2007 TOYOTA RAV4 Wheels Problems

I BOUGHT THE CAR 3 MONTHS AGO FROM PRICE AUTO. THE TIRES WEE FINE AT THAT POINT ALTHOUGH AFTER ABOUT 30 DAYS I NOTICED THE DRIVER REAR TIIRE WAS WEARING A LOT AND THE PASSENGER REAR WAS WEARING ALSO SO I DECIDED TO BUY NEW TIRES 4 OF THEM FROM TIRE WAREHOUSE. WHEN DOING SO I ASKED FOR AN ALIGNMENT THATS WHEN I FOUND OUT THAT THERE WAS A RECALL ON MY VEHICLE AND IT WAS WITH THE ALIGNMENT. THE REAR ALIGNMENT HAS TO E SEALED SHUT AFTER INITIAL ADJUSTMENT OR IT COULD COME LOOSE AND A BAD ACCIDENT COULD HAPPEN. I IMMEDIETLY MADE GRAPPONE TOYOTA IN CONCOD NH AWARE OF THIS AND THEY SCHEDULED ME TO COME IN SO THEY COULD TAKE PICS AND SEND A REPORT TO HEADQUARTERS TO SEE IF THEY WOULD COVER THE COSTS SINCE IT WAS A RECALL. I SPOKE WITH A SCOTT AT TOYOTA....

77000 MILE LOWER CONTROL ARMS WITH BUSHINGS WENT BAD ,LOWER BALL JOINTS BAD INNER & OUTER TIE RODS BAD , SWAY BAR END LINKS BALL JOINTS BAD.ALIGNMENT & RE-BALANCED TIRES AFTER REPLACEMENT .BEGAN SWAYING IN ROAD FIGHTING STEERING ON EVERY BUMP WITH DIPPING OF FRONT END & VIBRATION BADLY OF CAR ESPECIALLY STEERING WHEEL , WORN NEW TIRES ON OUTSIDES .COMPLETE RECORDS IN TOYOTA VEHICLE REPAIR SERVICE SITE.TOTAL COST SO FAR FOR THE ABOVE IS 158.00 PLUS 44.95 PLUS 1 WEEK DOWN TIME, DUE TO ALL JOINTS BAD AND VIBRATIONS AND SWAYING AROUND HAS CAUSED THE CV SHAFTS TO GET LOOSE GOOD SHAKE AND NOT IN TO OUT SIDEWAYS DIRECTION - UP TO DOWN THEY HAVE SLIGHT PLAY AND HEAR A CLUNK BOTH WAYS (TO BE REPLACED WHEN HAVE MONEY WILL BE ANOTHER 150 TO 195 BUCKS AND ANOTHER DAY OR 2 DOWN TIME, NOT SURE OF FRONT WHEEL BEARINGS...

IN LATE SUMMER/EARLY FALL 2016 MY 2007 TOYOTA RAV4 BEGAN EXPERIENCING REAR SUSPENSION, ALIGNMENT, AND TIRE WEAR PROBLEMS ASSOCIATED WITH THE TOYOTA RECALL AT THE TIME, ALTHOUGH MY CAR WAS NOT INCLUDED IN THE RECALL. WHEN MY MECHANIC EXAMINED THE CAR, HE SAID IT MADE NO SENSE THAT TOYOTA'S SOLUTION IN THEIR SECOND SUSPENSION RECALL WAS TO EPOXY PIECES IN PLACE AND NOT ALLOW THE VEHICLE'S SUSPENSION TO ADJUST TO MOVEMENT ON THE ROAD WHILE DRIVING. I HAD TO ARGUE WITH THE DEALERSHIP WHO SOLD THE CAR TO GET THEM TO MAKE THE PROPER REPAIRS (PERFORM THE RECALL WORK ON MY CAR) AT NO CHARGE TO ME. THE DAMAGED RUINED MY RELATIVELY NEW TIRES AND I HAD TO GET ANOTHER SET. RECENTLY DURING GENERAL SERVICING, MY MECHANIC DISCOVERED THE SAME TIRE WEAR PROBLEM AND THAT THE REAR TIRES ARE SEVERELY TILTING INWARD, AND THE MOST RECENT REPAIR BY THE DEALER...

