2004 TOYOTA TUNDRA Suspensionfrontcontrol Armlower Ball Joint Problems

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHEN THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, THE FRONT DRIVER SIDE TIRE DISENGAGED FROM THE VEHICLE WITHOUT WARNING. THE CONTACT WAS ABLE TO DRIVE ONTO THE EMERGENCY LANE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE POLICE ARRIVED AT THE SCENE. THERE WERE NO INJURIES OR DAMAGES. THE CONTACT EXPERIENCED THE IDENTICAL FAILURE WITH NHTSA CAMPAIGN ID NUMBER 05V225000 (SUSPENSION: FRONT: CONTROL ARM: LOWER BALL JOINT). THE FAILURE AND CURRENT MILEAGES WERE 103,000.

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. WHILE DRIVING 52 MPH THE FRONT PASSENGER WHEEL DETACHED FROM THE VEHICLE. HE WAS ABLE TO SAFELY STOP THE VEHICLE. THE ENTIRE WHEEL ASSEMBLY AND DRIVE TRAIN WERE ON THE GROUND. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY. HE WAS ADVISED BY THE MANUFACTURER THAT HIS VEHICLE IDENTIFICATION NUMBER WAS INCLUDED IN RECALL #07V013000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT). HE FILED A COMPLAINT, AND THE CASE# IS 0910124225. HE WAS AWAITING A RESPONSE. THE FAILURE MILEAGE WAS 75,000.

2004 TOYOTA TUNDRA RECALL FOR FRONT BALL JOINTS--2006 RECEIVED NOTICE AND TOOK TO DEALER IN BOZEMAN, MT TO CHECK...WE WERE TOLD OUR TRUCK WASN'T PART OF RECALL....MONTHS LATER, RECEIVED ANOTHER NOTICE...CALLED AND EMAILED DEALER, BUT THEY DID NOT RETURN CALLS OR EMAILS. OCTOBER 2007 FRONT PASSENGER WHEEL "BROKE" WHILE DRIVING AND WE WRECKED. DEALER IN LARAMIE, WY STATED THAT "YES, YOUR TRUCK WAS PART OF THE RECALL AND THIS WAS DUE TO FRONT BALL JOINT FAILURE." LUCKILY WE WERE ONLY DRIVING 10MPH, BUT IF WE HAD BEEN DRIVING ON INTERSTATE, WE WOULD HAVE ROLLED. *TR

LOWER BALL JOINT RECALL DANGER. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 07V013000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT). HE IMMEDIATELY SCHEDULED AN APPOINTMENT TO HAVE THE VEHICLE REPAIRED. THE DEALER STATED THAT IT WOULD TAKE THREE MONTHS TO GET REPAIRED BECAUSE THE PARTS WERE ON BACK ORDER. IT HAS NOW BEEN NINE MONTHS AND THE DEALER WILL NOT RETURN HIS PHONE CALLS. HE ATTEMPTED TO FILE A COMPLAINT WITH THE MANUFACTURER, BUT THEY GAVE HIM AN INCORRECT TELEPHONE NUMBER. HE STATED THAT THE VEHICLE VIBRATES TERRIBLY WHEN THE BRAKES ARE APPLIED. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 34,600.

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED A FRONT SUSPENSION LOWER BALL JOINT RECALL NOTICE IN JUNE OF 2007. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THEY DID NOT HAVE THE PARTS FOR THE RECALL REPAIR AND WOULD HAVE TO WAIT A MONTH FOR THEM TO ARRIVE. A MONTH LATER HE CALLED THE DEALER AND WAS INFORMED THAT THE PARTS WERE STILL UNAVAILABLE AND THEY WOULD CALL HIM WHEN THE PARTS ARRIVED. MONTHS PASSED AND THE CONTACT NEVER RECEIVED A PHONE CALL. WHILE DRIVING APPROXIMATELY 45 MPH, THE BALL JOINTS BECAME LOOSE AND HE LOST CONTROL OF THE VEHICLE. WHEN THE VEHICLE FINALLY CAME TO A STOP, IT WAS TOWED TO THE SHOP. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 87,000. UPDATED 12-12-07. *KB UPDATED.

