2004 VOLKSWAGEN JETTA Electrical System Problems

The contact owns a 2004 Volkswagen Jetta. The contact stated that while driving at an undisclosed speed while it was raining, the windshield wipers were activated; however, the wipers failed to function as intended. The contact stated that the wipers failed to operate. In addition, the contact stated the brake lights failed to function as intended. The contact was informed that the brake lights failed to activate while the brake pedal was depressed. The contact stated that the front driver's side window was closed; however, the driver's front side window was independently lowered. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with an electrical system failure. The contact stated that the battery, the alternator, the fuses, and the windshield wiper motor were all replaced; however, the failure reoccurred. The failure became a persistent failure. The manufacturer was not made aware of...

Unknown, very complex. Multiple issues. Have been addressed as well as parts been replaced however other issues arised that are definitely safety concerns between electrical issues engine motor etc

ALTERNATOR WIRE MELTED PART OF THE BATTERY TOP FUSE BOX. CABLE WAS VERY HOT AND MAY HAVE CAUGHT FIRE IF I HADN'T SMELLED IT FIRST. HAD TO REPLACE THE ALTERNATOR CABLE HARNESS AND FUSE BOX PANEL.

WHILE DRIVING DOWN ROAD EARLY IN MORNING APPROX 2 MILES FROM HOUSE I JUST LEFT FROM MY 2004 JETTA SHUTS DOWN TOTAL LOSS OF ALL POWER I PULLED CAR OVER IN A CHURCH PARKING LOT I SMELLED SMOKE AND COULD SEE SMOKE COMING FROM FIRE WALL I RAISED HOOD AND PULLED BATTERY CABLE OFF I COULD SEE SMPOKE FILLING INSIDE OF MY CAR WALKED AROUND TO DRIVER DOOR TO GET MY PHONE AND I SEEN FUSE BOX ON FIRE.ANOTHER VEHICLE STOPPED TO HELP ME AND HE APPROACHED MY CAR AND THEN CALLED POLICE ,FULL FLAMES WERE COMING FROM MY CAR WITHIN 5 MIN SO I STOOD BACK AND WATCHED MY CAR BURN .FIRE DEPT SHOWED UP AND PUT FIRE OUT MY CAR IS A TOTAL LOSS. IVE HAD ISSUES WITH ALTERNATOR,FUEL PUMP,AIR BAG LIGHT, HEADLIGHTS ARE REALLY DIM EVEN ON BRIGHT.NOTHING BUT ISSUES WITH THIS CAR SINCE I GOT IT....

THE INSULATION ON THE WIRING OF THE LEFT HEADLIGHT IS DETERIORATED AND FALLING OFF LEAVING THE WIRES BARE AND AT RISK OF SHORTING OUT.

PASSENGER SEAT (FRONT SEAT) HEATING ELEMENT IS BURNING THE UPHOLSTERY. THE SEAT HEATER WON'T SHUT OFF. THIS HAS HAPPENED MORE THAN ONCE; EACH TIME THE CAR WAS OPERATING.

HEATED SEAT MODULE MELTED A HOLE THROUGH MY LEATHER.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 65 MPH, ALL THE WARNING INDICATORS STARTED TO FLASH ON THE INSTRUMENT PANEL. THE DOOR CHIME SOUNDED AND THE VEHICLE STALLED. THE CONTACT COASTED THE VEHICLE ONTO THE SHOULDER. THE CONTACT HAD THE VEHICLE JUMP STARTED AND DROVE TO A NEARBY PARKING LOT. THE FAILURE OCCURRED TWO OTHER TIMES AND THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC. THE FUSE BOX MELTED AND HAD TO BE REPLACED. THE VEHICLE OPERATED NORMALLY AFTER THE REPAIRS WERE COMPLETED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 74,000.

