2023 TOYOTA COROLLA CROSS Engine Problems

Colant bypass valve

I purchased a brand-new 2023 Toyota Corolla Cross LE on [XXX], in St. Croix, Virgin Islands, selling price, $31, 500.00 Early July 2025, I started the vehicle, and unexpectedly, multiple lights emerged on the dashboard screen per below, Exhibit 1 - Check Engine - Visit your dealer Exhibit 2 -Drive Start Control Malfunction - Visit your dealer Exhibit 3 - Parking Brake Malfunction Exhibit 4 - Secondary Collision - Brake System Malfunction Exhibit 5- Parking System Malfunction The vehicle was taken to Island Toyota on July 5th. The codes were cleared by removing the battery terminal. Two days later, the warning lights reappeared. After the technician performed diagnostic testing, I received a phone call to pick up the vehicle. The total cost of the ordered parts exceeds $2,000, which includes a computer. This vehicle is under warranty, particular vehicle IS NOT TWO YEARS OLD. This vehicle is a LEMON. I...

ATTACHMENTS OF PICTURES FOR COMPLAINT NUMBER 11688637. [XXX] [XXX] . 2023 Toyota Corolla Cross The scanned pictures shows all the warning lights displayed on my vehicle. A NEW COMPUTER WAS INSTALLED YET IT CONTINUES TO REFLECT THESE LIGHTS. A NEW SWITCH ASSY, HOSE VENTILATOR, VALVE ASY, OI AND COMPUTER ASSEMBLY. CURRENTLY THE DEALER ORDERED INJECTOR SET, ALONG WITH SWITCH, PUSH. HONESTLY, THE PROBLEM CANNOT BE FOUND, PARTS WILL BE ORDERED CONTINUOSLY. THE DANGER WAS WHEN THE ENTIRE DASH BOARD WENT BLANK, WHILE ON THE HIGHWAY, THE VEHICLE LOST POWER AND THE TRANSMISSION STALLED TO SHIFT GEAR. I PULLED OVER ON THE SIDE OF THE ROAD AND CALLED THE CEO OF TOYOTA IN PUERTO RICO. I EXPLAINED TO THEM MY LIFE IS AT RISK. THEY DECIDED TO GIVE ME A RENTAL UNTIL THE NEW PARTS COME IN. PLEASE INVESTIGATE THIS MATTER. MY VEHICLE HAS A SERIOUS PROBLEM. IT HAS BEEN IN...

On [XXX], and again on [XXX], vehicle began beeping while driving on the freeway and flashing the following warning messages: 1) 12-Volt Battery Charging - System Malfunction - Stop in a Safe Place - See Owner's Manual 2) AWD System Malfunction - 2WD Mode Engaged - Visit your Dealer 3) Voltage Abnormality - Steering Power Low - Visit Your Dealer Vehicle shut down and lost power steering while driving on the freeway. My safety was put at risk as I could not easily pull my car over to a safe place due to the car losing power, not turning back on, and power steering turning off. This may have resulted in severe injury or death if I had not been able to eventually pull over. Additionally, the safety of others was put at risk as we were travelling at freeway-level speed, which may have resulted in other vehicles being unable...

If raining you stop in red light the engine is shut off need to wait about 10 minutes and start again why they no recall this problem that dangerous

I was at a red light with my windshield wipers on. I then heard several warning beeps with messages stating "steering power low", battery low, and then the steering locked. I tried to turn the wheel after the last message came up but the steering wheel was locked. I couldn’t accelerate. I had to park the car and turn it off and on again. This has happened twice now and Toyota says it is “fine”.

As I stopped at the stoplight the vehicle enter the automatic shut off pause as it should when the brake is firmly pressed. when I released the brake the engine did not restart. instead the following message showed on the vehicle information center in the dash: ENGINE STOPPED, STEERING POWER LOW. then it prompted me to restart the car. I have to put the car in PARK, depress the brake and press my start button to restart the car. This happen in an intersection! This is the third time and it seems it happens in wet conditions. to temporarily remedy the problem I have deactivated the gas saving automatic engine stop. The manufacturer and dealer have been contacted.