OVER THREE MONTHS AGO, I CALLED DAVID MAUS TOYOTA IN SANFORD TO GET THE LOWER BALL JOINTS ON MY 2004 TOYOTA TUNDRA PER RECALL SSC 70B. I WAS TOLD IT WOULD TAKE SIX TO EIGHT WEEKS FOR THE PARTS TO COME IN AND THEY WOULD CALL ME WHEN IT DID. I HAVE NOT HEARD FROM THEM YET AND THEY HAVE NOT RETURNED MY PHONE CALLS. THE FRONT END OF MY TRUCK IS ACTING UN-STABLE AT THIS TIME AND I FEAR THAT I MIGHT GET INTO AN ACCIDENT IF I CONTINUE TO DRIVE IT IN THIS CONDITION. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED RECALL NOTICE NUMBER 05V225000 (SUSPENSION FRONT:LOWER BALL JOINTS). WHILE DRIVING, THE VEHICLE SHAKES SEVERELY. THE CONTACT HAS CALLED THE DEALER TO HAVE THE RECALL REPAIRED, HOWEVER, THEY CONTINUE TO INFORM HIM THAT THE PARTS ARE UNAVAILABLE AND THAT HE WOULD HAVE TO PAY FOR THE REPAIR. THE CONTACT STATED THAT THE RECALL NOTICE INDICATED THAT THE REPAIR WOULD BE PERFORMED FOR FREE. THE DEALER STATED THAT THEY WOULD CALL HIM WHEN THEY HAD AN AVAILABLE APPOINTMENT TIME, BUT THEY HAVE NOT CALLED OR PROVIDED A LOANER OR RENTAL VEHICLE. THE SPEED WAS UNKNOWN. THE FAILURE MILEAGE WAS 41,000 AND CURRENT MILEAGE WAS 42,000.

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. HE STATED THE HE HEARD A NOISE COMING FROM THE FRONT END OF HIS VEHICLE. THERE IS A RECALL FOR THE FRONT LOWER BALL JOINTS (NHTSA CAMPAIGN # 07V013000). THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 43,000.

I RECEIVED A RECALL NOTICE FOR MY 2004 TOYOTA TUNDRA FOR THE FRONT BALL JOINTS. I HAVE CALLED 3 TIMES AND EACH TIME MY NAME IS SUPPOSEDLY PLACED ON A LIST TO CALL AS SOON AS THE PART ARRIVES. WELL, 90 DAYS LATER I HAVEN'T HEARD FROM ANYONE. I CALLED MY LOCAL DEALER TODAY AND WAS TOLD MY INFORMATION WOULD HAVE TO BE TAKEN DOWN AND THEY WOULD CALL WHEN THE PART ARRIVED, I ESCALATED AND SPOKE TO THE MANAGER TO SAID THE PART WAS IN BUT IT COULD ONLY BE INSTALLED ON 7/25/07, NO OTHER DAY OF THE WEEK WOULD WORK SINCE HIS STAFF IS GOING BACK TO SCHOOL? I GUESS THEY JUST EXPECT ME TO QUIT MY JOB IN AN EFFORT TO HAVE THIS PROBLEM FIXED. I ALSO ESCALATED THIS ISSUE TO THE MANAGER OF SERVICE DEPARTMENT AT LAKE NORMAN DEALERSHIP WHERE TRUCK WAS PURCHASED. THEY KEPT TRANSFERRING...

I RECEIVED A SAFETY RECALL NOTICE ON MY 2004 TOYOTA NOTICE #SSC 70B FRONT BALL JOINTS, I CONTACTED THE LOCAL TOYOTA DEALERSHIP WHERE I PURCHASED THE VEHICLE, THEY HAVE STATED I MUST GO ON A WAITING LIST AS THERE ARE LIMITED SUPPLIES OF THE REPLACMENT PARTS FROM TOYOTA, 2-WEEKS LATER THEY ARE NOW TELLING ME IT MAY BE "WEEKS AND WEEKS" BEFORE PARTS ARE AVAILIBLE. MY COMPLAINT IS WITH TOYOTA FOR NOT FOLLOW THROUGH ON PROVIDING THIER DEALERSHIPS WITH THESE PARTS IN A TIMELY FASHION, ESPECIALLY IN THIS CASE WHERE THIS IS A CRITICAL REPAIR. PLEASE FEEL FREE TO CONTACT ME IF FURTHER INFO IS NEEDED, AND FEEL FREE TO PRESSURE-CHEW OUT TOYOTA. THANKS FOR YOUR HELP.

FRONT BALL JOINT ON DRIVER'S SIDE JUST COLLAPSED AND THE AXLE CAME OUT AND THE WHEEL TURNED SIDEWAYS AT 45 MPH, CAUSING A 300' SKID.*AK

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. ON MAY 21, 2007, THE CONTACT RECEIVED SAFETY RECALL # 07V013000 FOR THE LOWER BALL JOINTS. HE CALLED THE DEALER AND HE WAS TOLD THAT THEY DID NOT HAVE ANY PARTS IN THE UNITED STATES TO PERFORM THE REPAIR. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 13,800.

