2012 TOYOTA SIENNA — Problems, Recalls & Safety Data
4/5
Safety Rating
331
Owner Complaints
9
Recalls
27
Service Bulletins
0
Investigations
Overview of the 2012 TOYOTA SIENNA
The 2012 TOYOTA SIENNA has received a total of 331 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). It earned an overall safety rating of 4 out of 5 stars in NHTSA's New Car Assessment Program crash tests. There have been 11 recall campaigns affecting this vehicle, covering issues with SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS, AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE, AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE. 27 technical service bulletins have been issued by Toyota Motor Corporation for this model year. The most commonly reported problems involve the Air Bags (84 complaints), Structurebody (55 complaints), and Unknown Or Other (28 complaints).
Recalls for the 2012 TOYOTA SIENNA
NHTSA has recorded 11 recalls for the 2012 TOYOTA SIENNA, potentially affecting up to 4,702,861 vehicles.
Recall 19V553000 — SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
| 303 vehicles affected
Defect: Vantage Mobility International, LLC (Vantage) is recalling certain 2012-2018 AMS Genesis wheelchair vans, built on a Toyota Sienna vehicles. The rubber brake hoses that attach to the rear wheel assembly may be too short, causing them to rub against the rear axle trailing arm.
Consequence: The contact may cause failure of the rear brake hoses, resulting in a loss of vehicle control and reduced braking ability, increasing the risk of a crash.
Remedy: Vantage will notify owners, and dealers will install a set of rear brake hoses that will provide the proper clearance, free of charge. The recall began December 16, 2019. Owners may contact Vantage customer service at 1-800-488-9082.
View full details →Recall 19V741000 — AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
| 928,220 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger...
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact...
View full details →Recall 19V741000 — AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
| 928,220 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger...
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact...
View full details →Recall 19V005000 — AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
| 1,299,448 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2014-2016 Toyota 4Runner, 2014-2015 Scion xB, Lexus IS350C, IS250C, 2014 Toyota Sienna, Lexus IS-F, and 2014-2017 Lexus GX460 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin...
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began February 15, 2019. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers...
View full details →Recall 16V858000 — STRUCTURE:BODY:DOOR
| 744,437 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.
Consequence: If door opens while the vehicle is moving, there would be an increased risk of injury to the vehicle occupants.
Remedy: Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331....
View full details →Recall 17V006000 — AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
| 577,875 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2012 Toyota 4Runner, Corolla, Corolla Matrix, Sienna, Yaris, Scion xB, Lexus ES350, GX460, IS-F, IS250, IS350, IS250C, IS350C, and Lexus LFA vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S....
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began...
View full details →Recall 13V123000 — EQUIPMENT:OTHER:LABELS
| 7,525 vehicles affected
Defect: Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion...
Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may...
View full details →Recall 13V014000 — SEATS
| 3,235 vehicles affected
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model...
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
View full details →Recall 13V014000 — AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
| 3,235 vehicles affected
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model...
Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
View full details →Recall 12V120000 — EQUIPMENT:ELECTRICAL
| 363 vehicles affected
Defect: GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2012 4RUNNER AND SIENNA VEHICLES, EQUIPPED WITH NON-ORIGINAL EQUIPMENT REMOTE ENGINE STARTERS. A MALFUNCTION IN THE AUDIOVOX ELECTRONICS BRAND REMOTE ENGINE STARTER MODULE CAN PREVENT NORMAL COMMUNICATION OF THE VEHICLES CONTROLLER AREA NETWORK (CAN).
Consequence: IF THIS CONDITION OCCURS, ANTILOCK BRAKING AND STABILITY CONTROL MAY BE LOST, INCREASING THE RISK OF A CRASH. DRIVERS SHOULD RECEIVE DASHBOARD WARNING LIGHTS WARNING THEM OF A MALFUNCTION.
Remedy: GULF STATES TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE REMOTE ENGINE STARTER WITH A NEW ONE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JUNE 4, 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-444-1074.
View full details →Recall 11V560000 — EQUIPMENT:OTHER:LABELS
| 210,000 vehicles affected
Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 THROUGH 2012 SIENNA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110, "TIRE SELECTIONS AND RIMS." THESE VEHICLES DO NOT MEET THE REQUIREMENT FOR DISPLAYING THE CORRECT VEHICLE CAPACITY WEIGHT AS THE RATED LOAD FOR THE COMBINATION OF CARGO AND OCCUPANTS.
Consequence: INCORRECT INFORMATION ON THE VEHICLE PLACARD MAY LEAD TO TIRE OVERLOADING AND POSSIBLY CAUSE TIRE FAILURE INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND WILL PROVIDE A REMEDY WHEN IT IS AVAILABLE. TOYOTA WILL MAIL OUT A CORRECTED PLACARD TO CUSTOMERS ALONG WITH REVISED OWNER MANUAL INFORMATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN...
View full details →Owner Complaints for the 2012 TOYOTA SIENNA
331 complaints have been filed with NHTSA for the 2012 TOYOTA SIENNA. Below is a breakdown by vehicle component.
