2022 HYUNDAI SANTA FE Electrical System Problems

Took my 22 Sante fe to the Hyundai dealership to have the blower motor checked since I have no air flow in my car. Dealership informed me that the engine harness needs replaced and that it melted the fuse box under the hood. So, I am not able to replace my blower motor at this time due to the melted fuse box. Dealership also advised that they have seen the same problem in multiple 22 Sante Fe. and that there is likely more with the same issue within the United States. I have been noticing a melting/hot smell in the car before the airflow quit and I took it to the dealership to be diagnosed.

Engine control harness with under fuse box due to melted fuse box. This caused my blower motor and relay to go bad. No air flow currently in car due to control harness. Dealership stated that there has been several Sante Fe that has came in this year with the same issue.

The contact owns a 2022 Hyundai Santa Fe. The contact stated that intermittently, the gear shifter was inoperable, and the message "Gear Shift Malfunction" was displayed. The contact stated that the failure required that the vehicle be turned, which automatically engaged the parking brake. The contact stated that upon pressing the Start button, and then depressing the brake pedal, the contact was able to move the gear shifter to park(P) and to the other gears. The vehicle was taken to the dealer, where it was diagnosed that the wiring was open between the transaxle, the rain switch, and the shift control unit. The dealer replaced the wiring. Upon test-driving the vehicle, the dealer noticed that the vehicle was still experiencing abnormal vibrations. The dealer recommended that the transmission be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 98,000.

Vehicle experienced a spontaneous interior fire while parked and turned off. No collision, no injuries. Fire originated under the driver-side lower dash/kick panel near the fuse/BCM wiring, then spread into the driver door harness/trim. Exterior body and engine bay show no impact or external origin. Details: Heavy charring/melt concentrated at lower dash/junction area with upward/sideways spread along wiring paths; interior plastics, dash switches, and door wiring damaged. Vehicle was unoccupied. Aftermarket: No hardwired accessories in the origin zone. A dashcam was powered via center console USB/12V with a small battery pack (not connected to the under-dash fuse block). Status: Towed to [Dealer, City/State]; Hyundai Corporate Case #XXX opened. Insurance comprehensive fire claim opened; origin-and-cause inspection pending. Request: NHTSA investigation into potential electrical/wiring defect in driver lower dash/door-harness area on this model/year; safety risk of parked, unattended fires. Photos/videos available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5...

Horn stopped working

Bought Car in 2022 when COVID was still a problem. I had problems with the LED screen on the dash turning off. It did come back after about 10-15 minutes. I had to pull over to the side of the road in the meantime. I brought my car in and no problem was found. I was told that there was no way they could order a $6,000 part if they could not reproduce the problem. I still have had this problem periodically, but it does not last as long. This can be a safety risk when the screen goes out when driving. My check engine light has gone off many time in the 3 yrs and 7 months of me owning the vehicle. I am asked if the light is blinking when this occurs. If I said 'no', I was told 'then you don't have to worry'. I had my...

The horns stopped working, and this is a safety item since it’s the only way to notify another vehicle or pedestrian if they will be hit by my car. Another day, a car came out of the parking lot and almost hit my car. I was only able to avoid that accident because I reversed quickly. I took my car to the dealership, and it was confirmed that the horns are not working. To fix this issue, I need to replace them. But since my car is out of warranty, I will need to pay for this service. On 07/14/2025, I called Hyundai (Case number 4117-7538) to request the application of an extended warranty that they started to offer for the 2021-2025 model year Elantra (Z03). Since my car is the 2022 model year Santa Fe, they did not accept my request. I noticed that on several websites, Hyundai car...

Vehicle will stall out while driving at speeds Loss of braking capability and steering capabilities all lost when this happens. Vehicle will roll until stop. No control to steer or brake

On [XXX] at [XXX], my [XXX] daughter was locked inside my 2022 Hyundai Santa Fe (VIN: [XXX] ) while holding the Smart Key fob in the back seat. She pressed the lock button, and the vehicle completely locked — with her and the key fob still inside. This violates the Smart Key safety feature described in Hyundai’s owner’s manual, which says the car should not lock if the key is inside. That system failed. There were no warning lights or alerts. I had no way to unlock the doors. I experienced a full panic attack. I feared my child could die from heat exposure. I was forced to break the rear window to rescue her. I was terrified the glass might injure her, but I had no choice. Since then, I have been emotionally traumatized and avoid driving out of fear it will happen again. To my knowledge, this has...

The reverse camera system did not come on when reversing. It could lead to someone like a child getting hurt if they’re walking behind the vehicle. The problem was reproduced by the dealer and serviced for this issue. They confirmed it was the same problem as the recall. There is a recall for 2022 Hyundai Santa Fe’s that were manufactured in the Alabama plant. This is where my car was manufactured. For some reason, it was not included in the VINs that were recalled.