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT HE RECEIVED RECALL NOTICE # 05V225000 CONCERNING SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT. ON APRIL 20, 2007 THE CONTACT CALLED THE DEALER, AND THEY STATED THAT THE PART SHOULD ARRIVE WITHIN SEVEN DAYS. A WEEK LATER THE DEALER STATED THAT THEY DID NOT KNOW WHEN THE PART WOULD ARRIVE. THE CONTACT STATED THAT THIS WAS UNACCEPTABLE ,AND THE WAIT TIME WAS TOO LONG. NO FAILURES OCCURRED AT THIS PRESENT TIME. THE CURRENT MILEAGE IS 12,000, AND THE FAILURE MILEAGE WAS UNKNOWN. *AK UPDATED 05/21/07 *TR

TL*THE CONTACT OWNS 2004 TOYOTA TUNDRA. THE CONTACT STATED THAT HE HEARD A NOISE WHILE DRIVING 45 MPH AND SUSPECTED FAILURE WITH THE LOWER BALL JOINT. THE VEHICLE WAS TOWED TO THE DEALER, AND THE BALL JOINT WAS REPLACED AT THE CONTACT'S EXPENSE. ALSO, THE DEALER STATED THAT THE CONTACT WOULD HAVE TO PAY FOR THE TIRES, BATTERY, AND POWER STEERING FLUID FLUSH. HE STATED THAT HE SHOULD NOT HAVE TO PAY FOR THESE EXPENSES BECAUSE THE VEHICLE WAS INCLUDED IN THE RECALL. THE MANUFACTURER STATED THAT THIS VEHICLE WAS INCLUDED IN THE RCALL AND WOULD MAIL HIM THE NOTICE. THE CURRENT AND FAILURE MILEAGES WERE 80,000.*AK LEFT MESSAGE 10/16/2007 . *LJ

I RECEIVED A NOTICE FROM TOYOTA THAT THE FRONT SUSPENSION LOWER BALL JOINT ON MY 2004 TUNDRA WAS BEING RECALLED. THE NOTICED STATED THAT I SHOULD CONTACT MY LOCAL TOYOTA DEALER TO SCHEDULE SERVICE TO REPLACE THIS PART. WHEN I CALLED I WAS TOLD THAT THEY WERE OUT OF THE PARTS AND WOULD NOT GET MORE UNTIL ABOUT 10 DAYS LATER. AFTER WAITING 10 DAYS, I THEN EMAILED THE SERVICE DEPARTMENT AT MY LOCAL DEALERSHIP THROUGH THEIR WEBSITE REQUESTING THAT THEY SCHEDULE AN APPOINTMENT FOR ME. I HAVE NOT HEARD BACK FROM THEM TWO WEEKS LATER DESPITE THEIR CLAIM THAT THEY WILL TRY TO RESPOND TO EACH INQUIRY WITHIN 24 HOURS. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED RECALL # 07V013000 REGARDING SUSPENSION: FRONT: CONTROL ARM: LOWER BALL JOINTS. HE TOOK THE VEHICLE TO TWO TOYOTA DEALERS, AND WAS INFORMED THAT IT WOULD BE APPROXIMATELY TWO WEEKS BEFORE THE NECESSARY PARTS ARRIVED. WHILE DRIVING 15 MPH HE LOST CONTROL OF THE VEHICLE. THE FRONT PASSENGER SIDE OF THE VEHICLE LOWERED AND THE TIRE DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO HIS RESIDENCE, AND HE WAS WAITING TO HEAR FROM THE DEALER. HE STATED THAT HE WILL FILE A COMPLAINT WITH THE MANUFACTURER, AND WILL CONTACT HIS STATE'S ATTORNEY GENERAL. THE INSURANCE COMPANY WILL NOT FILE A CLAIM FOR THE VEHICLE BECAUSE OF THE RECALL. HE WILL SUBMIT PICTURES, THE POLICE REPORT, AND OTHER INFORMATION ALONG WITH THE HARD COPY. THE CURRENT MILEAGE IS 61,000, AND THE FAILURE MILEAGE WAS UNKNOWN. *AK

