2007 TOYOTA RAV4 — Problems, Recalls & Safety Data
N/A
Safety Rating
1,240
Owner Complaints
14
Recalls
11
Service Bulletins
1
Investigation
Overview of the 2007 TOYOTA RAV4
The 2007 TOYOTA RAV4 has received a total of 1,240 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 15 recall campaigns affecting this vehicle, covering issues with SUSPENSION:REAR, SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER, SEAT BELTS:REAR/OTHER. 11 technical service bulletins have been issued by Toyota Motor Corporation for this model year. The most commonly reported problems involve the Steering (268 complaints), Engine (195 complaints), and Suspension (123 complaints).
Recalls for the 2007 TOYOTA RAV4
NHTSA has recorded 15 recalls for the 2007 TOYOTA RAV4, potentially affecting up to 11,284,327 vehicles.
Recall 16V596000 — SUSPENSION:REAR
| 337,449 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a...
Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are...
View full details →Recall 16V396000 — SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
| 7,749 vehicles affected
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element....
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET...
View full details →Recall 16V096000 — SEAT BELTS:REAR/OTHER
| 1,123,752 vehicles affected
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
Consequence: A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Remedy: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is...
View full details →Recall 15V689000 — VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
| 1,814,284 vehicles affected
Defect: Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been...
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20,...
View full details →Recall 14V743000 — SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
| 3,233 vehicles affected
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact...
View full details →Recall 14V168000 — AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
| 1,486,413 vehicles affected
Defect: Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of...
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when...
View full details →Recall 13V383000 — SUSPENSION:REAR
| 780,584 vehicles affected
Defect: Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the...
Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future...
View full details →Recall 12V373000 — SUSPENSION:REAR
| 780,584 vehicles affected
Defect: Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the...
Consequence: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on...
View full details →Recall 12V491000 — VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
| 2,519,424 vehicles affected
Defect: Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process...
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a...
View full details →Recall 11V245000 — AIR BAGS:SIDE/WINDOW
| 307,848 vehicles affected
Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION...
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE....
View full details →Recall 11V245000 — AIR BAGS
| 307,848 vehicles affected
Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION...
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE....
View full details →Recall 11V113000 — VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
| 1,363,244 vehicles affected
Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT...
View full details →Recall 10V036000 — EQUIPMENT:OTHER:LABELS
| 153,418 vehicles affected
Defect: SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
View full details →Recall 10V035000 — EQUIPMENT:OTHER:LABELS
| 271,417 vehicles affected
Defect: GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS...
View full details →Recall 09V223000 — EQUIPMENT:OTHER:LABELS
| 27,080 vehicles affected
Defect: TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
View full details →Owner Complaints for the 2007 TOYOTA RAV4
1,240 complaints have been filed with NHTSA for the 2007 TOYOTA RAV4. Below is a breakdown by vehicle component.
Most Recent Complaints
UNKNOWN
My driver side door caught on fire and was completely destroyed to include all associated wiring. Toyota had my contact information but never contacted me about any of the recalls.
The contact owns a 2007 Toyota Rav4. The contact stated that the vehicle could not be aligned. There were no warning lights illuminated. The vehicle was previously taken to the local dealer to be repaired under NHTSA Campaign Number: 16V596000 (Suspension). The vehicle was taken to a tire shop, and the contact was informed that the rear tie rods were welded, and an alignment was impossible. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 182,342.
Other people keep using my Bluetooth from my Toyota RAV4 2007. I don't even use it anymore. I found out because my android vehicle app keeps activating. Also, I live in a apartment complex, and notice when I look out my window, people walk by and slow down and stop right in front of my car and start messing with their phone. It appears they are hacking into the Bluetooth. I've also had much financial theft from my bank account.. including I paid for my auto insurance months ago, now I go on the AZ MDV and it's saying that my car is not insured! I'm a domestic violence victim..Its causing safety issues for me..I'm really upset. Also, your website is saying it's September 8, 2025. My phone is saying it's September 7th 2025. I don't know what to do!?!? Someone is causing me a lot of mental anquish. I know I have Recalls on this car, it says I have nun on the Toyota site yet in other places it says I have Recalls. I just feel extremely unsafe and angry that Toyota never sends me anything about my car.
Safety Rating for the 2007 TOYOTA RAV4
NHTSA has not yet tested the 2007 TOYOTA RAV4 in its New Car Assessment Program.
