2002 VOLKSWAGEN JETTA Fuelpropulsion System Problems
5 NHTSA complaints on file
Fuelpropulsion System Issues in the 2002 VOLKSWAGEN JETTA
5 fuelpropulsion system complaints have been filed with NHTSA for the 2002 VOLKSWAGEN JETTA. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
5
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Fuelpropulsion System Complaints
WHILE MAINTAINING SPEED AT OR ABOVE 40 MPH AND WITH 1/4 TANK OR LESS OF FUEL REMAINING, MY JETTA WILL CONSISTENTLY STALL OUT AND TURN OFF FROM FUEL STARVATION. THIS HAS HAPPENED TO ME BETWEEN 40 AND 80 MPH SEVERAL TIMES, BOTH IN THE CITY AND ON THE HIGHWAY. I HAVE REPLACED THE CRANKSHAFT POSITION SENSOR, THE FUEL SENDER, AND THE FUEL PUMP WITH NO SUCCESS. ADDITIONALLY, THE JETTA WILL DIE THE FIRST TIME I TRY TO START IT AS MY FUEL LEVEL APPROACHES 1/4, ESPECIALLY IF I AM PARKED ON AN INCLINE. HOWEVER, IT NEVER FAILS TO START ON THE SECOND TRY ONCE SOME FUEL HAS BEGUN MOVING THROUGH THE SYSTEM. FULLY REFUELING ALLEVIATES ALL PROBLEMS.
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT WAS GETTING AN ALLERGIC REACTION FROM THE INTERIOR OF THE VEHICLE. THE CONTACT STATED THERE WAS AN ODOR EMITTING FROM THE VEHICLE, WHICH CAUSED THE REACTION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
WATER PUMP REPLACED, TIRES ALWAYS HAVE ISSUES BECAUSE OF THE RIM DESIGN, CODE ERRORS, REAR RODS REPLACED, MUFFLER, MISFIRING, RADIATOR ECT.
ENGINE SHUTS DOWN WHEN THE FUEL TANK IS AT OR BELOW A 1/4 TANK OF FUEL WHILE DRIVING... THERE IS A LOSS OF STEERING AND BRAKING RENDERING IT UNSAFE TO DRIVE. HERE IS A ONLINE DISCUSSION OF OTHERS HAVING THE SAME PROBLEM... HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?4971876-CAR-STALLING-WHILE-AT-SPEED-IS-LOW-FUEL-THE-PROBLEM.
WHILE DRIVING ON THE FREEWAY AT APPROXIMATELY 70MPH WITH A QUARTER TANK OF GAS, MY 2002 JETTA GLX DISPLAYED THE BATTERY LIGHT AND THEN STALLED AT FULL SPEED. THE CAR SLOWED, THE STEERING AND GAS PEDAL WERE STIFF AND I HAD TO PULL TO THE SHOULDER AND CALL FOR A TOW TRUCK. I HAD THE CRANK POSITION SENSOR REPLACED, NEW SPARK PLUGS PUT IN AND THE THROTTLE BODY CLEANED. I TEST DROVE THE CAR AND ONCE AGAIN, THE ENGINE STARTED TO STALL AT AROUND 70MPH ON THE FREEWAY. THIS TIME I WAS ABLE TO FLOOR THE ACCELERATOR AND THE CAR DID NOT COMPLETELY STALL. THIS DEFECT SEEMS IS INCREDIBLY DANGEROUS AND SEEMS TO BE UNACCEPTABLY PREVALENT ON VW JETTAS. MY NEXT PART TO REPLACE IS THE FUEL PUMP BUT IT APPEARS THAT DOES NOT ALWAYS REMEDY THE PROBLEM. THIS SHOULD BE A RECALL. *TR
Other 2002 VOLKSWAGEN JETTA Problem Areas
Seatsfront Assemblyseat Heatercooler
86 complaints
Air Bagssidewindow
63 complaints
Electrical Systemignition
61 complaints
Power Trainautomatic Transmission
56 complaints
Electrical System
51 complaints
Engine And Engine Cooling
41 complaints
Air Bags
35 complaints
Visibilitypower Window Devices And Controls
33 complaints
Engine And Engine Coolingengine
31 complaints
Exterior Lightingbrake Lightsswitch
28 complaints
Power Train
25 complaints
Electrical Systemignitionmodule
18 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
17 complaints
Seats
16 complaints
Vehicle Speed Control
14 complaints
Exterior Lighting
13 complaints
Service Brakes Hydraulic
13 complaints
Air Bagsfrontal
11 complaints
Power Trainmanual Transmission
10 complaints
Unknown Or Other
10 complaints
Electrical Systemwiring
8 complaints
Power Trainclutch Assembly
8 complaints
Structurebodydoor
8 complaints
Tires
8 complaints
Engine
7 complaints
Equipment
7 complaints
Engine And Engine Coolingcooling System
6 complaints
Engine And Engine Coolingexhaust System
6 complaints
Exterior Lightingbrake Lights
6 complaints
Structure
6 complaints
Engine And Engine Coolingexhaust Systememission Control
5 complaints
Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor
5 complaints
Fuel System Gasoline
5 complaints
Seat Belts
5 complaints
Engine And Engine Coolingenginediesel
4 complaints
Exterior Lightinghazard Flashing Warning Lightsswitch
4 complaints
Service Brakes Hydraulicfoundation Componentsmaster Cylinder
4 complaints
Suspension
4 complaints
Tiressidewall
4 complaints
Visibilitysunmoon Roof Assembly
4 complaints
Electrical System Instrument Clusterpanel
3 complaints
Equipmentapplianceair Conditioner
3 complaints
Equipmentelectricalradiotape Deckcd Etc