TL*- THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT RECEIVED A RECALL 7V013000 ON MARCH 15, 2007 CONCERNING THE LOWER BALL JOINTS. THE DEALER STATED THAT THE PARTS WERE NOT AVAILABLE, AND THEY COULD NOT ESTIMATE WHEN THEY COULD PERFORM THE REPAIRS. HOWEVER, THEY ADDED HIS NAME TO THE WAITING LIST. THIS WAS THE ONLY DEALER IN THE AREA. THE CURRENT AND FAILURE MILEAGE WERE 51,140. THERE HAD BEEN NO FAILURES TO DATE. *AK

TL*- THE CONTACT CALLED REGARDING THE 2002 TOYOTA TUNDRA. THE CONTACT RECEIVED A RECALL NOTICE FOR THE LOWER BALL JOINTS. THE LOWER BALL JOINTS WERE REPLACED. THE CONTACT STATED THAT APPROXIMATELY 6 WEEKS LATER HE WAS TRAVELING AT 30 MPH, WHEN SOMETHING CAME LOOSE ON THE DRIVER'S SIDE AND THE VEHICLE STARTED TO WOBBLE. THE CONTACT LOST CONTROL AND STRUCK ANOTHER VEHICLE. THERE WAS DAMAGE TO THE DRIVER'S SIDE FRONT END. THE AIR BAGS DID NOT DEPLOY. THE FAILURE MILEAGE WAS 80,000. THERE WERE NO INJURIES. THERE WAS NO POLICE REPORT TAKEN THE CONTACT HAD PICTURES OF THE VEHICLE. *AK

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. ON JULY 31, 2006 THE LOWER BALL JOINTS FELL OFF THE FRONT PASSENGER SIDE WHILE PARKING. A MONTH LATER IN SEPTEMBER 2006THE LOWER BALL JOINTS FELL OFF THE DRIVER'S SIDE OF THE VEHICLE WITH THE TIRE WHILE SITTING AT A STOP SIGN. THE LOWER BALL JOINTS WERE REPAIRED, AND THE FOLLOWING YEAR THERE WAS A SAFETY RECALL FOR THE LOWER BALL JOINTS. THE CONTACT WOULD LIKE TO BE REIMBURSED FOR THE SAFETY REPAIRS. THE CONTACT MAILED ALL OF THE NECESSARY INFORMATION TO BE REIMBURSED IN OCTOBER 2006 TO THE MANUFACTURER AND RECEIVED NO RESPONSE TO DATE. *AK

TL* THE CONTACT OWNS A 2004 TOYOTA TUNDRA. THE CONTACT VIEWED A RECALL NOTICE FOR THE LOWER BALL JOINTS ON THE INTERNET. THE DEALER ADVISED THE CONTACT THEY WERE WAITING ON A RECALL NOTIFICATION FROM THE CORPORATE OFFICE. THE CONTACT WAS HAVING PROBLEMS MAINTAINING CONTROL OF THE VEHICLE WHILE DRIVING. THE CURRENT AND FAILURE MILEAGE WAS 100,000. THE DEALER DIAGNOSED THE FAILURE AS THE POWER STEERING PUMP AND REPLACED IT AT COST TO THE CONTACT. TWO TO THREE WEEKS AGO THE DEALER DIAGNOSED THE LOWER BALL JOINTS, AND ADVISED THE CONTACT THAT THEY WERE OPERATING NORMALLY. ON 2/19/07, WHILE DRIVING 25 MPH THE DRIVER LOST CONTROL OF THE VEHICLE AND CROSSED THE CENTER LINE, HITTING A WOODEN POST. THERE WAS DAMAGE TO THE FENDER, THE HOOD AND THE TIRE. THE DRIVER WAS UNABLE TO OPEN THE DOOR. THERE WERE NO PRIOR WARNING LIGHT INDICATORS. THERE WERE NO INJURIES ,AND THE...

THERE WAS NO EVENT LEADING UP TO FAILURE. THIS WAS TOTALLY UNSUSPECTED. THE FAILURE I EXPERIENCE IN MY 2004 TOYOTA TUNDRA OCCURRED AS I WAS TURNING FROM A SMALL STREET TO A MAJOR STREET. AS I WAS MAKING THIS TURN, THE DRIVER'S SIDE WHEELED SEPARATED FROM THE BALL JOINT CAUSING ME TO LOSE CONTROL OF THE VEHICLE. AS I LOST CONTROL OF THE VEHICLE THE TIRE BECAME LODGED IN THE WHEEL WELL CAUSING MY DRIVER'S SIDE DOOR TO BECOME JAMMED. I WAS NOT ABLE TO EXIT THE VEHICLE USING THIS DOOR. AS OF NOW, THE TRUCK IS STILL IN THE PARKING LOT AT THE DEALER BEING HELD UP BY A WOOD BLOCK. I WAS TOLD BY THE REPAIR DEPARTMENT THAT THE PARTS WILL NOT BE IN FOR A FEW WEEKS. TOYOTA CORP HAS NOT YET CONFIRMED OR DENIED RESPONSIBILITY, ALTHOUGH I WAS GIVEN A CASE NUMBER FOR MY CLAIM. I...