ON 12/18/2016 I WAS DRIVING THIS CAR BACK FROM THE MOVIES AT 2:30 A.M. ONCE THE MOVIE HAD ENDED IT WAS STORMING AND SLEETING. I STARTED TO NOTICE SYSTEMS SHUTTING DOWN AS INDICATED BY VARIOUS DASH LIGHTS SUCH AS ABS, AIRBAG, AMONG OTHERS. EVENTUALLY THE RADIO, INTERIOR LIGHTS SHUT OFF. THE WINDSHIELD WIPERS SLOWED AND THE HEADLIGHTS DIMMED, AND EVENTUALLY THE CAR DIED GOING 50 MILES AN HOUR IN SLEETING CONDITIONS LEAVING ME WITH NO ABS, NO AIRBAG SYSTEM (AT LEAST PER WHAT THE DASH LIGHTS INDICATED) AND, OF COURSE, NO POWER STEERING. I INSPECTED THE VEHICLE THIS MORNING AND FOUND THE ALTERNATOR WIRE COMING INTO THE HIGH AMPERAGE FUSE BOX THAT SITS ON TOP OF THE BATTERY HAD MELTED AND DISCONNECTED THE CIRCUIT, DISABLING THE ALTERNATOR FROM CHARGING THE BATTERY, AND LETTING THE BATTERY DIE. THE INCIDENT DID NOT CAUSE A CRASH, BUT IT COULD HAVE IF THERE WAS...

ALTERNATOR CABLE MELTED THE FUSE BLOCK AND WIRES ABOVE THE BATTERY. I WILL NEED TO REPLACE THE ALTERNATOR, ALTERNATOR WIRING HARNESS, THE FUSES, AND POSSIBLY THE BATTERY. MY CAR HAS SHUT DOWN WHILE DRIVING AND THIS IS DANGEROUS NOT JUST FOR ME BUT FOR OTHERS ON THE ROAD AROUND ME. TOO MANY VW OWNERS ARE EXPERIENCING THIS EXACT SAME ISSUE. VW PLEASE TAKE OWNERSHIP OF THIS ONGOING SAFETY ISSUE. THIS SAME ISSUE IS BEING ADDRESSED IN A CLASS ACTION FOR BEETLES.

INSTRUMENT CLUSTER STOPPED WORKING. VEHICLE MILEAGE, AND SPEEDOMETER DO NOT WORK AT ALL. MILEAGE WHEN OCCURRED 48,800. EVERY SPEED SENSOR WAS REPLACED WITH NO CHANGE. I HAVE NO WAY OF KNOWING HOW FAST I AM GOING, OR HOW MANY MILES ARE ON MY CAR WITHOUT TRACKING THEM MYSELF. THIS IS A COMMON PROBLEM WITH MULTIPLE VW'S AND AUDI'S WITH NO APPARENT SOLUTION. I HAVE SPENT HUNDREDS OF DOLLARS TRYING TO FIX THIS PROBLEM AND STILL AM WITHOUT A SPEEDOMETER AND ODOMETER.

MY (GENERATOR CABLE - S177) ALTERNATOR CABLE MELTING THE FUSE BOX AND WIRES ABOVE THE BATTERY. MY CAR NEEDED A NEW ALTERNATOR. MY CAR DOES NOT ALWAYS START EVEN WITH A NEW BATTERY AND ALTERNATOR. MY CAR HAS SHUT DOWN WHILE DRIVING ON THE HIGHWAY. VW ADMITS THIS IS A KNOWN PROBLEM BUT WILL NOT DO ANYTHING ABOUT IT. I AM THE SECOND OWNER OF THIS VEHICLE. THOUSANDS OF PEOPLE ARE HAVING THIS SAME PROBLEM.

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE STALLED, BACK FIRED, AND IT WAS LEAKING COOLANT UNDER THE WATER PUMP. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. PRIOR TO THIS FAILURE THAT THE VEHICLE HAD EXPERIENCED LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THE WATER PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14E007000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 156,000.

OVER THE PAST FEW DAYS IT HAS BEEN RAINING HEAVILY & ALTHOUGH IT HAS HAPPENED TO ME ONCE BEFORE THIS TIME IS WHAT WORSE. MY CAR IS LEAKING FROM SOMEWHERE & ITS COMING ON THE INSIDE. MY CARPETS ARE CONSTANTLY WET, MY AIRBAGS ALONGSIDE WINDSHIELD LEAK, AND THE HANDLE WHERE YOU OPEN THE HOOD OF THE CAR IS LITERALLY A STREAM OF WATER ENTERING THE CAR DURING HEAVY RAINFALL. THE AIRBAG LIGHT HAS COME ON AND THE CHECK ENGINE. I WAS MORE CONCERNED WITH THE CHECK ENGINE LIGHT SO I WENT AND GOT IT CHECKED. THE CODE CAME UP AS U0155 - WHICH REFERS TO (LOST COMMUNICATION WITH INSTRUMENT PANEL CLUSTER (IPC) CONTROL MODULE) MEANING MY ENTIRE DASHBOARD NEEDS TO BE REPLACED BECAUSE OF THIS LEAKING ! I HAVE TAKEN MY CAR ON MULTIPLE OCCASIONS TO VW DEALERSHIP FOR SERVICING (NEVER FOR THIS PROBLEM) AND THEY NEVER ONCE TOLD ME...

