NHTSA Complaint #11676618 — 2023 TOYOTA COROLLA CROSS

On [XXX], and again on [XXX], vehicle began beeping while driving on the freeway and flashing the following warning messages: 1) 12-Volt Battery Charging - System Malfunction - Stop in a Safe Place - See Owner's Manual 2) AWD System Malfunction - 2WD Mode Engaged - Visit your Dealer 3) Voltage Abnormality - Steering Power Low - Visit Your Dealer Vehicle shut down and lost power steering while driving on the freeway. My safety was put at risk as I could not easily pull my car over to a safe place due to the car losing power, not turning back on, and power steering turning off. This may have resulted in severe injury or death if I had not been able to eventually pull over. Additionally, the safety of others was put at risk as we were travelling at freeway-level speed, which may have resulted in other vehicles being unable to stop, and consequently crash, if my car had stayed in the freeway lane. Both times I had the vehicle towed to Beaverton Toyota Dealership (Address: 4300 SW Murray Blvd, Beaverton, OR 97005 / Phone: (503) 626-7200) to be inspected and serviced. The first time I was told it was a bad battery cell, which was replaced on 07/26/25. However, the same situation happened after this replacement on 07/27/25. Currently, vehicle is at Beaverton Toyota dealership being inspected. Vehicle was purchased at Wilsonville Toyota (Address: 9155 Boeckman Rd, Wilsonville, OR 97070 / Phone: (503) 582-9040). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)