2016 SUBARU OUTBACK Unknown Or Other Problems

Steering wheel controls frequently fail to work properly on the cruise control system specially the speed control. Also the exhaust system bellow has cracked. The moonroof leaks into the cabin and floor area of the passenger side. Also leaking into the A pillar on the passenger side. I only have a picture of the engine valve cover that is leaking and had to be replaced. I have video of the exhaust leak coming from the crack in the bellow pipe. Do not have video of the cruise control speed issues as I can’t take a video while driving.

Catalytic converter is cracked. This is confirmed by an independent service center. Apparently there is a recall for this issue for 2015 and 2016 Subaru Outbacks manufactured up until September 2015. My 2016 Subaru Outback has the same issue and was manufactured in April 2016. The recall should include all 2016 Subaru Outbacks, not just those manufactured in 2015.

I reached under the steering well to the foot well because it seemed that my AC was not putting out any air. I touched something and received a burn on my hand. I reached out to the SOA but was told to take it to the dealer. Then they asked me to call back and discuss further. When I called back I was told to take it to the dealer. I'm not sure I want to take it to the dealer to be charged a diagnosis fee. It seems the "kick panel" should cover this hot part to not allow access.

Horn quit working

Known battery drain likely from DCM and also they designed the alternator not to completely charge battery causing frequent dead battery without warning and for no operator error and causing frequent need to replace car batteries over the years.There was a class action lawsuit but no recall for these issues so has not been addressed properly.

Exhaust gas smells in the driver cabin and the exhaust shield and the pipe is breaking off.

There’s an open recall on an exhaust leak for similar models and years and my car needs the same work done but it’s not covered under the recall

The 8 month old battery on my 2016 Subaru Outback just died. I understand that the warranty on the DCM was extended by a year, but the dealership said that if it turned out the DCM was not defective, I would have to pay for the test ($185) . The warranty only covers having the battery recharged or replaced. If the DCM is the cause of the battery drain, than the warranty should pay for replacing the DCM, in addition to replacing the battery. Otherwise the problem will continue to reoccur. There should be a recall on the DCM!

My 2016 Subaru Outback, manufactured 23 business days after the end date of recall WUJ-95, has the same exhaust system and now the same exhaust system failure as the cars covered under the recall. My car is available for inspection. This exhaust failure poses a risk of carbon monoxide poisioning. The problem in my car was identified by an independent mechanic who works exclusively on Subarus and has seen this failure in other clients' vehicles. He referred me to Subaru for repairs and recommended I look into why I hadn't received a recall notice. I contacted Subaru, opened a case, then didn't recieve a response in the timeframe they defined. After waiting a few days, I called back to learned my case had been closed. Their customer advocacy representative responded the next week and said my car was not recalled because it was manufactured on 11/3/2015, after the end date...

The catalytic converter on my vehicle has an air leak causing my engine light to come on and almost all features such as cruise control become disabled. There is a recall that was issued in 2020 for the exact same problem my vehicle is having and the recall covers the same year, make and model of my vehicle. I was told that my vehicle isn’t under the recall but the representative was unable to specify why. I am trying to get the part replaced as the vehicle is polluting the air and causing my vehicle to not perform as expected.

The lock on the side of the door that turns on the child lock so kids cannot open the door from the inside is stuck in the lock position and will not disengage.

Can not take the key out of ignition.

I have a vehicle built in 11/15. I had an issue with cracked pipes associated with the catalytic converter that appear to match an existing nhsta recall for vehicles built between 12/09/2013 – 9/30/2015. It appears that the previous recall was not expansive enough.

Travelling on I-95 southbound at approx. 70 mph in the right lane at least 8-10 car lengths behind another vehicle in front of me. Clear skies, 78* F, calm weather. I heard a loud, sudden noise followed by wind and what sounded like glass on my roof, thought it was fireworks or a gunshot. Pulled over to make sure my dogs are OK (all good, just spooked!) and see what happened to the car when I observed a large hole and continued cracking noise in the sunroof - glass was pushed outwards/ convex rather than concave as if an object had struck the glass from above or in front of my vehicle. Notified insurance then carefully drove home the remaining 20 or so miles, called dealership and started researching the issue. There are nearly 40 reports of spontaneous sunroof explosions on NHTSA website for Subaru Outbacks. Dealing with Subaru Corporate...

