2010 MERCURY MILAN Steering Problems

I was driving on the freeway and the steering began to stiffen. I got to my destination and decided to check the tires for any ice or snow, thinking that might be why it was difficult to drive but there was no buildup. I made it home and parked the car. The next day, I can't even turn the steering and a warning comes up that says service power steering and advancetrac.

Bought this car less then a year ago with 38k miles and just last week after coming back from vacation my power steering system went while on the expressway. The advancetrac warning light came on and then the service power steering now. The steering wheel was impossible to turn and to make matters worse it was snowing out.

The electric power steering has failed again this will make it twice in 18 months the last time it cost 1800 dollars to fix it know that only some of the 2010 Mercury Milans are on a recall list unfortunately mine is not on that list why because it is absurd that I should I have to make this repair for 1800 dollars again you cant safely drive this car it takes everything I have to turn the steering wheel

The contact owns a 2010 Mercury Milan. The contact stated that while driving approximately 30 MPH, the "Service Traction Control" and “Power Steering Sensor” warning lights illuminated. The contact stated that the steering wheel became difficult to turn to the left or the right. The contact was able to drive the vehicle back to the residence. The local dealer was contacted and sent an agent to the residence to drive the vehicle to the dealer. The vehicle was diagnosed, and it was determined that the power steering assist had failed, and the steering gears and rack, and pinion needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 60,562.

Check engine light is on mechanic says it's a fuel tank issue

I experienced a loss of power steering while driving and a dash display "Service Power Steering Now" and "Service Advancetrac". The messages started just before the failure. The lack of power steering was a risk to everyone as the car could only be turned with significant effort and not respond to quick movement. The dash messages are still on after a restart and the car cannot be driven because of safety. My independent mechanic confirmed the issue and fix to be a bad rack. He noted the rack part number is the same as the 2011 Milan, currently under recall for this issue. However, the 2010 is not included.

The contact owns a 2010 Mercury Milan. The contact stated while driving at various speeds, the steering wheel was difficult to turn. Additionally, the contact stated while driving 30-35 MPH, the steering wheel seized inadvertently. There were no warning lights illuminated. The contacted depressed the brake pedal and pulled over to the side of the road and parked the vehicle. The contact stated that upon returning to the vehicle, the vehicle was restarted, and the steering wheel was no longer seized, but the steering wheel was difficult to turn. The contact was able to drive the vehicle; however, the failure recurred while driving. The dealer was notified of the failure and informed the contact that the failure was related to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was...

The contact owns a 2010 Mercury Milan. The contact stated while driving at approximately 45 MPH while turning the steering wheel to the right, the steering warning illuminated, and the steering wheel became difficult to turn. The contact stopped and turned off the vehicle and the power steering function returned. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 15V340000 (Steering). The manufacturer was informed of the failure. The failure mileage was approximately 126,000.

started vehicle, "power steering assist fault" message appeared on dash message center, unable to turn steering wheel. Turn car off, waited, turn back on, message appeared again. tried an additional 3 times, same results. Had to leave the car where i was visiting.

My power steering light came on and then immediately the wheel got tight. I was unable to turn the wheel and then eventually the car is un drivable. There is a lot of complaints about this happening to thousands of cars and it is still under investigation. Imagin someone jumps out in front of you and you are stopping and unable to maneuver your car out of the way. By the grace of God I was able to do so. Please advise me when this recall is open.

The contact owns a 2010 Mercury Milan. The contact stated that the power steering assist became inoperable. The driver was unable to turn the steering wheel. The contact stated that the steering wheel had seized. The vehicle was restarted, and the steering wheel operated as designed. The power steering assist fault and service power steering soon messages were displayed. The contact stated that the failure was related to NHTSA Campaign Number: 15V340000 (Steering). The local dealer was contacted, and the contact was referred to the Ford Warranty Department for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 38,000.

See attached document for complaint

After turning the car on one morning, an alert displayed on the dash saying "Power Steering Assist Fault" and "Service Advancetrac". I turned the car off, and back on, but the same message appeared. When driving, there is no power steering and it is difficult to turn the steering wheel. The Milan only has 110,000 miles. Ford needs to issue a recall as this is obviously a defect affecting many customers.

Upon starting the vehicle, the steering wheel is firm and very difficult to manouver. It requires a great amount of strenght to just turn. The vehicle was diagnosed by the dealer and by a mechanic and both said there was a problem with the steering wheel.