Technical Service Bulletins for the 2007 TOYOTA RAV4
Toyota Motor Corporation has issued 11 technical service bulletins (TSBs) for the 2007 TOYOTA RAV4. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
G0Y_JR8_Region E — EQUIPMENT
Region Email: Toyota will be sending Safety Recall and Special Service Campaign follow-up notices to owners whose vehicles have not yet had the following Safety Recall or Special Service Campaign repairs completed. Please note the following information for Regional and PD associates.
G0Y_Dealer Packa — ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Dealer Package: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (?Cold Climate States?) may exhibit more-than-normal corrosion to the vehicle?s Center No.2 Exhaust Pipe sub-assembly...
G0Y Dealer Packa — ENGINE AND ENGINE COOLING
Dealer Package Email: Toyota has received reports that certain 2006 through 2008 Model Year RAV4 vehicles (equipped with a V6 (2GR) engine) operated in specific cold climate areas where high amounts of road salt are used (?Cold Climate States?) may exhibit more-than-normal corrosion to the vehicle?s Center No.2 Exhaust Pipe...
ZF4_DEALERD 12/3 — POWER TRAIN
"DD: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 4WD VEHICLES. IN SOME OF THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS THAT THE...
T-TT-0361-15 — EQUIPMENT
TT: Based on current part order allocation, some piston types have been incorrectly identified while undergoing the ZE7 2AZ Oil Consumption repair procedure. Replacement pistons for ZE7 should be ordered based on the pistons removed from the existing cylinder block and no longer by the measurement. This Tech Tip includes...
T-TT-0255-13 — EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
While performing T-SB-0318-08, this document should be used to help supplement which parts to order prior to performing the repair.
TSB-0157-12 — STEERING:LINKAGES:TIE ROD ASSEMBLY
TOYOTA: PROCEDURAL INFORMATION PROVIDED FOR REAR TIE ROD ADJUSTMENT TO ASSURE PROPER SEQUENCE OF TIGHTENING AND USE WHENEVER PERFORMING TOE ADJUSTMENT DURING WHEEL ALIGNMENT. MODELS 2006-11 RAV4. *PE
TSB-0056-11 — ENGINE AND ENGINE COOLING:ENGINE
TOYOTA: 2006-2008 RAV4. ABNORMAL NOISE FROM THE IDLER PULLEY ASSEMBLY. *RM
TSB-0111-10 — ENGINE AND ENGINE COOLING:ENGINE
TOYOTA: 2AZ-FE & 2AZ-FXE THROTTLE BODY. ENGINE CONTROL. PROVIDE UPDATED THROTTLE BODY PART NUMBER INFORMATION FOR CERTAIN VEHICLES. THE DRAIN PIPE HAS BEEN ELIMINATED ON THROTTLE BODY SERVICE PARTS. *PE
TSB-0318-08 REV1 — STEERING
TOYOTA: STEERING INTERMEDIATE SHAFT NOISE. MAY HEAR A CLUNK, POP, OR KNOCK TYPE NOISE WHEN TURN IN THE STEERING WHEEL LEFT OR RIGHT. A NEW INTERMEDIATE SHAFT HAS BEEN DEVELOPED TO ADDRESS THIS CONDITION. *PE UPDATED 5/22/2012. *JS
Showing 10 of 11 technical service bulletins.
NHTSA Investigations for the 2007 TOYOTA RAV4
NHTSA has opened 1 investigation into potential safety defects in the 2007 TOYOTA RAV4.
Other Model Years of the TOYOTA RAV4
- 2002 TOYOTA RAV4 — 682 complaints
- 2003 TOYOTA RAV4 — 392 complaints
- 2004 TOYOTA RAV4 — 180 complaints
- 2005 TOYOTA RAV4 — 168 complaints
- 2006 TOYOTA RAV4 — 879 complaints
- 2007 TOYOTA RAV4 (current)
- 2008 TOYOTA RAV4 — 707 complaints
- 2009 TOYOTA RAV4 — 391 complaints
- 2010 TOYOTA RAV4 — 493 complaints
- 2011 TOYOTA RAV4 — 398 complaints
- 2012 TOYOTA RAV4 — 355 complaints
Other TOYOTA Models
- TOYOTA CAMRY — 23,209 total complaints
- TOYOTA PRIUS — 15,411 total complaints
- TOYOTA COROLLA — 14,342 total complaints
- TOYOTA SIENNA — 10,769 total complaints
- TOYOTA TACOMA — 10,512 total complaints
- TOYOTA TUNDRA — 8,997 total complaints
- TOYOTA HIGHLANDER — 6,663 total complaints
- TOYOTA 4RUNNER — 6,405 total complaints