The child lock of right side is stuck its on on position we can't open the door from inside nd now the button is broken.

My Subaru Key is Stuck in Ignition. Two to three times a week the key can not be removed from the key switch . The vehicle will shut off, but the key remains.

Right rear door will not open from inside, child door lock will not shift although child lock not engaged. InCase of crash or fire cannot exit vehicle. confirmed by repair shop. No insurance inspection. No warning lights associated with this visible

I bought this vehicle used. I was the 2nd owner. I purchased it on the evening of August 18, 2023. On the morning of August 19, 2023, I drove the vehicle for about 45 miles. I reached my destination, got out of the car, and saw what looked like either smoke or dust from under my car. I worried it might be overheating. A bystander told me the car was on fire. I walked forward to see flames coming from the front passenger side below the grill, possibly in the axle. The fire grew aggressively despite attempts to extinguish it. When the fire department arrived within 5 minutes the car was fully engulfed. The damage is so severe that it may be impossible to determine the source and cause of the fire. The dealer and my mechanic performed inspections on the vehicle before I bought it and found everything to...

My key keeps getting stuck in the ignition, and forced me to have to leave the key in the car while I went in to a store, when i got back someone was in my car. I realize that this is a different type of safety issue, but it truly is a safety issue. I am having to leave my key in my car everywhere i do because it doesn't come out,, eventually it will come out randomly but not everytime I shut the car off. this should be a recall issue for Subaru's that have this problem. I have read many complaints about Subaru owners with this issue happpening to them. I am not the only one. Thank You!

Key intermittently stuck in ignition. Unable to lock car doors with key stuck in the ignition. Problem started early on occasionally and now happens nearly every other time and requires a few tries up to 10 minutes of trying to get it out. This is a known issue among my model - Service Bulletin 16-112-18R

While driving on the highway at about 60mph my 2016 Outback suddenly accelerated much faster. The only way to avoid collision with another car or cars or end up in a ditch was to drive around them. The brake did not work! After a minute or more(?) I eventually was able to stop using the brake.

Motorized power liftgate is failing (diagnosed by dealer on 7/7/23) apparently because motor is undersized or 2 motors should have instead been used/designed to deal with load. Safety issue if motor failure causes trunk not to open. Newer models have been redesigned.

I was in a parking lot at a near-complete stop. I needed to nose the car about 18 inches to move it all the way into the spot. I lightly touched the accelerator to inch the car forward, and it shot forward as if some outside force had stomped on the accelerator. The car jumped the sidewalk and slammed into the wall of the building. The car inner body bent and the car is totaled. The airbags did not inflate. The passenger in the passenger seat sustained a fractured sternum and two broken ribs from going into the seatbelt. The driver sustained a sore neck and dizziness.

THE BATTERY is completely unreliable - I have had 3 batteries since I purchased the car in 2015 - REPEATED RECURRENT DISCHARGE WITHOUT APPARENT CAUSE - SUCH AS LIGHTS LEFT ON - PARASITIC DRAIN IT SEEMS In recent research have discovered this is not a new issue and there is a class action lawsuit settlement - I did not exclude myself and somewhat now wish that I had, in order to attempt to get some buy back incentive from Subaru. Beginning in 2019 - and maybe prior though I had not recognized it as a chronic issue then - I have encountered recurrent issues of complete battery discharge after time periods ranging from 5 to 24 hours. Estimate at least 1 to 2 discharges per month requiring cable jump, and many more times when the car was very difficult to start (almost fully discharged) To minimize risk as consumer I...

