2022 HYUNDAI SANTA FE Engine Problems

Took my 22 Sante fe to the Hyundai dealership to have the blower motor checked since I have no air flow in my car. Dealership informed me that the engine harness needs replaced and that it melted the fuse box under the hood. So, I am not able to replace my blower motor at this time due to the melted fuse box. Dealership also advised that they have seen the same problem in multiple 22 Sante Fe. and that there is likely more with the same issue within the United States. I have been noticing a melting/hot smell in the car before the airflow quit and I took it to the dealership to be diagnosed.

Engine control harness with under fuse box due to melted fuse box. This caused my blower motor and relay to go bad. No air flow currently in car due to control harness. Dealership stated that there has been several Sante Fe that has came in this year with the same issue.

Ever since I bought by car in 2022 brand new the car has been shaking when I press on the brakes going around 70 mph. I took the car multiple times to the dealership and all they do is resurface the rotos. One time they refused to even look at the car so I called corporate and they got the dealership to do the same thing as before. But still the car shakes. I called corporate and they said to take to dealership to once again get the rotos resurfaced (how many times are they planning to resurface the damn rotors?) I took to dealership because the car was saying it was overheating. They ended up changing the thermostat or something related to it. And I asked them to once again look at the rotors because of the issue. The guy came back and said “we didn’t look at your...

Bought Car in 2022 when COVID was still a problem. I had problems with the LED screen on the dash turning off. It did come back after about 10-15 minutes. I had to pull over to the side of the road in the meantime. I brought my car in and no problem was found. I was told that there was no way they could order a $6,000 part if they could not reproduce the problem. I still have had this problem periodically, but it does not last as long. This can be a safety risk when the screen goes out when driving. My check engine light has gone off many time in the 3 yrs and 7 months of me owning the vehicle. I am asked if the light is blinking when this occurs. If I said 'no', I was told 'then you don't have to worry'. I had my...

My Santa Fe limited 2022, has stopped running while traveling at 50 to 60 miles per hour on 3 different occasions. Car has 19000 miles and incidents have occurred over past 10000 miles.

Vehicle will stall out while driving at speeds Loss of braking capability and steering capabilities all lost when this happens. Vehicle will roll until stop. No control to steer or brake

A few days before the complete engine failure the car became very jerky on the throttle response I would slowly add throttle and the car would jump all over the place with RPMs and felt extremely jerky when shifting gears. At one point the engine downshifted past redline when decelerating off the highway. The day of the engine failure I was accelerating up hill after leaving a stop sign. Around 25 mph the throttle stopped responding and the engine went to idle around 800 rpm. The car started violently shaking and sounding like it was running on 3 cylinders. I tried the throttle again and nothing happened. At this time I was slowing to a stop on the hill while still in lane being unable to get out of lane to the shoulder. Upon coming to a stop the vehicle continued to shake and eventually the engine stalled while keeping...

While driving the car keeps Jenkins, and on the dash board it cane up have your power train checked. My vehicle has been in the shop 4 times since February over 30 days twice. My vehicle is still currently in the shop at the dealership. They refuse to check my power train area, and keep telling me 2 of the cylinders are backfiring

Was traveling on [XXX] near Reston, VA when the Santa Fe engine started missing and losing power and check engine light came on. Vehicle was towed to dealer and repaired on 04/26/24 Mileage was 36285. The repair order says it was fuel injector for cylinder #1. The second time the same thing happened was on [XXX] near Haymarket, VA. The date was [XXX], mileage was 36577. The engine started missing lost power and check engine light came on. Vehicle taken to dealer for repaired. They replaced injector #2. The third time was about [XXX] mileage about 51000. Was traveling near Haymarket, VA. Engine started to miss, decrease in power, check engine light came on. Vehicle was towed to dealer. Inspection of the engine revealed injector #3 was malfunctioning and they needed to replace it but could not get the injector for it from Hyundai. The vehicle has been setting at...

My vehicle made 3 ringing sounds and began to decelerate from 67mph to 0 in less than 2 minutes. I had to pull over quickly to avoid getting rear ended. This incident happened twice already. I took it in to the dealer and they were not able to recreate what happened. This occurrence happened 2weeks ago.