I WAS DRIVING MY VW JETTA 2004 TDI ON A HIGHWAY, I WAS USING MY HIGH BEAM AND LOW BEAM HEADLIGHTS TO YIELD TO INCOMING TRAFFIC WHEN ALL OF A SADDEN MY HEADLIGHTS WENT OFF, I HAD TO STOP IT WAS VERY DARK AND DANGEROUS ROAD, I MOVED AND WIGGLE THE LEVER TO SEE IF I COULD MAKE IT COME ON AGAIN, EVENTUALLY IT DID, IT DID THAT ABOUT 4 TIMES,EVERY TIME IT SCARED THE ... OUT OF ME COULD NOT SEE ROAD. TOOK IT TO A MECHANIC, REPLACED THE TURN SIGNAL HIGH BEAM LOW BEAM AND CRUSE CONTROL LEVER, ITS ALL IN ONE LEVER. I LOOKED ON LINE TO SEE IF SOMEONE ELSE HAVE THE SAME PROBLEM AND IT SEEMS THAT IS A COMMON PROBLEM WITH THIS VEHICLE.

THE HIGH VOLTAGE FUSE BOX, THAT SITS ON TOP OF THE BATTERY MELTED DUE TO HEAT AND POOR DESIGN. THIS CAUSED A SHORT AND COMPLETE LOSS OF POWER TO MY VEHICLE. THIS WAS BOTH DANGEROUS AND FRIGHTENING! I WAS ON THE FREEWAY GOING 60MPH AND COULD HAVE EASILY LOST CONTROL OF THE VEHICLE, CAUSING AN INJURY OR FATAL ACCIDENT. I FOUND 44 SIMILAR COMPLAINTS REGARDING THIS SAME ISSUE AND AM SURPRISED THAT THIS PUBLIC AGENCY HAS FAILED TO TAKE ANY ACTION ON THIS, AND DEMANDING A RECALL, AND THUS RESOLVING A DANGEROUSLY REOCCURRING ELECTRICAL ISSUE.

I HAVE REPLACED MY BATTERY TWICE AND MY ALTERNATOR ONCE. MY CAR COMPLETELY SHUTS DOWN WHEN I PART IT. I HAVE ALSO TURNED ON MY CAR AND THEN COMPLETELY SHUTS DOWN BY ITSELF, YET IF I JUMP START IT WILL TURN ON. I'M NOT ABLE TO TURN MY CAR BACK ON, AS THOUGH SOMETHING IS DRAINING MY BATTERY. THIS HAS BEEN OCCURRING FOR OVER ONE YEAR NOW AND I'M GETTING STRANDED AT MY LAST DESTINATION AND HAVE HAD TO GET TOWED TO THE MECHANIC SHOW. IT'S GETTING VERY EXPENSIVE AND RIDICULOUS. THE MECHANIC HAS DONE HIS DUE DILIGENCE BUT PROBLEM IS STILL OCCURRING. I'M AFRAID TO DRIVE ON THE HIGHWAY IN FEAR MY CAR WILL SHUT DOWN! *TR

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 50 MPH, THERE WAS SMOKE COMING FROM THE HEATED SEATS ON THE FRONT PASSENGER SIDE THE CONTACT STATED THAT THERE WAS A HOLE BURNED INTO THE FRONT PASSENGER SEAT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED . THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 05/31/17*LJ UPDATED 06/02/2017*JS

THE BATTERY FUSE BOX MELTED DUE TO CORROSION ON THE TERMINAL OF THE ALTERNATOR WIRE, THIS IS A VERY COMMON PROBLEM WITH THIS CAR AND CARS OF SIMILAR MAKE (AUDI A4, TT ETC.) AND CAN LEAD TO FIRES. *TR

ALTERNATOR WIRING HARNESS OVERHEATED MY BATTERY FUSE BOX AND MELTED IT. THE VEHICLE BATTERY LIGHT CAME ON SO I PULLED OVER, TURNED THE VEHICLE OFF, AND INSPECTED THE BATTERY, NOTICING THE DAMAGE (MELTED PLASTIC, SMOKE). *TR

