2005 NISSAN ALTIMA Structurebody Problems

FLOOR BOARDS ON BOTH DRIVER'S AND PASSENGER'S SIDE SEVERELY CORRODED; AFFECTED AREA ~8X12 INCHES. BOARDS AND SHEET METAL RUSTED THROUGH COMPLETELY ON BOTH DRIVER'S AND PASSENGER'S SIDE, FORMING ~2X2 INCH HOLES. *TR

TL* THE CONTACT OWNS A 2005 NISSAN ALTIMA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS HAVING ROUTINE MAINTENANCE PERFORMED BY AN AUTHORIZED DEALER, IT WAS FOUND THAT THE FRONT PASSENGER AND DRIVER SIDE FLOOR BOARDS WERE SEVERELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 65,000.

VEHICLE FLOOR UNDER BODY BELOW PASSENGER AND DRIVER SEAT HAS RUSTED AND ABOUT TO GET A HOLE. I CALLED NISSAN SERVICE CENTER AND THEY SAY ITS NOT IN WARRANTY. BUT ITS A SAFETY ISSUE AND THE MODEL IS JUST 7 YEARS OLD WITH 89000 MILES ON IT. *TR

I WAS CHANGING THE OIL ON MY 2005 NISSAN ALTIMA AND REALIZED THE FLOORBOARDS ARE NEARLY COMPLETELY RUSTED THROUGH. I LIFTED THE CARPET INSIDE THE CABIN AND REALIZED IT IS RUSTED THROUGH. I HAD MY OIL CHANGED AT THE LOCAL NISSAN DEALERSHIP FOR OIL CHANGES. WHEN I INQUIRED ABOUT THE FLOORBOARDS THEY STATED NISSAN ALTIMA 2005 HAD A 5 YEAR CORROSIVE WARRANTY FOR THE UNDERBODY AND IT IS OUT OF WARRANTY FOR THIS REPAIR. I AM CONCERNED OF THE SAFETY OF DRIVING THIS MODEL. THE RUSTED FLOORBOARDS ARE NEAR THE FRONT DRIVER SEATS. I AM ALSO CONCERNED BECAUSE OF WATER OR MOLD NEAR THE FRONT FLOOR VENTS COULD ENTER THE CABIN THROUGH THE RUSTED FLOORBOARDS. THE FORT WAYNE NISSAN STATED THEY DID NOT NOTICE THIS RUST DURING MY OIL CHANGES. I BEGAN CHANGING MY OIL WHEN THE CAR WAS JUST OUT OF WARRANTY. I IMMEDIATELY REALIZED THE RUSTY FLOORBOARDS. THIS...

I GOT USED 2005 NISSAN ALTIMA, WHEN I GOT I DIDN'T CHECK UNDER CAR. AFTER FEW MONTHS I WAS AT DEALER FOR RECALLS AND THEY TOLD ME THAT MY CAR HAS RUSTED FLOORBOARD PAN AND ITS BIG HOLE IN BODY , THROUGH THAT WE CAN TOUCH THE CARPET OF INSIDE CAR, AND THAT KIND OF 2 BIG( APPROX. 8-10 INCH) SPOT , ONE DRIVER SIDE AND ONE PASSENGER SIDE, I TRIED TO CONTACT NISSAN CONSUMER AFFAIRS , BUT THEY SAID ITS NOT COVERED WITH WARRANTY OR ANY KIND OF RECALLS , MEANS I HAVE TO FIX THEM BY MYSELF. ITS WEIRD THAT ITS NOT THAT OLD CAR AND ONLY PARTICULAR TWO SPOTS NOT ANYWHERE ELSE UNDER WHOLE CAR SO ITS KIND OF DESIGN MISTAKE , SOME SAYS ITS WATER DRAINAGE IS HOLDING WATER ON THAT SPOTS AND THAT'S WHY ITS GETTING RUSTED. BUT MAY BE NISSAN COMPANY MUST KNOW EXACTLY...

TL* THE CONTACT OWNS A 2005 NISSAN ALTIMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR A ROUTINE OIL CHANGE WHEN THE MECHANIC ADVISED HER THAT THERE WERE HOLES IN THE FRONT DRIVER AND PASSENGER SIDE FLOORBOARDS. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THEY WOULD NOT ASSIST WITH THE REPAIR COSTS. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 107,000. UPDATED 11/27/12*LJ THE CONSUMER STATED THERE ARE WHOLES ON EQUAL PLACES ON BOTH THE DRIVER AND PASSENGER'S SIDE FLOOR BOARD. UPDATED 11/28/2012 *JS