Summary of Electrical system issues: 1.pertaining to battery draining and 2. eyesight randomly goes out and other dash board lights flash and later goes away. As well as, 3. Windows that can not completely close at times. Details: I purchased 2016 Subaru outback - 4 cylinder in 2019 with 64,000 miles. By 2020, the car experienced random dashboard lights indicator flashing that would resolve itself (*the flashing light) in a few days. One issue was the eye sight would randomly inactivate while driving and resolve after turning off car for a half day or a day. However it happens often. Dealer Car repair shop said it could not duplicate. Besides the dash board lights issues; the passenger front window and moonroof would not go up to completely close at random times. Rendering the windows useless to use. These issues continued on and off from purchase thru to-date. The biggest issue...

I have had two incidents where my battery has died. The first time it happened I had the keys in the ignition, the car was off, while I was talking on my phone. Weird, but I was told not to do that any more. Since than I have made sure the keys were out of the ignition when sitting in the car with the ignition off. We brought a new battery then. The second happened yesterday 10-14-22. I had gone to a business to pick up items. We loaded my car. No keys in the ignition, the car was off. The door and truck were opened for maybe 10 minutes. I get back in the car to start and it’s dead, does not even try to turn over.

I have owned this vehicle since July 2016 and in Sep/Oct 2018, Nov 2020, and Sep 2022 I have had to replace my battery. So I have owned my car for just over six years and have replaced my battery three times. My garage states it should last at least 3-5 years per battery.

Car won't start, battery dead. This happened in first year (2016) I bought the car.

The rear passenger side child lock will not disengage. The child lock is engaged when the dog is in the back seat and disengaged otherwise. The lock was engaged once and will not disengage. If adults are riding in the back seat and there is an emergency, they are limited to the driver's side to exit. If the driver's side child lock mechanism fails, they will be forced to rely on someone to open the door from the outside. I feel this is a massive safety concern and could be potentially dangerous.

Windshield is very susceptible to cracking. I had a small stone hit our windshield in spring 2020 that made a huge crack in the windshield and required replacement and re-calibration of eyesight which was quite an expense. Yesterday, I was driving and a very small stone hit the windshield and again the windshield is cracked and will need replacing. I was not behind a truck or any construction vehicle and the stone was very tiny. I have never had a replace a windshield before and now this is twice in less than two years.

Experienced intermittent starting problems, with other odd warning light behaviors, including unable to turn them off to try again. I know another 2016 Outback owner that was given a new battery at no charge. I paid $203.60 for new battery on 03/02/2022

I bought this used 2016 Subaru Outback about a year and a half ago from McCords Vancouver Dealership. I've had the battery dying problem ever since I got it. I have had to call AAA for jump starts. I took the car into my mechanic because the "change warning light" had been on when I turned off the ignition the night before, and it was still blinking the next morning when I came out to start the car. He suggested that I go to Costco to get the battery replaced because it was down to only 22% efficient. They declined for several reasons. It wasn't the battery fault, it was the car! I am 92 years old and disabled. I can't get stuck on a freeway with a dead battery. I am still looking for someone to fix it. I bought this car because I assumed that a newer car...

The child lock in the back passenger door is stuck .

2016 Subaru Outback (purchased new) with severe electrical problems in the form of (frequent) battery discharge/non-start. This has been a reoccurring issue since early 2017 and is still a problem, even after replacement of the previous battery. I've had the replacement battery tested on several occasions after recharging and the result has always been that the battery is in good operating order. Subsequent alternator tests show the alternator is charging within manufacturer specifications. I've performed multiple tests after fully recharging the batter on several occasions, making sure all electrical accessories have remained (off) for extended periods of time, and the battery continues to discharge. The electrical system has been tested with a professional scan tool, on multiple occasions, and has yielded no adverse results. There has never been any vehicle warning indicators activate to indicate a problem. Today (2/25/2022) I had to have my Outback jump started 3 times in...

on 2/8/22 I brought my car in for service to an independent repair shop. The service was for the 120k standard service. I had been noticing exhaust smells. They checked the exhaust and found "exhaust leak from center exhaust flange, and exhaust leave from exhaust manifold". They recommended a complete replacement of the exhaust manifold "under Subaru recall". They printed the recall for me. It is WUJ-95. Which recalls 2015-2016 outbacks for this issue. When I contacted the dealer they indicated my vehicle was not under this recall. Subaru Customer care indicated the same as did your website. Subaru said that the recall was initiated by NHTSA and that until NHTSA indicated my vehicle was included in the recall they would not repair it. My vehicle has exactly the same issue as what was found for the recall. The only thing I can assume is that my actual 2016 Subaru...