Most Recent Complaints
The contact owns a 2012 Toyota Sienna. The contact was unable to use the driver's side cargo door. The contact stated that the door was possibly frozen; however, while driving at an undisclosed speed, the door opened unexpectedly. The contact referenced NHTSA Campaign Number: 16V858000 (Structure); however, the VIN was not associated with the recall. The dealer was not contacted, and the vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 201,235.
Coolant leaking from rear of the engine through the head gasket. Vehicle struggles to accelerate beyond 55mph or 80kmph. A quick search on the internet shows that this is a frequent occurrence in this 3.5L V6 engine from Toyota model years 2011 through 2017.
The battery light came on suddenly and the power steering went out making it extremely difficult to steer the vehicle. An accident was narrowly avoided. We replaced the battery, alternator, and serpentine belt. The problem resolved for over 6 months, then reappeared. It starts with no issue, is charging properly, the serpentine belt is intact. The power steering will come on and go off sporadically, the only warning being the battery indicator on the dash that comes on first. This creates a substantial hazard and risk as the steering is severely impacted with little warning.
Odometer Fraud. The contact purchased a 2012 Toyota Sienna. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 48,230. It was later discovered that the mileage on the Title was 241,080.
The power sliding door cables snap by itself and unable to open or closed. While my children and I were in the vehicle.
Safety Rating for the 2012 TOYOTA SIENNA
The 2012 TOYOTA SIENNA received an overall safety rating of 4 out of 5 stars from NHTSA's New Car Assessment Program (NCAP).
| Test Category | Rating |
|---|---|
| Overall Rating | ★★★★☆ (4/5) |
| Frontal Crash | ★★★★☆ (4/5) |
| Side Crash | ★★★★★ (5/5) |
| Rollover | ★★★★☆ (4/5) |
Safety ratings are based on controlled crash tests conducted by NHTSA. A 5-star rating indicates the highest level of occupant protection.
Technical Service Bulletins for the 2012 TOYOTA SIENNA
Toyota Motor Corporation has issued 27 technical service bulletins (TSBs) for the 2012 TOYOTA SIENNA. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
ZH5_Toyota POL17 — STRUCTURE
Customer Support Program: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011?2018 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or right power sliding door rear lock assembly caused that door to exhibit one...
ZH5_Dealer Packa — LATCHES/LOCKS/LINKAGES
Dealer Package: June 19, 2019 Information about a proposed class action settlement has been added. ? Toyota has expanded the covered vehicle population. ? Toyota has extended the coverage period by one additional year. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a class...
T-SB-0066-19 — STRUCTURE
TSB: Some 2011 ? 2018 model year Sienna vehicles equipped with manual doors may exhibit a condition where the slide door center hinge has corroded, causing the slide door to become difficult to operate while opening or closing. Follow the Inspection and Repair Procedures in this bulletin to address this...
ZKI_Dealer Packa — STRUCTURE:BODY:DOOR
Dealer Package: Certain 2011 - 2018 Model Year Sienna Vehicles Coverage for Internal Functional Concerns of Certain Sliding Door Parts. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a Sienna sliding door class action settlement, Toyota is announcing a Customer Confidence Program. The following...
ZKE_Toyota POL19 — FUEL/PROPULSION SYSTEM
Customer Support Program: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the fuel filler door hinge and pin. Although the fuel filler door hinge and pin are covered...
ZKD_Toyota POL19 — STRUCTURE:BODY:DOOR
Customer Program Support: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the power sliding door cable sub-assembly. Although the power sliding door cable sub-assemblies are covered by Toyota?s...
TSR-SC-032819 — EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Technician Certification Requirements.
E0N_Dealer Lette — EQUIPMENT
Dealer Letter: October 23, 2017 A watermark has been added to the Dealer Letter to indicate that E0N expired on June 30, 2017.
ZH4_Dealer Email — STRUCTURE:BODY:DOOR
Dealer Email: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side sliding door, the door would not completely close and latch due to corrosion...
ZH4_Toyota POL17 — LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Warranty Policy Bulletin: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side sliding door, the door would not completely close and latch due to...
Showing 10 of 27 technical service bulletins.
NHTSA Investigations for the 2012 TOYOTA SIENNA
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the TOYOTA SIENNA
- 2007 TOYOTA SIENNA — 448 complaints
- 2008 TOYOTA SIENNA — 569 complaints
- 2009 TOYOTA SIENNA — 270 complaints
- 2010 TOYOTA SIENNA — 226 complaints
- 2011 TOYOTA SIENNA — 809 complaints
- 2012 TOYOTA SIENNA (current)
- 2013 TOYOTA SIENNA — 223 complaints
- 2014 TOYOTA SIENNA — 205 complaints
- 2015 TOYOTA SIENNA — 281 complaints
- 2016 TOYOTA SIENNA — 98 complaints
- 2017 TOYOTA SIENNA — 189 complaints
Other TOYOTA Models
- TOYOTA CAMRY — 23,209 total complaints
- TOYOTA PRIUS — 15,411 total complaints
- TOYOTA COROLLA — 14,342 total complaints
- TOYOTA RAV4 — 11,737 total complaints
- TOYOTA TACOMA — 10,512 total complaints
- TOYOTA TUNDRA — 8,997 total complaints
- TOYOTA HIGHLANDER — 6,663 total complaints
- TOYOTA 4RUNNER — 6,405 total complaints