WHEN HAVING MY OIL CHANGED THE GARAGE NOTED EXTREME ROOT ON THE FRONT DRIVERS AND PASSENGER FLOOR BOARDS. THE MECHANIC INFORMED ME THAT THEY COULD SEE THE INTERIOR CARPETING THAT WOULD ALLOW EXHAUST FUMES TO LEAK INTO THE VEHICLE. *TR

I BROUGHT MY CAR TO BE SERVICED AT GLICK NISSAN, THE DIAGNOSTIC REPORT SAID THAT THE LEFT AND RIGHT SIDES OF THE FLOOR UNDER PASSENGER AND DRIVER SEATS ARE RUSTED OUT. I BROUGHT MY CAR FOR A SECOND OPINION FROM ANOTHER MECHANIC AND HIS REPORT SAID THE RUST IS SEVERE AND IN 6 MONTHS MY CAR WILL BE WORTH NOTHING! UPON FURTHER INVESTIGATION, I FIND THAT THOUSANDS OF OTHER NISSAN CUSTOMERS ARE EXPERIENCING THE SAME PROBLEM DUE TO A DEFECTIVE PRODUCT USED BY NISSAN. I FILED A CLAIM WITH NISSAN NORTH AMERICA, THEY ARE CLAIMING ZERO RESPONSIBILITY, LABELING THE ISSUE AS AN "ENVIRONMENTAL CONCERN" AND WILL IN NO WAY ASSIST WITH REPAIRS. NISSAN SHOULD TAKE RESPONSIBILITY FOR THIS ISSUE. *TR

I NOTICED A LOOSE PIECE OF HANGING METAL FROM UNDERNEATH THE FRONT PASSENGER SIDE OF MY 2005 NISSAN ALTIMA. I LOOKED UNDERNEATH AND QUICKLY FOUND THAT APPROXIMATELY AN 8" X 20" FLOORBOARD SECTION BEHIND THE FRONT RIGHT WHEEL WAS COMPLETELY RUSTED OUT AND CRUMBLED TO THE GROUND UPON TOUCHING IT. THE APPROXIMATE MILEAGE IS 135,000 MILES. THIS APPEARS TO BE A COMMON COMPLAINT WITH THIS MAKE AND MODEL AND NISSAN NEEDS TO ACKNOWLEDGE THAT THIS IS A MANUFACTURING DEFECT. IT IS EXPECTED THIS WOULD BE AN ISSUE 40 YEARS AGO, BUT NOT WITH TODAY'S CARS. *TR

IT WAS NOTICED DURING INSPECTION THAT THE PASSENGER SIDE FLOORBOARDS WERE STARTING TO PEEL AWAY. THIS IS A KNOWN PROBLEM WITH THIS VEHICLE. CONTACTED NISSAN ABOUT CORRECTING THE PROBLEM AND THEY DID NOT WANT TO TAKE RESPONSIBILITY FOR THEIR POOR ENGINEERING AND MATERIALS OF THE VEHICLE. THEY SHOULD MAKE GOOD ON THE PROBLEM BUT THEY SAID BECAUSE THEY DIDN'T HAVE ENOUGH SERVICE HISTORY , THE CAR WAS OUT OF WARRANTY, IT HAD TO MANY MILES. ALL REASONS THAT HAVE NOTHING TO DO WITH POOR MATERIALS AND WORKMANSHIP. I THINK NISSAN SHOULD TAKE RESPONSIBILITY AND CORRECT THE PROBLEM THEY SHOULD BE INVESTIGATED ABOUT THE PROBLEM. THIS IS NOT AN ISOLATED PROBLEM. *TR

THE FLOOR IS ALL RUSTED OUT AND WILL NOT PASS INSPECTION. *TR

MY VEHICLE IS A LOW MILEAGE GARAGED 2005 NISSAN ALTIMA WHICH IS IN PERFECT CONDITION EXCEPT THAT THE DRIVER AND PASSENGER SIDE FLOOR BOARDS ARE ROTTED OUT SO THAT YOU CAN STEP THROUGH. VEHICLE HAS BEEN GARAGED AND METICULOUSLY MAINTAINED WITH FRESH WATER CLEANING OF THE UNDERCARRIAGE WHEN WASHED AND ESPECIALLY IN THE SPRING. THIS IS A SERIOUS SAFETY HAZARD WITH POTENTIAL FOR INJURY STEPPING THROUGH AND POSSIBLE DEATH FROM EXHAUST FUMES CAUSING UNCONSCIOUSNESS WHILE DRIVING. THIS IS AN OBVIOUS VEHICLE DEFECT AND SHOULD BE RECALLED. I HAVE READ NUMEROUS INCIDENTS OF THIS PROBLEM BOTH ON THIS NHTSB SITE AND IN OWNER FORUMS SO IT IS A WELL KNOWN PROBLEM THAT NEEDS TOP BE ADDRESSED. *TR

