRENTLY AT THE DEALER AND THEY HAVE NOT YET DIAGNOSED THE CAUSE OF THE SECOND FAILURE. THE CURRENT MILEAGE WAS 55,000 AND FAILURE MILEAGE WAS 22,000.