My car spontaneously burst into flames after I parked it. I had left the car parked and locked in a parking lot next to a rental house and went in to prepare dinner. 20 minutes later my friends arrived at the scene and alerted us to the fact that my car was engulfed in flames. It seems that the fire originated in the engine somehow, but exactly what started it is unclear. There was no accident or collision, and no foul play. Security cameras in the area couldn't see much, but indicate that the vehicle burst into flames pretty much just after I had left it parked and locked.

I OWN A 2016 SUBARU OUTBACK. WHILE DRIVING APPROXIMATELY 40:MPH ON A LOCAL MAIN ROAD (CT RTE 10) THE EYESIGHT PRE-COLLISION BRAKE ASSIST SUDDENLY ACTIVATED AND CAUSED THE VEHICLE TO COMPLETELY STOP. THE BRAKES THEN RELEASED AND I WAS ABLE TO CONTINUE DRIVING. THIS IS THE SECOND INCIDENT WITH IN A MONTH THAT THIS HAS HAPPENED. THE APPROXIMATE FAILURE MILEAGE WAS 104,000 THERE WERE NO PRIOR WARNING LIGHTS OR ENGINE LIGHTS ON. THE VEHICLE HAS NOT BEEN INSPECTED BY THE DEALER. THIS SUDDEN STOPPING CAN CAUSE AN ACCIDENT.

Multiple instances of the battery dying after being parked for a few days. New battery did not resolve the problem and diagnostics indicate that the battery is not the problem. Unable to use vehicle when it cannot be started. Most recent incident was 1/18/2022. First occurred shortly after I purchased the vehicle.

Battery rapidly drains leaving me stranded. 4th battery that has been replaced by dealer and the same thing happens. No warning lights or low battery lights. Dies from 1 week to over nite. Remote won't even open the car. Dealer refuses to fix the battery drain and keeps saying it isthe battery that is bad but replaces with the same battery which fails ! I see where there are lawsuits against Subaru but I am not getting any help at all from corporate or dealer. Personal safety and being stranded and unreliable are my main concerns.

Windshield got a very large crack from me trying to kill a bug inside the car. Windshield is thin. I didn’t hit it that hard with my hand. Had to be replaced. The repair service tech explained that the only replacements for my model are of the same thinness as the original, and to seek the recall glass replacement should it be thicker and safer.

Key sticks in ignition and won’t release. Takes from a few attempts to several minutes of restarting the car, putting car in drive and then park, turning the wheel etc.

Incident occurred on Interstate 25 Northbound at approximately mm 190. My speed was approximately 70 mph. Weather was dry and about 70 degrees. I was in the next to left lane in 4 lanes of traffic. The moonroof on my 2016 Subaru Outback exploded violently sending glass outward into traffic. I had never heard of this phenomena so when I saw black material from the top of my car going into traffic I thought it was pieces of my roof rack. I pulled over to the shoulder to examine my car and saw a massive hole in the moonroof. Knowing that if I continued shards of glass would continue to be expelled onto the interstate I pulled the remaining pieces of glass into the interior of the car. Not that it mattered, that's where they fell anyway when I opened the moonroof. The pieces of the moonroof fell into the...

Unable to turn key to off position when in neutral and unable to remove key from the ignition. In order to get the key out of the ignition, the car needs to be restarted and turned back off or the gear shift needs to be pushed as hard as possible into the neutral position multiple times. With the inability to turn the car totally off and remove the key, there are multiple safety issues that can arise. Was informed that the entire select lever assembly needs to be replaced due to a known issue by Subaru. The issue was reproduced by an independent service center. No warning lamps are illuminated.