I HAD MY 2005 NISSAN ALTIMA AT MY LOCAL MECHANIC TO HAVE SOME RATTLING UNDERNEATH MY CAR LOOKED AT. THERE WAS A LOOSE HEAT SHIELD THAT THE MECHANIC FIXED AND HE ALSO NOTIFIED ME THAT THERE WERE LARGE AREAS OF RUST ALONG BOTH FLOORBOARDS. THIS VEHICLE HAS BEEN METICULOUSLY MAINTAINED AND WASHED IN THE WINTER. THE LAST TIME THE CAR WAS AT THERE MECHANIC, THERE WAS NO RUST EVIDENT. UNFORTUNATELY MY CAR IS NO LONGER UNDER WARRANTY AND I WOULD LIKE NISSAN TO ACKNOWLEDGE THAT THIS IS A MANUFACTURING DEFECT. *TR

TODAY WHILE PERFORMING AN OIL CHANGE ON MY GIRLFRIENDS 2005 NISSAN ALTIMA I NOTICED A LARGE HOLE IN THE FLOOR OF THE CAR. THERE IS A LARGE RUSTED OUT HOLE, ONLY ON ONE SIDE OF THE VEHICLE THAT GOES COMPLETELY THROUGH TO THE INSIDE. IN EXACTLY THE SAME PLACE ON THE OPPOSITE SIDE OF THE CAR THERE IS NO RUST AT ALL. THIS CAR IS WASHED REGULARLY, AND HAS NO RUST ON THE PAINTWORK ANYWHERE. UPON LOOKING IT UP ON THE INTERNET THERE APPEARS TO BE MANY MANY PEOPLE WITH THIS ISSUE, AND NISSAN IS TRYING TO COVER IT UP AND NOT COVER THE REPLACEMENT OF PARTS THAT ARE CLEARLY DEFECTIVE. PLEASE HELP ME HOLD THEM ACCOUNTABLE. *TR

AFTER JACKING UP MY MOTHER'S CAR FOR AN OIL CHANGE, WHILE I WAS PLACING JACK STANDS BEHIND THE FRONT WHEELS IN THE APPROPRIATE JACKING POINTS, I NOTICED THAT THE FLOOR PANELS LOOKED SWOLLEN UNDERNEATH THE RUST PROOFING MATERIAL. I BEGAN TO POKE AT IT WITH MY FINGER, AND MY FINGER PUSHED THROUGH THE RUST PROOFING AND ALL KINDS OF SEVERELY RUSTED METAL BEGAN TO FALL OUT ON THE GARAGE FLOOR. THE STEEL FLOOR PANEL, HAD BASICALLY TURNED TO RUSTED DUST. I WAS ABLE TO PUSH MY FINGER UP THROUGH THE FLOOR PANEL UNTIL I COULD FEEL THE BOTTOM OF THE CARPET. NOTICING NO OTHER RUST ANYWHERE ELSE NEAR BY, I FIGURED IT HAD TO BE A MANUFACTURING DEFECT, SO I DECIDED TO CHECK THE DRIVER'S SIDE SAME LOCATION, AND SURE ENOUGH, WAS ABLE TO PUSH MY FINGER THROUGH THE RUST PROOFING AND THROUGH ROTTED STEEL LIKE IT WAS NOTHING. THIS...

RUSTED FLOOR PAN ON PASSENGERS SIDE HAD A 12" HOLE. *JS

MY 2005 NISSAN ALTIMA 2.5S HAS 88,500 MILES ON IT. IT IS IN EXCELLENT CONDITION, EXCEPT FOR THE FLOOR PANS UNDER THE VEHICLE (DRIVER AND PASSENGER SIDES) THAT ARE RUSTING THROUGH. IT IS APPARENT THAT THIS IS A KNOWN PROBLEM FOR THESE VEHICLES AND NISSAN HAS NOT ISSUED A RECALL. I NEED THIS FIXED, AS THIS IS A SAFETY CONCERN FOR 2 REASONS: STRUCTURAL INTEGRITY AND FUMES ENTERING VEHICLE. I WAS INFORMED BY MY LOCAL NISSAN DEALER THAT THE ONLY PROPER REPAIR IS TO COMPLETELY REPLACE THE FLOOR PAN METAL. THE ESTIMATE FOR THIS WAS AROUND $2500. I HAVE A 2 YEAR OLD SON AND A DAUGHTER ON THE WAY. I CANNOT AFFORD A NEW VEHICLE AT THIS TIME, AND NISSAN NEEDS TO STEP UP AND FIX THIS! *TR

