2010 TOYOTA SIENNA — Problems, Recalls & Safety Data

We recently had a full diagnostic check done on our vehicle (199 point at Parkway Automotive in Little Rock, Arkansas) that listed some components in need of repair. The only part involving the electrical system needing repair was our battery which was testing as no longer holding enough charge. We took the vehicle to Sam's Club in North Little Rock, AR within the last 2-3 weeks and had the battery replaced with a new Duracell with 3 year warranty. We drove away with no issues with the vehicle and used it for local driving without issues for those 2-3 weeks. The morning of Thursday, December 29, 2022 we started the car to drive to our church about 2 miles away with our four young children (1, 5, 8, 10). In the short drive, dash lights were flickering and the nav/audio screen system was turning off and restarting. Upon arrival at the church, as we were parking the car, gray smoke began to come from the hood quickly. The children were all still strapped in seatbelts and carseat, so we quickly unloaded them from the car and took them inside the building. While we were unloading them from the vehicle we observed the following: -black smoke pouring from driver's side hood -sparks falling on the ground from driver's side engine compartment, near bumper -spurts of fire coming from the hood and below the bumper on driver's side -charring and melting coming from the vents/lights where each child was seated in the 2nd and 3rd row seating After calling the fire department and locating a fire extinguisher, the fire quickly grew into an uncontrollable blaze so we all went inside the building as quickly as possible to avoid injury. Shortly thereafter, the battery itself seemed to explode (a loud explosion was heard and then a smaller one) and the driver windshield was blown. The fire was large enough to seem to be traveling toward the gas tank and we were afraid of a big disaster. The fire department then arrived and extinguished the fire and made a report.

Massive Oil Leak and Loss of Oil Pressure: Oil line burst while driving on the HWY coming back home from a work. Loss nearly all of the oil, but there were no warning lights. Pulled over into gas station. Checked dip stick, completely dry! Catastrophic oil leak without warning. Could have been stalled on the HWY and caused major ACCIDENT. Tried to refill oil but it all leaked out as soon as I started engine. Research around the web and find out that this is a known issue to Toyota for using rubber VVTI oil line - Part # 15772-31030 Now this part is made all metal!

The contact's father owned a 2010 Toyota Sienna. The contact stated while his father was driving to the hospital at 30-40 MPH for a medical emergency, he lost consciousness. The vehicle crashed into a steel fence. The air bags failed to deploy. The contact's father was transported to the hospital by emergency units where it was diagnosed that he had sustained a broken neck, which made it impossible for the medical personnel to treat him. The contact's father deceased while in the hospital. A police report was filed. The vehicle was towed to a tow yard where it was totaled. The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2010 Toyota Sienna. The contact stated while driving approximately 15-20 MPH, the vehicle stalled inadvertently. The check engine warning light, the traction control warning light, and other unknown warning lights illuminated. Additionally, the contact stated that the steering wheel lost power steering functionality. The contact was able to veer to the side of the road. The contact stated that the vehicle failed to restart while in Park; however, the vehicle restarted when he shifted into Neutral. The contact drove the vehicle to his residence. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that they could not assist as there were no open recalls associated with the failure. The failure mileage was approximately 115,000.

The contact owns a 2010 Toyota Sienna. The contact stated while driving approximately 15-20 MPH, the vehicle stalled inadvertently. The check engine warning light, the traction control warning light, and other unknown warning lights illuminated. Additionally, the contact stated that the steering wheel lost power steering functionality. The contact was able to veer to the side of the road. The contact stated that the vehicle failed to restart while in Park; however, the vehicle restarted when he shifted into Neutral. The contact drove the vehicle to his residence. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that they could not assist as there were no open recalls associated with the failure. The failure mileage was approximately 115,000.