Middle of May 2024 car begins to feel like it's shifting when accelerating and stopping. Nothing found by Hyundai Service Dept. Lakeland. On apx. [XXX] while driving stepped on gas pedal and felt no power. Kept pumping the pedal & car started jerking. Managed to get to light and get in left lane to turn into plaza honking horn. Car slid to a stop at entrance. On apx. [XXX] my husband was driving home and same thing happened. Managed to slide car into our driveway. Both times the car had to be towed to dealership. Two fuel injectors have been changed and when I asked them to change other two they said warranty would not allow. Worst case scenario is if this happens on the interstate traveling at 75 miles per hour. Not only could we be killed but others. Both times there was no warning lights or any other...

My vehicle has been having repeated issues within 2.5 years of my purchase. Initially it was the transmission and Hyundai service center with poor customer service kept the car for almost 20-25 days before replacing the vehicle. Now, I have picked up the vehicle for less than a week and I get another Powertrain DTC code P030100 and check engine light on. Hyundai service centers are worst in the country, very poor customer service. I have to take my caribou 100 miles away to a different service center because the in town service center wouldn’t even look at the car and says has no appointment. I have to drive the car for about 100 miles with engine light on which poses a major risk to the car and myself to even ben able to get the car service done under warranty. The company advertises best warranty in the industry but...

When you go from drive to park it doesn't go into park. If you try to go to park to reverse it won't go into reverse. Has happened 3 times. Have take it in to dealership and found nothing.

The contact owns a 2022 Hyundai Santa Fe. The contact stated that on two occasions while driving at approximately 25 MPH, the vehicle lost motive power. On the second occasion, the vehicle was steered to the side of the road and restarted. The vehicle was taken to a dealer where the failure was not able to be replicated. The manufacturer was notified of the failure. The failure mileage was approximately 10,000.

The vehicle shuts off completely when stopped at a stop sign, traffic light, or parking space. This has occurred multiple times. Hyundai can not find the problem after multiple times in the shop. The last time it occurred I was in the middle of a busy intersection and was almost broadsided.

The car completely shut off in the middle of driving and I was unable to put the car into park or use the emergency brake and hazard lights because all of the controls are electronic. The lack of mechanical safety features is a danger.

On November 28 2023, I was pulling onto a small highway when an alarm went off, car stopped (engine off) as other cars were coming towards me. The message displayed was "autostop is off. Shift to P or N and start engine manually". Because the alarm was so loud and I was concerned, I snapped a picture which will be attached. I immediately pushed start button and was able to get out of the way. I had not turned the Idle Start Stop (ISS) button to off - so supposedly it was on. (You have to push this button to turn ISS off. This happened twice until I was able to get to service department. After much time (and using a loaner car) Hyundai agreed to provide a new battery because of its health. This happened again. I took the car back and the manager showed me a technical service...

Was driving on the highway while it was in cruise control and on several occasions when trying to accelerate the vehicle would jerk aggressively and struggle to accelerate. It did this about 3 times on my way to my destination. Took it in and they said they couldn’t find anything wrong with it nor could they replicate the issue. No work was on done on it.

On Monday nite returning Tuesday Morning I was coming home from work and I noticed my engine light is on and car is not running properly. I had to drive slower than normal at 12:30 AM I can usually drive the expressway but I am glad I didn’t .I live in Detroit Mi My employer which is Amazon is located in Romulus Michigan so I took [XXX] to [XXX] that when I notice my automobile was not driving as usual so I pull over and I notice my check engine light was on so I restarted my car several and it still was on so I Prayed and drove slow all the way home Thank God I made safely my auto have 7100 miles on it I had one oil change the next one is due at 10,000 miles. So the next morning I was at dealership when it opened...