After the first issues with start stop car would just shut off in the middle of driving, came a new issues In august 2024 When all these lights came on car had been park over night and not driven so it was a fresh start . Warning lights included parking brake system, Drive start control, check engine, vehicle stability control and secondary collision brake system. Corolla cross would not back nor move this time . Took to dealership with no findings or solutions. Again September 2024 same warning lights and car had just been driven 8 miles and was in park. These warning lights are very much a safety concern. Have taken to dealership with no resolution or findings

While driving in the rain with my windshield wipers on, my car suddenly stopped and the message on the car said “engine stopping, steering slowly” and after that it said “press on brakes slowly, engine stopping , steering slowly” and then it started to cut off. I forcibly put it in park and then the engine came back on and the car started to drive fine. An hour later, I turned my car back on and started driving and my screen went black. I turned the car off and turned it back on and it started working again. I think it could be an electrical issue but I don’t know for sure. I bought this car used with a little over 30k miles on it.

Car would not restart after auto stop/start engaged and wipers on. I had to put car in park, turn off the engine then restart. Third time this has happened.

Car just shuts off while driving or at stop lights or stop signs. Car won’t start , takes 10-20 minutes to cut back on after putting car in park or stopping at stop sign or light.

My 2023 Corolla cross XLE, at least 5 times since ownership, has experienced a complete engine shut off at stop lights when driving in the rain with windshield wipers on. A message appears on the driver display saying that the engine shut off and the brake needs to be pressed hard and start button must be pushed to start the engine again. It seems to only occur in association with the engine stop/start capability that is engaged when the vehicle comes to a complete stop and the break pedal is pushed extra to engage the engine. This may sound like the normal start/stop function to save fuel, but it is not. Normally, the capability turns the engine back on upon release of the brake pedal. This issue is very different, in that the engine shut down is not normal, and requires in real time traffic, returning the vehicle to park...

The contact owns a 2023 Toyota Corolla Cross. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The contact stated that several unknown warning lights were illuminated. The failure became persistent. The vehicle was taken to the dealer; however, the failure had not been diagnosed. The contact stated that the vehicle had been taken to the dealer twice due to the failure. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 100.

When I was driving, I stopped at a light, and the engine turned off. Lights, alarms went on and my car would not start. The dashboard read that there was engine failure. The car didn’t respond to pressing the brake, or shifting gears. I had to turn the car off and restart it for it to start working again. Thankfully, I was not on a hill where the car would’ve started rolling forwards or backwards. This had previously happened at another stop light. When we brought the vehicle in for a recall related to the steering column, they mentioned our car is not affected. But there seems to be an issue, and I’m concerned that it will endanger me and my passengers.

Vehicle stalled while driving with both front and rear wind shield wipers on. It was raining when this occurred. We were in heavy traffic and vehicle would not move, putting us at risk. The dealer states that they are unaware of this failure occurring in the 2023 corolla cross model. The failure happened suddenly without any type of warning.

The car shuts off completely when I brake at a stop light. When I lifted off my foot from the brake pedal it didn't restart. It had completely shut off and I had to put the car in park and restart in order to drive. This is dangerous as when the light turned green I could not move and cars behind me are already in drive. This incident has happened 5 times and I took the car into Toyota and they said they could not diagnose the code.

When driving to work it’s the 4 times the 2023 Toyota Corolla Cross turns on the engine light and starts beeping with the power steering low message and shuts down and I am unable to continue driving I have taken it 4 times to Toyota dealership with them continue to say no issue is found. For me to get the vehicle working again I have to completely turn it off lock it and then unlock it and turn it back on. This is unacceptable and a big hazard issue because it does this in the middle of traffic without any indication.

Stopped at a stop light and the engine automatically shut off as expected, however warnings appeared on the dashboard indicating that the engine stopped and power steering was low. I had to turn on my hazards at a very busy intersection as the light turned green so I could completely turn off the vehicle and restart it. This happened twice in the same trip two days ago and has happened once before a few months ago. Very dangerous.

This has happened several times since I have bought the car in October 2023. Every time I am driving in the rain, stopped at a red light, with the windshield wipers engaged my car completely shuts off (no it is not the auto-start/stop feature). I receive the message stating “engine stopped, press brake firmly to restart. Power steering low.” Everytime I have been at a red light and in order to get the car to start again, I have to put my car in park, then turn it back on. This is a very dangerous issue as I worry if it will happen while I am driving with wind shield wipers engaged. So far it has happened at a red light everytime. I have already taken it into the dealer and they thought they solved the problem with a software update, but it just happened again, three times today (1/22/24).