FAILURE OF LOWER BALL JOINT ON RIGHT SIDE CAUSED LOSS OF CONTROL AFTER WHEEL FELL UNDER VEHICLE, 4 WEEKS LATER LEFT BALL JOINT FAILED CAUSING LOSS OF CONTROL AFTER WHEEL FELL UNDER VEHICLE. BOTH HAD TO BE REPLACED. MANUFACTURER STATES THAT THIS YEAR VEHICLE IS NOT UNDER A RECALL AND HAS NO PROBLEM. *JB

I WAS TRAVELING NORTH ON SR 73 IN CALIFORNIA AT APPROXIMATELY 65 MPH. THE RIGHT FRONT LOWER BALL JOINT ON MY 2004 TOYOTA TUNDRA SNAPPED, WHICH CAUSED THE RIGHT FRONT WHEEL TO FOLD UNDER THE FRAME OF THE VEHICLE. I LOST CONTROL MOMENTARILY, BUT WAS ABLE TO REGAIN CONTROL AND GUIDE THE VEHICLE TO THE RIGHT SHOULDER. THE BALL JOINT FAILURE ALSO SEVERED THE BRAKE LINES, LEAVING ME WITH NO STOPPING ABILITY. I RESORTED TO THE MECHANICAL PARKING BRAKE TO STOP MY TRUCK. MY 2004 TUNDRA WAS TOWED TO LONGO TOYOTA IN EL MONTE CALIFORNIA WHERE IT SITS. I HAVE CONTACTED THE TOYOTA CORPORATE HQ, BUT WAS TOLD THAT MY TUNDRA WAS NOT INCLUDED WITH THE 775,000 OTHER TUNDRAS THAT WERE RECALLED FOR FAULTY LOWER BALL JOINTS. AS OF THIS TIME, THE DEFECTIVE PARTS ARE STILL ON THE VEHICLE AT LONGO. *NM

TL*- THE CONTACT HAS A TOYOTA TUNDRA WITH 45000 MILES WITH A FRONT DRIVER SIDE BALL JOINT FAILURE. THE CONTACT SAID THAT HE WAS DRIVING 35 MPH IN DRY WEATHER WHEN THE FAILURE HAPPENED, AND HE SLID ONTO THE SIDEWALK. THE CONTACT HAD THE TRUCK TOWED TO THE DEALER AND WILL HAVE THE REPAIR ORDER. THE CONTACT STATED THAT THERE IS A RECALL FOR THE BALL JOINT ON HIS YEAR AND MODEL TRUCK BUT THE DEALER TOLD HIM THAT HIS TRUCK WAS NOT INCLUDED.

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH ON NORMAL ROAD CONDITIONS AND PRIOR TO MAKING SHARP TURNS, THERE WAS A NOISE COMING FROM UNDERNEATH THE VEHICLE. ALSO, AFTER MAKING SHARP TURNS, THERE WAS DIFFICULTY IN THE RETURN MOVEMENT OF THE STEERING WHEEL. THIS DEFECT WAS OF A PERMANENT NATURE. DURING ALL TURNS, THE VEHICLE PULLED TO THE MEDIAN OR TO THE DIRECTION OF HOW IT WAS BEING TURNED. THERE WAS NO WARNING SIGNALS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO DETERMINED THAT THE FRONT LOWER BALL JOINTS WERE WORN. THE VEHICLE WAS NOT REPAIRED UNDER NHTSA RECALL #05V225000 REGARDING SUSPENSION:FRONT:CONTROL ARM: LOWER BALL JOINT. THE MANUFACTURER WAS NOT ALERTED. UPDATED 01/10/07. *JB

LOWER CONTROL BALL JOINT ON BOTH SIDES BUT ON DIFFERENT DATES OF ACCIDENT AND THERE IS A RECALL 05V-225 AND EA04-024 POLICE REPORT DATES 19 OCT 2006 # 2006-11-038-04829 RIGHT SIDE ON LEFT SIDE POLICE REPORT 3 NOV 2006 #2006-11-038-05061*JB