The adjustment of the passenger side side view mirror has malfunctioned. The mirror can not be adjusted properly for visibility of cars to the side of the vehicle. Only the driver-side window is operable. All other windows fail to open from the driver side control. The passenger window will no longer operate from the passenger side either. These windows would have to be broken in order to escape the vehicle in some situations (flooding). My mechanic says that this is a common problem in 2016 Subaru Outbacks. No warning lights were activated. A mirror not able to be adjusted for optimum sighting of other vehicles is surely a safety issue.

The car does not recognize that it is in park, and the key gets stuck in the ignition frequently. The only fix is to repeatedly shift in and out of the park position until the key releases (which can take anywhere from 1 minute to 10 minutes -- it seems to get worse over time). It's a safety concern for various reasons: you can't exit your car quickly in case of emergency -- you can't just leave your vehicle with the keys in the ignition (dangerous/negligent/someone could steal your car). It's also concerning that the car doesn't recognize what gear it is in. This is a widespread issue across Subaru vehicles that is documented in many online forums. The issue was confirmed by the dealership that I went to on my vehicle specifically, but they also knew the source of the problem, before they even looked at the vehicle.

For the past 6 months out key has become very hard to remove. The ignition system will not disengage and release the key. Multiple methods have been tried and sometimes are effective. Placing the car into park, then neutral, back to park and so on eventually releases the key. The service center said to play with the breaks and shifters to fix the issues. I’ve been reading of multiple problems that keep occurring with these cars.

Unable to remove key from ignition when car is parked. I am unable to leave car without threat of it being stolen. An internet search indicates this is a common problem and repair cost can be several hundred dollars

THE BATTERY WAS REPLACED IN 2017 (I PAID) FOR THIS 2016 OUTBACK. IN NOVEMBER 2020, DURING OIL CHANGE, SUBARU DEALER STATED BATTERY NEED TO BE REPLACED, I PAID AND REPLACED BATTERY. LAST WEEK, MAY 2021, DURING OIL CHANGE, SUBARU DEALER STATED THAT BATTERY "FAILED" AND THEY REPLACED THE BATTERY FOR NO CHARGE. IT APPEARS THE BATTERY IS DRAINING RAPIDLY 24/7 BECAUSE OF A LIKELY SOFT WARE PROBLEM.

I HAVE REPLACED THE BATTERY 4 TIMES SINCE BUYING THE CAR IN 2016. I CAN'T LET IT SIT MORE THAN 3 DAYS IF ITS COLD OUT OR THE BATTERY DIES. I HAVE TO JUMP THE BATTERIES QUITE FREQUENTLY. I CAN'T LET THE CAR SIT MORE THAN 7 DAYS IF IT IS WARM OUTSIDE. I HAVE CALLED THE DEALERSHIP TWICE AND THEY HAVE TOLD ME THIS IS NORMAL. I ASKED WHAT COULD BE CONSTANTLY DRAINING THE BATTERIES. I HAD THOUGHT THE CAR WAS A LEMMON WHEN I FIRST BOUGHT IT. THE BATTERY PROBLEM HAS BEEN ONGOING SINCE I BOUGHT IT. IT WAS A BRAND NEW CAR.

THE CAR WAS PARKED IN THE GARAGE AND IT WAS ABOVE FREEZING. NONE OF THE LIGHTS HAD BEEN LEFT ON/DOORS OPEN... THE CAR DOESN'T HAVE A FOB KEPT TOO CLOSE... THE CAR WOULDN'T START. THIS ISN'T THE FIRST TIME THIS HAS HAPPENED AND WE'RE NOT SURE IF IT'S A BATTERY, ALTERNATOR, ELECTRICAL ISSUE OR WHAT. WE'VE HAD THE BATTERY REPLACED ONCE ALREADY. IT FIRST HAPPENED WITHIN A WEEK OF PURCHASING THE CAR IN 2017 IN THE SUMMER TIME, AND HAS HAPPENED SEVERAL TIMES SINCE WITHOUT EXCESSIVE ELECTRICAL COMPONENTS IN USE.