Rattling noise while climbing uphill and the cross is loosing engine power.

malfunctions of electronic control of engine, AWD system, drive-start control system codes displayed on dash all of a sudden, My vehicle is new bought it Feb 2023, Acceleration doesn't engage Change of gears is rough, Got scared on the slow road bought the vehicle back to parking lot now getting it towed to the dealer.

It was a snow/ rain day I had my wipers on and was stopped at a traffic light when my engine stopped and I got a message on my dashboard “ engine stopped power steering low”. This vehicle is new with less than 5000 miles. I had to turn off the engine and restart the car in the middle of traffic.

In November, the engine stalled at a light when it was raining and the wipers were on. Warning noises were activated and the console read "steering Power Low." The car had to be pushed out of the intersection by other drivers. After a half hour the car was able to be restarted . The Car taken to dealership and they ran diagnostics on it and declared that there was nothing wrong with the vehicle. Yet on December 27th, it happened again. This time my daughter was driving the vehicle. It was raining, the lights and wipers were on and we stopped at a light. The engine shut off and would not restart. She pressed the brake multiple times and put the car in park. After about 5 minutes of sheer terror, she was able to restart the car.

Driving in Bumper-to-Bumper traffice on interstate 10. It was raining and the wipers were on. The problem occurred on December 20th during frequent starts and stops to maintain traffic flow with other vehicles. During one of the stops, the engine turned off as it normally does at a traffic light or when stuck in traffic. Upon lifting my foot off the brake, the car emiited loud sounds and various lights came on the dashboard. Cars behind me started honking their horns and other cars began acclerating passed me on the adjacent lanes. I was very upset and frightened. I tried several times to try and restart the car. I finally was able to get it started and drove directly to the dealer- Toyota of the Desert in Cathedral City. The Service writer said they could not find anything wrong with the car and would not give me a loaner. I...

I bought my car yesterday. Was driving tonight when it was raining with my wipers on. I stopped at a stoplight and the engine stopped, the check engine light came on, a loud and long beep sounded, and messages came up on the screen saying steering power low, press brake firmly to restart. I tried multiple times to press the brake for restarting but it didn't work. I had to put on my flashers for cars to go around me because I couldn't get the car to go. I finally put it in park and had to turn it completely off and on I believe twice before I finally got it started and could drive home.

Dear NHTSA Representative: I bought a Toyota Cross LE 2023 in April of 2023. During the first few weeks of owning and using the vehicle, seat belt alarms got activated even though all passengers were wearing their respective seat belts. Also, open door alarms got activated randomly while all of them were properly closed. On the 27 of July 2023 at a stop light the vehicle turned off in accordance with the Auto Stop Programming feature, however once the brake pedal was released, the engine failed to start while faults appeared on the instrument cluster display. When the vehicle was taken to the Toyota dealer, the manufacturer representative did not recognize the situation as a technical problem. They just advised to turn off the Auto Stop Feature as a "remedy" on August 3, 2023. Service job orders were not given when repair was requested. On November 13, 2023 the vehicle...

Engine stopped while the car was stopped at a red light, later at a stip sign and later while at a stop in traffic. A message popped up on the screen that indicated “Engine Stopped…Steering Power Low”. Had to put the car in park and restart the vehicle. 5 times it happened in one rainy afternoon while using the intermittent wipers and also while not using the wipers at all.

Idling in drive foot on break at stop light, 12197 miles and UTD on service and the “engine stopped” and indicated “power steering low”. Had the put in park and restart vehicle.

I bought this car less than a month ago! I pulled out of a parking lot and was waiting to turn left when my car suddenly shut off with a loud alarm sound. The check engine light came on as well as a steering pressure light. The dashboard read to press the brake firmly into the ground to start the car..it did not start. I was able to put the car in park and after 3 attempts get the car to start. I was in rush hour traffic with many cars around and behind me honking their horns and yelling all while I was stuck. There was no warning it simply just shut off in the middle of traffic. I am now waiting for it to be inspected by the service department where I purchased it from.

I was stopped at a light and the engine breaked. It did not reengage when I pressed the break harder or let off the break. I had to put the car in park and press the ignition button. Engine started at that time. it was raining and I did have my wipers on.

Some of the times when the function Autostart/Stop is on and the windshield wipers are active the car shuts down and throws engine lights on the car and the car won’t start after releasing the brakes, the car panics , and only will start again when moving from D to Park again and pressing the button .