HEADLIGHTS DIMMING- TO POINT WHERE YOU CAN NOT TELL THEY ARE ON. ENGINE LIGHT COMES ON DESPITE ALL DIAGNOSTICS STATING ALL IS OK WITH CAR. PERIODICALLY FAILS TO START-DESPITE DIAGNOSTICS THAT STATE STARTER, BATTERY, DRAIN ALTENATOR ALL GOOD AND FUNCTIONING PROPERLY. CAR JUMPS EASILY WITH "BOOST". *TR

2004 VW JETTA GLS TDI OPERATING AT 75MPH ON INTERSTATE ON CRUISE CONTROL WHEN THE ENGINE SHUTOFF COMPLETELY. THE VEHICLE STILL HAD ELECTRICAL POWER AND ENGINE WOULD CRANK BUT WOULD NOT START. I ROLLED THE VEHICLE OFF TO THE SIDE OF THE ROAD AND ATTEMPTED TO RE-START THE ENGINE AND IT FINALLY CRANKED AND DROVE VEHICLE APPROXIMATELY 500 MILES BEFORE EXPERIENCING SIMILAR ISSUE. SINCE THAT TIME VEHICLE HAS HAD SAME ISSUE OVER 10 TIMES. DEALER HAS INSPECTED VEHICLE THREE TIMES AND HAS NOT DISCOVERED ISSUE. *TR

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN JETTA. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE ENTIRE ELECTRICAL SYSTEM INCLUDING THE LIGHTING AND INSTRUMENT PANEL FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE PRIVATE MECHANIC CONFIRMED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 90,000.

I HAVE A 2004 VW JETTA. IT HAS ABOUT 48,000 MILES ON IT. A LITTLE OVER A YEAR AGO, IT DEVELOPED AN ELECTRICAL PROBLEM. IT PROGRESSES FROM THE DASHBOARD LIGHTS FLICKERING INITIALLY & THE TRIP MILEAGE GOING AWAY, TO BEEPING 3 TIMES, AND EVENTUALLY TO STALLING WHEN I STOP. IT'S PROGRESSIVE, THE LONGER IT HAPPENS THE MORE FREQUENTLY IT HAPPENS. THIS MAKES THE CAR UNRELIABLE AND DANGEROUS. I'VE TAKEN THE CAR TO THE DEALERSHIP 4 TIMES. THE FIRST 2 TIMES, THEY SAID IT WAS A SHORT. I WAS CHARGED FOR THE SERVICE. THE NEXT TIME THEY SAID IT WAS THE IGNITION SWITCH. I PAID FOR THE PART BUT NOT THE LABOR. THE LAST TIME, THEY SAID IT WAS THE FUEL PUMP RELAY SWITCH. I WASN'T CHARGED. I GOT THE CAR BACK THURSDAY. THE PROBLEM REOCCURRED SATURDAY. I SPOKE TO VW CORP. PRIOR TO THE THIRD & FOURTH TIMES I TOOK...

AFTER SERVICE BY VW FOR WINDOW GLASS CLIP RECALL THE TRACTION CONTROL LIGHT WILL NOT TURN OFF. NO TRACTION CONTROL FOR THE VECHICLE. *TR

BOUGHT NEW IN 2004. STARTING AT 60K MILES THE CHECK ENGINE LIGHT WOULD COME-ON SAYING MISS FIRE ON #1 CYL WHEN ITS WET OUTSIDE; RAINING OR SNOW. SPARK PLUG AND WIRE REPLACED REGULARLY AND CHECKED WITHIN SPECS. THE ACCELERATION STARTED TO DETERIORATE AND FLAT SPOT IN THE ACCELERATION CAN BE DANGEROUS IN DRIVING CONDITIONS. 86K THE ORIGINAL VW COIL WAS REPLACED; #1 TERMINAL WAS CORRODED. *TR

MY 2004 VW JETTA 1.8 TURBO WHICH I PURCHASED NEW IS HAVING TRANSMISSION PROBLEMS. MY CAT HAS ONLY 66,000 MILES IN IT AND HAS BEEN WELL MAINTAINED. IN THE PAST TWO YEARS I HAVE REPLACED THE FUEL PUMP, BATTERY, CATALYTIC CONVERTER, NUMEROUS VACUUM LEAKS ECT...BUT A TRANSMISSION???? VOLKSWAGEN NEEDS TO ISSUE A RECALL AS THIS IS WAY TO COMMON!! PLEASE HELP! *TR

ELECTRICAL FIRE IN IGNITION HARNESS MELTED HARNESS (INCLUDING COILS) WHICH RESULTED IN STALL-OUT. IGNITION FUSE TO COMPUTER WAS DISABLED PREVENTING RE-START OF AUTOMOBILE. *TR