I WAS TURNING MY 2007 TOYOTA RAV4 SOUTH ONTO INTERSTATE 182 TO HEAD EAST, THE CAR SUDDEN OUT OF MY CONTROL AND WENT OFF THE ROAD AND HIT A CONCRETE BARRIER AT 5:49 PM AT 5/8/17. TWO PASSENGERS WERE HURT.

THE WHEELS WERE DESIGNED WITH A LIP THAT DOES NOT DRAIN, CAUSING THEM TO RUST OVER TIME AS WATER AND ROAD WASTE SITS IN THE LIP. I ONLY LEARNED ABOUT THE RUST, WHICH IS NOT VISIBLE, WHEN I RECENTLY PURCHASED A NEW SET OF TIRES. SURPRISINGLY, MY NEW TIRES IMMEDIATELY STARTED LOSING AIR. AFTER CHECKING THE TIRES AND REPLACING THE VALVE STEMS, MY MECHANIC USED THE SOAPY WATER TEST TO DETERMINE THAT THE WHEELS THEMSELVES ARE SO RUSTED THAT THEY ARE LETTING AIR ESCAPE. THE LIP OF ALL FOUR WHEELS ARE RUSTED TO THE POINT WHERE THE RUST IS FLAKING OFF. GIVEN THE DETERIORATION OF THE WHEELS, I AM CONCERNED FOR MY SAFETY. MY INITIAL CONTACT WITH TOYOTA RESULTED IN NO ACTION BY THEM. I AM WRITING TO THE VP OF MARKETING TO MAKE HIM AWARE OF MY CONCERNS.

ON JULY 31ST, 2015, THE TOYOTA DEALERSHIP PERFORMED A SUSPENSION RECALL WORK TO REPLACE BOTH "REAR #1 LOWER SUSPENSION ARMS". THAT WORK INCLUDED A 4 WHEEL ALIGNMENT AND A PERMANENT SEALANT THAT PREVENTED FUTURE REAR ALIGNMENT OF THE REAR WHEELS. ON AUGUST 3RD, 2016, (APPROX. 13K MILES LATER) THE VEHICLE WAS TAKEN TO A LES SCHWAB TIRE CENTER TO HAVE THE BRAKES INSPECTED. DURING THE BRAKE INSPECTION, THE TECHNICIAN NOTED SEVERE ABNORMAL TIRE TREAD WEAR ON THE INSIDE SHOULDERS OF BOTH REAR TIRES. THE INSIDE SHOULDER OF THE RIGHT REAR TIRE WAS SO SEVERE THAT IT WAS SHOWING STEEL BELTS AND WAS NEAR FAILURE (IMMANENT TIRE BLOWOUT CONDITION). LES SCHWAB NOTED THAT THE FRONT TIRES HAD NORMAL EVEN WEAR. NOTE: THE 4 WHEEL ALIGNMENT PERFORMED ON 7/31/2015 WAS THE ONLY ALIGNMENT PERFORMED PRIOR TO 8/3/2016, THE ALIGNMENT CHECK ON 8/3/2016 INDICATED THE FRONT WHEEL ALIGNMENT WAS VERY CLOSE AND WITHIN...

THE METAL RIMS WHICH HOLD THE TIRES GET RUSTED DUE TO DESIGN. THIS IS A GREAT SAFETY CONCERN. THE RIMS ARE DESIGN SUCH WAY THAT THEY HOLD WATER, RAINWATER, AND SALTY ICE/SNOW INSIDE THE RIMS AND NEVER DRAIN OUT; WHICH CAUSES THE WHEELS TO RUST, AND COULD CAUSE A SAFETY CONCERN. THE RIMS/WHEELS SHOULD HAVE BEEN RUST PROOF IN FIRST PLACE. THESE RIMS/WHEELS ARE NOT, AND ON THE CONTRARY HOLD WATER INSIDE ALONG THE OUTER EDGE.