FAILURE OF LOWER BALL JOINT LEFT FRONT WHEEL. UPPER AND LOWER BALL JOINTS BOTH FAILED AND SEPARATED RESULTING IN FRONT WHEEL FALLING OFF AD LODGING UNDER FRAME OF TRUCK. *JB

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH, THE FRONT DRIVER WHEEL SEPARATED FROM THE VEHICLE. IT WAS TOWED OFF THE ROAD AND TO THE DEALER WHO DETERMINED THE FRONT LOWER BALL JOINT NEEDED TO BE REPLACED. THERE WAS A NHTSA RECALL, # 05V225000, REGARDING THE FRONT LOWER BALL JOINT. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. UPDATED 12/18/2006 - *NM

WHILE DRIVING MY 2004 TOYOTA TUNDRA AT APPROXIMATELY 55 MILES PER HOUR, ON A STATE HIGHWAY, THE RIGHT FRONT WHEEL SUDDENLY CAME OFF. THE LOWER BALL JOINT HAD FAILED. VEHICLE HAS 27,000 MILES. ACCORDING TO TOYOTA COMPANY MY VEHICLE WAS NOT INCLUDED IN THE 2005 RECALL SINCE ITS SERIAL NUMBER WAS "OUTSIDE THE SERIES OF NUMBERS RECALLED.". *JB

DT*: THE CONTACT STATED WHILE DRIVING 30 MPH IN THE CITY, A NOISE WAS HEARD AND THE RIGHT FRONT WHEEL DROPPED. THE VEHICLE WAS UNABLE TO MOVE OFF THE ROAD AND WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE RIGHT FRONT LOWER BALL JOINT FRACTURED. THE REPAIR SHOP REPLACED BOTH FRONT UPPER AND LOWER BALL JOINTS AND THE FRONT RIGHT TIRE. THE DEALER WAS NOTIFIED. UPDATED 11/20/2006 - THE CONSUMER CONTACTED THE MANUFACTURER BUT THE PROVIDED NO ASSISTANCE. THERE WAS A RECALL FOR THE BALL JOINT BUT THE CONSUMER'S VEHICLE WAS NOT INCLUDED IN THE RECALL. *NM

DT*: THE CONTACT STATED WHILE TRAVELING 40 MPH, THE DRIVER SIDE FRONT TIRE DISLOCATED FROM THE VEHICLE. AFTER BEING TOWED TO THE DEALERSHIP, IT WAS DETERMINED THE LOWER BALL JOINT WAS FRACTURED. THERE WAS A NHTSA RECALL, #05V225000, REGARDING THE LOWER BALL JOINT, BUT THE VEHICLE WAS NOT INCLUDED DUE TO THE VIN. UPDATED 11/30/06. *JB

THIS IS A SECOND COMPLIANT. THE FIRST COMPLIANT DID NOT HAVE THE CORRECT HOME ADDRESS. THE P.O. BOX IS MY MAILING ADDRESS. ON 2/24/06 ANTIOCH TOYOTA DELIVERED A 2004 TOYOTA TUNDRA TO MY HOME. THE FIRST COMPLIANT NUMBER IS #10169458 MOST OF THE INFO IS THE SAME ACCEPT THE ADDRESS TO WHERE THE CAR IS LOCATED. THE SUSPENSION:FRONT CONTROL ARM LOWER BALL JOINT BROKE AND THE AXLE ON MY TRUCK SNAPPED AND BROKE. THE TRUCK WAS TOWED TO ALMADEN TOYOTA IN SAN JOSE CA AND THAT IS WHERE IT IS NOW. I CALLED TOYOTA AND THEY TOLD ME TODAY THAT THIS TRUCK WAS NOT ONE THAT WAS RECALLED ACCORDING TO THEIR RECORDS, BUT THEY WILL HAVE SOMEONE COME OUT AND INSPECT THE TRUCK. HOW DID IT BREAK IF THE PART WAS NOT BAD? THE RECALL DOES NOT LIST VIN NUMBERS THAT ARE AFFECTED BY THIS RECALL, ONLY MODEL NAMES: 2004...