The contact owns a 2010 Mercury Milan. The contact stated that upon starting the vehicle, the steering wheel was firm and difficult to maneuver. The contact stated that an unknown warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the steering rack needed to be replaced. The vehicle was repaired. The contact related the failure to NHTSA Campaign Number: 15V340000 (Steering). The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 69,000.

I have a 2010 Mercury Milan with only 60000 miles on it and the electric power steering went out. It happened while i was driving causing the car to hard right. The part costs $900 and then it has to be programmed at a dealership. I know there was a recall for this but only for the 2011 model. After researching and reading other safety complaints, it's pretty clear that a recall should be done for the 2010 model.

The contact owns a 2010 Mercury Milan. The contact stated that after restarting the vehicle, the power steering message was displayed. Later, while driving approximately 30 MPH and making a right turn, the steering wheel malfunctioned causing the vehicle to make a sharp right turn nearly causing the driver to lose control of the steering wheel. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not yet contacted. The failure mileage was 130,000.

The contact owns a 2010 Mercury Milan. The contact stated that while driving approximately 55-60 MPH, the "Service Power Steering" warning light was illuminated. The steering wheel then locked causing the contact to veer off into a ditch on the side of the road. The contact was able to stop the vehicle. The vehicle was towed to their home. The vehicle had not been taken to the dealer, diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 120,000.

The contact owns a 2010 Mercury Milan. The contact stated that at start-up and while driving at various speeds, the power steering assist fault message was displayed on the instrument panel. The contact stated that excessive force was needed to steer the vehicle due to the failure. The dealer and the manufacturer were both notified of the failure and informed the contact’s husband that there were no recalls on the VIN. An independent mechanic was notified of the failure and the contact was provided an estimate for the repair. The vehicle was not repaired. The failure mileage was approximately 67,000.

While driving the dash displayed Service Power Steering Now & Advance Trac. The car seemed normal until we pullled off the side of the road & turned off the ignition. Restarted & there was not any power assist & the traction control was iit up. It was extremely hard to steer so we had it towed.

Power steering fault. Steering wheel locks up.

Steering became hard to steer. Power steering assist failure light on and 75 years old hardly could turn wheel. Many 2010 Milan's are having same problem. I cannot afford the repair. I noticed 2011-2012 Milan's are recalled for a fix not 2010??? Please help

Periodically I would receive a a steering assist fault. Now my steering is completely out with the same warning. With the steering assist out the vehicle is very hard to steer and dangerous. There is a recall for 2010 Mariner and other ford vehicles but not the mercury with the same system. Also the 2011 Milan has recalls for this issue but want me to pay thousands to repair my 2010 It’s the same system and parts for this issue

The contact owns a 2010 Mercury Milan. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The "Service Power Steering" message was displayed. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 188,000.

While driving the power steering failed and the qheel wouldn't turn at all. Luckily I was in my neighborhood.

The power assist malfunctioned nearly causing a crash. 2011 model was recalled 2010 was not.

Power Steering Control Module Difficulty steering, loss of control No No No, 10/20/22

I was driving to the store, luckily only going 30mph. Suddenly the power steering stopped working, the message center displayed "service power steering now" and "service advancetrac" along with an illuminated light on the dash. I've looked into the issue and there is no recall for 2010 models. Only 2011. Knowing my way around cars, I've looked into purchasing a new steering rack and installing it but new they are $1000 or more. This issue needs to be resolved with a recall. Things could have gone a lot different if I was on the highway and this happened.

I drove my Mercury Milan to a store a few blocks from my house and when I tried to drive home, I couldn't get the steering to turn. I turned my car off and tried again and same thing. I waited a while longer, tried again, and was able to turn it. I thought it was just a fluke. A couple days later the same thing happened and a message "Power Steering Assist Fault" appeared. My husband and I then took it to our local independent mechanic. He had to replace the steering rack and pinion. He said Ford has a recall for the 2011 Milan for this same problem but not for the 2010. I do quite a bit of interstate driving and am thankful it didn't go out while I was driving at a high rate of speed or it could have been a major safety concern (as...

The power steering in my car just randomly started getting really hard to steer while I was driving out of my neighborhood a few days ago. I was turning a corner and it became so hard to steer, I almost got hit by another vehicle coming really fast and I had both of my small children in my car with me. I have researched and see that a 2011 is recalled for this same exact issue but my 2010 is not. I didn’t have any warning lights come on until it started locking up. I’m so upset that this is not an issue that needs to be fixed by a recall. This is so scary for myself and for my children.