NOTICED AN OBJECT HANGING FROM UNDERSIDE OF PASSENGER FLOOR AREA. UPON EXAMINATION FOUND FLOORPAN AREA COMPLETELY RUSTED THROUGH AND HANGING PIECE WAS PART OF RUSTED FLOOR PAN. *TR

TL* THE CONTACT OWNS A 2005 NISSAN ALTIMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR A TRADE-IN AND THE CONTACT WAS INFORMED THAT THE FLOOR BOARDS ON THE PASSENGER SIDE OF THE VEHICLE WERE RUSTED. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS DANGEROUS TO DRIVE AND THEY WOULD NOT TAKE THE VEHICLE. THE MANUFACTURER WAS NOTIFIED AND ADVISED HIM TO CONTACT THE DEALERS. THE FAILURE MILEAGE WAS 89000.

WHILE JACKING MY 2005 NISSAN ALTIMA UP UPON LOOKING UNDERNEATH I NOTICED A 4 INCH BY 4 INCH PATCH OF RUST. AFTER FURTHER INSPECTION I NOTICED THAT IT WAS RUSTED ALL THE WAY THROUGH TO THE CARPET INSIDE THE CAR. SIX MONTHS AGO WHEN I WAS WORKING ON MY CAR THERE WAS NOT RUST AT ALL. I TAKE CARE OF MY CAR AND INSPECT THE CAR FOR ANY PROBLEMS. THERE ARE NO RECALLS FOR THIS BY NISSAN AND THIS NEEDS TO BE FIXED. AFTER RESEARCHING I FOUND THIS IS A COMMON PROBLEM WITH 02 - 05 ALTIMAS AND IS A SERIOUS SAFETY ISSUE. *TR

TL* THE CONTACT OWNS A 2005 NISSAN ALTIMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE WHEN THE MECHANIC ADVISED THE CONTACT THAT THERE WERE RUST SPOTS UNDER THE DRIVER AND PASSENGER SEATS, UNDERNEATH THE VEHICLE. IN ADDITION, THE MECHANIC DISCOVERED RUST OVER THE ENTIRE FRONT END OF THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THEY COULD PROVIDE NO ASSISTANCE BECAUSE THE WARRANTY WAS EXPIRED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 56,903.

I HAVE A 2005 NISSAN ALTIMA SL AND TOOK MY CAR INTO CONICELLI NISSAN BACK IN FEBRUARY OF THIS YEAR FOR AN ORDER CHANGE AND SOMETHING ELSE MINOR. CONICELLI NISSAN BROUGHT TO MY ATTENTION THAT THE FLOOR PAN WAS RUSTED ON THE PASSENGER SIDE FRONT. I WAS TOLD TO CONTACT THE BODY SHOP OF CONICELLI WHICH I DID AND THEY IN TURN TOLD ME THAT THEY CAN NOT DO THE REPAIR BECAUSE OF THE RUST AND THEY DIDN'T WANT TO BE HELD ACCOUNTABILITY FOR IT AND PERHAPS RISK A LAW SUIT FURTHER DOWN THE LINE. MY COMPLAINT IS THE CAR IS ONLY 8 YEARS OLD WITH 60,000 MILES ON IT AND I HAVE TAKEN IT TO TWO DIFFERENT BODY SHOPS AND THEY ARE AMAZED THAT THE FLOOR PAN HAS RUSTED ALREADY BEING THAT THE CAR IS ONLY 7 YEARS OLD AND IN VERY GOOD CONDITION. THIS SEAMS LIKE A KNOWN...

PASSENGER SIDE UNDERBODY RUSTED COMPLETELY THROUGH. *JS

I HAVE A 2005 NISSAN ALTIMA THAT I JUST TOOK IN FOR A FRONT END CHECK AND WAS NOTIFIED THAT THE FLOORBOARD ON THE DRIVER SIDE IS COMPLETELY RUSTED OUT, I CAN ACTUAL TOUCH THE CARPETING THROUGH THIS LARGE HOLE. I CAN NOT BELIEVE THIS, THE CAR IS ONLY 7 YEARS OLD. I HAVE SEARCHED THIS ON THE INTERNET AND IT SEEMS TO BE A VERY COMMON COMPLAINT, WHY ISN'T NISSAN DO ANYTHING ABOUT THIS? HOW MANY COMPLAINTS NEED TO BE MADE BEFORE SOMETHING IS DONE ABOUT THIS? OBVIOUSLY THIS A MANUFACTURER DEFECT. *TR