THE LATEST INCIDENT WITH THIS 2004 VW JETTA IS ONE IN WHICH EVERYTHING ELECTRIC STOPS WORKING. NO A/C, NOT LIGHTS, NO BLINKERS, NO WINDOWS, NO HORN - AND THERE IS A SMELL OF SMOKE IN THE CAR. THIS FIRST HAPPENED IN JANUARY/08 AND THE DEALERSHIP SAID IT WAS WIRING. NOW IT HAPPENED AGAIN! OCCURS JUST WHILE DRIVING ALONG. CAR SMELLS LIKE SMOKE AND EVERYTHING STOPS WORKING. I GET THE RUNAROUND FROM THE DEALER, VISTA VW IN POMPANO BEACH, FL. THEY ALWAYS SEEM TO FIND SOMETHING WRONG WITH THE CAR NOW THAT IS NOT UNDER WARRANTY. PLEASE INVESTIGATE THIS - THERE IS SOMETHING WRONG WITH THESE JETTA'S! I HAVE FOUND 100'S OF COMPLAINTS ON CONSUMER SITES ABOUT THIS CAR. I AM TIRED OF PAYING MY HARD EARNED DOLLARS TO THE DEALER WHEN THIS IS AN ISSUE WITH THE MANUFACTURER OF THIS CAR. I ADVISED THE DEALER OF THIS WHEN I TOOK...

OUR 2004 VW JETTA 1.8T HAS HAD NUMEROUS PROBLEMS FROM A CLICKING/POPPING NOISE IN THE FRONT END AT APPROXMIATELY 10,000 MILES, TO THE TRANSMISSION LOCKING UP WHILE OPERATING VEHICLE. THE CLUTCH/DISC WENT COMPLETELY OUT AT 15,000 MILES. ALL THE INTERIOR AND EXTERIOR LIGHTS WENT OUT AS MY WIFE WAS DRIVING IN THE DARK ON A NON LIT BACK ROAD TO WORK, TRANSMISSION LOCKED UP BETWEEN 3RD AND 4TH GEARS, TRANSMISSION STILL SLIPPING, BACK DOOR LOCKS DO NOT UN-LOCK WHEN REMOTE IS ACTIVATED, SERVICE DEPARTMENT HAS RE-TORQUED EVERYTHING ON VEHICLE BUT THIS HAS NOT MADE PROBLEMS GO AWAY. SINCE MAY 2005, THE SERVICE DEPARTMENT AT LOCAL VW DEALERSHIP HAS HAD MY CAR FORA TOTAL OF 62 DAYS FOR SERVICE AND IT IS STILL NOT FIXED. PROBLEMS CONTINUE TO MOUNT AND THE DEALERSHIP FOR THE MOST PART STATES "THAT THEY CANNOT REPLICATE THE PROBLEM." THE DEALERSHIP REPLACED ALL THE WHEEL BEARINGS IN...

DT: THE CALLER HAD THE VEHICLE'S ELECTRICAL SYSTEM REPLACED 5 TIMES. THE WINDOWS/THE ALARM SYSTEM/THE LIGHTS/THE GAUGES, AND THE DASHBOARD LIGHTS FAILED. AS THE CALLER INDICATED EVERYTHING ELECTRICAL MALFUNCTIONED. THE CALLER WAS ABLE TO DRIVE VEHICLE TO THE DEALER, AND A FEW TIMES HE HAD TO HAVE IT TOWED. DEALER COULD NEVER GIVE HIM AN ANSWER WHY THE VEHICLE WAS HAVING THESE PROBLEMS. THE MANUFACTURER SAID THEY COULD NOT HELP HIM FOR FREE, AND SINCE THE PROBLEM INCLUDED DIFFERENT COMPONENTS IT DID NOT FALL UNDER THE LEMON LAW. MANUFACTURER SAID THAT IF THE CALLER GOT A LOAN ON THE VEHICLE IT WOULD BE A DIFFERENT SITUATION. *AK

ENGINE CONTROL COMPUTER FAILED RESULTING IN VERY HARD TO START OR NO START CONDITIONS. VEHICLE HAS BEEN OUT OF SERVICE FOR 2 WEEKS WAITING ON PARTS. VEHICLE ONLY HAS 1600 MILES ON IT. WAS SUGGESTED TO BY THE DEALER TO DRIVE THE VEHICLE WHILE WAITING FOR PARTS.*AK