BALL JOINT RECALL FOR 2004 TOYOTA TUNDRAS 4X4. MY TRUCK HAS BAD BALL JOINTS TOYOTA SAYS IT IS NORMAL WEAR AND TEAR AFTER I GOT RECALL NOTICE. HELP. *NM

DT*: THE CONTACT STATED WHILE TRAVELING 5 MPH, THE FRONT LOWER CONTROL ARM HAD FRACTURED OFF. THERE WAS A RECALL (05V225000) REGARDING THE LOWER CONTROL ARM, BUT THE MANUFACTURER STATED THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

DT*: THE CONTACT STATED WHILE DRIVING 5 MPH ON NORMAL CITY ROAD THE FRONT SUSPENSION BALL JOINT FRACTURED CAUSING THE RIGHT WHEEL TO SEPARATE. PRIOR TO THE INCIDENT, THERE WAS A NOISE WHILE MAKING TURNS. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE BALL JOINTS WERE REPLACED. TWO MONTH LATER THE LEFT BALL JOINT FAILED WITH THE LEFT WHEEL SEPARATION. DURING THIS INCIDENT, THE VEHICLE WAS ALSO TRAVELING AT LOW SPEEDS. THERE WAS A RECALL # 05V225000 REGARDING THE BALL JOINTS. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE MANUFACTURER WAS ALERTED. UPDATED 11/21/06. *JB

DT*: THE CONTACT STATED, THE STEERING BEGAN TO FAIL WHILE TRAVELING AT 65 MPH., IN DRY, CLEAR CONDITIONS ON THE FREEWAY. THE VEHICLE WAS PULLED OFF TO THE SIDE OF THE HIGHWAY AND SLOWED TO 15 MPH. WHILE ATTEMPTING TO STOP THE FRONT LEFT WHEEL FELL OFF DISLOCATING THE AXLE. WHEN TOWED TO THE SERVICE DEALER, THE MECHANIC IDENTIFIED THE LOWER FRONT BALL JOINT HAD FRACTURED AND THE UPPER BALL JOINT HAD BEEN DAMAGED. THE MANUFACTURER WAS CONTACTED. UPDATED 05/21/07 *TR

WE RECEIVED A NOTICE FOR RECALL FOR ALL TOYOTA TUNDRAS BETWEEN THE YEAR 2002 TO 2004 BECAUSE OF FRONT SUSPENSION LOWER BALL JOINT (SSC50J). BECAUSE OF THE RECALL, WE MADE AN APPOINTMENT AND WENT TO THE SERVICE LOCATION GIVEN IN THE NOTICE. THE APPOINTMENTS FOR BOTH WERE MADE AND USING OUR VIN NUMBER TOLD US THAT BOTH OUR TRUCKS DON'T NEED SERVICING AND SO DISMISSED BOTH, IN FLORIDA AND NEW YORK. ON FRIDAY, MY HUSBAND WAS DRIVING THE TRUCK IN NEW YORK AND WAS ABOUT TO ENTER A MAJOR HIGHWAY WHEN THE TIRE FELL OUT. WE ARE INCLINED TO BELIEVE THAT IT WAS THE RESULT OF A DEFECTIVE PART PUT IN BY THE MANUFACTURER. BECAUSE MY HUSBAND WAS DRIVING, HE WAS ABLE TO SAFELY STEER AWAY FROM A MAJOR COLLISION. BASICALLY WE WERE VERY LUCKY THIS TIME. IMAGINE IF IT WERE SOMEONE, MYSELF INCLUDED, WITH LESS EXPERIENCE WHO HAPPENED TO...

DT*: THE CONTACT STATED THE BALL JOINTS HAD BEEN REPLACED TWICE. PRIOR TO BOTH FAILURES THE STEERING BECAME DIFFICULT. THE DEALERSHIP REPLACED THE RIGHT FRONT LOWER BALL JOINT SIX MONTHS AGO UNDER A GOOD WILL CAMPAIGN. THE LEFT UPPER BALL JOINT ALSO FRACTURED HOWEVER THE DEALERSHIP WILL NOT REPAIR IT AT NO COST. THE MANUFACTURER WAS ALERTED WHO EXPLAINED THERE WAS NOT A RECALL.

DT*: THE CONTACT STATED WHILE TRAVELING LESS THAN 10 MPH, THE DRIVER'S SIDE FRONT END COLLAPSED TO THE GROUND. THE VEHICLE WAS TOWED TO THE DEALERSHIP, WHERE IT WAS DETERMINED THE LOWER BALL JOINT FRACTURED. THERE WAS MINOR DAMAGE TO THE BODY AS A RESULT. THERE IS A NHTSA RECALL, # 05V225000, REGARDING THE LOWER BALL JOINT; HOWEVER, IT IS NOT INCLUDED IN THE RECALL. UPDATED 6/12/2006 -*NM