DRIVING 50 MPG AROUND CURVE IN HEAVY TRAFFIC STEERING LOCKED UP HARDLY ABLE TO PULL.OFF SIDE OF ROAD. HAPPENED AGAIN TODAY 2 TIMES AND HAPPENED AT LEAST 5 TIMES BEFORE IN THE PAST 3 MONTHS.STEERING FROZE HAD TO GET OF TO THE SIDE AND RESTART THEN IT WAS ABLE TO STEER BUT BATTERY.LIGHT FLICKERS. THREE OTHER LIGHTS ON THE LEFT OF THE DASHBOARD STAYED ON AFTER RESTARTING THE VEHICLE. WENT TO PEP-BOYS AND I WAS ASKED TO REPLACE THE BATTERY DUE TO LOW VOLTAGE. BATTERY WAS REPLACED AND ONE DAY LATER SAME THING HAPPENED AGAIN.

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 38 MPH, THE REAR BACK WHEELS LOCKED UP AND THE VEHICLE SWERVED FROM SIDE TO SIDE. ALSO, THE CONTACT STATED THAT THE DOWNWARD HILL ASSIST WARNING LIGHT ILLUMINATED WHEN THE WHEELS LOCKED UP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 13V383000 (SUSPENSION). HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE MANUFACTURER HAD BEEN NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

RIGHT REAR LOWER SUSPENSION ARM SNAPPED CAUSING THE RIGHT REAR TIRE TO TURN TO THE SIDE, CAUSING US TO LOSE CONTROL OF THE VEHICLE. I WAS ABLE TO GAIN CONTROL AND STOP THE CAR DUE TO THE LOW RATE OF SPEED. WE HAD A RECALL FOR THIS PROBLEM. TOYOTA INSTALLED A TEMPORARY FIX, HOWEVER WHEN WE RECEIVED AN UPDATED RECALL, WE CONTINUALLY CALLED TO HAVE THE PERMANENT FIX ONLY TO BE TOLD THAT THE PART WAS NOT AVAILABLE WE ASKED THEM TO CALL US WHEN THE PART ARRIVED AND THEY WOULD NOT AGREE TO THIS. WE HAVE CALLED THEM CONTINUOUSLY BUT THEY NEVER HAD THE PART. CALLED TOYOTA TODAY AND THEY CANNOT HELP ME TODAY. THEY WILL NOT APPROVE TOWING, RENTAL CAR, OR REPAIR AS OF THIS DATE. I CANNOT GET TO WORK, I AM HANDICAPPED AND I DO NOT HAVE ACCESS TO PUBLIC TRANSPORTATION. THE POLICE DID COME TO...

2007 TOYOTA RAV4 REAR SPEED SENSORS CAN ABRUPTLY FAIL DURING POOR CLIMATE, CAUSING FAILURE TO THE VEHICLE STABILITY CONTROL, ABS, AND TRACTION CONTROL SYSTEMS. TOYOTA HAS REFUSED TO ACKNOWLEDGE THAT FAILURE OF THIS PART IS COMMON, WHICH IS ESPECIALLY DANGEROUS WHEN DRIVING CONDITIONS ARE POOR. *TR