3 complaints
Fuel System Diesel
3 complaints
Latcheslockslinkagesdoorslatch
3 complaints
Service Brakes Hydraulicfoundation Components
3 complaints
Service Brakes Hydraulicfoundation Componentsdiscrotor
3 complaints
Service Brakes Hydraulicpower Assist
3 complaints
Steering
3 complaints
Structurebody
3 complaints
Tirestreadbelt
3 complaints
Visibility
3 complaints
Electrical System12v24v48v Battery
2 complaints
Electrical Systemalternatorgeneratorregulator
2 complaints
Electrical Systemwiringfuses And Circuit Breakers
2 complaints
Engine And Engine Coolingenginegasoline
2 complaints
Engine And Engine Coolingengineother Fuel Typesturbosupercharger
2 complaints
Exterior Lightingtail Lights
2 complaints
Exterior Lightingturn Signalswitch
2 complaints
Fuel System Gasolinefuel Injection Systeminjectors
2 complaints
Fuel System Other
2 complaints
Interior Lighting
2 complaints
Latcheslockslinkages
2 complaints
Latcheslockslinkagestrunk Lidlock
2 complaints
Power Trainautomatic Transmissionparkneutral Start Interlock Switch
2 complaints
Service Brakes
2 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipcontrol Unitmodule
2 complaints
Steeringcolumn
2 complaints
Suspensionfront
2 complaints
Vehicle Speed Controlaccelerator Pedal
2 complaints
Visibilitywindshield
2 complaints
Wheels
2 complaints
Wheelsrim
2 complaints
Air Bagsfrontalsensorcontrol Module
1 complaint
Electrical Systemhorn
1 complaint
Electrical Systemignitionanti Theftcontrol Module
1 complaint
Electrical Systemstarter Assembly
1 complaint
Electrical Systemstarter Assemblyrelay
1 complaint
Electrical Systemwiringfront Underhood
1 complaint
Engine And Engine Coolingcooling Systemhoseslinespipingfittings
1 complaint
Engine And Engine Coolingcooling Systemradiator Assembly
1 complaint
Engine And Engine Coolingenginegasolineturbosupercharger
1 complaint
Engine And Engine Coolingexhaust Systememission Controlcrankcase Pcv
1 complaint
Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe
1 complaint
Equipmentelectrical
1 complaint
Equipmentmechanicalaccessory Scissorscrewbottle Jacklift
1 complaint
Equipmentotherownersserviceother Manual
1 complaint
Equipmentrecreational Vehicletrailer
1 complaint
Exterior Lightingback Up Lights
1 complaint
Exterior Lightingback Up Lightsswitch
1 complaint
Exterior Lightingtail Lightsswitch
1 complaint
Exterior Lightingturn Signal
1 complaint
Exterior Lightingturn Signalflasher Unit
1 complaint
Fuel System Gasolinedelivery
1 complaint
Fuel System Gasolinedeliveryhoses Linespiping And Fittings
1 complaint
Fuel System Gasolinefuel Injection System
1 complaint
Fuel System Gasolinestoragetank Assembly
1 complaint
Fuel System Gasolinestoragetank Assemblyfiller Pipe And Cap
1 complaint
Parking Brake
1 complaint
Parking Brakeconventionalmechanical
1 complaint
Power Trainautomatic Transmissioncooling Unit And Lines
1 complaint
Power Trainautomatic Transmissiongear Position Indication Prndl
1 complaint
Power Trainautomatic Transmissionlever And Linkagefloor Shift
1 complaint
Power Trainclutch Assemblypedalhand Levermotorcycle
1 complaint
Seat Beltsfront
1 complaint
Seat Beltsfrontretractor
1 complaint
Service Brakes Airantilockcontrol Unitmodule
1 complaint
Service Brakes Electric
1 complaint
Service Brakes Hydraulicbrake Fluid Low Warning Lamp
1 complaint
Service Brakes Hydraulicfoundation Componentsdisc
1 complaint
Service Brakes Hydraulicfoundation Componentshoses Linespiping And Fittings
1 complaint
Service Brakes Hydraulicpedals And Linkages
1 complaint
Service Brakes Hydraulicpower Assisthydraulic
1 complaint
Service Brakes Hydraulicpower Assistvacuum
1 complaint
Steering Steering Wheelhandle Bar
1 complaint
Steeringhydraulic Power Assist System
1 complaint
Steeringlinkagestie Rod Assembly
1 complaint
Structurebodybumpers
1 complaint
Structurebodyroof And Pillars
1 complaint
Suspensionfrontshock Absorber
1 complaint
Suspensionfrontwheel Bearing
1 complaint
Suspensionmultiple Axletorque Arm
1 complaint
Suspensionrearspringscoil Springs
1 complaint
Vehicle Speed Controlcruise Control
1 complaint
Visibilitydefrosterdefoggerhvac Systemheater Core
1 complaint
Visibilityglass Siderear
1 complaint
Visibilityrearview Mirrorsdevicesexterior
1 complaint
Visibilitywindshield Wiperwasher
1 complaint
Wheelslugsnutsboltsstuds
1 complaint