2016 TOYOTA HIGHLANDER Engine Problems

The water pump on my 2016 Toyota Highlander XLE disintegrated while I was driving in heavy traffic. The pulley came loose from the water pump shaft. I have the water pump. Our safety was at risk because this happen in heavy traffic and it could have effected my control of the vehicle if it had came off completely. The pulley was wedge between the wheel well and fame. I sent a claim to Toyota and it was rejected due to the vehicle be out of warranty. I'm saying this is a manufacturing defect. No warning before it happen.

2016 toyota highlander le model v-6 cylinder. The FUEL PUMP runs after engine has been turned off for several hours, even up to as many as 8 hours. This situation can be heard in a closed in garage, in the completely quiet of night time, and at multiple times during the same time period. It happens intermittently with various levels of gas in the tank. The length of time FUEL PUMP can run can be as little as 10 minutes to over 60 minutes.

The contact owns a 2016 Toyota Highlander. The contact stated that while driving at various speeds, the vehicle would shut-off without warning. The contact would be able to restart the vehicle a few minutes after the failure. The contact had taken the vehicle to an unknown dealer. The dealer attempted to charge him a diagnostic fee and the contact refused. The manufacturer had been notified of the failure and they sided with the dealer and insisted that he pay a diagnostic fee to have the vehicle serviced. The vehicle was not repaired. The failure mileage was unknown.

ENGINE IS MAKING A AUDIBLE KNOCKING SOUND THAT INCREASES WITH ENGINE RPM. THE SOUND IS EMITTING FROM THE BOTTOM RIGHT HAND SIDE OF THE ENGINE (UNDERNEATH/TO THE RIGHT OF THE OIL PAN ON THE SIDE NEAREST TO THE PULLEYS AND SERPENTINE BELT). I HAVE REPORTED THIS ISSUE TO RELIABLE TOYOTA IN SPRINGFIELD MISSOURI. DEALER CLAIMS THE SOUND IS NORMAL EVEN AFTER VIDEO EVIDENCE WAS PROVIDED. HOWEVER, I HAVE NOT HEARD A KNOCKING SOUND COMING FROM OTHER HIGHLANDERS. A NON DEALER MECHANIC WAS CONSULTED AND HE HEARD TO NOISE AND ADVISED MY TO RETURN TO THE DEALER SO THEY MAY SOLVE THE ISSUE UNDER WARRANTY,

CRANKSHAFT POSITION SENSOR INOPERATIVE DURING NORMAL USE

WHISTLING/SQUEAKING NOISE FROM ENGINE WHEN TURNED OFF AFTER DRIVING. TOOK A VIDEO AND SHOWED DEALER WHO THOUGHT IT WAS UNUSUAL BUT NO DIAGNOSIS ON MULTIPLE VISITS.

WHENEVER THE WEATHER IS COLDER LIKE 35 DEGREES OR LOWER I AM HAVING ISSUES STARTING THE VEHICLE. THE DEALER ALREADY CHANGED THE BATTERY BUT IT DID NOT HELP. I HAD THE VEHICLE BY THE DEALER FOR 10 DAYS BUT THEY COULDN'T FIGURE IT OUT. IN THIS TIME I HAD TO PAY OUT OF POCKET FOR RENTAL AND OTHER EXPENSES. YESTERDAY IT TOOK ME 45 MINUTES UNTIL I WAS ABLE TO START THE VEHICLE. I SPOKE TO TOYOTA AND THEY ARE NOT VERY HELPFUL.

OCCASIONALLY, AT A STOP SIGN/INTERSECTION OR ENTERING A HIGHWAY IF I HAVE COME TO A FULL STOP BEFORE PROCEEDING THE CAR WILL STALL. I PRESSED ON THE ACCELERATOR AND NOTHING HAPPENS. MY WIFE AND I HAVE FOUND OURSELVES IN THIS PREDICAMENT SEVERAL TIMES NOW AND IT IS ONLY GETTING WORSE. THIS SCENARIO IS VERY DANGEROUS FOR SEVERAL REASONS, BUT THE MOST IMPORTANT ONE IS THAT MY FAMILY HAS BEEN INSIDE THE CAR WHEN THIS HAS HAPPENED. WE HAVE HAD SEVERAL SCARES NOW, BECAUSE THE CAR STALLED ON US AS WE WERE ENTERING THE HIGHWAY. I HAVE SPOKEN TO THE DEALER ABOUT THIS OVER THE PHONE AND BOTH TIMES THAT THE CAR HAS BEEN SERVICED. AFTER THEY TEST DROVE THE VEHICLE, I WAS TOLD THAT THIS WAS NORMAL BEHAVIOR DUE TO A DELAY BETWEEN THE COMPUTER AND THE ACCELERATOR THROTTLE. ADDITIONALLY, I WAS ALSO TOLD THAT TOYOTA IS AWARE OF THIS,...

MY CAR ENGINE STARTED ON ITS OWN AFTER BEING TURNED OFF. I WENT SHOPPING AT WALMART AND PARKED MY 2016 TOYOTA HIGHLANDER XLE IN THE PARKING LOT. I PUT THE CAR IN PARK AND PUSHED THE ENGINE START/STOP BUTTON TO TURN OFF THE CAR. MY FAMILY AND I EXITED THE CAR AND I USED THE KEYLESS ENTRY PAD TO LOCK THE DOORS. WE SHOPPED FOR APPROXIMATELY 45 MIN. WHEN WE RETURNED TO THE CAR, I USED THE KEYLESS ENTRY PAD TO UNLOCK THE DOORS SO I COULD PUT OUR PURCHASES IN THE TRUNK. AS I GOT CLOSE TO THE VEHICLE I HEARD AN ENGINE RUNNING, BUT THOUGHT IT WAS THE CAR NEXT TO US. I BENT DOWN AND LISTENED UNDER THE FRONT END OF MY HIGHLANDER AND TO MY SURPRISE, I REALIZED MY CAR ENGINE WAS RUNNING. WHEN I OPENED THE DRIVER SIDE DOOR AND LOOKED AT THE DASHBOARD, I...