2014 TOYOTA SIENNA — Problems, Recalls & Safety Data

The vehicle died while driving and when I try to start again it will crank but can't start.

Dear sir/ madam, I am writing to report an issue with recall status reporting. All open recalls for my vehicle (VIN: [XXX] ) were completed at an authorized dealership on [01/27/2026]. I have documentation from the dealer confirming that the recall repairs were successfully performed. However, the recall status has not been updated in the NHTSA database and still appears as “open.” I request assistance in ensuring the recall completion is properly reported and reflected in the NHTSA system. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The passenger-side power sliding door system failed to stop or reverse when it encountered physical interference with the vehicle’s open fuel door. The door continued opening under power despite clear obstruction by a fixed exterior body component. The affected components, including the sliding door mechanism and damaged fuel door latch, remain available for inspection upon request. A powered sliding door continuing to operate against an obstruction creates a foreseeable risk of injury to occupants or bystanders, as well as vehicle damage. If a person’s hand, arm, or clothing had been in the same position as the fuel door, injury could have occurred. The incident occurred during normal vehicle use and demonstrates inadequate safeguards against obstruction. The issue has been formally reproduced or confirmed by an independent service center which noted that the incident occurred as described during normal operation of the power sliding door, and no abnormal conditions were present at the time. No warning lamps, messages, or other symptoms appeared prior to the incident. The power sliding door operated normally and without indication of malfunction until it failed to stop when encountering the open fuel door. Fueling the vehicle with the fuel door open is routine and expected vehicle use. The absence of any interlock, sensor logic, or safeguard preventing a powered sliding door from operating against an open body panel represents a design deficiency rather than a maintenance or wear issue. This condition may affect other vehicles equipped with similar power sliding door systems and warrants evaluation.

Odometer Fraud. The contact purchased a 2014 Toyota Sienna. The contact stated that upon taking the vehicle to a dealer for an oil change, it was discovered through the Carfax report that there was a mileage discrepancy. The vehicle was a private sale through Facebook Market Place. At the time of purchase, the vehicle mileage was 146,000, but upon retrieving the Carfax report, the contact discovered that the mileage was 187,391 on the State inspection report dated June 18, 2025. The issue had not been reported to another agency.

The contact owns a 2014 Toyota Sienna. The contact stated that while driving 70 MPH, there was an audible alarm coming from the vehicle, alerting the contact that the door was ajar. The passenger’s side slide door opened independently while the vehicle was in motion. The vehicle was modified to accommodate a ramp for the contact's two wheel-bound children. The contact pulled over to the side of the road and closed the sliding door. The contact's husband tied the door to prevent it from opening independently again. The check engine warning light was intermittently illuminated. The vehicle was taken to the dealer, where it was inspected. The contact was informed that two latches had corroded and needed to be replaced. The vehicle was not repaired. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 16V858000 (STRUCTURE). However, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,500.