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle lost power steering functionality and the vehicle was difficult to steer. The brake pedal was depressed; however, the vehicle failed to stop as intended. In addition, several unknown warning lights were illuminated. The contact stated that the vehicle was almost involved in three crashes due to the failure. The contact had to drive the vehicle onto a curb to avoid a crash on one occasion. The contact stated that during the failure, the rear hatch switch became inoperable. The vehicle was taken to the dealer on several occasions; however, the failure could not be duplicated. The dealer replaced several unknown sensors; however, the failure reoccurred. The contact stated that the failure had occurred six times. The contact stated that the vehicle was towed to the dealer after the first failure...

I was driving in the freeway and all of a sudden my engine power became week. I try to step accelerator but it did not cooperate.

[XXX] Driving down road car began shaking, driving rough and wouldn't pick up speed. Check engine light came on with code P030400/POWERTRAIN/EMS/Odometer 46,056. Car towed to Hyundai in Gainesville, GA. Tech found Cylinder 4 misfire and Cylinder 4 was replaced. [XXX] Driving down Highway and car began shaking, driving rough and wouldn't pick up speed ,again. Check engine light with code P030300/POWERTRAIN/EMS/Odometer 47,176. Car driven to Hyundai in Gainesville, GA. Tech found Cylinder 3 misfire and Cylinder 3 was replaced. [XXX] Driving down highway and check engine light came on. Car was running okay. Code P219CFO/POWERTRAIN/EMS/Odometer 47,315. Car was driven to Hyundai in Gainesville, GA for diagnosis. Tech found Cylinder 1 Air-fuel ration imbalance, [XXX] internal GDI injector leakage and parts were ordered. Replaced 2 fuel injectors, high pressure fuel pipe and 2 rail bolts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car has been taken to the dealer multiple times for not accelerating out of 1st gear when starting up, and also for shuddering at high speeds. We have been stranded, hundreds of miles from home on 2 occasions, first with less than 30,000 miles because the spark plugs needed to be replaced. And the second occasion, also hundreds of miles from home, because the car failed on the highway and limped into a dealership, where one of the fuel injectors was replaced at approx 50,000 miles. The mechanic at this dealership voiced his concerns that these were the original fuel injectors, He said he was aware of the problem, but was only permitted to replace one of the fuel injectors. The car continues to shudder at occasionally, and refuses to shift out of 1st gear at odd times. We have tried to get Hyundai to replace the fuel injectors,...

Ref NHTSA TRACKING # 11557625 Vehicle broke down again within 5K miles and 45 days of prior repair referenced in above case. Similar conditions, highway speed, bucking and vibrating, loss of speed control, no warning. Subsequent repair confirmed same issue (fuel injector) as original breakdown/repair and my initial notification to NHTSA.

On 10/31 I loss power while on the freeway for the 2nd time since August. The car was assessed and fixed according to the dealership. My car threw a 2nd code which was cleared and not fixed due to not showing issues according to the dealership. I got my car back in mid November. I immediately complained that I still had a rough idle and was told my car was fine by the manager via service rep. On 11/28 my car loss power on the freeway again for the 3rd time since August. According to the codes, all my cylinders are failing one by one. This is a huge safety concern. The dealership could care less.

Vehicle began to shake, buck and emit a grinding noise while traveling on highway resulting in loss of speed control and associated fear. Check engine light appeared simultaneously. No prior indication of a problem. Managed to limp to next exit via shoulder. Had car towed to dealer as warranty was still in effect. Problem was diagnosed as fuel injector failure and repaired. Learned it is a common, recurring issue with Hyundai 4 cylinder engine. Not unusual to have multiple failures per vehicle. Hyundai is only authorizing repair/replacement upon individual failures, not pre-emptive even though common and recurring. Confirmed this is a common, recurring issue across Hyundai via our local mechanic and internet info. Vehicle has now experienced a second failure and is being towed to dealer.

The issue with Hyundai 2.5 L turbocharged engines is getting a lot of exposure on-line. My story begins about a year ago with me complaining to the Hyundai service department about my 2022 Santa Fe Limited hesitating, lurching, and stalling (once) following acceleration from a complete stop, all without the Check Engine Light (CEL) illuminating (which the dealership said is needed to initiate troubleshooting). In addition, there is a common thread where dealerships are telling owners that it is "... probably bad gas." On 2 October 2023 the SUV started and was idling very rough, and as I drove off, the CEL illuminated (finally). After turning off the SUV for five minutes, it started fine with no CEL. My OBD-II code reader pulled three codes from the SUV that afternoon: P0300, P0301, and P0302 (Misfire - General, Misfire - Cylinder 1, and Misfire - Cylinder 2). The trouble codes should...