The contact owns a 2010 Mercury Milan. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 160,000. The VIN was not included.

Power steering has failed multiple times on the vehicle. The dashboard displays 'power steering assist fault' and the steering wheel is locked. This is very dangerous and this vehicle is driven my my 80 year old mother.

THE POWER STEERING STOPPED WORKING GOING 60 MPH. POWER STEERING ASSIST FAULT. LUCKY TO GET THE CAR STPPED WITH OUT WRECKING . 93500 MILES 2010 MILAN PREMIER. WHY WAS THESE CARS RE CALLED ?

I backed out of a parking space in a parking lot and turned the steering wheel left then as I put vehicle into "drive" my steering seemed to lock up and became extremely hard to turn. I kept attempting to turn wheel and suddenly it was easily turned again as normal. While I was driving home the power steering stopped working causing steering wheel to feel as if locked again and almost impossible to turn in any direction. I almost wrecked my vehicle and hit another vehicle on the road way but hit my brakes and continued to aggressively turn the wheel to missed the vehicle in front of me. I heard and felt a pop and then steering wheel was easily turned again. I barely missed the vehicle in front of me but I did hit the curb and a bicycle a pedestrian was holding next to him on...

The contact owns a 2010 Mercury Milan. The contact stated while driving approximately 60 MPH on the interstate, the power steering became inoperable. The power steering fault message was displayed. The contact pulled over, restarted the vehicle, and the power steering started to work as designed. The contact stated that the failure recurred without warning. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 102,000.

The contact owns a 2010 MERCURY Milan. The contact stated while reversing out of a parking spot, the steering wheel became difficult to turn. The vehicle was driven to the residence. The contact stated that the power steering assist fault warning light was displayed. The vehicle was not taken to a dealer to be inspected. The manufacturer was informed of the failure. The contact was informed that VIN was not under recall for the failure. The failure mileage was approximately 121,800.

The contact owns a 2010 Mercury Milan. The contact stated that his father was driving 35 MPH, and heard a beeping sound coming from the vehicle with an unknown warning light illuminated. The driver continued to drive the vehicle to his destination. The driver exited the vehicle and when he returned and started the vehicle the power steering was inoperable. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 102,000.

As I was driving the service power steering now was indicated on the dash and the steering got super tight and almost caused an accident.

The power steering went out while I was driving in a parking lot. I replaced the rack and pinion and it went out again the day after I got it fixed. Warning lights saying fix power steering now and trac control are on. My mechanic can’t figure out why the power steering keeps going out and isn’t sure how to fix it.

Driving and steering fault showed on dash. Steering failed became dangerous to control vehicle.

Prior to incident I had a light come on power steering assist fail I would turn the car off and it would go away and didn’t have any issues. I was on a curvy county road leaving work and I got about a block away from job and going about 45 mph when my car starts ringing and said power steering assist fault and my steering was completely locked up I had to slam my brakes before I went off the road. Very scary I also had another light come on as I was sitting parked saying service advancetrac. Thankfully I wasn’t injured and it happens right before a sharp curve. It’s nearly impossible to turn the wheel. This could have been deadly. I had to get my car towed home. I called the Ford dealer about it and was informed it would need a rack and pinion and reprogramming...

In April of 2014 I was driving down a major highway in Phoenix, AZ when suddenly the power steering on the car failed and I received a warning message from the car. I had taken the vehicle to Earnhardt Ford in Chandler, AZ twice prior to this incident and worked with service advisor Gina prior to this incident because the power steering had also stopped working previously but would start working again a few moments after turning on the ignition so Earnhardt Ford was unable to reproduce the issue. After the power steering failed in April 2014, I drove the car to San tan Ford in the gilbert, az area. After a few days, I was quoted a repair price of $7,000 to replace the steering rack entirely. I was told there was no way to repair individual parts in the rack and the whole thing had to be replaced....