The integrated thermal monitor is stuck. When I took it to Ken Vance Hyundai today, they said it is a common issue and if left unfixed. It would blow the engine.

I have a 2022 santa fe xrt within the 1st yr of owing in 2022 the horn stopped working in the winter. Went to dealership told it was known issue they replaced it. A few months later into following year still winter went out again they fixed again stating my car has 2 horns and both failed. So far 2022 and 2023 2 times. Fast forward to earlier in 2024 beginning of year horn failed again took to dealer expressed my concern of this is a safety and inconvenience issue they apologized but no recall yet. Now it's almost 2025 and I will be taking my car back to the dealership this weekend for yet another time due to the horn not working at all. I've found out my horn has not worked due to driving and a vehicle almost colliding into my lane and went to honk horn and...

The back doors should unlock when the SUV is put in park or the motor is turned off. However, it does not unlock over 25% of the time. This means the back doors can not be opened from the outside or inside. People in the back cannot get out unless the doors are manually unlocked from the control panel in the front. This is a real safety issue if there was an accident and the people are trapped in the car. This issue has been reported to the dealer for almost two years. They have not been able to fix the issue. I have reported this problem to Hyundai National Consumer Affairs (case # [XXX]) asking for their help. I ask if this falls under the lemon law since it can not be fixed and is safety issue. I was informed they could not help me. INFORMATION REDACTED PURSUANT TO...

The car completely shut off in the middle of driving and I was unable to put the car into park or use the emergency brake and hazard lights because all of the controls are electronic. The lack of mechanical safety features is a danger.

On Monday nite returning Tuesday Morning I was coming home from work and I noticed my engine light is on and car is not running properly. I had to drive slower than normal at 12:30 AM I can usually drive the expressway but I am glad I didn’t .I live in Detroit Mi My employer which is Amazon is located in Romulus Michigan so I took [XXX] to [XXX] that when I notice my automobile was not driving as usual so I pull over and I notice my check engine light was on so I restarted my car several and it still was on so I Prayed and drove slow all the way home Thank God I made safely my auto have 7100 miles on it I had one oil change the next one is due at 10,000 miles. So the next morning I was at dealership when it opened...

Engine light comes on and car starts jerking or when I start the car it does it and jerks and drives 5 mph. Cruise control jerks when using it and the sensors go off for no reason.

I was driving the vehicle my pregnant wife and 1 year old baby were in the car with me. Car started shaking and i was loosing speed right before getting off the freeway. There was a very strong smell of gas as if it was leaking but it was not. I have an appointment to be checked at the dealership Wednesday August 16th. This is the second time something like this happens while driving in the freeway.

My car has stalled and shut down and locked up completely while I was driving the vehicle for the 4 th time Thanksgiving Day. I was petrified! I called service at the dealership and they wanted to charge me. The car isn’t even a year old! What is Hyundai going to do about this?

We have had already had two issues with our Hyundai Santa Fe that we purchased new from a dealer on 5/21.The first malfunction happened on 7/23. While driving, we had several messages come across the dashboard warning that some sensors were not working properly. We then had the warning light, front collision light, the traction control light, the abs light, the auto hold and the emergency brake all light on the dash. We also lost the blind spot sensor on the side mirrors. Called the dealer and took the car in. Two days later was told it was a wheel sensor and all should be good. Then on 8/31, while merging onto a highway, I pressed the accelerator and although the engine revved, the car did not increase in speed. Luckily the car behind me was able to swing around me and I put on my hazards and pulled to...

We have a 2022 Hyundai Santa Fe with less than 17,000 miles. We pulled into the left turn lane at an intersection. When we stopped for a red light, the vehicle abruptly shut down all power with no warning. We tried to restart the car and nothing would work. We tried the hazard warning flashers and they did not work. Our vehicle was completely dead with no dash lights, no infotainment screen, we could not put the car in park or drive. We could not activate the emergency brake. It was as if the battery was disconnected. We were sitting in the travel lane of a very busy multi-lane roadway with no way to exit the vehicle unless we allowed it to become an errant vehicle. If my husband took his foot off the brake, the vehicle would have rolled backwards down the hill where we were stopped. After several...

The contact owns a 2022 Hyundai Santa Fe. The contact stated that the vehicle was not able to start. Triple A towing company was not able to jumpstart the vehicle, and the vehicle was towed to the dealer. The dealer was not able to duplicate the failure however, the mechanic replaced the battery. The contact stated that the failure recurred. Triple A was made aware of the failure but was unable to jumpstart the vehicle. The vehicle was towed to the dealer however, the dealer could not duplicate the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 209.