Vehicle check engine light came On while driving and vehicle began misfiring. Vehicle was in the shop and injector was found defective. Vehicle again had same issue but intermittently and wife would have to pull over and shut down the car to be able to drive it safely home. Dealership tried blaming bad gas which was purchased a mile from dealership. Within 50 miles vehicle began acting the exact same way and Hyundai dealership says injector needs replaced but blaming contamination not a known issue Hyundai has with injectors. Found multiple instances of same issue and same made up issue of contaminated gasoline even at the same dealership I went to. Faulty injectors make the vehicle unsafe when traveling at highway speeds on busy highways.

I have experienced a sudden loss of power when accelerating and then sudden vehicle slowdown and engine shutdown. Twice this occured at either hiway speed or accelerating to highway speeds. In both of these cases I easily could have caused or been involved in a serious crash. The third time happened on a city street and was not as egregious. There was no forewarning this might happen...no warning lights on the dash, etc. The vehicle is currently in a dealership service department after the last occurrence , and has been for five days with no knowledge of the current status. The prior times the dealership, Kolar Hyundai in Hermantown, Mn. has only cleared the error codes stored in the computer, but not identified a cause. The three times it was in the dealership were 2/15/22, 6/28/23, and 9/5/23. The second time it had to be towed in. The car currently...

I was driving the vehicle my pregnant wife and 1 year old baby were in the car with me. Car started shaking and i was loosing speed right before getting off the freeway. There was a very strong smell of gas as if it was leaking but it was not. I have an appointment to be checked at the dealership Wednesday August 16th. This is the second time something like this happens while driving in the freeway.

I had previously filed a complaint and received an issue number 11494975 I have not been able to retrieve any information related to this number. In any event I am constantly having problems with acceleration, stalling, the car puts itself in Neutral, and on occasion has completely turned itself off at a light or while driving. I do have a video of the acceleration problem and revived an email back from Laura Nelson. This is a very serious safety issue. Hyundai is not responding to following up. I also took it to an outside mechanic to put in the computer and got a general code so there is a problem somewhere. Thank you Susan Piller

On Friday the 7th of April while driving about 40 miles/hr my car lost power in traffic. I pushed gas pedal all way to floor to no avail. Then I was able to get it to move at about 20m/hr for short distance and it cut out and engine lite on as well as a horrible smell like something was burning. It had to be towed into dealer.

I have experienced power loss soon after I bought the car in Dec 2021. While I was driving the car was going in a constant speed of 20 to 30 mph. However hard I pressed the gas, car felt not responsive. Reported this to the service center and was advised that this may be since car is learning my driving habit. Later in december 2022, received a recall 236 letter from hyundai which was mentioning an issue similar to the one I experienced. Took the car for recall and informed me that the software upgrade is done as per manufacturer recommendations. Now on March 28th 2023 while I took the car out in the morning, there was more smoke than usual. And the same issue happened again. The car was not going beyond 20 to 30 mph for around 6 miles. Reported the same to the nearest service center and...

My vehicle has been having intermittent cylinder misfires for about 4-5 months now. Initially, before I knew this was the issue, I didn't think much of it because the shaking that would occur was mild, but as it gradually worsened I knew there was a bigger issue. I will start my car, the check engine light will be on, and the car will shake very hard with acceleration throughout the entire drive. I know that it is a cylinder misfire because I will get an alert on MyHyundai app telling me that a DTC code has been detected, this is the code, "DTC P030100" (the servicing department confirmed this was the misfire code). I have come to learn that the car usually only populates the code when the issue occurs for consecutive trips. As this is an intermittent issue, there are times when I know that the car is misfiring...

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The check engine warning light was illuminated. In addition, the blue link feature failed to contact Law Enforcement as needed. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 55,777.