TL* THE CONTACT OWNS 2005 NISSAN ALTIMA. THE CONTACT HAD TAKEN THE VEHICLE TO AN AUTHORIZED DEALER FOR AN UNRELATED REPAIR AND THE TECHNICIAN NOTICED THAT THE FRONT DRIVER AND PASSENGER SIDE FLOORBOARDS WERE COMPLETELY RUSTED. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC FOR REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. UPDATED 02/22/12 *BF THE BRAKES WERE REPLACED, AS WELL AS THE AC LINE THAT WAS LEAKING. UPDATED 03.05.12

I PURCHASED MY CAR IN JANUARY OF 2006 USED WITH ABOUT 3,800 MILES. I'VE TAKEN MY VEHICLE SEVERAL TIME TO NISSAN DEALER FOR MY 15,000 MILE SERVICE AND ALSO THEY REPLACE MY SUSPENSION ON A RECALL. I DISCOVERED TODAY THAT MY FRONT PASSENGER FLOORBOARD IS COMPLETELY RUSTED OUT, I MEAN IF IT WASN'T FOR THE INTERIOR CARPET I COULD PUT MY WHOLE ARM DOWN IN THE HOLE. I'VE DONE RESEARCH AND IT SEEM TO BE A VERY COMMON PROBLEM WITH MODEL AND YEAR. NISSAN HAS LIFTED MY CAR NUMEROUS TIME AND HAS NOT ONCE MENTIONED SEEING RUST, WHICH AT THIS POINT IS NOW OUT OF WARRANTY. THIS COULD'VE BEEN FIXED AND STILL UNDER WARRANTY MONTHS AGO. I WAS MY CAR ALL THE TIME AND EVEN IN WINTER, I UNDERSTAND THAT RUST IS NATURAL ON A CAR, BUT WHEN YOU SEE THAT THIS HAPPENS MORE THAN OFTEN ON THIS PARTICULAR MODEL...

TL* THE CONTACT OWNS A 2005 NISSAN ALTIMA. THE CONTACT STATED THE DRIVER AND PASSENGER SIDE FLOOR PANEL WAS COMPLETELY COVERED WITH RUST AND THE ONLY THING HOLDING IT IN PLACE WAS THE CARPET. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED HIM THAT THE FLOOR PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND HE HAD NOT RECEIVED A RESPONSE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 103,000.

CAR PURCHASED NEW ,05 ALTIMA SER 3.5, $30,000 PRICE TAG. NOTICED RUST AT APPROX 3/11, TOOK TO DEALER THEY CLAIMED NEVER HAVING SEEN ANYTHING LIKE IT BEFORE TOLD ME TO CONTACT NISSAN CORP AND FILE COMPLAINT, I DID ( FILE #[XXX]) DEALERSHIP ALSO TOOK PICTURES AND SENT THEM TO NISSAN. " [XXX]" NISSAN REGIONAL SPECIALIST ( EX: # 457225) STATED IT WAS NOT THERE PROBLEM "RUST HAPPENS". RUST IN FLOORBOARDS ON PASSENGER SIDE OF VEHICLE. VEHICLE HAS NOW 67,000 MILES AND NOW CARRIES MY NEW BORN SON, BORN 5/09/11. WHY ISN'T THIS BEING ADDRESSED, WHERE'S IS THE GOVERNMENTS PROTECTION OF MY FAMILY AND I ? THERE ARE SO MANY COMPLAINTS ABOUT THE SAME ISSUE ONLINE AND IN BLOGS. WHAT ARE U WAITING FOR? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHAT ONCE WAS TWO DECENT SIZED RUST AREAS ON THE FLOORBOARD OF MY NISSAN ALTIMA IS NOW TWO GAPING HOLES IN WHICH YOU CAN SEE AND PUT YOUR HAND STRAIGHT THROUGH AND TOUCH THE GROUND OUTSIDE IF IT WASN'T FOR THE CARPET. I FIRST NOTICED IT WHEN I WAS GETTING AN OIL CHANGE AND MY MECHANIC POINTED OUT TO ME. THE IT ALL MADE SENSE BECAUSE WHEN EVER IT RAINED OR SNOWED BADLY IN MY AREA I WOULD ALWAYS HAVE WET FLOORS AND AT FIRST I THOUGHT SOMETHING WAS LEAKING BUT I NOW KNOW IT'S THE TWO RUST CORROSION SPOT IN THE FLOORBOARD. AND SOME DAYS THE ODOR FROM THE WETNESS ON THE CARPET IS PUNGENT. ONE IS ON THE DRIVER SIDE AND THE OTHER IS RIGHT ON THE PASSENGER SIDE. I WAS LOOKING THROUGH MY WARRANTY AND VEHICLE INFO BOOKS THAT CAME WITH THE VEHICLE AND IT DEFINITELY SHOWS...