DT*: THE CONTACT STATED WHILE ATTEMPTING TO MAKE A RIGHT HAND TURN AT 15 MPH THE LOWER BALL JOINT FRACTURED AND BENT THE DRIVESHAFT AND FRONT FENDER. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. THE INSURANCE AGENCY NOTIFIED THE CONTACT THERE WAS A RECALL. NHTSA RECALL # 05V225000 REGARDING THE SUSPENSION FRONT CONTROL ARM LOWER BALL JOINT. THE DEALERSHIP DETERMINED THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE MANUFACTURER WAS CONTACTED. UPDATED ON 05/30/2006. *AK

DT*: THE CONTACT STATED WHILE DRIVING AT 10 MPH THE FRONT DRIVERS SIDE WHEEL FELL OFF. THE VEHICLE WAS TOWED TO THE RESIDENCE WHERE THE CONTACT REPLACED THE LOWER BALL JOINT. FOUR MONTHS LATER THE FRONT PASSENGER SIDE WHEEL FELL OFF DUE TO THE SAME PROBLEM. THE VEHICLE IS AT THE DEALERSHIP CURRENTLY FOR THE SECOND REPAIR. THERE IS A NHTSA RECALL, # 05V225000, REGARDING THE LOWER BALL JOINT. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

WE HAVE A TOYOTA TUNDRA A 2004, MY HUSBAND SAID IT WAS STEERING LIKE SOMETHING WAS CATCHING HE TOOK IT TO A REPAIR SHOP THEY COULD NOT FIND ANYTHING WRONG, SO WE PICKED IT UP THAT SAME DAY, TOOK IT ON A TRIP, ON OUR WAY BACK GOING 70 MPH ON THE HIGHWAY IT FELT LIKE THE WHOLE FRONT DRIVERS SIDE OF OUR TRUCK FELL OFF, IT WAS A TERRIBLE TERRIFYING JOLT MY HUSBAND KNEW THAT WE HAD LOST THE TIRE AND RIM SPARKS WERE FLYING EVERYWHERE AS WE WERE SLIDING DOWN THE HIGHWAY ON THE AXEL, LUCKILY WE WERE ON A STRAIGHT AWAY WITH NO TRAFFIC BUT ONE VEHICLE BEHIND US. THE FRICTION SLOWED THE TRUCK DOWN, WE PULLED IT OFF THE HIGHWAY, WE WERE SURPRISED TO SEE THAT THE BALL JOINT HAD COLLAPSED AND THE TIRE AND WHEEL WERE FOLDED UNDER THE TRUCK SO THAT THE TRUCK WAS...

DT: THE CONTACT RECEIVED NHTSA RECALL CAMPAIGN 05V225000 CONCERNING THE LOWER BALL JOINT. THIS VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL. ACCORDING TO THE DEALER AND MANUFACTURER THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. ALTHOUGH THE LOWER BALL JOINTS FAILED THE VEHICLE HAD NOT BEEN REPAIRED. *AK UPDATE 2/21/2006 - THE CONSUMER WAS DRIVING WHEN THE RIGHT LOWER BALL JOINT FAILED WITHOUT WARNING. AS A RESULT THE FRONT RIGHT TIRE SEPARATED FROM THE VEHICLE. *NM

DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 05V225000 CONCERNING THE FRONT LOWER BALL JOINTS. THIS VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IT IS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONTACT REPAIRED THE VEHICLE AT HIS OWN EXPENSE. *AK

DT: 2004 TOYOTA TUNDRA. THE CONSUMER STATED THE LOWER BALL JOINT ON THE FRONT PASSENGER'S SIDE SEPARATED AND THE TIRE FELL OFF. THE CONSUMER FOUND RECALL, 05V225000, BUT HIS VEHICLE WAS NOT INCLUDED. THIS HAPPENED ON AUGUST 31, 2005. THE CONSUMER NOTICED THE STEERING FELT FUNNY, LIKE THERE WAS LOW AIR PRESSURE IN THE TIRE. THE VEHICLE WAS TOWED TO A DEALERSHIP, AND THEY WOULD NOT COVER THE REPAIRS. THE WHOLE FRONT END WAS DAMAGED; IT PULLED OUT OF THE AXLE FROM THE 4 WHEEL DRIVE. IT BENT THE UNDER CARRIAGE, THE FENDER, TIE ROD ENDS AND STEERING. ALSO, IT RUINED THE TIRE. CONSUMER STATED THE VEHICLE WAS GOING BETWEEN 30-35 MPH AND HE WAS ABLE TO KEEP IT ON THE ROAD. THERE WAS NO CRASH.*AK *JB