The engine has had an oil leak since purchased new in 2021. This is a 2022 Hyundai Santa Fe with 4 cyl turbo engine. The air filter housing is also saturated with engine oil and the air filter is about 1/3 covered in engine oil, resulting in minimal protection. The possibility of fire is very realistic.

HAVE REPEATEDLY TRIED TO GET THIS RECALL FIXED. HYUNDAI CURRENTLY HAS NO FIX AND NONE IN THE FUTURE

My car has stalled and shut down and locked up completely while I was driving the vehicle for the 4 th time Thanksgiving Day. I was petrified! I called service at the dealership and they wanted to charge me. The car isn’t even a year old! What is Hyundai going to do about this?

The car started to stall and then completely turned off while I was driving. I had to turn the engine off and restart the car. I was petrified. This has happened to me twice

On Friday 10/28/2022, I took my vehicle to receive its first oil change at a third party location at 7,042 miles and was told by the mechanic that there was significant metal pieces in the oil filter, which was abnormal for a brand new car but I was told it should be okay so I continued driving the car. My family and I left on a 700 mile road trip the next morning and by that night, the engine began making a knocking noise. On Sunday morning 10/30/2022, the engine would not accelerate anymore. On Tuesday 11/01/2022, I took the vehicle to Sport Durst Hyundai in Durham, NC who informed me the engine has failed but it would not be covered under warranty because they do not deem this to be a manufacturers defect. The car is not drivable and Hyundai is unwilling to replace the engine on a car...

The contact owns a 2022 Hyundai Santa Fe. The contact stated that on multiple occasions while driving approximately 25-40 MPH, the RPM increased to 5,000 however, the vehicle failed to respond. The contact was turned off and restarted the vehicle. No warning lights were illuminated. The contact called the local dealer and was advised to schedule an appointment to have the vehicle diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 9,000.

We have had already had two issues with our Hyundai Santa Fe that we purchased new from a dealer on 5/21.The first malfunction happened on 7/23. While driving, we had several messages come across the dashboard warning that some sensors were not working properly. We then had the warning light, front collision light, the traction control light, the abs light, the auto hold and the emergency brake all light on the dash. We also lost the blind spot sensor on the side mirrors. Called the dealer and took the car in. Two days later was told it was a wheel sensor and all should be good. Then on 8/31, while merging onto a highway, I pressed the accelerator and although the engine revved, the car did not increase in speed. Luckily the car behind me was able to swing around me and I put on my hazards and pulled to...

We have a 2022 Hyundai Santa Fe with less than 17,000 miles. We pulled into the left turn lane at an intersection. When we stopped for a red light, the vehicle abruptly shut down all power with no warning. We tried to restart the car and nothing would work. We tried the hazard warning flashers and they did not work. Our vehicle was completely dead with no dash lights, no infotainment screen, we could not put the car in park or drive. We could not activate the emergency brake. It was as if the battery was disconnected. We were sitting in the travel lane of a very busy multi-lane roadway with no way to exit the vehicle unless we allowed it to become an errant vehicle. If my husband took his foot off the brake, the vehicle would have rolled backwards down the hill where we were stopped. After several...

It's been 6 months since I bought my car new. Around about 5,000 miles I started noticing that it rev'd really high before it would switch gears. It really became a problem when I pulled out onto a busy main road from a side street and it got up to 20mph then just rev'd really high and wouldnt go any faster. I had my son with me in the car and he looked behind us and said, mom cars are coming why arent we moving. I told him I was trying to, I took my foot off the gas pedal then pushed it again, I did this several times as we were coasting to a stop. The car then felt like it finally jolted into gear and started to go. It did this a couple more times, especially when trying to speed up from a stop or a slow roll....

Vehicle under normal operation began to lose power as the accelerator was depressed. Eventually stalling and consequently cutting power to the engine. The vehicle became immobile and would not move or engage out of drive until repeated efforts to turn off/on the vehicle. For a few days following the incident the vehicle idled very low, nearly shutting off in a few instances.

Service engine light is on sine the vehicle has 850 miles. Several attend to repair but still not been repair.