Sunday 10/22/23 while idling and brakes engaged at red light. Engine failure again at 11,619 miles. Had to put in park and restart vehicle and put in drive. This is the 4th time in 11 months. It idles weird as well.

When it is raining, wipers are on, and I stop at the traffic light, start/stop function turns on when I press the pedal all the way down, but when I release it to drive again, the engine won't start back and the message appears on screen "engine stopped, steering power low", which is scary because the cars at the back starts honking, then I turn the car into parking, switch the car off and turn it back on and then I can drive. Apparently, it is a know problem with this model but Toyota refuse the accept that they know about it and they do not have the solution. It has happened to me 5 times in 3 months, since I bought the car.

My vehicle was stopped at a stoplight with the start stop engine feature engaged. I had my windshield wipers on, and it was raining heavily, when suddenly that car turned completely off and started emitting a loud beep. There was a power steering error on my dash and the wheel locked itself completely, the car would not restart at all. There was a message on my dash to firmly press the brake, and the car would restart, but pressing the brake did nothing. I was stuck in the middle of an intersection in a vehicle that is less than two months old in the middle of traffic, and live in a city, where it rains continuously for several months out of the year. Toyota is aware of this issue, but there aren't any fixes available for a vehicle that will turn itself off when using the windshield wipers while it's...

Engine stop and start while stopped in traffic 2 times on Saturday and vehicle lane assist seems to be off a bit- pulling to the right a bit. Also idles weird. Charges engine weird times when parked or idling.

I was driving during the rain with the wipers on (intermittent) and the auto start/stop feature engaged. I got to a red light and stopped. I lifted my foot off the brake to press the accelerator and then the car didn't restart. The instrument panel then said low steering power and another message about the brake. A loud tone was continuously emitted. I pressed the brake and put the car in park and was able to restart it. I was scared because traffic behind me was honking for me to proceed and I was not able to at first.

I was at a red light on a busy highway. All of a sudden my car stopped working: I got a message on the dashboard along the lines of "engine power low" and "press brake hard to restart". But even if I pressed the brake hard, nothing would happen, and my car wouldn't move forward. In fact, because I was on a slight uphill, releasing the brake pedal made my car go backwards. The steering wheel also felt locked. I was panicked because the light turned green and a lot of cars were waiting behind me. I put my hazard lights on, and kept trying to press the brake hard to no avail. Finally after about a minute, I put my car in park, and turned off my car. I then restarted it, and it suddenly worked. This was a super scary experience, and very disappointing since my car is...

I ordered the car in July and it arrived on 8/3/23. On 8/31/23, I got in the car while in my garage, attempted to start it as usual, and a loud sound occurred when I shifted from park to reverse. Lights began flashing. I turned off the car, got out and walked around to make sure I hadn’t hit anything. After verifying clearance all around, I checked my phone. The Toyota Corolla Cross XLE had 4 codes listed: malfunctions of: electronic control of engine, AWD system, drive-start control system, and the advanced ultrasonic detecting and ranging system. I restarted the car and backed out of my garage. The check engine light was still on. I backed out and tried to drive down my neighborhood street. When I steeped in the accelerator, the engine would race but not engage. Acceleration was problematic so I returned home. Later the same day, I...

The car has suddenly turn off while driving, all lights come one and does take a while to be able.to turn back on. It had happened 4 times already. Twice today while my daughter was driving on a busy street, nearly missing getting it by someone else. And the second time in the middle of an intersection today was a rainy day, and she had the automatic on/off button off. Twice before, on 2 separate days one was sunny, the day was sprinkling.

I was driving in the pouring rain with intermittent wipers on in bumper to bumper traffic and stopped at a red light. Car shut off, with traffic behind me and I had to put hazard lights on. Dashboard messages appeared - Low steering power light and then said to press brake and auto start button. Luckily it restarted. Second time this has happened as I had 500 miles and thought I didn't know how to operate the car since it was new. This time 2,400 miles and there was no doubt the fear I experienced was an electrical issue. Drove to Northshore Toyota, who advised no codes were stored and couldn't duplicate the issue. I contacted Toyota Brand Engagement with case # [XXX] and [XXX]. Northshore Toyota contacted field technician and said to reprogram the main computer. They will do this today. If it doesn't fix the issue, after 3...