MY 2005 NISSAN ALTIMA DRIVER SIDE FLOOR HAS ROTTED UNTIL THERE ARE HOLES IN THE FLOOR. THE FLOOR NEED TO BE PATCHED. *TR

I FILED A COMPLAINT WITH NISSAN NORTH AMERICA REGARDING RUST DAMAGE ON MY 2005 ALTIMA 3.5 SE W/67,000 MI. AFTER BEING REFERRED TO MY DEALERSHIP FOR AN INVESTIGATION A REP WITH NISSAN REGIONAL CONSUMER AFFAIRS SAYS THAT UNFORTUNATELY MY WARRANTY DOESN'T COVER RUST AFTER 5 YEARS. I ASKED IF IT'''S NISSAN'''S POSITION THAT I WAS NEGLIGENT IN MAINTAINING MY VEHICLE. HOW ELSE WOULD YOU EXPLAIN A 6 YR LOW-MILEAGE CAR HAVING EXTENSIVE RUST ISSUES? WOULD THEY AT LEAST ADMIT TO PARTIAL RESPONSIBILITY AND HELP WITH THE COST OF REPAIRS? EVERYTHING ON MY CAR IS STILL LIKE NEW EXCEPT PREMATURE RUSTING THROUGH THE FLOORBOARDS ON BOTH THE DRIVER'S SIDE AND PASSENGER SIDE. I EXPLAINED I'VE DILIGENTLY MAINTAINED THIS VEHICLE WITH THE HOPES OF IT LASTING FOR YEARS BASED ON THE REPUTATION OF IMPORTED CARS. IT'S BEEN GARAGED DURING MOST INCLEMENT WEATHER. I EXPLAINED HOW SHOCKED I WAS WHEN I SAW ALL...

I PURCHASED MY 2005 NISSAN ALTIMA 2.5S USED IN NOVEMBER OF 2006. IT HAD APPROXIMATELY 33,000 MILES ON IT. FIVE YEARS LATER, THE CAR HAS 101,000 MILES ON IT AND THE PASSENGER SIDE FLOORBOARD HAS MAJOR RUST DAMAGE; SO MUCH THAT YOU CAN ACTUALLY TOUCH THE INTERIOR RUBBER FLOORBOARD OF THE CAR FROM THE OUTSIDE. I HAVE YET TO TAKE IT TO A NISSAN DEALERSHIP, SINCE I KNOW MY WARRANTY IS EXPIRED, BUT I HAVE HAD MANY PROFESSIONALS TAKE A LOOK AND THEY ARE RENDERED SPEECHLESS OVER THE DAMAGE. I HAVE BEEN TOLD NUMEROUS TIMES THAT THE DAMAGE IS OBVIOUSLY A FACTORY DEFECT, A CAR THAT'S ONLY A FEW YEARS OLD SHOULD NOT HAVE THAT KIND OF DAMAGE AND THAT IT WOULD COST WELL OVER $1000.00 TO REPAIR. I HAVE MAINTAINED MY VEHICLE WELL AND HAVEN'T HAD ANY OTHER MAJOR PROBLEMS WITH IT; JUST THE USUAL REPLACEMENTS. I'VE PUT A...

I HAVE JUST DISCOVERED THAT MY 2005 NISSAN ALTIMA IS RUSTING UNDER THE DRIVER SIDE AND ALSO UNDER THE PASSENGER SIDE. UNDER THE DRIVER SIDE THE RUSTING IS WORSE, I CAN JUST PEEL OFF THE THE RUSTING AREA WITH MY BARE HANDS. I KNOW THAT THIS TYPE IS PROBLEM IS COMMON WITH THESE VEHICLES, I HAVE SEEN SEVERAL PICTURES PUBLISHED BY OTHER NISSAN ALTIMA OWNERS ON THE INTERNET. MY CAR HAS 86000 MILES ON IT AND IT IS 6 YEARS OLD. I DID NOT EXPECT SUCH A SERIOUS DEFECT ON A RELATIVELY YOUNG CAR, WHICH WAS GARAGED A WELL CARED FOR EVER SINCE A BOUGHT IT NEW. *TT

TL* THE CONTACT OWNS A 2005 NISSAN ALTIMA. THE CONTACT STATED THE FLOOR BOARDS ON THE DRIVER AND PASSENGER SIDE WERE ROTTEN. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THE REPAIR COST WOULD BE $440 PER SIDE IN ORDER TO REPAIR THE FLOOR BOARDS AND THEY WERE OUT SOURCING THE REPAIRS TO A BODY SHOP. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO WILL REPLACE THE FLOOR BOARDS AT THE OWNERS EXPENSE FOR $600. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 104,000.