For years I have sporadically gotten a "Power Steering Sensor Fault" displayed when I would start the car. You could barely turn the steering wheel. In searching the Owner's Manual, owners are advised to turn off the ignition, wait briefly then restart the car (how this issue got into the Owner's Manual and could not be addressed and eliminated, I don't understand). This would correct the fault and the power steering would function normally. Fortunately it never happened while driving. In the last week this display was occurring more frequently until on 5/16/21 it would not go away and I could not drive the car. Today, 5/20/21 I got it towed to the local Ford dealer. The situation will probably not be diagnosed until next week. From reading everything on the internet, this is a routine safety concern, and a recall for the control module has been issued on the...

POWER STEERING HAS FAILED MULTIPLE TIMES ON THE VEHICLE. THE DASHBOARD DISPLAYS 'POWER STEERING ASSIST FAULT' AND THE STEERING WHEEL IS LOCKED. THIS OCCURRED BOTH WHEN THE VEHICLE WAS STATIONARY AND IN MOTION. FORTUNATELY I WAS DRIVING IN A SAFE LOCATION EACH TIME, BUT HAD IT BEEN ON A HIGHWAY THIS WOULD HAVE CAUSED A CRASH. THERE IS A RECALL FOR THIS SPECIFIC ISSUE ON 2011 MERCURY MILANS, BUT NOT ON 2010 MODELS.

I WAS AT A STORE FOR A WHILE I CAME OUTSIDE I CRANK MY CAR PUT THE CAR IN REVERSE SIMULTANEOUSLY THE TRACTION CONTROL LIGHT THE ABS SYSTEM LIGHT CAME ON ALONG WITH THE POWER STEERING GOING OUT I DID SEE. THIS IS ALL THE SYMPTOMS OF A RECALL BUT IT IS NOT ASSOCIATED WITH MY VIN NUMBER NOW THE DEALERSHIP THAT HAS MY VEHICLE HAS SERVICE THREE OTHER RECALLS WHERE IS SERVICING THREE OTHER RECALLS THAT HAS TOLD ME THAT NOW I WILL HAVE TO PAY $3,500 FOR A RACK AND PINION REPLACEMENT AND WHATEVER THIS RECALL CAUSES FOR MY BRAKES

STARTED MY CAR UP AND IT SAID POWER STEERING FAILED..I CUT THE CAR OFF AND WAITED THEN IT WENT OFF...AS I WAS HEADED TO WORK THE AIRBAG LIGHT CAME ON FOR THE PASSENGER SIDE..I PULLED INTO THE STORE TURNED THE CAR OFF A WHILE AND STARTED IT BACK UP THE LIGHT WENT OFF BEFORE LEAVING WORK THE POWER STEERING MESSAGE POPPED BACK UP I ONCE AGAIN TURNED OFF THE CAR FOR A WHILE...I MANAGE TO MAKE IT HOME BUT A MILE FROM MY HOUSE THE AIRBAG LIGHT ONCE AGAIN CAME ON.. PLEASE CHECK INTO THIS..I LOVE MY LIFE AND THE LIFE OF MY LOVED ONES DRIVING LIKE THIS IS VERY DANGEROUS AND THIS IS MY ONLY MEANS OF TRANSPORTATION.

I STARTED MY CAR TO GO TO WORK AND THE POWER STEERING ASSIST LIGHT CAME ON AND MY STEERING WHEEL IS LOCKED.

MULTIPLE TIMES NOW THE STEERING COLUMN LOCKS UP AND POWER STEERING.FAILS WHILE DRIVING. THE LATEST TIME WAS IN A PARKING LOT. THIS IS A VERY DANGEROUS SITUATION. THE LAST TIME WAS 1/30/2021.

MY CARS POWER STEERING SOMETIMES WON'T WORK WHEN I START THE CAR. IT WILL WORK AFTER I TURN CAR OFF AND RESTART IT. I SAW ON THE INTERNET THAT THIS A COMMON PROBLEM. I CALLED FORD AND HE SAYS THE RECALL DOES INCLUDE MY CAR. I DON'T UNDERSTAND WHY MY CAR IS NOT INCLUDED IN THE RECALL. LATELY IT IS HAPPENING MORE OFTEN.

POWER STEERING ASSIST FAULT ON DASH WITH POWER STEERING NOT WORKING. UNIT WAS ALREADY REPLACED 7 MONTHS AGO AND HAS FAILED AGAIN. THIS IS A REAL SAFETY ISSUE AND FORD MUST ISSUE A RECALL! SERVICE ADVANCETRAC ERROR ALSO DISPLAYED. ONLY 46,000 MILES ON VEHICLE AND THE POWER STEERING HAS FAILED TWICE!