The contact owns a 2023 Toyota Corolla Cross. The contact stated while the vehicle was idling at a traffic light, the vehicle stalled. The messages "Engine Shut Off" and "Steering Power Low" were displayed, and the check engine warning light and other unknown warning lights were illuminated. The contact stated that she turned off and restarted the vehicle, and the messages and warning lights were turned off. The dealer was notified of the failure and informed the contact that the failure needed to be duplicated to diagnose the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 4,600.

I was in New York taking my boyfriend to work and was at a red light and out of nowhere the car started to beep and said the power steering was low and to press the brake to restart, nothing happened when I pressed the brake and then I received a message saying the engine turned off, the traffic light turned green and I had to put my car in neutral to park it and turn it off. I looked up what it could be for my car model and apparently A LOT of people are having this issue when the wipers are on and auto on/off is on as well which was my scenario this morning. This is a huge issue and needs to be addressed immediately by Toyota!!!

I was driving on the highway in traffic with the stop/start function active. It was raining and windshield wipers were on. Engine stalled in traffic and I couldn't turn the car back on, pressed the brake and it wouldn't restart. I put it in park and it started back up. The dash had a low power steering indicator and check engine light was on.

When at a red light the steering wheel froze and the stop/ start did not work. It stated to depress the brake hard but everything was frozen. It was raining and the wipers were on when this occurred. Finally started after putting it in park and restarting the car. Had many angry cars behind me. Very unsettling.

Multiple times now, my 23 Corolla cross LE has stopped in traffic. Each time, I was sitting at a red light and I heard a long beep come through my car. Then, a sign flashed onto my car dashboard that said “check engine, low power steering, press brake firmly to reactive”. I pressed firmly and nothing happened. I shifted my car into park, turned it off to wait a couple of seconds and turned it back on. Luckily I was only 1-2 miles from home so it didn’t happen again. This has happened in wet conditions each time. I have taken it to the dealership the first time it happened and they found nothing in the diagnostic run. I connected with Toyota headquarters and they at least know of my situation but have offered no assistance. I’m grateful this has happened to me when I’ve been at stop signs, but...

When stopped at a red light, the car started beeping, the check engine light turned on, "steering power low" was displayed, the brake pedal could not be pushed in, and the steering wheel was locked. After putting the car into park and pressing the engine start/stop button, the beeping stopped and the car was able to drive again. The car had a full tank of gas and it was raining outside. Not only did this happen in the middle of a busy intersection, but while the weather conditions were difficult which could potentially put safety at risk.

I have now had two separate instances where the start / stop system in my car led to the engine stalling out at a stoplight, which was very dangerous. The car displayed messages to press the brake firmly to restart engine, which did not work either time, and that power steering would be low. Both times, I had to put the car in park and complete restart the car. Please note that unlike other reports, it was not raining nor were the windshield wipers activated during either instance.

For the 3rd time, my 2023 Corolla Cross LE has completely shut off when stopped at a light. Similarities across events include: > it has been raining, so windshield wipers are on > auto-stop/start has been initiated > no warning lights appear before this happens; it just shuts off and the screen says "Steering power low" This seems to be a documented occurrence, per this forum in which the same problem is detailed by numerous contributors: https://www.corollacrossforum.com/threads/vehicle-malfunction-at-start-stop.396/ The sudden shut-down of the vehicle is safety risk because, in a frantic state of mind, one could end up holding up traffic and generating more road rage, never mind the state of mind that I'm left in after this happens - totally anxious and frazzled! After the 2nd time this happened, the car was brought to the dealership where they kept the car overnight to try and recreate the problem. They didn't...

While stopped at a stop light, the automatic on/off initiated as usual. However, twice in the past 24 hours the engine has stopped and the driver display provided a message stating “engine stopped” and prompting me to depress the brake harder to start the engine—this action did not restart the vehicle and it had to be put in parked and fully turned off and on to restart both times. The display also stated “steering power low” when the engine stopped message displayed.

My partner was driving in stop and go traffic. One of her stops the engine just shut down. She needed to restart. The most recent issue is the rear sensor. It shows it is blocked. When I checked the back bumper the round spot, where I guess the sensor is, was pushed in. I then checked the front bumper, one of those circular spots appear close to being detached. Another issue, the phone charger located in front of the gear handle never worked. I am going to the dealership today. The vehicle was purchased January 2023 and has about 2500 miles on it.