WHILE HAVING THE OIL CHANGED IT WAS BROUGHT TO THE OWNER'S ATTENTION THAT THE PASSENGER FRONT FLOORBOARD WAS COMPLETELY RUSTED THROUGH. THE VEHICLE WAS TAKEN TO A BODY SHOP WHERE THEY ADVISED TO TAKE THE VEHICLE TO THE LOCAL NISSAN DEALER BECAUSE THERE WAS NO OTHER RUST ON THE CAR AND THE EXTENT OF PERFORATION WAS SO SEVERE THE BODY SHOP SAID THERE MUST BE SOME PROBLEM WITH THE WAY THE CAR WAS ASSEMBLED. THE CAR WAS TAKEN TO THE LOCAL NISSAN DEALER WHERE THE WARRANTY REPRESENTATIVE LOOKED AT THE VEHICLE AND DENIED ANY WARRANTY SUPPORT OR ASSISTANCE WITH GETTING THE VEHICLE REPAIRED. I RETURNED THE VEHICLE TO A REPUTABLE BODY SHOP WHERE THE CAR WAS REPAIRED FOR $600.00. THE BODY SHOP INFORMED ME THAT THE RUST HAD STARTED ON THE INSIDE AND RUSTED THROUGH FROM THE TOP. AFTER REPAIRS, THE OWNER SAW THAT SEVERAL OTHER VEHICLES OF THE SAME...

RUSTED FLOOR BOARD ON PASSENGER SIDE. *TR

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

DURING A ROUTINE BRAKE INSPECTION IT WAS BROUGHT TO MY ATTTENTION THE FLOORBOARDS ON THE PASSENGER SIDE (FRONT SEAT) HAVE CORRODED TO THE POINT WHERE A FINGER COULD PUNCH THROUGH THE FLOOR. THE DAMAGE IS ISOLATED AND APPEARS TO BE FROM A FAULTY DRAIN SYSTEM FROM THE AIR CONDITIONING UNIT. AFTER DRIVING THE CAR FOR OVER AN HOUR WITH THE AIR RUNNING, THERE IS NO DRAINING ON THE FLOOR OF MY GARAGE. IT APPEARS THE WATER IS PUDDLING UNDER THE FLOOR MATS AND CAUSING THE EROSION OF THE FLOOR. I AM THE ONLY OWNER OF THE VEHICLE AND IT HAS BEEN GARAGED SINCE THE DAY I BROUGHT IT HOME.

'2005' NISSAN ALTIMA 2.5 SL. NOTICED A LARGE AREA OF RUST UNDER THE PASSENGER FRONT FLOORBOARD WHEN CAR WAS ON A LIFT. DID A SEARCH ONLINE AND FOUND THAT THERE WERE NUMEROUS COMPLAINTS FOR THIS SAME PROBLEM. AFFECTED YEARS '02' - '06'. MANY OTHERS HAVE CONTACTED NISSAN AND THEY HAVE REFUSED REPAIR. *TR

TO WHOM IT MAY CONCERN: I PURCHASED A 2005 NISSAN ALTIMA IN JULY 2009. RECENTLY, I HAD MY CAR INSPECTED AND A RUST PERFORATION WAS NOTICED ON THE UNDERSIDE OF THE PASSENGER SIDE. IT IS THE SIZE OF A BASEBALL WHICH IS THROUGH THE FIRST LAYER OF METAL. I SPOKE WITH THE DEALER, WHERE I PURCHASED THE VEHICLE, AND THEY STATED THAT MY WARRANTY FOR PERFORATION WAS 5 YEARS AND HAS EXPIRED. I HAD PLANNED ON REPAIRING IT MYSELF; HOWEVER, UPON ONLINE RESEARCH I FOUND THAT THIS IS A COMMON PROBLEM WITH THE 2002-2006 ALTIMA MODELS. THE PERFORATION ON THESE CARS APPEARS ON THE PASSENGER SIDE FLOOR EXACTLY WHERE MINE IS. THE FLOOR IS DESIGNED WITH TWO PIECES OF SHEET METAL WITH A GAP IN BETWEEN WHICH, UNFORTUNATELY ALLOWS WATER TO BECOME TRAPPED. THIS IS A DESIGN ERROR WHICH CAUSES PREMATURE RUST TO FORM. I AM CONCERNED THAT IF I...