WE WERE DRIVING 55MPH ON HIGHWAY 168 IN NORTH CAROLINA NORTH TOWARDS VIRGINIA COMING HOME FROM VACATION IN THE OUTER BANKS, NC. WE WERE DRIVING IN LEFT LANE PASSING A JEEP, PULLING A SMALL TRAILER, IN THE RIGHT LANE WHEN WE HEARD A POP AND THE CAR STARTED TO SWERVE TO THE RIGHT. OUR CAR STRUCK THE JEEP ON THE DRIVER'S SIDE TURNING THE JEEP SO IT ENDED UP IN FRONT OF US. BOTH VEHICLES FINALLY CAME TO A STOP AFTER I APPLIED THE BRAKES. AFTER CHECKING ON THE PASSENGERS (MY WIFE, TWO CHILDREN AND OUR DOG) IN OUR CAR AND JEEP PASSENGERS, I WENT TO MOVE THE CAR AT THE REQUEST OF THE POLICE AND THE DRIVER'S SIDE REAR TIRE COLLAPSED IN AT THE TOP AT ABOUT A 45 DEGREE ANGLE. THANKFULLY NOBODY WAS HURT. AFTER HAVING THE CAR PUT ONTO THE FLAT BED TOW TRUCK BY AAA, THE...

FAILURE # 1 ONE OF THE STEEL RIMS ON MY RAV 4 DEVELOPED A CRACK CAUSING A SUDDEN LOSS OF PRESSURE. I HAD THE RIM REPLACED WITH A NEW ONE. SINCE THEN I HAVE HAD TO REPLACE 2 ADDITIONAL RIMS WITH THE SAME (BROKEN WELD) SYMPTOMS, ONE WITH A BREAK OVER 21" LONG. TOYOTA HAS FAILED TO ADDRESS THIS ISSUE OF UNINTENDED CONSEQUENCES. FAILURE # 2 THE AIR BAG SENSING LIGHT CAME ON IN MY RAV 4 SO I HAD IT CHECKED OUT AT MY LOCAL DEALER. I WAS TOLD NOT TO WORRY ABOUT IT. I'M AN EMT AND I HAVE A TENDENCY TO WORRY ABOUT "LIFE SAFETY" ISSUES. I TOOK IT TO ANOTHER DEALER AND WAS TOLD THAT THERE MIGHT BE UNINTENDED CONSEQUENCES AND THAT I SHOULD HAVE IT FIXED. IT TURNED OUT THE "SPIRAL CABLE" IN THE STEERING COLUMN WAS FAULTY AND NEEDED TO BE REPLACED. IT'S IMPORTANT...

STEEL WHEELS ARE BADLY CORRODED TO THE EXTENT THAT I AM CONCERNED ABOUT THEIR INTEGRITY. RUSTED STEEL IS FLAKING OFF IN STRIPS. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT WAS TRAVELING 60 MPH WHEN THE BRAKES WERE DEPRESSED AFTER A GUN SHOT LIKE NOISE EMITTED FROM THE REAR OF THE VEHICLE. ANOTHER VEHICLE CRASHED INTO THE CONTACT'S VEHICLE AND SOMETHING FROM THE PASSENGER'S SIDE OF THE VEHICLE DETACHED ALONG WITH PART OF THE PASSENGER SIDE REAR WHEEL. THE VEHICLE WAS NOT DESTROYED. THE CRASH CAUSED NO INJURIES, BUT THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 49,600 AND THE CURRENT MILEAGE WAS UNKNOWN.

DRIVER SIDE STEEL WHEEL PARTIALLY SEPARATED FROM HUB DUE TO SHEARING OF 4 OF 5 WHEEL LUGS. TESTED AN ADDITIONAL WHEEL LUG/NUT ON PASSENGER REAR WHEEL WITH TORQUE WRENCH SET AT 85 LB-FT AND IT SHEARED OFF. JUST PRIOR TO WHEEL SEPARATION, LOUD "POPS" WERE HEARD WHICH CAUSED VEHICLE DRIVER TO REDUCE SPEED AND SHOULDER THE VEHICLE. NO BODY DAMAGE, JUST SHAKEN DRIVER. ALL WHEEL NUTS WERE PROPERLY TORQUED TO FACTORY SPECIFICATION OF 85 LB-FT LESS THAN 3 MONTHS AGO. *TR *JS