THERE IS A RUSTED HOLE ON THE PASSENGER SIDE FLOOR OF THE CAR. THE HOLE IS THE SIZE OF A SOFTBALL WITH RUSTED METAL AROUND THE AREA OF THE HOLE. APPARENTLY THIS IS COMMON ON 2002-2006 NISSAN ALTIMAS. THE CAR HAS NEVER BEEN IN AN ACCIDENT AND HAS BEEN WELL MAINTAINED. *TT

VEHICLE WAS BROUGHT FOR ROUTINE INSPECTION. 2 HOLES WERE DISCOVERED IN FLOOR PANELS THAT PREVENTED IT FROM PASSING VT INSPECTION. CORROSION WAS FROM INSIDE OUT UNDER BOTH FRONT SEATS NOT VISIBLE FROM VEHICLE INTERIOR. VEHICLE HAS BEEN GARAGED SINCE PURCHASE 6/25/04. CORROSION IS EXCESSIVE FOR AGE AND MILEAGE EVEN IN AN AREA PRONE TO ROAD SALT CORROSION. MULTIPLE COMPLAINTS HAVE BEEN FILED ON MODEL YEARS 2001-2005 YET NO RECALL. THE PROBLEM IS EXTREMELY EXPENSIVE TO REPAIR AND IF NOT RECOGNIZED CAN ALLOW CARBON MONOXIDE INTO PASSENGER COMPARTMENT.

I HAVE BOUGHT BRAND NEW 2005 NISSAN ALTIMA 3.5SE IN OCTOBER OF 2004. JUST YESTERDAY DURING MY OIL CHANGE I HAVE NOTICED A HOLE UNDERNEATH THE CAR AND RUSTED AREA IN THE DIAMETER OF A FOOT OR SO. FLOORING RUSTED AND IT WAS OBVIOUSLY RESULT OF NOT FORCED DAMAGE BUT DEFECTIVE MATERIALS USED TO MAKE THE CAR FLOORING. I AM FINDING FORUMS AND LOADS OF COMPLAINTS THAT RIGHT AFTER THE WARRANTY IS EXPIRED CAR'S FLOORING SIMPLY START TO RUST. I DO NOT KNOW WHAT TO DO AND I AM SURE DEALERSHIP WILL TURN ME AWAY AS THE CAR IS NOT UNDER WARRANTY AND THEY USUALLY DO NOT HAVE BODY SHOPS. WHO CAN HELP ME AS I SPENT ABOUT $33,000.00 FOR THIS CAR (LAST 6 YEARS OF PAYING IT OFF.... HELP!!?!? *TR

TOOK MY CAR IN TO BE INSPECTED (PA INSPECTION). FLOOR PAN ON MY 2005 ALTIMA IS COMPLETELY RUSTED THROUGH ON THE PASSENGER SIDE OF THE VEHICLE. NEEDS TO HAVE FLOOR PAN REPLACED. THIS CAR HAS VERY LOW MILEAGE, IS CLEAN AND GARAGE KEPT. CHECKED THE INTERNET, AND NOTICED QUITE A FEW COMPLAINTS ABOUT RUST ON THE PASSENGER AND DRIVE SIDE. NOTHING ELSE IS SHOWING RUST. HOW CAN ONE PART COMPLETELY RUST OUT AND THE REMAINING PART OF THE CAR HAS NONE AT ALL?? APPARENTLY THERE IS A DEFECT THAT IS HOLDING WATER/MOISTURE AND CAUSING THE RUST. THE CAR DOES NOT HAVE ANY MECHANICAL ISSUE - BASICALLY LIKE NEW. HOWEVER, TOTALLY RUSTED OUT IN ONE SPOT. *TR

I WOULD LIKE TO REPORT A SITUATION I HAD WITH MY LEASED 2005 ALTIMA THAT COULD BE A SERIOUS PROBLEM FOR DRIVERS AND I THINK YOU SHOULD LOOK INTO FOR A POSSIBLE CALL BACK. SEVEN (7) OF THE CLIPS ( PART 01553-09321) CAME OFF THE CAR WHILE DRIVING, CAUSING THE LOWER ENGINE COVER TO FALL DOWN AND HANGING BY THE REMAINING CLIPS. NOT KNOWING THE PROBLEM, I WAS STARTLED AND HAD TO QUICKLY PULL OVER TO SEE WHAT THE PROBLEM WAS. I HAD TO TAPE THE LOWER ENGINE COVER WITH DUCT TAPE IN ORDER TO BE ABLE TO DRIVE THE CAR. THE COVER IS BEING HELD ON BY CLIPS RATHER THAN BOLTS. IF BOLTS OR SCREWS WERE IN IT, IT WOULD NOT HAVE HAPPENED. I HAVE BEEN TOLD THAT THE SERVICE DEPARTMENT THAT THEY REPLACES A LOT OF THESE CLIPS. IT SEEMS TO ME THAT IF YOU ARE REPLACING A...