MY 2007 TOYOTA RAV4 HAD A REAR RIGHT WHEEL TIE ROD BREAK WHILE I WAS DRIVING WITH MY WIFE AND OUR ONE YEAR OLD CHILD IN THE VEHICLE. WE WERE ON OUR WAY TO SEE MY WIFE'S DOCTOR FOR HER MEDICAL CONDITION AT THE TIME. THANKFULLY WE HAD JUST MADE A TURN ON TO THE ON-RAMP OF THE GARDEN STATE PARKWAY AND WERE MOVING AT A RELATIVELY SLOW SPEED. I CAN'T IMAGINE WHAT WOULD HAVE HAPPENED IF WE WERE TRAVELING AT HIGHWAY SPEED WHEN THE TIE ROD BROKE, I MIGHT HAVE LOST CONTROL OF THE VEHICLE AND HAD A TERRIBLE CRASH WITH SERIOUS INJURY (OR WORSE) TO OUR FAMILY AND POSSIBLY OTHER DRIVERS ON THE ROAD. AFTER SEARCHING ON THE INTERNET ABOUT TOYOTA RAV4 TIE ROD INCIDENTS, IT SEEMS THAT IT HAS HAPPENED TO OTHER RAV4 DRIVERS MANY TIMES ON ALL DIFFERENT MODEL YEARS OF THE VEHICLE. JUST LIKE US...

ALLOY RIMS ARE RUSTED ON 2007 TOYOTA RAV 4. *TR

DRIVER OWNS A 2007 TOYOTA RAV 4. WHILE DRIVING APPROXIMATELY 35 MPH, CAR BEGAN TO SKID AND INTERMITTENT WARNING BEEP CAME ON. DRIVER PULLED OVER, AND UPON EXITING AND INSPECTING THE VEHICLE, DRIVER SAW THAT THE REAR DRIVERS SIDE TIRE WAS SLANTED INWARD APPROXIMATELY 45 DEGREES. CAR WAS TOWED TO DEALERSHIP AND DRIVER WAS INFORMED THAT THE TIE ROD HAD RUSTED THROUGH AND BROKEN. ALL OTHER TIE RODS APPEARED NORMAL. TIE ROD WAS REPLACED BY DEALERSHIP. FAILURE OCCURRED AT 43,500 MILEAGE. *TR

MY 2007 TOYOTA RAV4 SPORT RIMS OEM ARE RUSTING A AT FAST PACE. SOME BIG CHUNKS ARE FALLING OFF. I AM AFRAID THAT THE WHEEL WILL FALL OFF WHILE DRIVING. I WROTE TO TOYOTA CORP THEY HAVE NOT RESPONDED. *TR

2007 RAV4 RIMS RUSTING STARTING THE WINTER OF 2008. *TR

NEW AIR MONITOR VALVE STEMS ON TOYOTA VEHICLES ARE MADE OF ALUMINUM ALLOY MATERIAL, NOT THE STANDARD BRASS METAL USED ON MOST VALVE STEMS. THE USE OF COMMON METAL CAPS TO COVER THE VALVE STEMS IN CONJUNCTION WITH COMMON HIGHWAY DE-ICER CHEMICALS CAN RESULT IN ACCELERATED CORROSION AND SEIZING OF THE VALVE CAPS TO THE STEM. THE RESULT IS THAT YOU CANNOT REMOVE THE VALVE CAP TO PUT AIR IN THE TIRE AND IF TOO MUCH FORCE IS APPLIED TO TRY AND REMOVE THE CAP, THE STEM WILL FAIL AND LET THE AIR OUT. THIS COULD RESULT IN POTENTIAL STRANDED VEHICLE, ETC. LONG TERM EFFECTS OF THE HIGHWAY CHEMICALS ON THE ALUMINUM VALVE STEMS IS UNKNOWN, COULD BE PROBLEMATIC. PLASTIC CAPS ARE ADVISED TO MINIMIZE THE RISK. *TR